Stewart-Warner-AVC1-Sams-64-12电路原理图.pdf

《Stewart-Warner-AVC1-Sams-64-12电路原理图.pdf》由会员分享，可在线阅读，更多相关《Stewart-Warner-AVC1-Sams-64-12电路原理图.pdf（23页珍藏版）》请在收音机爱好者资料库上搜索。

1、PHOTO FACT* Folder STEWART-WARNER MODELS AVC1, AVC2, AVT1 WIDTHVERT. HOLD HEIGHT VOLUME ON-OFF SW. HORIZ. HOLD FOCUS CHANNEL SELECTOR SW. CONTRAST STEWART-WARNER MODEL AVT1 TRADE NAME Stewart-Warner Models AVT1 (9053-A) AVC1 (9054-B) AVC2 (9054-C) MANUFACTURER Stewart-Warner Corp., 1826 Diversey Pkw

2、y., Chicago, Illinois TYPE SET Television Receiver TUBES Twenty-Five POWER SUPPLY 117 Volts, 60 Cycles AC,or DC with Polarizing Relay TUNING RANGE-Channels 2 through 13 RATING 1.6 Amps (a) 117 Volts Alignment Instructions Block Diagram Disassembly Instructions Horizontal Frequency Adjustment Parts L

3、ist and Description Photographs Cabinet-Rear View Capacitor Identification Chassis-Top View INDEX 6,7,8 Photographs (continued) 16 20 20 13,14,15,16 11,18 3 High Voltage Supply Resistor Identification Trans. Inductor and Alignment Identification Production Changes Schematic Tube Placement Chart Volt

4、age and Resistance Measurements 19 12,17 4,9 20 2 5 10 o D E 3 ?l S 90 HOWARD W. SAMS AC Voltage measured at 1,000 ohms. 2. Pin numbers ore couniea in a clockwise direc- tion on bottom of socket. 3. Measured values are from socket pin to com- mon negative unless otherwise stated. 4. Line voltage mai

5、ntained at 117 volts for volt- age readings. 5. Front panels controls set at minimum. 6. Where readings may vary according to the setting of the service controls, both minimum and maximum readings are given. RadioFans.CN CHASSIS BOTTOM VIEW-CAP PAGE 18 RadioFans.CN o PS :APACITOR IDENTIFICATION PAGE

6、 1 1 RadioFans.CN CHASSIS BOTTOM VIEW-F PAGE 12 RadioFans.CN o o t 0 -RESISTOR IDENTIFICATION PAGE 17 RadioFans.CN PARTS LIST AND DESCRIPTIONS TUBES (SYLVANIA or Equivalent) ITEM No. VI V2 V3 V4 V5 V6 V7 V8 V9 V10 Vll V12 V13 V14 V15 V16 V17 V18 V19 V20 V21 V22 V23 V24 V25A B USE SF Amp. Converter 1

7、st IF Amp. 2nd IF Amp. 3rd IF Amp. tth IF Amp. DET.-AGC Video Amp. DC Rest. Cath. Pollower-Horiz. Wilt. Llmlter Ratio Det.-AF Amp. Audio Output Sync. Clipper Vert. Mult. Vert. Output Hor. Mult. -H or. Amp. Horiz. Output Horiz. Output Horiz. Output Damper Booster Rect. HV Osc. HV Osc. HV Rect. Pictur

8、e Tube Picture Tube REPLACED STEW. WARN. PART No. 6BH6 6J6 12AU6 12AU6 12AU6 12AU6 12AL5 12AU6 12AU7 12AU6 19T8 50L6GT 12AU6 12SN7GT 50L6GT 12SN7GT SOBS 5085 50B5 35Z5GT 35Z5GT 35L6GT 3SL6GT 1B3GT 10BP4 10FP4 :NT DATA STANDARD REPLACEMENT 6BH6 6J6 12AU6 12AU6 12AU6 12AU6 12AL5 12AU6 v 12AU7 12AU6 19

9、T8 50L6GT 12AU6 12SN7GT 50L6GT 12SN7GT SOBS 50B5 50B5 35Z5GT 35Z5GT 35L6GT 35L6GT 1B3GT 10BP4 10FP4 RMA BASE TYPE 7CM 7BF 7BK 7BK 7BK 7BK 7BK 9A 7BK 7AC 7BK 8BD 7AC 8BD 7BZ 7BZ 7BZ 6AD 6AD 7AC 7AC 3C 12D 12D NOTES Used in model AVT1 Used In models AVC1 and AVC2. CAPACITORS Capacity values given in t

10、he rating column are in mfd. for Electrolytic and Paper Capacitors, and in mmfd. for Mica and Ceramic Capacitors. ITEM No. CIA B C2A B C3A B C C4 C5A B C6 C7 C8 C9 CIO Cll C12 CIS C14 CIS C16 C17 CIS 019 C20 C21 022 C23 C24 C25 C26 C27 C28 C29 C30 C31 C32 033 C34 035 C36 C37 C38 C39 C40 C41 C42 C43

11、C44 C45 C46 C47 C48 C49 C50 C51 C52 C53 C54 CSS 056 C57 CSS C59 RATING CAP. 200 200 200 200 40 20 20 500 150 50 8 10 10 10 5 220 220 .001 .001 .001 .001 1 .5 .5 .001 .001 220 220 .001 10 7 51 51 2.2 2.5 .001 220 220 .001 47 .001 .001 .001 .001 100 240 47 47 .001 .001 .001 .001 47 .001 .001 100 .001

12、.001 100 47 .001 .001 .001 .001 VOLT 150 150 150 150 150 150 150 3 25 25 300 25 25 150 500 500 500 500 500 REPLACEMENT DATA STW. WARN. PART No. 507319 507318 506798 507322 507359 507386 502286 502286 505174 513432 513018 513018 513009 513009 513009 513009 513000 513019 513019 513009 513009 513018 51

13、3018 513009 513437 513402 513416 513416 513001 513436 513009 513018 513018 513009 512526 513009 513009 513009 513009 513003 513438 512526 513009 513009 513009 513009 512526 513009 513009 513003 513009 513009 513003 512526 513009 513009 513009 513009 AEROVOX PART No. AFH4040D AFH4040D AFH844D PRS6/50

14、0 AF888D* PRS25/50 PRS350/8 PRS 25/10 PRS25/10 PRS150/12 1468-00005 1468-001 1468-001 1468-001 1468-001 1468-0001 1469-00025 1469-00005 1468-00005 1468-001 1468-001 1468-001 1468-001 1468-00005 1468-001 1468-001 1468-0001 1468-001 1468-001 1468-0001 1468-00005 1468-001 1468-001 1468-001 1468-001 COR

15、NELL- DUBILIER PART No. UP11BJ 1055 UP11BJ 1055 UP4CJ 1056 BRH-605 UP4BJ 1059 BR835 BR102A BR102A BR1015 5W5Q5 1W5D1 1W5D1 1W5D1 1W5D1 5W5T1 5R5T25 5R5Q5 5WSQ5 1W5D1 1W5D1 1W5D1 1W5D1 5W5Q5 1W5D1 1W5D1 5W5T1 1W5D1 1W5D1 5W5T1 5W545 1W5D1 1W5D1 1W5D1 1W5D1 ERIE PART No. GP2K-250 GP2K-250 GP2L-001 GP2

16、L-001 GP2L-001 GP2L-001 GP2L-001 GP2L-001 GP2K-250 GP2K-250 GP2L-001 NPOK-10 N750L-47 N750L-47 GP2L-001 GP2K-250 GP2K-250 GP2L-001 GP1K-50 GP2L-001 GP2L-001 GP2L-001 GP2L-001 GP1K-100 NPOM-50 GP1K-50 GP2L-001 GP2L-001 GP2L-001 GP2L-001 GP1K-50 GP2L-001 GP2L-001 GP1K-100 GP2L-001 GP2L-001 GP1K-100 GP

17、1K-47 GP2L-001 GP2L-001 GP2L-001 GP2L-001 SOLAR PART No. MO. 5-45 MW.5-21 MW.5-21 MW.5-21 MW.5-21 MO. 5-31 MOS. 5-325 MOS.5-45 MO. 5-45 MW.5-21 MW.5-21 MW.5-21 MW.5-21 MO. 5-45 MW.5-21 MW.5-21 MO. 5-31 FW.5-21 MW.5-21 MO. 5-31 MO. 5-45 MW.5-21 KH.5-21 MW.5-21 MW.5-21 SPRAGUE PART No. D14906 D14906 E

18、LS-13 UHC-506 D14904 JT-83 PVA-5 TVA-5 UT-121 LFM-45 1FM-21 1FM-21 1FM-21 1FM-21 1FM-31 13-325 E-45 1KM-45 1FM-21 1FM-21 1FM-21 1FM-21 1FM-45 1FM-21 1FM-21 1FM-31 1FM-21 1FM-21 1FM-31 1FM-45 1FM-21 1FM-21 1FM-21 1FM-21 IDENTIFICATION CODES AND INSTALLATION NOTES Filter fi it a Filter A Decoupling De

19、coupling Video Amp. Cath. Bypass Vert. Output Cath. Bypass Output Cath. Bypass Filter Stabilizing Cap. Sync. Clipper Cath. Byp. Dyn. Limiter Cap. Fixed Trimmer 1J%, Note 2 RF Coupling n It RF Bypass n )i RF Screen Bypass RF Supp. Bypass RF Coupling ti ti ii n RF Plate Decoupling RF Bypass RF Fil. By

20、pass n n it RF Bypass Con IT. Cath. Bypass Fixed Trimmer Fixed Padder Osc. Feedback Osc. Coupling Osc. Feedback RF Bypass Conv. Fil. Bypass Conv. Kil. bypass Conv. Plate Decoup. IF Coupling AGC Filter RF Bypass 1st V. IF Supp. Byp. 1st V. IF Decoupling 1st V. IF Fil. Bypass Fixed Trimmer ti n IF Cou

21、pling AGO Filter RF Bypass 2nd V. IF Supp. Bypass 2nd V. IF Decoupling IF Coupling AGO Filter RF Bypass 2nd V. IF Fil. Bypass 3rd V. IF Supp. Bypass 3rd V. IF Decoupling 3rd V. IF Fil. Bypass IF Coupling RF Bypass RF Bypass 4th V. IF Cath. Bypass 4th V. IF Supp. Bypass O P PAGE 13 RadioFans.CN PARTS

22、 LIST AND DES CAPACITORS CCONTO ITEM No. C60 061 062 C63 C64 C65 C66 067 068 C69 070 C71 C72 C73 074 075 C76 C77 C78 C79 C80 C81 C82 C83 C84 085 C86 087 088 C89 C90 091 C92 C93 C94 C95 C96 C97 C98 C99 C100 C101 C102 C103 C104 C105 C106 C107 C108 C109 C110 cm C112 C113 C114 0115 CUB C117 C118 C119 C1

23、20 C121 C122 C123 C124 C125 C126 C127 C128 C129 C130 RATING CAP. .001 100 100 1.0 .001 .01 .001 5 .005 .001 .001 .001 .05 .001 .05 47 .0015 220 .001 220 500 .0015 .01 .05 .01 .002 200 200 .01 .0015 .001 .05 .05 .005 .01 .01 500 .2 .2 .25 470 56 47 500 .01 150 .25 .5 .25 330 .5 .1 .1 .01 .1 .02 .01 .

24、02 .02 .02 560 500 500 .1 .1 .02 .02 .05 .01 220 220 VOLT 200 200 200 200 500 500 200 200 200 600 500 500 400 600 200 200 600 200 400 500 400 400 200 500 500 200 200 200 200 1000 200 200 200 200 200 200 200 200 200 200 500 10000 10000 200 200 200 200 600 400 REPLACEMENT DATA STEW. WARN. PART No. 513

25、009 513003 513003 512056 513009 512008 513009 513432 513013 513009 513009 513009 512026 513009 512026 S13433 513010 513018 513009 512527 512513 513010 512008 512026 512008 512002 512508 512508 512008 513010 512000 512026 S12026 512006 512008 512303 512513 512302 512304 512044 512528 513015 513020 51

26、2513 512008 513004 512044 512051 512045 512524 512051 512032 512032 512009 512033 512014 512009 512015 512015 512014 512530 513021 513021 512033 512032 512014 512014 512030 512010 513018 513018 AEROVOX PART No. 1468-001 1468-0001 1468-0001 48*-1.0 1468-001 P488-01 1468-001 1469-000005 1467-005 1468-

27、001 1468-001 1468-001 P288-05 1468-001 P286-05 1469-00005 1467-0015 1468-00025 1468-001 1468-0002 1468-0005 1467-0015 P288-01 P288-05 P288-01 P688-002 1468-0002 1468-0002 P488-01 1467-0015 P688-001 P288-05 P288-05 P688-005 P288-01 P488-01 1468-0005 P488-22 P488-22 P488-25 1468-0005 1468-00005 1468-0

28、0005 1468-0005 P488-01 1468-00015 P488-25 P288-2 P488-25 P288-5 P288-1 P288-1 P488-01 P288-1 P4S8-02 P488-01 P488-02 P488-02 P488-02 P288-1 P288-1 P488-02 P488-02 P688-05 P488-01 1468-0002 1468-0002 CORNELL- DUBILIER PART No. 1W5D1 51 51 G LW 0 J5T1 J5T1 F2W1 5D1 P2S1 1W5D1 51 1 1 V5 D5D5 J5D1 1W5D1

29、 1W5D1 Gl IV 2S5 5D1 GT2S5 5R5Q5 1W5D15 5W5T25 1W5D1 5W5T2 5W5T5 1W5D15 GT2S1 GT2S5 012S1 GT6D2 5W5T2 5W5T2 GT4S1 1W5D15 01 Gl Gl Gl 6D1 6S5 6S5 6D5 GT2S1 GlF4S1 5W5T5 GT4P2 GT4P2 GT2P25 5W5T5 5W5Q5 5W5Q5 5W5T5 GT2S1 5W5T15 GT2P25 GT2P5 GT2P25 GT2P5 GT2P1 GT2P1 GT2S1 GT2P1 GT2S2 GT2S1 GT2S2 GT2S2 3T

30、2S2 Gt2Pl GTS2P1 GT2S2 OT2S2 OT6S5 OT4S1 5W5T2 5W5T2 Note 1. Some models use 430MMF In Note 2. Not used In all models. ERIE PART No. GP2L-001 GPlK-100 GP1K-10O GP2L-001 GP2-335-01 GP2L-001 NPOK-5 GP2M-005 GP2L-001 GP2L-001 GP2L-001 GP2L-001 NPOM-50 GP2L-0015 GP2K-250 GP2L-001 GP2K-200 GP2K-500 GP2L-

31、0015 GP2-33S-01 GP2-335-01 GP2M-002 GP2K-200 GP2K-200 GP2-335-01 GP2L-0015 GP2M-005 GP2_335-01 GP2-335-01 GP2K-500 GP2K-500 GP1K-50 GP1K-50 GP2K-500 GP2-335-01 GP2K-150 GP2K-200 GP2K-200 SOLAR PART No. MW.5-21 MO. 5-31 MO. 5-31 ST-2-1M MW.5-21 ST-2-01 MW.5-21 MOS.5-55 MW.5-25 MW.5-21 MW.5-21 MW.5-21

32、 ST-4-05 MW.5-21 ST-4-05 MOS.5-45 MW. 5-215 MO. 5-325. MW.5-21 MO. 5-32 MO. 5-35 MW. 5-215 ST-4-01 ST-4-05 ST-4-01 ST-6-002 MO. 5-32 MO. 5-32 ST-4-01 MW. 5-215 ST-6-001 ST-4-05 ST-4-05 ST-6-005 ST-4-01 ST-4-01 MO. 5-35 ST 4-2 ST-4-2 ST-2-25 MO. 5-35 MO. 5-45 MO. 5-45 MO. 5-35 ST-4-01 MO. 5-315 ST-2-

33、25 ST-2-5 ST-2-25 ST-2-5 ST-2-1 ST-2-1 ST-4-01 ST-S-1 STl-02 ST-4-01 ST-4-02 ST-4-02 ST-4-02 ST-2-1 ST-2-1 ST-4-02 ST-4-02 ST-6-05 ST-4-01 MO. 5-32 MO. 5-32 SPRAGUE PART No. LFM-21 LFM-31 LFM-31 rc-io IFM-21 TM-11 IFM-21 B-S5 LFM-25 LFM-21 .FM-21 IFM-21 TM-15 IFM-21 FM-15 hB-45 IFM-215 1FM-325 IFM-2

34、1 1FM-32 1FM-35 IFM-215 TM-11 TM-15 TM-11 TM-22 1FM-32 1FM-32 TM-11 IFM-215 TM-21 TM-15 TM-15 TM-25 TM-11 TM-11 1FM-35 68P36 68P36 TC-2 1FM-35 1FM-4S 1FM-45 1FM-35- TM-11 1FM-315 TC-2 rc-s TC-2 rc-5 TM-1 TM-1 TM-11 TM-1 TM-12 TM-11 JM-12 TK-12 TM-12 TM-1 PM-1 m-12 FM-12 PM-15 PM-11 1FM-32 1FM-32 IDE

35、NTIFICATION CODES AND INSTALLATION NOTES 4th V. IF Decoupling 4th V. IF Fll. Bypass IF Coupling AGO Filter n w AGO Diode Filter n n n Diode Filter RF Bypass Note 4 DET-AGC Fll. Bypass )ET-AGC Fil. Bypass RF Bypass Video Coupling RF Bypass Video Coupling S. IF Coupling - 10% Llmlter Decoupling jlmlte

36、r Fil. Bypass Note i IF Coupling Diode Load Cap. De-emphasis fF Bypass 3hono Isolation Vol. Cont. Isolation Audio Coupling RF Bypass AF Plate Bypass Audio Coupling Pone Compensation )utput Plate Bypass Video Coupling Sync. Coupling Integrator Net. Vert. Mult. Feedback Vert. Mult. Plate Byp. Vert. Di

37、scharge Vert. Coupling rixed Trimmer Differentiator Net. Hor. Mult. Feedback lor. Discharge Note 3 Hor. Coupling Hor. Output Grid Filter Note 2 Hor. Output Screen Byp. temper Filter Hor. Coupling Fixed Trimmer Filter RF Bypass Pic. Tube Grid Filter HV Osc. Grid Cap. Bias Filter n n HV Osc. Feedback

38、HV Osc. Screen Byp. HV Osc. Plate Dec. RF Bypass Fixed Trimmer Note 1 HV Filter n n Line Isolation HV Osc. Fil. Bypass run II Line Isolation Line Filter Ant. Coupling this application. Note 3. Some models use 82MMF in this, application. Note 4. Some models use 1000MMF inthis application. Parallel se

39、ctions to obtain desired capacity. ITEM No. R1A B C R2 R3A B R4 R5 R6A B R7 R8 R9 CONTROLS ,.- REPLACEMENT DATA KA i IN(j TEW WARN IRC jj WATTS PART No. PART No. 1 Msg. 4 507294 D13-137 Shaft Not Req. E Switch Not Req. 41 20002 2 507295 W-2000J 250KE 4 507298 Dll-130 Shaft Not Req. E 500K2 4 507296

40、500KS2 4 507296 50K2 4 507299 Dll-123 Shaft Not Req. E 10K2 4 507297 W-lOKf 20002 2 507305 20002 2 507304 W-2000* Note 1. Use original Insulating wasm CLAROSTAT INSTALLATION NOTES PART No. AM-63-Z Volume control See Note 1 KSS-3 Attach to R1A Per Instructions SW-A 43-2000; Width Control AM-55-S Hori

41、z. Hold Control KSS-3 Attacn to R3A Per Instructl ons 15/16-58-S Vert. Hold Control 15/16-58-S Height Control AM-44-S Brightness Control KSS-3 Attach to R6A Per Instructions 43-10W Foous Control Contrast Control 43-2000/ Vert. Linearity Control rs and lug sleeve to isolate control from chassis. t Fi

42、le slot in shaft for screw driver. ITEM No. RIO Rll R12 R13 R14 R15 R16 R17 R18 R19 R20 R21 R22 R23 R24 R25 R26 R27 R28 R29 R30 R31 R32 R33 R34 R35 R36 R37 R38 R39 R40 R41 R42 R43 R44 R45 R46 R47 R48 R49 R50 R51 R52 R53 R54 R55 R56 R57 R58 R59 R60 R61 R62 R63 R64 R65 R66 R67 R68 R69 R70 R71 R72 R73

43、R74 R75 R76 R77 R78 R79 R80 R81 R82 R83 R84 R85 R86 R87 R88 R89 R90 R91 R92 R93 R94 R95 R96 R97 R98 R99 R100 R101 R102 R103 R104 R105 R106 R107 R108 R109 R110 Rill R112 R113 R114 R115 R116 RATING RESISTANCI 100K2 682 56002 10002 56002 56002 10K2 10K2 2202 10K2 5600 102 10S2 10002 5600S2 10002 822 56

44、002 10002 82002 8SS2 56002 10002 10002 56002 822 56002 82002 10002 10002 682 56002 10002 100K2 47K2 682 82KS2 82002 -| flflO -LUUM 1 Meg. 120S2 10K2 82002 1 Meg. 12K2 470K2 10002 10K2 10 Meg. 33K2 33K2 470K2 22K2 470K2 1802 10K2 1 Meg. 2702 22K2 220K2 180K2 47002 47002 10002 100K2 390K2 150KS2 2200S

45、 1 Meg. 3302 18K2 4702 3302 18K2 2702 18002 22002 560K2 220K2 3.9 Meg. 220K2 100K2 1002 1002 002 002 1002 1002 2202 472 5602 470K2 6K2 1 Meg. 150K2 5602 15002 82002 10K2 1002 1002 OOK2 02 002 02 ooa 0002 WATT X 4 4 4 4 4 4 4 4 4 4 4 I I 4 4 l 4 4 4 j. | I 1 5 1 Z i 2 X Z , . V ; p 4 2 REPLACEMENT DA

46、TA STEW. WARN. PART No. 510172 510115 510150 510137 510150 510150 510154 510154 510124 510154 510150 510100 510100 510137 510150 510137 510117 510150 510137 510153 510117 510150 510137 510137 510150 510117 510150 510153 510137 510137 510115 510150 510137 510173 510166 510115 510171 510153 510119 510

47、191 510120 510155 510253 510191 510156 510185 510137 510155 510197 510163 510163 510185 510160 510185 510223 510155 510191 510126 510160 510179 510177 510149 510149 510137 510173 510719 510176 510143 510191 510128 510159 510130 510127 510159 510126 510141 510143 510186 510178 510714 510178 510173 51

48、0119 510119 510119 510119 510119 510119 510716 510213 510332 510185 510168 510191 510176 510332 510139 510153 510155 510119 510119 510173 510101 510119 510101 510119 510713 IRC PART N( BTS-5600 BTS-1000 BTS-5600 BTS-5600 BTS-1000 BTS-1000 BTS-5600 BTS-1000 BTS-8200 BTS-5600 BTS-1000 BTS-1000 BTS-560

49、0 BTS-8200 BTS-1000 BTS-1000 BTS-5600 BTS-1000 BTS-100K BTS-47K BTS-82K BTS-8200 BTS-1 Meg. BTS-10K BTA-8200 BTS-1 Meg. BTS-12K BTS-470K BTS-1000 BTS-10K BTS-10 Meg BTS-33K BTS-33K BTS-470K BTS-22K BTS-470K BW-1-180 BTS-10K BTS-1 Meg. BTS-22K-5S BTS-220K BTS-180K BTS-4700 BTS -4700 BTS-1000 BTS-100K BTS-390K BTS-150K BTS-2200 BTS-1 Meg. BTA-330 BTS-18K iTS-470 3TS-18K JTS-1800 3TS-2200 BTS-560K BTS-220K BTS-3.9 Meg BTS-220K BTS-100K AB-225 W-2-47 W-2-560 TS-470K TS-56K BTS-1 Meg. JTS-150K 3W-2-560 BTS-1500 BTS-8200 BTS-10K TS-100K W-2-3300 PAGE 14 RadioFans.CN PARTS LIST