Denon-AVR1604-avr-sm维修电路原理图.pdf

《Denon-AVR1604-avr-sm维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《Denon-AVR1604-avr-sm维修电路原理图.pdf（71页珍藏版）》请在收音机爱好者资料库上搜索。

1、SERVICE MANUALMODEL AVR-1604/684 AVC-1580AV SURROUND RECEIVER / AMPLIFIER16-11, YUSHIMA 3-CHOME, BUNKYO-KU, TOKYO 113-0034 JAPAN X0174V.02 DE/CDM 0311For U.S.A., Canada, Europe, U.K.,Asia, China,Taiwan R.O.C., Korea& Japan model前、必読。本機、火災、感電、対安全性確保配慮、法的電気用品安全法、所定許可得製造。従際、安全性維持、記載注意事項必守。本機仕様性能改良、予告変更

2、。Please use this service manual with referring to the operating instructions without fail.Some illustrations using in this service manual are slightly different from the actual set.修理際、必取扱説明書参照上、作業行。本文中使用、説明都合上現物多少異場合。補修用性能部品保有期間、製造打切後8年。注意For purposes of improvement, specifications anddesign are su

3、bject to change without notice.RadioFans.CN 收音机爱 好者资料库22AVR1604/684 / AVC-1580SAFETY PRECAUTIONSThe following check should be performed for the continued protection of the customer and service technician.LEAKAGE CURRENT CHECKBefore returning the unit to the customer, make sure you make either (1) a

4、leakage current check or (2) a line to chassisresistance check. If the leakage current exceeds 0.5 milliamps, or if the resistance from chassis to either side of thepower cord is less than 460 kohms, the unit is defective.(1) (2) 500V1M(1) (2) RadioFans.CN 收音机爱 好者资料库33AVR-1604/684 / AVC-1580CAUTION

5、IN SERVICING Initializing AV SURROUND RECEIVERInitializing AV SURROUND RECEIVERAV SURROUND RECEIVER initialization should be performed when the mcom, peripheral parts of mcom, and DSP P.W.B. are replaced.1.Switch off the unit and remove the AC cord from thewall outlet.2.Hold the following SPEAKER A

6、button and SPEAK-ER B button, and plug the AC cord into the outlet.3.Check that the entire display is flashing with aninterval of about 1 second, and release your fingersfrom the 2 buttons and the microprocessor will be initializedNote: Note: If step 3 does not work, start over from step 1. Alluser

7、settings will be lost and this factorysetting will be recovered when this initialization mode. So make sure to memorize your setting for restoring after the initialization.時注意事項 AV 初期化 AV 初期化周辺部品、DSP 基板等交換場合、AV 初期化行下。1.電源押状態、壁電源電源抜。2.SPEAKER A SPEAKER B 同時押、電源差込。3. 表示約 1 秒間隔点滅確認後、2 指離。初期化。注意 :注意 :上記

8、 3 状態場合、一度操作 1 直。 初期化行客様設定内容工場出荷 状態戻、設定内容 控初期化後再設定。44AVR-1604/684 / AVC-1580LEVEL DIAGRAMSFRONT/CENTR/SURROUND/SURROUND BACK20dB10dB0dB(200mV)-10dB-20dB6CH IN40dB30dB0dB(200mV)-10dB-20dB-12dB6CH INCD IN-10dBFS-30dBFS-20dBFS6CH INCENTERSURROUNDSURROUND-BACK6CH IN-10dBFS-20dBFS-30dBFS6dBD/A OUT100mV R

9、EFDSP OUTD/A+MUTEDSP OUTD/A+6dBD/A-10dBFS0dBFS-20dBFS-30dBFSMUTED/A OUT100mV REFCENTERSL/SR/SBFRONT40dB30dB20dB10dBA/D- -+A/D0dBFSCD IN6CH INA/D INREV AMPA/D INREV AMPA/D INREV AMPINPUTBUFFERAMPDIRDIGITALD/A OUTLPFREV AMPSW SUMREV AMP+HPFMUTEDSPD/A- - -SUM S/W+D/A0dBFSBD3811K1+MUTEPOWER AMPTONEPRE A

10、MPELECTRICVOLUMESPK OUTFRONT2.83V(1W/8ohm)SPK OUTFRONTATTH/P OUTMUTE-18dB15.5dBVOL 00MUTE-18dBBD3811K1BD3812F+15.5dBVOL 00-35.5dBH/P OUT47mV(0.27W 8ohm)SPK OUTCENTERSURROUNDSPK OUTSURROUNDBACK25.5dBSPK OUT2.83V(1W/8ohm)25.5dB55AVR-1604/684 / AVC-1580SUB WOORER6dBConfig1-38dBFS(112mV)(200mV)-5dB-30dB

11、-20dB-10dB30dB20dB10dBOdBD/A-10dBFS0dBFS6dB6dB10.5dB6CH IN-20dBFS-30dBFSConfig2-25dBFSLFELFEFront D/A Out200mV refD/A+MUTESUB_WOOFER- - -DSP OUTD/A OUTLPFSW SUMREV AMPREV AMP6CH INPUT+MUTEELECTRICVOLUMEPRE AMPSUB WOOFERPRE OUTBD3811K1SUB WOOFERPRE OUT150mVTO FRONT CH-18dBVOL 0027.5(15.5+6+6)dB66AVR-

12、1604/684 / AVC-1580BLOCK DIAGRAMLOOP FILTERFMFRONTENDTUNERSRSLSWCFRFLTUNERPARTFM ANTAM ANT6CH_EX_INPUTIF AMPIF FILTERIF FILTERIF ICFM & AMAM TUNINGPLL CIRCUITFROM u-COMMUTINGL.P.FMPX ICFRONT INOPTICAL 3V.AUX L/RV.AUX VIDEOANALOG INCDR/TAPEANALOG INCDVCRCDR/TAPETV/DBSDVD/VDPAUXVCRANALOGOUTADCADCHPFBD

13、3811K1ALRCKSERIAL DATACOUTMCLKI/O PORTDSDATA1ASDATAABCLKDIGITALFILTERDIGITALFILTERDIGITALFILTERVOLUMEVOLUMEVOLUMEDIGITALFILTERDIGITALFILTERSDOUTVOLUMEDIGITALFILTERDIGITALFILTERVOLUMEVOLUMEAUDIO CODECAD1837DIGITALFILTERDIGITALFILTERVOLUMEDIGITALFILTERVOLUMEINPUT SELECTOR & VOLUMEDVD/VDPTV/DBSVCR+DACD

14、ACDAC-VIDEO INPUTMUTE+DACDAC+DACDACDAC-EX_CCENTEREX_SRSRSWANA_INDSP_FREX_FR-DSP_FLEX_FLSLEX_SL-+12V-EX_SW2CH-VOLUME ICBD3812FMICOM, FLT DRVENCODERDIRCODECDSPRMC_IN/OUT+2.5V+3.3VCXA1511MRMC IN/OUTDVD/VDPTV/DBSMONITOR OUTCOMPONENT VIDEO INPUT( Y, B-Y, R-Y )BA7625*1,BA7626*2VIDEO SWITCHVIDEO SWITCHLA79

15、52*1( C, Y )LA7952*2VIDEO SWITCHDVD/VDPTV/DBSVCRS-VIDEO INPUTVCR OUTMONITOR OUTVCR OUTMONITOR OUT+12VOP AMPINPUT/VOL+5VA/D POWERRELAYVIDEO78127805MAIN +BOP AMPINPUT/VOLTUNERDATA IN (REMOCON)+5.6V(CPU)7805COMPONENTSEL1/2-VKKMAIN -B-36VDACDIGITALFILTERINPUTDIGITAL INOPTICAL 2OPTICAL 1COAXIALSelectorX-

16、TALOPTICALDIGITALOUTROM512k X 8RAM64k X 16RDATA(21)XMCKFROMMICOMCLATCHCINCCLKDIRDeModulateLock Detect&DATASelectorfs64fs256fsLC89057W-VF4DT0(56)74LV244BUFFERDATA256fs64fs64fsfsDR1CLKIN(32)DR0fsFL/FR/CSL/SRCONTROLPORTMUTESWFMIXINGTCLK1(65)RCLK1(68)RFS3(41)RFS1(69)RCLK0(61)TCLK0(57)TCLK2(47)SW/SBCLOCK

17、RESETDSPDIGITAL AUDIO DECODERMELODY 32AVC1570X / AVR1604 BLOCK DIAGRAMSCDININTREQSCDIOSCCLKCSFROMMICOMKEY_MATRIXRESONATOR12MHzANA_INDATATUNER PLLDATAFLT DRIVERMICOMCXP740096PART DATADTS/DD/PL IIBD3811K1+FL DRIVER+LC75721NE+FL DISPLAY16-ST-42GNK+FR-SPK BFLFR+-+SPK AFL-+-H/P OUT79157815AC OUTLET7805FI

18、LAMENT AC7805+MUTE+-+-+-SURR RSURR L-+CENTERSURR BACKSPEAKEROUTAC CORDPRE OUTSUB WOOFER77AVR-1604/684 / AVC-1580ADJUSTMENTTuner Section (AVR-1804/884 only)CONNECTION DIAGRAM OF MEASURING INSTRUMENTS? FMSTEREOMODULATORFM SSGDigitalVoltmeter75ohmT402T403IC402VR402TUNER BDR47120+1410dB? AMT402T403IC402

19、TUNER BDR471VR401FM ALIGNMENTInputOutputAdjustmentStepAlignmentItemTuningFrequencySettingTypeFrequencyInputLevelModulationCouplingTypeConnect toPointsAdjust to1CenterAdjustment98.1MHz(98.0MHz)FM SSG98.1MHz60dBMono1kHz 100%AntennaTerminalDigitalVoltmeterR471T402 50mV2Distortion98.1MHz(98.0MHz)FM SSG9

20、8.1MHz60dBMono1kHz 100%AntennaTerminalDistortionMeterOutputTerminal (L)T403MinimumDistortion3Repeat Steps 1 and 24Signal Level98.1MHz(98.0MHz)FM SSG98.1MHz20dBOFFAntennaTerminalLight “TUNED” onFL DisplayVR402AM ALIGNMENTOutputAdjustmentStepAlignmentItemFrequencyInputTypeConnect toPointsAdjust toRema

21、rks1Signal Level999 (1000)kHzAM SSGVR401Light “TUNED” onFL DisplaySSG OUTPUT74dB (EMF)88AVR-1604/684 / AVC-1580Audio SectionIdling CurrentRequired measurement equipment : DC Voltmeter調整必要測定器 : 直流電圧計Preparation(1)Avoid direct blow from an air conditioner or an electric fan, and adjust the unit at nor

22、mal room tempereture15 C 30 C (59 F 86 F).(2)Presetting POWER (Power sourse switch)OFF SPEAKER (Speaker terminal)No load (Do not connect speaker, dummy resistor, etc.)(1)、扇風機風通良場所避、通常使用状態置。周囲温度1530、湿度常湿。Adjustment(1)Remove top cover and set VR101, VR102, VR103, VR104, VR105 on Amp. Unit, VR106 on SU

23、RR.-BACK ch Amp.Unit at full counterclockwise ( ) position.(2)Connect DC Voltmeter to test points (FRONT-Lch: TP104, FRONT-Rch: TP105, CENTER ch: TP103,SURROUND-Lch: TP101, SURROUND-Rch: TP102, SURROUND-BACK ch: CP106).(3)Connect power cord to AC Line, and turn power switch ON.(4)Presetting.MASTER V

24、OLUME : - counterclockwise ( min.)MODE: 6CH STEREOFUNCTION: CD(5)Within 2 minutes after the power on, turn VR101 clockwise ( ) to adjust the TEST POINT voltage to 1.5 mV 0.5 mVDC.(6)After 10 minutes from the preset above, turn VR101 to set the voltage to 2.5 mV 0.5 mV DC.(7)Adjust the Variable Resis

25、tors of other channels in the same way.(1)上、基板VR101, VR102, VR103, VR104,VR105 及Surr. Back 基板VR106 反時計方向 () 回切状態。(2) (FRONT-Lch: TP104, FRONT-Rch: TP105, CENTER ch: TP103, SURROUND-Lch: TP101,SURROUND-Rch: TP102, SURROUND-BACK ch: CP106) 直流電圧計接続。(3)電源AC100V （95105V 範囲可）接続、電源ON 。(4)後、次。VOLUME（音量調節）反時

26、計方向 () 回、最小状態。SPEAKER-A（端子）無負荷（、抵抗器接続。）MODE : 6CH STEREOFUNCTION : CD(5)2分以内VR101 時計方向 () 回電圧次調整。1.5mV 0.5mV DC(6)予備調整10分後VR101 回、次電圧設定。2.5mV 0.5mV DC(7)同方法各可変抵抗調整。VR104TR104VR105TP105VR106CP106S Back chS RchVR102TP102VR103,TP103C chVR101,TP101F LchS LchF RchDC Voltmeter99AVR-1604/684 / AVC-1580SEMI

27、CONDUCTORSOnly major semiconductors are shown, general semiconductors etc. are omitted to list.主半導体記載。汎用半導体記載省略。? ? ? ? ? ICsCXP740096(IC201)PH7PH6PH5PH4PH3PH2PH1PH0PK7/TO1RSTVSSXTALEXTALPK6/CS0PK5/SI0PK4/SO0PK3/SCK0PF7/AN11PF6/AN10PF5/AN9PC6PC7PA0PA1PA2PA3PA4PA5PA6PA7NCVDDVSSPK1/TXPK2/TEXPI1/RMCPI2

28、/NMIPI3/TO0/ADJPI4/INT1/CS1PI5/SCK1PC5PC4PC3PC2PC1PC0PB7/SI2PB6/SO2PB5/SCK2PB4/TO2PB3PB2PB1PB0PJ7PJ6PJ5PJ4PJ3PJ2PJ1PJ0PD7PD6PD5PD4PD3PD2PD1PD0PI6/SO1PI7/SI1PE0/INT0PE1/INT2PE2/PWM0PE3/PWM1PE4PE5PE6PE7PG0/TxDPG1/RxDPG2/EC0PG3/EC1PG4/EC2PG5/INT3PG6/INT4PG7/CINTAN0AN1AN2AN3PF0/AN4PF1/AN5PF2/AN6PF3/AN7A

29、VDDAVREFAVSSPF4/AN8123456789101112131415161718192031323334353637383940414243444546474849501009998979695949392919089888786858483828121222324252627282930807978777675747372717069686766656463626160595857565554535251TOP VIEWCXP740096 Terminal Function13811K1MUTEOBD3811K1 CONTROL23811K1CLKOBD3811K1 CONTRO

30、L33811K1DATAOBD3811K1 CONTROL4CDR/TAPEOCDR/TAPE INHIBIT5VCROVCR INHIBIT6ERR MUTEOERR MUTE7ERR MUTE OFFOERR MUTE OFF889057 AUDIOILC89057 CONTROL989057 EMPHAILC89057 CONTROL10SW SUMOSW SUMMING CONTROL11M32 SDINIDATA INPUT FROM MELODY321289057 SDINIDATA INPUT FROM LC8905713EPROM RESETOEPROM RESET148905

31、7 RESETOLC89057 RESET15M32 CSOMELODY32 CS16M32 SDOUTOMELODY32 CONTROL DATA1789057 CEOLC89057 CE1889057 SDOUTOCONTROL DATA1989057 SCLKOCONTROL CLOCK201837 RESETOCODEC RESETOSURR. BACK RELAY21RELAY-SB22SW MUTEOSW MUTE23RELAY F-BOFRONT B RELAYPinNo.Pin NameFunctionI/O1010AVR-1604/684 / AVC-1580PinNo.Pi

32、n NameFunctionI/O24RELAY F-AOFRONT A RELAY25RELAY SURROSURROUND RELAY26RELAY CNTOCENTER RELAY27RELAY H/POH/P RELAY28FUNC UPIENCODER INPUT(FUNCTION)29H/P DETECTIH/P DETECT33NC30FUNC DOWNIENCODER INPUT(FUNCTION)32CNT MUTEOCENTER MUTE31SB MUTEOSURR. BACK MUTE69FRONT MUTEOFRONT MUTE34SURR MUTEOSURROUND

33、MUTE35NC36NC37NC38FL DRV RESETOLC75721NE RESET39RELAY POWEROPOWER RELAY40RESETIRESET41GNDI42XTAL43EXTAL44FL DRV CEOLC75721NE CE45FL DRV DATAOLC75721NE DATA46FL DRV/2090 CLKOCONTROL CLOCK472090 DATAOBU2090F DATA48VOL DOWNIENCODER INPUT(VOLUME)49VOL UPIENCODER INPUT(VOLUME)50SEL DOWNIENCODER INPUT(SEL

34、ECT)51SEL UPIENCODER INPUT(SELECT)52AVSS53VREF54AVDD55NC56GND57STEP OPTIAREA SELECT58SET OPTIMODEL SELECT59GND60KEY IN3IKEY INPUT61KEY IN2IKEY INPUT62KEY IN1IKEY INPUT639K/10K STEPITUNER STEP SELECT64PROTECTIPROTECTION6589057 INTILC89057 INTERUPT66M32 SCLKOMELODY32 CLOCK671837 CEOCODEC CE68M32 RESET

35、OMELODY32 RESET70NC71NC72NC73NC74NC75NC76NC1111AVR-1604/684 / AVC-1580PinNo.Pin NameFunctionI/O77PWR DOWNIPOWER DOWN DETECT78RDS CLKOTDA7330 CONTROL CLOCK79RDS DATAOTDA7330 CONTROL DATA80NC81VIDEO MUTEOVIDEO MUTE82M32 INTREQI/OMELODY32 CONTROL83VIDEO SEL1OVIDEO SELECT184VIDEO SEL2OVIDEO SELECT285REM

36、OCONIREMOTE CONTROL SIGNAL INPUT86GND87GND88VSS89VDD90NC91NC92PLL DATAOPLL CONTROL93PLL CLKOPLL CONTROL94PLL DT INOPLL CONTROL95TU MUTEOTUNER MUTE96STEREOISTEREO DETECT97TUNEDITUNED DETECT98PLL CEOPLL CONTROL99NC100 NC1212AVR-1604/684 / AVC-15801234567891011121314151617181920212223246463626160595857

37、5655545352515049484746454443424125268079787776757473727170696867666527282930313233343536373839405.1ch Mode SW2 DVD5.1ch Mode SW15.1ch Mode SW2 DSPBASSBOOSTLOGICTNF2TNF1BNF11BNF21BNF12BNF22BBNF2OUT2BBNF1OUT1AGND8AGND7VCCAGND6VEEAGND5MUTECLDADGNDAGND4GOUTSRVINSRAGND3IN22IN21IN12IN11ROUT32ROUT31ROUT22R

38、OUT21ROUT12ROUT11AGND10GOUT2VIN2AGND9GOUT1VIN1IN31IN32IN41IN42IN51IN52IN61IN62IN71IN72IN81IN82INDVDSRINDVDSLINDVDCINDVDSWOUT2(+)OUT2(-)OUT1(+)OUT1(-)IN1DSPIN1MIXIN2DSPIN2MIXINDSPSRINDSPSLINDSPCINDSPSWAGND1GOUTSWVINSWAGND2GOUTCVINCOUTSWOUTCOUTSLOUTSRVINSLGOUTSLTREBLEBASSBD3811K1 (IC701)12345678910111

39、21314151617181920212244434241403938373635343332313029282726252423A15A14A13A12A11CEI/O0I/O1I/O2I/O3VccGNDI/O4I/O5I/O6I/O7WEA10A9A8A7NCA0A1A2OEUBLBI/O15I/O14I/O13I/O12GNDVccI/O11I/O10I/O9I/O8NCA3A4A5A6NCA0-A15CEOEWE64K x 16MEMORY ARRAYDECODERCOLUMN I/OCONTROLCIRCUITGNDVCCI/ODATACIRCUITI/O0-I/O7Lower B

40、yteI/O8-I/O15Upper ByteUBLBCEOEWELBUBPIN DESCRIPTIONPin NameAddress inputsSymbolA0-A15Data Inputs/OutputsI/O0-I/O15Chip Enable InputOutput Enable InputWrite Enable InputLower-byte Control (I/O0-I/O7)Upper-byte Control (I/O8-I/O15)No ConnectionNCPowerVCCGroundGNDIS61LV6416 (IC806)PIN DESCRIPTIONPin N

41、ameAddress InputsSymbolA0-A18Data Input/Outputs, Command InputsDQ0-DQ7Data Input/OutputsDQ8-DQ14Data Input/Output or Address InputDQ15A-1Chip EnableOutput EnableWrite EnableReset/Block Temporary UnprotectReady/Busy OutputRBByte/Word OrganizationBYTESupply VoltageVCCGroundVSSNo Connected InternallyNC

42、Dont Use as Internally ConnectedDUEGWRPA1A0A2EA3VSSA4GA5DQ0A6DQ8A7DQ1A17DQ9A18DQ2RBDQ10NCDQ3NCDQ11RPVCCWDQ4NCDQ12NCDQ5A8DQ13A9DQ6A10DQ14A11DQ7A12DQ15A-1A13VSSA14BYTEA15A16241312125363748M29W800TM29W800T19A0-A18WDQ0-DQ14M29W800ATE15GRPDQ15A-1BYTERBVCCVssM29W800AT (IC805)1313AVR-1604/684 / AVC-1580AD1

43、837 (IC808)AD1837 Terminal FunctionDescriptionPin No.Pin NameInput/Output1,39DVDDDigital Power Supply. Connect to digital 5V supply.2CLATCHILatch Input for Control Data33CINISerial Control Input4PD/RSTIPower-Down/Reset5,10,16,24,30,35AGNDAnalog Ground6,12,25,31NCNot connected7,13,26,32OUTLxODACx Lef

44、t Channel Output8,14,27,33NCNot connected9,15,28,34OUTRxODACx Right Channel Output11,19,29AVDDAnalog Power Supply. Connect to analog 5V supply.17FILTDFilter Capacitor Connection. Recommend 10F/100nF.18FILTRReference Filter Capacitor Connection. Recommended 10F/100nF.20ADCLNIADC Left Channel Negative

45、 Input21ADCLPIADC Left Channel Positive Input22ADCRNIADC Right Channel Negative Input23ADCRPIADC Right Channel Positive Input36M/SIADC Master/Slave Select37DLRCLKI/ODAC LR Clock38DBCLKI/ODAC Bit Clock40,52DGNDDigital Ground41-44DSDATAxIDACx Input Data (Left and Right Supply)45ABCLKI/OADC Bit Clock46

46、ALRCLKI/OADC LR Clock47MCLKIMaster Clock Input48ADVDDDigital Output Driver Power Supply49ASDATAOADC Serial Data Output50COUTOOutput for Control Data51CCLKIControl Clock Input for Control Data12345678910111213AGNDAVDDOUTR2NCOUTL2NCOUTR1NCOUTL1NCPD/RSTCINCLATCHDVDDNCOUTL3NCOUTR3NCOUTL4NCOUTR4AGNDDLRCL

47、KDBCLKDGND141516171819202122232425262728293031323334353637383952515049484746454443424140FILTDFILTRAGNDM/SAGNDAVDDADCLNADCLPADCRNADCRPAGNDAGNDDGNDCCLKCOUTASDATAODVDDMCLKALRCLKABCLKDSDATA4DSDATA3DSDATA2DSDATA1DVDDAVDDTOP VIEWOUTL1CONTROL PORTCLOCKFILTDFILTRADCLPADCLNADCRPADCRNDLRCLKDBCLKDSDATA1DSDATA2

48、DSDATA3DSDATA4MCLKASDATAABCLKALRCLKODVDDDVDDDVDDDGND AGND AGND AGND AGNDDGNDCINCLATCHCCLKCOUTDIGITALFILTERPD/RST M/S AVDD AVDDVOLUMEOUTR1OUTL2OUTR2OUTL3OUTR3OUTL4OUTR4AD1837DIGITALFILTERSERIAL DATAI/O PORTVOLUMEVOLUMEVOLUMEVOLUMEVOLUMEVOLUMEVOLUMEDIGITALFILTERDIGITALFILTERDIGITALFILTERDIGITALFILTERV

49、REF-ADC-ADC-DAC-DAC-DAC-DAC1414AVR-1604/684 / AVC-1580LC89057W Terminal FunctionFunctionPinNo.Pin NameLC89057W (IC807)1RXOUTOInput bi-phase select data output terminal2RX0I5TTL compatible digital data input terminal3RX1ICoaxial compatible amp built-in digital data input terminal4RX2I5TTL compatible

50、digital data input terminal5RX3I5TTL compatible digital data input terminal6DGNDDigital GND7DVDDDigital power8RX4I5TTL compatible digital data input terminal9RX5/VII5TTL compatible digital data/Validity flag input terminal for modulation10RX6/UII5TTL compatible digital data/User data input terminal