Airline-05BR-3021-3024-3027-Sams-150-3电路原理图.pdf

《Airline-05BR-3021-3024-3027-Sams-150-3电路原理图.pdf》由会员分享，可在线阅读，更多相关《Airline-05BR-3021-3024-3027-Sams-150-3电路原理图.pdf（18页珍藏版）》请在收音机爱好者资料库上搜索。

1、PHOTOFACT* Folder AIRLINE MODELS O5BR-3O21B, O5BR-3O24B, O5BR-3O27A VOLUME CONTROL ON-OFF SWITCH BRIGHTNESS HOLDf CONTROL CONTROL CONTROL CHANNEL TUNING CONTROL AIRLINE MODEL 05BR-3027A TRADE NAME Airline, Models 05BR-3021B, 05BR-3024B, 05BR-3027A SUPPLIER Montgomery Ward Co., 619 Chicago Ave., Chic

2、ago, Illinois TYPE SET Television Receiver TUBES Twenty One POWER SUPPLY 1 10-115 Volts AC-60 Cycle TUNING RANGEChannels 2 Thru 13 RATING 1. 8 Amp. 115 Volts AC INDEX Alignment Instructions 6, 7 Disassembly Instructions 10 Photographs (cont.) Chassis - Top View. Horizontal Sweep Circuit Adjustments

3、10 Parts List and Description 12, 13, 15 RF Tuner Resistor and Inductor Identification. Photographs Cabinet - Rear View. 10 Schematic Tube Placement Charts Capacitor and Alignment Identification 4, 9 Voltage and Resistance Measurements . 3 7 .11, 14 2 5 8 o Ul OB 70 I) O KJ 2? 8s O m DO 70 CO O to H

4、OWARD W. SAMS AC Voltage measured at 1,000 a_e reoejjnqs 2. Pin numbers are counted in a clockwise direc- tion on bottom of socket. 3. Measured values ore from socket pin to com- mon negative unless otherwise stated. 5. Front panels controls set at minimum. 6. Where readings may vary according to th

5、e setting of the service controls, both minimum and maximum readings are given. RadioFans.CN VERT LINEARITY CONTROL VERT COURSE PHONO SIZE HORIZ SWITCH CONTROL HOLD Fl HORIZ HORIZ LINEARITY SIZE (ITI IBS CABINET-REAR VIEW HORIZONTAL SWEEP CIRCUIT ADJUSTMENTS Turn the set on and tune in a TV staion,

6、preferably a test pattern. Turn the horizontal hold, fine, (front panel), to the mid-position of its range. Adjust the horizontal hold control, coarse slug, (Bl), (rear of chassis), to the center of the range over which the picture synchronizes horizontally. Adjust the horizontal drive trimmer, (B2)

7、, counter-clockwise until a fold over, (bright vertical line)appears in the picture. Then turn the trimmer clockwise until the fold over disappears and then one half turn additional. Adjust the horizontal size slug, (B3), until the picture is slightly wider than necessary to fill the mask horizontal

8、ly. Adjust the horizontal linearity slug, (B4), until the picture is symmetrical from left to right. Slight readjustment of B2 may be necessary for optimum linearity. DISASSEMBLY INSTRUCTIONS 1. Remove three push-on type control knobs and channel pointer. 2. Remove four wood screws from rear cover.

9、Remove rear cover. 3. Disconnect built-in antenna. 4. Disconnect speaker. 5. Remove five metal screws from chassis. Remove chassis. 6. Remove two 5/10 hex nuts from speaker. Remove speaker. NOTE: - FOR PICTURE TUBE REMOVAL IT IS NECESSARY TO REMOVE THE CHASSIS AS OUTLINED ABOVE. PAGE 10 RadioFans.CN

10、 Fi6 CHASSIS BOTTOM VIEW-RESISTOR PAGE 14 RadioFans.CN o m O K) O 55 Ui i- 00 7 75 CJ _, 0 I K O 0 OB m n1 O w Ul DO 73 I CO o IO s AND INDUCTOR IDENTIFICATION PAGE 11 RadioFans.CN PARTS LIST TUBES (SYLVANIA or Equivalent) ITEM No. VI V2A B V3 V4 V5 V6 V7 V8A B V9 V10 VU V12 V13 V14 V15 V16 vn V18 V

11、19 V20 USE RF Amplifier Converter Converter 1st. Video IF Amp. 2nd. Video IF Amp. 3rd. Video IF Amp. 4Ui. Video IF Amp. Video Detector- DC Restorer Video Amplitier Video Amplifier AGC Amplifier Sound IF Amplifier Ratio Detector- AF Amplifier Audio Output 3ync. Separator- Sync. Amplifier Vert. Amplif

12、ier - Vert. Oscillator Horiz. Phase Discr. Horiz. Mult. Horiz. Output Damper HV Rectifier LV Rectifier REPLACEMENT DATA AIRLINE PART No. 6AG5 6J6 12AT7 6AU6 6AU6 6AU6 6AU6 6AL5 12AT7 12AU7 6AU6 6AU6 6T8 6K6GT 6SN7GT 6SN7GT 6AL5 6SN7GT 6BG6G 6W4GG 1X2 5U4G STANDARD REPLACEMENT 6AG5 616 12AT7 6AU6 6AU

13、6 6AU6 6AU6 6AL5 12AT7 12AU7 6AU6 6AU6 6T8 6K6GT 6SN7GT 6SN7GT 6AL5 6SN7GT 6BG6G 6W4GT 1X2 4U4G RMA BASE TYPE 7BD 7BF 9A 7BK 7BK 7BK 7BK 6BT 9A 9A 7BK 7BK 9E 7S 8BD 8BD 6BT 8BD 5BT 4CG 7CB 5T NOTES CATHODE-RAY TUBE ITEM No. V 21 REPLACEMENT DATA AIRLINE PART No. 12LP4A SYLVANIA PART No. 12LP4A THOMA

14、S PART No. 12LP4A (B RTMA BASE TYPE NOTES D Use single magnet ion trap. CAPACITORS Capacity values given in the rating column are in mfd. for Electrolytic and Paper Capacitors, and in mmfd. for Mica and Ceramic Capacitors. ITEM No. CIA B C C2A B C C3 C4 C5 C6 C7 C8 C9 CIO Cll C12 C13 C14 CIS C16 C17

15、 CIS C19 C20 C21 C22 C23 C24 C25 C26 C27 C28 C29 C30 C31 C32 C33 C34 C35 C36 C37 C38 C39 C40 C41 C42 C43 C44 C45 C46 C47 C48 C49 C50 C51 C52 C53 C54 C55 C56 C57 RATING CAP. 30 60 10 30 30 125 8 5 10 10 10 8 220 5000 1000 15 1000 4.7 1000 .5 1.5 2.2 2.2 51 2.5 7 51 220 1000 7 1000 5000 100 1000 1000

16、.1 1000 1000 47 1000 1000 1000 47 1000 1000 1000 47 1000 1000 1000 1000 5 22 1000 68 .01 .1 .1 3.3 .004 5000 VOLT 450 450 450 450 450 25 450 50 50 50 150 450 500 200 500 500 500 500 400 400 400 400 REPLACEMENT DATA AIRLINE PART No. A-8C-17845 A-8C-18487 A-8C-13453 A-8C-11751 A-8C-17183 A-8C-17183 A-

17、8C-11495 A-8C-13453 C-8G-16045 A-8G-13962 C-8G-13201 C-8G-13201 C-8G-13201 A-8G-12495-7 A-8G-12495-4 A-8G-12495-4 A-8G-11891 C-8G-15737 C-8G-15224 A-8G-11891 C-8G-16045 C-8G-13201 C-8G-15224 C-8G-13201 A-8G-13962 C-8F3-8 C-8G-13201 C-8G-13201 C-8D-10770 C-8G-13201 C-8G-13201 C-8F3-109 C-8G-13201 C-8

18、G-13201 C-8G-13201 C-8F3-109 C-8G-13201 C-8G-13201 C-8G-13201 C-8F3-109 C-8G-13201 C8G-13201 C8G-13201 C-8G-13201 C-8G-12166 C-8G-13201 c -en-m C-8D-10761 C-8D-10760 C-8D-10760 A-8G-12495-5 C-8D-17958 A-8G-13962 AEROVOX PART No. AFH3666J AF644J PRS25/100 PHS450/8 PRS150/4 PRS50/10 PHS50/10 PRS150/12

19、 PHS450/8 SI220 BPD-005 SI1000 SI1000 SI4 . 7NPO S11000 SI1.5NPO SI6.8NPO SI51 SI220 SI1000 SI6 . 8 NPO SI1000 BPD-005 1468-0001 SI1000 SI1000 P288-1 3UOOO 511000 1469-00005 illOOO SI1000 SI1000 1468-00005 SI1000 SI1000 SI1000 1468-00005 SI1000 SI1000 SI1000 SI1000 SI5NPO S11000 1469-00007 P488-01 P

20、488-1 P488-1 S13.3NPO P688-004 BPD-005 CENTRALAB PART No. D6-221 DD-502 D6-102 TC2-15 D6-102 TCZ-4.7 D6-102 TCZ-.5 TCZ-1.5 TC2-2.2 TCZ-2.2 TCN-51 TCZ-6.8 TCN-51 D6-22I D6-102 TCZ-6.8 D6-102 DD-502 D6-101 D6-102 D6-102 DF-104 D6-102 D6-102 D6-470 D6-102 D6-102 D6-102 D6-470 D6-102 D6-102 D6-102 D6-47

21、0 D6-102 D6-102 D6-102 D6-102 TCZ-22 D6-102 D6-680 D6-103 DF-104 DF-104 TCZ-3.3 D6-402 DD-502 CORNELL- DUBILIER PART No. UPT36145 UPT409 BR845A BH550 BR105 BR105 BH1015 BR845A 1W5D1 1D5D5 1W5T1 1W5D1 1W5D1 PTE4P1 1W5D1 1W5D1 5R5Q5 1W5D1 1W5D1 1W5D1 5H5Q5 1W5D1 1W5D1 1W5D1 5R5Q5 1W5D1 1W5D1 1W5D1 1W5

22、D1 1W5D1 5R5Q7 PTE4S1 PTE4P1 PTE4P1 PTE6D4 1D5D5 ERIE PART No. GP2K-221 811-005 GP2L-102 NPOK-150 GP2L-102 NPOK-4R7 GP2L-102 NPOK-OR5 NPOK-1H5 NPOK-2R2 NPOK-2H2 N750K-510 NPOK-6R8 GP1K-510 GP2K-220 GP2L-102 NPOK-6R8 GP2L-102 811-005 GP1K-101 GP2L-102 GP2L-102 GP2L-102 GP2L-102 GP1K-470 GP2L-102 GP2L

23、-102 GP2L-102 GP1K-470 GP2L-102 GP2L-102 GP2L-102 GP1K-470 GP2L-102 GP2L-102 GP2L-102 GP2L-102 NPOK-050 NPOK-220 GP2L-102 GP1K-680 GP2-333-103 NPOK-3R3 GP2-333-402 811-005 SPRAGUE PART No. TVL-3790 TVL-3741 TVA-1207 TVA-1704 TVA-1303 TVA-1304 TVA-1304 TVA-1406 TVA-1704 5GA-T22 5HK-D5 5HK-D1 5TCC-Q15

24、 5HK-D1 5HK-D1 5GA-Q5 5GA-T22 5HK-D1 5HK-D1 5HK-D5 1FM-31 5HK-D1 5HK-D1 2TM-P1 5HK-D1 5HK-D1 MS-45 5HK-D1 5HK-D1 5HK-D1 MS-45 5HK-D1 5HK-D1 5HK-D1 MS-45 5HK-D1 5HK-D1 5HK-D! 5HK-D1 5TCC-Q22 5HK-D1 MS-47 4TM-S1 4TM-P1 4TM-P1 6TM-D4 5HK-D5 IDENTIFICATION CODES AND INSTALLATION NOTES . Filter Filter A

25、Decoupling . Filter Audio Output Dec. * Vert. Amp. Cathode Decoupling AGC Filler Audio Output cathode Stabilizing Cap. Decoupling Decoupling RF Coupling RF Amp. Cathode RF Amp. Screen Fixed Trimmer t RF Bypass Fixed Trimmer # RF Bypass RF Coupling RF Coupling Osc. Coupling Osc. Coupling Osc . Feedba

26、ck Osc. Grid Cap. Fixed Trimmer Mixer Cathode Conv. Fil. RF Bypass Fixed Trimmer Conv. Plate Dec. RF Bypass IF Coupling AGC Filter AGC Filter AGC Filter 1st. Video IF Dec. 1st. Video IF Fil. IF Coupling AGC Filter 2nd. Video IF Dec. 2nd. Video IF Fil. IF Coupling AGC Filter 3rd. Video IF Dec. 3rd. V

27、ideo IF Fil. IF Coupling 4th. Video IF Plate 4th. Video IF Screen 4th. Video IF Cathode 4th. Video IF HI. Video Diode Filter Fxed Trimmer Video Del. Fil. Video Coupling Video Coupling Video Coupling Picture Tube Cathode Sound IF Coupling Sound IF Decoupling Sound IF Cathode ITEM No. C58 C59 C60 C61

28、C62 C63 C64 C65 C66 C67 C68 C69 C70 C71 C72 C73 C74 C75 C76 C77 C78 C79 C80 C81 C82 C83 C84 CBS C86 C87 C88 C90 RATING CAP. 5000 5 470 2000 .01 .02 .01 .01 .005 470 .1 .01 .005 .02 .05 .25 470 680 220 680 220 .02 .002 3900 220 680 .001 22 .1 .1 .5 1000 VOLT 500 200 200 200 400 600 500 200 400 600 40

29、0 400 400 500 500 500 500 500 600 600 500 500 500 400 400 200 200 500 REPLA AIRLINE PART No. A-8G-13962 C-8F3-121 C-8D-11738 C-8D-17268 C-8D-U738 C-8D-10761 C-8D-10935 C-8F3-121 C-8D-10770 C-8D-10761 C-8D-10935 C-8D-10774 C-8D-14461 C-8D-13439 C-8F3-121 C-8F3-123 C-8F3-117 C-8F3-123 C-8F3-117 C-8D-1

30、7268 C-8D-10778 C-8F11-132 C-8F3-117 C-8F3-123 C-8D-12020 C-8G-11892 C-8D-17990 C-8D-10770 C-8D-H270 C-8F6-125 AEROVOX PART No. BPD-005 SIS 1469-0005 SI2000 P488-01 P488-02 P488-01 P488-01 P4 88-005 1469-0005 P288-1 P488-01 P688-005 P488-02 P488-05 P488-25 469-0005 479-0007 1469-00025 1479-0007 1469

31、-00025 P688-02 P688-002 1464-004 1469-00025 1479-0007 P688-001 P488-1 P288-1 P288-5 1468-001 CEN PAf DD- D6- D6- D6-1 DF- D6-1 D6-) D6-! D6- DF- D6-I D6-1 DF- DF- D6- D6-I D6-: D6- D6- DF- D6- D6- D6- D6- D6- TC1 DF DF- D6- t Some models use 4.7MMF Mfgrs. Part # t Some models use I2MMF Mfgrs. Part #

32、 ( if Some models use 4MMF Mfgrs. Part # C ft Some models use 470MMF Mfgrs. Part # tt Some models use .01MF Mfgrs. Part H C #0 Some models use . 05MF Mfgrs. Part # C Not used in all models. cTE4S1 TE4S2 TE4S1 TE4S1 TE6D5 .R5T5 TE4P1 TE4S1 JTE6D5 TE4S2 TE4S5 1T4P25 H5T5 R5T7 R5T25 2H5T7 5R5T25 PTE6S2

33、 PTE6D2 1DR5D4 5R5T25 2H5T7 PTE6DI PTE4P1 PTE4P1 3T2P5 1W5D1 ERIE PART No. 8U-005 GP1K-050 GP2K-471 GP2-333-202 GP2-333-103 GP2-333-103 GP2-333-103 GP2-333-502 GP2K-471 GP2-333-103 GP2-333-502 GP2K-471 GP2K-681 GP2K-221 GP2K-681 GP2K-221 GP2-333-202 GP2-333-402 GP2K-221 GP2K-681 GP2L-102 N750K-220 G

34、P2L-102 SPRAGUE PART No. 5HK-D5 MS-35 5HK-D2 4TM-S1 2TM-S2 4TM-S1 4TM-S1 6TM-D5 MS-35 2TM-P1 4TM-S1 6TM-D5 4TM-S2 4TM-S5 4TM-P25 MS-35 MS -37 MS-32 MS-37 MS-32 6TM-S2 6TM-D2 MS-24 MS-32 MS-37 6TM-D1 5TCU-Q22 4TM-P1 2TM-P1 2TM-P5 1FM-21 IDENTIFICATION CODES AND INSTALLATION NOTES RF Bypass Balancing

35、Cap. Diode Load Cap. De-emphasis Audio Coupling Tone Comp. * Audio Coupling Audio Coupling Audio Output Platett Sync. Coupling Sync. Coupling Sync. Sep. Plate Vert. Sync. Coupling Integrator Net. Vert. Discharge Vert. Sweep Coupling Horiz. Sync. Coupling Voltage Divider Horiz. Jeedback Voltage Divid

36、er Horiz. Feedback AFC Filter AFC Filter Fixed Trimmer Horiz. MV Feedback Horiz. Discharge Horiz. Sweep Coupling Horiz. Feedback Horiz. Output Screen Fixed Trimmer # Horiz. Sweep Coupling RF Bypass 1495-6 in this application. 05 in this application. 3 in this application. ;2 in this application, il

37、in this application. fO in this application. OLS CENTRALAB PART No. SBBT-617-S AN-31 AK-4 AN-40 AK-4 AN-10 AK-1 AN-69 AK-1 AN-31 AK-4 INSTALLATION NOTES Contrast Control - Front Volume Control and SW - Tapped 100KS2 - Rear Brightness Control Attach to R2A per instructions Vert. Hold Control Attach t

38、o R3A per instructions Vert. Linearity Control Attach toR4A per instructions Vert. Size Control Attach toR5A per instructions Horiz. Hold Control Attach to R6A per instructions ORS IDENTIFICATION CODES LL RESISTORS * 10% UNLESS OTHERWISE SPECIFIED ntenna Isolation ntenna Coil Shunt F Amp. Grid F Amp

39、. Cathode F Amp. Screen F Coil Shunt lixer Grid onv. Cathode He. Grid sc. Plate anisitic Suppressor arasitic Suppressor e coupling GC Network ;t. Video IF Amp. Grid ,t. Video IF Amp. Cathode ;t. Video IF Amp. Decoupling GC Network id. Video IF Amp. Grid id. Video IF Amp. Cathode id. Video IF Amp. De

40、coupling GC Network d. Video IF Amp. Grid d. Video IF Amp. Cathode d. Video IF Amp. Decoupling h. Video IF Transformer Shunt h. Video IF Amp. Cathode h. Video IF Amp. Screen h. Video IF Amp. Plate Decoupling h Video IF Transformer Shunt ideo Det. Diode Load 3C Network 3C Network 3C Network jltage Di

41、vider Restorer Diode Load deo Amp. Plate deo Arnp. Plate iltage Divider RESISTORS CCONTO ITEM No. R46 R47 H48 R49 R50 R51 H52 H53 H54 R55 H56 R57 R58 R59 R60 R61 R62 R63 R64 R65 R66 R67 R68 R69 R70 R71 R72 R73 R74 R75 R76 R77 R78 R79 R80 R81 R82 R83 R84 BBS R86 R87 R88 R89 R90 R91 R92 R93 R94 R95 H9

42、6 R97 R98 R99 R100 RATING RESISTANCE 5600S! 2 . 2Meg loon 4700S2 20% 1000! 1200! 68KS! 22KI2 100K! 1000! 220KSJ 120! 2200SJ 22KH 20% 27Kn 20% 47KIJ lOMeg 20% 220K! 470Kn 20% 680S1 10KS! 4.7Meg 68KS! 8200S2 2.2Meg 47KO 5% 56KB l.SMeg 220Kf! 220Kt! 3900S! 470KO 5% 47K IMeg 1000! 2200! 470KSJ 150KS2 15

43、0K.O 2.2Meg 2.2Meg 68KS! 20% 1500H 5600S! 100KS! 220KS! 220! 470KB 68000 680KS! 20% 2.21 5600! 560on 5600S! 470KS! 5% Note 1 Not ugec WAns iI | 2 10 10 I f 2 . 2 a I Z i. I f 2 2 I 1 z 2 I 2 I | I f Z 2 I z 1 1 I ? f 1 2 2 2 2| REPLACEMENT DATA AIRLINE PART No. C-9B2-71 L-9B1-102 C-9B1-50 C-9B4-70 C

44、-9C14-1099 C-9C14-1100 C-9B1-84 C-9B1-78 C-9B1-86 C-9B1-62 C-9B1-90 C-9B1-51 C-9B1-66 C-9B1-78 C-9B1-82 C-9B1-37 C-9B1-90 C-9B1-94 C-9B2-60 C-9B1-74 C-9B1-106 C-9B4-84 C-9B1-73 C-9B1-102 C-9B2-82 C-9B1-83 C-9B1-100 C-9B1-90 C-9B1-90 C-9B1-69 C-9B1-94 C-9B1-82 C-9B1-98 C-9B1-62 C-9B1-66 C-9BI-94 C-9B

45、1-88 C-9B1-88 C-9B1-102 C-9B1-102 C-9B1-84 C-9B1-64 C-9B2-71 C-9B1-86 C-9B1-90 C-9B1-54 C-9B1-94 C-9B2-72 C-9B1-96 C-9C1-1067 C-9B4-71 C-9B4-71 C-9B4-71 C-9B1-94 IRC PART No. BTA-5600 BTS-2.2Meg BTS-100 BTB-9700 1 3/4A-1000 1 3/4A-1200 BTS-68K BTS-22K BTS-100K BTS-1000 BTS-220K BTS-120 BTS-2200 BTS-

46、22K BTS-27K BTS-47K BTS-lOMeg BTS-220K BTS-470K ETA-680 BTS-10K BTS-4.7Meg BTB-68K BTS-8200 BTS-2.2Meg BTA-47K-5% BTS-56K BTS-1.5Meg BTS-220K BTS-220K BTS-3900 BTS-470K-5% BTS-47K BTS-IMeg BTS-1000 BTS-2200 BTS-470K BTS-150K BTS-I50K BTS-2.2Meg BTS-2.2Meg BTS-68K BTS-1500 BTA-5600 BTS-100K BTS-220K

47、BTS-220 BTS-470K BTA-6800 BTS-680K. BTB-5600 BTB-5600 BTB-5600 BTS-470K-5% IDENTIFICATION CODES Decoupling Video Amp. .Grid Video Amp. Cathode Video Amp. Plate Voltage Divider - Wire Wound Voltage Divider - Wire Wound Voltage Divider Picture Tube Grid Picture Tu be Cathode Ace Anode Sound IF Transfo

48、rmer Shunt Sound IF Amp. Cathode Sound IF Amp. Decoupling Ratio Det. Diode Load De-emphasis - See Note 2 Tone Compensation - See Note 1 AF Amp. Grid AF Amp. Plate Output Grid Output Cathode Isolation Sync. Sep. Grid Sync. Sep. Plate Voltage Divider Sync. Amp. Grid Sync. Amp. Plate Integrator Vert. O

49、sc. Grid Vert. Osc. Plate Vert. Osc. Plate Vert. Peaking Voltage Divider Voltage Divider Vert. Amp. Grid Vert. Amp. Cathode Dampling Horiz. Feedback Network - See Note 3 Horiz. Phase Det. Diode Load Horiz. Phase Det. Diode Load Horiz. Phase Det. Diode Load Horiz. Phase Det. Diode Load Horiz. AFC Filter Horiz. MV Cathode Horiz. MV Plate Horiz. MV Grid Horiz. MV Plate Parasitic Suppressor Horiz. Output Grid Horiz. Output Screen Horiz . Feedback Network HV Rectilier Filament Decoupling Voltage Divider Decoupling Isolation in all models. Note 2 Some models use 10K&