JVC-CSBB2J-sub-sm 维修电路原理图.pdf

《JVC-CSBB2J-sub-sm 维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《JVC-CSBB2J-sub-sm 维修电路原理图.pdf（21页珍藏版）》请在收音机爱好者资料库上搜索。

1、SERVICE MANUALCOPYRIGHT 2006 Victor Company of Japan, LimitedNo.MA2522006/3ACTIVE SUBWOOFER SYSTEMMA25220063CS-BB2J, CS-BB2ULead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade)TABLE OF CONTENTS1PRECAUTION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

2、. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-32SPECIFIC SERVICE INSTRUCTIONS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-33DISASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

3、 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-34ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-55TROUBLESHOOTING . . . . . . . . . . . . . . . . . .

4、. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-5RadioFans.CN 收音机爱 好者资料库1-2 (No.MA252)SPECIFICATIONDesign and specifi cations are subject to change without notice.TypeClosed Active Subwoofer (Built-in amplifi er)Speaker Unit14 cm (5-9/16 in.) coneInp

5、ut TerminalLINE IN (1 system), 0.19 V/25 kSPEAKER (1 system), 3.7 VPower Output32 W RMS x 2 channels at 2 and or = 1% THD + NSignal-to-Noise Ratio75 dBA (reference: 1 W into 2 )Maximum Amplifi er Power Output60 W + 60 W (Impedance 2 + 2 )Cut-off Frequency110 Hz (L.P.F. switch ON, -12 dB/oct low pass

6、 fi lter)Crossover Frequency20 Hz to 200 Hz (L.P.F. switch ON)20 Hz to 500 Hz (L.P.F. switch OFF)Sound Pressure Level88 dB/ m (with line input: 0.03 V)Level Control-50 dB to 0 dB (Center) to + 10 dBPower RequirementDC 14.4 V (11 V to 16 V allowance), Negative groundDimensions (W/H/D)290 mm 60.5 mm 2

7、00 mm (11-7/16 in. 2-7/16 in. 7-7/8 in.)Mass2.1 kg (4.7lbs) (Excluding accessories)RadioFans.CN 收音机爱 好者资料库(No.MA252)1-3SECTION 1PRECAUTION1.1Safety PrecautionsSECTION 2SPECIFIC SERVICE INSTRUCTIONSThis service manual does not describe SPECIFIC SERVICE INSTRUCTIONS.SECTION 3DISASSEMBLY3.1Removing the

8、 almi plate (See fig.1)(1) Remove the six screws A, two screws B and one screw Cattaching the almi plate.(2) Remove the almi plate from main body.Fig.1!Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair o

9、f this system.AABCalmi plate1-4 (No.MA252)3.2Removing the main board (See fig.2 to 4) Remove the almi plate.(1) Remove the five screws D and one screw D attaching themain board. (See fig.2)(2) Remove the one screw E attaching the main board. (Seefig.3)(3) Take out the main board, and then remove the

10、 wire fromspeaker terminal. (See fig.4)Reference:When attach the screw D, spring and washer are attachedwith screw D. (See fig.2)Caution:When reassembly, wire should connect as same as before dis-assembly. (See fig.4)3.3Removing the speaker (See fig.4) Remove the almi plate. Remove the main board.(1

11、) Remove the base cabinet.(2) Remove the four screws F attaching the speaker.(3) Shift up the speaker and take out.Fig.2Fig.3Fig.4DDDDwasherbase cabinetspacermain boardspringEupper cabinetFFFbase cabinetwire (white)wire (blue)spacerspeaker(No.MA252)1-5SECTION 4ADJUSTMENTThis service manual does not

12、describe ADJUSTMENT.SECTION 5TROUBLESHOOTING5.110 PIN CORD DIAGRAM1.BL/WH2.YL3.BK4.WH/BK5.GY/BK6.NC7.YL8.BK9.WH10.GYREMOTE OUT OR POWER LEADPOWER LEADGROUNDTO L CHANNELSPEAKER OUTPUTTO R CHANNELSPEAKER OUTPUTTO ANPLEFIER ORRECEIVERTO ANPLEFIER ORRECEIVER1 BL/WH2 YL7 YL3 BK8 BK9 WH4 WH/BK10 GY5 GY/BK

13、BKBLWHGYYLBlackBlueWhiteGrayYellowRRRear RightFRFront RightFLFront LeftRLRear LeftREMOTERemote OutGNDGroundMEMORYMemory Backup Battery+REMOTEMEMORYGNDFL+FL-FR+FR-(No.MA252)Mobile Entertainment Business Group Mobile Entertainment Category 10-1,1chome,Ohwatari-machi,Maebashi-city,Gumma-ken, 371-8543,J

14、apanVictor Company of Japan, LimitedVPTPrinted in Japan3-1PARTS LIST* All printed circuit boards and its assemblies are not available as service parts.- Contents - Exploded view of general assembly and parts list (Block No.M1) Electrical parts list (Block No.01) Packing materials and accessories par

15、ts list (Block No.M3)CS-BB2J,CS-BB2U3-23-43-6MA2523-2Exploded view of general assembly and parts listAABBMain boardBlock No.MMM127272725252515169928243017262612172134310516322424353120768231132219172182941133143-3General AssemblyBlock No. M1MMSymbol No.Part No.Part NameDescriptionLocal 1LV10905-003A

16、BASE CABINET 2LV34988-001ASPACER 3LV10906-002AUPPER CABINET 4LV43784-002AINPUT LABEL 5LV43801-001ASPACER(x2) 6LV43801-003ASPACER 7LV43801-002ASPACER 8LE10014-019ASPEAKER 9QYSBSF4010ZATAP SCREWM4 x 10mm(x4) 10WJJ0473-001A-EE-SI C WIRE C-C 11LV43938-001ACUSHION(x2) 12LV10907-002AUPPER COVER 13LV34921-

17、004AGRILL ASSY 14LV43801-004ASPACER(x2) 15LV43801-005ASPACER(x2) 16LV43801-001ASPACER(x2) 17QYSDSF3016ZATAP SCREWM3 x 16mm(x8) 18LV43955-001AWASHER 19GN40028-001ALEAF SPRING 20QYSDSF3008MATAP SCREWM3 x 8mm 21LV34922-001AALMI PLATE 22LV34923-002ASPACER 23LV43803-001ASPACER(x2) 24QYSDSF4045NATAP SCREW

18、M4 x 45mm(x6) 25LV43785-001ASPECIAL SCREW(x4) 26GN30007-016ASPACER(x4) 27LV43785-001ASPECIAL SCREW(x4) 28QYSDSP4008MASCREWM4 x 8mm 29QYSDSP3008MASCREWM3 x 8mm(x2) 30LV37031-001ANAME PLATE 31QYSDSF3010MATAP SCREWM3 x 10mm(x2) 32GN40036-001AIC BRACKET 33LV34929-001ASUB HEATSINK 34QYSDSP3012ZASCREWM3 x

19、 12mm(x2) 35LV34991-001ASW BLACKET3-4Electrical parts listMain boardBlock No. 01Symbol No.Part No.Part NameDescriptionLocalIC101NJM4580LICIC301NJM2777DICIC311NJM4580LICIC321NJM4580LICIC331NJM4580LICIC511NJM78M08FAICIC701TDA8560QICQ5112SB1322/RS/-TTRANSISTORQ512DTC144ESA-TDIGI TRANSISTORQ601DTA144ESA

20、-TDIGI TRANSISTORQ602DTC144ESA-TDIGI TRANSISTORQ603DTC144ESA-TDIGI TRANSISTORQ604DTA144ESA-TDIGI TRANSISTORQ7012SD1302/ST/-TTR.IMD301MTZJ10A-T2Z DIODED302MTZJ4.7A-T2Z DIODED5011N5401-F64DIODED5111SS133-T2SI DIODE I/MD5121SS133-T2SI DIODE I/MD513MTZJ10A-T2Z DIODED6011SR139-400-T2SI DIODED602MTZJ3.6A-

21、T2ZENER DIODE IMD6031SS133-T2SI DIODE I/MD6041SS133-T2SI DIODE I/MD801SLR-342MC-TLEDD802SLR-342MC-TLEDC101QEKJ1EM-106ZE CAPACITOR10uF 25V MC102QEKJ1EM-106ZE CAPACITOR10uF 25V MC103QCFB1HZ-104YC CAPACITOR0.1uF 50V ZC104QCFB1HZ-104YC CAPACITOR0.1uF 50V ZC105QDYB1CM-103YC CAPACITOR0.01uF 16V MC106QEKJ1

22、HM-474ZE CAPACITOR0.47uF 50V MC107QEKJ1HM-474ZE CAPACITOR0.47uF 50V MC201QEKJ1EM-106ZE CAPACITOR10uF 25V MC202QEKJ1EM-106ZE CAPACITOR10uF 25V MC203QCFB1HZ-104YC CAPACITOR0.1uF 50V ZC204QCFB1HZ-104YC CAPACITOR0.1uF 50V ZC205QDYB1CM-103YC CAPACITOR0.01uF 16V MC206QEKJ1HM-474ZE CAPACITOR0.47uF 50V MC20

23、7QEKJ1HM-474ZE CAPACITOR0.47uF 50V MC210QEKJ1CM-476ZE CAPACITOR47uF 16V MC301QEKJ1EM-106ZE CAPACITOR10uF 25V MC302QEKJ1CM-226ZE CAPACITOR22uF 16V MC303QEKJ1EM-106ZE CAPACITOR10uF 25V MC304QEKJ1EM-106ZE CAPACITOR10uF 25V MC310QEKJ1CM-476ZE CAPACITOR47uF 16V MC311QEKJ1HM-105ZE CAPACITOR1uF 50V MC312QE

24、KJ1HM-475ZE CAPACITOR4.7uF 50V MC313QEKJ1HM-475ZE CAPACITOR4.7uF 50V MC314QEKJ1HM-475ZE CAPACITOR4.7uF 50V MC320QEKJ1CM-476ZE CAPACITOR47uF 16V MC321QFV61HJ-104ZMF CAPACITOR0.1uF 50V JC322QFV61HJ-104ZMF CAPACITOR0.1uF 50V JC323QFV61HJ-104ZMF CAPACITOR0.1uF 50V JC324QFV61HJ-104ZMF CAPACITOR0.1uF 50V

25、JC330QEKJ1CM-476ZE CAPACITOR47uF 16V MC331QFV61HJ-473ZMF CAPACITOR0.047uF 50V JC332QFV61HJ-563ZMF CAPACITOR0.056uF 50V JC333QFV61HJ-183ZMF CAPACITOR0.018uF 50V JC334QFV61HJ-124ZMF CAPACITOR0.12uF 50V JC340QEKJ1CM-476ZE CAPACITOR47uF 16V MC501QETM1CM-338E CAPACITOR3300uF 16V MC502QDX31EM-104ZC CAPACI

26、TOR0.1uF 25V MC503QFV61HJ-104ZMF CAPACITOR0.1uF 50V JC504QFV61HJ-103ZMF CAPACITOR0.01uF 50V JC511QEKJ1CM-107ZE CAPACITOR100uF 16V MC512QDX31EM-104ZC CAPACITOR0.1uF 25V MC513QDX31EM-104ZC CAPACITOR0.1uF 25V MC514QEKJ1CM-107ZE CAPACITOR100uF 16V MC521QEKJ1CM-107ZE CAPACITOR100uF 16V MC601QEKJ1AM-227ZE

27、 CAPACITOR220uF 10V MC602QEKJ1HM-105ZE CAPACITOR1uF 50V MC603QEKJ1HM-105ZE CAPACITOR1uF 50V MC604QETM1EM-108E CAPACITOR1000uF 25V MC605QEKJ1EM-106ZE CAPACITOR10uF 25V MC701QDX31EM-473ZC CAPACITOR0.047uF 25V MC702QEKJ1HM-475ZE CAPACITOR4.7uF 50V MC703QFV61HJ-334ZMF CAPACITOR0.33uF 50V JC704QFV61HJ-33

28、4ZMF CAPACITOR0.33uF 50V JR101QRE141J-102YC RESISTOR1k 1/4W JR102QRE141J-102YC RESISTOR1k 1/4W JR103QRE141J-102YC RESISTOR1k 1/4W JR104QRE141J-474YC RESISTOR470k 1/4W JR105QRE141J-104YC RESISTOR100k 1/4W JR106QRE141J-102YC RESISTOR1k 1/4W JR107QRE141J-222YC RESISTOR2.2k 1/4W JR108QRE141J-102YC RESIS

29、TOR1k 1/4W JR109QRE141J-273YC RESISTOR27k 1/4W JR110QRE141J-104YC RESISTOR100k 1/4W JR111QRE141J-104YC RESISTOR100k 1/4W JR112QRE141J-224YC RESISTOR220k 1/4W JR113QRE141J-224YC RESISTOR220k 1/4W JR114QRE141J-102YC RESISTOR1k 1/4W JR201QRE141J-102YC RESISTOR1k 1/4W JR202QRE141J-102YC RESISTOR1k 1/4W

30、JR203QRE141J-102YC RESISTOR1k 1/4W JR204QRE141J-474YC RESISTOR470k 1/4W JR205QRE141J-104YC RESISTOR100k 1/4W JR206QRE141J-102YC RESISTOR1k 1/4W JR207QRE141J-222YC RESISTOR2.2k 1/4W JR208QRE141J-102YC RESISTOR1k 1/4W JR209QRE141J-273YC RESISTOR27k 1/4W JR210QRE141J-104YC RESISTOR100k 1/4W JR211QRE141

31、J-104YC RESISTOR100k 1/4W JR212QRE141J-224YC RESISTOR220k 1/4W JR213QRE141J-224YC RESISTOR220k 1/4W JR214QRE141J-102YC RESISTOR1k 1/4W JR302QRE141J-104YC RESISTOR100k 1/4W JR304QRE141J-473YC RESISTOR47k 1/4W JR305QRE141J-102YC RESISTOR1k 1/4W JR306QRE141J-203YC RESISTOR20k 1/4W JR311QRE141J-104YC RE

32、SISTOR100k 1/4W JR312QRE141J-223YC RESISTOR22k 1/4W JR313QRE141J-223YC RESISTOR22k 1/4W JR314QRE141J-223YC RESISTOR22k 1/4W JR315QRE141J-104YC RESISTOR100k 1/4W JR316QRE141J-223YC RESISTOR22k 1/4W JR317QRE141J-104YC RESISTOR100k 1/4W JR318QRE141J-104YC RESISTOR100k 1/4W JR319QRE141J-104YC RESISTOR10

33、0k 1/4W JR321QRE141J-433YC RESISTOR43k 1/4W JR322QRE141J-363YC RESISTOR36k 1/4W JR323QRE141J-104YC RESISTOR100k 1/4W JR324QRE141J-153YC RESISTOR15k 1/4W JR331QRE141J-682YC RESISTOR6.8k 1/4W JR332QRE141J-682YC RESISTOR6.8k 1/4W JR333QRE141J-303YC RESISTOR30k 1/4W JR334QRE141J-303YC RESISTOR30k 1/4W J

34、R336QRE141J-102YC RESISTOR1k 1/4W JR511QRE141J-103YC RESISTOR10k 1/4W JR512QRE141J-472YC RESISTOR4.7k 1/4W JR521QRE141J-472YC RESISTOR4.7k 1/4W JR522QRE141J-562YC RESISTOR5.6k 1/4W JR601QRE141J-102YC RESISTOR1k 1/4W JR602QRE141J-473YC RESISTOR47k 1/4W JR603QRE141J-101YC RESISTOR100 1/4W JR604QRE141J

35、-102YC RESISTOR1k 1/4W JR605QRE141J-154YC RESISTOR150k 1/4W JR606QRE141J-473YC RESISTOR47k 1/4W JR607QRE141J-472YC RESISTOR4.7k 1/4W JR701QRE141J-103YC RESISTOR10k 1/4W JR702QRE141J-222YC RESISTOR2.2k 1/4W JR703QRE141J-152YC RESISTOR1.5k 1/4W JR801QRE141J-392YC RESISTOR3.9k 1/4W JSymbol No.Part No.P

36、art NameDescriptionLocal3-5R802QRE141J-104YC RESISTOR100k 1/4W JVR801QVQ0294-Z24V RESISTORL501QQR0703-001CHOKE COILCJ101QNN0068-001JACK ASSYCJ301QNS0240-0013.5 JACKCN101QGA4201F2-10CONNECTOR W-B (1-10)CN301QGB2022K1-06CONNECTOR B-B (1-6)CN401QGB2022K2-06CONNECTOR B-B (1-6)CN701QGA3901C1-04CONNECTOR

37、W-B (1-4)CN801QGA2001C1-03CONNECTOR W-B (1-3)S401QSW0991-001SLIDE SWITCHS402QSW0991-001SLIDE SWITCHS801QSW0799-001PUSH SWSymbol No.Part No.Part NameDescriptionLocal3-6Packing materials and accessories parts listBlock No.MMM3No additional / supplemental order of WARRANTY CARDs are available.P3P4P2P6P

38、8P7P5P9P6P1A9A10A5A4A11A12A6,A7,A8A1,A2,A13,A14,A15CS-BB2JA1,A2,A3CS-BB2U3-7Packing and AccessoriesBlock No. M3MMSymbol No.Part No.Part NameDescriptionLocalA 1LVT1544-001AINST BOOKENGA 2LVT1544-002AINST BOOKSPA FREBB2JA 2LVT1544-003AINST BOOKCHI(TAIWAN) TAIBB2UA 3LVT1544-004AINST BOOKARA PERBB2UA 4R

39、M-RK80CREMOTE CONTROLLERA 5QAM0650-002CAR CABLEA 6GN40033-001AMAGIC TAPE(x4)A 7LV41413-001ADOUBLE FACEA 8QZW0004-001WIRE CLAMPA 9QYSDSA4016MATAP SCREWM4 x 16mm(x4)A 10QYSSSA4020MATAP SCREWM4 x 20mm(x4)A 11LV43826-001ASTAY(x4)A 12LV41298-002ACAUTION LABELA 13-WARRANTY CARDBT-51018-4BB2JA 14BT-51034-2

40、J=REGIST CARDBB2JA 15-WARRANTY CARDBT-52006-2BB2JP 1LV36780-002ACARTONP 2LV21719-001ACUSHION(L)P 3LV21720-001ACUSHION(U)P 4QPC04003515PPOLY BAG40cm x 35cmP 5QPA01503505POLY BAG15cm x 35cmP 6QPC02503515PPOLY BAG25cm x 35cmP 7QPA00701005POLY BAG7cm x 10cmP 8QPA00701005POLY BAG7cm x 10cmP 9QPA00701005P

41、OLY BAG7cm x 10cmContentsBlock diagramStandard schematic diagramsPrinted circuit boards2-22-32-5 to 6CD-ROM No.SML200603SCHEMATIC DIAGRAMSACTIVE SUBWOOFER SYSTEMNo.MA252SCH2006/3CS-BB2J,CS-BB2UCOPYRIGHT 2006 Victor Company of Japan, Limited.Lead free solder used in the board (material : Sn-Ag-Cu, me

42、lting point : 219 Centigrade)2-1!Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair of this system.Safety precaution2-2IC101 -1IC101 -2INPUT AMP.PHASESELECTCN301IC321IC331 -1IC331 -2H.P.FL.P.FIC701 POWER

43、AMP.CN701CJ101CN401S402PHASE SWL.P.F. SWS401IC301 E.VOL (V.C.A) PHASEIC311 -1IC311 -2Q604 Q701 MUTECN101LINE INBATTERYSPEAKER(CAR CABLE)8VREG.IC511Q601 to Q603STAND BY+8VCJ301CN801S801 BOOST SWVR801 LEVELSPEAKERBlock diagram2-3Parts are safety assurance parts.When replacing those parts makesure to u

44、se the specified one.C304D602R113R213R111R110R211R210C106C103D512C107C206C207CJ301R802IC101( 1/2) IC101( 1/2) CN101R103R101R102R202R201R203IC301R114S801VR801R214C104CN801D511D802D801R801R302L501R304R336IC301IC511Q512Q511C203C204R315R312C311ICJ101C101D601R109C604C511R209C102R522R521C201R108R208C105C2

45、05R306R212R112R104R204R205C210C202D302R305C512D513C513R105C514C521D301C501D501C502C303C310C302R311R512R511C503C504R106R206R107R20710/16MTZJ3.6A-T1S220k220k100k100k100k100k0.47/500.11SS133-T20.47/500.47/500.47/50QNS0240-001100kNJM4580LNJM4580LQGA4201F2-101k1k1k1k1k1kNJM2777D1kQSW0799-001QVQ0294-Z241k

46、0.1QGA2001C1-031SS133-T2SLR-342MC-TSLR-342MC-T3.9kQAM0477-001100kQQR0703-00147k1kN10/16NJM78M08FADTC144ESA-T2SB1322/RS/-T0.10.1100k22k1/50NQNN0068-00110/161SR139-400-T227k1000/25100/1627k10/165.6k4.7k10/161k1k0.010.0120k220k220k470k470k100k47/1610/16MTZJ4.7A-T21k0.1MTZJ10A-T20.1100k100/10100/10MTZJ1

47、0A-T23300/161N5401-F640.110/1647/1622/16100k4.7k10k0.10.011k1k2.2k2.2k!Standard schematic diagram2-4IC701D602D603C703C704CJ301CN701S401CN301Q701CN401D802D801R801R332R334R701R702Q604IC311( 1/2) R601Q601Q602R602R605S402R324R331C334R322C321C322C323C324C332R333IC321( 1/2) IC331( 1/2) IC321( 1/2) IC331(

48、1/2) Q603R315R312C312C314IC311( 1/2) C313R316R313R314D601C604R317R318C701R319C702R703R606C605R607D604R311C602R604C601C603R321R323C340C330C333C331R603C320TDA8560QMTZJ3.6A-T21SS133-T20.330.33QNS0240-001WJJ0473-001AQGA3901C1-04QSW0991-001QGB2022K1-062SD1302/ST/-TQGB2022J1-06SLR-342MC-TR-342MC-T3.9k6.8k

49、30k10k2.2kDTA144ESA-TNJM4580L1kDTA144ESA-TDTC144ESA-T47k150kQSW0991-00115k6.8k0.1236k0.10.10.10.10.05630kNJM4580LNJM4580LNJM4580LNJM4580LDTC144ESA-T100k22k4.7/254.7/25NJM4580L4.7/2522k22k22k1SR139-400-T21000/25100k100k0.047100k4.7/25100/101.5k47k10/164.7k1SS133-T2100k1/501k220/101/5043k100k47/1647/1

50、60.0180.04710047/162-5Printed circuit boardMain boardLead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade)C101C102C103C104C105C106C107C201C202C203C204C205C206C207C210C301C303C304C501C502C503C504C603C604C701C702C703C704CJ101CN101CN701D301D501D511D512D601D602IC101IC7