Sony-STRD660Z-rec-sm维修电路原理图.pdf

《Sony-STRD660Z-rec-sm维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《Sony-STRD660Z-rec-sm维修电路原理图.pdf（260页珍藏版）》请在收音机爱好者资料库上搜索。

1、MICROFILM Manufactured under license from Dolby Laboratories Licensing Corporation. “Dolby”, the double-D symbol a and “Pro Logic” are trademarks of Dolby Laboratories Licensing Corporation. FM STEREO/FM-AM RECEIVER Photo : STR-DE615 US Model STR-D560Z/D660Z/DE615/DE715 Canadian Model STR-DE615/DE71

2、5 Australian Model STR-DE715 SERVICE MANUAL STR-D560Z/D660Z/DE615/DE715 Continued on page 2 SPECIFICATIONS RadioFans.CN 收音机爱 好者资料库 2 TABLE OF CONTENTS Specifications . 1 1.GENERAL Location and Function of Controls . 4 2.DIAGRAMS 2-1. IC Pin Functions . 6 2-2. Circuit Boards Locations . 10 2-3. Print

3、ed Wiring Boards AMP Section . 11 2-4. Schematic Diagram AMP Section . 15 2-5. Schematic Diagram Surround Section . 19 2-6. Printed Wiring Boards Surround Section . 23 2-7. Schematic Diagram Display Section (STR-D560Z/DE615) . 26 2-8. Printed Wiring Boards Display Section (STR-D560Z/DE615) . 29 2-9.

4、 Printed Wiring Boards Display Section (STR-D660Z/DE715) . 33 2-10. Schematic Diagram Display Section (STR-D660Z/DE715) . 37 3.EXPLODED VIEWS 3-1. Front Panel Section. 44 3-2. Chassis Section . 46 3-3. Back Panel Section . 47 4.ELECTRICAL PARTS LIST . 48 RadioFans.CN 收音机爱 好者资料库 3 3. Measuring the vo

5、ltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The “ limit” indication is 0.75V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a pas- sive VOM that is suitable. Nearly all battery operated digital multim

6、eters that have a 2V AC range are suitable. (See Fig. A) Fig. A. Using an AC voltmeter to check AC leakage. Earth Ground To Exposed Metal Parts on Set 1.5k0.15F AC voltmeter (0.75V) SAFETY CHECK-OUT After correcting the original service problem, perform the follow- ing safety check before releasing

7、the set to the customer : Check the antenna terminals, metal trim, “metallized” knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below. LEAKAGE TEST The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed m

8、etal part having a return to chassis, must not exceed 0.5mA (500 microampers). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCAWT-540A. Follow the manufacturers instructions to use these instruments. 2. A battery-operated AC

9、milliammeter. The Data Precision 245 digital multimeter is suitable for this job. SAFETY-RELATED COMPONENT WARNING! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOS

10、E PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. ATTENTION AU COMPOSANT AYANT RAPPORT LA SCURIT! LES COMPOSANTS IDENTIFIS PAR UNE MARQUE ! SUR LES DIAGRAMMES SCHMATIQUES ET LA LISTE DES PICES SONT CRITIQUES POUR LA SCURIT DE FONCTIONNEMENT. NE REMPLACER CES COMPOSAN

11、TS QUE PAR DES PICES SONY DONT LES NUMROS SONT DONNS DANS CE MANUEL OU DANS LES SUPPLMENTS PUBLIS PAR SONY. 4 SECTION 1 GENERAL LOCATION AND FUNCTION OF CONTROLS This section is extracted from instruction manual. ? !?! ! !?!? ! ! !? 0?9 1234?5?678 FRONT PANEL ! AUDIO FUNCTION buttons ! VIDEO FUNCTIO

12、N buttons ! DIRECT button ! SHIFT button ! Numeric buttons PRESET TUNING +, buttons MEMORY button DISPLAY button FM/AM button FM MODE button TUNING +, buttons PHONES jack SPEAKERS switch 1 DPC MODE button 2 POWER switch 3 SUR, TONE, INDEX indicators 4 Digital processing control buttons 5 Function in

13、dicators 6 DIRECT PASS indicator 7 5.1 INPUT indicator 8 MASTER VOLUME control 9 BALANCE control ! BASS BOOST button/indicator ! SOUND FIELD ON/OFF button ! MODE button ! GENRE button ! DIRECT PASS, SET UP, 5.1/DVD INPUT buttons 5 123 456 7 0 8 9 0)=+ rPp(9 1 2 3 4 5 6 7 8 9 0 ! ! ! ! ! ! ! ! ! !SYS

14、TEM CONTROL/FUNCTION buttons !5.1/INPUT button !TV/VIDEO button !Direct TUNING button !CH/PRESET button !TEST TONE button !CENTER LEVEL +, buttons REAR LEVEL +, buttons MASTER VOL buttons MUTING button BASS BOOST button 1LEARN button/indicator 2SLEEP button 3TV CONTROL ON button 4Numeric, ENTER butt

15、ons 5BACKGROUND button 6VCR/CD/DVD control buttons 7SOUND FIELD buttons 8DIRECT button 9DPC MODE button 0DIGITAL PROCESSING CONTROL buttons !VISUAL POWER button !SYSTEM OFF button REMOTE REAR PANEL 6 SECTION 2 DIAGRAMS IC103 MB90673PF-G-196-BND (SYSTEM CONTROL) (STR-D660Z/DE715) Pin No.Pin nameI/ODe

16、scription 1AC MUTEOAC mute drive. 2D. LATOData latch output. 3T. LATOTuner function latch output. 4S. CLKOSerial clock output. 5S. DATAOSerial data output. 6S. LATOSerial latch output. 7AUTO STOPOTuner auto stop output. 8T. MUTEOTuner mute output. 9STEREOIStereo detect signal input. 10IF DATA INIIF

17、data input. 11VSS (D)Ground. 12V-AOVideo switch control output. 13V-BOVideo switch control output. 14RM INPUTIRemote control signal input. 15V-EOVideo switch control output. 16V-INHNot used (Open). 17LED DATAOLED data output. 18LED CLROLED clock signal output. 19S. POWERIPower switch input. 20RX (SI

18、N)Not used (Fixed at “ L ” ) 21TX (SOUT)Not used (Open). 22BUSYNot used (Open). 23FL CLEAROFL reset signal output. 24FL DATAOFL data output. 25FL CLKOFL clock output. 26FL LATOFL latch signal output. 27Not used (Ground). 28VCC(A)Analog power supply (+4.9V). 29 + AVRConnect to VDD (+5.1V). 30 AVRNot

19、used (Ground). 31GND (D)Ground. 32AD KEY IN1IKey input. 33AD KEY IN2IKey input. 34VSS(D)Ground. 35AD KEY IN3IKey input. 36AD KEY IN4IKey input. 37AD KEY IN5IKey input. 38AD VERSIONIModel select. 39VOL +OVolume up control output. 40VOL OVolume down control output. 41MODE0Not used (Fixed at “ H ” ) 42

20、MODE1Not used (Fixed at “ H ” ) 43MODE2Not used (Ground). 44STANDBYConnect to VDD (+5.1V). 45STOPOPower ON/OFF control output. 2-1. IC PIN FUNCTION 7 Pin No.Pin nameI/ODescription 46LERNING LEDNot used (Open). 47Not used (Ground). 48Not used (Ground). 49CTR A INIControl S signal input (DE715 : US, C

21、anadian model). 50STANDBY LEDNot used (Open). 51VOL LEDOVolume LED drive. 52S-OUTOControl S signal output (DE715 : US, Canadian model). 53CTR A OUTOControl S signal output (DE715 : US, Canadian model). 54VIDEO1 (M-BUS)OVIDEO1 control signal output. 55VIDEO2 (M-BUS)OVIDEO2 control signal output. 56TV

22、 (M-BUS)OTV control signal output. 57Not used (Ground). 58SP OFF INISpeaker switch input. 59SIGNAL INNot used (Ground). 60Not used (Ground). 61Not used (Ground). 62RESETIReset terminal. 63VSS(D)Ground. 64XOOSystem clock (4.19MHZ). 65XIISystem clock (4.19MHZ). 66VCC(D)Digital power supply (+4.9V). 67

23、Not used (Ground). 68POWER RYOPower relay drive. 69BRIDGE RYPower key input. 70SUR RYOSurround relay drive. 71CENTER RYOCenter relay drive. 72FRONT RY (H,P)OFront (Headphone) relay drive. 73MIX/SUB RYOWoofer relay drive. 744/8 INNot used (Ground). 75PROTECT INIProtector operation input. 76DIRECT PAS

24、SODirect pass relay drive. 77BASS BOOSTOBass boost ON/OFF control. 78F/C/W MUTEOFront, Center, Woofer mute drive. 79SL MUTEOSurround L-CH mute drive. 80SR MUTEOSurround R-CH mute drive. 8 IC103 PD780205GF-027-3BA (SYSTEM CONTROL) (STR-D560Z/DE615) Pin No.Pin nameI/ODescription 1Not used (Connect to

25、VDD). 2 4Not used (Connect to ground). 5F/C/W. MUTEOFront, Center, Woofer mute drive. 6SL MUTEOSurround L-CH mute drive. 7SR MUTEOSurround R-CH mute drive. 8AC MUTEOAC mute drive. 9D LATCHOData latch output. 10RESETIReset terminal. 11X2OSystem clock (4.19MHZ). 12X1ISystem clock (4.19MHZ). 13VSSGroun

26、d. 14NPNot used (Open). 15Connect to reset terminal. 16VDDPower supply (+5V). 17T LATCHOTuner function latch output. 18S CLOCKOSerial clock output. 19S DATAOSerial data output. 20S LATCHOSerial latch output. 21AUDIO. STOPOTuner auto stop output. 22TUNER MUTEOTuner mute output. 23STEREOIStereo detect

27、 signal input. 24IF DATA INIIF data input. 25GND A/DGround. 26SIRCSIRemote control signal input. 27POWER KEYIPower key input. 28VERSIONIModel select input. 29KEY 5IKey input. 30KEY 4IKey input. 31KEY 3IKey input. 32KEY 2IKey input. 33KEY 1IKey input. 34VDD A/DPower supply (+5V). 35VREF A/DIReference

28、 voltage input. 36V-AOVideo switch control output. 37V-BOVideo switch control output. 38V-EOVideo switch control output. 39STOPOPower ON/OFF control output. 40VSSGround. 41DIRECT PASSODirect pass relay drive. 42SUR RYOSurround relay drive. 43CENTER RYOCenter relay drive. 44FRONT RYOFront relay drive

29、. 45MIX SUB RYOWoofer relay drive. 9 Pin No.Pin nameI/ODescription 46VDDPower supply (+5V). 47PROTECTOR INIProtector operation input. 48POWER RYOPower relay drive. 49BASS BOOSTOBass boost ON/OFF control. 50SP OFFISpeaker switch input. 51VOL OVolume down control output. 52VOL +OVolume up control outp

30、ut. 53VOL LEDOVolume LED drive. 54STANDBY LEDNot used (Open). 55Not used (Open). 56BASS BOOST LEDOBASS BOOST LED drive. 575.1 INPUT LEDO5.1 INPUT LED drive. 58DIRECT PASS LEDODIRECT PASS LED drive. 59SUR LEDOSUR LED drive. 60TONE LEDOTONE LED drive. 61VIDEO 1 LEDOVIDEO 1 LED drive. 62INDEX LEDOINDEX

31、 LED drive. 63PHONO LEDOPHONO LED drive. 64TUNER LEDOTUNER LED drive. 65DAT MD LEDODAT/MD LED drive. 66CD LEDOCD LED drive. 67TAPE LEDOTAPE LED drive. 68TV/DBS LEDOTV/DBS LED drive. 69VIDEO2 LEDOVIDEO2 LED drive. 70 78P1 P9OFL segment drive. 79V LOARDFL power supply ( 35V). 80 87P10 P17OFL segment d

32、rive. 88 100G1 G13OFL segment drive. 10 2-2. CIRCUIT BOARDS LOCATIONS ? ? ? ? ? ? ? ? ? ? AUDIO SW board ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? AUDIO board AU-VIDEO board SURR AUDIO board HP board DISPLAY board VOL board VIDEO board SP SW board SW board BALANCE board L. B. SW board 5.1 IN board SP board REAR

33、 AMP board AMP JOINT (B) board SURR board CONT (AS-1) board AMP board SECONDARY board STANDBY board S-A-SP board CTRL-A board (DE715 : US, Canadian model) 41 r IC BLOCK DIAGRAMS (AMP) IC701 uPC2581V 1 2 3 45 6 7 8 V+ VSB/SESIN VSA RESET GND OUTC VSC CR VREF + + + Q RS 1 2 3 4 5 6 7 8 9 10 11 12 13 1

34、4 15 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 CONTROL LATCH SHIFT RESISTOR LEVEL SHIFT CL DI CE VEE OUT IN OUT IN OUT IN VSS S RESET VDD OUT ININ OUT IN OUT IN IC901 NJM2103D 235467981 MUTE + VOUT1 VOUT1 COMP1 MF1 IN1 GND IN2 NF2 COMP2 VOUT2 + VOUT2 VCC1 VCC2 VEE PROTECTOR BIAS CIRCUIT REGDRIVE

35、PRE DRIVE 111012131514 DRIVE PRE DRIVE 1 2 3 4 5 6 7 8 9 TR3R1 R2 TR4 TR6 TR7 R4 R9 TR5 TR1 TR2 R6 D4 D3 R7R8 TR8 D1 D2R5 R3 INPUT NF -VEOUT +VEOUT VSS GND VCC SUB IC301, IC303 LC7822 r IC BLOCK DIAGRAMS (SURROUND) + 236 7 4581 V+ + V IC405 M5218AL IC502 TC9184P 161514131211109 12345678 S. DATA T. L

36、AT +9V9V GND S. CLK TONE CE BASS + BASS COM TREBLE TREBLE + BASS + BASS COM TREBLE TREBLE + IC601 STK350-230 42 1 2 3 4 5 6 7 89 15 10 11 12 13 14 16 DECODER DECODER MONITOR OUT GND IN5 GND IN4 CTL E IN3 CTL D 6dB 6dB IN1 CTL A V OUT1 VCC IN2 CTL B V OUT2 CTL C IC201 SN761200 1 2 3 4 5 6 7 8 9 10 11

37、 12 13 14 15 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 CONTROL LATCH SHIFT RESISTOR LEVEL SHIFT CL D1 CE VEE L1 L2 L COM1 L3 L4 L COM2 L5 L6 L COM3 L7 R1 R2 R COM1 R3 R4 R COM2 R5 R6 R COM3 R7 L COM4 VSS S RES VDD R COM4 IC406 LC7823 235467981 MUTE + VOUT1 VOUT1 COMP1 MF1 IN1 GND IN2 NF2 COMP2 VO

38、UT2 + VOUT2 VCC1 VCC2 VEE PROTECTOR BIAS CIRCUIT REGDRIVE PRE DRIVE 111012131514 DRIVE PRE DRIVE IC501 uPC2581V 43 r IC BLOCK DIAGRAMS (DISPLAY ) IC102 M66004FP-M6 (STR-D660Z/DE715) 123456789 NC OUTPUT 2 Vcc GND NC INPUT 2 INPUT 1 NC MOTOR DRIVE MOTOR DRIVE REG SWITCH SWITCH OUTPUT1 IC106 BA6208 (ST

39、R-D550Z/D660Z/DE615/DE715) IC1102 NJM2129D (STR-D660Z/DE715) + + 23546 7 98 1 INHIBIT GND REG OUT NC OUT1 IN2 IN3 IN4 VCC1 VCC2 REG-SW IN1 INHIBIT1 OUT2 INHIBIT2 REGULATOR INHIBIT 1110121314 SEGMENT OUTPUT CIRCUIT (35BIT x 16) DECODER INDICATION CODE RESISTOR (8BIT x 16) DECODER (35BIT x 16) CODE/CO

40、MMAND CONTROL CIRCUIT INDICATION CONTROL RESISTOR INDICATION CONTROLLER DIGIT OUTPUT CIRCUITCODE WRITE CODE SELECT SERIAL RECEIVE CIRCUIT OUTPUT PORT (2BIT) CLOCK GENERATOR CIRCUIT RAM WRITE 212019221332 6064 - 6159 - 33 23 - 311 - 1217 1814 15 16 G13 | G16 VCC2 P1 | P27 VSS XIN XOUT VCC1 RST G12 |

41、G1 VP CS SCK SDATA P36 | P28 44 Les composants identifis par une marque !sont critiques pour la scurit. Ne les remplacer que par une pice portant le numro spcifi. The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. SECTION

42、3 EXPLODED VIEWS NOTE : r-XX, -X mean standardized parts, so they may have some difference from the original one. rItems marked “ * ”are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. rThe mechanical parts with no reference

43、 number in the exploded views are not supplied. rHardware (# mark) list and accessories and pack- ing materials are given in the last of this parts list. rAbbreviation CND: Canadian AUS: Australian 3-1. FRONT PANEL SECTION 4A : L.B. SW board SONYSONY 1 2 3 4 5 6 7 8 9 10 11 12 12 12 13 14 14 15 16 1

44、6 16 16 17 18 19 20 21 (including 4A) 22 23 23 24 25 not supplied not supplied supplied with RV401 not supplied #1 #1 #1 #1 #1 #1 FL101 4A DE715 : US,CND Model 45 Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark * 171-665-478-11BALANCE BOARD (D660Z/DE715) * 171-665-467-11BALANCE BO

45、ARD (D560Z/DE615) * 181-665-477-11VOL BOARD (D660Z/DE715) * 181-665-466-11VOL BOARD (D560Z/DE615) 191-773-130-11WIRE (FLAT TYPE) (19 CORE) (100mm) 201-769-928-11WIRE (FLAT TYPE) (9 CORE) (DE715:US,CND) * 21A-4392-893-A DISPLAY BOARD, COMPLETE (D560Z/DE615) * 21A-4392-918-A DISPLAY BOARD, COMPLETE (D

46、E715:US,CND) * 21A-4392-919-A DISPLAY BOARD, COMPLETE (DE715:AUS) * 21A-4392-942-A DISPLAY BOARD, COMPLETE (D660Z) 221-773-115-11WIRE (FLAT TYPE) (19 CORE) (320mm) * 234-921-941-01CUSHION (FL) * 243-386-245-11HOLDER (FL) (D560Z/DE615) * 244-981-656-01HOLDER (C), FL INDICATION TUBE (D660Z/DE715) * 25

47、A-4392-908-A SW BOARD, COMPLETE FL1011-517-519-11INDICATOR TUBE, FLUORESCENT (D660Z/DE715) FL1011-517-672-11INDICATOR TUBE, FLUORESCENT (D560Z/DE615) 14-980-639-01KNOB (R14) 2X-4946-873-1KNOB (R48) ASSY 3X-4948-324-1PANEL ASSY, FRONT (DE615) 3X-4948-325-1PANEL ASSY, FRONT (D560Z) 3X-4948-328-1PANEL ASSY, FRONT (DE715:US,CND) 3X-4948-329-1PANEL ASSY, FRONT (D660Z) 3X-4948-557-1PANEL ASSY, FRONT (DE715:AUS) 44-989-850-01BUTTON (BB) 54-989-842-01INDICATOR (BB) 64-989-852-01RING (SUR) 74-989-846