《AN-GRC-106_serv_TM11-5820-520-34P-1_1978.pdf》由会员分享，可在线阅读，更多相关《AN-GRC-106_serv_TM11-5820-520-34P-1_1978.pdf（328页珍藏版）》请在收音机爱好者资料库上搜索。
1、T M 1 1 - 5 8 2 0 - 5 2 0 - 3 4 P - 1 TECHNICAL MANUAL DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST (INCLUDING DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS) FOR RADIO SET AN/GRC - 106 ( N S N 5 8 2 0 - 0 0 - 4 0 2 - 2 2 6 3 ) This copy is a reprint which inc
2、ludes current p a g e s f r o m C h a n g e 1 . HEADQUARTERS, DEPARTMENT OF THE ARMY APRIL 1978 HIGH VOLTAGE is used in the operation of this equipment. DEATH ON CONTACT may result if personnel fail to observe safety precautions. Learn the areas containing high voltage in each piece of equipment. Be
3、 careful not to contact high-voltage connections when installing or operating this equipment. Before working inside the equipment, turn power off and ground points of high potential before touching them. DANGEROUS CHEMICALS ARE USED IN NICKEL-CADMIUM BATTERIES The electrolyte used in nickel-calmium
4、batteries contains potassium hydroxide (KOH), which is a caustic chemical agent. Serious and deep burns of body tissue will result if the electrolyte is in contact with the eyes or any part of the body. Use rubber gloves, rubber apron, and protective goggles when handling the electrolyte. If acciden
5、tal contact with the electrolyte is made, use ONLY clean water, and immediately (seconds count) flush contaminated areas. Continue flushing with large quantities of clean water for at least 15 minutes. Seek medical attention without delay. EXPLOSIVE DEVICES are used in the ejection seats of the airc
6、raft. Maintenance personnel shall familiarize themselves with the ground safety locking devices. Prior to performing any maintenance in the cockpit check that all locking pins are installed and the upper and lower firing handles are locked. * T M 1 1 - 5 8 2 0 - 5 2 0 - 3 4 P - 1 TECHNICAL MANUAL N0
7、.115820-520-34P-1 HEADQUARTERS DEPARTMENT OF THE ARMY WASHINGTON,D.C., 26 April 1978 DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST (INCLUDING DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS) FOR RADIO SET AN/GRC- 106 (NSN 5820-00-402-2263) Current as of 10 Augus
8、t 1977 REPORTING OF ERRORS You can improve this manual by recommending improvements using DA Form 2028-2 (Test) located in the back of the manual. Simply tear out the self-addressed form, fill it out as shown on the sample, fold it where shown, and drop it in the mail. If there are no blank DA Forms
9、 2028-2 (Test) in the back of your manual, use the standard DA Form 2028 (Recommended Changes to Publications and Blank Forms) and forward to the Commander, US Army Electronics Command, ATTN: DRSEL-MA -Q, Fort Monmouth, New Jersey 07703. In either case a reply will be furnished direct to you. Table
10、of Contents SECTION I. Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . II.Repair parts list . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
11、 . . . . . . . . . . . . . . . . . . GROUP00 Radio Set AN/GRC-106 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 01 Receiver-Transmitter RT-662/GRC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
12、 . . . . . . . . . . . . 0101 Chassis assembly (lAl) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 010101 Front end protection assembly (lA1A1A10) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 010102
13、Internal ALC assembly (lAl2A5) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0102 100 kHz synthesizer module (lA2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0103 Frequency standard module (lA3) . .
14、. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0104 100 and l kHz synthesizer module (lA4) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0105 Transmitter intermediate frequency and audio module (1A5) . . . . .
15、 . . . . . . . . . . . . . . . . . . . . 0106 Frequency divider module (lA6) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0107 Receiver intermediate frequency module (1A7). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
16、0108 Translator module (lA8) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0109 MHz synthesizer module (lA9) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0110 Receiver audio
17、 module (lA10) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0111 DC to DC conveter and regulator module(lAll) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0112 Radio frequency amplifier module (lA12) . . . . . .
18、. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0113 Case assembly (lA13) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 02 Amplifier, Radio Frequency AM-3349/GRC . . . . . . . . . . . . . . . . . . . .
19、. . . . . . . . . . . . . . . . . . . . . . . . 0201 Chassis, panel assembly (2Al) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 020101 Chassis, amplifier (2A1A1) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
20、 . . . . . . . . . . . . . . 020102 Panel, power amplifier (2A1A5) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 02010201 Filter assembly (2AlA5Al) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
21、. 02010202 DC to DC converter (2AlA5A2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0201020201 Screen rectifier assembly (2AlA5A2A4) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0201020202 Start circuit assembly (2AlA5A2A
22、6) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 1 5 5 11 17 35 37 39 55 67 81 93 105 108 127 139 147 155 163 165 169 175 193 203 207 211 213 215 Illus Figure 13 4 5-7 8 9 10-14 15-18 19-22 23-26 27-30 31-35 36-39 40-43 44,45 46,47 48,49 50 51 52 53-57 58,59 60
23、 61 62 63 6402010203 Plate assembly(2A1A5A3) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . *This manual supersedesTM 11-5820-520-34P-1, 15 November 1974, and so much of TM 11-5820-520-34P-3, 15 November 1974, as pertained to the AN/GRC-106. i T
24、M 11-5820-520-34P-1 GROUP 03 04 05 06 07 08 09 10 11 12 13 SECTIONIII. IV. Table of Contents Continued 02010204 Terminal board assembly (2AlA5A5) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 02010205 Protection circuit (2AlA5A7) . . . . . . . . . . . . . . . .
25、. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0202 Turret assembly (2A2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0203 Antenna coupler (2A3) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
26、. . . . . . . . . . . . . . . . . . . . . . . . . . . . 0204 Discriminator assembly (2A4) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0205 Case assembly (2A6) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
27、 . . . . . . . . . . . . . . . . . . . . 020501 Inverter assembly (2A6Al) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0206 Relay assembly (2A7) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
28、. . . . . . . . . . . . . 0207 Drive assembly (2A8) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0208 P. A. stator assembly (2A9) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
29、 . . . . . Mounting Assembly MT-3140/GRC-106 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Interconnecting cables. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Antenna Group A
30、N/GRA-50 (See TM 11-5820-467-25P for parts) Loudspeaker LS166/U (See TM 11-5965-222-14P for parts) (Not used) Mast Base AB652/GR (No parts authorized) Mast Sections MS-l16-A, MS-l17-A, MS-l18-A . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Telegraph Key KY- 116/U (No parts au
31、thorized) Headset H-227/U (No parts authorized) Handset H-33()/PT (No parts authorized) Microphone M29B/U (No parts authorized) Special tools list (Not applicable) National stock number andpart number index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 217
32、219 221 237 243 253 257 261 265 269 271 273 275 276 Illus Figure 65 66 67-70 71 72-75 76 77 78 79,80 81 82 83 84 ii T M 1 1 - 5 8 2 0 - 5 2 0 - 3 4 P - 1 SECTION I INTRODUCTION 1. Scope This manual lists spares and repair parts; special tools; special test, measurement, and diagnostic equipment (TMD
33、E), and other special support equip- ment required for performance of direct support, and general support maintenance of the AN/GRC106. It authorizes the requisitioning and issue of spares and repair parts as indicated by the source and maintenance codes. 2. General This Repair Parts and Special Too
34、ls List is divided into the following sections: a. Section II. Repair Parts List. A list of spares and repair parts authorized for use in the perfor- mance of maintenance. The list also includes parts which must be removed for replacement of the authorized parts. Parts lists are composed of func- ti
35、onal groups in numeric sequence, with the parts in each group listed in figure and item number se- quence. b. Section III. Special Tools List. Not applicable. c. Section IV. National Stock Number and Part Number Index. A list, in National item identification number (NIIN) sequence, of all National s
36、tock numbers (NSN) appearing in the listings, followed by a list, in alphameric sequence, of all part numbers appearing in the listings. National stock numbers and part numbers are cross-referenced to each illustra- tion figure and item number appearance. 3. Explanation of Columns a. Illustration. T
37、his column is divided as follows: (1) Figure number. Indicates the figure number of the illustration on which the item is shown. (2) Item number. The number used to identify item called out in the illustration. b. Source, Maintenance, and Recoverability (SMR) Codes. (1) Source code. Source codes ind
38、icate the manner of acquiring support items for maintenance, repair, or overhaul of end items. Source codes are entered in the first and second positions of the Uniform SMR Code format as follows: CodeDefinition PA Item procured and stocked for anticipated or known usage. XA Item is not procured or
39、stocked because the requirements for the item will result in the replacement of the next higher assembly. XD A support item that is not stocked. When re- quired, item will be procured through nor- mal supply channels. NOTE Cannibalization or salvage may be used as a source of supply for any items so
40、urce coded above except those coded XA and air- craft support items as restricted by AR 70042. (2) Maintenance code. Maintenance codes are assigned to indicate the levels of maintenance authorized to USE and REPAIR support items. The maintenance codes are entered in the third and fourth positions of
41、 the Uniform SMR Code format as follows: (a) The maintenance code entered in the third position will indicate the lowest maintenance level authorized to remove, replace, and use the support item. The maintenance code entered in the third posi- tion will indicate one of the following levels of mainte
42、nance: CodeApplication/Explanation O Support item is removed, replaced, used at the organizational level. F Support item is removed, replaced, used at the direct support level. H Support item is removed, replaced, used at the general support level. D Support items that are removed, replaced, used at
43、 depot, mobile depot, specialized repair activity only. (b) The maintenance code entered in the fourth position indicates whether the item is to be repaired 1 T M 1 1 - 5 8 2 0 - 5 2 0 - 3 4 P - 1 and identifies the lowest maintenance level with the capability to perform complete repair (i.e., all a
44、utho- rized maintenance functions). This position will con- tain one of the following maintenance codes: CodeApplication/Explanation FThe lowest maintenance level capable of com- plete repair of the support item is the direct support level. HThe lowest maintenance level capable of com- plete repair
45、of the support item is the gen- eral support level. DThe lowest maintenance level capable of com- plete repair of the support item is the depot level. z Nonreparable. No repair is authorized. (3) Recoverability code. Recoverability codes are assigned to support items to indicate the disposition acti
46、on on unserviceable items. The recoverability code is entered in the fifth position of the Uniform SMR Code format as follows: Recoverability codesDefinition zNonreparable item. When unserviceable, con- demn and dispose at the level indicated in position 3. FReparable item. When uneconomically repar
47、- able, condemn and dispose at the direct sup- port level. H Reparable item. When uneconomically repar- able, condemn and dispose at the general support level. D Reparable item. When beyond lower level re- pair capability, return to depot. Condemna- tion and disposal not authorized below depot level
48、. L Reparable item. Repair, condemnation, and disposal not authorized below depot/spe- cialized repair activity level. c. National Stock Number. Indicates the National stock number assigned to the item and will be used for requisitioning purposes. 2 TM 11-5820-520-34P-1 d. Part Number. Indicates the
49、 primary number used by the manufacturer (individual, company, firm, corporation, or Government activity), which controls the design and characteristics of the item by means of its engineering drawings, specifications, standards, and inspection requirements to identify an item or range of items. NOTE When a stock numbered item is req- uisitioned, the repair part received may have a different part number than the part being replaced. e. Federal Supply Code for Manufacturer (FSCM). The FSCM is a 5-digit numeric code listed in SB 708-42 which is used to identify the manufacturer
免费区 
