Arcam-DivaA65-int-sm维修电路原理图.pdf

《Arcam-DivaA65-int-sm维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《Arcam-DivaA65-int-sm维修电路原理图.pdf（42页珍藏版）》请在收音机爱好者资料库上搜索。

1、A65/75DiVA A65, A75 & P75 PlusAmplifi ers Service Manual ARCAMARCAMIssue 1.0RadioFans.CN 收音机爱 好者资料库 Contents List ! Contents list ! Circuit description ! Service guide ! Circuit diagrams ! Component overlays ! Circuit board parts list ! General assembly parts list RadioFans.CN 收音机爱 好者资料库A65/75/75P P

2、lus Circuit Description PSU In order get the output devices to turn fully on and achieve the greatest efficiency, an auxiliary rail is formed from a charge pump driven by the main AC outputs from the transformer. C304,305 & D301,302 charge on alternate cycles. In the other cycle the charge on C304,3

3、05 is pumped into C310,311 respectively. This creates a voltage much greater than the standard rails, but with low regulation and high ripple. This is then regulated to 38V via emitter followers Q300,302,303,305 from a zener stabilized voltage (D304,305) The Pre-amp 15V supply comes from linear regu

4、lators Z300,301. The transformer is a dual voltage unit, the required voltage being selected by which fuse holder is fitted with the appropriate fuse. If an alternative to 115V or 230V is required then a different transformer is fitted. The secondary is centre tapped for the main rails, but a separa

5、te winding is added for the uC supply. The star ground point SP300 is not a component on the PCB and is on the schematic only for layout purposes. Pre-amp The direct signal path (line in, tone controls defeated) consists of a single op-amp gain stage, buffering the j-fet input multiplexers and Tape

6、Monitor and AV switches. The selected input is AC coupled to the op-amp, the output is DC to the Pre-out, via a j-fet pre-mute switch. This switch is controlled by the uC in such a way that when ever the output relay changes state signal is removed from the power amplifier (A65/75). The MM phono sta

7、ge (by passable A75 only, SW100) is opamp based. The circuit is AC coupled to give RIAA/IEC low frequency response. The cartridge is loaded by R100,101,C119,120. The 1kHz gain is 56dB, and RIAA eq set by R110,112,111,113,C127,129,128,130. Each line input has static protection afforded by the back to

8、 back diodes (e.g. D101,103), and RF filtering is set by R118,C134 etc. The selected input is buffered for Tape output by Z104 set as a follower. The output resistor is inside the feedback loop so to keep the output impedance low and short protection is catered for. C121,122 maintain stability into

9、capacitive loads. From the tape monitor switch (Z105) onwards the signal is AC coupled (C151,152). From there the signal is fed to the tone controls. These consist of two stages: Balance and buffer (Z160), and Bass/Treble Z161. The output of this stage is again AC coupled. Switch SW162 selects wheth

10、er the tone adjusted signal or a direct signal reaches the gain section. In the A75 Z164 can be used to bypass the volume control when AV input is selected. This fixes the gain to allow an external AV processor to control the volume setting. The gain stage (Z163) has a gain of 2.2, and the same low

11、impedance output arrangement as the Tape output. The signal from this stage to the Pre- amp outputs and the Power amp input is controlled by a A65, A75 & P75 Service Guide Fault diagnostics Fault Action No power Check mains fuse Check transformer connections Check power supply rails Stuck in protect

12、ion Check power supply rails Check protection circuit voltages Check for dry joints on o/p devices Intermittent audio on one channel Check for dry joints around o/p devices Fails to respond to commands Check supply to remote circuit Check IC Z900 Check remote flex foil cable Check for dry joints on

13、selector pcb Volume control rubs on front panel Pull knob out from fascia Audio crackles on o/p Check for component break down using hot air gun & freezer spray Check transformer connections Power supply test points Position Voltage LK125 +37 volts DC LK126 -37 volts DC LK271 or black speaker termin

14、al 0 volts LK303 +15 volts DC LK301 - 15 volts DC Q300 emitter +38 volts DC Q304 emitter +38 volts DC Q302 emitter -38 volts DC Q305 emitter -38 volts DC D910 emitter +5 volts DC remote supply IQ settings Model IQ setting Comments - (22/01/02) A65 37mV A75 37mV P75 37mV A85 12mV Set for 8.5mV cold,

15、reset for 12mV when warm P85 12mV Set for 8.5mV cold, reset for 12mV when warm A65 plus 12 to 15mV A75 plus 12 to 15mV P75 plus 12 to 15mV Hints & tips ! To isolate a fault between pre and power stage remove C602 (left channel) or C702 (right channel). ! Always check and re-solder o/p device SAP15N

16、and SAP15P pin connections. ! Replace Z900 IC if software version is below version 3 ( note version 82 is also ok ). ! Make sure R127 is not touching LK130. ! When replacing the top cover with a new top it may be necessary to re-drill the fixing holes. ISSUEDRAWING NO.DRAWING TITLEDATEFilename:ECO N

17、o.DESCRIPTION OF CHANGEL942C1_1.0.PRJA65 PLUS AMPContact Engineer:L942C111-Dec-2001INITIALSPrinted:17SheetofNotes:Contact Tel:(01223) 203 200Travis PierceA & R Cambridge Ltd.Pembroke AvenueCambridge CB5 9PBWaterbeachPWRLEFTPROTECTIONA1SP2_SEND_LSP2_RETN_LOP_LA1LEFT CHANNELL942C5_1.0.SCHACLT1MUTEAVCO

18、NTROLTAPECONTROLMUX1MUX2MUX3PREMUTEPROT SENSEREMOTE CONTROLL942C7_1.0.SCHSELOPRSELOPLMUX1MUX2MUX3TAPECONTROLACSENSEPROT_OP_LPROT_OP_RPROTECTIONMUTEHPSW2HPSW1TAPOLTAPORPROT SENSEPHONO & INPUTSL942C3_1.0.SCHACSENSEACLT1POWER SUPPLYL942C2_1.0.SCHPWRRIGHTA1SP2_RETN_ROP_RSP2_SEND_RA1RIGHT CHANNELL942C6_1

19、.0.SCHPWRLEFTPWRRIGHTSELOPRSELOPLHPSW2AVCONTROLHPSW1SP2_SEND_LSP2_RETN_LOP_LOP_RSP2_SEND_RSP2_RETN_RPREMUTETAPORTAPOLPROT_OP_RPROT_OP_LTONE CONTROLL942C4_1.0.SCHTGP12/12/01PRODUCTION RELEASE1.0USE exlude A65 FILTER FOR BOM01_E020TOP SHEET FOR A65 L942AYISSUEDRAWING NO.DRAWING TITLEDATEFilename:ECO N

20、o.DESCRIPTION OF CHANGEL942C5_1.0.SCHA65 PLUS AMPContact Engineer:L942C511-Dec-2001INITIALSPrinted:57SheetofNotes:Contact Tel:(01223) 203 200Travis PierceA & R Cambridge Ltd.Pembroke AvenueCambridge CB5 9PBWaterbeachQ600BC556BQ601BC556BQ6042SA970GRQ606BC546BQ607BC546BR617680R MFR61910K MFR61810K MFR

21、61347R MFR61447R MFR612100K MFR6001K0 MFPWRLEFTQ6112SC2240GRQ6102SC2240GRR62010K MFQ6032SA970GRQ608BC546BQ609BC546B+C601100U EL 100V+C600100U EL 100V0V_HF+C61610U ELL6002U2H LAC SMALLR6312R2 CFR6304R7 W2 CFD6031N4003F+37V-37VC621470P CDRLY1ARLY G5Z-2A-EC620470P CDC6221N0 CDSPLD600SPLS600PD6OP_LSP2_S

22、END_LSP2_RETN_LR6162K7 MFR611100K MFC603100P PPW0V_SIG0V_HF0V_SIG0V_HFQ6122SC2240GRR627430R MFR606100R MFR605100R MFR6256K8 MFR62210K MFR621680R MFR62947K MF+C61710U ELQ605BC556BA1PROTECTIOND6041N4003FR628430R MFR6266K8 MF+C61810U ELR608100R MFR607100R MFA1D6051N4148D6061N41480V_LS_L0V_LS_LQ602BC556

23、BR61547R MFR601100R MFR602100R MFR603100R MFR604100R MFSPLE600Left Channel Power AmplifierQ614SAP15NQ615SAP15PD6004V7 400MWISSUEDRAWING NO.DRAWING TITLEDATEFilename:ECO No.DESCRIPTION OF CHANGEL942C7_1.0.SCHA65 PLUS AMPContact Engineer:L942C711-Dec-2001INITIALSPrinted:77SheetofNotes:Contact Tel:(012

24、23) 203 200Travis PierceA & R Cambridge Ltd.Pembroke AvenueCambridge CB5 9PBWaterbeachWARNING SAFETY CRITICAL COMPONENTREPLACE WITH IDENTICAL PARTuC, Volume Drive & Remote ControlC91210N CDC90010N CDR9001R0 FUD9061N4003FD9071N4003F+C9201M0 25VC91310N CDMOTE900P900+5vVOLUME DRIVEMOTOR DRIVER+5VGND1MD

25、12CC13REF4MC15MC26VCC17VCC28CC29MD210Z905BA610912VOLMOT9001Y271ACLT1MUTEMUX1MUX2MUX3AVCONTROLTAPECONTROLR915220R MFA01A12A23VSS4SDA5SCL6WP7VDD8Z90624C01C917100N CDX900CST4.00C918100N CD+C914220U EL+5v+5v+5vC919100N CD123SW900A2PCO_NON_LAT456SW900B2PCO_NON_LATR912100K MF+C92110U ELD9101N4148R91310K M

26、F+5v+5VR9144K7 MF0V_DIG0V_DIG0V_DIG0V_DIG0V_DIG0V_DIG0V_DIG0V_DIG0V_DIG0V_DIG0V_DIG0V_DIG0V_DIGVDD16GND8Z907B74HC4051R90410R MF+C915100U ELPREMUTE0V_DIG+5VMOTSUP900VOLM901VOLM900REMO900C916100N CD123LK9033WAY CABLE HOLDERD9111N414812345678910SK900FFC10VR902100R MFR903100R MFISSUEDRAWING NO.DRAWING T

27、ITLEDATEFilename:ECO No.DESCRIPTION OF CHANGEL942C3_1.0.SCHA65 PLUS AMPContact Engineer:L942C311-Dec-2001INITIALSPrinted:37SheetofNotes:Contact Tel:(01223) 203 200Travis PierceA & R Cambridge Ltd.Pembroke AvenueCambridge CB5 9PBWaterbeach321Z100ANE5532C119100P PPR10047K MFR108470R MFC12447P CD+C1252

28、2U ELR110680K MFR11256K MFC1274N7 PPC1291N3 PPC120100P PPR10147K MFR109470R MFC12347P CD+C12622U ELR111680K MFR11356K MFC1284N7 PPC1301N3 PP567Z100BNE5532-15V+15VCDTUNERVCRAV/DVDTAPE INTAPE OUTEMC1NFSK100APHONO4GBOT56TOP4NFSK100BPHONO4GEMC1NFSK103APHONO4GNFSK103BPHONO4GEMC1NFSK102APHONO4GNFSK102BPHO

29、NO4GEMC1NFSK101APHONO4G84Z100CNE5532Phono Stage & Input SelectionD1041N4148D1061N4148D1051N4148D1071N4148D1081N4148D1121N4148D1131N4148D1091N4148D1141N4148D1101N4148D1151N4148D1111N4148D1241N4148D1201N4148D1211N4148D1251N4148D1221N4148D1261N4148D1231N4148D1271N4148D1011N4148D1031N4148D1001N4148D1021

30、N4148R1181K0 MFR1191K0 MFR1221K0 MFR1231K0 MFR1241K0 MFR1251K0 MFR1261K0 MFR1271K0 MFR1281K0 MFR1211K0 MFR130100K MFR131100K MFR133100K MFR134100K MFR135100K MFR136100K MFR137100K MFR142100K MFR143100K MFR144100K MF+15v+15v+15v+15v+15v+15v+15v+15v+15v+15v+15v+15v-15v-15v-15v-15v-15v-15v-15v-15v-15v-

31、15v-15v-15vVCROLVCRORTUNOLTUNORCDOLCDORDVDOLDVDORTAPEOLTAPEORAUXOLVCROLTUNOLCDOLDVDOLAUXORVCRORTUNORCDORDVDORTAPECONTROLMUX1MUX2MUX3MUX1MUX2MUX3+5v+5v+15v+15v+15v-15v-15v-15vTAPECONTROLR1201K0 MFR1171K0 MFR129100K MFR132100K MFAUXOLAUXORTAPEOLTAPEORC134470P PPWC144470P PPWC143470P PPWC142470P PPWC14

32、1470P PPWC140470P PPWC139470P PPWC138470P PPWC137470P PPWC135470P PPWC136470P PPWC133470P PPW+5vR15447R MFR15547R MFC122100P PPC121100P PPD1161N4148D1181N4148D1171N4148D1191N4148-15v-15v+15v+15v+15v+15v+15v-15v-15v-15v567Z104BTL072321Z104ATL07284Z104CTL072SELOPLSELOPRR140100K MFR141100K MFMUX3MUX2MU

33、X1TAPECONTROL+15V-15VRLY1CRLY G5Z-2A-EPWR1IN12IN230V4V-5O6FB7RC8V+9Z101TA7317PR10547K MFR10347K MFR10247K MFR10447K MF+C1481U0 ELR149100K MFD1281N4003FR10647K MFQ1002SC2240GRR1531K0 1W CFD1301N4003FR14510K MFR150100K MF+C149100U EL+37VR15118K MF-37VR15233K MFR10747K MFD1291N4003FR1472K7 1W CF+37VR14

34、62K7 1W CFRGLED100LED RED/GRN 3MMD1315V6 400MW132LK100L856CAR148470R FUACSENSEPROT_OP_LHPSW1MUTEPROT_OP_RC112100N CDC113100N CDC109100N CDC114100N CDC110100N CDC118100N CDC107100N CDC108100N CDC101100N CDC102100N CD+C14510U EL+C14610U ELC115100N CDC116100N CDR139100K MFR138100K MFPROTECTION0V_SIG0V_

35、SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_SIG0V_HF0V_HF0V_HF0V_HF0V_HF0V_HF0V_SIG0V_SIGR1148K2 MFR1158K2 MFR11618K MF+C1501U0 ELHPSW2TAPEC

36、ONTROLMUX1MUX2MUX3C147100U NPCDLCDRTUNLTUNRVCRLVCRRDVDLTAPLTAPRTAPOLTAPORTAPOLTAPORPHINLPHINRDVDR123LK100A3WAY CABLE HOLDER+C151100U SILMIC 2+C152100U SILMIC 2R157100K MFR1561K5 MFC15310N CDTH100PTH90DEGD1321N4148PROT SENSE12LK10110MM LINK12LK10210MM LINK12LK10410MM LINK12LK10310MM LINKThermAC DetPr

37、otRC+15v-15vD1345V6 400MWC117470P CD0V_HF+C13122U EL+C13222U ELX04X15X26X37X412X511X610X79EN2A01A116A215V-3D8GND14V+13Z102DG408DJX04X15X26X37X412X511X610X79EN2A01A116A215V-3D8GND14V+13Z103DG408DJSEL11S214D12V+13S13S311V-4GND5VL12S46D310D47SEL39D215SEL48 SEL2 16Z105DG413DJTGP12/12/01PRODUCTION RELEAS

38、E1.001_E020C154100N PE 100VUSE exlude A65 FILTER FOR BOMISSUEDRAWING NO.DRAWING TITLEDATEFilename:ECO No.DESCRIPTION OF CHANGEL942C2_1.0.SCHA65 PLUS AMPContact Engineer:L942C211-Dec-2001INITIALSPrinted:27SheetofNotes:Contact Tel:(01223) 203 200Travis PierceA & R Cambridge Ltd.Pembroke AvenueCambridg

39、e CB5 9PBWaterbeachLNENELSK300IEC3FS300AS1A25+C30810M EL 50V+C30910M EL 50V+300-300+15V-15V+37V-37VSW300BA1007SW300AA1007SELECT VOLTAGEBY FITTING FS201OR FS202MAINS INPUTMAINS SWITCHFIT ONLY ONE FUSEChassis Earth Point,Use correct screw and washer.R300100R MFT300T301PD300TOOLINGFS301AS2A5_115VBlue1D

40、ark Grey2Orange3SK301CAGECLAMP3Green1SK302CAGECLAMP1Grey1Grey2SK303CAGECLAMP2Orange1Blue2Orange3SK304CAGECLAMP3AGREEN300OR300OR301BLUE301BLUE300POWER SUPPLYACSENSEACLT1C3013N3 MAINSC3003N3 MAINSC3023N3 MAINS0V_DIG0V_HFPSUP300NSUP300MAINS_N300MAINS_E300MAINS_L300WARNING SAFETY CRITICAL COMPONENTREPLA

41、CE WITH IDENTICAL PARTPD301TOOLINGPD302TOOLINGPD304TOOLINGPD305TOOLINGY300TX WIRE CLIPPD311TARGET1PD312TARGET1Y301TX WIRE CLIPPD306TOOLINGPD307TOOLINGC3031N0 CDPhoto StripPS300PHOTO_STRIPSpare Fuse ClipEL300FUSE CLIPPD303TOOLINGPD308TOOLINGPD309TOOLINGPD310TOOLINGPaper MarkerA1 HorizontalDD302DD_A1H

42、CEM1, 2 OZ CuPCB MATERIALDD300CEM1_20Z0V_DIGPCBPCB1L940PB_A+12-43BR300BRGBU8DQ300BC546BQ302BC556BD3031N4003FD3001N4003FD3011N4003FD3021N4003F+C310100U EL 100V+C311100U EL 100VD304ZENER 500MW 39VD305ZENER 500MW 39V+C312220U EL 50V+C313220U EL 50V+C30447U EL 100V+C30547U EL 100VR3014K7 MFR3024K7 MF+38

43、V_R-38V_RQ304BC546BQ305BC556B+38V_L-38V_LR31110R FUR31210R FUAC+38V_R+37V_L-37V_R-37V_LLK1LINK10NPLK6LINK10NPLK11LINK10NPLK16LINK10NPLK21LINK10NPLK26LINK10NPLK31LINK10NPLK36LINK10NPLK41LINK10NPLK46LINK10NPLK51LINK10NPLK56LINK10NPLK61LINK10NPLK66LINK10NPLK71LINK10NPLK96LINK10NPLK76LINK10NPLK81LINK10N

44、PLK86LINK10NPLK91LINK10NPLK2LINK10NPLK7LINK10NPLK12LINK10NPLK17LINK10NPLK22LINK10NPLK27LINK10NPLK32LINK10NPLK37LINK10NPLK42LINK10NPLK47LINK10NPLK52LINK10NPLK57LINK10NPLK62LINK10NPLK67LINK10NPLK72LINK10NPLK97LINK10NPLK77LINK10NPLK82LINK10NPLK87LINK15NPLK92LINK10NPLK3LINK10NPLK8LINK10NPLK13LINK10NPLK1

45、8LINK10NPLK23LINK10NPLK33LINK10NPLK38LINK10NPLK43LINK10NPLK48LINK10NPLK53LINK10NPLK58LINK10NPLK63LINK10NPLK68LINK10NPLK73LINK10NPLK98LINK10NPLK78LINK10NPLK83LINK10NPLK88LINK10NPLK93LINK10NPLK4LINK10NPLK9LINK10NPLK14LINK10NPLK19LINK10NPLK24LINK10NPLK29LINK10NPLK34LINK10NPLK39LINK10NPLK44LINK10NPLK49L

46、INK10NPLK54LINK10NPLK59LINK10NPLK64LINK10NPLK69LINK10NPLK74LINK10NPLK99LINK10NPLK79LINK10NPLK84LINK10NPLK89LINK10NPLK94LINK10NPLK5LINK10NPLK10LINK10NPLK15LINK10NPLK20LINK10NPLK25LINK10NPLK30LINK10NPLK35LINK10NPLK40LINK10NPLK45LINK10NPLK50LINK10NPLK55LINK10NPLK60LINK10NPLK65LINK10NPLK70LINK10NPLK75LI

47、NK10NPLK80LINK10NPLK85LINK10NPLK90LINK10NPLK95LINK10NPLK106LINK10NPLK111LINK10NPLK116LINK10NPLK121LINK10NPLK131LINK10NPLK136LINK10NPLK141LINK10NPLK151LINK10NPLK156LINK10NPLK161LINK10NPLK166LINK10NPLK196LINK10NPLK181LINK10NPLK186LINK10NPLK191LINK10NPLK107LINK10NPLK112LINK10NPLK117LINK10NPLK122LINK10N

48、PLK127LINK10NPLK132LINK10NPLK137LINK10NPLK142LINK10NPLK152LINK10NPLK157LINK10NPLK162LINK10NPLK167LINK10NPLK197LINK10NPLK182LINK10NPLK187LINK10NPLK192LINK10NPLK108LINK10NPLK113LINK10NPLK118LINK10NPLK123LINK10NPLK128LINK10NPLK133LINK10NPLK138LINK10NPLK143LINK10NPLK148LINK10NPLK153LINK10NPLK158LINK10NP

49、LK163LINK10NPLK198LINK10NPLK178LINK10NPLK183LINK10NPLK188LINK10NPLK193LINK10NPLK109LINK10NPLK114LINK10NPLK119LINK10NPLK124LINK10NPLK129LINK10NPLK134LINK10NPLK139LINK10NPLK149LINK10NPLK154LINK10NPLK159LINK10NPLK164LINK10NPLK199LINK10NPLK179LINK10NPLK189LINK10NPLK194LINK10NPLK105LINK10NPLK110LINK10NPL

50、K115LINK10NPLK120LINK10NPLK130LINK10NPLK135LINK10NPLK140LINK10NPLK145LINK10NPLK150LINK10NPLK155LINK10NPLK160LINK10NPLK165LINK10NPLK180LINK10NPLK185LINK10NPLK190LINK10NPLK195LINK10NPLK201LINK10NPLK202LINK10NPLK203LINK10NPLK204LINK10NPLK205LINK10NPLK206LINK10NPLK207LINK10NPLK208LINK10NPLK209LINK10NPLK