RCA-TK29-8TR29-Sams-88-9电路原理图.pdf

《RCA-TK29-8TR29-Sams-88-9电路原理图.pdf》由会员分享，可在线阅读，更多相关《RCA-TK29-8TR29-Sams-88-9电路原理图.pdf（29页珍藏版）》请在收音机爱好者资料库上搜索。

1、PHOTOFACT* Folder RCA VICTOR MODELS 8TK29, 8TR29 (CH.KCS32, A, B, C, NT USING AM SIGNAL GENERATOR AND VTVM Connect two matched 100KO (t 1%) resistors in series from point toto chassis. The junction of these two resistors is alignment pointfXs shown on the schematic. Alternate loading is used on the

2、transformers during FM IF a ignment, that is, the primary of each transformer is shunted with 680 ohms while the secondary of the same transformer is being adjusted. When the primary is to be adjusted, the 680J3 resistor is used to shunt the secondary. This process is repeated for each transformer.

3、DUMMY ANTENNA . 01MFD . 01MFD . 01MFD SIGNAL GENERATOR COUPLING High side to pin 1 (Grid) of 6AU6 (V21). Low side to chassis. SIGNAL GENERATOR FREQUENCY 10. 7MC (Unmod. ) BAND SWITCH POS. FM (third position CW) RADIO DIAL SETTING Tuning gang fully open CONNECT VTVM DC Probe to Pointy Common to chass

4、is. DC Probe to Point Common to Poim$ DC Probe to Point) Common to chassis. ADJUST A46 A47 A48, A49, A50, A51 REMARKS Adjust for maximum deflection. Adjust for zero reading. A positive and negative reading will be obtained on either side of the correct setting. Use alternate loading as explained abo

5、ve. Adjust for maximum deflection. FM IF ALIGNMENT USING FM SIGNAL GENERATOR AND OSCILLOSCOPE Use frequ DUMMY ANTENNA Direct DUMMY ANTENNA 270SZ carbon res. ency modulated signal with 60 - modulation and 450KC sweep. Use 120 - sawtooth voltage n scope for horizontal deflection SIGNAL GENERATOR COUPL

6、ING High side to ungrounded tube shield floating over converter tube (V25). Low side to chassis. SIGNAL GENERATOR COUPLING High side thru 270J1 to un- grounded antenna terminal. Low side to chassis. SIGNAL GENERATOR FREQUENCY 10.7MC (450KC Sweep) SIGNAL GENERATOR FREQUENCY 106MC (Unmod. ) 90MC BAND

7、SWITCH POS. FM (third pos. CW) BAND SWITCH POS. FM RADIO DIAL SETTING Point of non- interference RADIO DIAL SETTING 106MC Tune for max. deflection. CONNECT SCOPE Vert. Amp. to Point Low side to chassis. Vert. Amp. to Point Low side to chassis. CONNECT VTVM DC Probe to PoinU Low side to chassis. ADJU

8、ST A46, A48, A49, A50, A51 A47, A46 ADJUST A52, A53 A54 REMARKS Disconnect stabilizer capacitor (C107). Ad- just for maximum amplitude and symmetry as per Fig 9. . Reconnect capacitor (C107). Adjust A47 so 10. 7MC occurs at center of crossover lines as per Fig 10. Slightly retouch A46 for maximum am

9、plitude and straightness of crossover lines. Continue with step 27. REMARKS Set A52 to maximum capacity. Expand or compress turns of A53 for maximum de- flection, then adjust A52 for maximum de- flection . Expand or compress coil turns for maximum deflection. Repeat steps 27 and 28 until no further

10、improvement can be made. FIG. 9FIG. 10 PAGE 1O RadioFans.CN HEIGHTFOCUSVERT. LIN. CABINET-REAR VIEW AGC THRESHOLD ADJUSTMENT WIDTH HORIZ. LIN. Turn the set on and tune in a local TV station. Turn the contrast control to maximum clockwise. Turn the AGC threshold control to maximum counter-clockwise,

11、a bend may appear in the upper part of the pic- ture. Turn the AGC threshold control clockwise until there is a very slight bend, or slight change of the bend which may already be there. Then turn the AGC threshold control slowly counter-clockwise until the slight bend, or change of bend disappears.

12、 Turn the contrast control to approximately the center of its range. The picture should be of proper contrast. _ r o IF=455 KC AM IF=I0.7 MC FM .s, ,-vvv-, oo J vW- D 88-9 AM-FM TUNER SCHEMATIC RadioFans.CN 9L lOVd RadioFans.CN 5 o CHASSIS BOTTOM VIEW-CAPACITOR IDENTIFICATION (VSC DIHMD 6CU18 60J18

13、S13QOW MO1DIA RadioFans.CN O a. RadioFans.CN 0 O to in CHASSIS BOTTOM VIEW-RESISTOR IDENTIFICATION (VSC IHITHD 6CX18 S13QOW MOiDIA V3d RadioFans.CN RCA VICTOR MODELS 8TK29, 8TR29 (Ch.KCS32,A,B,C,olation ;t Sync. Sep. Grid it Sync. Sep. Cathode ;t Sync- Sep. Cathode ;t Sync. Sep. Plate ;olation oltag

14、e Divider ?nc. Amp. Grid fnc. Amp. Plate id Sync. Sep. Grid id Sync. Sep. Cathode itegrator itegrator tegrator 3rt. Osc. Grid 3rt. Osc. Plate )ltage Divider jltage Divider rt. Peaking art. Output Grid =rt. Output Cathode =rt. Output Plate Decoupling liter iriz. AFC Grid 3riz. AFC Cathode jriz. AFC C

15、athode iriz. AFC Filter Network altage Divider altage Divider altage Divider Driz. Osc. Grid Driz. Osc. Transformer Shunt Driz. Osc. Transformer Shunt Driz. Osc. Plate Driz. AFC Filter Network irasitic Supp. Driz. Output Grid Driz. Output Grid Driz. Output Cathode ias Network Driz. Output Screen See

16、 Note 4 ilter VRecL Filament V Filter ?edback as Network-Wire Wound Her Network See Note 5 jcus Coil Shunt-Wire Wound See Note Iter-Wire Wound altage Divider-Wire Wound ias Network-Wire Wound jltage Divider .eeder ;eeder TRANSFORMER (POWER) ITEM No. Tl RAtING PRI. invAC at 2.05A SEC. 1 750VCT . 250A

17、DC SEC. 4 6. 3VAC at7.4A SEC. 2 5VAC at 3A SEC. 5 6.3VAC at 1. 6A SEC. 3 5 VAC at 2A REPLACEMENT DATA RCA PART No. 74046 STANCOR PART No. P-8153 (2) MERIT PART No. CHICAGO PART No. TP-355 Redrill mounting holes. TRANSFORMER (SWEEP CIRCUITS) ITEM No. T2 T3 T4 T5 T6A B T7 RATING DC RESISTANCE PRI. 125

18、n Tap at 90n 165n 33in Tap at 173O 52in 13. 5n 64. 6n 364n SEC. 36n 13100 SEC. 1 10. 8n Tap at .en SEC. 2 on 6. 9n REPLACEMENT DATA RCA PART No. 73576 73569 73570 73568 71420 73566 STANCOR PART No. A-8121 A-8117 A-8116 DY-1 MERIT PART No. A-4000 A-3035 CHICAGO PART No. TBO-2 TFB-1 TSO-4 NOTES Hor. O

19、sc. Trans. Vert. Block Osc. Trans. Hor. Output Trans. Vert. Output Trans. Hor. Deflection Coil Vert. Defection Coil Focus Coil Drill one new mounting hole. TRANSFORMER (AUDIO OUTPUT) ITEM No. T8 RATING IMPEDANCE PRI. 1 SEC. 5.8KSJ | 4.2n DC RES. PRI. soon SEC. .2en REPLACEMENT DATA RCA PART No. 7141

20、9 STANCOR PART No. A-3877 MERIT PART No. A-2930 CHICAGO PART No. RO-9 INSTALLATION NOTES Drill one new mounting hole n u 70 ft SPEAKER ITEM No. SP1A B SP2A B RATINGS FIELD RES. PM PM CONE DIA. 4 3/4 x 7 12 V. C. IMP. 4. 2!i V. C. DIA. 3/4 REPLACEMENT DATA RCA PART No. 73993 73635 73934 JENSEN PART N

21、o. QUAM PART No. 57A15 NOTES FILTER CHOKE ITEM No. LI RATINGS TOTAL DIRECT CURRENT .250A D. C. RESISTANCE 43O INDUCTANCE (0 CURRENT 1000 ./) 1. 3 Henries REPLACEMENT DATA RCA PART No. 73154 STANCOR PART No. C-2325 MERIT PART No. C-2991 CHICAGO PART No. TR-3300d INSTALLATION NOTES Drill one new mount

22、ing hole. fo o TO 70 i O / 9:00 COILS (RF-IF) ITEM No. L2 L3 L4 L5 L6 L7A B L8 L9 L10 LUA B L12 1,13 L14A B L15 L16 L17 LISA B L19 L20 L21 L22 L23 L24 L25 L26 USE Ant. Input Trans. IF Trap IF Trap Shunt IF Trap RF Grid RF Plate Trimmer RF Plate Trimmer RF Plate HF Plate RF Coupling Mixer Grid Trimme

23、r Mixer Grid Trimmer Mixer Grid Mixer Grid Osc. Plate Trimmer Osc. Plate Trimmer Osc. Plate Osc. Plate Osc. Plate Osc. Plate Trimmer Osc. Plate Trimmer Fil. Choke Fil. Choke Fil. Choke Conv. Trans. 1st Video IF Fil. Choke 2nd Video IF 3rd Video IF & Sound Take Off DC RES. PRI. .5n .sn .5SJ .5J2 on o

24、n on on on on on on on on on on on on on on on on on on .5SI .in on .in .in SEC. .2n on on REPLACEMENT DATA RCA PART No. 73578 73476 73475 73476 73633 73446 74110 73471 73460 73462 74109 73444 73470 73874 73444 74109 73468 73469 73874 74108 73443 73477 73477 73477 73448 73571 73477 73572 73573 MEISS

25、NER PART No. NOTES Includes mounting bracket and socket. Includes 12MMF capacitor. Includes 12MMF capacitor. Complete with stator, rotor, coils and segments. Channel #13. Smooth bushing type with screw adjust- ments. Channel #13. Threaded bushing type with screw adjustments. Includes stator, rotor,

26、coils and segments. Channel 6 Channel #13. Threaded bushing type with screw adjustment. Channel #13. Smooth bushing type with screw adjust- ment. Includes stator, rotor, coils and segments. Channel 6 Channel #13. Smooth bushing type with screw adjust- ment. Channel #13. Threaded bushing type with sc

27、rew adjust- ment. Includes stator, rotor, coils and segments. Includes stator, rotor, coils and segments. Channel #6 Channel #13. Threaded bushing type with plunger adjustment. Channel #13. Smooth bushing type with plunger adjust- ment. Includes C29 and R21 Includes C30 Includes C38 PAGE 21 RadioFan

28、s.CN TV PARTS LIST AND DESCRIPTIONS (Continued) CCHLSCRF-IFDCONT. ITEM No. L27 L28 L29 L30 L31 L32 L33 L34 L35 L36 L37 L38 L39 L40 USE Peaking 4th Video IF Sound Trap 5th Video IF Peaking Peaking 4. SMC Trap Peaking Peaking Peaking Sound IF Disc. Trans. Width Cont. Hor. Line- arity DC RES. PRI. 2.3R

29、 .in on .in 4. in en 2. 5 7.2n en 6. an on on .2n 34n SEC. on on on on REPLACEMENT DATA RCA PART No. 74170 73574 71778 73575 72619 71528 73577 71526 71528 71526 71424 71427 71429 71449 MEISSNER PART No. NOTES 36 microhenries. Wound on 8. 2Kn resistor. Includes 36MMF capacitor. Includes C41 Includes

30、56MMF and 8. 2MMF capacitor. 93 microhenries. Wound on lOKn resistor . Orange identification dot. 180 microhenries. Wound on 39KS1 resistor. White identification dot. Includes C51 250 microhenries. Green identification dot. 180 microhenries. Wound on 39Kn resistor. White identification dot. 250 micr

31、ohenries. Green identification dot. MISCELLANEOUS ITEM No. Ml M2 M3 PART NAME RF Tuner Fuse Ion Trap Cabinet Back Cabinet Back Safety Glass Knob Knob Knob Knob Knob Knob Knob Knob Escutcheon Escutcheon Trimmer Strip RCA PART No. KRK5 73600 73301 74058 74053 73863 73224 73222 73226 73228 73225 73223

32、73227 73229 73642 73740 73580 NOTES Type GJV .25A Permanent magnet type Model 8TK29 Model 8TR29 Channel selector | Fine tuning i Walnut and mahogany models. Tone, Vert, hold, Brightness Volume, Contrast, Hor. hold ) Channel selector A Tonee,tUBr|htness, Vert, hold Sted mahany models. Volume, contras

33、t, Hor. hold J Channel marker (Walnut or mahogany models) Channel marker (Toasted mahogany models.) Hor. locking range (10-160MMF), Hor. drive cont. (40-370MMF) RADIO PARTS LIST AND DESCRIPTIONS TUBES (SYLVANIA or Equivalent) ITEM No. V25 V26 V27 V28 V29 USE Converter 1st IF Amp. FM 2nd IF Amp. Rati

34、o Det. DET. -AVC REPLACEMENT DATA RCA PART No. 616 6BA6 6AU6 6AL5 6AV6 STANDARD REPLACEMENT 6J6 6BA6 6AU6 6AL5 6AV6 RMA BASE TYPE 7BF 7BK 7BK 6BT 7BT NOTES CAPACITORS Capacity values given in the rating column are in mfd. for Electrolytic and Paper Capacitors, and in mmfd. for Mica and Ceramic Capac

35、itors. ITEM No. C107 C108 C109 C110 cm C112 C113 C114 C115 C116 CUT C118 C119 C120 C121A B C122 C123A B C124A B C125 C126 C127 C128 C129A B RATING CAP. 2 1500 100 68 15 56 2 150 .01 47 .005 100 .05 5000 4000 4000 5000 200 200 4000 4000 005 330 330 005 4000 4000 VOLT 50 400 400 200 400 500 500 400 RE

36、PLACEMENT DATA RCA PART No. 73747 73748 39396 33103 31353 73867 73866 48125 71925 39042 71553 39396 54859 73473 74009 73473 * 74009 71553 39640 39640 71553 74009 AEROVOX PART No. PRS150/4 GP1500M CN100KN750 GP68M GP15M GP150M P488-01 GP47M P688-005 CN100JN750 P288-05 BPD-5 GP4000M GP4000M BPD-5 GP20

37、0M GP200M GP4000M GP4000M P688-005 1468-0003 1468-0003 P688-005 GP4000M GP4000M CORNEU- DUBILIER PART No. BBR2-50T 1W5D15 5R5T1 5W5T15 PTE4S1 5W5Q5 PTE6D5 5R5T1 PTE4S5 1D5D5 1D5D4 1D5D4 1D5D5 5W5T2 5W5T2 1D5D4 1D5D4 PTE6D5 5W5T3 5W5T3 PTE6D5 1D5D4 1D504 ERIE PART No. GP2L-0015 N750L-100 GP1K-68 GP1K

38、-15 GP2K-150 GP2-335-01 GP1K-47 GP2M-005 N750L-100 811-005 811-005 811-005 811-005 GP2K-200 GP2K-200 811-005 811-005 GP2M-005 GP2K-330 GP2K-330 GP2M-005 811-005 811-005 SPRAGUE PART No. TVA-12 1FM-215 MS-31 1FM-315 TM-11 1FM-45 TM-25 MS-31 TM-15 29C1 36C2 29C1 1FM-32 1FM-32 36C2 TM-25 1FM-335 1FM-33

39、5 TM-25 36C2 IDENTIFICATION CODES AND INSTALLATION NOTES Stabilizing Cap. RF Coupling Fixed Trimmer Osc. Feedback Osc. Grid Cap. Fixed Trimmer Fixed Trimmer Osc. Grid Cap. Osc. Plate Decoupling Conv. Filament Bypass Cony. Plate Dec. Fixed Trimmer AVC Filter AVC Filter 1st IF Screen Bypass 1st IF Dec

40、oupling 1st IF Fil. Bypass Diode RF Filter Diode RF Filter 2nd IF Screen Bypass 2nd IF Decoupling 2nd IF Cath. Bypass Diode Load Cap. T Diode Load Cap- T De-emphasis DAVC Decoupling DAVC Decoupling Hems C123A, C123B and R143 are combined into one unit, obtainable under MFGRS part No 74011 t When eit

41、her item C126 or C127 are replaced, replace both with capacitors of equal value. PAGE 22 RadioFans.CN RADIO PARTS LIST AND DESCRIPTIONS (Continued) RESISTORS ITEM No. R130 R131 R132 R133 R134 R135 R136 R137 R138 R139 R140 R141 R142 R143 R144 R145 R146 R147 R148 R149 R150 R151 R152 R153 R154 R155 RAT

42、ING RESISTANCE ion 3. 9 Meg. 27KSJ 18KSJ loon 15KS2 68SJ 27KSJ 680S2 22 Meg. 150KJJ 150KSJ 2. 2 Meg. 47KSJ 120JJ i5Ka 680(2 won 15KSI 3300SJ 5% 1200S2 39KS2 5% 470KO 10E! .sin .5m WATTS i z 2 1 i 1 *1 3 I 1 REPLACEMENT DATA RCA PART No. IRC PART No. BTS-3.9Meg. BTS-27K BTS-18K BTS-15K BTS-27K BTS-68

43、0 BTS-22 Meg. BTS-150K BTS-I50K BTS-2. 2 Meg. BTS-47K BTS-15K BTS-680 BTS-15K BTS-3300-5% BTS-1200 BTS-39K-5% BTS-470K BTS-10K IDENTIFICATION CODES Parasitic Supp. Conv. Grid Conv. Plate Decoupling Osc. Grid Parasitic Supp. Osc. Plate Decoupling 1st IF Cathode 1st IF Screen Decoupling Delayed AVC Di

44、ode Load AVC Network AVC Network Diode Filter See Note 7 2nd FM IF Cathode 2nd FM IF Screen 2nd FM IF Decoupling Balancing De-emphasis Ratio Del. Diode Load Balancing Ratio Det. Diode Load AVC Network De-emphasis Filament Dropping-Wire Wound Filament Dropping-Wire Wound Note 7. Items C123A, C123B an

45、d R143 are combined into one unit, obtainable under MFGRS part No. 74011. COILS (RF-IF) 70 ITEM No. L41 L42 L43 L44 L45 L46 L47 USE FM Ant. AM Ant. FM Osc. AM Osc. 1st IF FM AM 2nd IF FM AM Ratio Det. Trans. DC RES. PRI. on 24S2 on 1S2 .3S2 an .Ml 7CJ .9!J SEC. 2Si 6. 5S! .3S2 80 .80 7f! .3S1 REPLAC

46、EMENT DATA RCA PART No. 74024 74020 74025 73744 73745 74019 73743 MEISSNER PART No. NOTES No. 16 buss tinned, 8 turns per inch, 2 1/2 turns L. H. No. 16 buss tinned, 9 turns per inch, 4 7/8 turns L. H. Pick-up coil 2JJ r a 9:00 DIAL LIGHTS ITEM No. M4 M5 M6 BASE TYPE Bayonet Bayonet Bayonet VOLTS 7.

47、5 7.5 7.5 AMPS. .2 .2 .2 BEAD COLOR White White White REPLACEMENT DATA RCA PART No. 11765 11765 11765 NOTES Type *51 Type *51 Type #51 (Jewel lamp used in model 8TK29 only. ) MISCELLANEOUS ITEM No. M7A B M8 M9 M10 PART NAME Function Switch Function Switch Heater Switch Shorting Switch Tuning Cap. Kn

48、ob Knob Bezel RCA PART No. 74260 74018 74031 74032 74017 74056 74057 74052 NOTES Used with RK135A tuner. Complete with heater SW and shorting SW. Used with RK135 tuner. Complete with heater SW and shorting SW. (20-392MMF) (17-197MMF) (W/T) Radio tuning, selector switch (Walnut and mahogany models) R

49、adio tuning, selector switch (Toasted mahogany models) Lucite bezel and dial scale assembly PAGE 23 RadioFans.CN DISASSEMBLY INSTRUCTIONS-MODEL 8TR29 1. Remove six push-on type control knobs. 2. Remove five screws holding rear cover. Remove cover. 3. Loosen two screws holding antenna terminal strip. Free strip. 4. Loosen two screws holding audio plug. Free plug. 5. Remove two screws holding top panel. Remove panel. 6. Remove two screws on bottom holding front of cabinet. 7. Loosen two wing nuts on back of front panel. Remove front panel. Remove two panel lamp assembli