《AN-ARM-109_test_set_repair_parts_TM11-6625-1636-34P_1981.pdf》由会员分享，可在线阅读，更多相关《AN-ARM-109_test_set_repair_parts_TM11-6625-1636-34P_1981.pdf（25页珍藏版）》请在收音机爱好者资料库上搜索。
1、TM 11-6625-1636-34P TECHNICAL MANUAL DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS (INCLUDING DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS) FOR TEST SET, ANTENNA COUPLER AN/ARM-109 (NSN 6625-00-903-6385) HEADQUARTERS, DEPARTMENT OF THE ARMY 5 JANUARY 1981 *T
2、M 11-6625-1636-34P TECHNICAL MANUAL HEADQUARTERS DEPARTMENT OF THE ARMY No. 11-6625-1636-34P WASHINGTON, DC, 5 January 1981 DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS (INCLUDING DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS) FOR TEST SET, ANTENNA COUPLER A
3、N/ARM-109 (NSN 6625-00-903-6385) Current as of July 1980 REPORTING ERRORS AND RECOMMENDED IMPROVEMENTS You can help improve this manual. If you find any mistakes or if you know of a way to improve the procedures, please let us know. Mail your letter DA Form 2028 (Recommended Changes to Publications
4、and Blank Forms), or DA Form 2028-2 located in back of this manual direct to: Commander, US Army Communications and Electronics Materiel Readiness Command, ATTN: DRSEL-ME-MQ, Fort Monmouth, New Jersey 07703. In either case, a reply will be furnished direct to you. Table of Contents Illus Page Figure
5、 Section I. Introduction. 1 II. Repair Parts List.5 Group 00 Test Set, Antenna Coupler AN/ARM-109.5 1 01 Antenna Coupler Control Tester TS-2353/ARM-109 .7 2,3 02 Control, Amplifier Electronic TS-2354/ARM-109.11 4,5 03 Discriminator Tester TS-2352/ARM-109.17 6 04 Cables and Connectors.19 7 Section II
6、I. Special Tools List (Not applicable) IV. National Stock Number and Part Number Index.20 *This manual supersedes TM 114625-163634P, 12 October 1978. i TM 11-6625-1636-34P SECTION I INTRODUCTION 1. Scope This manual lists spares and repair parts; special tools; special test, measurement, and diagnos
7、tic equipment (TMDE), and other special support equipment required for performance of direct support and general support maintenance of the AN/ARM-109. It authorizes the requisitioning and issue of spares and repair parts as indicated by the source and maintenance codes. 2. General This Repair Parts
8、 and Special Tools List is divided into the following sections: a. Section II. Repair Parts List. A list of spares and repair parts authorized for use in the performance of maintenance. The list also includes parts which must be removed for replacement of the authorized parts. Parts lists are compos
9、ed of functional groups in numeric sequence, with the parts in each group listed in figure and item number sequence. b. Section III. Special Tools List. Not applicable. c. Section IV. National Stock Number and Part Number Index. A list, in National item identification number (NIIN) sequence, of all
10、National stock numbers (NSN) appearing in the listings, followed by a list, in alphameric sequence, of all part numbers appearing in the listings. National stock numbers and part numbers are cross-referenced to each illustration figure and item number appearance. 3. Explanation of Columns a. Illustr
11、ation. This column is divided as follows: (1)Figure number. Indicates the figure number of the illustration on which the item is shown. (2)Item number. The number used to identify item called out in the illustration. b. Source, Maintenance, and Recoverability (SMR) Codes. (1)Source code. Source code
12、s indicate the manner of acquiring support items for maintenance, repair, or overhaul of end items. Source codes are entered in the first and second positions of the Uniform SMR Code format as follows: CodeDefinition PA-Item procured and stocked for anticipated or known usage. XD-A support item that
13、 is not stocked. When required, item will be procured through normal supply channels. NOTE Cannibalization or salvage may be used as a source of supply for any items source coded above except those coded XA and aircraft support items as restricted by AR 700-42. (2)Maintenance code. Maintenance codes
14、 are assigned to indicate the levels of maintenance authorized to USE and REPAIR support items. The maintenance codes are entered in the third and fourth positions of the Uniform SMR Code format as follows: (a)The maintenance code entered in the third position will indicate the lowest maintenance le
15、vel authorized to remove, replace, and use the support item. The maintenance code entered in the third position will indicate one of the following levels of maintenance: CodeApplication/Explanation O-Support item is removed, replaced, used at the organizational level. H-Support item is removed, repl
16、aced, used at the general support level. (b)The maintenance code entered in the fourth position indicates whether the item is to be repaired and identifies the lowest maintenance level with the capability to perform complete repair (i.e., all authorized maintenance functions). This position will con
17、tain one of the following maintenance codes: CodeApplication/Explanation H-The lowest maintenance level capable of complete repair of the support item is the general support level. Z-Nonreparable. No repair is authorized. (3)Recoverability code. Recoverability codes are assigned to support items to
18、indicate the disposition action on unserviceable items. The recoverability code is entered in the fifth position of the Uniform SMR Code format as follows: Recoverability codesDefinition Z-Nonreparable item. When unserviceable, condemn and dispose at the level indicated in position 3. H-Reparable it
19、em. When uneconomically reparable, condemn and dispose at the general support level. c. National Stock Number. Indicates the National stock number assigned to the item and will be used for requisitioning purposes. d. Part Number. Indicates the primary number used by the manufacturer (individual, com
20、pany, firm, corporation, or Government activity), which controls the design and characteristics of the item by means of its engineering drawings, specifications, standards, and inspection requirements to identify an item or range of items. NOTE When a stock numbered item is requisitioned, the repair
21、 part received may have a different part number than the part being replaced. 1 TM 11-6625-163-34P e. Federal Supply Code for Manufacturer (FSCM). The FSCM is a 5-digit numeric code listed in SB 70842 which is used to identify the manufacturer, distributor, or Government agency, etc. f. Description.
22、 Indicates the Federal item name and, if required, a minimum description to identify the item. g. Unit of Measure (U/M). Indicates the standard of the basic quantity of the listed item as used in performing the actual maintenance function. This measure is expressed by a two-character alphabetical ab
23、breviation (e.g., ea, in, pr, etc). When the unit of measure differs from the unit of issue, the lowest unit of issue that will satisfy the required units of measure will be requisitioned. h. Quantity Incorporated in Unit. Indicates the quantity of the item used in the breakout shown on the illustra
24、tion figure, which is prepared for a functional group, subfunctional group, or an assembly. 4. Special Information The following publications pertain to the AN/ARM-109 and its components: TM 11-6625-1636-14, Test Set, Antenna Coupler AN/ARM- 109 TM 11-6625-1636-20P, Test Set, Antenna Coupler AN/ARM
25、109 5. How to Locate Repair Parts a. When National stock number or part number is unknown. (1)First. Using the table of contents, determine the functional group within which the item belongs. This is necessary since illustrations are prepared for functional groups and listings are divided into the s
26、ame groups. (2)Second. Find the illustration covering the functional group to which the item belongs. (3)Third. Identify the item on the illustration and note the illustration figure and item number of the item. (4)Fourth. Using the Repair Parts Listing, find the figure and item number noted on the
27、illustration. b. When National stock number or part number is known. (1)First. Using the Index of National Stock Numbers and Part Numbers, find the pertinent National stock number or part number. This index is in NIIN sequence followed by a list of part numbers in alphameric sequence, cross-referenc
28、ed to the illustration figure number and item number. (2)Second. After finding the figure and item number, locate the figure and item number in the repair parts list. 6. Abbreviations Not applicable. (Next printed page is 4) 2 TM 116625163634P Figure 1. Test Set Antenna Coupler AN/ARM-109. 4 SECTION
29、 IITM 11-6625-3008-24P (1)(2)(3)(4)(5)(6)(7) (8) ILLUSTRATIONDESCRIPTION (a)(b)NATIONALQTY FIGITEMSMRSTOCKPARTINC NO.NO.CODENUMBERNUMBERFSCMUSABLE ON CODEU/MIN UNIT GROUP 00 TEST SET. ANTENNA COUPLER AN/ARM-109 11PAOHH6625-00-070-1103TS2353U80058TEST SET, CONTROL .EA1 12PAOHH6625-00-498-9459TS-2354/
30、U80005TEST SET, AMPLIFIER.EA1 13XOOHH6625-00-067-81S-2352/U80058TEST SET, DISCRIMIN.EA1 14PAOHH6625-00-935-2638CX-10736/U80058CABLE ASSEMBLY, W -3 .EA1 15PAOHH6625-00-935-237CX-10736/U80058CABLE ASSEMBLY, W-2 .EA1 16PAHZZ5930-00-655-75MS35059-2296906SWITCH, TOGGLE.EA1 17PAHZZ5905-00-975-160RW67V2728
31、1349RESISTOR, FIXED, WIRE.EA1 18PAOZZ6210-00-827-6574856019-5MB08717LENS.EA1 19PAOZZ6240-00-941-269638508806LAMP, INCANDESCENT.EA1 110PAHZZ6210-00-059-649885600108717LAMP, HOLDER.EA1 111PAOHH6625-00-935-2636CG-3440/U80058CABLE ASSEMBLY, W-4 .EA1 112PAOHH6150-00-935-2629CX1037AMI0980058CABLE ASSEMBLY
32、, W-1 .EA1 113XDHZZ5920-0-121-5509HKLEJQRW-AA-ZZ71400FUSEHOLDER .EA1 114XDOZZAGC250-271400FUSE, CARTRIDGE .EA1 5 TM 11-625-16334P Figure 2. Antenna Coupler Control Tester TS-2353/ARM-109. 6 SECTION IITM 11-6625-3008-24P (1)(2)(3)(4)(5)(6)(7) (8) ILLUSTRATIONDESCRIPTION (a)(b)NATIONALQTY FIGITEMSMRST
33、OCKPARTINC NO.NO.CODENUMBERNUMBERFSCMUSABLE ON CODEU/MIN UNIT GROUP 01 ANTENNA COUPLER CONTROL TESTER TS-2353/ARM-I09 (COLLINS P/N 878L-15) 21XDHZZMS16108-8A96906CONNECTOR.EA4 22PAOZZ5355-00-767-5008757-0233-00113499KNOB .EA2 23PAOZZ5355-00-941-9660757-0233-00313499KNOB .EA1 24PAOZZ5920-00-280-8342A
34、G0250-171400FUSE, CARTRIDGE .EA1 25PAOZZ5920-00-280-8344AG0250-1/2A71400FUSE, CARTRIDGE .EA3 26PAHZZ5935-00-892-8804MS16108-2A96906CONNECTOR.EA2 27XDOZZ5920-00-735-6457AG0250-371400FUSE, CARTRIDGE .EAA 28PAOZZ5920-00-050-4953AG0250-1-1/2A71400FUSE, .CARTRIDGE .EA1 29PAHZZ5935-00-577-2336MS16108-3A96
35、906CONNECTOR.EA1 210PAOZZ6240-00-965-138138208806LAMP. INCANDESCENT.EA5 211PAOZZ6240-00-941-269638508806LAMP, INCANDESCENT.EA73 212PAOZZ6210-00-827-6579856019-4MB08717LENS.EA39 213PAOZZ6210-00-827-6574856019-5MB08717LENS.EA39 7 TM 11-662-163634P Figure 3. Antenna Coupler Control Tester TS-2353/ARM-1
36、09, Rear and Top Views. 8 SECTION IITM 11-6625-3008-24P (1)(2)(3)(4)(5)(6)(7) (8) ILLUSTRATIONDESCRIPTION (a)(b)NATIONALQTY FIGITEMSMRSTOCKPARTINC NO.NO.CODENUMBERNUMBERFSCMUSABLE ON CODEU/MIN UNIT 31PAHZZ5905-00-279-1724R032GF151J81349RESISTOR, FIXED.EA5 32PAHZZ5905-00-279-1724R032GF151J81349RESIST
37、OR, FIXED.EA1 33PAHZZ5905-00-195-6761R020GF1O4J81349RESISTOR .EA2 34PAHZZ5961-00-964-68072N88607688SEMICONDUCTOR DEVIC.EA2 35PAHZZ5905-00-290-8876R020GF53K81349RESISTOR, FIXED. .EA2 36PAHZZ5905-00-295-3410R020GF13K81349RESISTOR, FIXED.EA2 37PAHZZ5910-00-080-1718805-014X5V0103Z72982CAPACITOR, FIXED .
38、EA2 38PAHZZ5905-00-279-3513R020GF221J81349RESISTOR, FIXED.EA1 39PAHZZ5905-00-975-1160RW67V27200213RESISTOR, FIXED, WIRE.EA2 310PAHZZ5910-00-886-5187186P15403S156289CAPACITOR, FIXED .EA2 311PAHZZ5905-00-279-1880R020GF272J81349RESISTOR, FIXED.EA2 312PAHZZ5905-00-943-3970A1487670674TRANSFORMER, POWER.E
39、A1 313PAHZZ5961-00-226-37171N120281349SEMICONDUCTOR.At2 314PAHZZ5945-00-847-9837T154X58370309RELAY, ELECTROMAGNET.EA1 315PAHZZ6210-00-059-649885600108717LAMPHOLDER.EA78 316XDHZZDFC-375-03371468CONNECTOR.EA1 317PAHZZ5935-00-761-3797DDF50S03371468CONNECTOR.EA1 318PAHZZ5905-00-583-7670RA20NASD501A81349RESISTOR, VARIABLE.EA2 319XDHZZ5920-00-904-1370HKR-EJQRW-AA-ZZ71400FUSEHOLDER .EA5 320XDHZZ5920-00-121-5509HKLEJQRW-AA-ZZ71400FU
免费区 
