HarmanKardon-AVR630-avr-sm1维修电路原理图.pdf

《HarmanKardon-AVR630-avr-sm1维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《HarmanKardon-AVR630-avr-sm1维修电路原理图.pdf（126页珍藏版）》请在收音机爱好者资料库上搜索。

1、 harman/kardon AVR430 AVR430 7 X 65W 7.1 CHANNEL A/V RECEIVER AVR630 AVR630 7 X 75W 7.1 CHANNEL A/V RECEIVER SERVICE MANUAL CONTENTS ESD WARNING.2 LEAKAGE TESTING.3 AVR430 BASIC SPECIFICATIONS.4 AVR630 BASIC SPECIFICATIONS.5 FRONT PANEL CONTROLS.6 REAR PANEL CONNECTIONS.9 REMOTE CONTROL FUNCTIONS.12

2、 TROUBLESHOOTING GUIDE.16 PROCESSOR RESET16 SERVICE PROCEDURE.17 BULLETIN HK2004-04.20 TECH TIP HKTT2004-03.23 TECH TIP HKTT2003-01.27 BLOCK DIAGRAM.28 EXPLODED VIEW.29 EXPLODED VIEW PARTS LIST.30 AVR630 MECHANICAL PARTS LIST.32 AVR630 ELECTRICAL PARTS LIST.34 AVR430 MECHANICAL PARTS LIST.54 AVR430

3、ELECTRICAL PARTS LIST.56 SEMICONDUCTOR PINOUTS.75 PCB DRAWINGS.103 SCHEMATICS.114 WIRING DIAGRAM.125 PACKING.126 harman/kardon, Inc. 250 Crossways Park Dr. Woodbury, New York 11797 Rev1 7/2005 RadioFans.CN 收音机爱 好者资料库Eachprecautioninthismanualshouldbefollowedduringservicing.Components identified with

4、 the IEC symbolin the parts list are special significance to safety. When replacing a component identified with, use only the replacement parts designated, or parts with the same ratings or resistance, wattage, or voltage that are designated in theparts list in this manual. Leakage-current or resist

5、ance measurements must be made to determine that exposed parts are acceptablyinsulated from the supply circuit before retuming the product to the customer.Some semiconductor (solid state) devices can be damaged easily by static electricity. Such components commonly are calledElectrostatically Sensit

6、ive (ES) Devices. Examples of typical ES devices are integrated circuits and some field effect transistors andsemiconductor chip components.The following techniques should be used to help reduce the incidence of component damage caused by static electricity.1. Immediately before handling any semicon

7、ductor component or semiconductor-equipped assembly, drain off any electrostatic charge onyour body by touching a known earth ground. Alternatively, obtain and wear a commercially available discharging wrist strap device,which should be removed for potential shock reasons prior to applying power to

8、the unit under test.2. After removing an electrical assembly equipped with ES devices, place the assembly on a conductive surface such as aluminum foil, toprevent electrostatic charge build-up or exposure of the assembly.3. Use only a grounded-tip soldering iron to solder or unsolder ES devices.4. U

9、se only an anti-static solder removal device. Some solder removal devices not classified as anti-static can generate electrical chargessufficient to damage ES devices.5. Do not use freon-propelled chemicals. These can generate electrical change sufficient to damage ES devices.6. Do not remove a repl

10、acement ES device from its protective package until immediately before you are ready to install it. (Most replacementES devices are packaged with leads electrically shorted together by conductive foam, aluminum foil or comparable conductive material.)7. Immediately before removing the protective mat

11、erial from the leads of a replacement ES device, touch the protective material to thechassis or circuit assembly into which the device will be installed.Be sure no power is applied to the chassis or circuit, and observe all other safety precautions.8. Minimize bodily motions when handling unpackaged

12、 replacement ES devices. (Otherwise harmless motion such as the brushing togetheror your clothes fabric or the lifting of your foot from a carpeted floor can generate static electricity sufficient to damage an ES devices.CAUTION :AVR430/AVR630AVR430/AVR630 harman/kardon RadioFans.CN 收音机爱 好者资料库21. In

13、spect all lead dress to make certain thatleads are not pinched or that hardware is notlodged between the chassis and other metalpartsintheunit.2. Be sure that any protective devices such asnonmetallic control knobs, insulating fish-papers,cabinetbacks,adjustmentandcompartment covers or shields, isol

14、ationresistor-capacitynetworks,mechanicalinsulators, etc. Which were removed for theservicingareproperlyre-installed.Before returning the unit to the user, perform the following safety checks :3. Be sure that no shock hazard exists ; check for leakagecurrentusingSimpsonModel229LeakageTester,standard

15、equipment item No. 21641, RCA Model WT540A or usealternate method asfollows : Plug the power cord directlyInto a 120 volt AC receptacle (do not use an IsolationTransformer for this test). Using two clip leads, connect a1500ohms,10wattResistorparalleledbya0.15uFcapacitor,inserieswithallexposedmetalca

16、binetpartsandaknownearthground,suchas a water pipe or conduit. Use a VTVM or VOM with 1000 ohms per volt, or higher sensitivity to measure the AC voltage drop across theresistor. (See diagram) Move the resistor connection to each exposed metal part having a return path to the chassis (antenna, metal

17、,cabinet,screwheads,knobsandcontrolshafts,escutcheon,etc.)andmeasuretheACvoltagedropacrosstheresistor.(Thistestshouldbeperformedwiththe0.35voltRMSormoreisexcessiveandindicatesapotentialshockhazardwhichmustbecorrectedbeforereturningtheunittotheowner.AVR430/AVR630AVR430/AVR630 harman/kardon 3AVR 430 T

18、ECHNICAL SPECIFICATIONSAudio SectionStereo Mode Continuous Average Power (FTC)80 Watts per channel, 20Hz20kHz, 0.07% THD, both channels driven into 8 ohmsSeven-Channel Surround Modes Power per Individual ChannelFront L&R channels:65 Watts per channel 0.07% THD, 20Hz20kHz into 8 ohmsCenter channel:65

19、 Watts 0.07% THD, 20Hz20kHz into 8 ohmsSurround (L & R Side, L & R back) channels:65 Watts per channel 0.07% THD, 20Hz20kHz into 8 ohmsInput Sensitivity/ImpedanceLinear (High-Level)200mV/47k ohmsSignal-to-Noise Ratio (IHF-A)95dBSurround System Adjacent Channel SeparationPro Logic I/II 40dBDolby Digi

20、tal (AC-3)55dBDTS55dBFrequency Response 1W (+0dB, 3dB)10Hz 130kHzHigh Instantaneous Current Capability (HCC)40 AmpsTransient Intermodulation Distortion (TIM)UnmeasurableSlew Rate40V/secFM Tuner SectionFrequency Range87.5108.0MHzUsable SensitivityIHF 1.3V/13.2dBfSignal-to-Noise RatioMono/Stereo 70/68

21、dBDistortionMono/Stereo 0.2/0.3%Stereo Separation40dB 1kHzSelectivity400kHz, 70dBImage Rejection80dBIF Rejection90dBAM Tuner SectionFrequency Range5201720kHzSignal-to-Noise Ratio45dBUsable SensitivityLoop 500VDistortion1kHz, 50% Mod 0.8%Selectivity10kHz, 30dBVideo SectionTelevision FormatNTSCInput L

22、evel/Impedance1Vp-p/75 ohmsOutput Level/Impedance1Vp-p/75 ohmsVideo Frequency Response (Composite and S-Video)10Hz8MHz (3dB)Video Frequency Response (Component Video) 10Hz50MHz (3dB)GeneralPower RequirementAC 120V/60HzPower Consumption59W idle, 940W at rated power output (7 channels driven)Dimension

23、sProductShippingWidth17.3 inches (440mm)20.1 inches (510mm)Height6.5 inches (165mm)10 inches (254mm)Depth17.1 inches (435mm)22.2 inches (565mm)Weight39 lb (17.7kg)45 lb (20.4kg)Depth measurement includes knobs, buttons and terminal connections.Height measurement includes feet and chassis.All feature

24、s and specifications are subject to change without notice.Harman Kardon, Power for the Digital Revolution and Logic 7 are registered trademarks of Harman International Industries, Incorporated.is a trademark of Harman International Industries, Incorporated (patent no. 5,386,478).*Manufactured under

25、license from Dolby Laboratories.“Dolby,”“Pro Logic” and the Double-D symbol are trademarks of Dolby Laboratories.DTS, DTS Surround, DTS-ES and DTS Neo:6 are registered trademarks of Digital Theater Systems, Inc.VMAx is a registered trademark of Harman International Industries, Incorporated, and is a

26、n implementation of Cooper Bauck Transaural Stereo under patent license.A-BUS and A-BUS/Ready are registered trademarks of Leisure Tech Electronics Pty Ltd.Australia.TiVo is a registered trademark of TiVo, Inc.Replay TV is a registered trademark of SONICblue, Inc.TMTECHNICAL SPECIFICATIONS 51AVR430/

27、AVR630AVR430/AVR630 harman/kardon 4AVR 630 TECHNICAL SPECIFICATIONSAudio SectionStereo Mode Continuous Average Power (FTC)90 Watts per channel, 20Hz20kHz, 0.07% THD, both channels driven into 8 ohmsSeven-Channel Surround Modes Power per Individual ChannelFront L&R channels:75 Watts per channel 0.07%

28、 THD, 20Hz20kHz into 8 ohmsCenter channel:75 Watts 0.07% THD, 20Hz20kHz into 8 ohmsSurround (L & R Side, L & R back) channels:75 Watts per channel ?SELECT?UP(FOR?2?SEC)?-?SELECT?NTSC/PAL?BY?TOGGLE?SELECT?UP?KEY-?SET?NTSC?OR?PAL?BY?SET?KEY?micomVrefKey_in1Key_in2(77)(78)S200S201S20S203S204S205S206S20

29、7S208S211S212S213S214S215S216S217S218S219S209S220Standby?on/offSurr.?ModeSurr.?Down?Select?UpSurr.?Up?Select?DownTunning?DownTunning?UpAM/FM(BAND)Preset?DownPreset?UpSource?DownTune.?ModeSource?UpTest?ToneSelect?Up(change?adjustment)Speaker?AdjustmentChannel?AdjustmentDigital?SelectDelay?AdjustmentS

30、elect?Down(change)Select(SET?adjustment)120AVR430/AVR630AVR430/AVR630 harman/kardon 100uPD70F3033B?(V850/SB1)PORT?ASSIGNMENTAVR540/340PORT?ASSIGNMENTPINDESCRIPTIONRECEVIER?NAMEIN/OUTFUNCTION1P14/SO1/TXD0RS-232?TXTXCPU?FLASH?UPGRADE?UART?TX?PORT2P15/SCK1/ASCK0VPP_CONTROLOUTFlash?Upgrade?VPP?Control?P

31、in3P20/SI2/SDA1HDCD?GAINOUTHDCD?GAIN?(DSP)4P21/SO2THX?GAINOUTTHX?GAIN?(DSP)5P22/SCK2/SCL1FIP?RST?/?FL?STBOUTFIP?DRIVER?IC?RESET?/?FL?STROBE6P23/RXD1/SI3FIP?SI?/?FL?BLKSIFIP?DRIVER?IC?DATA?IN?/?FL?BLANK7P24/TXD1/SO3FIP?SO?/?FL?DISOFIP?DRIVER?IC?DATA?OUT?/?FL?DI8P25/ASCK1/SCK3FIP?CLK?/?FL?CLKSCKFIP?DR

32、IVER?IC?CLOCK?OUT?(NEC?CPU?MASTER)?/?FL?CLK9EVDDEVDDVDDVDD10EVSSEVSSVDDGND11P26/TI2/TO2ADC?RESETOUTADC?RESET(DSP)12P27/TI3/TO3CODEC_RESETOUTCODEC?RESET(DSP)13P30/TI00RMC_INCAPTUREREMOCON?IN14P31/TI01CODEC_CEOUTCODEC?CHIP?ENABLE(DSP)15P32/T110/S14RMC_MULTICAPTUREMULTI?ROOM?REMOCON16P33/TI11/SO4CODEC?

33、CLKOUTCODEC?CLK(DSP)17P34/TO0/SCK4CODEC_DATA_OUTOUTCODEC?DATA_OUT(DSP)18P35/TO1CODEC_DATA_ININCODEC?DSP_IN(DSP)19P36/TI4/TO4CODEC_INTINCODEC?INT(DSP)20P37/TI5/TO5FAN?OUTOUTFAN?OUT?CONTROL(PWM)21IC/VPPVPPIN?47K?Pull_Down,?FLASH?WRITE?7.8V22P100/RTP0/KR0DSP_RESETOUTCS49400?RESET(DSP)23P101/RTP1/KR1DSP

34、_HINBSYINCS49400?HINBSY(DSP)24P102/RTP2/KR2DSP_INTERQ_ABINCS49400?INTERQ_AB(DSP)25P103/RTP3/KR3DSP_CLK_ABOUTCS49400?CLK?AB26P104/RTP4/KR4DSP_CE_ABOUTCS49400?CE?AB27P105/RTP5/KR5DSP_DATA_OUT_ABOUTCS49400?DATA?OUT(DSP)28P106/RTP6/KR6DSP_DATA_IN_ABIN/OUTCS49400?DATA?IN(DSP)29P107/RTP7/KR7DSP_INTERQ_CIN

35、CS49400?INTERQ?C(DSP)30P110/WAITDSP_CLK_COUTCS49400?CLK?C(DSP)31P111DSP_CE_COUTCS49400?CE?C(DSP)32P112DSP_DATA_OUT_COUTCS49400?DATA?OUT?C(DSP)33P113DSP_DATA_IN_CIN/OUTCS49400?DATA?IN?C(DSP)34/RESETRESETINLOW?ACTIVE35XT1XT1INPull_Down36XT2XT2OUTOPEN37REGCREGCVDDVDD38X2Fx_OUTOUT20.00MHz?RESONATOR?39X1

36、Fx_ININ20.00MHz?RESONATOR?40VSSVSSVDDGND41VDDVDDVDD5V?42CLKOUTCLKOUTOUTOPEN?(STOP?MODE:?LOW)43P90/LBEN/WRLADC?MODE?0OUTADC?MODE?0(DSP)44P91/UBENADC?MODE?1OUTADC?MODE?1(DSP)45P92/RW/WRHHP?MUTEOUTHEADPHONE?MUTE46P93/DSTB/RDEEPROM?DATAOUTEEPROM?DATA47P94/ASTBEEPROM?CLKOUTEEPROM?CLK48P95/HLDAKVOL?IC?CEO

37、UTTC9481/TC9482/TC9459?CE49P96/HLDRQ4094?CEOUT4094?CHIP?ENABLEAVR430/AVR630AVR430/AVR630 harman/kardon 101uPD70F3033B?(V850/SB1)PORT?ASSIGNMENTAVR540/34050P404094?CLKOUT4094?CLKPINDESCRIPTIONRECEVIER?NAMEIN/OUTFUNCTION51P414094?DATAOUT4094?DATA?52P429482/59/81?DATAOUT9482/59/81?VOL?IC?DATA53P439482/

38、59/81?CLKOUT9482/59/81?VOL?IC?CLK54P44A?DATAOUT9273_1,?9273_3,?9162,?9162_2,?9163?DATA55P45A?CLKOUT9273_1,?9273_3,?9162,?9162_2,?9163?CLK56P469273?CE1OUT9273_1,?9162,?9163?CHIP?ENABLE57P479273_CE3OUT9273_3,?9162_2?CHIP?ENABLE58BVDDBVDDVDDVDD59BVSSBVSSVDDGND60P50T_MUTEOUTTUNER?MUTE?OUT61P51TUNEDINTUN

39、ED?CHECK?IN62P52T_CEOUTTUNER?PLL?IC(LC72131)?CHIP?ENABLE63P53T_CLOCKOUTTUNER?PLL?IC(LC72131)?CLOCK64P54T_DATA?IN/STEREOINTUNER?PLL?IC(LC72131)?DATA?IN?/?STEREO?CHECK65P55T_DATA?OUTOUTTUNER?PLL?IC(LC72131)?DATA?OUT66P56MMUTEOUTFRONT?SPEAKER?MUTE67P57CMUTEOUTCENTER?SPEAKER?MUTE68P60SMUTEOUTSURROUND?SP

40、AKER?MUTE69P61SBMUTEOUTSURR?BACK?SPEAKER?MUTE70P62SUBMUTEOUTSUB?WOOFER?MUTE71P63PMUTEOUTPOWER?MUTE72P64RECMUTEOUTREC?MUTE73P65MULTI?MUTEOUTMULTI?ROOM?MUTE74AVDDAVDDVDDVDD75AVSSAVSSVDDGND76AVREFAVREFVDDVDD(AD?KEY?PULL?UP?VDD)77P70/ANI0AD?KEY1ADINA/D?KEY?INPUT178P71/ANI1AD?KEY2ADINA/D?KEY?INPUT279P72/

41、ANI2FAN?IN1ADINTEMPERATURE?SENSOR?INPUT80P73/ANI3FAN?IN2ADINLEVEL?SENSOR?INPUT81P74/ANI4ENCODE1INVOLUME?ENCODER?INPUT?182P75/ANI5ENCODE2INVOLUME?ENCODER?INPUT?283P76/ANI6yc/comp?checkADINY/C,COMPO?jack?check?in?84P77/ANI7HP_ININHEADPHONE?INPUT85P80/ANI8STEPINTUNER?FREQ?OPTION86P81/ANI9NTSC/PAL?SELIN

42、NC87P82/ANI10PROTECTIONINPROTECTION?IN88P83/ANI11MODELINNC89P00/NMISTANDBYOUTMAIN?POWER?ON/OFF90P01/INTP0POWER?DOWNINTP0POWER?DOWN?CHECK?&?WAKE?UP?:?RISING?EDGE91P02/INTP1RDS_CLOCKINTP1RDS_CLOCK?(INTERRUPT)?:?FALLING?EDGE92P03/INTP2RDS_DATAINRDS_DATA93P04/INTP3COAX_INOUT?SELOUTCOAX?IN/OUT?SELECT94P0

43、5/INTP4/ADTRGSYNC?pluse?checkINSYNC?PLUSE?CHECK(OSD?IC?7PIN)95P06/INTP5/RTPTRGSYNC?CHECKINSYNC?CHECK(OSD?IC?29PIN)96P07/INTP6A19OUTA1997P10/SI0OSD?CEOUTOSD?CHIP?ENABLE98P11/SO0OSD?CLKOUTOSD?CLK99P12/SCK0OSD?DATAOUTOSD?DATA100P13/SI1/RXD0RS-232?RXRXCPU?FLASH?UPGRADE?UART?RX?PORTAVR430/AVR630AVR430/AV

44、R630 harman/kardon 102DSP BOARD (TOP VIEW)AVR430/AVR630AVR430/AVR630 harman/kardon 103DSP BOARD (BOTTOM VIEW)AVR430/AVR630AVR430/AVR630 harman/kardon 104PROCESSOR BOARD (TOP VIEW)AVR430/AVR630AVR430/AVR630 harman/kardon 105PROCESSOR BOARD (BOTTOM VIEW)AVR430/AVR630AVR430/AVR630 harman/kardon 106MAIN

45、 AMP BOARDAVR430/AVR630AVR430/AVR630 harman/kardon 107FRONT BOARD (BOTTOM VIEW)AVR430/AVR630AVR430/AVR630 harman/kardon 108FRONT BOARD (TOP VIEW)AVR430/AVR630AVR430/AVR630 harman/kardon 109VIDEO BOARD (BOTTOM VIEW)AVR430/AVR630AVR430/AVR630 harman/kardon 110VIDEO BOARD (TOP VIEW)AVR430/AVR630AVR430/

46、AVR630 harman/kardon 111SUPPLY BOARDAVR430/AVR630AVR430/AVR630 harman/kardon 112BACK SURROUND BOARDAVR430/AVR630AVR430/AVR630 harman/kardon 113114115116117118119120121122() AVR430/AVR630AVR430/AVR630 harman/kardon 123() AVR430/AVR630AVR430/AVR630 harman/kardon 124125 Ref# Part Number Description AVR

47、430 120v AVR630 120v AVR430 230v AVR630 230v 1-1 ZQC1101HAWH-2 Right Foam End X X X X 1-2 ZQC1102HAWH-9 Left Foam End X X X X ZKC1004HA00-5 Outer Carton 430-120v X ZKC1104HA00-A Outer Carton 630-120v X ZKD0104HA00-9 Outer Carton 430-230v X 2 ZKD0204HA00-3 Outer Carton 630-230v X 3 Plastic Bag X X X

48、X 4 H01-ATALF039ABK-A AM Antenna Loop X X X X H01-WAB01200203-9 FM Antenna 120v X X 5 H01-WAD01200303-3 FM Antenna 230v X X 6 H01-RYC1202HA00-5 Zone II Remote Control X X X X BE18A03 Remote Control 430-120v X BE18A04 Remote Control 630-120v X H01-RYD0101HA00-8 Remote Control 430-230v X 7 H01-RYD0201

49、HA00-6 Remote Control 630-230v X 8 Plastic Bag X X X X 9 Misc. card X X X X 10 ZKC1113HA00-9 Warranty Card X X X X 11 Safety Paper X X X X ZKC1001HB00-6 Owners Manual 430-120v X ZKC1101HA00-0 Owners Manual 630-120v X ZKD0101HA00-A Owners Manual 430-230v X 12 ZKD0201HA00-4 Owners Manual 630-230v X 13 1.5v AA Batteries X X X X Label-Barcode 430-120v X Label-Barcode 630-120v X Label-Barcode 430-230v X 14 Label-Barcode 630-230v X H01-WAUSA2103BK-1 Power Cord 120v X X 15 H01-WAD022000BK-2 Power Cord 230v X X 126