Sony-TAFE330R-int-sm维修电路原理图.pdf

《Sony-TAFE330R-int-sm维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《Sony-TAFE330R-int-sm维修电路原理图.pdf（23页珍藏版）》请在收音机爱好者资料库上搜索。

1、http:/cxema.ru MICROFILM SERVICE MANUAL INTEGRATED STEREO AMPLIFIER AEP Model UK Model SPECIFICATIONS TA-FE230/FE330R/FE530R Photo: TA-FE530R (BLACK) RadioFans.CN 收音机爱 好者资料库 http:/cxema.ru 2 TABLE OF CONTENTS 1.GENERAL Location of Controls .3 2.DISASSEMBLY.4 3.DIAGRAMS 3-1.Note for Printed Wiring Bo

2、ards and Schematic Diagrams .7 3-2.Printed Wiring Board MAIN Section .9 3-3.Schematic Diagram MAIN Section . 11 3-4.Printed Wiring Boards PANEL Section . 13 3-5.Schematic Diagram PANEL Section . 15 3-6.Printed Wiring Boards POWER Section . 17 3-7.Schematic Diagram POWER Section . 19 3-8.IC Pin Funct

3、ion Description . 22 4.EXPLODED VIEWS. 23 5.ELECTRICAL PARTS LIST. 26 SAFETY-RELATED COMPONENT WARNING! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBE

4、RS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB- LISHED BY SONY. RadioFans.CN 收音机爱 好者资料库 http:/cxema.ru 3 SECTION 1 GENERAL This section is extracted from instruction manual. LOCATION OF CONTROLS Front View 1 I/u button 2 Remote sensor (TA-FE330R/FE530R) 3 EON LINK button and indicator (TA-F

5、E530R) 4 PHONES jack 5 SPEAKERS switch 6 BASS dial 7 TREBLE dial 8 BALANCE dial 9 LOUDNESS button 0 INPUT SELECTOR ! SOURCE DIRECT button (TA-FE330R/FE530R) ! VOLUME dial ! TAPE1 MONITOR switch (TA-FE530R) 12 3456789! ! Rear View http:/cxema.ru 4 CASE PANEL ASSY Note: Follow the disassembly procedur

6、e in the numerical order given. SECTION 2 DISASSEMBLY 1two screws (CASE) 1screw (CASE) 1two screws (CASE) 2case 2connector (CN7) (FE230) 2connector (CN903) (FE330R/FE530R) 3two clamps 4screw (BVTP3 8) 5claw 6panel assy 4three screws (BVTP3 8) 5claw 4screw (BVTP3 8) 2connector (CN812) (FE530R) 1wire

7、(flat type) (13 core) (CN815) 1wire (flat type) (13 core) (CN811) http:/cxema.ru 5 MAIN BOARD 1connector (CN951) 1connector CN952: FE330R/FE530R CN952A: FE230 4screw (BVTP3 8) 5MAIN board 3six screws (BVPT 3 8) (FE330R/FE530R) 3six screws (BVPT 3 8) (FE230) 2six screws (BVPT 3 8) FE230 () http:/cxem

8、a.ru 7 8 SECTION 3 DIAGRAMS 3-1.NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS Note on Printed Wiring Boards: Y : parts extracted from the component side. : internal component. b : Pattern from the side which enables seeing. Indication of diode Note on Schematic Diagrams: All capacitors are i

9、n F unless otherwise noted. pF: F 50 WV or less are not indicated except for electrolytics and tantalums. All resistors are in and 1/4 W or less unless otherwise specified. : internal component. 2 : nonflammable resistor. 5 : fusible resistor. C : panel designation. U : B+ Line. V : B Line. Voltages

10、 are dc with respect to ground under no-signal conditions. no mark : TUNER Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal produc- tion tolerances. Signal path. F: TUNER E: TAPE1/DAT IN a: REC OUT d: TAPE2/MD IN J: CD I : PHONO Note: The components

11、 identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. This marking side is cathode. D DC-SUP board FUSE board AC-SW board (FE230) POWER SW board (FE330R/FE530R) H. P board FUNCTION SW board CONTROL boardTAPE MONITOR board (FE530R) MAIN boa

12、rd AC OUTLET board (FE330R: AEP/FE530R: AEP) AC-RY board (FE330R/FE530R) Circuit Boards Location http:/cxema.ru TA-FE230/FE330R/FE530R 3-2.PRINTED WIRING BOARD MAIN Section See page 8 for Circuit Boards Location. (Page 17) 9 10 D101C-4 D301E-6 D302E-6 D351E-6 D352E-6 D601C-5 D902C-5 D903C-5 IC101D-3

13、 IC102C-1 IC301E-7 IC601E-3 IC901E-5 Q101E-5 Q102E-5 Q103C-4 Q104E-4 Q151E-5 Q301E-6 Q351D-6 Q901C-5 Q902C-5 Q903E-4 Semiconductor Location Ref. No.Location (Page 13)(Page 18) (Page 17)(Page 14)(Page 13) http:/cxema.ru TA-FE230/FE330R/FE530R 11 12 3-3. SCHEMATIC DIAGRAM MAIN Section See page 21 for

14、IC Block Diagrams. The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. (Page 15) (Page 15)(Page 16) (Page 19) (Page 20) (Page 19) http:/cxema.ru TA-FE230/FE330R/FE530R 13 14 3-4.PRINTED WIRING BOARDS PANEL Section See page

15、8 for Circuit Boards Location. (Page 9)(Page 9) (Page 18) (Page 9) D811A-4 D812B-4 D813B-5 D814B-6 D816B-6 D817B-6 D819B-6 D820B-2 D821F-10 D822E-10 D823E-1 D801B-7 D802B-7 D803B-6 D804B-7 D805B-7 D806B-8 D807B-3 D808A-3 D809A-3 D810A-4 Semiconductor Location IC801B-5 IC802B-2 IC803F-10 Q801B-7 Q802

16、B-8 Q803C-2 Q804B-5 Q806B-3 Q807B-3 Q808A-4 Q809F-10 Q810B-8 Q811B-10 Q812F-10 Q813F-10 Ref. No.LocationRef. No.LocationRef. No.LocationRef. No.Location http:/cxema.ru TA-FE230/FE330R/FE530R 15 16 3-5. SCHEMATIC DIAGRAM PANEL Section See page 21 for IC Block Diagrams. Waveform 1 IC801 2 (XIN) 2.5 Vp

17、-p 4 MHz (Page 11)(Page 11) (Page 11) (Page 20) http:/cxema.ru TA-FE230/FE330R/FE530R 17 18 3-6.PRINTED WIRING BOARDS POWER Section See page 8 for Circuit Boards Location. Semiconductor Location Ref. No.Location D901D-2 D904D-3 D905D-3 D906D-3 D907D-3 D908D-2 D909D-3 D911B-7 D912A-6 D913B-6 D914A-6

18、D915B-6 D916A-6 (Page 10) (Page 9) (Page 14) (Page 9) http:/cxema.ru TA-FE230/FE330R/FE530R 19 20 3-7. SCHEMATIC DIAGRAM POWER Section The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. (Page 12) (Page 12) (Page 12) (Page

19、15) http:/cxema.ru 21 22 IC Block Diagrams MAIN Board IC101LC7821IC601PC1237HA CONTROL Board IC802BA6208 (TA-FE330R/FE530R) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 CONTROL LATCH SHIFT RESISTER LEVEL SHIFT CL DI CE VEE L COM3 L7 L COM2 L5 L4 L2 VSS S RES VDD R

20、 COM3 R8 R7 R COM2 R6 R4 R2 R5 R COM1 R3 R1 L3 L1 L COM1 L6 L8 BUFFER 12345678 OVER LOAD DET F/F OFFSET DET LATCH/ AUTORESET VCC ON MUTE AC OFF DET VCC 12345678 OVER LOAD DET F/F OFFSET DET LATCH/ AUTORESET VCC ON MUTE AC OFF DET VCC 3-8.IC PIN FUNCTION DESCRIPTION CONTROL BOARD IC801 TMP47C103N-JP4

21、7 (FUNCTION SWITCH CONTROL, LED DRIVER) Pin No.Pin NameI/ODescription 1XOUTOMain system clock output terminal (4 MHz) 2XINIMain system clock input terminal (4 MHz) 3RESETI System reset signal input terminal “L”: reset For several hundreds msec. after the power supply rises, “L” is input, then it cha

22、nges to “H” 4PMDI Setting terminal for the model TA-FE230: fixed at “L”, TA-FE330R/FE530R: fixed at “H” 5VOL+O Motor drive signal output to the volume motor drive (IC802) (volume up direction) Used for the TA-FE330R/FE530R only (TA-FE230: Not used (pull up) 6VOLO Motor drive signal output to the vol

23、ume motor drive (IC802) (volume down direction) Used for the TA-FE330R/FE530R only (TA-FE230: Not used (pull up) 7SW0I 8SW1IRotary switch input of the INPUT SELECTOR (S801) 9SW2I 10EONI Detection signal input of the enhanced other networks (EON) Used for the TA-FE530R only (TA-FE230/FE330R: Not used

24、 (fixed at “H”) 11PHONOOLED drive signal output of the PHONO LED (D808) “L”: LED on 12TUNEROLED drive signal output of the TUNER LED (D809) “L”: LED on 13CDOLED drive signal output of the CD LED (D810) “L”: LED on 14GNDGround terminal 15AUXOLED drive signal output of the AUX LED (D811) “L”: LED on 1

25、6DATOLED drive signal output of the TAPE2/MD LED (D812) “L”: LED on 17TAPEOLED drive signal output of the TAPE1/DAT LED (D813) “L”: LED on 18MONO Tape monitor on/off control signal output terminal “L”: tape monitor on Used for the TA-FE530R only (TA-FE230/FE330R: Not used (pull up) 19PRYO AC on/off

26、relay drive signal output terminal “L”: power on, “H”: standby mode Used for the TA-FE330R/FE530R only (TA-FE230: Not used (pull up) 20PKYI Power switch (S1; I/u) input terminal “H”: power on Used for the TA-FE330R/FE530R only (TA-FE230: Not used (fixed at “H”) 21MONI TAPE1 MONITOR switch (S802) inp

27、ut terminal When pressing the key: “H” Used for the TA-FE530R only (TA-FE230/FE330R: Not used (fixed at “H”) 22SIRCSI Sircs signal input from the remote control receiver (IC803) Used for the TA-FE330R/FE530R only (TA-FE230: Not used (pull up) 23MUTEOAudio line muting on/off control signal output ter

28、minal “H”: muting on 24SCEOChip enable signal output to the function switch (IC101) 25SDTOSerial data output to the function switch (IC101) 26SCKOSerial data transfer clock signal output to the function switch (IC101) 27STOPIDetection signal input of the AC input 28+3VPower supply terminal (+3V) htt

29、p:/cxema.ru 23 (1)CASE SECTION SECTION 4 EXPLODED VIEWS The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipat

30、ed when ordering these items. The mechanical parts with no reference num- ber in the exploded views are not supplied. Hardware (# mark) list and accessories and packing materials are given in the last of the electrical parts list. NOTE: -XX and -X mean standardized parts, so they may have some diffe

31、rence from the original one. Color Indication of Appearance Parts Example: KNOB, BALANCE (WHITE) . . . (RED) Parts Color Cabinets Color Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark 14-996-698-41 EMBLEM, SONY 23-704-366-01 SCREW (CASE) (M3X8) (BLACK) 23-704-366-71 SCREW (CASE) (

32、SILVER) * 34-211-940-21 CASE (BLACK) * 34-211-940-31 CASE (SILVER) 44-977-591-01 FOOT (F50150S) (BLACK) 44-977-591-31 FOOT (F50150S) (SILVER) * 54-978-398-21 CUSHION 1 2 2 3 4 #1 #1 #1 5 4 #1 #1 5 2 http:/cxema.ru 24 Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark (2)FRONT PANEL S

33、ECTION 51X-4950-306-1 KNOB ASSY, VOLUME (BLACK) 51X-4950-307-1 KNOB ASSY, VOLUME (SILVER) 524-211-947-01 KNOB (FUNCTION) (BLACK) 524-211-947-11 KNOB (FUNCTION) (SILVER) 534-211-945-01 KNOB (BALANCE) (BLACK) 534-211-945-11 KNOB (BALANCE) (SILVER) 544-211-950-01 KNOB (SPEAKER) (BLACK) 544-211-950-11 K

34、NOB (SPEAKER) (SILVER) * 561-673-107-11 AC-SW BOARD (FE230) 574-211-946-01 BUTTON (LINK) (BLACK) 574-211-946-11 BUTTON (LINK) (SILVER) 584-211-949-01 BUTTON, POWER (BLACK) 584-211-949-11 BUTTON, POWER (SILVER) * 591-673-099-11 POWER SW BOARD (FE330R/FE530R) 604-951-620-01 SCREW (2.6X8), +BVTP 611-67

35、3-100-11 H. P BOARD 624-211-951-01 WASHER (FIBER DIA. 8) 634-211-948-01 BUTTON (LOUDNESS) (BLACK) 634-211-948-11 BUTTON (LOUDNESS) (SILVER) * 641-673-101-11 FUN-SW BOARD * 65A-4419-874-A CONTROL BOARD, COMPLETE (FE230) * 65A-4419-881-A CONTROL BOARD, COMPLETE (FE330R) * 65A-4419-892-A CONTROL BOARD,

36、 COMPLETE (FE530R) * 664-211-953-01 SHIELD (VOLUME) * 671-673-102-11 TAPE MONITOR BOARD (FE530R) 68X-4951-634-1 PANEL ASSY (BLACK) 68X-4951-635-1 PANEL ASSY (SILVER) 68X-4951-636-1 PANEL ASSY (FE330R) 68X-4951-637-1 PANEL ASSY (FE230) supplied with S205 supplied with RV202 supplied with RV201, 203,

37、204 supplied with S801 not supplied not supplied #1 not supplied not supplied supplied with JK501 FE330R/FE530RFE230 FE530R FE530R 58 57 5960 56 60 60 61 63 62 60 64 62 62 65 66 67 60 60 68 51 52 53 54 http:/cxema.ru 25 (3)CHASSIS SECTION Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionR

38、emark * 1021-673-106-11 AC-RY BOARD (FE330R/FE530R) * 1041-673-105-11 DC-SUP BOARD 1054-221-642-01 CUSHION * 1061-673-104-11 FUSE BOARD * 107A-4419-873-A MAIN BOARD, COMPLETE (FE230) * 107A-4419-880-A MAIN BOARD, COMPLETE (FE330R) * 107A-4419-891-A MAIN BOARD, COMPLETE (FE530R) 1084-211-952-01 WASHE

39、R (FIBER DIA. 10) * 1103-703-244-00 BUSHING (2104), CORD !1111-770-019-11 ADAPTOR, CONVERSION PLUG 3P (UK) * 1124-211-938-31 PANEL, BACK (FE530R: AEP) * 1124-211-938-41 PANEL, BACK (FE330R: AEP) * 1124-211-938-51 PANEL, BACK (FE330R: UK) * 1124-211-938-61 PANEL, BACK (FE230: AEP) * 1124-211-938-71 P

40、ANEL, BACK (FE230: UK) * 1124-211-938-81 PANEL, BACK (FE530R: UK) * 1131-673-103-11 AC OUTLET BOARD (FE330R: AEP/FE530R: AEP) !CN41-526-794-11 OUTLET, AC (AC OUTLET, SWITCHED 100W MAX) (FE330R: AEP/FE530R: AEP) !CN51-526-794-11 OUTLET, AC (AC OUTLET, SWITCHED 100W MAX) (FE330R: AEP/FE530R: AEP) !CN6

41、1-526-794-11 OUTLET, AC (AC OUTLET, SWITCHED 100W MAX) (FE330R: AEP/FE530R: AEP) !CP11-575-651-21 CORD, POWER !T11-433-621-11 TRANSFORMER, POWER (FE230) !T11-431-802-11 TRANSFORMER, POWER (FE530R) !T11-431-803-11 TRANSFORMER, POWER (FE330R) FE530R FE330R/ FE530R FE330R: AEP/ FE530R: AEP FE330R: AEP/

42、 FE530R: AEP not supplied not supplied #1 #1 #1 #1 not supplied not supplied #1 #1 #1 UK CN6 CN5 CN4 #1 #1 #3 #2 #4 CP1 #1 #5 #4 #3 not supplied not supplied 107 110 111 112 113 #2 T1 104 105 106 not supplied 108 102 not supplied The components identified by mark ! or dotted line with mark ! are cri

43、tical for safety. Replace only with part number specified. http:/cxema.ru 26 SECTION 5 ELECTRICAL PARTS LIST Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark NOTE: Due to standardization, replacements in the parts list may be different from the parts speci- fied in the diagrams or

44、the components used on the set. -XX and -X mean standardized parts, so they may have some difference from the original one. RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable Items marked “*” are not stocked since they are seldom

45、required for routine service. Some delay should be anticipated when order- ing these items. SEMICONDUCTORS In each case, u: , for example: uA. .: A. .uPA. . : PA. . uPB. . : PB. .uPC. . : PC. . uPD. . : PD. . CAPACITORS uF: F COILS uH: H The components identified by mark ! or dotted line with mark !

46、 are critical for safety. Replace only with part number specified. When indicating parts by reference number, please include the board. Abbreviation EE: East European *1-673-103-11 AC OUTLET BOARD (FE330R: AEP/FE530R: AEP) * 1-533-293-11 FUSE HOLDER !CN41-526-794-11 OUTLET, AC (AC OUTLET, SWITCHED 1

47、00W MAX) !CN51-526-794-11 OUTLET, AC (AC OUTLET, SWITCHED 100W MAX) !CN61-526-794-11 OUTLET, AC (AC OUTLET, SWITCHED 100W MAX) !F21-532-464-51 FUSE (T2.5AL/250V) * *1-673-106-11 AC-RY BOARD (FE330R/FE530R) * !C11-113-924-11 CERAMIC0.0047uF20%250V C9171-136-153-00 FILM0.01uF5%50V C9191-126-941-11 ELECT470uF20%25V * CN11-580-230-31 PIN, CONNECTOR (PC BOARD) 2P CN21-564-321-00 PIN, CONNECTOR 2P (FE330R: AEP/FE530R: AEP) * CN9031-564-506-11 PLUG, CONNECTOR 3P * CN9541-564-506-11 PLUG, CONNECTOR 3P D9118-719-911-19 DIODE 1SS119 D9128-719-