《AN-ARM-109_test_set_repair_parts_TM11-6625-1636-20P_1981.pdf》由会员分享，可在线阅读，更多相关《AN-ARM-109_test_set_repair_parts_TM11-6625-1636-20P_1981.pdf（16页珍藏版）》请在收音机爱好者资料库上搜索。
1、TM 11-6625-1636-20P TECHNICAL MANUAL ORGANIZATIONAL MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS FOR TEST SET, ANTENNA COUPLER AN/ARM-109 (NSN 6625-00-903-6385) H E A D Q U A R T E R S , D E P A R T M E N T O F T H E A R M Y 6 February 1981 *TM 11-6625-1636-20P TECHNICAL MANUAL HEADQUARTERS DEPA
2、RTMENT OF THE ARMY No. 11-6625-1636-20WASHINGTON, DC, 6 February 1981 ORGANIZATIONAL MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST FOR TEST SET, ANTENNA COUPLER AN/ARM-109 (NSN 6625-00-903-6385) Current as of 25 September 1980 REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS You can help improve thi
3、s manual. If you find any mistakes or if you know of a way to improve the procedures, please let us know. Mail your letter, DA Form 2028 (Recommended Changes to Publications and Blank Forms), or DA Form 2028-2 located in back of this manual direct to: Commander, US Army Communications and Electronic
4、s Materiel Readiness Command, ATTN: DRSEL-ME-MQ, Fort Monmouth, NJ 07703. In either case, a reply will be furnished to you. TABLE OF CONTENTS Illus PageFigure SECTIONI.Introduction . 1 II.Repair Parts List. 5 GROUP00Test Set, Antenna Coupler AN/ARM-102.1 01Antenna Coupler Control Tester TS-2353/ARM-
5、109 .2 02Control, Amplifier Electronic TS-2354/ARM-109 9.4 03Discriminator Tester TS-2352/ARM-109 .6 04Cables and Connectors (No parts authorized) SECTIONIII.Special Tools List (Not applicable) IV.National Stock Number and Part Number Index . 12 *This manual supersedes TM 11-6625-1636-20P, 14 Septem
6、ber 1978. TM 11-6625-1636-20P SECTION I INTRODUCTION 1. Scope This manual lists spares and repair parts; special tools; special test, measurement, and diagnostic equipment (TMDE), and other special support equipment required for performance of organizational maintenance of the AN/ARM-109. It authori
7、zes the requisitioning and issue of spares and repair parts as indicated by the source and maintenance codes. 2. General This Repair Parts and Special Tools List is divided into the following sections: a.Section II. Repair Parts List. A list of spares and repair parts authorized for use in the perfo
8、rmance of maintenance. The list also includes parts which must be removed for replacement of the authorized parts. Parts lists are composed of functional groups in numeric sequence, with the parts in each group listed in figure and item number sequence. b. Section III. Special Tools List. Not applic
9、able. c.Section IV. National Stock Number and Part Number Index. A list, in National item identification number (NIIN) sequence, of all National stock numbers (NSN) appearing in the listings, followed by a list, in alphameric sequence, of all part numbers appearing in the listings. National stock nu
10、mbers and part numbers are cross-referenced to each illustration figure and item number appearance. 3. Explanation of Columns a. illustration. This column is divided as follows: (1) Figure number. Indicates the figure number of the illustration on which the item is shown. (2) Item number. The number
11、 used to identify item called out in the illustration. b.Source, Maintenance, and Recoverability (SMR) Codes. (1) Source code. Source codes indicate the manner of acquiring support items for maintenance, repair, or overhaul of end items. Source codes are entered in the first and second positions of
12、the Uniform SMR Code format as follows: Code Definition PA-Item procured and stocked for anticipated or known usage. XD-A support item that is not stocked. When required, item will be procured through normal supply channels. NOTE Cannibalization or salvage may be used as a source of supply for any i
13、tems source coded above except those coded XA and aircraft support items as restricted by AR 700-42. (2)Maintenance code. Maintenance codes are assigned to indicate the levels of maintenance authorized to USE and REPAIR support items. The maintenance codes are entered in the third and fourth positio
14、ns of the Uniform SMR Code format as follows: (a)The maintenance code entered in the third position will indicate the lowest maintenance level authorized to remove, replace, and use the support item. The maintenance code entered in the third position will indicate one of the following levels of main
15、tenance: CodeApplication/Explanation O - Support item is removed, replaced, used at the organizational level. (b) The maintenance code entered in the fourth position indicates whether the item is to be repaired and identifies the lowest maintenance level with the capability to perform complete repai
16、r (i.e., all authorized maintenance functions). This position will contain one of the following maintenance codes: CodeApplication/Explanation H - The lowest maintenance level capable of complete repair of .the support item is the general support level. Z - Nonreparable. No repair is authorized. (3)
17、 Recoverability code. Recoverability codes are assigned to support items to indicate the disposition action on unserviceable items. The recoverability code is entered in the fifth position of the Uniform SMR Code format as follows: Recoverability CodesDefinition Z-Nonreparable item. When unserviceab
18、le, condemn and dispose at the level indicated in position 3. H - Reparable item. When uneconomically reparable, condemn and dispose at the general support level. c.National Stock Number. Indicates the National stock number assigned to the item and will be used for requisitioning purposes. d.Part Nu
19、mber. Indicates the primary number used by the manufacturer (individual, company, firm, corporation, or Government activity), which controls the design and characteristics of the item by means of its 1 TM 11-6625-1636-20P engineering drawings, specifications, standards, and inspection requirements t
20、o identify an item or range of items. NOTE When a stock numbered item is requisitioned, the repair part received may have a different part number than the part being replaced. e. Federal Supply Code for Manufacturer (FSCM). The FSCM is a 5-digit numeric code listed in SB 708-1/ 42 which is used to i
21、dentify the manufacturer, distributor, or Government agency, etc. f.Description. Indicates the Federal item name and, if required, a minimum description to identify the item. g.Unit of Measure (U/M). Indicates the standard of the basic quantity of the listed item as used in performing the actual mai
22、ntenance function. This measure is expressed by a two-character alphabetical abbreviation (e.g., ea, in, pr, etc). When the unit of measure differs from the unit of issue, the lowest unit of issue that will satisfy the required units of measure will be requisitioned. h.Quantity Incorporated in Unit.
23、 Indicates the quantity of the item used in the breakout shown on the illustration figure, which is prepared for a functional group, subfunctional group, or an assembly. 4.Special Information a.The following publication pertains to the AN/ARM-109 and its components: TM 11-6625-1636-14, Test Set, Ant
24、enna Coupler AN/ARM-109 b.The illustrations in this manual are identical to those published in TM 11-6625-1636-34P. Only those parts assigned the third position SMR maintenance code C or O are listed in the tabular listing; therefore, there may be a break in the item number sequence. Only illustrati
25、ons containing organizational authorized items appear in this manual. c.National stock numbers (NSNs) that are missing from P source coded items have been applied for and will be added to this TM by future change/revision when they are entered in the Army Master Data File (AMDF). Until the NSNs are
26、established and published, submit exception requisitions to Commander, US Army Communications and Electronics Materiel Readiness Command, ATTN: DRSEL-MM, Fort Monmouth, NJ 07703 for the part required to support your equipment. 5. How to Locate Repair Parts a.When National stock number or part number
27、 is unknown. (1) First. Using the table of contents, determine the functional group within which the item belongs. This is necessary since illustrations are prepared for functional groups and listings are divided into the same groups. (2) Second. Find the illustration covering the functional group t
28、o which the item belongs. (3) Third. Identify the item on the illustration and note the illustration figure and item number of the item. (4) Fourth. Using the Repair Parts Listing, find the figure and item number noted on the illustration. b.When National stock number or part number is known. (1)Fir
29、st. Using the Index of National Stock Numbers and Part Numbers, find the pertinent National stock number or part number. This index is in NIIN sequence followed by a list of part numbers in alphameric sequence, cross-referenced to the illustration figure number and item number. (2) Second. After fin
30、ding the figure and item number, locate the figure and item number in the repair parts list. 6. Abbreviations Not applicable. (Next printed page is 4) 2 TM 11-6625-1636-20P Figure 1. Test Set, Antenna Coupler AN/AMR-109. 4 SECTION IITM 11-6625-1636-20P (1)(2)(3)(4)(5)(6)(7) (8) ILLUSTRATIONDESCRIPTI
31、ON (a)(b)NATIONALQTY FIGITEMSMRSTOCKPARTINC NO.NO.CODENUMBERNUMBERFSCMUSABLE ON CODEU/MIN UNIT GROUP 00 TEST SET, ANTENNA COUPLER AN/ARM-109 11 PAOHH 6625-00-010-1103 T52353U80058 TEST SET, CONTROL.EA1 12 PAOHH 6625-00-498-9459 TS-2354/U80058 TEST SET, AMPLIFIER.EA1 13 XDOHH 6625-00-067-8110 TS-2352
32、/U80058 TEST SET, DISCRIMINA .EA1 14 PAOHH 6625-00-935-2638 CX-10735/J80058 CABLE ASSEMBLY.EA1 15 PAOHH 6625-00-935-2637 CX-10736/J80058 CABLE ASSEMBLY .EA1 18 PAOZZ6210-00-827-6574 856019-5MB08717 LENS .EA1 19 PAOZZ6240-00-941-2696 38508806 LAMP, INCANDESCENT .EA1 I 111 PAOHH 6625-00-935-2636 CG-34
33、40/U80058 CABLE ASSEMBLY .EA1 112 PAOHH 6150-00-935-2629 CX1037ARM10980058 CABLE ASSEMBLY.EA1 114 XDOZZAGC250-271400 FUSE, CARTRIDGE.EA 1 5 TM 11-6625-1636-20P Figure 2. Antenna Coupler Control Tester TS-2353/ARM-109. 6 SECTION IITM 11-6625-1636-20P (1)(2)(3)(4)(5)(6)(7) (8) ILLUSTRATIONDESCRIPTION
34、(a)(b)NATIONALQTY FIGITEMSMRSTOCKPARTINC NO.NO.CODENUMBERNUMBERFSCMUSABLE ON CODEU/MIN UNIT GROUP 01 ANTENNA COUPLER CONTROL TESTER TS-2353/ARM-109 22 PAOZZ5355-00-767-5008 757-0233-00113499 KNOB .EA2 23 PAOZZ5355-00-941-9660 757-0233-33 13499 KNOB . EA1 24 PAOZZ5920-00-280-8342 AGC250-1-71400 FUSE,
35、 CARTRIDGE.EA 1 25 PAOZZ5920-00-280-8344 AGC250-1/2A71400 FUSE, CARTRIDGE.EA3 27 XDOZZ5920-00-735-6457 AGC250-371400 FUSE, CARTRIDGE.EA1 28 PAOZZ5920-00-050-4953 AGC250-1-1/2A71400 FUSE, CARTRIDGE .EA1 210 PAOZZ6240-00-965-1381 38208806 LAMP, INCANDESCENT.EA5 211 PAOZZ6240-00-941-2696 38508806 LAMP,
36、 INCANDESCENT .EA 73 212 PAOZZ6210-00-827-6579 856019-4MB08717 LENS.EA 39 213 PAOZZ6210-00-827-6574 856019-5MB08717 LENS .EA 39 7 TM 11-6625-1636-20P Figure 4. Control, Amplifier Electronic TS-2354/ARM-109. 8 SECTION IITM 11-6625-1636-20P (1)(2)(3)(4)(5)(6)(7) (8) ILLUSTRATIONDESCRIPTION (a)(b)NATIO
37、NALQTY FIGITEMSMRSTOCKPARTINC NO.NO.CODENUMBERNUMBERFSCMUSABLE ON CODEU/MIN .UNIT GROUP 02 CONTROL AMPLIFIER ELECTRONIC TS-2354/ARM-109 41 PAOZZ6210-00-827-6574 856019-5MB08717 LENS.EA6 42 PAOZZ6210-00-827-6579 856019-4MB08717 LENS.EA7 43 PAOZZ 6240-00-941-2696 38508806 LAMP.EA 13 44 XDOZZ757-0233-0
38、0213499 KNOB .EA2 45 PAOZZ5355-00-767-5030 757-0232-00113499 KNOB .EA1 46 PAOZZ5920-00-280-8342 AGC250-171400 FUSE, CARTRIDGE .EA2 9 TM 11-6625-1636-20P Figure 6. Discriminator Tester TS-2352/ARM-109. 10 SECTION IITM 11-6625-1636-20P (1)(2)(3)(4)(5)(6)(7) (8) ILLUSTRATIONDESCRIPTION (a)(b)NATIONALQT
39、Y FIGITEMSMRSTOCKPARTINC NO.NO.CODENUMBERNUMBERFSCMUSABLE ON CODEU/MIN UNIT GROUP 03 DISCRIMINATOR TESTER TS-2352/ARM-109 COLLINS P/N B78L-17) 61 XDOZZ5355-00-941-9660 757-0233-00313499 KNOB .EA 1 11 SECTION IVTM 11-6625-1636-20P NATIONAL STOCK PART NUMBER AND PART NUMBER INDEX NOTE: LATEST NATIONAL
40、 STOCK NUMBER AND PART NUMBER ASSIGNMENTS ARE INCLUDED AT END OF INDEX STOCK NUMBERFIG.ITEMSTOCK NUMBERFIG.ITEM 5920-00-050-4953286210-00-827-657942 6625-00-070-1103116150-00-935-2629112 5920-00-280-8342246625-00-935-2636111 5920-00-280-8342466625-00-935-263715 5920-00-280-8344256625-00-935-263814 5
41、920-00-735-6457276240-00-941-269619 5355-00-767-5008226240-00-941-2696211 5355-00-767-5030456240-00-941-269643 6210-00-827-6574185355-00-941-966023 6210-00-827-65742135355-00-941-966061 6210-00-827-6574416240-30-965-1381210 6210-00-827-6579212 PARTFIG.ITEMPARTFIG.ITEM NUMBERFSCMNO.NO.NUMBERFSCMNO.NO
42、. AGC250-171400243850880619 AGC250-1714004638508806211 ASC250-1-1/2A71400283B50880643 AGC250-1/2A7140025757-0232-0011349945 AGC250-271400114757-0233-0011349922 AGC250-37140027757-0233-0021349944 CG-3440/U80058111757-0233-0031349923 CX-10735/U9305814757-0233-0031349961 CX-10736/U8005815856019-4MB0871
43、7212 CX10737ARM10980058112856019-4MB0871742 TS-2352/U8005813856019-5MB0871718 TS-2354/U8005812856019-5MB08717213 TS2353U8005811856019-5MB0871741 38208806210 LATEST NATIONAL STOCK NUMBER ASSIGNMENTS FIG.ITEM STOCK NUMBERNO.NO. 6625-00-067-811013 6625-00-498-945912 12 By Order of the Secretary of the
44、Army: E. C. MEYER General, United States Army Official: Chief of Staff J. C. PENNINGTON Major General, United States Army The Adjutant General Distribution: To be distributed in accordance with DA Form 12-36A, Organizational Maintenance requirements for AN/ARM-109. * U.S. GOVERNMENT PRINTING OFFICE : 1983 0 - 381-302(1270) PIN: 016304-000
免费区 
