Denon,DCD-1500AE_service.pdf

《Denon,DCD-1500AE_service.pdf》由会员分享，可在线阅读，更多相关《Denon,DCD-1500AE_service.pdf（88页珍藏版）》请在收音机爱好者资料库上搜索。

1、SERVICE MANUAL SUPER AUDIO CD PLAYER MODEL DCD-1500AE TOKYO, JAPAN Denon Brand Company, D Number of times to error generating. ) 表 5 表 No.内容FL 管表示 1 ( Back End ) E1 * 2不良 E2 * 3 E2 * 4 E2 * 5 E4 * 6 (Front End ) E5 * 7 E6 * 8通信 E7 * 9無 NO DISC * (* ; 発生回数 ) 表 判別情報 PI level 計算式：PI level (V) = 測定値 1.6

2、 256 - 無効 表 種別情報 Mirr CountMirr WidthFZC CountPI Level No Disc2 3 以外- CD 高反射20 x8ED 以上-0 x99 以上 CD 低反射20 x8ED 以上-0 x98 以下 DVD 高反射20 x8ED 以下10 x81 以上 DVD 低反射20 x8ED 以下10 x80 以下 DVD 2 層20 x8ED 以下2- SACD Hybrid3- Disc TypeMedia 0 x00No Disc 0 x01Unknown Disc 0 x04DVD Single 高反射 0 x05DVD Dual Parallel 低

3、反射 0 x06DVD Dual Opposite 低反射 0 x08CDDA 高反射 0 x0AVCD 高反射 0 x44DVD Single 低反射 0 x48CDDA 低反射 0 x4AVCD 低反射 0 x8FSACD Hybrid Disc 19 DCD-SA11 BLOCK DIAGRAM 1U-3714-2 POWER UNIT CX023 (BLK) CX082 (8)+12V_M1 (7)GND_M (6)+8V_M1 (5)GND_M (4)+5V_A (3)GND_A (2)+5V_B (1)GND_B (1)+5V_U (2)GND_DISP (3)?32V (4)F+

4、 (5)F? 7805 2412 7812 7912 7808 CX024 (BLU) CX026 (WHT) CX081 CX051 5P-PH CX054 (1)+16V_MU (2)GND_RL (3)+12V_A (4)GND_A (5)?12V_A FL Driver ; M66005-0001AHP 1U-3714-1 DISPLAY UNIT (Remocon) CY052 5P-PH CY112 (11)KEY2 (10)KEY1 (9)KEY0 (9)GND_+5V(9)GND_+5V (7)REMOTE (6)GND_+5V(6)GND_+5V (5)FRES (4)FCE

5、N (3)FCLK (2)FDAT (1)GND_5V(1)GND_5V 1U-3714-5 P.SW UNIT CY024 BA330FP GND_A GND_A GND_DGND_D BD9702 (1)+5V_U (2)GND_DISP (2)GND_DISP (3)?32V (4)F+ (5)F? MUT1 H/P OUT (1)MUT1 (2)H/P_L (3)GND_A (4)H/P_R 1U-3624 SACD MODULE INIT CXD2753 (SACD Dec) CXD1885 (F/E Prosessor) PLD EPM3128 DVD DRIVE MECH TD-

6、5HP-D6-DE CXD1881 (RF Amp) FAN8042 (Act Driv) AN8471 (Spi Driv) CX241 (27)DIR_RST2 (26)ROM_RST (25)VPP (24)GND (23)SPDIF (22)GND (21)MCLK (20)GND (19)DLINKCD (18)DL_ON (17)DIT_CE (16)GND (11)(15) (10)RST2 (19)DSCLK (20)DSDI (7)GND (6)DSRST1 (5)DSCS1 (4)EXT/INT (3)MUT1 (2MODE (1)GND MCLK 768FS SPDIF

7、(29)GND (28)PCM_DATA (27)PCM_LRCK (26)GND (25)PCM_BCK (24)GND (23)DSAL (22)DSAR (21)DSALS (20)DSARS (19)DSAC (18)DSASW (17)GND (16)DSDBCK (15)GND (14) SEL4fs (13)RST3 (12)DSD/PCM (11)GND (10)EXT_SEL (9)(7)AL_Test3 (6)(1)OPEN (1)CD_SEL (2)DSD_NORM (3)AL_Test3 (4)AL_Test4 (5)AL_Test5 CX151 1M SRAM 16M

8、 SDRAM 16M DRAM CX052 ucon M30625FGPGP (1)KEY2 (2)KEY1 (3)KEY0 (4)GND (4)GND (5)REMOCON (6)GND6)GND (7)FRRST (8)FCS (9)FCLK (10)FDAT (11)GND (11)GND 29PFFC 27PFFC 5PZH (OPEN) (1)+12V_M1 (2)GND_M (2)GND_M (3)+8V_M1 (4)GND_M (4)GND_M (5)+5V_A (6)GND_A (6)GND_A (7)+5V_B (8)GND_B(8)GND_B 11P FFC (9)(7)A

9、L_Test3/4/5 PURE DIRECT H/P VR CY042 4P-PH 1U-3713-3 H/P UNIT 1U-3713-1 AUDIO UNIT CX042 4P-PH ANALOG OUT OPT OUT DIGITAL OUT COAX OUT DSD1791 DARD MODE MUT1 SO1L DBCK LRCK PBCK SCK DSD/DXP_DI DSD/DXP_CL DSD_CS DSD_RST 7805 BA033 Vout_+L Vout_?L Vout_+R Vout_?R Lch Rch GND_D1GND_D1 MODE 157 33.8688M

10、Hz Master CLOCK 33.8688MHz Master CLOCK DXP6001AF SO1R DSAL (1)+16V_MU (2)GND_RL (2)GND_RL (3)+12V_A (4)GND_A (4)GND_A (5)?12V_A (1)GND_D1(1)GND_D1 (2)PCM_DATA (3)PCM_LRCK (4)GND_D1 (4)GND_D1 (5)PCM_BCK (6)GND_D1 (6)GND_D1 (7)DSAL (8)DSAR (9)DSALS(OPEN) (10)DSARS(OPEN) (11)DSAC(OPEN) (12)DSASW(OPEN)

11、 (13)GND_D1 (13)GND_D1 (14)DSDBCK (15)GND_D1 (15)GND_D1 (16)SEL_4fs(OPEN) (17)RST3(OPEN) (18)DSD/PCM(OPEN) (19)GND_D1 (19)GND_D1 (20)EXTSEL(OPEN) (21)(23)(OPEN) (24)(29)(OPEN) (1)DIR_RST2(OPEN) (2)ROM_RST(OPEN) (3)VPP(OPEN) (4)GND_D1 (4)GND_D1 (5)SPDIF (6)GND_D1 (6)GND_D1 (7)MCLK (8)GND_D1 (8)GND_D1

12、 (9)DSD_RST (10)DL_ON(OPEN) (11)DSD_CS (12)GND_D1 (12)GND_D1 (13)DSD/DXP_CL (14)(DIR_INT(OPEN) (15)DSD/DXP_DI (16)DIR_DO(OPEN) (17)DXP_CS (18)RST2(OPEN) (19)DXP_RST (20)DIR_DI(OPEN) (21)GND_D1 (21)GND_D1 (22)DF_RST(OPEN) (23)GAL_RST (24)EXT/INT(OPEN) (25)MUT1 (26)MODE (27)GND_D1(27)GND_D1 CY051 5P-P

13、H CY291 29PFFC (25)DSDL (24)DSDR (1)PLRCK (2)PBCK TRANS DXP_RST +3.3V_D2+3.3V_D2+5V_A1 +5V_A1 +5V_D2+5V_D2 7WHCU04 74HCT7007 7SHU04 74HCT7007 JUMPER 1U-3413-4 H/P UNIT CX035 (1)+5V_D1 (2)GND_D1 (3)+5V_DO (4)GND_DO (1)+5V_D1 (2)GND_D1 (2)GND_D1 (3)+5V_DO (4)GND_DO(4)GND_DO CX041 4P-PH 11A12111A121 BA

14、033 +3.3V_D1+3.3V_D1 7WHCU04 64fs +5V_D1+5V_D1 1?12 GAL16 (1)KEY2 (2)KEY1 (3)KEY0 (4)GND (4)GND (5)REMOCON (6)GND6)GND (7)FRRST (8)FCS (9)FCLK (10)FDAT (11)GND(11)GND 11A121 74HCT7007 +3.3V_D1+3.3V_D1 +5V_D1+5V_D1 (11)KEY2 | (2)FDAT (1)GND(1)GND CX112 CY111 (4)DBCK GAL_RST CY041 4P-PH +3.3V CY271 27

15、PFFC 20 DCD-1500AE SEMICONDUCTORS Only major semiconductors are shown, general semiconductors etc. are omitted to list. 主半導体記載。汎用半導体記載省略。 1. ICs Note: Abbreviation ahead of IC No. indicates the name of P.W.B., etc. 注 ):IC No. 前記号、基板名称表。 AD : AUDIO P.W.B. PD : POWER/DISPLAY/HP P.W.B. SM : SACD MODULE

16、 P.W.B. CXD1885Q (SM: IC502) Pin Assignment 12345678910 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 9

17、2 93 94 95 96 97 98 99 100 101 102 103 104 105106107108109110111112113114115116117118119120121122123124125126127128129130131132133134135136137138139140141142143144145146147148149150151152153154155156 157 158 159 160 161 162 163 164 165 166 167 168 169 170 171 172 173 174 175 176 177 178 179 180 181

18、182 183 184 185 186 187 188 189 190 191 192 193 194 195 196 197 198 199 200 201 202 203 204 205 206 207 208 DVDD33 DVDD18 VMCHG TDO TCK TDI TMS TRST GIO19 GIO18 GIO17 GIO16 GIO15 GIO14 GIO13 DVSS GIO12 GIO11 GIO10 GIO9 GIO8 DVDD18 GIO7 GIO6 GIO5 GIO4 DVDD33 GIO3 GIO2 GIO1 GIO0 MODSEL2 DVSS MODSEL1 M

19、ODSEL0 TEST15 TEST14 TEST13 TEST12 TEST11 TEST10 TEST9 TEST8 TEST7 TEST6 TEST5 TEST4 TEST3 TEST2 TEST1 TEST0 RD8 DVDD33 DVDD33 DRVTX DRVRX DRVCLK DRVRDY C2PO DADT DOTK LRCK BCK EXVCO EXPLDT CSL SI SO SCLKH RFOKGH HFD MIRRORH DTC AVSS ATC HF TLC0 TLC1 IREF AVDD33 JMREF JMOUT CHG VFBC AVDD18 VCOI LPF1

20、 LPF2 RC AVSS AVSS AD0 AD1 AD2 AVDD33 AD3 AD4 AD5 AD6 AD7 AD8 AD9 VREFH VREFL AVDD18 ALCR MSEL0 MSEL1 MA0 MA1 MA2 MA3 MA4 MA5 MA6 MA7 MA8 TESTSEL MD0 MD1 MD2 MD3 MD4 MD5 DVSS MD6 MD7 MALE MCS MWR DVDD33 MRD MRDY MINT SYSCK DVDD18 XI XO DVSS VDT7 VDT6 DVSS VDT5 VDT4 VDT3 VDT2 VDT1 VDT0 HDRQ XHAC VEFG

21、 XSHD DCK DRVIRQ DRVRST DVDD18 DVDD18 RD9 RD10 RD11 RD12 RD13 RD14 RD15 RD0 RD1 RD2 RD3 RD4 RD5 DVSS RD6 RD7 XMWR XRAS RA0 DVDD18 RA1 RA2 RA3 RA4 DVDD33 RA5 RA6 RA7 RA8 RA9 DVSS RA10 RA11 XMOE XUCAS XLCAS GPWM5 GPWM4 GPWM3 GPWM2 GPWM1 GPWM0 SPWM2 SPWM1 FG AVSS DA3 (SLED2_TILT) DA2 (FSCON) DA1 (SLED)

22、 DA0 (TSCON) AVDD33 DRAM I/FPWM.FGD/A A/DData PLL/Data SlicerASP S-I/O, Defect etcAudio D/AVSTEM I/F VSTEM I/FClockB/E MCU I/F JTAGTest/Monitor PinGeneral Port 21 DCD-1500AE Block Diagram Functions (A/D : Analog/Digital, PU : Pull-up, PD : Pull-down, SMT=Schumitt ) No.Terminal NameI/OA/DClassificati

23、onFunctionPUPDSMT 1DVDD33PVDD 15 VC16 (3) SACD Dual Layer DTS Test Disc TCD-784 TCD-784 2 FSCON 3 FE 4 PI 5 MIRR 2 FSCON 3 FE 4 PI 5 MIRR 2 FSCON 3 FE 4 PI 5 MIRR 2 FSCON 3 FE 4 PI 5 MIRR 3 FE 2 FSCON 6 FOK 4 PI 3 FE 2 FSCON 6 FOK 4 PI 3 FE 7 TE 8 DMO 1 RFAC 3 FE 7 TE 8 DMO 1 RFAC 3 FE 7 TE 8 DMO 1

24、RFAC 3 FE 7 TE 8 DMO 1 RFAC 3 FE 7 TE 8 DMO 1 RFAC 3 FE 2 FSCON 6 FOK 4 PI 3 FE 2 FSCON 6 FOK 4 PI (2) SACD Hybrid DAC Test Disc Single Layer DTS Test Disc Single Layer DTS Test Disc (2) SACD (2) SACD 1 RFAC GND ; 15 VC16 GND ; 15 VC16GND ; 15 VC16 (4) SACD Hybrid DAC Test Disc GND ; 15 VC16GND ; 15

25、 VC16 GND ; 15 VC16GND ; 15 VC16 (3) SACD Dual Layer DTS Test Disc (1) CD (5) SACD Layer : SACD GND ; 15 VC16 (3) SACD Dual Layer DTS Test Disk Hybrid DAC Test Disk TCD-784 (4) SACD Hybrid DAC Test Disc (2) SACD GND ; 15 VC16 GND ; 15 VC16GND ; 15 VC16 GND ; 15 VC16 GND ; 15 VC16 GND ; 15 VC16 (4) S

26、ACD Layer : CD Hybrid DAC Test Disc Single Layer DTS Test Disk 75 DCD-1500AE 5. LOADER open-close 9 LD+ 10 LD- 11 OPN SW 12 CLS SW 10 LOAD- 9 LOAD+ 11 OPN SW 12 CLS SW GND ; 16 GNDGND ; 16 GND OPENCLOSEOPENCLOSE 76 DCD-1500AE NOTE FOR SCHEMATIC DIAGRAM WARNING: Parts marked with this symbol ! have c

27、ritical characteristics. Use ONLY replacement parts recommended by the manufactur- er. CAUTION: Before returning the unit to the customer, make sure you make either (1) a leakage current check or (2) a line to chassis resis- tance check. If the leakage current exceeds 0.5 milliamps, or if the resist

28、ance from chassis to either side of the power cord is less than 460 kohms, the unit is defective. WARNING: DO NOT return the unit to the customer until the problem is lo- cated and corrected. NOTICE: ALL RESISTANCE VALUES IN OHM. k=1,000 OHM M=1,000,000 OHM ALL CAPACITANCE VALUES IN MICRO FARAD. P=M

29、ICRO-MICRO FARAD EACH VOLTAGE AND CURRENT ARE MEASURED AT NO SIGNAL INPUT CONDITION. CIRCUIT AND PARTS ARE SUBJECT TO CHANGE WITHOUT PRIOR NOTICE. 配線図 ! 印部品安全維持重要部品。 従交換時必指定部品使用。 注） (1) 指定抵抗値 、 、M M 示。 (2) 指定値F、 F 示。 (3) 各部電圧無信号値示。 (4) 配線図基本配線図。改良等変更 了承。 SIGNAL LINE 1234567891011 A B C D E F G H SCH

30、EMATIC DIAGRAMS (1/6) DCD-1500AE 77 SCHEMATIC DIAGRAMS (1/6) 1U-3624C SACD MODULE UNIT (1/3) SIGNAL LINE 1234567891011 A B C D E F G H SCHEMATIC DIAGRAMS (2/6) DCD-1500AE 78 SCHEMATIC DIAGRAMS (2/6) 1U-3624C SACD MODULE UNIT (2/3) SIGNAL LINE 1234567891011 A B C D E F G H SCHEMATIC DIAGRAMS (3/6) DC

31、D-1500AE 79 SCHEMATIC DIAGRAMS (3/6) 1U-3624C SACD MODULE UNIT (3/3) SIGNAL LINE 1234567891011 A B C D E F G H SCHEMATIC DIAGRAMS (4/6) DCD-1500AE 80 SCHEMATIC DIAGRAMS (4/6) 1U-3713 AUDIO UNIT 1234567891011 A B C D E F G H SCHEMATIC DIAGRAMS (5/6) DCD-1500AE 81 SCHEMATIC DIAGRAMS (5/6) 1U-3714-1 DI

32、SPLAY UNIT 1U-3714-5 P.SW UNIT SIGNAL LINE 1234567891011 A B C D E F G H SCHEMATIC DIAGRAMS (6/6) DCD-1500AE 82 SCHEMATIC DIAGRAMS (6/6) 1U-3714-2 POWER UNIT 1U-3714-4 H/P UNIT 83 DCD-1500AE DOCUMENTS FOR WEEE Details of Recycle parts for Main Unit You have to remove the parts that marked “WEEE Mark

33、 when the recycling processing. (Europe model only) Ref. No. WEEE Mark Part NameMatrrialQty 1 AUDIO UNIT ASSY Complex1 2-1 DISPLAY UNITComplex1 2-2 POWER UNITComplex1 2-3 H/P VR UNITComplex1 2-4 H/P UNITComplex1 2-5 POWER SWITCH UNITComplex1 3 SACD MODULE UNIT ASSYComplex1 4REAR PANEL(E2) SECC1 5AC

34、INLET (2P) Complex1 6FOOT ASSY ABS4 7MECHA BRACKET BOTTOMSECC1 8TRANS BRACKET SECC1 9 POWER TRANS(E2)Complex1 10H/P BRACKETSECC1 11HOLDER (A) NYLON1 12CARD SPACER (L=18) NYLON2 13FRONT PANEL (SP) AL, ABS1 14KNOB(FUJI)ABS1 15WINDOW PMMA1 16ADJUST. COLLARC3604B2 17BLIND ASSY Complex1 18SPRING SUS2 19F

35、UNCTION KNOB (SP) ABS1 20OP/CL/FUNC KNOB (SP) ABS1 21SACD MECHA UNIT Complex1 22POWER KNOB ASSY AL, ABS1 23LOADER PANEL (SP) ABS1 24SACD PLATE Ni Electroforming1 25TOP COVER(SP) PVC, STEEL1 26DVD MECHA(TD-5HP-DE)Complex1 27MECHA BRACKET TOP SECC1 28CHASSIS SECC1 29CORD HOLDER (L50) Complex1 31RUBBER

36、 SHEET CR2 32WIRE BAND BASENYLON2 33CARD SPACER(L=4)NYLON2 354 W (S)PC2 SCREWS 1013X8 CFTS (S)-B STEEL37 1024X8 CBTS (S)-B STEEL4 1033X10 CBTS (P)-B STEEL12 1043P.SWELLING SCREW STEEL8 105SPECIAL SCREW STEEL2 1062.6X6 CBTS (S)-Z STEEL4 107FIXING SCREWSTEEL4 1083X8 CBTS (P)-Z STEEL2 1093X10 CFTS (P)-

37、ZSTEEL2 1103X8 CBTS (S)-B STEEL10 84 DCD-1500AE Exploded view of Main unit 25 26 21 16 27 22 15 20 29 33 37 32 32 11 12 12 29 29 28 19 23 14 24 13 31 35 18 10 17 104 104 104 110 107 110 110 106 101 101 101 101 101 110 110 103 103 103 102 101 101 101 108 109 101 101 101 101 105 2-5 2-4 2-3 2-2 2-1 5

38、4 3 7 9 8 1 6 You have to remove the parts that marked WEEE mark when the recycling processing. (Europe model only) 85 DCD-1500AE Details of Recycle parts for Mechanism unit You have to remove the parts that marked “WEEE Mark when the recycling processing. (Europe model only) Ref. No. WEEE Mark Part

39、 NameMaterialQty 1MAIN CHASSIS ASSYComplex1 2CLAMPER BRACKETSteel1 3GUIDE CLAMP BRACKETSteel1 4LOADING MOTOR ASSYComplex1 5LOADING GEARPOM1 6LOADING GEAR 2NDPOM1 7LOADING GEAR 3RDPOM1 8SUB CHASSIS-LPC+ABS1 9SUB CHASSIS-RPC+ABS1 10TRAYPC+ABS1 11SLIDE-CAMPOM1 12TRAVERSE ARMPC1 14CLAMPER HPOM1 15CLAMPE

40、R LPOM1 16LOADING BELTRubber1 17 SWITCH P.W.B.Complex1 185P PH WIREComplex1 19SWITCH ESE22MH21Complex1 20SWITCH ESE22MH23Complex1 21POLY.SLIT WASHER 2.6X6X0.25CPOLY3 22WIRE CLAMPERPOM1 23PRECISION SCREW 1.7X2.2 TYPE3Steel2 24SCREW 2.6X6 CBTS(B)-ZSteel6 25PRECISION SCREW 2X3(S) TYPE3Steel1 26SCREW 2X

41、6 CBTS(P)-ZSteel2 27A TRAVERSE MECHA (FEED) ASSY Complex1 23PRECISION SCREW 1.7X2.2 TYPE33 27PU CHASSIS ASSY1 28SHAFT HOLDER L1 29SHAFT HOLDER R1 30SHAFT TILT BASE1 31SHAFT TILT PLATE1 32TILT SPRING2 33MAIN SHAFT1 34SUB SHAFT1 35PU RACK GEAR1 37PICK UP HOP-1200R1 38PU SPRING1 39SHAFT SPRING1 40RACK

42、GEAR SPRING1 42T/T MOTOR ASSY1 43SCREW 2.6X6 CBTS(S)-Z2 44SCREW 2.6X4 CBTS(S)-Z1 46SCREW 2.6X15 CFTS(S)-Z2 47SCREW 3X4 BSS2 48SCREW 3X8 BSS (A)1 55PRECISION SCREW 1.7X5 TYPE31 23PRECISION SCREW 1.7X2.2 TYPE32 36FEED GEAR 2ND ASSY1 41FEED MOTOR ASSY1 50POLY.SLIT WASHER 2.1X4X0.25C2 53FEED GEAR 3RD1 8

43、6 DCD-1500AE 49DAMPERSilicon4 51DAMPER SCREWSteel4 54TRAY-SPRING-VXFSUS1 56RUBBER CUSHIONRubber2 57PLATE-RE-2HPCSteel2 58WF-PLATE-RE-2HPC-2 59PRECISION SCREW 2X4(P) TYPE1Steel2 6624P FFC CABLE L=70 Complex1 Ref. No. WEEE Mark Part NameMaterialQty 87 DCD-1500AE Exploded view of Mechanism unit You hav

44、e to remove the parts that marked WEEE mark when the recycling processing. (Europe model only) 88 DCD-1500AE Details of Recycle parts for Power transformer 16Polyester Film/Polyester Non-woven Insulating Tape 17Nylon 18Polyester Tape 19Polyester Tape 20Thermal Fuse 21Polyethylene Terephthalate 22Sil

45、icon Steel 23Steel 24Steel 25Polyurethane Enameled Copper Wire 26Polyurethane Enameled Copper Wire 27Complex 28Complex 29Complex NO.MaterialNO.Material 1Polyurethane Enameled Copper Wire 2Polyurethane Enameled Copper Wire 3Polyurethane Enameled Copper Wire 4Polyurethane Enameled Copper Wire 5Polyurethane Enameled Copper Wire 6Polyurethane Enameled Copper Wire 7Polyester Tape 8Polyester Sheet 9Polyester Tape 10Pressed Paper 11Polyester Tape 12Polyester Tape 13Polyester Sheet 14Polyester Sheet 15Polyester Tape