MEP-002A_generator_diesel_serv_TM5-6115-584-34_1977.pdf

《MEP-002A_generator_diesel_serv_TM5-6115-584-34_1977.pdf》由会员分享，可在线阅读，更多相关《MEP-002A_generator_diesel_serv_TM5-6115-584-34_1977.pdf（194页珍藏版）》请在收音机爱好者资料库上搜索。

1、ARMY TECHNICAL MANUAL TM 5-6115-584-34 NAVFAC P-8-622-34 NAVY PUBLICATION TO-35C2-3-456-2 TM-0568C-34 AIR FORCE TECHNICAL ORDER MARINE CORPS TECHNICAL MANUAL TECHNICAL MANUAL INTERMEDIATE (FIELD) (DIRECT AND GENERAL SUPPORT) AND DEPOT LEVEL MAINTENANCE MANUAL GENERATOR SET, DIESEL ENGINE DRIVEN, TAC

2、TICAL SKID MTD 5KW, 1 PHASE -2 WIRE, 1 PHASE -3 WIRE, 3 PHASE -4 WIRE, 120, 120/240 AND 120/208 VOLTS DOD MODELCLASSHERTZNSN MEP-002AUTILITY606115-00-465-1044 Published UNDER THE AUTHOR lTYOFTHEDEPARTMENTS 0F THE ARMY, AIR FORCE, NAVY, AND HEADQUARTERS U.S. MARINE CORPS JULY 1977 TM 5-6115-584-34 NA

3、VFAC WARNING All specific cautions and warnings contained in this manual shall be strictly adhered to. Otherwise, severe injury,death damage to the equipment may result. HIGH VOLTAGE is produced when this Generator Set is in operation. DEATH or severe burns may result if personnel fail to observe sa

4、fety precautions. not operate this Generator Set until the ground terminal stud has been connected to a suitable ground. Disconnect the battery ground cable before removing and installing components on the engine or in the electrical control panel system. Remove all rings, watches, and other jewelry

5、 when performing maintenance on this equipment. Loose fitting clothing should be secured to prevent it catching in moving parts. not attempt to service or otherwise make any adjustments, connections or nections of wires or cables until Generator Set is shut-down and completely energized. DANGEROUS B

6、atteries generateexplosive gas during charging: therefore, utilize extreme caution, do not smoke, or use open flame in the vicinity of the Generator Set when servicing batteries. Exhaust discharge contains noxious and deadly fumes. Do not operate Generator Sets in enclosed areas unless exhaust disch

7、arge is properly vented to the outside. To avoid sparking between filler nozzle and fuel tank, always maintain metal to metal contact between filler and fuel tank when filling fuel tank. Do not smoke or use open flame the vicinity of the Generator Set while fueling. LIQUIDS UNDER HIGH PRESSURE are g

8、enerated as result of operation of the Generator Set. Do not expose any part of the body to high pressure leak in the fuel injection system. WARNING Clean parts in a well-ventilated area.Avoid inhalation of solvent fumes and pro- longed exposure of skin to cleaning solvent. Wash exposed skin thoroug

9、hly. Dry cleaning solvent (Fed. Spec. used to clean parts is potentially dangerous to personnel and property. not use near open flame or excessive heat. Flash point of solvent is F. to 138 F. (38 C. to 59 C.). WARNING If conditions require fuel tank repairs by welding or other methods involving heat

10、 or flame, take care to assure that all fumes are purged from the tank or fill tank with water before commencing the repair. If possible, tank should be filled with water prior to welding after being thoroughly purged of fumes. Applying heat or flame to a fuel tank containing residue, may result in

11、a violent explosion, causing death or injury to maintenance personnel. NOISE Operating level of this generator can cause hearing damage. Ear protectors, as recommended by the medical or safety officer,must be worn when working near this set. TM 5-6115-584-34 NAVFAC P-8-622-34 TO-35C2-3-456-2 CHANGEH

12、EADQUARTERS DEPARTMENTS OF THE ARMY, NAVY, AND AIR FORCE NO. 8WASHINGTON, D. C., 9 NOVEMBER 1992 C 8 Intermediate (Field) (Direct Support and General Support) and Depot Level Maintenance Manual GENERATOR SET, DIESEL ENGINE DRIVEN, TACTICAL SKID MTD, 5 kW, 1 PHASE -2 WIRE, 1 PHASE -3 WIRE, 3 PHASE -4

13、 WIRE, 120, 120/240 AND 120/208 VOLTS DOD MODELCLASSHERTZNSN MEP-002AUTILITY606115-00-465-1044 Approved for public release; Distribution is unlimited TM 5-6115-584-34/NAVFAC P-8-622-34/TO-35C2-3-456-2, 22 July 1977 is changed as follows: 1. Remove and insert pages as indicated below. New or changed

14、text material is indicated by a vertical bar in the margin. An illustration change is indicated by a miniature pointing hand. Remove pagesInsert pages 6-11 and 6-126-11 and 6-12 2. Retain this sheet in front of manual for reference purposes. TM 5-6115-584-34 NAVFAC P-8-622-34 TO-35C2-3-456-2 C8 By O

15、rder of the Secretaries of the Army, Navy and Air Force: Official: GORDON R. SULLIVAN General, United States Army Chief of Staff MILTON H. HAMILTON Administrative Assistant to the Secretary of the Army 03009 MERRILL A. McPEAK General, USAF Chief of Staff Official: RONALD W. YATES General, United Sta

16、tes Air Force Commander, Air Force Materiel Command DAVID E. BOTTORFF Rear Admiral, CEC, US Navy Commander Navy Facilities Engineering Command DISTRIBUTION: To be distributed in accordance with DA Form 12-25-E, block no. 0858, requirements for TM 5-6115-584-34. TM 5-6115-584-34 NAVFAC P-8-622-34 TO-

17、35C2-3-456-2 C7 CHANGE NO. 7 HEADQUARTERS , DEPARTMENTS OF THE ARMY, NAVY AND AIR FORCE AND HEADQUARTERS U.S. MARINE CORPS WASHINGTON, D.C., 25 July 1991 Intermediate (Field) (Direct and General Support) and Depot Level Maintenance Manual GENERATOR SET, DIESEL ENGINE DRIVEN, TACTICAL SKID MTD 5 kW,

18、1 PHASE -2 WIRE, 1 PHASE -3 WIRE, 3 PHASE -4 WIRE, 120, 120/240 AND 120/208 VOLTS DOD MODELCLASSHERTZNSN MEP-002AUTILITY606115-00-465-1044 Approved for public release; distribution is unlimited TM 5-61 15584-34, NAVFAC P8-622-34, TO-35 C2-3-45 TACTICAL SKID MTD 5 KW, 1 WIRE, 1 WIRE, 3 WIRE, 120, 120

19、/140 AND 120/208 VOLTS DOD MODELCLASSHERTZNSN UTILITY606115-00-465-1044 Approved public release; distribution is unlimited TM 561 0568 22 July 1977, is changed as follows: 1. Remove and pages as indicated or changed text material is indicated by a vertical bar in the margin An illustration change is

20、 indicated by a miniature pointing hand. Remove pagesInsert pages iii through v/vi 11 through 14 211 and 212 215 and 216 through 33/ 34 4-1/4-2 6-7 and 6-8 71 and 72 7-5 and 7-6 7-25 and 7-26 729 and 730 7-41 through 744 8-1 and 8-2 9-1 and 92 Index through Index 4 iii through vi 11 through 14 14.1/

21、1-4,2 21 1 and 212 215 and 21 6 31 through 33/3-4 41 /42 6-7 and 6-8 71 and 72 75 and 76 7-25 and 7-26 7-29 and 730 7-41 through 744 81 and 82 91 and 92 101 through 1014 Index 1 through Index 4 TM 5-6115-584-34 NAVFAC P-8-622-34 TO-35C2-3-456-2 TM-0568C-34 C6 2. Retain this sheet in front ofmanual f

22、or reference purposes. By Order of the Secretaries of the Army , Air Force, and Navy (Including the Marine COtpS): CARL E. VUONO General, United States Army Chief of Staff Official: THOMAS F. SIKORA Brigadier General, United States Army The Adjutant General LARRY D. WELCH, General USAF Chief of Staf

23、f Official: ALFRED G. HANSEN General, USAF, Commander, Air Force Logistics Command B.F. MONTOYA Rear Admiral, CEC, US Navy Commander Navy Facilities Engineering Command H.E. REESE Executive Director Marine Corps Research, Development and Acquisition Command DISTRIBUTION: To be distributed in accorda

24、nce with DA Form 12-25E, (qty rqr block no 0858). Army Technical ManualTM 5-6115-584-34 Navy PublicationNAVFAC Technical Order Marine Corps Technical Manual CHANGEHEADQUARTERS, DEPARTMENTS OF THE ARMY, NAVY AND AIR FORCE AND HEADQUARTERS, U.S. MARINE CORPS No. 5Washington, D.C.,5 1989 Intermediate (

25、Field) (Direct and General Support) and Depot Level Maintenance Manual GENERATOR SET, DIESEL ENGINE DRIVEN; TACTICAL SKID MTD 5 KW, 1 WIRE, 1 WIRE 3 WIRE, 120, 120/140 AND 120/208 VOLTS DOD MODELCLASSHERTZNSN UTILITY606115-00-465-1044 TM 22 changed as follows: 1.Remove and insert pages as indicated

26、below. New or changed indicated by a vertical bar in the margin.An illustration change is indicated a miniature pointing hand. Remove pagesInsert pages iii and iv 1-9/1-10 2-5 and 2-6 2-11 and 2-12 6-1 and 6-2 6-7 and 6-8 6-13 through 6-16 - 6-19 and 6-20 6-20.1 and 6-20.2 7-13 and 7-14 7-25 and 7-2

27、6 - 7-37 and 7-38 8-3 and 8-4 - - - iii and iv 1-9/1-10 2-5 and 2-6 2-11 and 2-12 6-1 and 6-2 6-7 and 6-8 6-13 through 6-16 6-16.1 and 6-16.2 6-19 and 6-20 6-20.1 7-13 and 7-14 7-25 and 7-26 7-26.1/7-26.2 7-37 and 7-38 8-3 and 8-4 DA Form 2-28-2 (4) 2.Retain this sheet reference purposes. TM 5-6115-

28、584-34 NAVFAC P-8-622-34 TO-35C2-3-456-2 TM-0568C-34 C5 By Orderofthe Secretaries of the Army, the3favy, and the Air Force: CARLE. VUONO of!lcial: General. United States Army Chief of Stafl R,L.DILWORTH Btigedier(kneml, UnitedState8.4rmg !teA TACTICAL SKID MTD 5 KW, 1 PHASE-2 WIRE, 1 PHASE-3 WIRE, 3

29、 PHASE-4 WIRE, 120, 120/140 AND 120/208 VOLTS DOD MODELCLASSHERTZNSN MEP-002AUTILITY606115-00-465-1044 TM 5-6115-584-34/NAVFAC P-8-622-34/TO 35C2-3-456-2/ TM 05682C-34, 22 UIY 1977, is changed as follows: 1.Remove and insert pages as indicated below. New or changed text material is indicated by a ve

30、rtical bar in the margin.An illustration change is indicated by a miniature pointing hand. Remove pagesInsert pages iii and iv 1-3 and 1-4 2-11 and 2-12 6-17 through 6-20 - 7-1 and 7-2 7-10.1 and 7-10.2 7-37 and 7-38 iii and iv 1-3 and 1-4 2-11 and 2-12 6-17 through 6-20 6-20.1 and 6-20.2 7-1 and 7-

31、2 7-10.1 and 7-10.2 7-37 and 7-38 2.Retain this sheet in front of manual for reference purposes. . TM 5-6115-584-34 NAVFAC P-8-622-34 TO-35C2-3-456-2 TN-0568C-34 C4 By Orderofthe Secretaries of the Army, the Navy, and theAirForce: Official: JOHN A. WICKHAM, JR. General, United States Army Chief of S

32、tat7 R. L. DILWORTH Brigadier General, United States Army The Adjutant General J. P. JONES, JR. Rear Admiral, CEC, US Navy Commander Naval Facilities Engineering Command Official: EARL T. OLOUGHLIN General, USAF, Commander, Air Force Logistics Command GEORGE B. CRIST Lieutenant General, USMC Deputy

33、Chief of Staff for Installations and Logistics CHARLES A. GABRIEL, General USAF Chief of Staff DISTRIBUTION: To be distributed in accordance with DA Form 12-25A, Direct and General Support Maintenance requirements for Generator Set, Diesel Driven, Tactical , Skid Mounted, 120V, 120/240V, 120/208V, 5

34、KW, 60 HZ, lPH/2 Wire, lPH/3 Wire, 3PH/4 Wire (MEP-002A). DEPARTMENT OF THE ARMY TECHNICAL MANUALTM 5-6115-584-34 DEPARTMENT OF THE NAVY PUBLICATIONNAVFAC P-8-622-34 DEPARTMENT OF THE AIR FORCE TECHNICAL ORDERTO-35 C2-3-456-2 MARINE CORPS TECHNICAL MANUALTM-05682C-34 P? CHANGE DEPARTMENTS OF THE ARi

35、VY, NAVY, AIR FORCE AND MARINE CORPS NO. 3 TASHINGTON, D.C., 14 octbe 1983 Itermediate (Field) (Direct and General Support) and Depot Level Maintenance Manual GENERATOR SET,DIESEL ENGINE DRIVEN; TACTICAL SKID MTD 5 K W ,1 PHASE2 WIRE, 1 PHASE3 WIRE, 3 PHASE4 WIRE, 120,120/140 AND 120/208 VOI.,TS DOD

36、 MODELCLASSHERTZNSN MEP002AUTILITY606115004651044 TM 5-6115-584-34/NAVFAC P-8-622-34/TO 35C2-3-456-2/ TM 05682C34, 22 July 1977,is changed as follows: 1.Remove and insert pages as indicated below. Remove pagesInsert pa,qes Table of Contentsiii and iviii thru v/vi Chapter 221 thru 2421 thru 24 211 an

37、d 212211 and 2-12 Chapter 331 and 3231 and 3-2 Chapter 441/424-1/4-2 Chapter 779 and 7lo79 thru 710.2 Chapter 883 and 8483 and 84 ? U,New or changed text matera isindicated by a vertical bar in the margin.An illustration change isindicated by a miniature pointing hand. 3.Retain these sheets in front

38、 of manual for reference purposes. TM 5-6115-584-34 NAVFAC P-8-622-34 TO-35 C2-3-456-2 TM-0568C-34 r :3 By Order of the Secretaries of the Army, the Navy, and the Air Force: Official: ROBERT M. JOYCE Major General, United States Army The Adjutant General Official: JOHN A. WICKHAM, JR. General, Unite

39、d States Army Chief of Staff W. M. ZOBEL Read Admiral, CEC, US Navy NavaiFaciiitiea Eqp”neen”ng Command CHARLES A. GABRIEL, GeneraJ, WM.F Chief of Staff JAMES P. MULLINS General, USAF, Commander, Air Fome Logistics Command V. J. WALLS Ach”ngDeputy Chief of Staff for Installations and Logx”s MARCORPS

40、: AGB DEPARTMENT OF THE ARMY TECHNICAL MANUAL DEPARTMENT OF THE NAVY PUBLICATION DEPARTMENT OF THE AIR FORCE TECHNICAL ORDER MARINE CORPS TECHNICAL MANUAL CHANGE NO. 2 I TM 5-6115-584-34 NAVFAC P-8-622-34 TO-35C2-3-456-2 TM-05682C-34 C2 DEPARTMENTS OF THE ARMY, NAVY, AIR FORCE AND MARINE CORPS Washi

41、ngton, DC, 30 March 1979 Intermediate (Field) (Direct and General Support) and Depot Level Maintenance Manual GENERATOR SET, DIESEL ENGINE DRIVEN; TACTICAL SKIP MTD 5 KW, 1 PHASE-2 WIRE, 1 PHASE-3 WIRE, 3 PHASE-4 WIRE, 12Q, 120/240 AND 120/208 VOLTS DOD MODEL MEP-002A CLASSHERTZ NSN UTILITY606115-00

42、-465-1044 TM 5-6115-584-34/NAVFAC P-8-622-34/TO 35C2-3-456-2/TM 05682C-34, 22 July 1977, is changed as follows: 1.Remove old pages and insert new pages as indicated below. 2.New or changed material is indicated by a vertical bar in the margine of the page. Remove PagesInsert Pages 1-9/(1-10 blank)1-

43、9/(1-10 blank) 6-1 and 6-26-1 and 6-2 6-3 and 6-46-3 and 6-4 6-5 and 6-66-5 and 6-6 6-7 and 6-86-7 and 6-8 6-13 and 6-146-13 and 6-14 3.File this change sheet in front of the publication for reference purposes. TM 5-6115-564-34 NAVFAC P-8-622-34 TO-35C2-3-456-2 TM-05662C-34 C2 By Order of the Secret

44、aries of the Army, the Navy, and the Air Force: Official: BERNARD W. ROGERS General, United States Army Chief of Staff J, C. PENNINGTON Major General, United States Army The Adjutant General D. G. ISELIN Rear Admiral, CEC, U. S. Navy Commander, Naval Facilities Engineering Command Official: LEW ALLE

45、N, JR., General, USAF Chief of Staff VAN L. CRAWFORD, JR., Colonel, USAF Director of Administration H. A. HATCH Major General, U. S. Marine Corps Deputy Chief of staff for Installations and Logi8tic8 Distribution: Active Army: To be distributed in accordance with DA Form 12-25D, direct support and g

46、eneral support maintenance requirements for generatxm sets, engine driven, 5 KW, 60 HZ. Marine Corps: MARCORPS CODE: AGB TM 5-6115-584-34 NAVFAC P-8-622-34 TO 35C2-3-456-2 TM 05682C-34 cl DEPARTMENTS OF THE ARMY, NAVY, AIR FORCE AND MARINE CORPS WASHINGTON, DC, 15 March 1978 Intermediate (Field) (Di

47、rect and General Support) and Depot Level Maintenance Manual GENERATOR SET, DIESEL ENGINE DRIVEN; TACTICAL SKIP MTD 5 KW, 1 PHASE-2 WIRE, 1 PHASE-3WIRE, 3 PHASE-4 WIRE, 120, 120/240 AND 120/208 VOLTS DOD MODELCLASSHERTZ NSN MEP-O02AUTILITY606115-00-465-1044 TM -6115-S84-34/NAvFLC p.8-622_34() 35G2-3

48、.456-2M 05682C+4, 22 July 1977, is changed as follows: on front cover and throughout manual, Nal,y publication, NAVFAC P-8-262-11, should read: “NAVFAC P-8-622-34”. By Olcler of the Secretaries of the Army, the Navy, and the Air Force: BERNARD W. ROGERS Official: General, lnited States Army Chief of

49、 St%ff J. C. PENNINGTON Brigadier Ge)(e)al, UH itecl States Ar)zy The Acljita)zt General D. G. ISELIX Rear Admiral, CEC, U. S. i%avy Commander, Na!al Facilities Engi7eering Com)la(d Official: JAMES J. SHEPARD, Co/o)/e/, SAF Directo) ofA) i)l ist)(tio) H. A. HATCH .Ilajo, Ge)e)vl, S .Ilu t.i)ie Corps Depttg 211 ief qt Stuff ,fb), l)stallatio)s a )/(1 Logist ics DAVID C. JONES, General USAF Chif of Staff l)istliution: o be distributed in accordance with DA Form 12-25D, DS TACTICAL SKI DMTD lPHASE -2 WIRE, 1 PHASE -3 WIRE, 3 PHASE -4 WIRE, 120, 120/240 AND 120