McIntosh-MC207-pwr-sm 维修电路原理图.pdf

《McIntosh-MC207-pwr-sm 维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《McIntosh-MC207-pwr-sm 维修电路原理图.pdf（32页珍藏版）》请在收音机爱好者资料库上搜索。

1、SERVICE MANUALPerformance Specifications . 2Notes . 2Rear Panel . 3Section Location . 5Block Diagram . 6Interconnection Diagram . 7 - 8Input Schematic and PCB. 9 - 12Heatsink 1-Channel Schematic and PCB . 13 - 18Heatsink 2-Channel Schematic and PCB . 21 - 26Display Schematic and PCB . 29 - 32Capacit

2、or Schematic and PCB . 33Power Supply Schematic and PCB. 34 - 35Parts List . 36 - 42Exploded Views and Parts Lists . 43 - 46Repacking Instruction . 47CONTENTSPOWER AMPLIFIERSerial Number VQ1001 And AboveSERIAL NO. VQ1001 And AboveRadioFans.CN 收音机爱 好者资料库PERFORMANCE SPECIFICATIONS21. The heavy lines o

3、n the schematic denote the primarysignal path.2. Unless otherwise noted, all voltages indicated on theschematics are measured under the following conditions:a. AC input at 120 volts, 50/60Hz.b. All voltages are +/-10% with respect to ground. A high impedance (10 megaohm) voltmeter must be used.3. Un

4、less otherwise specified:a. Resistor values are in ohms.b. Capacitor values are microfarads (uF).c. Inductor values are in microhenries (uH).4.On PC board drawings, Square pad indicates:a. Polarized Capacitors - Positiveb. Diodes - Cathodec. Others - Pin 15.WARNINGParts marked with the symbol have c

5、riticalcharacteristics. Use only replacement parts recom-mended by the manufacturer.NOTESPower OutputMinimum sine wave continuous average power output perchannel, all channels operating is: 200 watts into 4 ohm or8 ohm loadRated Power Band20Hz to 20,000HzTotal Harmonic DistortionMaximum Total Harmon

6、ic Distortion at any power level from250 milliwatts to rated power output is: 0.005% for 4 or 8ohm loadsDynamic Headroom1.7dBFrequency Response+0, -0.25dB from 20Hz to 20,000Hz+0, -3dB from 10Hz to 100,000HzSensitivity1.0 Volt Unbalanced with a 4 ohm Loudspeaker2.0 Volt Balanced with a 4 ohm Loudspe

7、aker1.4 Volt Unbalanced with a 8 ohm Loudspeaker2.8 Volt Balanced with a 8 ohm LoudspeakerA-Weighted Signal To Noise Ratio89dB (112dB below rated output)Intermodulation DistortionMaximum Intermodulation Distortion if instantaneous peakoutput per channel does not exceed twice the rated output, forany

8、 combination of frequencies from 20Hz to 20,000Hz, withall channels operating is: 0.005% for 4 or 8 ohm loadsInput Impedance20,000 ohms Balanced10,000 ohms UnbalancedWide Band Damping FactorGreater than 60 at 4 ohmsGreater than 140 at 8 ohmsPower Requirements100 Volts, 50/60Hz at 1440 watts110 Volts

9、, 50/60Hz at 13.0 amps120 Volts, 50/60Hz at 12.0 amps220 Volts, 50/60Hz at 6.0 amps230 Volts, 50/60Hz at 6.0 amps240 Volts, 50/60Hz at 6.0 ampsNote: Refer to the rear panel of the MC207 for the correct voltage.DimensionsFront Panel: 17-1/2 inches (44.45cm) wide, 9-7/16 inches(23.97cm) high. Depth be

10、hind front mounting panel is18-3/4 inches (47.63cm), including clearance for connectors.Weight83 pounds (37.6kg) net, 116 pounds (52.6kg) in shipping cartonRadioFans.CN 收音机爱 好者资料库REAR PANEL3MC207NOTES45MC207SECTION LOCATIONSTOP VIEW WITH COVER REMOVEDTOP VIEW6BLOCK DIAGRAM78MC2071INTERCONNECT910INPU

11、T 05006521112INPUT 0500652MC2071314HEATSINK 1-CHANNEL 0500703AB1516HEATSINK 1-CHANNEL DRIVER SECTION 0500703ABMC207HEATSINK 1-CHANNEL 0500703AB1718* Denotes components on reverse or backside of PC Board.NOTES1920MC207HEATSINK 2-CHANNEL 0500644ABC2122232524HEATSINK 2-CHANNEL DRIVER SECTION 0500644ABC

12、MC2072628275DISPLAY ILLUMINATION SECTION 050066HEATSINK 2-CHANNEL 0500643AB4ABC* Denotes components on reverse or backside of PC Board.5DISPLAY METER SECTION 0500665DISPLAY POWER GUARD SECTION 0500662930MC2075DISPLAY 0500663132* Denotes components on reverse or backside of PC Board.CAPACITOR 0500636

13、33MC207* Denotes components on reverse or backside of PC Board.POWER SUPPLY 05006273435POWER SUPPLY 0500627MC207RefNo.DescriptionPartNo.PARTS LISTINTERCONNECTC1ASSEMBLY CAPACITOR052005C2ASSEMBLY CAPACITOR052005D1DIODE BRID RECT070139M1METER MC207124089M2METER MC207124089M3METER MC207124089RT1ASSEMBL

14、Y THERMISTOR052017RT2ASSEMBLY THERMISTOR052017S1SWITCH POWER146243S2SWITCH POWER146243T1POTTED TRANSFORMER POWER050061TB1TERMINAL BLOCK AC074091TB2POST BINDING DUAL084124TB3POST BINDING DUAL084124TB4POST BINDING DUAL084124TB5POST BINDING DUAL084124TB6POST BINDING DUAL084124TB7POST BINDING DUAL084124

15、TB8POST BINDING DUAL084124050065 INPUT PCBC1CAP ELECT 10UF 16V 4X5 CASE066382C2CAP ELECT 10UF 16V 4X5 CASE066382C3CAP MONO 47PF 200V 10% NPO061299C4CAP MONO 47PF 200V 10% NPO061299C5CAP ELECT 10UF 16V 4X5 CASE066382C6CAP ELECT 10UF 16V 4X5 CASE066382C7CAP MONO .1uF 50V 20% Z5U061305C8CAP MONO .1uF 5

16、0V 20% Z5U061305C9CAP MONO 22PF 200V 10% NPO061298C10CAP MONO 22PF 200V 10% NPO061298C11CAP MONO 47PF 200V 10% NPO061299C12CAP ELECT 10UF 50V066445C13CAP MONO 47PF 200V 10% NPO061299C14CAP ELECT 10UF 50V066445C15CAP ELECT 10UF 16V 4X5 CASE066382C16CAP ELECT 10UF 16V 4X5 CASE066382C17CAP MONO 47PF 20

17、0V 10% NPO061299C18CAP ELECT 10UF 16V 4X5 CASE066382C19CAP MONO 47PF 200V 10% NPO061299C20CAP MONO .1uF 50V 20% Z5U061305C21CAP MONO .1uF 50V 20% Z5U061305C22CAP ELECT 10UF 16V 4X5 CASE066382C23CAP MONO 22PF 200V 10% NPO061298C24CAP MONO .1uF 50V 20% Z5U061305C25CAP MONO .1uF 50V 20% Z5U061305C26CAP

18、 MONO 47PF 200V 10% NPO061299C27CAP MONO 22PF 200V 10% NPO061298C28CAP MONO 47PF 200V 10% NPO061299C29CAP ELECT 10UF 16V 4X5 CASE066382C30CAP MONO 47PF 200V 10% NPO061299C31CAP ELECT 10UF 16V 4X5 CASE066382C32CAP MONO 22PF 200V 10% NPO061298C33CAP MONO 47PF 200V 10% NPO061299C34CAP ELECT 10UF 16V 4X

19、5 CASE066382C35CAP MONO 47PF 200V 10% NPO061299C36CAP ELECT 10UF 16V 4X5 CASE066382C38CAP MONO 22PF 200V 10% NPO061298C39CAP MONO .1uF 50V 20% Z5U061305C40CAP MONO .1uF 50V 20% Z5U061305C41CAP MONO 47PF 200V 10% NPO061299C43CAP ELECT 10UF 16V 4X5 CASE066382C44CAP MONO 47PF 200V 10% NPO061299C45CAP E

20、LECT 10UF 16V 4X5 CASE066382C46CAP MONO 22PF 200V 10% NPO061298C47CAP MONO 22PF 200V 10% NPO061298J1CONN MALE 9 POS FRICTION LOCK 117244J2JACK RCA BLK117847J3JACK RCA 1X2 BLK/BLK 14MM117848J4CONN 4 PIN117215J5CONN 4 PIN117215J6RECEPTACLE XLR FEMALE117685J7RECEPTACLE XLR FEMALE117685J8JACK RCA 1X2 BL

21、K/BLK 14MM117848J9CONN 4 PIN117215J10CONN D 25-PIN117501J11CONN 4 PIN117215J12RECEPTACLE XLR FEMALE117685J13RECEPTACLE XLR FEMALE117685J14RECEPTACLE XLR FEMALE117685J16JACK RCA 1X2 BLK/BLK 14MM117848J17CONN 4 PIN117215J18RECEPTACLE XLR FEMALE117685J19JACK HEADPHONE DUAL BLACK 1/8117825J20RECEPTACLE

22、XLR FEMALE117685R1RES MF 1K 1% 1/4W144090R2RES MF 1K 1% 1/4W144090R3RES MF 20K 1% 1/4W144104R4RES MF 221 OHM 1% 1/4W144172R5RES MF 20K 1% 1/4W144104R6RES MF 221 OHM 1% 1/4W144172R7RES MF 100K 1% 1/4W144113R8RES MF 100K 1% 1/4W144113R9RES MF 20K 1% 1/4W144104R10RES MF 20K 1% 1/4W144104R11RES MF 10K 1

23、% 1/4W144053R12RES MF 10K 1% 1/4W144053R13RES MF 10 OHM 1% 1/4W144157R14RES MF 10K 1% 1/4W144053R16RES MF 100K 1% 1/4W144113R17RES MF 10K 1% 1/4W144053R18RES MF 100K 1% 1/4W144113R19RES MF 10 OHM 1% 1/4W144157R20RES MF 1K 1% 1/4W144090R21RES MF 20K 1% 1/4W144104R22RES MF 221 OHM 1% 1/4W144172R23RES

24、MF 1K 1% 1/4W144090R24RES MF 100K 1% 1/4W144113R25RES MF 20K 1% 1/4W144104R26RES MF 20K 1% 1/4W144104R27RES MF 221 OHM 1% 1/4W144172R28RES MF 100K 1% 1/4W144113R29RES MF 10K 1% 1/4W144053R30RES MF 20K 1% 1/4W144104R31RES MF 10K 1% 1/4W144053R33RES MF 100K 1% 1/4W144113R34RES MF 10K 1% 1/4W144053R35R

25、ES MF 10K 1% 1/4W144053R37RES MF 100K 1% 1/4W144113R38RES MF 1K 1% 1/4W144090R39RES MF 20K 1% 1/4W144104R40RES MF 221 OHM 1% 1/4W144172R41RES MF 100K 1% 1/4W1441133621R42RES MF 20K 1% 1/4W144104R43RES MF 10K 1% 1/4W144053R44RES MF 10K 1% 1/4W144053R45RES MF 100K 1% 1/4W144113R46RES MF 100 OHM 1% 1/4

26、W144196R47RES MF 1K 1% 1/4W144090R48RES MF 20K 1% 1/4W144104R49RES MF 221 OHM 1% 1/4W144172R50RES MF 100K 1% 1/4W144113R51RES MF 20K 1% 1/4W144104R55RES MF 10K 1% 1/4W144053R56RES MF 10K 1% 1/4W144053R58RES MF 100K 1% 1/4W144113R59RES MF 1K 1% 1/4W144090R60RES MF 20K 1% 1/4W144104R61RES MF 221 OHM 1

27、% 1/4W144172R62RES MF 100K 1% 1/4W144113R63RES MF 20K 1% 1/4W144104R64RES MF 100 OHM 1% 1/4W144196R65RES MF 10K 1% 1/4W144053R66RES MF 10K 1% 1/4W144053R68RES MF 100K 1% 1/4W144113S1SWITCH SLIDE148059SP1BRACKET PCB CARD MOUNTING003611U1IC DUAL OPERATIONAL AMPLIFIER 133260U2IC DUAL OPERATIONAL AMPLIF

28、IER 133260U3IC DUAL OPERATIONAL AMPLIFIER 133260U4IC DUAL OPERATIONAL AMPLIFIER 133260050070 HEATSINK 1-CHANNEL PCBC1CAP ELECT 47UF 35V066446C2CAP ELECT 47UF 35V066446C3CAP MONO .1uF 50V 20% Z5U061305C4CAP POLYPROP 0.15UF 10% 250VDC064363C7CAP MONO 100PF 100V 10% NPO061300C8CAP MONO 100PF 100V 10% N

29、PO061300C9CAP MONO .01UF 50V 20% X7R061304C14CAP MONO 100PF 100V 10% NPO061300C16CAP MONO .01UF 50V 20% X7R061304C22CAP ELECT 220UF 25V066507C27CAP MONO 100PF 100V 10% NPO061300C30CAP ELECT 47UF 35V066446C31CAP ELECT .47UF 50V066244C32CAP MONO .1uF 50V 20% Z5U061305C33CAP MONO .1uF 50V 20% Z5U061305

30、C35CAP ELECT 10UF 100VDC066462C36CAP ELECT 10UF 100VDC066462C37CAP ELECT 10UF 100VDC066462C38CAP ELECT 10UF 100VDC066462C40CAP ELECT 220UF 50V 20%066254C41CAP ELECT 10UF 100VDC066462C47CAP POLYPROP .047UF 10% 250VDC064364C51CAP ELECT 10UF 100VDC066462C200CAP ELECT 10UF 100VDC066462D1DIODE SILICON070

31、047D2DIODE SILICON070047D4DIODE SILICON070047D5DIODE SILICON070047D6DIODE RECTIFIER070131D7DIODE RECTIFIER070131IC2IC DUAL AMP133259J1CONN MALE 9 POS FRICTION LOCK 117244J2CONN 4 PIN117215J4CONN HEADER 2 PIN 0.156117404J5BLADE FASTON .110117712J6BLADE FASTON W/FEET117708J8CONN HEADER 2 PIN 0.1561174

32、04J9CONN 2 PIN MALE117213K1RELAY 24VDC 5A 277VAC087057K2RELAY 24VDC 5A 277VAC087057L2CHOKE 0.65UH OUTPUT122297LD1LDR NETWORK144179Q1TRANSISTOR NPN132223Q2TRANSISTOR PNP132224Q3TRANSISTOR NPN132268Q4TRANSISTOR PNP132267Q5TRANSISTOR NPN132223Q6TRANSISTOR NPN132285Q7TRANSISTOR PNP132286Q8TRANSISTOR PNP

33、 POWER132297Q9TRANSISTOR NPN POWER132296Q10TRANSISTOR PNP POWER132297Q11TRANSISTOR NPN POWER132296Q20TRANSISTOR NPN POWER132296Q22TRANSISTOR PNP POWER132297Q23TRANSISTOR NPN POWER132296Q25TRANSISTOR PNP POWER132297Q27TRANSISTOR PNP132224Q29TRANSISTOR PNP POWER132255Q30TRANSISTOR SI NPN 25V132254Q31T

34、RANSISTOR NPN132223Q32TRANSISTOR NPN132223Q33TRANSISTOR PNP POWER132255Q35TRANSISTOR NPN132223Q37TRANSISTOR NPN132285Q39TRANSISTOR PNP132286Q41TRANSISTOR PNP132224Q49TRANSISTOR PNP132224Q50TRANSISTOR NPN132223Q51TRANSISTOR NPN132223Q52TRANSISTOR NPN132223Q53TRANSISTOR PNP POWER132255Q54TRANSISTOR PN

35、P132224Q55TRANSISTOR PNP POWER132255Q56TRANSISTOR PNP POWER132255Q59TRANSISTOR NPN132223Q60TRANSISTOR SI NPN 25V132254Q61TRANSISTOR SI NPN 25V132254Q63TRANSISTOR NPN132223Q64TRANSISTOR PNP POWER132255R1RES MF 332 OHM 1% 1/4W144446R2RES MET OX 680 OHM 5% .5W137093R3RES MF 22.1K 1% 1/4W144187R4RES MF

36、100K 1% 1/4W144113R5RES MF 22.1K 1% 1/4W144187R6RES MET OX 1.8k 5% .5W137094R7RES MET OX 430 OHM 5% .5W137095R8RES MF 332 OHM 1% 1/4W144446R9RES MET OX 680 OHM 5% .5W137093R10RES MF 22.1K 1% 1/4W144187R11RES MET OX 1.8k 5% .5W137094R12RES MET OX 47 OHM 5% .5W137096R13POT TRIM 200 OHM 20% HORIZ AD134

37、390R14RES MF 100K 1% 1/4W144113R15RES MF 100 OHM 1% 1/4W144196PARTS LIST contMC207373A3BR16RES MF 100 OHM 1% 1/4W144196R17RES MF 100 OHM 1% 1/4W144196R30RES MF 475K 1% 1/4W144364R32RES MF 47.5K 1% 1/4W144108R33RES MF 47.5K 1% 1/4W144108R34RES MF 5.11K 1% 1/4W144083R36RES 511 OHM 1% 1/4W144123R37RES

38、MF 681K 1% 1/4W144443R38RES MF 866 OHM 1% 1/4W144028R39RES MF 2.21 OHM 1/4W 1%144378R41RES WW DUAL .47 OHM 5% 3W139244R42RES WW DUAL .47 OHM 5% 3W139244R43RES WW DUAL .47 OHM 5% 3W139244R45RES WW DUAL .47 OHM 5% 3W139244R46RES MF 4.75K 1% 1/4W144097R48RES MF 100 OHM 1% 1/4W144196R50RES MF 14.7K 1% 1

39、/4W144149R51RES MF 221 OHM 1% 1/4W144172R52RES MF 267K 1% 1/4W144118R53RES MF 221 OHM 1% 1/4W144172R54RES MF 3.32K 1% 1/4W144095R55RES MF 3.32K 1% 1/4W144095R56RES MF 10K 1% 1/4W144053R57RES MF 475K 1% 1/4W144364R58RES MF 1.1K 1% 1/4W144091R59RES MF 2.21 OHM 1/4W 1%144378R60RES FP 22 OHM 1/4W 5%1370

40、33R62RES MF 22.1K 1% 1/4W144187R63RES FP 22 OHM 1/4W 5%137033R65RES MF 681K 1% 1/4W144443R67RES MF 100 OHM 1% 1/4W144196R70RES MF 100 OHM 1% 1/4W144196R71RES MF 100 OHM 1% 1/4W144196R72RES MF 100 OHM 1% 1/4W144196R77RES MF 1M 1/4W144269R79RES CF 10 OHM 5% 1/2W141165R82RES MF 1M 1/4W144269R83RES MF 1

41、0K 1% 1/4W144053R84RES MF 47.5K 1% 1/4W144108R85RES MF 1.1K 1% 1/4W144091R86RES MF 4.75K 1% 1/4W144097R88RES MF 12.1K 1% 1/4W144154R90RES MF 1.1K 1% 1/4W144091R93RES MF 4.75K 1% 1/4W144097R101RES MF 953 OHM 1/4W 1%144473R103RES MF 332K 1% 1/4W144119R104RES MF 15K 1% 1/4W144412R105RES MF 6.49K 1% 1/4

42、W144140R106RES MF 475 OHM 1% 1/4W144086R109RES CF 0 OHM 5% 1/4W141389R111RES MET OX 430 OHM 5% .5W137095R114RES CF 10 OHM 5% 1/2W141165R119RES MO 4.7 OHM 1W 5%144464R122RES MF 47.5K 1% 1/4W144108R123RES MF 22.1K 1% 1/4W144187R124RES MF 47.5K 1% 1/4W144108RT1SENSOR THERMAL144249RT2SENSOR THERMAL14424

43、9050064 HEATSINK 2-CHANNEL PCBC1CAP ELECT 47UF 35V066446C2CAP ELECT 47UF 35V066446C3CAP MONO .1uF 50V 20% Z5U061305C4CAP POLYPROP 0.15UF 10% 250VDC064363C7CAP MONO 100PF 100V 10% NPO061300C8CAP MONO 100PF 100V 10% NPO061300C9CAP MONO .01UF 50V 20% X7R061304C10CAP ELECT 47UF 35V066446C11CAP ELECT 47U

44、F 35V066446C12CAP MONO 100PF 100V 10% NPO061300C13CAP MONO 100PF 100V 10% NPO061300C14CAP MONO 100PF 100V 10% NPO061300C15CAP MONO .1uF 50V 20% Z5U061305C16CAP MONO .01UF 50V 20% X7R061304C17CAP MONO .01UF 50V 20% X7R061304C18CAP MONO .01UF 50V 20% X7R061304C19CAP MONO 100PF 100V 10% NPO061300C22CAP

45、 ELECT 220UF 25V066507C27CAP MONO 100PF 100V 10% NPO061300C28CAP MONO 100PF 100V 10% NPO061300C29CAP ELECT 47UF 35V066446C30CAP ELECT 47UF 35V066446C31CAP ELECT .47UF 50V066244C32CAP MONO .1uF 50V 20% Z5U061305C33CAP MONO .1uF 50V 20% Z5U061305C35CAP ELECT 10UF 100VDC066462C36CAP ELECT 10UF 100VDC06

46、6462C37CAP ELECT 10UF 100VDC066462C38CAP ELECT 10UF 100VDC066462C39CAP ELECT .47UF 50V066244C40CAP ELECT 220UF 50V 20%066254C41CAP ELECT 10UF 100VDC066462C44CAP ELECT 220UF 25V066507C47CAP POLYPROP .047UF 10% 250VDC064364C48CAP POLYPROP .047UF 10% 250VDC064364C50CAP ELECT 10UF 100VDC066462C51CAP ELE

47、CT 10UF 100VDC066462C200CAP ELECT 10UF 100VDC066462D1DIODE SILICON070047D2DIODE SILICON070047D4DIODE SILICON070047D5DIODE SILICON070047D6DIODE RECTIFIER070131D7DIODE RECTIFIER070131D8DIODE SILICON070047D9DIODE SILICON070047D11DIODE SILICON070047D12DIODE SILICON070047D13DIODE RECTIFIER070131D14DIODE

48、RECTIFIER070131IC1IC DUAL AMP133259IC2IC DUAL AMP133259J1CONN MALE 9 POS FRICTION LOCK 117244J2CONN 4 PIN117215J3CONN HEADER 2 PIN 0.156117404J4CONN HEADER 2 PIN 0.156117404J5BLADE FASTON .110117712J6BLADE FASTON W/FEET117708J8CONN HEADER 2 PIN 0.156117404J9CONN 2 PIN MALE117213J10CONN 2 PIN MALE117

49、213K1RELAY 24VDC 5A 277VAC087057K2RELAY 24VDC 5A 277VAC087057L1CHOKE 0.65UH OUTPUT122297L2CHOKE 0.65UH OUTPUT122297PARTS LIST cont384A4B4BLD1LDR NETWORK144179LD2LDR NETWORK144179Q1TRANSISTOR NPN132223Q2TRANSISTOR PNP132224Q3TRANSISTOR NPN132268Q4TRANSISTOR PNP132267Q5TRANSISTOR NPN132223Q6TRANSISTOR

50、 NPN132285Q7TRANSISTOR PNP132286Q8TRANSISTOR PNP POWER132297Q9TRANSISTOR NPN POWER132296Q10TRANSISTOR PNP POWER132297Q11TRANSISTOR NPN POWER132296Q12TRANSISTOR NPN132223Q13TRANSISTOR PNP132224Q14TRANSISTOR NPN132223Q15TRANSISTOR PNP132286Q16TRANSISTOR NPN132285Q17TRANSISTOR PNP132267Q18TRANSISTOR NP