Philips-AX530x-cd-sm 维修电路原理图.pdf

《Philips-AX530x-cd-sm 维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《Philips-AX530x-cd-sm 维修电路原理图.pdf（29页珍藏版）》请在收音机爱好者资料库上搜索。

1、PRODUCT FAMILY 2004 CDDA-5 SERIESTechnical specification .1-1Features and Accessories.1-2Connections and controls.1-3Instruction for use.1-4.1-7Safety & Warnings.1-8Handling chip components .1-9Service tools.1-9Service hintsRepair positions.2-1Dismantling CD-door .2-1Pin description of ICs .3-1.3-5S

2、ervice Test Program.3-6Blockdiagram.3-7Circuit diagramsControl/support part .4-1Audio part.4-2Drive/ESP part .4-3Layout diagramsComponentside view.4-4Copperside view.4-5Exploded view .5-1Mechanical partslist.5-1Electrical partslist .6-1.6-4 3140 785 32841Published by LX 0344 Service Audio Printed in

3、 The Netherlands Subject to modificationPortable Compact Disc PlayerCLASS 1LASER PRODUCTTABLE OF CONTENTSCopyright 2003 Philips Consumer Electronics B.V. Eindhoven, The NetherlandsAll rights reserved. No part of this publication may be reproduced, stored in a retrievalsystem or transmitted, in any f

4、orm or by any means, electronic, mechanical, photocopying,or otherwise without the prior permission of Philips.AX5301 AX5303 AX5305 AX5311 AX5312 all versionsversion1.1RadioFans.CN 收音机爱 好者资料库1 - 1TECHNICAL SPECIFICATIONGeneralDimensions (HxD):23.3x137.5 mmWeight without batteries:187gPower supply mo

5、desDC-in socket: 2.9 - 6.0VPrimary batteries (2xLR6): 2.0 - 3.6VRechargable batteries : 2.0 - 3.6VBattery lifetimeBattery level detectionCurrent consumption CDDA-playbackShock resistance+X/-X direction: 2.5 g+Y/-Y direction: 2.5 g+Z/-Z direction: 2 gHeadphone out (measured with 16 load, DBB/ESP off)

6、Output power (THD=10%)/17 version only: 2x8mW (+1/-3dB)all other versions: 2x4mW (+2/-2dB)Frequency response (1mW): 100Hz-20kHz within 6dBS/N ratio (unwght): 80dB (82dB typ.)S/N ratio (A-wght): 82dB (84dB typ.)THD+N (1kHz, 1mW): 1% (0.2% typ.)Channel crosstalk (1kHz, w/o load) :-24dB (-44dB typ.)Cha

7、nnel unbalance (-40dB): 5dBVolume attenuation (1kHz): 60dBDynamic Bass Boost DBBLaserOutput power: 5mW (3mW typ.)Wavelength: 780nmMeasurement setupCDUse Audio Signal disc SBC4294822 397 30184Low pass filterDUTS/N and distortion meterLRi.e. Sennheiser UPM550with FF-filterLevel meteri.e. Sound Technol

8、ogy ST1700Bi.e. 4822 395 3020422kHz13th orderEGATSBBDesnopserycneuqerFzH36zHk1zHk01DBB1+8dB2dB 0dB2dB 0dB2dBEDOMNOITAREPO)V5.4(YLPPUSNI -CD)V52.2(YLPPUS.TTABedom-ya lPA typ.m90edom-ChargeA typ.m220A typ.m80edom-pmuJA typ.m400A typ.m400yb-dnatSA typ.m06A typ.m110350A typ.A typ.m120PowersaveESP=ONPowe

9、rsaveESP=ONn/aEPYTYRETTAB 7h15h) .py th( ) .py th(Primary Batteries 2 x LR6Primary Batteries2 x AAARechargable BatteriesAY3363ESP=ONPSM 209h) .py th( 6 4h36) .py th() .py th(4015) .py th(12y tpmeyret taBV8.1Vm05- /001+V8.1Vm05- /001+1kaewyret taB+l eve ly tpmeyret tabV57.0Vm001+l eve ly tpmeyret tab

10、V7.0Vm0012kaewyret taB+l eve ly tpmeyret tabV54.0 Vm001+l eve ly tpmeyret tabV5.0Vm0013kaewyret taB+l eve ly tpmeyret tabV3.0Vm001+l eve ly tpmeyret tabV3.0Vm001DETECTION LEVELPrimary bateriesRechargable batteriesRadioFans.CN 收音机爱 好者资料库1 - 2AX5301/00CAX5301/01AX5301/05ZAX5303/00CAX5303/05ZAX5305/10A

11、X5311/17AX5312/17CD-RW COMPATIBILITYELECTRONIC SKIP PROTECTIONESP DRAM SIZE MbitHOLD / RESUME FUNCTION DBB STAGESACOUSTIC FEEDBACKPROGRAM MEMORYRECHARGE NiCd / NiMHBELT-CLIPCORD REMOTE CONTROLLINE / OPT. DIGITAL OUTPUT16/130-/-FEATURES OF CD-PORTABLE16/13016/13016/13016/13045s/13045s16/13045s16/130/

12、AX5301/00C/01/05Z/00C/05Z/10/17XXXXXAY3170/00 AC/DC AdaptorAY3170/02 AC/DC AdaptorAY3170/05 AC/DC AdaptorAY3170/10 AC/DC AdaptorAY3584/00 DC/DC AdaptorAY3150/00 Car Cassette Adaptor Car AdaptorAY3545/00 Pouch AY3363AY3363 Door-Battery-2A Battery-NIMH-AAA-BYD Battery-NIMH-AAA Remote ControlHE570/77s

13、Headphone HS383/77s Headphone (S-plug)X.supplied with the setACCESSORIES FOR CD-PORTABLE3140 118 319233140 118 320243140 118 336113140 118 321823140 118 719013140 118 715813140 118 329633140 113 108013103 308 845423103 308 847213140 117 669113139 128 730113140 118 515819082 100 018219082 100 01724XX

14、XXXXXXXXXXXXXXXXXXXXXXXXXXXXXX-/-45s45s45s45s45s16-/-/-/- -/-/-/-/-/-/-/-/-AX5305AX5311AX5303AX5312/17GR1-AX Mains plug adapterXXXXFEATURESACCESSORIES1 - 3STOPPROGRAMMODE/+repeat allshuffle resumeprogramDBBvolSTOPPROGRAMMODE/+repeat allshuffle resumeprogramDBBvolp13#4HOLD OFF5PLAY 2;6VOL!STOPPROGRAM

15、MODErepeat allshuffle resumeprogramDBBvol2STOPPROGRAMMODE/+repeat allshuffle resumeprogramDBBvol POWER SAVEESP ON/+/+1 .1 .2 .2 .+-+-OP/+- -+STOPPROGRAMMODE/+#!$%&11247509368repeat allshuffle resume programDBBvol POWER SAVEESP ONQUICKSTARTMISE EN SERVICE RAPIDE2CONNECTIONS AND CONTROLSEnglishCONTROL

16、SControls( see figure 1 )1 LINE OUT/p.3.5 mm headphone socket, socket to connect the player toanother audio input of an additional appliance, remote control socket (not on all versions)2 2;.switches the player on, starts or pauses CD play3 MODE.selects the different playing possibilities: shuffle,sh

17、uffle repeat all, repeat, repeat all and SCAN4 PROGRAM.programs tracks and reviews the program5 .display6.skips and searches CD tracks backwards7 .skips and searches CD tracks forwards8 STOP .stops CD play, clears a program or switches the player off9 DBB.switches the bass enhancement on and off. Th

18、is button alsoswitches acoustic feedback (the beep) on/off when it ispressed for more than 2 seconds0 VOL +/.adjusts the volume! 4.5V DC.socket for external power supply OPEN 2.opens the CD lid# ESP ON / POWER SAVE.to select between the battery powersave mode andElectronic Skip Protection (ESP). ESP

19、 ensures continuousCD playback regardless of vibrations and shocks$ OFF.switches RESUME and HOLD offRESUME.stores the last position of a CD track playedHOLD.locks all buttons on the set only% .typeplate .battery compartment& .AAA battery doorThis set complies with the radio interference requirements

20、 of the European Union.12345621 - 4Handling instructions Recharging already charged or half-charged batteries will shorten their lifetime. We therefore recommend that you let the rechargeable ECO-PLUSNiMH battery run till it is completely empty before you recharge it. To avoid a short circuit, do no

21、t let the battery touch any metal object. If the battery becomes empty soon after recharging, then either its contacts are dirty or it has reached the end of its lifetime.Mains adapter (supplied or optionally available)Use only the AY 3170 adapter (4.5 V / 300 mA direct current, positive pole to the

22、 center pin). Any other productmay damage the player.1 Make sure the local voltage corresponds to the poweradapters voltage.2 Connect the power adapter to the 4.5V DC socket ofthe player and to the wall socket.Note: Always disconnect the adapter when you are not using it.Environmental information Al

23、l redundant packing material has been omitted. We have done our utmost tomake the packaging easily separable into two mono materials: cardboard (box)and polyethylene (bags, protective foam sheet). Your set consists of materials which can be recycled if disassembled by a specialized company. Please o

24、bserve the local regulations regarding the disposal of packing materials, exhausted batteries and old equipment.POWER SUPPLY / GENERAL INFORMATIONAverage playing time of batteries under normal conditionsBattery typeESP onPower SaveNormal AA10 hours20 hoursNormal AAA6 hours12 hoursAlkaline AA24 hours

25、42 hoursAlkaline AAA10 hours16 hoursRechargeable ECO-PLUS NiMH battery8.5 hours13 hoursBatteries contain chemical substances, so they should be disposed of properly.ECO-PLUS NiMH battery information (for versions supplied with the rechargeable ECO-PLUS NiMH battery AY 3363)Recharging works only on p

26、layers supplied with the rechargeable ECO-PLUSNiMH battery AY 3363.Recharging the ECO-PLUS NiMH battery on board1 Insert the rechargeable ECO-PLUS NiMH battery AY 3363.2 Connect the mains adapter to the 4.5V DC socket of the player and then to the wall socket.yis pulsing. Recharging stops after a ma

27、ximum of 7 hours, orwhen you start playback.3 When the battery is fully recharged, FULL appearsin the display.Notes: It is normal for the batteries to become warm during recharging. If the batteries become too warm, recharging will be interrupted forapproximately 30 minutes . Toensure proper recharg

28、ing on board, take care that contacts are clean. Use only the ECO-PLUS NiMH battery AY 3363.Batteries (supplied or optionally available)For convenience, this model is designed with 2 different detachable battery doors.This allows you to operate the player using 2 choices of battery size. You can use

29、the following batteries with this CD-player: alkaline batteries type AAA (LR03, UM4) or AA (LR6, UM3) preferablyPhilips.Notes: Old and new or different types of batteries should not be combined. Remove batteries if they are empty or if the player is not going to be used fora long time.Inserting AAA

30、(LR03, UM4) or AY 3363 batteries1 Open the AAA battery door.2 Insert AAA batteries as shown onto the back of thedoor.3 Replace the battery-loaded AAA door back onto theset.Inserting AA (LR6, UM3) batteriesTo double playback time, insert AA batteries into the bat-tery compartment and use the AA marke

31、d battery door. Open the battery compartment and insert either 2 normal or alkaline batteries.Battery indicationThe approximate power level of your batteries is shown in the display.Battery fullBattery two-thirds fullBattery one-third fullBattery dead or empty. When the batteries aredead or empty, t

32、he symbol flashes, bAttis displayed, and the beep tone sounds repeatedly.+-+-AA SIZELR6 / UM34.5V DC- -+LR03/AAA /UM4+AAA (LR03, UM4)AA (LR6, UM3)CONTROLS / POWER SUPPLYRemote ControlAY 3785 ( see figure 2 )1 p.3.5 mm headphone plug to connect to headphones socket2 2;.switches the set on, starts pla

33、yback and interrupts playback3 9.stops playback and switches the set off4 / .skips and searches forward / backward tracks5 HOLD.locks all buttons (on the remote control only)6 VOLUME +/-.adjusts the volumeConnecting the remote controlUse the AY 3785 cord remote control.The buttonson the remote contr

34、ol have the same functions asthe corresponding buttons on the set.1 Press 9 twice to switch off the set.2 Firmly connect the remote control to LINEOUT/p on the set.3 Firmly connect the headphones to the plug onthe remote control.4 On the remote control press 2; to switch on the set and to start play

35、back.5 Adjust the volume on the CD player or your remote control.Notes: Check the HOLD switch on the remote control is adjusted to the offposition if you wish to operate the player using the remote control.pSTOPPROGRAMMODE/+repeat allshuffle resumeprogramDBBvolINSTRUCTION FOR USE1 - 5GENERAL INFORMA

36、TIONCD player and CD handling Do not touch the lens A of the CD player. Do not expose the unit, batteries or CDs to humidity,rain, sand or excessive heat (caused by heatingequipment or direct sunlight). You can clean the CD player with a soft, slightly dampened, lint-free cloth. Do not use any clean

37、ingagents as they may have a corrosive effect. To clean the CD, wipe it in a straight line from thecenter toward the edge using a soft, lint-free cloth. Acleaning agent may damage the disc! Never write on a CD or attach a stickerto it. The lens may cloud over when the unit is moved suddenly from col

38、d to warmsurroundings. Playing a CD is not possible then. Leave the CD player in a warmenvironment until the moisture has evaporated. Active mobile phones in the vicinity of the CD player may cause malfunctions. Avoid dropping the unit as this may cause damage.Headphones HE570 Connect the supplied h

39、eadphones to the LINE OUT/psocket of the player.Note: LINE OUT/p can also be used for connecting this set to your HiFi system.To adjust thesound and volume, use the controls on the connectedaudio equipment and on the CD player.IMPORTANT!Hearing safety: Do not play your headphones at a high volume. H

40、earing experts advisethat continuous use at high volume can permanently damage your hearing.Traffic safety: Do not use headphones while driving a vehicle. It may create a hazardand it is illegal in many countries. Even if your headphones are an open-air typedesigned to let you hear outside sounds, d

41、o not turn up the volume so high that youcannot hear what is going on around you.CD PLAYPlaying a CDThis CD-player can play all kinds of Audio Discs suchas CD-Recordables and CD-Rewritables. Do not try toplay a CD-ROM, CDi, VCD, DVD or computer CD.1 Push the OPEN 2 slider to open the player.2 Insert

42、 an audio CD, printed side up, by pressing theCD onto the hub. 3 Close the player by pressing the lid down.4 Press 2; to switch the player on and start playback.yThe current track number and elapsed playingtime are displayed. You can pause playback by pressing 2;.yThe time at which playback was paus

43、ed startsflashing. You can continue playback by pressing 2; again.5 Press STOP to stop playback.yThe total number of tracks and the total playingtime of the CD are displayed.6 Press STOP again to switch the player off. To remove the CD, hold it by its edge and press thehub gently while lifting the C

44、D.Note: If there is no activity, the set will automaticallyswitch off after a while to save energy.+In-car use (connections supplied or optionally available)Only use the AY 3545 or AY 3548 car voltage converter (4.5 V DC, positive pole tothe centre pin) and the AY 3501 car cassette adapter. Any othe

45、r product may dam-age the set.1Put the set on a horizontal, vibration-free andstable surface. Make sure it is in a safe place,where the set is neither a danger nor an obstacle to the driver and the passengers.2Plug the voltage converter into the cigarette lighter socket (only for 12 V car battery, n

46、egative grounding), then connectthe wired end with 4.5V DC input socket on theset.3If necessary, clean the cigarette lighter socket to obtain a good electrical contact.4Turn down the volume and connect the cassette adapter plug to LINE OUT/pon the set.5Carefully insert the cassette adapter into the

47、car radios cassette compartment.6Make sure the cord does not hinder your driving.7Decrease the volume on the set if necessary. Start playback on the set andadjust the sound with the car radio controls. Always remove the voltage converter from the cigarette lighter socketwhen the set is not in use.No

48、te: If your car radio has a LINE IN socket, it is better to use it for the car radio connection instead of the adapter cassette. Connect the signallead to this LINE IN socket and to LINE OUT/p on the set.4,5 V DC12 V DCSTOPPROGRAMMODE/+repeat allshuffle resume programDBBvolOP/+STOPrepeat allshuffle

49、resumePlayback information If a CD-Recordable (CD-R) or a CD-Rewritable (CD-RW) is not recorded properly, NF dISC isdisplayed, indicating that the CD has not been finalized. In that case, use FINALIZE on your CDrecorder to complete the recording. When playing a CD-Rewritable (CD-RW), please notethat

50、 it takes 315 seconds after pressing 2; forsound reproduction to start. Playback will stop if you open the CD lid. While the CD is read, 1 -:- flashes in the display.Volume and bassVolume adjustment Adjust the volume by using VOL/+/+on the CD playeror your remote control.Bass adjustment Press DBB to