Infinity-KappaOne caramp 电路图.pdf

《Infinity-KappaOne caramp 电路图.pdf》由会员分享，可在线阅读，更多相关《Infinity-KappaOne caramp 电路图.pdf（26页珍藏版）》请在收音机爱好者资料库上搜索。

1、 Kappa One Kappa One 1 CHANNEL POWER AMPLIFIER SERVICE MANUAL Infinity Systems Incorporated 250 Crossways Park Dr. Woodbury, New York 11797 Rev0 11/2008 Released 2008 Discontinued XXXX RadioFans.CN 收音机爱 好者资料库 - CONTENTS - SPECIFICATIONS .1 PACKING.2 CONTROL/INSTALLATION INSTRUCTIONS.3 CONTROL/INSTAL

2、LATION DRAWINGS.4 BASIC TROUBLESHOOTING5 DISASSEMBLY INSTRUCTIONS.6 EXPLODED VIEW/PARTS LIST.7 AMPLIFIER BLOCK DIAGRAM.8 ELECTRICAL PARTS LIST .9 P.C.B. DRAWINGS.14 IC/TRANSISTOR PINOUTS.20 SCHEMATICS.23 Kappa One Specifications Output Power: 500W RMS x 1 channels 4 ohms; 1% THD + N (14.4V supply) 8

3、00W RMS x 1 channels 2 ohms; 1% THD + N Total Peak Power 1600W Signal-to-noise ratio: 85dBA (reference 1W into 4 ohms) 109dBA (reference rated power into 4 ohms) Frequency response: 20Hz 320Hz (3dB) THD+N 1KHz LPF=22KHz 0.05% (rated power 4 ohms) Input Impedance 20K ohms Maximum input signal: 6.0V M

4、aximum sensitivity: 200mV Bass Boost 20-100Hz 0-12dB DC Offset 30mV Idle Current 4 ohms 1.6A Max Current Draw 76A Remote Operating Voltages OFF 4V Circuit Protection Temperature (80C), Short circuit, over/under voltage Operating voltage range (8-16V) Dimensions: 13 x 7 x 1 ” (329 x 179 x 44mm) Fuses

5、: (3) x 40A Infinity Systems continually strives to update and improve existing products, as well as create new ones. The specifications and details in this and related JBL publications are therefore subject to change without notice. KAPPA ONE 1 RadioFans.CN 收音机爱 好者资料库 KAPPA ONE 2 RadioFans.CN 收音机爱

6、好者资料库 Installation Warnings and Tips Disconnect the negative () lead from your vehicles battery. Attheinstallationsites,locateandmakeanoteofallfuel lines, hydraulic brake lines, vacuum lines and electrical wiring. Use extreme caution when cutting or drilling in and around these areas. Chooseasafemou

7、ntinglocationawayfrommoisture. Makesurethereissufficientaircirculationatthemount- ing location for the amplifier to cool itself. Mounttheamplifier,usingthesuppliedhardware. Specifications CEA-2006A-compliant 0 Speaker Output Connectors Connectthespeakerstotheseterminals,observing proper polarity. Go

8、ld screws indicate +, and silver screws indicate . Minimumspeakerimpedanceis2ohms. 1 Fuses Replaceonlywiththesametypeandrating. 2 Power Input Connectors +12V:Connecttothepositiveterminalofthevehicles battery. Install an appropriate fuse holder and fuse (120Aminimum)within18”(457mm)ofthebattery. Make

9、surethewireisnotdamagedorpinchedduring installation. Install protective grommets when routing wires through the firewall or other sheet metal. GND:Connecttothevehicleschassis.Refertothe illustration below. REM:Connecttothe“RemoteOut”leadfromthe source unit or to a source of switched +12V(ACC). 4 AWG

10、 Adapter Forpowerwirelongerthan4(1.2m),4AWGwireis recommended. Use the adapter to make the connection according to the illustration below. 3 DBO: Variable Subsonic High-Pass Filter With Variable Boost (Q) Forwoofersintuned(vented)enclosures,setthe frequency control to a value 10Hz below the enclo- s

11、ures resonance (tuned) frequency. Forwoofersinsealedboxes,setthecontroltoany value you prefer between 30Hz and 50Hz. SettheBoostcontrolaccordingtoyourpreference, being careful not to apply enough boost to damage your woofer(s). A DBOBoostcontrolprovidesupto12dBofboost, slightly above the high-pass f

12、ilters frequency. See above for appropriate settings. B DBOHigh-PassFilterFrequencycontrol,variable between 10Hz and 80Hz. See above for appropri- ate settings. 4 Crossover-Frequency Control 12dB/octavecrossover,variablefrom32Hzto320Hz. See for the adjustment procedure. Input Level Control Usedtomat

13、chtheinputleveloftheamplifierto the output level of the source unit. See A for the adjustment procedure. Input Connectors Connecttofrontoutputsfromthesourceunitor signal processor. Aux Output Connectors Nonfilteredpass-throughoutput.Connecttothe input of an additional subwoofer amplifier. Protect LE

14、D Illuminatedunderanyofthefollowingfault conditions: battery over/under voltage; short circuit in speaker wires; amplifier is too hot; amplifiers output circuit has failed (DC voltage present in the amplifiers output). Power On LEDs Illuminatedwhentheamplifierison. A Setting Input Level A TurnInputL

15、evelcontrolcounterclockwiseto6V. B With a dynamic music track playing, turn the head unitsvolumecontroltothe3/4position. C Turn Input Level control clockwise until the bass output is proportionate to the output of the high- frequency speakers, according to your preference. D Input level is now adjus

16、ted correctly. Setting the Crossover A Crossover setting for subwoofers. Note: Acceptable frequency ranges indicated in gray. Factory BoltRing Connector Ground Wire Note: Remove any paint below ring connector. Star Washer 3a ENGLISH 0058CSK - Infinity Kappa One OM Cover HIGH.indd 529/09/08 15:49:10

17、KAPPA ONE 3 A ABCD 3x4x1x 1x AB 3a ENGLISH 0058CSK - Infinity Kappa One OM Cover HIGH.indd 429/09/08 15:49:10 KAPPA ONE 4 Amplifier Troubleshooting Guide 1. Status LED on Amplifier not Lit - Head Unit (Source) Turned ON Verify: A. Remote turn-on wire from source to amplifier has proper voltage B. Po

18、wer (B+) connections at amplifier, terminal blocks, and battery are secure C. Ground (GND) connections at amplifier and vehicle chassis are secure D. Battery B+ fuse (if used) is OK E. Amplifier fuse is OK F. B+ at battery and B+ at amplifier has proper voltage 2. Status LEDs Lit, No Output from Spe

19、akers in Normal Operating Condition Verify: A. RCA cables from amplifier to source are securely connected B. Volume adjustment on amplifier is correctly adjusted C. Source is ON and playing 3. Engine Noise From Speaker(s) Turn source OFF, Disconnect RCA cables at amplifier. If noise stops, check equ

20、ipment it will be attached with a cable so unplug at Molex connector CN1 For any component repair, the entire PCB must be removed from the heatsink 5) Remove the Output end panel, four Phillips screws. 6) Remove the single remaining Phillips screw on the bottom of the heatsink 7) Remove all Phillips

21、 screws holding the Aluminum transistor clamps on 8) Slide the complete PCB out of the heatsink channel. KAPPA ONE 6 KAPPA ONE 7 1234 A B C D 4321 D C B A OP OP OP OP OPOP 11253201132050 AMP SPEAKER GAIN CONTROL BASS BOOST VARIABLE 0dB-12dB MODEL FREQ VARIABLE LP 11HZ-320HZ/12dB MAIN AMP FRONTL 2ohm

22、/4ohm AUX OUT L AUX OUT R + - Battery +VCC -VCC +5V -5V +15V -15V POWER SUPPLY 1 2 3 4 5 6 7 8 OP OP RJ45 R L 102580 MODEL FREQ VARIABLE HP 10HZ-80HZ/12dB KAPPA ONE 8 KAPPA ONE Electrical Parts List Part NumberQtyReference Designator Main PCB Resistors 0702-0106-03Resistor0.1 1% 1.5 10.5MM H16.5MM47

23、R R127 R126 R124 0701-A123-02ResistorSMD 1W 12K 5% 251261R 2R 4R 3R R177 R176 0702-3103-02Resistor 1/2W 10K 5%12.5MM1R69 0701-54R7-02ResistorSMD 4.7 1/2W 5% 25121R119 0705-5470-04Resistor 5W 47 5% 13.5*9*23MM1R142 0701-2100-03ResistorSMD 10 1/8W 1% 08056R112 R111 R110 R109 R108 R107 0712-64R7-02Resi

24、stor 2W 4.7 5% 10MM 1R139 0701-A220-02ResistorSMD 22 1W 5% 25123R168 R167 R169 0704-6221-02Resistor 2W 220 5% 1R136 0701-3220-02ResistorSMD 22 1/4W 5% 120626R 5R 0702-3331-02Resistor 1/2W 330 5%12.5MM2R67 R66 0701-2101-03ResistorSMD 100 1/8W 1% 080519 R188 R187 R166 R165 R164 R162 R161 R160 R47 R190

25、 R189 R144 R128 R90 R89 R86 R74 R125 R101 0703-3222-03Resistor 1/2W 2.2K 1% 1R131 0701-3101-02ResistorSMD 100 1/4W 5% 12062R179 R178 0706-A222-02Resistor 2.2K 10W 22.5*13*13MM 5% 1R130 0701-2221-03ResistorSMD 220 1/8W 1% 08052R3 R60 0701-2821-02ResistorSMD 820 1/8W 5% 08051R50 0701-2221-03ResistorSM

26、D 220 1/8W 1% 08051R2 0701-2102-03ResistorSMD 1K 1/8W 1% 08057R41 R42 R158 R157 R18 R54 R53 0701-2182-02ResistorSMD 1.8K 1/8W 5% 08051R19 0701-2222-02ResistorSMD 2.2K 1/8W 5% 08054R37 R135 R185 R140 0701-2302-03ResistorSMD 3K 1/8W 1% 08051R29 0701-2472-03ResistorSMD 4.7K 1/8W 1% 08051RX 0701-2512-02

27、ResistorSMD 5.1K 1/8W 5% 08053R38 R81 R82 0701-2432-03ResistorSMD 4.3K 1/8W 1% 08051R27 0701-2103-03ResistorSMD 10K 1/8W 1% 08059R61 R87 R22 R21 R28 R17 R33 R34 R197 0701-2333-03ResistorSMD 33K 1/8W 1% 08053R31 R30 R184 0701-2223-03ResistorSMD 22K 1/8W 1% 08054R36 R20 R4 R1 07012487YK03ResistorSMD 4

28、8.7K 1/8W 1% 08051R80 0701-2473-03ResistorSMD 47K 1/8W 1% 080522 R5 R25 R24 R194 R181 R77 R26 R14 R11 R8 R7 R10 R180 R59 R196 R195 R75 R68 R23 R13 R9 R6 0701-2183-03ResistorSMD 18K 1/8W 1% 08051R12 0701-2104-03ResistorSMD 100K 1/8W 1% 08054R83 R63 R62 R16 0701-2622-03ResistorSMD 6.2K 1/8W 1% 08051R3

29、5 0701-2332-03ResistorSMD 3.3K 1/8W 1% 08051R134 0701-2511-02ResistorSMD R0805 510 1/8W 5% 1R39 0701-2133-02ResistorSMD 1/8W 13K 5% 08051R15 0701-2164-03ResistorSMD 160K 1/8W 1% 08051R40 0704-4123-02Resistor 1W 12K 5% 15MM1R120 0701-2682-03ResistorSMD 6.8K 1/8W 1% 08051R32 1204-2040-01VR, HP FREQB20

30、0K/B2K L=15 10% B200K,B2K1VR3 1204-2030-01VR, LEVEL B20K L=15 10% 2.5dB1VR1 1204-5031-30VR, LP FREQB50K 10% :R0971G KQ1VR2 1204-5011-01VR, BOOSTB500 KQ L=15 15%1VR4 Capacitors 06D1C3357700Capacitor 3.3UF/100V 10% MAX：24*18.5*10.5MM 20MM CBB21 1C105 06D2C335C701Capacitor 3.3UF/250V 20% 105 27mm CBB21

31、1C96 06D2C1067001Capacitor 10UF/100V20% 20MM 10.5MM5C141 C106 C101 11C 12C 06D212266010Capacitor 22uF/50V 20% 5*11 1055.0MM11C9 C6 C5 C11 C41 C31 C10 C8 C7 C4 C3 06D102266000Capacitor 22UF/50V 10% 6.3*11 85 NP1C119 06D214765000Capacitor 47UF/35V 20% 5*11 1055MM3C50 C49 C35 06D211073116Capacitor 100U

32、F/16V 20% 5*11 1055MM3C131 C130 C129 06D214775101Capacitor 470UF/35V 20% 8*20MM 105 3C134 C133 C127 Description KAPPA ONE 9 Part NumberQtyReference DesignatorDescription Main PCB 06D212285001Capacitor 2200UF/35V 16*26MM 20% 105 7.5MM SUSCON 4C112 C111 C110 C109 06D213387002Capacitor 3300UF/100V 35MM

33、*25MM 20% 105 4C148 C147 C146 C145 06D231047000Capacitor 0.1uF/100V 20%5MM1C122 06D3C104C701Capacitor 104/250V 5% 5mm3C139 C86 C65 06D942247401Capacitor 224/100V 2% 7.2*8.5*3.5MM 5MM 2C103 C102 06D184717400Capacitor 471/100V X7R 10% 1C124 06D1C4747701Capacitor 474/100V 10% 7.5mm4C99 C98 C152 C135 06

34、D342749400Capacitor 274/63V 5% 5MM1C2 06D344737400Capacitor 473/100V 5% 1C47 06S15101F000CapacitorSMD 101/1KV 10% X7R 12061CX100 06D941247401Capacitor 124/100V 2% 7.2*6.5*3.0MM 5MM 1C46 06S15222F000CapacitorSMD 222/1KV 10% X7R 12061C97 06D322227200Capacitor 222/100V 5% 5MM 415C CX1 C24 C23 06S321006

35、000CapacitorSMD 10pF/50V 0805 NPO 5%3C14 C12 C13 06S322206000CapacitorSMD 22pF/50V 0805 NPO 5%2C33 C32 06S321016000CapacitorSMD 100pF/50V 0805 NPO 5%13 C40 C22 C36 C15 C44 C38 C37 C17 C16 14C 13C 3C 4C 06S121046000CapacitorSMD 0.1uF/50V 0805 X7R 10%28 C121 C120 C138 C137 C118 C76 C51 C48 C21 C20 C19

36、 C18 C108 C90 C115 C128 C116 C29 C28 C27 C26 JP428 JP426 7C 5C 8C 2C 1C 06S321026000CapacitorSMD 1000pF/50V 0805 NPO 5%4C42 9C 6C C25 06S121244000CapacitorSMD 0.12UF/25V 0805 X7R 10%1C123 06S124716000CapacitorSMD 470pF/50V 0805 X7R 10%4C30 C150 C149 CX2 06S131037000CapacitorSMD 103/100V X7R 10% 1206

37、2C126 C125 06D201066200Capacitor 10UF/50V 20% 5*11 85 5mm2C34 C39 06D2410644CBCapacitorSMD 10uF/25V CASE-D 20% 2C76 C136 06D212256301Capacitor 2.2UF/50V 20% 5*11 105 5mm 1C43 06D348249400Capacitor 824/63V 5%1C1 Semiconductors 04ZL-6A10-00Diode 6A10 1000V1D17 04ZL-4007-03Diode 1N4007 DO-41 1D16 04GS-

38、R104-00Diode FR104 1A 400V 52MM 4D29 D28 D27 D26 03D1-TP50-24MOSFET TP50N20P TO-2206Q14 Q13 Q12 Q11 Q10 Q9 01FA-7812-04RegulatorKA7812E TO-220 FAIRCHILD +12v2U13 U15 01FA-7912-04RegulatorKA7912 TO-220 FAIRCHILD -12v1U14 04PT-4148-01DiodeSMD 1N4148 DO-213AA13 D51 D1 DX1 D2 D14 D13 D12 D11 D10 D9 D6 D

39、3 D4 04ZL-2512-00DiodeSMD MUR120 1A 25122D35 D34 2202-1602-05Bridge UF1602CT AKA 16/200V TO-220 2D31 D30 03N1-5551-04TransistorSMD MMBT5551LT1 NPN SOT-23 1Q3 2202-20RG-05Bridge MUR1620RG KAK 16A/200V TO-220 ON SEMI 2D33 D32 03N1-2222-04TransistorSMD BT2222 SOT-23 NPN1Q29 04WY-51AV101DiodeSMD 5.1V DO

40、-213AA 0.5W2DZ3 DZ2 04ZL-4007-02DiodeSMD FM4007 DO-214AC3D25 D24 D23 0100-M833-08Dual Op-ampSMD LM833 SOP-87U6 U3 U7 U1 U5 U4 U2 04GS-RS1G-02DiodeSMD RS1G 400V 1A DO-214AC5D22 D21 D20 D7 D5 03T1-3205-02MOSFET IRF3205 110A 50V TO-220 6Q28 Q27 Q26 Q24 Q23 Q22 03T1-K30A-01FET 2SK30A TO-92 1Q1 01TI-L072

41、-09Dual Op-ampSMD TL072 SO-811U1 04WY-12BV101DiodeSMD 12V DO-213AA 0.5W1DZ1 0100-78M1-07RegulatorSMD 78M12 TO-252 +12v1U8 Miscellaneous 1404-0020-04RCA QUAD AV4-8.4-38 JACKS1J1 1601-403G-01Fuse 40A/32V UL Littelfuse6F1 1401-0001-03Fuse holder 3PIN :BXS3-091for F1 1380-0214-00Temperature switch 905 T

42、O-220 PCS1SW1 1003-1002-08InductorSMD 10UH CPL-0805 20MA 20%2L1 DX2 KAPPA ONE 10 Part NumberQtyReference DesignatorDescription Main PCB 3000-MONE-01HF transformer 4:24:6:7 F1=F2=1.0*8*4TS S1=S2=0.8*5*24TS S3=S4=0.8*1*6TS S5=S6=0.8*1*7TS 1L8 2901-224C-00RelayYL-224-C DC12V 30A 1RL1 1004-3003-10Induct

43、or 90 30UH 1252L12 L11 1001-1820-10Inductor 32 1.8MH L1=L2 1.0*12 4TS 38*22MM 42MM 1L6 1001-4000-10Inductor40UH 40A ETD-49 0.1*80*14TS1L4 1501-0300-04Terminal JS23A-25A 3PIN POWER1CN3 1501-0400-02Terminal JS24A-23A 4PIN 2个2个 SPEAKER1CN2 1501-0404-00Socket Pitch 2.0MM 4PIN1CN1 24D1-0070190GroundingUL

44、1015#18AWG L=70MM 2JK1 JK2 1001-3501-10Inductor 35UH 330.3*18*2 29MM1L5 2102-0052-04FFC4P 1430.26L=80MM一5MM一2.01051connect to the LED board 1501-0300-05Terminal3P JSZ3-83 1801Accessory 1400-0001-16RJ45 socket 16PIN RJ45 10P16C1RJ1 PWM PCB Resistors 0701-2221-03ResistorSMD 220 1/8W 1% 080512R65 0701-

45、2102-03ResistorSMD 1K 1/8W 1% 080552R156 2R155 2R5 R8 R9 0701-2202-02ResistorSMD R0805 2K 1/8W 5% 22R33 2R138 0701-2222-02ResistorSMD 2.2K 1/8W 5% 080522R200 2R132 0701-2472-03ResistorSMD 4.7K 1/8W 1% 080522R147 2R46 0701-2682-03ResistorSMD 6.8K 1/8W 1% 080512R102 0701-2103-03ResistorSMD 10K 1/8W 1%

46、 080552R99 2R137 2R78 2R34 2R146 0701-2113-03ResistorSMD 11K 1/8W 1% 080512R171 0701-2123-03ResistorSMD 12K 1/8W 1% 080522R35 2R149 0701-2183-03ResistorSMD 18K 1/8W 1% 080512R1 0701-2203-03ResistorSMD 20K 1/8W 1% 080512R104 0701-2303-02ResistorSMD 30K 1/8W 5% 080512R175 0701-2333-03ResistorSMD 33K 1

47、/8W 1% 080512R98 0701-2473-03ResistorSMD 47K 1/8W 1% 080572R3 2R44 2R97 2R4 2R20 2R145 2R19 0701-2753-03ResistorSMD 75K 1/8W 1% 080512R103 0701-2104-03ResistorSMD 100K 1/8W 1% 080532R2 2R148 2R154 Capacitors 06S321026000CapacitorSMD 1000pF/50V 0805 NPO 5%12C143 06S121047000CapacitorSMD 104/100V 0805

48、 X7R 10%12 2C1 2C132 2C84 2C81 2C22 2C79 2C117 2C82 2C34 2C80 2C89 2C151 06D252274000Capacitor 220UF/25V 8*9 20% 10522C88 2C87 06D211074101Capacitor 100UF/25V 6.3*7mm 5mm 20% 10512C2 Semiconductors 04PT-4148-01DiodeSMD 1N4148 DO-213AA10 2D1 2D42 2D46 2D47 2D45 2D43 2D2 2D5 2D18 2D19 03N1-5551-04TransistorSMD MMBT5551LT1 NPN SOT-23 10 2Q38 2Q8 2Q7 2Q5 2Q6 2Q37 2Q2 2Q33 2Q3 2Q4 03P1-5401-04TransistorSMD MMBT5401LT1 PNP SOT-2312Q32 01TI-L494-09PWMSMD TL494C SO-1612U18 04WY-39AV101DiodeSMD 3.9V DO-21