Emerson-571-606-611-612-619-620-624-627-Sams-76-11电路原理图.pdf

《Emerson-571-606-611-612-619-620-624-627-Sams-76-11电路原理图.pdf》由会员分享，可在线阅读，更多相关《Emerson-571-606-611-612-619-620-624-627-Sams-76-11电路原理图.pdf（26页珍藏版）》请在收音机爱好者资料库上搜索。

1、PHOTO FACT* Folder EMERSON MODELS 571, 6O6, 611, 612, 619, 62O, 624, 627 CONTRAST CONT. FINE TUNING VOL. CONT. ON-OFF SW. BRIGHTNESS HORIZ. HOLD VERT. HOLD CONT. CONT. CONT. CHANNEL SELECTOR TRADE NAMEEmerson Models 571 and 606 (Ch. 120086B), 606, 611, 612 and 624 (Ch. 120087B-D), 619 (Ch. 120092D),

2、 620 (Ch. 120091D), 620 (Ch. 120091QD), 627 (Ch. 120107B). MANUFACTURER Emerson Radio and Phono Corp., Ill Eighth Ave., New York 11, New York TYPE SET Television Receiver TUBES Twenty Eight (Models using 25Z6 Rectifiers) Twenty Three (Models using Selenium Rectifiers) POWER SUPPLY 105-125 Volts AC 6

3、0 Cycle FREQ. RANGE Channels 2 thru 13 RATING: 1.66 Amp. 117 Volts AC (Selenium Rect. Models). Alignment Instructions Block Diagram Horizontal Oscillator Adjustments Parts List and Description Photographs Cabinet-Rear View Capacitor Identification Chassis-Top View RF Tuner 470452-S RF Tuner 470320 I

4、NDEX 7,8,9,10 Photographs (continued) 17 RF Tuner 470233 14 24 Resistor Identification 16,21 18,19,20 Trans., Inductor and Alignment Identification 4,13 24 Schematic (Main) 2 15,22 Schematic and Parts List (Tuner 470320) 6 3,17 Schematic and Parts List (Tuner 470233) 23 10 Tube Placement Chart 5 11

5、Voltage and Resistance Measurements 12 HOWARD W. SAMS 87.75MC 77.25M2 81.75MC 67 . 25MC 71.75MC 61.25MC 65.75MC bb.25MC 59.75MD CHANNEL 13 7 8 9 10 11 12 6 5 4 3 2 CONNECT SCOPE Vert. top. to Polnt Low side to chassis. ADJUST A301-, A302, A303, A304 A305, A306 A307, A308, A309, A310 REMARKS Adjust f

6、or approximately response shown In Fig 9 with markers appear- ing at more than 70% of peak ampli- tude. Keep RF and mixer trimmer pairs in approximately same relative position. Adjust rings for wave form as per Tig 9. Check response on all high- band channels . SLIGHT adjustments of A301, A302, A303

7、, A304, A305 and A306 may be required to obtain op- timum response on all channels. Adjust for approximate response as shown In Fig 9. Check response on all low band channels. SLIGHT adjustments of A307, A308, A309 and A310 may be necessary to obtain optimum res- ponse on all channels. PAGE 8 RadioF

8、ans.CN 14. 15. 16. 10. 11. 12, 13 OSCILLATOR ALIGNMENT (TUNER NO. 470320) Fine tuning control should be set at the mid position of its range. DUMMY ANTENNA Two 1502 carbon res. ti SWEEP GENERATOR COUPLING To antenna termin- als with 1502 In each lead. SWEEP GENERATOR FREQUENCY 216MC (10MC Sweep ) 88

9、MC (10MC Sweep) 82MC (10MC Sweep) 721* (10MB Sweep) 66MC (10MC Sweep) 60MC (lOrK Sweep) 210MC (10MC Sweep) 204MC (lOrK Sweep) 19811; (10MC Sweep) 192MC (10MC Sweep) 186M3 (10MC Sweep) 180MC (10MC Sweep ) MARKER GENERATOR FREQUENCY 25.P5MC 25.75MO 25.751E CHANNEL 13 6 5 4 5 2 12 11 10 9 8 7 CONNECT V

10、TVM C Probe to Point Common to ssis. ADJUST A311 A312 REMARKS Adjust for zero reading. Check to see that all other channels are received well within the range or the fine tuning control. If not, compromise may be made using A311 for high channels and A312 for low channels . RF AND MIXER ALIGNMENT (T

11、UNER NO. 470233) It is recommended that the RF and Mixer circuits not be aligned unless definitely known to be out of adjustment and then only if proper test equipment Is available. The sweep generator output lead should be terminated with Its characteristic Impedance, usually 50 ohms. Keep the RF a

12、nd Mixer slug pairs at approximately the same relative position. DUMMY ANTENNA Two 120S2 carbon res . SWEEP GENERATOR COUPLING Across antenna ter- minals with 120S2 In each lead. ti SWEEP GENERATOR FREQUENCY 213MC (10MC Sweep) 207MC (10MC Sweep) 201MC (10MC Sweep) 195MC (10MC Sweep) 189MC (10MC Swee

13、p) 183MC (10MC Sweep) 177MC (10MC Sweep) 85MC (10I1C Sweep ) 79MC (10MC Sweep) 69MC (10IC Sweep) 63MC (10MC SweepJ 57MC (10MC Sweep) MARKER GENERATOR FREQUENCY 211.25MC S15.75MC 205.25MC 809.75MC 199.25MC 203.75MC 193.25MC 197.75MC 187.25MC 191.75MC 181.25MC 185.75MC 175.25MC 179.75MC 83.25MO 87.75M

14、C 77.25MC 81.75MC 67.25MC 71.75MC 61.25MC 65.75MC 55.25MC 59.75MC CHANNEL 13 12 11 10 9 8 7 6 5 4 3 2 CONNECT SCOPE Vert . Amp . thru 10K52 to Polnt Low side to chas- sis. ADJUST A601, A602, A603, A604 A605, A606, A607, A608 REMARKS Adjust for response curve as per Fig 9 with markers above t m PC o

15、ui 10 M FIG. 9 PAGE 9 RadioFans.CN OSCILLATOR ALIGNMENT (TUNfcK NO. 470233) 14. 15. it,. 17. 18. 19. 20. 21 23. 34. 25, Set the fine tuning control approximately 140 from Its fully counter-clockwise position. This aliens the holes In drive disc with the adjustment screws on the oscillator wafer of t

16、he channel switch. Do not change this setting during oscillator alignment. DUMMY ANTENNA rwo 120S2 carbon res . it it SWEEP GENERATOR COUPLING Across antenna ter- minals with 120S2 In each lead. w it SWEEP GENERATOR FREQUENCY 216MC (10M3 Sweep ) 210MC done Sweep) 204MC (10MC Sweep) 198I1C (10MC Swee

17、p) 192MC (10N3 Sweep) 186MC (10MC Swe ep ) 180MC (10MC Sweep) 88MC (10MC Sweep) 82M3 (10MC Sweep) 72IC (10MC Sweep) 66MC (10MC Sweep) 60110 (10MC Sweep) MARKER GENERATOR FREQUENCY 25.75M3 ; CHANNEL 13 12 11 10 9 8 7 6 4 Z Z CONNECT VTVM f Probe to Point Common to assls. tt ADJUST A609, A610 A611 A61

18、2 A613 A614 A615 A616 A617, A618 A619 A620 A621 A622 REMARKS Adjust for zero reading. A positive and negative reading will be obtain- ed on either side of the correct setting. Keep oscillator slug pairs at approximately the same relative position. Adjust for zero reading as outlined on step 14. Adju

19、st for zero reading as outlined In step 14. Keep oscillator slug pairs at approximately the same relative position. Adjust for zero reaoing as outllnec In step 14. n RF TUNER PAGE 10 RadioFans.CN RF TUNER-LF.FT SIDE RF TUNER-RIGHT SIDE PAGE 11 RadioFans.CN o VOLTAGE AND RESISTANCE MEASUREMENTS VOLTA

20、GE READINGS RESISTANCE READINGS Item V 1 V 2 V 4 V 5 V6 V7 V8 V9 V 10 V I 1 V12 V 13 V 14 V15 V16 V 17 V18 V19 V20 V21 V22 V28 V29 V30 Tube 6AG5 6J6 6AG5 6AG5 6AU6 6AL5 6AU6 12AU7 6BA6 6AU6 6S8GT 6V60T 12AU7 6SN70T 6SN7GT 6K6GT 6AL5 6SN7GT 6B06R 5V4G 1B3GT 10BP4 Pin 1 -.4VDC 70VDC -.4VDC - . 4VDC 0V

21、 0V -.2VDC 225VDC 0V -.4VDC -.4VDC 0V 100VDO #.2VDC -135VDC 0V #-9VDC I-50VDC 0V 0V Pin 2 ov 105VDC .5VDO .3VDC OV -.4VDC 2VDC -1.4VDC OV OV OV OV -1.5VDC *240VDC -75VDC -220VDC OV I-.9VDC *260VDC OV 270VDC Pin 3 6.3VAC 6.3VAC OV OV OV OV OV OV OV OV -.9VDC 16SVDO OV I9.6VDC -OV -205VDC OV *OV -BVDC

22、 ov Pin 4 OV OV 6.3VAC S.3VAO 6.3VAC 6.3VAC S.3VAC OV 6.3VAC 6.3VAC -.5VDC 150VDO OV I-.2VDC -135VDC 205VDC 6.3VAC *-50VDC OV 175VDC Pin 5 87VDO -1.9VDC 120VDC 130VDC 160VDC OV 125VDC OV 115VDC 12SVDC -.2VDC -2.4VDC OV M7.5VDC 280VDC -14VDC *-1.2VDC I260VDC -19VDC OV Pin 6 87VDC S-3.4VDC 120VDC 120V

23、DC 160VDC OV 125VDC 42VDC 125VDC 41VDC 75VDC -8.4VDC 45VDC I.8VDC -OV -5VDO -60VDC lov *OV OV 175VDC Pin 7 OV OV .5VDC .3VDC 1.6VDC -.3VDC 2VDC OV 1.2VDC OV 6.3VAC 6.3VAC -.7VDC 6.3VAC 6.3VAC 6.3VAC I-1.3VDC 6.3VAC 6.3VAC OV Pin 8 3.5VDO OV OV OV OV OV -5VDC -60VDC OV -240VDC 270VDC Pin 9 6.3VAC TOP

24、 CAP -.6VDC 6.3VAC TOP CAP * DO NOT MEASURE 0V2.7VDC PIN 10 240VDC PIN 11 130VDC PIN 12 6.3VAC Item V 1 V 2 V 4 V 5 V 6 V7 V 8 V9 V 10 V 1 1 V 12 V13 V 14 V 15 V16 V 17 V 18 V 19 V20 V21 V22 V2S V29 V30 Tube 6AG5 6J6 6AG5 SAGS 6AU6 6AL5 6AU6 12AU7 6BAS 6AU6 6S8GT 6V6GT 12AU7 6SN7GT 6SN7GT 6K6GT 6AL5

25、 6SN7GT 6BG6G 5V4G 1B3GT 10BP4 Pin 1 3.2 MfiS- T6K2 3.2 Mee 3.2 Mee 2.52 Iffl 1 Meg. T14.5K2 42 100K2 100K2 02 tllKffl 1 MeK. 1.5Meg. Inf. Inf. 150K2 Inf. Inf. Inf. Offl Pin 2 02 tSKffl 682 332 Offi 2.2 Meg lOOOffl 1 Meg. Offl 02 OS Offl 180K2 T7K2 I2.5Meg t470Kffi OS Inf. T4.7K2 02 T7.5K2 Inf. t700

26、KH Pin 3 .12 .12 02 OS! 02 02 02 02 02 02 100KS T500S2 02 4.5Kffl 42002 TlOKffl 02 .1502 13002 Inf. Inf. PIN 10 3.5K2 Pin 4 02 02 .Ifl .12 .12 .12 .12 02 .IK .12 Inf. T11K2 02 Inf. l.SMeg. TlOKffi .12 ISOKffi Inf. T1502 Inf. PIN 11 SKffi Pin 5 T4K2 220K2 T1.6K2 T1.6K2 T 10002 .58 T2K2 Offl T1.6K2 T1

27、.6K2 200K2 470KS2 02 tlOOKH T100K2 4.7Meg. 150K2 T470K2 470K2 Inf. Inf. PIN 12 .12 Pin 6 T4K2 lOKffl T1.6K2 tl.6KS! TlOOOffl 02 T6002 118K2 T1.6K2 T6.5K2 T470KS 2002 T18KS 4.5K2 1200S 17K2 12K2 41502 41502 42002 T1502 Inf. Pin 7 02 02 682 332 1502 4.7K2 10002 02 682 02 .12 .12 1 Meg. .12 .12 .12 150

28、KS2 .12 .12 Inf. Inf. Pin 8 470K2 02 02 Offl 02 02 10K2 4.5K2 02 TlOKffl t7.5Kfl Inf. Pin 9 .12 TOP CAP 15 Meg. .12 TOP CAP T7.5K2 TOP CAP 3602 Taken with vacuum tube voltmeter. I Measured from pin 6 of V18 * Measured from pin 6 of V16 T Measured from pin 4 of M8. * -Measured from pin 8 of V21. Meas

29、ured from pin 7 of MS. 1. DC Voltage measurements are at 20,000 4. Line voltage maintained at 117 volts for volt- ohms per volt; AC Voltage measured at 1,000 age readjngs_ 2. Pin numbers are counted in a clockwise direc- tion on bottom of socket. 3. Measured values are from socket pin to com- mon ne

30、gative unless otherwise stated. 5. Front panels controls set at minimum. 6. Where readings may vary according to trie setting of the service controls, both minimum and maximum readings are given. RadioFans.CN RF TUNER-LEFT SIDE RF TUNER-RIGHT SIDE PAGE 14 RadioFans.CN aovd /0-M3IA IAIO11O9 SISSVHO I

31、KJ 9C3 oeo) eeo ezo RadioFans.CN EMERSON MODELS 571, 6O6, 611, 612,619,620,624, 627 g L_ I- LJ Q cr o o RadioFans.CN I p o CD CO CO K) O BLOCK DIAGRAM CHASSIS-TOP VIEW PAGE 17 RadioFans.CN TUBES (SYLVANIA or Equivalent) PARTS LIST ANI CAPACITO ITEM No. VI V2 V4 V5 V6 V7 V8 V9 V10 Vll V12 V13 V14 V15

32、 V16 V17 V18 V19 V20 V21 V22 V23 V24 V25 V26 V27 V28A B C USE RF Amp . Converter 1st Video IF 2nd Video IF 3rd Video IF Video Det.-AGC Rect. 1st Video Amp. 2nd Video Amp.- Sync. Sep. -DC Restorer Sound IF Amp . Llmlter Disc.-AF Amp. Audio Output 1st and 2nd Sync. Amp. -Sync Clipper 3rd Sync. Amp.- H

33、or. Phase Inv. DC Amp . Vert. Osc. Vert. Output Hor. Phase Det. Hor. Osc. and Disch. Hor . Output Damper HV Rectifier Rectifier Rectifier Rectifier Rectifier Rectifier Picture Tube Picture Tube Picture Tube REPLACEMENT DATA EMERSON PART No. 800535 800536 800535 800535 800533 800541 800533 800026 800

34、531 800533 800015 800270 800026 800380 800380 800016 800541 800380 800004 800011 800450 800480 800480 800480 800480 800480 810000 STANDARD REPLACEMENT 6AG5 6J6 6AG5 6AG5 6AU6 6AL5 6AU6 12AU7 6BA6 6AU6 6S8GT 6V6GT 12AU7 6SN7GT 6SN7GT 6K6GT 6AL5 6SN7GT 6BG6G 5V4G 1B3GT 25Z6GT 25Z6GT 25Z6GT 25Z6GT 252

35、6GT 10BP4 12LP4 12QP4 RMA BASE TYPE 7BD 7BF 7BD 7BD 7BK 5BT 7BK SA 7BK 7BK 8CB 7AC 9A 8BD 8BD 7S 6BT 8BD 5BT 5L 3C 7Q 7Q 7Q 12D 12D 12D NOTES - Chassls 120086B only. Chassis 120086B, 120087B-D, 120092D only. Chassis 120091D, 120107B only. Chassis 120091QD only. CAPACITORS Capacity values given in th

36、e rating column are in mfd. for Electrolytic and Paper Capacitors, and in mmfd. for Mica and Ceramic Capacitors. ITEM No. CIA B C2A B C3A C D C4A B C D C5A B C6A B C C7 C8A B C9A B CIO Oil 012 CIS C14 015 C16 017 CIS 019 C20 021 022 023 C24 C25 C26 027 028 C29 030 C31 C32 033 C34 035 C36 C37 038 039

37、 040 041 042 C43 044 RATING CAP. 80 80 80 80 80 80 80 80 80 80 80 1000 1000 60 60 80 80 80 80 80 80 8 8 8 8 8 10 1000 1000 .05 5 1000 120 100 10 20 1000 1000 10 100 270 1500 5000 1500 1500 270 75 1500 1500 270 1500 1500 30 .1 .05 200 VOLT 150 175 150 150 300 300 300 300 300 300 350 350 15 15 300 350

38、 250 300 300 250 300 250 250 350 250 250 250 50 400 300 500 500 500 200 400 500 REPLACEMENT DATA EMERSON PART No. 925128 925099 925099 925098 925129 925086 925131 925096 925097 925134 925091 925132 925133 925093 925133 925093 925111 925114 925111 925111 925111 925072 928006 928006 922101 910015 9280

39、06 928006 928006 910015 928006 928006 910015 928006 928006 910290 923067 923062 910028 AEROVOX PART No. WN16D WN16D AFN16D AFH1616G AFH1616G AF200200P AF10J AFH16G AFH16G AFH16G PRS250/8 PRS350/8 PRS250/8 PRS250/8 PRS250/8 PRS50/10 1468-001 1468-001 P488-05 1468-00025 1467-0015 1467-005 1467-0015 14

40、67-0015 1468-00025 1469-000075 1467-0015 1467-0015 1468-00025 1467-0015 1467-0015 P288-1 P488-05 1468-0002 CORNELL- DUBILIER PART No. UP7AJ474 UP4AJ 1005 UP4AJ 1005 UP8830 UP8830 UP10BJ 1059 UP8030 UP8030 UP8030 UP8030 BR825 BR835 BR825 BR825 BR825 BR105 1W5D1 1W5D1 GT4S5 5W5T25 1W5D15 1D5D5 1W5D15

41、1W5D15 5W5T25 1W5D15 1W5D15 5W5T25 1WSD15 1W5D15 5W5Q3 GT2P1 GT4S5 5W5T2 ERIE PART No. GP2L-001 GP2L-001 NPOK-5 GP2L-001 GP2K-120 GP1K-100 NPOK-10 NPOK-20 GP2L-001 GP2L-001 NPOK-10 GP1K-100 GP2K-270 GP2L-0015 GP2M-005 GP2L-0015 GP2L-0015 GP2K-270 NPOM-75 GP2L-0015 GP2L-0015 GP2K-270 GP2L-0015 GP2L-0

42、015 N080-338-33 GP2K-200 SPRAGUE PART No. PVL-61 rVL-1 rvL-i fVL-14 IYL-14 TVL-13 TVL-4 TVL-5 rvL-s TVL-5 UT-82 UT-82 UT-82 UT-82 UT- 82 TVA-14 1FM-21 1FM-21 ffl-15 1FH-325 1FM-215 2901 1FM-215 1FM-215 1FM-325 1FM-215 1FM-215 1FM-325 1FM-215 1FM-215 E-43 rn-i TM-15 1FM-32 IDENTIFICATION CODES AND IN

43、STALLATION NOTES Voltage Doubler Cap. T Voltage Doubler Cap. * Voltage Doubler Cap. t Voltage Doubler Cap. * Filte t Fi Ite T Filte * Filte * Filte t Fllte t Fllte * Fllte * Hor. Cent. Cont. Byp. Vert. Cent. Cont. Byp. Filter t Filte Fllte Filte t Filte t Filte * Fllte t Filte Decoupling Low Pass Fi

44、lter Output Decoupling Decoupling Vert. Output Dec. Vert. Output Cath. Byp. Ant. Coupling Ant. Coupling Ext. Ground Isolation Fixed Trimmer RF Fll. Bypass RF Decoupling RF Coupling Fixed Trimmer Osc. Grid Cap. Mixer Fll. Bypass RF Bypass Fixed Trimmer Mixer Plate Dec. IF Coupling AGC Filter 1st V. I

45、F Cath. Bypass 1st V. IF Dec. Decoupling -t- IF Coupling Fixed Trimmer AGC Filter 2nd V. IF Decoupling IF Coupling 3rd V. IF Cath. Bypass 3rd V. IF Decoupling IF Coupling AGC Filter Video Coupling 1st V. Amp. Cath. Byp. ITEM No. C45 C46 047 048 049 050 C51 052 053 054 055 C56 057 058 C59 060 061 C62

46、 C63 C64 065 C66 C67 068 C69 C70 071 C72 C73 C74 075 C76 C77 078 C79 080 081 C82 083 084 C85 086 C87 088 089 090 RATIN CAP. 150 .01 1500 .05 .05 .1 10 1500 1500 68 1500 1500 110 .001 .01 .005 .01 .05 .005 .01 .05 .05 .01 .005 .005 .25 .003 .05 .05 1000 1000 110 .05 .25 .005 780 470 .001 .1 .05 .05 .

47、035 .05 500 .1 .05 3 VOLT uu 400 i L L I : i f i i L L L i L L t f I L 00 00 too 100 ;00 00 00 wo too ,00 100 wo wo wo too 00 wo 100 wo 400 f300 600 f 00 )00 500 200 200 600 500 500 600 200 600 600 600 400 10000 400 400 REPLACEMENT EMERSON PART No. 910029 923061 928006 923062 923062 923064 910130 92

48、8006 928006 910031 928006 928.006 910010 923079 923061 923078 923061 923062 9S3078 923061 923062 923062 923075 923078 923078 923066 923075 923073 923073 910027 910027 910010 923068 923080 923077 910023 910017 923079 923067 923073 923073 923074 923062 923003 923064 922101 AEROVOX PART No. 1468-03015

49、P488-01 1467-0 P488-0 P488-0 P488-1 1468-0 1467-0 1467-0 1468-0 1467-0 1467-0 1468-0 P688-0 P488-0 P688-0 P488-0 P488-0 P686-0 P488-0 P483-0 P488-0 P688-0 P688-0 P688-0 P488-2 315 D 0001 315 315 00075 315 015 301 31 1 35 L 3 35 1 5 5 L J5 J5 P688-003 P688-0D P688-05 1468-0 1468-00101 1468-0001 P288-05 P488-25 P688-005 1468-0005 -SS-OOl P288-1 P688-05 P688-05 P688-033 P488-05 P488-1 P488-05 CORNI DUBILI PART 5W5T1! GT4S1 1W5D1: GT4S5 GT4S5 GT4P1 5W5Q1 1W5D1! 1W5D11 5W5Q7 1W5D11 IWSDli 5W5T1 GT6D1 GT4S1 GT6D5 GT4S1 GT4S5 GT6D5 GT4S1 GT