Hitachi-HTADD3E-avr-sm 维修电路原理图.pdf

《Hitachi-HTADD3E-avr-sm 维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《Hitachi-HTADD3E-avr-sm 维修电路原理图.pdf（34页珍藏版）》请在收音机爱好者资料库上搜索。

1、CAUTION:Beforeservicing this chassis, itisimportantthat the servicetechnician read the“SafetyPrecautions”and“ProductSafetyNotices”inthisservicemanual.ATTENTION:Avantdeffectuerlentretienduchassis,letechniciendoitlirelesPrcautionsdescuritetlesNoticesdescuritduproduitprsentsdansleprsentmanuel.VORSICHT:

2、VorffnendesGehuseshatderService-IngenieurdieSicherheitshinweise“undHinweisezurProduktsicherheit“indiesemWartungshandbuchzulesen.SERVICE MANUALMANUEL DENTRETIENWARTUNGSHANDBUCHDatacontainedwithinthisServicemanualissubjecttoalterationforimprovement.Les donnes fournies dans le prsentmanueldentretienpeu

3、ventfairelobjetdemodificationsenvuedeperfectionnerleproduit.DieindiesemWartungshandbuchenthaltenenSpezifikationenknnensichzwecksVerbesserungenndern.September 2000AV SURROUND SYSTEMHTADD3EHTADD3EBSHTADD3WHTADD3WUNHTADD3WAUSM0103 SPECIFICATIONS AND PARTS ARE SUBJECT TO CHANGE FOR IMPROVEMENTCONTENTSSP

4、ECIFICATIONS.3SERVICE POINTS.4WIRING DIAGRAM.9PRINTED WIRING BOARD.10SCHEMATIC DIAGRAM.25EXPLODED VIEW.43REPLACEMENT PARTS LIST.47ADJUSTMENT.8BLOCK DIAGRAM.23RadioFans.CN 收音机爱 好者资料库ENGLISHSAFETY PRECAUTIONS WARNING: The following precautions must be observed.ALL PRODUCTS Before any service is perfor

5、med on the chassis an isolation transformer should be inserted between the power line and the product. 1. When replacing the chassis in the cabinet, ensure all the protective devices are put back in place. 2. When service is required, observe the original lead dressing. Extra precaution should be ta

6、ken to ensure correct lead dressing in any high voltage circuitry area. 3. Many electrical and mechanical parts in HITACHI products have special safety related characteristics. These characteristics are often not evident from visual inspection, nor can the protection afforded by them necessarily be

7、obtained by using replacement components rated for higher voltage, wattage, etc. Replacement parts which have these special safety characteristics are identified by marking with a ? on the schematics and the replacement parts list.The use of a substitute replacement component that does not have the

8、same safety characteristics as the HITACHI recommended replacement one, shown in the parts list, may create electrical shock, fire, X-radiation, or other hazards. 4. Always replace original spacers and maintain lead lengths. Furthermore, where a short circuit has occurred, replace those components t

9、hat indicate evidence of overheating. 5. Insulation resistance should not be less than 2M ohms at 500V DC between the main poles and any accessible metal parts. 6. No flashover or breakdown should occur during the dielectric strength test, applying 3kV AC or 4.25kV DC for two seconds between the mai

10、n poles and accessible metal parts. 7. Before returning a serviced product to the customer, the service technician must thoroughly test the unit to be certain that it is completely safe to operate without danger of electrical shock. The service technician must make sure that no protective device bui

11、lt into the instrument by the manufacturer has become defective, or inadvertently damaged during servicing. CE MARK 1. HITACHI products may contain the CE mark on the rating plate indicating that the product contains parts that have been specifically approved to provide electromagnetic compatibility

12、 to designated levels. 2. When replacing any part in this product, please use only the correct part itemised in the parts list to ensure this standard is maintained, and take care to replace lead dressing to its original state, as this can have a bearing on the electromagnetic radiation/immunity. PI

13、CTURE TUBE 1. The line output stage can develop voltages in excess of 25kV; if the E.H.T. cap is required to be removed, discharge the anode to chassis via a high value resistor, prior to its removal from the picture tube. 2. High voltage should always be kept at the rated value of the chassis and n

14、o higher. Operating at higher voltages may cause a failure of the picture tube or high voltage supply, and also, under certain circumstances could produce X-radiation levels moderately in excess of design levels. The high voltage must not, under any circumstances, exceed 29kV on the chassis (except

15、for projection Televisions). 3. The primary source of X-radiation in the product is the picture tube. The picture tube utilised for the above mentioned function in this chassis is specially constructed to limit X-radiation. For continued X-radiation protection, replace tube with the same type as the

16、 original HITACHI approved type 4. Keep the picture tube away from the body while handling. Do not install, remove, or handle the picture tube in any manner unless shatterproof goggles are worn. People not so equipped should be kept away while picture tubes are handled LASERS If the product contains

17、 a laser avoid direct exposure to the beam when the cover is open or when interlocks are defeated or have failed. - 1 -RadioFans.CN 收音机爱 好者资料库HTA-DD3? Checking method? ?!?#? ?$%?INSTRUMENT(Exposed part)Insulation tester (DC 500V)?&? (?#?)?*?#?+?_? ,?HTA-DD3?-?SPECIFICATIONS?AUDIO SECTION(Poweramplif

18、ier)For (E, EBS)For (W, WUN, WAU)Rated output:? ? !#?$%?%? !#?&?(? ? !#?SINUS power:?)?)? ?$%?%?)?&?(?)?)? ?Output terminals:?*?*?%$%?%?&?(?(Analog)LINE inputInput sensitivity / input impedance:?+?,-?Frequency response:?.?/0?(*S/Nratio:)0?(*?!?1?%?2?%(?Total harmonic distortion:?PHONO input-REC OUTI

19、nput sensitivity / input impedance:?.?+?,-?RIAA deviation:3?(*?S/Nratio:-,?(*?!?1?%?2?%(?.?+?4?Total harmonic distortion:?0?0+?Rated output / Maximum output:?.?+?-+VIDEO SECTION(Composite)Input/output level and impedance:?+414?-.?Frequency response:.?5?/0?(*(S-Video)Input/output level and impedance:

20、67?+414?$7?+414Frequency response:.?5?/0?(*(Component)Input/output level and impedance:67?+414?$?7?-?+414?$?7?-?+414Frequency response:.?5?/0?(*TUNER SECTIONFM?%?8+?9?-.?(*?7? AMReceiving range:?-?.?5?5?.?5?%4?.?)?%4? ? *&?.?)?%4?.?-?%4?:;?:?Usablesensitivity:?8+?-?(*?08+?0?.?(*;?(*?!?1?%?2?%(?&? =

21、-.?(*?!?1?%?2?%(?Total harmonic distortion:5;?&? = ?,? GENERALPower supply:$?0?+?.? ? *&?$?-+?,?+?.?:;?:?Power consumption:?&?9?(?(%?7?.?Maximum external dimensions:,0,?,?0?Weight:?2 REMOTE CONTROL UNIT (RB-DD1S)Batteries:=?A?4%?9?%?%?External dimensions:.,?-?-?Weight:?2?BC(?2?9?%?%? Accessory suppl

22、ied:4%?9?2?B?=%?%?B?C?=*1?&?=?A?9?%?%?5?C?4?9?%?9?9?(?5?(?9?%?9D?4?4?%?4?E%?%?4%B?B9?9?(?(%?2?9?%?F%B?B?9?2%?B%?HTA-DD3?.?121Top coverx 2x 2x 4Rear Plate3x 284x 121x 5Fig.1Fig.2SERVICE POINTS1. Removal of Top Cover? /?1? /?.?2?2. Removal of Rear Plate? /?0?3?4? /?$?-?,?HTA-DD3?$?6Claws (PWB Support)

23、56Flat Cable78x 4x 1x 120 x 3x 4Z19EABCDFHIJKNLMOPQMain PWBDSP PWBPush RivetHolder (Back)Holder (Front)Audio PWBS Video PWBComposit PWBComponent PWBRelay PWBTunerPWBSHIELDPLATEDSP PWB19 x 1for E, E(BS)Fig.43. Removal of Tuner & DSP PWB board? /?/?)?1? ?2?)?,? ?Z?&?3,? /?+? 4?&?2?5(?3,?A?B?C?D?E?2?F?

24、3,?Removal of Audio PWB board? 4?6?3,?.?H?I?J?2?K?3,?Removal of S Video/Composit PWB board? 4?(?7?3,?L?2?M?3,?Removal of Components PWB board? 4?3,?N?3,?Removal of Relay PWB board? 4?/?3,? ? -? ? O? P? 2? Q? ?3,?4. Removal of Transformer? /?.?5? ?3,?Removal of Power PWB board? /?6?,? /?3,?-?3,? ?Rem

25、oval of Main PWB board? 5?1?18?3,?,? /?.?7?9?#? /?-?,?#? /?8?#?Removal of Heat-Sink? 9?,?9?#?1?$ ?Fig.3HTA-DD3?:?1212Nut x 1Inner PanelNut x 21513x 1x 114x 2x 2x 11910 x 4x 211 x 1Bottom ChassisBass/Treble KnobMaster Vol.Front PanelFig.65. Removal of Front Panel? 9?,?.?!? ?/?7?2?,?;&?1?6. Removal of

26、 Inner Panel, Power Switch, Phone Jack & FL board.? /?1?$ ?#? /?$?-?18? /?%? /?&?9?1?!)?:?,7?=$?!)?6?7/8?:A?,?BC&+ ?6?7/9?D&?D?9?9?C?1?E?6?/?1?F?/?5?G0?)?&.%A-%?7?)?:%?,?$?)?,?5?1?E?(?B?8?7 6?7 1?+;+,(0=?$%?)?-#-?=?.?$%?)? %0?%?)?:?%#G?%=?$?3;3HB;36H0=?$%?)?-#-?=?.?$%?)? %0?%?)?:?%#G?%=?$6?+;+,($?)?

27、%?G#?G?)? :?)?:?%#G?%=?$?3;3HB;36H$?)?%?G#?G?)? :?)?:?%#G?%=?$A D J U S T M E N T S?G?HTA-DD3WIRING DIAGRAMFL DISPLAY UNITCN2BCN1BCN1ACN1BCN2AW17AW15AW16AW18AW14AW19AW13ACN204CN204ACN201ACN14CN12TUNER/VOL UNITAUDIO IN. UNITDIGITAL IN. UNITVIDEO(C)IN. UNITVIDEO(S)IN. UNITMAIN UNITCN22PG22PG13CN205THE

28、RMALUNITVIDEO(COMP.)IN. UNITSPEAKER OUT. UNITCN206PG14CN201DSP UNITPG205PG206W19BW18BW17BW16BW15BW14BW13BPOWER T.(2nd) UNITW5BW7BW9BW6BW8BW10BW4BPOWER T.(Pry.) UNITPOWER CONTROL UNITPG3CN13CN3PHONES/SPEAKER SW UNITPOWER SW UNIT*PG15PG12W3AW1AW1BW2BW6AW7AW10A W9AW8AW3BW2APOWER CORDPG25*VOLTAGE SELECT

29、OR(for W, WUN, WAU)REMARKS * SHOULD BE FOLLOW PWB ASSY.*CN15HTA-DD3PRINTED WIRING BOARD- 10 -Soldering SideMAIN PWBHTA-DD3- 11 -Component SideMAIN PWBHTA-DD3Soldering SideTuner PWB- 12 -HTA-DD3Component SideTuner PWB- 13 -HTA-DD3Soldering SideComponent SideAudio PWB- 14 -HTA-DD3Relay PWBSoldering Si

30、deComponent Side- 15 -HTA-DD3Digital PWBPower PWBComponent SideFL PWB- 16 -HTA-DD3Soldering SideFL PWBPower PWBDigital PWBHTA-DD3Component SideSoldering SideComponent PWBHTA-DD3Component SideSoldering SideDSP PWBHTA-DD3S-Video PWBComposit PWBPT2 PWBSoldering SideHTA-DD3S-Video PWBComposit PWBPT2 PWB

31、Component SideHTA-DD3Soldering SideComponent SidePhone PWBPT1 PWBP-SW PWBPhone PWBPT1 PWBP-SW PWB?-?HTA-DD3BLOCK DIAGRAMFR2. : ANALOG SIGNAL, : DIGITAL SIGNAL, : VIDEO SIGNAL0dB0dB+6dB12dB0dB+6dB+6dB+6dB+6dB0dB0dB+6dB+4dB+4dB-6dB0dB0dB0dB+4.5dB+10.5dB+10dB+10dB+28dB+28dB+28dB+28dB+14dB+14dB0dB0dB+14

32、dB+21dB0dB0dBREMARKS1. THIS DRAWING IS THE HTA-DD3 CIRCUIT BLOCK (LEVEL) DIAGRAM.3. : u-COM CONTROL SIGNAL+28dBANALOGPHONORIAAFUNCTION SWIC102BA4558BFH. P. FBA15218TC9273F-007CDDVD/VDPTV/DBSVCRMD/TAPE200mV/47k200mV50mV200mVBA4558BFBA15218BA15218 ADC +INBFA/DIC202ERR MUTESR BA15218CODEC AK4527D/ASLC

33、BA15218FR BA15218SWFLADC -INTAPE RACKVCR RECLA1838TUNER BLOCKLC7272ONSPFRXSDASDB-SDDBU4066BCNJM2267ROMDVD/VDPBA15218BA15218IC95196KHz CONTNJM2068x3ELE. VOLCH. TRIMNJM2068x3DTS SEL (CD/DVD)F GAIN SWPO. AMPMIX. AMPMIX. AMPMIX. AMPBA15218SWSWSRSLSLSRSTEREO6CH EXT. IN SEL.STEREO (WHEN SW)CCFLBFLC7536x3B

34、FBFBFBFBFPO. AMPPO. AMPPO. AMPTONE CONT.1VTONE CONT.MAIN AMPIC50IC4024. 5V200mV/22kMAIN AMPMAIN AMPMAIN AMPMAIN AMPVOL. MUTESUBWOOFER MUTEHP RELAYSP. RELAY2VHONES RchHONES LchFRONT RchCENTERSUBWOOFERPRE OUTFRONT LchSURROUND RchSURROUND LchSURROUND RchSUBWOOFERSURROUND LchCENTERCENTERFRONT Rch-BFRONT

35、 Rch-AFRONT Lch-BFRONT RchFRONT Lch6ch EXT. INFRONT Lch-ADVDTV/DBSCOMPONENT VIDEOBU4066BCVCR RECMONITOR OUTPUTCOMPONENT VIDEO FUNCTIONMONITOR OUTPUTBA15218PO.AMPPO.AMPPO.AMPFLFRNJM2267MIX. AMPL. P. FTV/DBSVCRIC611S. VIDEOS. VIDEO FUNCTIONIC201VIDEODVD/VDPVCR RECTV/DBSMONITOR OUTPUTVCRVIDEO FUNCTIONO

36、PT CDOPT DVDOPT TVTC74HCU04AF TC74HC151FDIGITAL INPUT SEL.DIGITAL INPUTIC92RDS(E, EBS)IC203DSP(ZR38650)?.?HTA-DD3HTA-DD3AA1135113231286OUTLET P.W.B.5AM LOOP ANTENNA 8TRemote ControlEDISON PLUG ADAPTERFM ANT4838404739FL DISP PWB13151246423741233621362022BB1011304519449161827271829BBAASHIELD PLATE(E/E

37、BS)(W/WUN)VOLTAGE SELECTOR(W/WUN)243349432515034825RELAY P.W.B.2431726(E, EBS)43COMPONENT P.W.B.S-VIDEO P.W.B.COMPOSIT P.W.B.AUDIO P.W.B.DSP P.W.B.TUNER P.W.B.752P-SW1 P.W.B.14MAIN P.W.B.EXPLODED VIEW (Cabinet Chassis) Nos. are reference Nos. of part listI?.-?II?.?I THE UPDATED PARTS LISTFOR THIS MO

38、DEL IS AVAILABLE ON ESTA Hitachi, Ltd. Tokyo, Japan International Sales Division THE HITACHI ATAGO BUILDING, No. 15 12 Nishi Shinbashi, 2 Chome, Minato Ku, Tokyo 105-8430, Japan. Tel: 03 35022111 HITACHI EUROPE LTD, Whitebrook Park Lower Cookham Road Maidenhead Berkshire SL6 8YA UNITED KINGDOM Tel:

39、01628 643000 Fax: 01628 643400 Email: consumer-servicehitachi- HITACHI EUROPE S.A. 364 Kifissias Ave. & 1, Delfon Str. 152 33 Chalandri Athens GREECE Tel: 1-6837200 Fax: 1-6835964 Email: service.hellashitachi- HITACHI EUROPE GmbH Munich Office Dornacher Strasse 3 D-85622 Feldkirchen bei Mnchen GERMA

40、NY Tel: +49-89-991 80-0 Fax: +49-89-991 80-224 Hotline: +49-180-551 25 51 (12ct/min) Email: HSE-DUS.servicehitachi- HITACHI EUROPE S.A. Gran Via Carlos III, 101-1 08028 Barcelona SPAIN Tel: 93 409 2550 Fax: 93 491 3513 Email: atencion.clientehitachi- HITACHI EUROPE srl Via Tommaso Gulli N.39, 20147

41、Milano, Italia ITALY Tel: +39 02 487861 Tel: +39 02 38073415 Servizio Clienti Fax: +39 02 48786381/2 Email: customerservice.italyhitachi- HITACHI Europe AB Box 77 S-164 94 Kista SWEDEN Tel: +46 (0) 8 562 711 00 Fax: +46 (0) 8 562 711 13 Email: csgswehitachi- HITACHI EUROPE S.A.S Lyon Office B.P. 45,

42、 69671 BRON CEDEX FRANCE Tel: 04 72 14 29 70 Fax: 04 72 14 29 99 Email: france.consommateurhitachi- HITACHI EUROPE LTD (Norway) AB STRANDVEIEN 18 1366 Lysaker NORWAY Tel: 67 5190 30 Fax: 67 5190 32 Email: csgnorhitachi- HITACH EUROPE AB Egebkgrd Egebkvej 98 DK-2850 Nrum DENMARK Tel: +45 43 43 6050 F

43、ax: +45 43 60 51 Email: csgnorhitachi- HITACHI EUROPE AB Neopoli / Niemenkatu 73 FIN-15140 Lahti FINLAND Tel : +358 3 8858 271 Fax: +358 3 8858 272 Email: csgnorhitachi- Hitachi Europe Ltd Bergensesteenweg 421 1600 Sint-Pieters-Leeuw BELGIUMTel: +32 2 363 99 01 Fax: +32 2 363 99 00 Email: sofie.van.bomhitachi- HITACHI EUROPE LTD Na Sychrove 975/8 101 27 Praha 10 Bohdalec CZECH REPUBLIC Tel: +420 267 212 383 Fax: +420 267 212 385 Email: csgnorhitachi-