JBL-SCS200_6-htss-sm 维修电路原理图.pdf

《JBL-SCS200_6-htss-sm 维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《JBL-SCS200_6-htss-sm 维修电路原理图.pdf（25页珍藏版）》请在收音机爱好者资料库上搜索。

1、 SCS200.5/SCS200.6/SCS260.5/SCS260.6 SERVICE MANUAL P R O S O U N D C O M E S H O M E ! JBL Consumer Products, Harman Consumer International, 2, Route de Tours, 72500 Chteau du Loir, France. Tel: + 33 (0)2 43 38 43 00, Fax: + 33 (0)2 43 44 93 83 RadioFans.CN 收音机爱 好者资料库 Advanced Product Information P

2、 R O S O U N D C O M E S H O M E ! JBL Consumer Products, Harman Consumer International, 2, Route de Tours, 72500 Chteau du Loir, France. Tel: + 33 (0)2 43 38 43 00, Fax: + 33 (0)2 43 44 93 83 Provisional Specifications SCS 260 Satellite Frequency Response: 100Hz 20kHz Sensitivity( 2.83V1m): 88dB No

3、minal Impedance: 8 Ohm Maximum Recommended Amplifier Power1: 100 Watt RMS Power Handling (Continuous/Peak): 50W/200W High Frequency Driver: ” (13mm) Titanium laminate dome with JBL EOS waveguide Low Frequency Driver: Dual 3” (75mm) PolyPlas Magnetic Shielding: Yes Dimensions*: 11” x 4” x 3” 292mm x

4、101mm x 89mm Weight per Speaker: 1.36kg (3 lb) *excludes shelf stand SCS 260 Center Frequency Response: 100Hz 20kHz Sensitivity( 2.83V1m): 88dB Nominal Impedance: 8 Ohm Maximum Recommended Amplifier Power1: 100 Watt RMS Power Handling (Continuous/Peak): 50W/200W High Frequency Driver: ” (13mm) Titan

5、ium laminate dome with JBL EOS waveguide Low Frequency Driver: Dual 3” (75mm) PolyPlas Magnetic Shielding: Yes Dimensions*: 4” x 11” x 3” 101mm x 292mm x 89mm Weight per Speaker: 1.36kg (3 lb) *excludes shelf stand SCS 260 Subwoofer Low Frequency Cut-off: 35Hz High Frequency Cut-off: 160Hz Built-in

6、Power Amplifier: 100 Watt RMS Inputs: Line Level: LFE + Left and Right RCA Phono Inputs: High Level: Left and Right speaker terminals Outputs High Level: Left and Right speaker terminals Auto-on Mode: Yes Driver: 8” (200mm) Long Throw Cellulose Fiber Port: FreeFlow flared Magnetic Shielding: No Dime

7、nsions*: 16” x 11” x 13” 413mm x 280mm x 349mm Weight per Speaker: 12.7kg (28 lb) *including feet RadioFans.CN 收音机爱 好者资料库 Advanced Product Information P R O S O U N D C O M E S H O M E ! JBL Consumer Products, Harman Consumer International, 2, Route de Tours, 72500 Chteau du Loir, France. Tel: + 33

8、(0)2 43 38 43 00, Fax: + 33 (0)2 43 44 93 83 Provisional Specifications SCS 200 Satellite Frequency Response: 110Hz 20kHz Sensitivity( 2.83V1m): 86dB Nominal Impedance: 8 Ohm Maximum Recommended Amplifier Power1: 75 Watt RMS Power Handling (Continuous/Peak): 40W/160W High Frequency Driver: ” (13mm)

9、Titanium laminate dome with JBL EOS waveguide Low Frequency Driver: 3” (75mm) PolyPlas Magnetic Shielding: Yes Dimensions*: 7” x 4” 3” 184mm x 101mm x 89mm Weight per Speaker: 0.79kg (1.75 lb) *excludes shelf stand SCS 200 Center Frequency Response: 100Hz 20kHz Sensitivity( 2.83V1m): 88dB Nominal Im

10、pedance: 8 Ohm Maximum Recommended Amplifier Power1: 100 Watt RMS Power Handling (Continuous/Peak): 50W/200W High Frequency Driver: ” (13mm) Titanium laminate dome with JBL EOS waveguide Low Frequency Driver: Dual 3” (75mm) PolyPlas Magnetic Shielding: Yes Dimensions*: 4” x 11” x 3” 101mm x 292mm x

11、89mm Weight per Speaker: 1.36kg (3 lb) *excludes shelf stand SCS 200 Subwoofer Low Frequency Cut-off: 35Hz High Frequency Cut-off: 160Hz Built-in Power Amplifier: 100 Watt RMS Inputs: Line Level: LFE + Left and Right RCA Phono Inputs: High Level: Left and Right speaker terminals Outputs High Level:

12、Left and Right speaker terminals Auto-on Mode: Yes Driver: 8” (200mm) Long Throw Cellulose Fiber Port: FreeFlow flared Magnetic Shielding: No Dimensions*: 16 x 11” x 13” 413mm x 280mm x 349mm Weight per Speaker: 12.7kg (28 lb) *including feet SCS200SUB / SCS260SUBSCS260 CENTER / SCS200 CENTERModel n

13、ame: SCS 300/260 SATNo.Part numberDescriptionQty01 306-HIPS-00725Plastic cover 287.89*97.2*86.4H black 1PC02 28DM13NH-DT01 13mm DOME TWEETER 4 OHM 1PC03 32PF55JZL-LW01 Woofer 3 1/4 19mm 12ohm (2.3+2.1)oz 2PCS04 351-KM04015A321 Screw8PCS05 354-HM04703 Screw8PCS06 352-FM04014D602 Screw6PCS07 013-7600-

14、00827 Crossover of CEN1PC08 352-AM03008D035 Screw2PCS09 327-010-00118 Grille cup 10*11.2 black 6PCS10 215-000-00827 Terminal 1PC11 352-CM03509D439 Screw1PC12 244-030-00306 Grille 255.99*92.78*19.88H black 1PC13 336-EVA-00297 EVA 330*5.5*0.5T black 2PCS14 424-000-05002 PO bag SCS200.7;300.71PCModel n

15、ame: SCS 200/300 CENNo.Part numberDescriptionQty01 306-HIPS-00724HIPS plastic cover 287.89*97.2*86.4H blac 1PC02 28DM13NI-DT01 Tweeter2PCS03 32PF55JZL-LW01 Woofer1PC04 351-KM04015A321 Screw8PCS05 354-HM04703 Screw8PCS06 352-FM04014D602 Screw6PCS07 013-7600-00827X-over1PC08 352-AM03008D035 Screw2PCS0

16、9 327-010-00118Grille cup6PCS10 215-000-00827Terminal1PC11 352-CM03509D439 Screw1PC12 244-030-00307HIPS grille 255.99*92.78*19.88H black1PC13 336-EVA-00297EVA 330*5.5*0.5T black2PCS14 424-000-05002PO bag SCS200.7;300.71PCModel name: SCS 200 SATNo.Part numberDescriptionQty01 306-HIPS-00726HIPS plasti

17、c cover 185.93*96.9*84.7H blac 1PC02 19DM13NJ-DT01Tweeter1PC03 32PF55JZF-FW01 Woofer 3 1/41PC04 351-KM04015A321 Screw4PCS05 354-HM04703Screw 4PCS06 352-FM04014D602 Screw4PCS07 013-7600-00828X-over1PC08 352-AM03008D035 Screw2PCS09 327-010-00118 Grille cup4PCS10 215-000-00827Terminal1PC11 352-CM03509D

18、439 Screw1PC12 244-030-00305HIPS grille 156.24*92.46*17.9H black1PC13 336-EVA-00295EVA 220*5.5*0.5T black 1PC14 424-000-05001PO bag SCS200.7 SAT1PCSAT200/260/300 ?Wall bracket?326-ABS-05010 Model name: SCS200/260 6No. Part numberDescriptionReferenceQty01051-A00374APCB ASSY amp 1PC02351-AM03008A079Sc

19、rew M3*86PCS03351-BM03012A088Screw M3*12 1PC04351-HM04016A218Screw M4*16 4PCS05354-GM04002Screw sheet M4 4PCS06352-AM03008D040Screw 3*8 Type B8PCS07352-AM03010D065Screw 3*10 Type P4PCS08350-EM04012D024Screw 4*124PCS09150-e8604106Transformer EI-86 230V/50Hz1PC10152-v602026Power wire SP-021A 6FT VDE1P

20、C11154-v12506t0Fuse TSD 1.25A 250V VDE1PC12155-520020Fuse connector R3-111PC13162-10082007WIRE RED 18AWG 80mm1PC14162-a040d001Speaker wire #1015 400mm 1PC15163-11009Mini tighen wire 100mm 2PCS16176-wjce1Terminal CE-11PC17180-prf1003sPower switch RF-1003-BB2-OHASW1011PC18193-2m1813PiezoTO-220 18*13mm

21、Q120,Q1242PCS19306-ABS-00714Plastic cover with metal spray 268*213*102 1PC20361-FE-00004IC HOLDER 26.9*12*1.4T1PC21323-AL-00019 HEAT SINK 117.5*60*25 1PC22311-ABS-00028Plastic knob 46077-W P.V.C.1PC23302-AL-00226-0BFAlu. Panel 215*270*2.5t SCS1401PC23302-AL-00226-0BG Alu. Panel 215*270*2.5t SCS1461P

22、C24335-NYL-00002Wire lock 4K-4 NO-BB2PCS25333-EVA-00096EVA gasket wide side 213*15*2.0mm2PCS26333-EVA-00097EVA gasket wide side 213*15*1.0t2PCS27333-EVA-00132EVA gasket long side 238*15*2.0mm2PCS28333-EVA-00133EVA gasket long side 238*15*1.0t2PCS29333-EVA-00220EVA gasket long side 225*15*1t UL1PC303

23、20-RUB-00033Rubber gasket 25*21*4t 4PCS31413-000-00188SPEAKER label 4 OHM 45*8mm1PC32 413-000-00540Label, MADE IN CHINA1PC33333-EVA-00188EVA gasket 170 x5x1t 1PC34362-FE-00013PCB Gasket L TYPE t=1.6mm S.P.C.C 89*9*1.6T2PCSPrint on: 11/08/04Page: 1/4File: Part list -SCS140 & 146 (JBL) for service man

24、ual .xlsElectric parts No. Part numberDescriptionReferenceQty02351-AM03014A094Screw M3*141PC03352-AM03008D040Screw 3*8 Type B4PCS04110-10821jk2 Resistor 820 1W 5% 10mmR1321PC05110-122r2j15Resistor 2.2 1/2W 5% 15mmR1271PC06113-500r1j10Cement resistor 0.1 5W 5% R121,R1222PCS07114-03302m0Semi-fixed res

25、istor 3K 0.3W 20% R1381PC08115-h503a101Variable resistor D16 50K/1 AVR2011PC09135-4478m35Electrolytic cap 4700uF 35V 20% C121,C1222PCS10135-4478m50Electrolytic cap 4700uF 50V 20%C133,C1342PCS11156-h010010Tube 1*10mmQ101,Q1152PCS12162-10202001Wire 26AWG 1007 200mm RED1PC13171-udhss124dRelay 5A 24V UD

26、H-SS124DRY1011PC14174-0rcb202vJack RCA JACK RCB-202VJK2021PC15174-0rca108nbRCA JACK RCA108NB 1P JK2031PC16174-2rsp108vSpeaker terminal 8 PIN RSP-108VJK2011PC17175-1c07v01Connector 7PIN PITCH=2.5mmP1011PC18175-1d02v01Connector 2PIN PITCH=3.96mmP1021PC19175-1d05v01Connector 5PIN 3.96mmP1031PC20180-tms

27、7210vSWITCH SLIDE 6PIN MS7210VSW2011PC21190-06m4558dI.C. OPA 4558D U101,U2032PCS22190-16tl074cnI.C TL074CN STU201,U2022PCS23192-021c1815grTransistor 2SC1815GRQ101,Q1152PCS24192-991d669aTransistorHI-SINCERITY HSD669A Q1061PC25192-021tip35cTransistor TIP35CQ1071PC26192-992b649t Transistor HSB649TQ1051

28、PC27192-022tip36cTransistor TIP36CQ1081PC28192-161tip41cTransistor TIP41C NPN SGSQ1241PC29192-162tip42c Transistor TIP42C PNP SGS Q1201PC30192-201d882yTransistor KSD882YQ1171PC31192-202b772yTransistor KSB772YQ1191PC32193-3m2520Piezo TO-3P 25x20mmQ107,Q1082PCS33195-10204hgwLED 204HGW 3D2091PC34197-00

29、kbl405Bridge rectifier 4A 500V KBL40D110,D1152PCS35197-101n4002Diode 1N4002D1041PC36197-101n5402Diode 1N5402D111,D1122PCS37361-FE-00051Transistor holder 14.2*8.0*5.2 t=1.6mm1PC38323-AL-00020HEAT SINK 65*32*31 1PC39361-NYL-00054Transistor isolated sheet 2PCS01104-sub135e00PCB OF SUB135E1PC02110-14122

30、j26Resistor 1.2K 1/4W 5% CF 26mm TAPR2651PC03110-14472j26Resistor 4.7K 1/4W 5% CF 26mm TAPR201,R2022PCS04110-14560j26Resistor 56 1/4W 5% CF 26mm TAPR1171PC05110-16101j26Resistor 100 1/6W 5% CF 26mm TAPR120,R213,R214,R2154PCS06110-16102j26Resistor 1K 1/6W 5% CF 26mm TAPR124,R166,R254,R2644PCS07110-16

31、103j26Resistor 10K 1/6W 5% CF 26mm TAPR133,R134,R209,R212,R216,R217,R220,R221,R222,R225,R226,R228,R229,R230,R232,R235,R240,R26018PCS08110-16104j26Resistor 100K 1/6W 5% CF 26mm TAPR163,R164,R2313PCS09110-16105j26Resistor 1M 1/6W 5% CF 26mm TAPR143,R2592PCS10110-16123j26Resistor 12K 1/6W 5% CF 26mm TA

32、PR135,R139,R1653PCS11110-16124j26Resistor 120K 1/6W 5% CF 26mm TAPR2331PC12110-16151j26Resistor 150 1/6W 5% CF 26mm TAPR2531PC13110-16152j26Resistor 1.5K 1/6W 5% CF 26mm TAPR103,R123,R136,R137,R141,R142,R1537PCS14110-16153j26Resistor 15K 1/6W 5% CF 26mm TAPR118,R145,R152,R154,R2345PCS15110-16154j26R

33、esistor 150K 1/6W 5% CF 26mm TAPR131,R2522PCS16110-16181j26Resistor 180 1/6W 5% CF 26mm TAPR111,R1142PCSPrint on: 11/08/04Page: 2/4File: Part list -SCS140 & 146 (JBL) for service manual .xlsElectric parts No. Part numberDescriptionReferenceQty17110-16183j26Resistor 18K 1/6W 5% CF 26mm TAPR2271PC1811

34、0-16223j26Resistor 22K 1/6W 5% CF 26mm TAP0,R237,R238,R255,R256,R262,R26312PCS19110-16273j26Resistor 27K 1/6W 5% CF 26mm TAPR2231PC20110-16205j26Resistor 2M 1/6W 5% CF 26mm TAPR2571PC21110-16332j26Resistor 3.3K 1/6W 5% CF 26mm TAPR106,R107,R144,R236,R2585PCS22110-16392j26Resistor 3.9K 1/6W 5% CF 26m

35、m TAPR105,R1082PCS23110-16393j26Resistor 39K 1/6W 5% CF 26mm TAP R1261PC24110-16470j26Resistor 47 1/6W 5% CF 26mm TAPR112,R113,R115,R1164PCS25110-16471j26Resistor 470 1/6W 5% CF 26mm TAPR140,R161,R1623PCS26110-16472j26Resistor 4.7K 1/6W 5% CF 26mm TAPR110,R125,R130,R147,R150,R157,R159,R207,R2089PCS2

36、7110-16473j26Resistor 47K 1/6W 5% CF 26mm TAPR101,R219,R249,R250,R2515PCS28110-16512j26Resistor 5.1K 1/6W 5% CF 26mm TAPR210,R2112PCS29110-16513j26Resistor 51K 1/6W 5% CF 26mm TAPR2241PC30110-16563j26Resistor 56K 1/6W 5% CF 26mm TAPR1041PC31110-16681j26Resistor 680 1/6W 5% CF 26mm TAPR148,R1512PCS32

37、110-16682j26Resistor 6.8K 1/6W 5% CF 26mm TAPR1091PC33110-16913j26Resistor 91K 1/6W 5% CF 26mm TAPR203,R204,R205,R2064PCS34130-sl101k503Disc capacitor 100P 50V SL 10% TAP5PCS35130-2b102k503Disc capacitor 1000P 50V 10% TAPC116,C141,C2033PCS36130-2b221k503Disc capacitor 220P 50V 10% TAPC204,C205,C210,

38、C211,C212,C2306PCS37130-2b681k503Disc capacitor 680P 50V 10% TAPC2081PC38130-2f104z503Disc capacitor 0.1U 50V +80/-20% TAPC108,C113,C115,C119,C137,C138,C232,C235,C236,C237,C239,C240,C24113PCS39130-3f473m503Disc capacitor 0.047U 50V 20% TAPC106,C2092PCS40130-sl470k503 Disc capacitor 47P 50V 10% TAPC2

39、291PC41132-103j503Mylar capacitor 0.01U 50V 5% TAPC223,C2242PCS42132-104j503Mylar capacitor 0.1U 50V 5% TAPC107,C218,C221,C2224PCS43132-223ja03Mylar capacitor 0.022uF 100V 5% TAPC123,C124,C125,C126,C127,C128,C131,C132, C2159PCS44132-473j503Mylar capacitor 0.047U 50V 5% TAPC216,C2172PCS45135-3105m50E

40、lectrolytic cap 1U 50V 20% TAPC105,C112,C2283PCS46135-3106m50Electrolytic cap 10uF 50V 20% TAPC201,C202,C206,C213,C219,C2316PCS47135-3107m16Electrolytic cap 100uF 16V 20% TAPC109,C110,C117,C120,C234,C238,C2427PCS48135-3107m50Electrolytic cap 100U 50V 20% TAPC135,C1362PCS49135-3226m50Electrolytic cap

41、 22U 50V 20% TAPC114,C118,C2253PCS50135-3227m10Electrolytic cap 220U 10V 20% TAPC129,C1302PCS51135-3227m16Electrolytic cap 220U 16V 20% TAPC111,C2332PCS52135-3476m25Electrolytic cap 47U 25V 20% TAPC1031PC53192-027c1815grTransistor 2SC1815GR TAPQ102,Q111,Q112,Q113,Q118,Q123,Q126,Q206,Q207,Q20810PCS54

42、192-027c2235y Transistor 2SC2235Y TAPQ1211PC55192-028a1015grTransistor 2SA1015GR TAPQ114,Q116,Q122,Q1274PCS56192-028a965yTransistor 2SA965Y TAPQ1251PC57192-1672n5551Transistor 2N5551 TAPQ103,Q1092PCS58192-1682n5401Transistor 2N5401 AI-PNP 350V 500mA Q104,Q1102PCSPrint on: 11/08/04Page: 3/4File: Part

43、 list -SCS140 & 146 (JBL) for service manual .xlsElectric parts No. Part numberDescriptionReferenceQty59197-131n4148Diode 1N4148 26mm TAP,4,D201,D202,D206,D207,D208,D2 19PCS60199-15000335Zener Diode 3.3V 1/2W 52mm TAPD102,D2052PCS61199-15000625Zener Diode 6.2V 1/2W 52mm TAPD106,D1072PCS62199-1500160

44、5Zener Diode 16V 1/2W 52mm TAPD1091PC63161-506520JUMPER WIRE 26mm TAP68PCSNo. Part numberDescriptionReferenceQty40051-A00014BPCB ASSY OF SCS135 LIMITER1PC02162-50129001CABLE ASSY 120mm AWG28 WHTP3021PC03175-9f40hr2HR2*400.15PC04190-16tl074cnI.C TL074CN STU3011PC05162-10059001Single wire 50mm WHITE U

45、L10071PC02110-16103j26Resistor 10K 1/6W 5% CF 26mm TAP,46PCS03110-16223j26Resistor 22K 1/6W 5% CF 26mm TAPR310,R3122PCS04110-16333j26Resistor 33K 1/6W 5% CF 26mm TAPR3051PC05110-16474j26Resistor 470K 1/6W 5% CF 26mm TAP R3071PC06110-16751j26Resistor 750 1/6W 5% CF 26mm TAP R311,R3132PCS07110-16755j2

46、6Resistor 7.5M 1/6W 5% CF 26mm TAPR3061PC08130-2f104z503Disc capacitor 0.1U 50V +80/-20% TAPC305,C3062PCS09132-103j503 Mylar capacitor 0.01U 50V 5% TAPC302,C3032PCS10135-3226m50Electrolytic cap 22U 50V 20% TAPC3011PC11135-3476m25Electrolytic cap 47U 25V 20% TAPC3041PC12192-027c1815grTransistor 2SC18

47、15GR TAPQ301,Q3022PCS13197-131n4148Diode 1N4148 26mm TAPD301,D3022PCS14161-506520JUMPER WIRE 26mm TAP6PCS15110-16153j26Resistor 15K 1/6W 5% CF 26mm TAPR3021PCPrint on: 11/08/04Page: 4/4File: Part list -SCS140 & 146 (JBL) for service manual .xlsSUB200/260 TRANSISTOR PINOUTSPARTS NAMEPINOUTS123TIP35CE

48、miterCollectorbaseTIP36CEmiterCollectorbasePARTS NAMEPINOUTS1232SB649AEmiterCollectorbase2SB772EmiterCollectorbase2SD669AEmiterCollectorbase2SD882EmiterCollectorbasePARTS NAMEPINOUTS1232SA1015EmiterCollectorbase2N5401EmiterbaseCollector2SC1815EmiterCollectorbase2N5551EmiterbaseCollectorLOW NOISE J-F

49、ET QUAD OPERATIONAL AMPLIFIERS.WIDE COMMON-MODE (UP TO VCC+) ANDDIFFERENTIAL VOLTAGERANGE.LOW INPUT BIAS AND OFFSET CURRENT.LOW NOISE en= 15nV/Hz (typ).OUTPUTSHORT-CIRCUIT PROTECTION.HIGHINPUTIMPEDANCEJFETINPUTSTAGE.LOW HARMONIC DISTORTION : 0.01%(typ).INTERNAL FREQUENCY COMPENSATION.LATCHUPFREE OPE

50、RATION.HIGH SLEWRATE : 13V/s (typ)NDIP14(Plastic Package)Inverting Input 2Non-inverting Input 2Non-inverting Input 1CCV-CCV1234856791011121314+Output 3Output 4Non-inverting Input 4Inverting Input 4Non-inverting Input 3Inverting Input 3-+-+-+-+Output 1Inverting Input 1Output 2PIN CONNECTIONS (top vie