Hitachi-HTDK160-mc-sm2 维修电路原理图.pdf

《Hitachi-HTDK160-mc-sm2 维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《Hitachi-HTDK160-mc-sm2 维修电路原理图.pdf（39页珍藏版）》请在收音机爱好者资料库上搜索。

1、SM9209SPECIFICATIONS AND PARTS ARE SUBJECT TO CHANGE FOR IMPROVEMENTDVD DIGITAL THEATRE SYSTEMSERVICE MANUAL2002November Digital Media DivisionHTDK160STAN DBYDVDTUNERAUX2580SLEEPREPEATA-BN/PMENU/PB CSLOW/MEMORYZoomEQLanguageAUDIOGoToSubTitleANGLEReturnDISP LAYMUT ESEL ECTADJ /VOLSET UPTITL EPLAY /PA

2、U SEOPE N/CL OSEPRO GLIST ENIN GENTPOWERREMOTE CONTROLLE RRB-HTDK160STANDBYRadioFans.CN 收音机爱 好者资料库 ENGLISH SAFETY PRECAUTIONS WARNING: The following precautions must be observed.ALL PRODUCTS Before any service is performed on the chassis an isolation transformer should be inserted between the power

3、line and the product. 1. When replacing the chassis in the cabinet, ensure all the protective devices are put back in place. 2. When service is required, observe the original lead dressing. Extra precaution should be taken to ensure correct lead dressing in any high voltage circuitry area. 3. Many e

4、lectrical and mechanical parts in HITACHI products have special safety related characteristics. These characteristics are often not evident from visual inspection, nor can the protection afforded by them necessarily be obtained by using replacement components rated for higher voltage, wattage, etc.

5、Replacement parts which have these special safety characteristics are identified by marking with a ! on the schematics and the replacement parts list. The use of a substitute replacement component that does not have the same safety characteristics as the HITACHI recommended replacement one, shown in

6、 the parts list, may create electrical shock, fire, X-radiation, or other hazards. 4. Always replace original spacers and maintain lead lengths. Furthermore, where a short circuit has occurred, replace those components that indicate evidence of overheating. 5. Insulation resistance should not be les

7、s than 2M ohms at 500V DC between the main poles and any accessible metal parts. 6. No flashover or breakdown should occur during the dielectric strength test, applying 3kV AC or 4.25kV DC for two seconds between the main poles and accessible metal parts. 7. Before returning a serviced product to th

8、e customer, the service technician must thoroughly test the unit to be certain that it is completely safe to operate without danger of electrical shock. The service technician must make sure that no protective device built into the instrument by the manufacturer has become defective, or inadvertentl

9、y damaged during servicing. CE MARK 1. HITACHI products may contain the CE mark on the rating plate indicating that the product contains parts that have been specifically approved to provide electromagnetic compatibility to designated levels. 2. When replacing any part in this product, please use on

10、ly the correct part itemised in the parts list to ensure this standard is maintained, and take care to replace lead dressing to its original state, as this can have a bearing on the electromagnetic radiation/immunity. PICTURE TUBE 1. The line output stage can develop voltages in excess of 25kV; if t

11、he E.H.T. cap is required to be removed, discharge the anode to chassis via a high value resistor, prior to its removal from the picture tube. 2. High voltage should always be kept at the rated value of the chassis and no higher. Operating at higher voltages may cause a failure of the picture tube o

12、r high voltage supply, and also, under certain circumstances could produce X-radiation levels moderately in excess of design levels. The high voltage must not, under any circumstances, exceed 29kV on the chassis (except for projection Televisions). 3. The primary source of X-radiation in the product

13、 is the picture tube. The picture tube utilised for the above mentioned function in this chassis is specially constructed to limit X-radiation. For continued X-radiation protection, replace tube with the same type as the original HITACHI approved type 4. Keep the picture tube away from the body whil

14、e handling. Do not install, remove, or handle the picture tube in any manner unless shatterproof goggles are worn. People not so equipped should be kept away while picture tubes are handled LASERS If the product contains a laser avoid direct exposure to the beam when the cover is open or when interl

15、ocks are defeated or have failed. RadioFans.CN 收音机爱 好者资料库CONTENTS1 GENERAL INFORMATION . E1-11-1 SPECIFICATIONS . E1-11-2 CONTROLLING VERSION OF FIRMWARE . E1-21-3 REPAIR INSTRUCTIONS . E1-32 EXPLODED VIEW .2-12-1 MAIN UNIT . 2-12-2 SUBWOOFER .2-23 REPLACEMENT PARTS LIST .3-13-1 MAIN UNIT SECTION .

16、3-13-1-1 MECHANICAL PARTS LIST .3-13-1-2 ELECTRICAL PARTS LIST . 3-2TUNER . 3-2SCART . 3-3KEY PANEL . 3-4POWER . 3-5MAIN .3-63-2 SUBWOOFER SECTION .3-93-2-1 MECHANICAL PARTS LIST .3-93-2-2 ELECTRICAL PARTS LIST . 3-10AMP & JACK . 3-10POWER . 3-10SCHEMATIC, CIRCUIT BOARD AND BLOCK DIAGRAMS . 11 MAIN

17、UNIT SECTION . 11-1 WIRING DIAGRAM . 11-2 BLOCK DIAGRAM . 21-3 SCHEMATIC DIAGRAMS . 3TUNER . 3SCART . 4KEY PANEL .5POWER . 6MAIN . 71-4 IC BLOCK DIAGRAMS .111-5 CIRCUIT BOARD DIAGRAMS .16TUNER . 16SCART . 18KEY PANEL .19POWER .20MAIN . 212 SUBWOOFER SECTION .232-1 WIRING DIAGRAM . 232-2 BLOCK DIAGRA

18、M . 242-3 SCHEMATIC DIAGRAMS . 25AMP & JACK . 25POWER .262-4 CIRCUIT BOARD DIAGRAMS .27AMP & JACK . 27POWER .28E1 - 1DVD Player Pickup Semiconductor laser, Wavelength 650 mm Signal system NTSC / PAL Video signal horizontal resolution 480 lines (DVD) Video signal-to-noise ratio 50 dB (DVD)Audio signa

19、l-to-noise ratio 60 dB Total harmonic distortion 0.05% Dynamic range DVD : 80 dB ; CD: 80 dBFM Tuner System PLL quartz-locked digital synthesizer system Tuning range 87.50 108.00 MHz (50 kHz step) Antenna FM pigtail antenna Antenna terminals 75 ohms, unbalanced Intermediate frequency 10.7 MHzAM Tune

20、r System PLL quartz-locked digital synthesizer system Tuning range 5221620 kHz (9 kHz interval) Antenna AM Loop antennaVideo outputs CVBS Video 1 Vp-p 75 ohms S-video Y: 1 Vp-p 75 ohmsC: PAL 0.3 Vp-p 75 ohms / NTSC 0.286 Vp-p 75 ohms Scart out 1 Vp-p 75 ohms Optical & Coaxial out 1 Vp-p 75 ohmsAudio

21、 line outputs Audio L/R 1 Vrms, 1k ohms Subwoofer 1.2Vrms maximum (adjustable), 1k ohmsAudio power outputs Stereo mode 50 W + 50 W (8 ohms at 1 kHz, THD 10%) Surround mode Front: 50 W + 50 W (8 ohms at 1 kHz, THD 10%)Center: 50 W (8 ohms at 1 kHz, THD 10%)Rear: 50 W + 50 W (8 ohms at 1 kHz, THD 10%)

22、 Phones Headphones jack(stereo 3.54mm)General (main unit) Power requirements AC 220 - 240 V, 50 Hz Power consumption 250 W Dimensions W 435 x H 59 x D 345 mm Weight 4.8 kgActive SubwooferOutput power : 100 W (4 ohms at 55Hz, THD 10%)Speaker system : Bass reflexPower requirements : AC 220 - 240 V, 50

23、 HzPower consumption : 165 WSpeaker unit : 8 inchesRated impedance : 4 ohmsDimensions : W 200 x H 360 x D 345 mmWeight : 9.8 kgFront / Center / Rear speakersPower: 50 W maximumSpeaker system: Bass reflexSpeaker unit: 3 inches,cone type: paperRated impedance: 8 ohmsDimensions: W 90 x H 150 x D 110 mm

24、Weight: 0.64 kg (rear speaker)0.82 kg (front , center speaker)1-1 SPECIFICATIONS MAIN UNIT SPEAKERSGENERAL INFORMATION1E1 - 21-2 CONTROLLING VERSION OF FIRMWAREThe firmware is regularly modified as required to improve theperformance.Check to see whether the customer problem can be solved byupgrading

25、 the firmware : If it can, do so.1) Open the tray with power on.2) While holding down the ADJ/VOL (+) key on remote control, press the Zoom key.3) The version of firmware will appear at the top left of screen.(The display will disappear in approx. 5 seconds.) VER XXXX 1 ATUO EUR 2 0 Version No. Regi

26、on Code Tuner Area1) Turn power on.2) Place the upgrade CD-R on tray, and press theOPEN/CLOSE or PLAY key.3) Messages will appear at the top left of screen in the ordershown below (MP3 STOP will appear in the display).4) When rewrite of the firmware is complete, the system willautomatically turn off

27、.5) Unplug the power cord and then plug it in again.6) Turn power on, and press the OPEN/CLOSE key whileLOADING is shown in the display to remove the upgradeCD-R (if the CD-R is left in the tray, rewrite of the firmwarewill restart).7) Check the version of firmware.Caution: Be sure not to unplug the

28、 power cord during therewrite operation.Note:If the firmware has been changed, etc., we will use ServiceNews, etc. to report on how to obtain new firmware data andcreate an upgraded disc. DISC LOADING BANK30.ROM READ START 015 WRITING READ START 000 READ OVER DONE READ START 000 READ OVERPower will

29、automatically turn off.* 1) 015 will be counted down to 000.* 2) WRITING will flash.C Confirm CorrectFE1 - 31-3 REPAIR INSTRUCTIONSE1 - 4POWER PCBSCART PCBTUNER PCBMAIN PCBKEY PANEL PCBPHONE JACK PCBPOWER SW PCB3214657832146578ABCED2-1 MAIN UNIT2 - 1EXPLODED VIEW22-2 SUBWOOFER2 - 2 THE UPDATED PARTS

30、 LISTFOR THIS MODEL IS AVAILABLE ON ESTA3214657832146578ABCED1 MAIN UNIT SECTION 1-1 WIRING DIAGRAM1SCHEMATIC, CIRCUIT BOARD AND BLOCK DIAGRAMS3214657832146578ABCED21-2 BLOCK DIAGRAMABCDABCD12341234L103C1L104C3L153B3L154B4Q101B1Q102B1Q103B2Q104C2Q105D4Q001A2R001A1R002A1R003A2R004B2R005B2R006B2R007C1

31、R008B1R101B1R102B1R103B1R104B1R105B1R106B1R108C2R109C2R110C2R113C1R114C1R115C1R116D2R117C3R118D3R119D3R122D4R123D4R124D3R125D3R126D4R129D2R130D2R131D2R133D3R134D3R135D4R136D4R137D3R138C4R154B3R155B2R156B3R157B3R158B3R159B3R160B3R161C3R162C3R163C3R165C3R167B4R168C4RB101 B4T101D1T102C3T103D1T104D1T105

32、D3TC001 A2TC002 C1T001A1T002A2T003C1VD002 A5VR102 D3XL152 B3C001A1C003B1C005A2C006A2C007B2C008B2C009B2C010B2C011B2C012B2C013C1C014C1C015B1C016A1C101B1C104C1C105C1C106C1C107C1C108D1C109D1C110D1C111D1C112C3C113C3C114D3C115D2C116D3C117D3C118D3C119C3C120C4C122D4C123D3C124D3C125D1C126D1C127D3C129D1C130D1

33、C131D1C132D1C133D1C134D1C135D2C136D2C137D2C138D2C139D3C140D3C141D4C142D4C143C3C144C3C145C4C161B3C163B3C164B3C165B3C166B3C167C3C169C3C170B3C171B3C173B3C174B3CF101 B1CF102 C1CF103 B3CN001 A2D101D4D001A1D002A1D003A2D004A2EF001 B1IC101D2IC152B3JK001L102A1B1C151A3C152A4C153A4C154A3C155A3C156A3C157A3R107

34、B1XL151 A3L151 A3L152 A4R151 A3IC151 A4180KTo MAIN CN0011-3 SCHEMATIC DIAGRAMS TUNER SCHEMATIC DIAGRAM3ABCDEFABCDEF12341234JK103A4JK401A3R1001B1R1002B1C1006B2C1007B3C1008B3C1009B4C1010F3FB142B2FB144B2FB145B2FB146B3FB147B4ZD1103D3ZD1104C4ZD1105C4C1001C1C1002C1C1003B1C1004B2C1005B2FB137C1FB138C1FB139B

35、1FB140B2FB141B2R1003E1RB2001 F3RB2002 F2ZD1101D2ZD1102C3ZD1106C4RB402F1C1011F3ToMAINRB402ToMAINRB2002ToMAINRB20014SCART SCHEMATIC DIAGRAMABCDEFABCDEF12341234C251D3C252D3C253A2C254B2C255B2C256A4C257B4C258B4C259C4C260D4C261D4C262D3C263D3C264C2C265A1C266B1R213A4R251A1R252A1R253A1R254A1R255A2R256A2R257A

36、2R259B2R260B2R261B2R262B2R263A4R264A4R265A4R266B3R267B3R268B3R269B3R270C3R271C3R272C3R273D2R274D3R275D3R276E3R277B1R278C4R279C4R281C4R282C4R283C4R284D4R285D4R286D3R288E4R289D4R290D4R291f4R292D3R293B4RB105A E2RB105B E3RB201E4RB202E3RB401E1D251C2D252C2D253D2CN201E4DP251C1IC251B1IC252C4JK302F1LD251E4Q2

37、51B3Q252B3Q253C3Q254E4Q255D2TA201C2TA202B3TA203C2TA204C3TA205B2TA206B2TA207C2TA208C3TA209B3TA210E3SN251D3XL251B4ZD251D4ZD252D3ZD253D3ToMAINCN401ToMAINCN105ToMAINCN2PHONE JACK PCBPOWER SW PCBKEY PANEL SCHEMATIC DIAGRAM5ABCDEFABCDEF12341234BR901 B1C901A1C902B1C903B1C904B2C905C1C906C1C907C1C908B1C909B1

38、C910C1C911C2C912C2C913C2C914B3C919D2C920E2C925E2C926E2C929E1C930E1C931E2C932F1C933F1C938E2C939E2C940F2C941F2C945E1C947E1C948E1C949E1C950E1C951F1C952F1C962B3C963D1C964C1C965D1C966D1C967D1C968B1C969D2C970F1C971E2CN902 A2D901C2D902C2D903B3D904C3D905D1D906D2D907D1D908E2D909D1D910D2F901A1IC903 C2IC904 D3

39、L901F1L903F1Q903D2Q904E1Q910B4Q912B4Q913C3R901B1R902B2R903C1R904C2R905C1R906C1R907C2R908C2R919D2R920D2R921D2R922D2R923E2R924D3R925E3R928E2R931D1R941B4R942B4R943C4R945C4R946C4R947B4R948B4R951C3R952E1RB904 F2RB906 F3RT901 B2RL901 B3SN901 D2T901A1T902A3T903D1ZD901 C1ZD902 D3ZD903 E1RB905 F1ToMAINCN904T

40、oMAINCN903ToMAINCN16POWER SCHEMATIC DIAGRAM345DCToTUNERRB101ToPOWERRB904ToKEY PANELRB202ToPOWERRB906MAIN SCHEMATIC DIAGRAM (TOP LEFT VIEW)72DC1CN1C5CN2D5CN102C4CN103C4CN105C1CN401A5CN903D4CN904B4CN905D3D1C1D101D1D102D1D103C1D104C1D105D1D106D1D107C1D108C1D400C5D402A3D404D5D405D5D407A4D408A4D409D5D410

41、C4D411D4D412D4FB1D4FB100D2FB101D2FB103D1FB104D1FB500B4FB502A2FB503A2FB900D1IC100D3IC101-A D5IC101-B D5IC101-C C2IC101-D C2IC101-E D5IC101-F D5IC102C3IC103C2IC104C3IC105C1IC106C1IC400B4IC401-A B4IC401-B B3IC402B3IC500B3IC501B3IC502B2IC503A1IC504A1IC505A2IC506B1IC900D4IC901D3IC914B4JK401C5JK402C5JK403

42、B4JK405-AB5JK405-BB5JK500B1L1D4L2D4L3D4L100D1L101D1L102D1L103D1L400A5L401A5L500B1L501B1L502B1L503B1L504A1L507A1L508B1L509B1L513A1L514A1L515B1L2005C2L2008B4L2009B2L2010B2L2032B1L2034A1L2036B1L2037B1L2038A1L2045A1Q101D2Q102D1Q400C5Q401B4Q402A5Q403A4Q404A4Q900D4Q903D4Q904D4Q905D4Q906D4Q907D4Q908D3Q909D

43、3Q2007 D5R1B2R2C1R3C1R4C2R41B3R42B3R103D5R105D3R107D3R108C2R109D3R111D3R112D3R113D3R114D2R115D2R116D2R118D2R120D2R121D1R122D2R123D2R124D2R125D2R126D2R129D1R130D1R131D1R132D1R133D1R134D1R135D1R137D1R139C3R143C4R144C4R145C4R146C3R147C3R148C3R149C3R150C3R151C3R152C3R153C3R154C3R155C3R156C3R157C3R158C3R

44、159C3R160C3R161C3R162C3R163C3R164C3R171D5R172D5R177C2R178C2R179C2R180C2R181C2R182C2R183C1R184C1R185C1R186C1R187C2R189C1R191C1R193C1R248C5R400C5R401C5R402C5R403C5R404C5R405B5R406B5R407B5R408B3R409C5R410C5R411B4R412B4R413B4R414B4R415B4R417B4R418B3R419B3R420B4R421B3R424B3R425A5R427B5R428B5R429A5R430B5R

45、431A4R432B5R433A5R434A4R435A4R436A4R439A4R440A4R441A4R442A4R443A4R444A4R446B4R448B4R449B4R451D3R500B2R501B2R502A2R503B2R504A2R505B1R506B1R507A1R508B1R509A1R510B1R511B1R512B1R513B1R514B1R515A3R516A2R517A2R518A2R519A1R520B1R521A1R522A1R523A1R524A1R525A1R526A1R527A1R528A1R529A1R530A1R531A1R532A1R533B2R

46、534B2R900D4R901D4R902D4R903D4R906D4R907D4R908D4R919D4R920D4R921D4R922D4R924D3R925D3R926D3R996C5R2018 D5R2061 C4R2108 C2RB2001D1RB402 B5RB2002D1RP100 C3RP101 C3RP102 C3RP103 C3RP104 C3RP105 C3RP106 C3RP107 C2RP108 C1RP109 C1RP110 C2XL100C2XL500B2Z2001C4ZD100 D1ZD401 C3ZD402 C1ToSCARTRB2001ToSCARTRB20

47、02ToKEY PANELPB105A, PB105B8MAIN SCHEMATIC DIAGRAM (TOP RIGHT VIEW)345BAToSCARTRB402ToPOWERRB905ToPHONEJACKRB401MAIN SCHEMATIC DIAGRAM (BOTTOM LEFT VIEW)9BA21C436A4C441D5C442D5C443D5C444D5C445D5C446D5C447D5C437A3C450A4C500B3C501B3C502B2C504B2C506A2C510A2C511B2C512A2C513B2C514B2C515B2C516B2C517B1C518

48、B1C519B2C520B1C523 B4C525B1C526B1C527B1C528B1C529B1C530B1C531A1C532B1C533B1C534B1C535B1C536B1C537B1C538A1C539B1C540B1C541B1C542B1C543B1C544B1C545B1C546B1C547B1C548A1C549B1C550B1C554A1C555D4C556A2C557A3C558A3C559A3C561A3C562A3C563A2C566A2C567A2C568A2C569A2C570A2C571A2C572A2C573A2C574A2C575A2C576A1C57

49、7A1C579A1C581A1C582A1C583A1C584A1C585A1C586B1C587A1C588A1C589A1C590A1C591A1C592A1C593A1C594A1C595A1C596A1C598A1C599A1C900D1C901D4C902D4C903D1C904D4C905D1C906D4C907D4C908D4C909D4C910D3C911D3C912D3C928B4C929B4C930B4C931B4C934D2C935C3C937D4C938D4C2015 D2C2016 D3C2017 D2C2018 D2C2019 D2C2020 C1C2021 D2C

50、2022 D2C2023 D2C2024 D2C2025 D2C2026 D2C2027 D2C2028 D2C2029 D2C2030 D2C2031 D2C2032 D2C2033 D2C2034 D2C2036 D1C2052 C4C2053 C4C2056 C2C2062 D2C2063 D2C2064 D2C2065 D2C2066 D2C2073 B4C2074 B4C2076 D4C2079 B2C2092 B2C2094 B2C2095 B2C2096 B2C2164 A3C2165 A3C2175 A2C2176 A2C2204 B2C2208 A1C2216 B1C2247