HarmanKardon-HKTS1-sub-sm维修电路原理图.pdf

《HarmanKardon-HKTS1-sub-sm维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《HarmanKardon-HKTS1-sub-sm维修电路原理图.pdf（18页珍藏版）》请在收音机爱好者资料库上搜索。

1、Rev A 11/99SUB-TS1TECHNICAL MANUALTECHNICAL MANUALAmplifier/SubwooferHarman Consumer Group250 Crossways Park DriveWoodbury, N.Y. 117971-800 422-8026 in the USAA Harman International CompanyRadioFans.CN 收音机爱 好者资料库2Amplifier/SubwooferHarman KardonSUB-TS1GENERAL SPECIFICATIONSHKTS-1 SystemFrequency Res

2、ponse35Hz 20kHz (6dB)SUB-TS1Amplifier . . 75 watts RMSBass. . . . . 8 woofer, bass-reflex enclosureDimensions (H x W x D)10? x 18? x 10? inches267 x 470 x 267mmWeight . . . 29.9 lbs/13.6 kgRefinements may be made on occasion to existing products without notice,but will always meet or exceed original

3、 specifications unless otherwise stated.TABLE OF CONTENTSCOVER.1GENERAL SPECIFICATIONS.2TABLE OF CONTENTS.2HKTS1 SPECIFICATIONS.3CONTROLS AND THEIR FUNCTION.5HKTS1 SPEAKER LEVEL CONNECTIONS.6HKTS1 LINE LEVEL CONNECTIONS .7SUB-TS1 TEST SET UP AND PROCEDURE.8SIMPLE TROUBLESHOOTING.9HKTS1 PACKING.10SUB

4、-TS1 EXPLODED VIEW.11SUB-TS1 PCB COMPONENT SIDE .12SUB-TS1 PCB SOLDER SIDE.13SUB-TS1 ELECTRICAL PARTS LIST.14SUB-TS1 INTEGRATED CIRCUIT DIAGRAMS .16SUB-TS1 POWER AMP SCHEMATIC DIAGRAM.17SUB-TS1 PRE-AMP SCHEMATIC DIAGRAM.18The SUB-TS1 is part of the HKTS1 systemRadioFans.CN 收音机爱 好者资料库HKTS1 SPECIFICAT

5、IONSLINE VOLTAGEYes/NoHi/Lo LineUnitNotesUS 120vac/60HzYes108-132VrmsNormal OperationEU 230vac/50-60HzYes207-264VrmsNormal operation, MOMSrequiredAsia 100vac/50HzYes90-110VrmsNormal OperationSpec.UnitLimitsConditionsNotesAmp SectionType (Class AB, D, other)ABABn/aSink required for Class ABLoad Imped

6、ance (speaker)4Ohmsn/aNominalZ-curve requiredRated Output Power80Watts801 input drivenTHD Rated Power0.08%0.322k filterTHD 1 Watt0.1%0.522k filterDC Offset10mV-DC20 Speaker OutputsDamping factor200DFn/aInput SensitivityInput Frequency50Hz50Nominal Freq.1 input drivenLine Input220mVrms2dBTo Rated Pow

7、er1 input drivenSpeaker/Hi Level Input4.26Vrms2dBTo Rated Power(-26dB below Line In).1input drivenSignal to NoiseSNR-A-Weighted100dBA90rel. to rated powerA-Weighting filterSNR-unweighted80dBr60rel. to rated power22k filterSNR 1W-unweighted60dBr55rel. to 1W Output22k filterResidual Noise Floor1.5mVrm

8、s2.5Volume max, using RMS reading DMM/VOM (or A/P)Residual Noise Floor1mVrms(max)2Volume max, w/ A/P Swept Bandpass Measurement(Line freq.+ harmonics)Input ImpedanceLine Input15Kohmsn/aNominalSpeaker/Hi Level Input4.7Kohmsn/aNominalFiltersLow Pass (fixed orvariable)fixedLow Pass filter (point orrang

9、e)135Hz2dB-3dB PointSlope24dB/Octaven/aQ1.8Dampingn/a2 cascaded 2nd orderfilters of 1.8 &0.7 QSubsonic filter (HPF)31Hz2dB-3dB PointSlope12dB/Octaven/aQ1.4Dampingn/a3Amplifier/SubwooferHarman KardonSUB-TS1Signal Sensing (ATO)Auto-Turn-On (yes/no)yesfunctionalATO Input Frequency50HzfunctionalATO Leve

10、l2mVfunctional2mV50Hz into Line Inputw/ 1 ch. drivenATO Bandwidth5kHzfunctionalATO-LPF for noiseimmunityDV1 measured 7mV 5kHz. 2mV 1kHzATO Turn-on time5msfunctionalAmp connected and AC on, then input signal appliedAuto Mute/ Turn-OFF Time20minutesfunctionalT before muting, aftersignal is removedPowe

11、r on Delay time3sec.functionalAC Power AppliedTransients/PopsATO Transient5mV-peak10 Speaker OutputsTurn-on Transient50mV-peak100 Speaker OutputsAC Line cycled from OFF toONTurn-off Transient50mV-peak100 Speaker OutputsAC Line cycled from ON toOFFEfficiencyStand-by Input Power10Wattsn/a nom. line vo

12、ltagePower Cons.rated power160Wattsn/a nom. line voltageProtectionShort Circuit ProtectionYesfunctionalDirect short at outputThermal Protection65 deg.Cfunctional1/8 max unclippedPowerDV1:Plate=50deg.Cmax.Tab=90deg.C max.T-on=65deg.CDC Offset ProtectionyesfunctionalDC present at SpeakerOut leadsRelay

13、 or crowbar (fordriver/fire protection)Line Fuse Rating2Amps2Type-T or Slo BloExternal fuse with UL/SEMKOrated holder4Amplifier/SubwooferHarman KardonSUB-TS11. Speaker Level Outputs - Connect the Left, Centerand Right speakers to these connectors.2. Speaker Level Inputs - These High Level Inputs are

14、for receivers that do not have line-level “pre-amp out”or “subwoofer out” jacks. When a pair of main orsatellite speakers are attached to the OUTPUTterminals, they are driven the full range of frequenciesas generated by the music source (receiver, amplifier,etc.)3. Line Level Input - These left and

15、right Line LevelInputs are normally used when the receiver/ processorhas line-level “pre-amp out ” or “subwoofer out” jacks.4. Auto/On Switch - This switch allows you to set theMode of the Amplifier. Turn the switch to Auto tocause it to Auto-matically turn on when it receives asignal and Auto-matic

16、ally turn off after twenty minuteswithout a signal. If this switch is left “On”, thesubwoofer will always be ON when the power switchis turned On, regardless of input signal.5. Subwoofer Level - This knob controls the volumelevel of the SUB125.6. LED - Red & Green. The LEDs indicate the Modestatus t

17、hat the subwoofer is in. When the SUB125 isturned OFF neither LED will be lit.The Green LEDwill light when the SUB125 is ON and receiving asignal. The Red LED will light when the amplifier hasnot received a signal for twenty minutes. Thesubwoofer will turn on when your receiver/amplifierbegins playi

18、ng again.7. Power Switch - This the master power switch. Use it(in Off mode) to disconnect power to the amplifier.8. Fuse - Use only same type of fuses. For the U.S.120V version use only a 2A 250V fuse. For theEuropean 230V version use only a 1A fuse.9. AC Cord5Amplifier/SubwooferHarman KardonSUB-TS

19、1AC 120V,60Hz160WPOWERRLMINMAXFUSESTAND BYONFUSE2A/250VTYPE TLINE LEVELINPUTSUBWOOFERLEVELSPEAKERLEVELOUTPUTSPEAKERLEVELINPUTLLCCRRONAUTOSUB-TS1123456789CONTROLS AND THEIR FUNCTION6Amplifier/SubwooferHarman KardonSUB-TS1HKTS1 SPEAKER LEVEL CONNECTIONSSPEAKER LEVELOUTPUTSPEAKER LEVELINPUTLLCCRRSUB-TS

20、1ReceiverLeft FrontLeft SurroundRight FrontRight SurroundCenterLeft FrontLeft SurroundRight SurroundRight FrontCenter7Amplifier/SubwooferHarman KardonSUB-TS1HKTS1 LINE LEVEL CONNECTIONSSUB-TS1ReceiverLeft FrontSubwooferOutLeft SurroundRight FrontRight SurroundCenterLeft FrontLeft SurroundRight Surro

21、undRight FrontCenterRLRLLINE LEVELINPUT8Amplifier/SubwooferHarman KardonSUB-TS1SUB-TS1 TEST SET UP AND PROCEDUREOUTPUT FROMAMPLIFIERFROMPRE AMPSPEAKERAMPLIFIERCD PLAYERPRE AMPAC VOLT METER ( 6V )SPEAKERUNDER TESTLINELEVELSPEAKER LEVELRLMINMAXLINE LEVELINPUTSUBWOOFERLEVELSPEAKERLEVELOUTPUTSPEAKERLEVE

22、LINPUTLLCCRRONAUTOGeneral FunctionUUT = Unit Under Test1.Connect both right and left line level inputs (RCA) tosignal generator and UUT. Use Y-cable if necessaryfrom mono source. VOLUME control should be fullcounterclockwise.2.Turn on generator, adjust to 200mV, 50 Hz.3.Plug in UUT; red LED should b

23、e ON. Turn VOLUMEcontrol full clockwise.4.LED should turn Green; immediate bass response shouldbe heard and felt from port tube opening.5.Turn off generator, turn VOLUME control fullycounterclockwise, disconnect RCA cables.6.Connect one pair of speaker cables to both high levelinput terminals on UUT

24、. Cables should be connected toan integrated amplifier fed by the signal generator.7.Turn on generator and adjust so that speaker level output is 3.0V, 50 Hz. Turn VOLUME control full clockwise.8.Green LED should light, immediate bass response should be heard and felt from the port tube opening.Swee

25、p Function1.Follow steps 1-4 above, using a sweep generator as a signal source.2.Sweep generator from 20Hz to 300Hz. Listen to the cabinet and drivers for any rattles, clicks, buzzes or anyother noises. If any unusual noises are heard, remove driver and test.Driver Function1.Remove driver from cabin

26、et; detach + and - wire clips.2.Check DC resistance of driver; it should be 3.3 ohms.3.Connect a pair of speaker cables to driver terminals. Cables should be connected to an integrated amplifier fed bya signal generator. Turn on generator and adjust so that speaker level output is 5.0V.4. Sweep gene

27、rator from 20Hz to 1kHz. Listen to driver for any rubbing, buzzing, or other unusual noises.9Amplifier/SubwooferHarman KardonSUB-TS1SIMPLE TROUBLESHOOTINGIf there is no sound from any of thespeakers, check the following: Receiver/amplifier is on and a source is playing. Powered subwoofer is plugged

28、in and is either in the “On”or “Auto” position. Check all wires and connections between receiver/amplifier and speakers. Make sure all wires are connected.Make sure none of the speaker wires are frayed, cut orpunctured. Review proper operation of your receiver/amplifier. If thereis no sound coming f

29、rom one speaker, check the following: Check the “Balance” control on your receiver/amplifier.If the system plays at low volumes butshuts off as volume is increased, check thefollowing: Check all wires and con-nections between receiver/amplifier and speakers. Make sure all wires are connected.Make su

30、re none of the speaker wires are frayed, cut orpunctured. If more than one pair of main speakers is being used,check the minimum impedance requirements of yourreceiver/amplifier.If there is low bass output, check thefollowing: Make sure the connections to the left and right “SpeakerInputs” have the

31、correct polarity (+ and ). Powered subwoofer is plugged in and is either in the “On”or “Auto” position.If there is no sound from the surroundspeakers, check the following: Check all wires and connections between receiver/amplifier and speakers. Make sure all wires are connected.Make sure none of the

32、 speaker wires are frayed, cut orpunctured. Review proper operation of your receiver/amplifier and itssurround sound features. Receiver mode must be in Dolby Pro logic, Dolby Digital,or any other mode that creates a surround-sound effect.Even under normal operation, when viewing movies andtelevision

33、, surround sound is not present at all times at ahigh volume - only when the program has chosen to sendinformation there.10Amplifier/SubwooferHarman KardonSUB-TS1HKTS1 PACKINGHKTS1OWNERSMANUAL#AI5058FEET/PADS#WI5162 (10)WARRANTYCARD#AT5073PLASTICBAGOUTER CARTON#WB5452SUBWOOFERFOAM SET#WB5078SATELLIT

34、EFOAM SET#WP5071SUB-TS1SUBWOOFEROPTIONAL SAT-TS1 SPEAKER STANDS: FSTS1WALL HOOKS#WI0408 (5)MURAL STANDS#WI0409 (5)HKTS1HKTS1SATELLITESPEAKERSSAT-TS1 (5)#HKTS1/SATACCESSORY WIRESPART NUMBERSAL5010SAL063-1SAL5009DESCRIPTIONRight, Left &Center cables (1 pack, 3 pairs)High level input cables (3 pack, 1p

35、air each)Surround cables (2 pack, 1 pair each)11Amplifier/SubwooferHarman KardonSUB-TS1SUB-TS1 EXPLODED VIEW25274125262424212223171414811101236235353231313235938282816292418181329281113112838654283828282828153829371920424443344039VIEWINGCABINETBOTTOMHGFEDCBAABCLMKJIFGHDELMIJKDESCRIPTIONPART NUMBER#3

36、PLASTIC KNOB700KB800#4POWER SWITCH180PBR12C11S#5FUSE HOLDER15552001#6POWER CORD 120V152U602015#8POWER TRANSFORMER150E8604104#11AMPLIFIER PLATE640RP125-4#15SLIDE SWITCH AUTO-ON180SMS50126#21FULLY LOADED MAIN PCB1010SUB125A#22MICAINSULATOR1933M2520#34HARMAN KARDON LOGOSZ5162#36PORT TUBE700PT125#408 WO

37、OFER20MF10DJ-DW04#41SPEAKER TERMINALS1742-CJ9030#42AMPLIFIER ASSEMBLY106HKTS1-1#43GRILLEXC085000#44GRILLE CUPS (RETAINERS)WI5192Ref.No.SUB-TS1Exploded ViewCABINETNOT FOR SALESUB-TS1 PAGE 11 - 1 of 2SUB-TS1 PAGE 11 - 2 of 212Amplifier/SubwooferHarman KardonSUB-TS1SUB-TS1 PCB COMPONENT SIDENETNETNETNE

38、TNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETPOLYGONSOLIDPOLYGONSOLIDNETNETPOLYGONSOLIDNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETPOLYGONSOLI

39、DPOLYGONSOLIDNETNETNETNETNETNETNETNETPOLYGONSOLIDPOLYGONSOLIDNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETPOLYGONSOLIDNETNETNETNETPOLYGONSOLIDNETNETNETNETNETNETPOLYGONSOLIDNETNETNETNETNETNETNETNETPOLYGONSOLIDNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNE

40、TNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETNETPOLYGONSOLIDPOLYG

41、ONSOLIDPOLYGONSOLIDPOLYGONSOLIDNETNETNETNETPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYG

42、ONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYG

43、ONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYG

44、ONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDNETNETPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLI

45、DPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLI

46、DPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLI

47、DPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLI

48、DPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPOLYGONSOLIDPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKCOMPONENTPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKCOMPONENTPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKPIN_P

49、ADSTACKCOMPONENTPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKCOMPONENTCOMPONENTPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKCOMPONENTCOMPONENTPIN_PADSTACKPIN_PADSTACKCOMPONENTPIN_PADSTACKPIN_PADSTACKCOMPONENTPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKCOMPONENTPIN_PADSTACKPIN_PADSTACKCOMPO

50、NENTPIN_PADSTACKPIN_PADSTACKCOMPONENTPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKCOMPONENTPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKCOMPONENTPIN_PADSTACKPIN_PADSTACKCOMPONENTPIN_PADSTACKPIN_PADSTACKCOMPONENTPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKPIN_PADSTACKCOMPONENTPIN_PADSTACKPIN_PADSTACKPI