《AM-3979_FRC-93_Collins_30L-1_HF_amplifier_serv_TM11-5820-554-24P-1_1977.pdf》由会员分享，可在线阅读，更多相关《AM-3979_FRC-93_Collins_30L-1_HF_amplifier_serv_TM11-5820-554-24P-1_1977.pdf（19页珍藏版）》请在收音机爱好者资料库上搜索。
1、TM 11-5820-554-24P-1 TECHNICAL MANUAL ORGANIZATIONAL, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS (INCLUDING DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS) FOR AMPLIFIER, RADIO FREQUENCY AM-3979/FRC-93 (NSN-5820-00-082-4081) This publication is a courtesy
2、quick copy from the UNITED STATES ARMY PUBLICATIONS CENTER, ST. LOUIS, MISSOURI, to meet your needs while we are replenishing our regular stock. H E A D Q U A R T E R S , D E P A R T M E N T O F T H E A R M Y AUGUST 1977 *TM 11-5820-554-24P-1 TECHNICAL MANUAL HEADQUARTERS DEPARTMENT OF THE ARMY No.
3、11-5820-554-24P-1WASHINGTON, DC, 12 August 1977 ORGANIZATIONAL, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS (INCLUDING DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS) FOR AMPLIFIER, RADIO FREQUENCY AM-3979/FRC-93 (NSN 5820-00-082-4081) Current as of 24 May
4、1977 REPORTING OF ERRORS You can improve this manual by recommending improvements using DA Form 2028-2 (Test) locates in the back of the manual. Simply tear out the self-addressed form, fill it out as shown on the sample, fold it where shown, and drop it in the mail. If there are no blank DA Form 20
5、28-2 (Test) in the back of your manual, use the standard DA Form 2028 (Recommended Changes to Publications and Blank Forms) and forward to the Commander, US Army Electronics Command, ATTN: DRSEL-MA-Q Fort Monmouth, NJ 07703. In either case a reply will be furnished direct to you. Table of Contents I
6、llus PageFig SECTIONI.Introduction.1 II.Repair parts, list.5 Group00Amplifier, Radio Frequency AM-3979/FRC-93.51-5 SECTIONIII.Special tools list (Not applicable) IV.National stock number and part number index . 14 *This manual supersedes TM 11-5820-532-24P, 29 June 1973. i TM 11 5820-554-24P-1 SECTI
7、ON I INTRODUCTION 1.Scope This manual lists spares and repair parts; special tools; special test, measurement, and diagnostic equipment (TMDE), and other special support equipment required for performance of organizational, direct support, and general support maintenance of the AM-3979/FRC-93. It au
8、thorizes the requisitioning and issue of spares and repair parts as indicated by the source and maintenance codes. 2.General This Repair Parts and Special Tools List is divided into the following sections: a. Section II. Repair Parts List. A list of spares and repair parts authorized for use in the
9、performance of maintenance. The list also includes parts which must be removed for replacement of the authorized parts. Parts lists are composed of functional groups in numeric sequence, with the parts in each group listed in figure and item number sequence. b. Section III. Special Tools List. Not a
10、pplicable. c. Section IV. National Stock Number and Part Number Index. A list, in National item identification number (NIIN) sequence, of all National stock numbers (NSN) appearing in the listings, followed by a list, in alphameric sequence, of all part numbers appearing in the listings. National st
11、ock numbers and part numbers are cross-referenced to each illustration figure and item number appearance. 3.Explanation of Columns a. Illustration. This column is divided as follows: (1) Figure number. Indicates the figure number of the illustration on which the item is shown. (2) Item number. The n
12、umber used to identify item called out in the illustration. b. Source, Maintenance, and Recoverability (SMR) Codes. (1) Source code. Source codes indicate the manner of acquiring support items for maintenance, repair, or overhaul of end items. Source codes are entered in the first and second positio
13、ns of the Uniform SMR Code format as follows: Code Definition PAItem procured and stocked for anticipated or known usage. XDA support item that is not stocked. When required, item will be procured through normal supply channels. NOTE Cannibalization or salvage may be used as a source of supply for a
14、ny items source coded above except those coded XA and aircraft support items as restricted by AR 700-42. (2) Maintenance code. Maintenance codes are assigned to indicate the levels of maintenance authorized to USE and REPAIR support items. The maintenance codes are entered in the third and fourth po
15、sitions of the Uniform SMR Code format as follows: (a) The maintenance code entered in the third position will indicate the lowest maintenance level authorized to remove, replace, and use the support item. The maintenance code entered in the third position will indicate one of the following levels o
16、f maintenance: Code Application/Explanation OSupport item is removed, replaced, used at the organizational level. FSupport item is removed, replaced, used at the direct support level. (b) The maintenance code entered in the fourth position indicates whether the item is to be repaired and identifies
17、the lowest maintenance level with the capability to perform complete repair (i.e., all authorized maintenance functions). This position will contain one of the following maintenance codes: Code Application/Explanation ZNonrepairable. No repair is authorized. (3) Recoverability code. Recoverability c
18、odes are assigned to support items to indicate the disposition action on unserviceable items. The recoverability code is entered in the fifth position of the Uniform SMR Code format as follows: Recoverability codes Definition Z Nonrepairable item. When unserviceable, condemn and dispose at the level
19、 indicated in position 3. c. National Stock Number. Indicates the National stock number assigned to the item and will be used for requisitioning purposes. d Part Number. Indicates the primary number used by the manufacturer (individual, company, firm, corpora- tion, or Government activity), which co
20、ntrols the design and characteristics of the item by means of its engineering drawings, specifications, standards, and inspection re- quirements to identify an item or range of items. NOTE When a stock numbered item is requisitioned, the repair part received may have a different part number than the
21、 part being replaced. e. Federal Supply Code for Manufacturer (FSCM). The FSCM is a 5-digit numeric code listed in SB 708-42 which is used to identify the manufacturer, distributor, or Government agency, etc. f. Description. Indicates the Federal item name and, 1 TM 11-5820-554-24P-1 if required, a
22、minimum description to identify the item. g. Unit of Measure (U/M). Indicates the standard of the basic quantity of the listed item as used in performing the actual maintenance function. This measure is expressed by a two-character alphabetical abbreviation (e.g., ea. in, pr, etc). When the unit of
23、measure differs from the unit of issue, the lowest unit of issue that will satisfy the required units of measure will be requisitioned. h. Quantity incorporated in Unit Indicates the quantity of the item used in the breakout shown on the illustration figure, which is prepared for a functional group,
24、 subfunctional group, or an assembly. 4.Special Information The following publication pertains to the AM-3979/FRC- 93 and its components: TM 11-5820-532-15, Amplifier, RF AM-3979/FRC-93 5.How to Locate Repair Parts a When National stock number or part number is unknown. (1) First Using the table of
25、contents, determine the functional group within which the item belongs. This is necessary since illustrations are prepared for functional groups and listings are divided into the same groups. (2) Second. Find the illustration covering the functional group to which the item belongs. (3) Third. Identi
26、fy the item on the illustration and note the illustration figure and item number of the item. (4) Fourth. Using the Repair Parts Listing, find the figure and item number noted on the illustration. b. When National stock number or part number is known. (1) First. Using the Index of National Stock Num
27、bers and Part Numbers, find the pertinent National stock number or part number. This index is in NIIN sequence followed by a list of part numbers in alphameric sequence, cross-referenced to the illustration figure number and item number. (2) Second. After finding the figure and item number, locate t
28、he figure and item number in the repair parts list. 6.Abbreviations Not applicable. (Next printed page is 4) 2 TM11-5820-554-24P-1 Figure 1. Amplifier, RF AM-3979/FRC-93. 4 SECTION IITM 11-5820-554-24P-1 GROUP 00 AMPLIFIER, RF AM-3979/FRC-93 11PAOZZ5355-00-966-5289547-3656-00213499KNOBEA2 12PAFZZ593
29、0-00-981-9342PA230-100571590SWITCH,ROTARYEA1 13PAOZZ5355-00-778-4967544-0779-00413499KNOBEA2 14PAFZZ5930-00-985-389501811-11301010939317SWITCH,PUSHEA1 15PAFZZ6625-00-958-1953458-0592-0013499METER,ELECTRICALEA1 16PAFZZ5935-00-928-3127UG1185BV80058CONNECTOR,PLUG,ELECEA1 17XDFZZ023594375CONNECTOR,PLUG,
30、ELECEA1 18PAFZZ5935-00-892-914835008556ADAPTER,CONNECTOREA1 19PAOZZ5995-00-990-8662C102-4893490CABLE ASSEMBLYEA2 110PAOZZ5995-00-901-43364C133682389CABLE ASSEMBLY, RFEA1 111PAOZZ5120-00-223-69958SHORTARM08664KEY,SOCKET HEAD SCREA1 112PAOZZ5120-00-781-8977S076- 4CADDRZNPL 08664KEY,SOCKET HEAD SCREA1
31、(1) ILLUSTRATION (8) QTY INC IN UNIT (7) U/M (6) DESCRIPTION USABLE ON CODE (5) FSCM (4) PART NUMBER (3) NATIONAL STOCK NUMBER (2) SMR CODE (a) FIG NO. (b) ITEM NO. 5 TM11-5820-554-24P-1 Figure 2. Amplifier, RF AM-3979/FRC-93, Bottom View. 6 SECTION IITM 11-5820-554-24P-1 21PAFZZ5910-00-984-0050154-
32、274970CAPACITOR.VARIABLEEAI 22PAFZZ5950-00-228-42343410376487COIL,RFEA1 23PAOZZ5960-00-189-597381104855ELECTRON TUBEEA4 24PAFZZ5305-00-685-73293X10871590INSULATOR,STANDOFFEA2 25PAFZZ5950-00-951-3807547-3708-00313499COIL,RFEAI 26PAFZZ5950-00-951-5067547-3718-00213499COIL,RFEA1 27PAFZZ 5910-00-668-364
33、7DA858-00371590CAPACITOR,FIXED,CEREA1 28PAFZZ5915-00-979-8225547-3707-00213499LEAD ASSEMBLY,SUPPREA2 29PAFZZ5915-00-979-8225449RSS402660SOCKET,ELCTRN TUBEEA4 210PAFZZ5935-00-162-3077Z14P6M1744655COIL,RFEA1 211PAFZZ5915-00-774-5201YA8355-205624PROPELLER,FANEA1 212PAFZZ 4140-00-985-0182CN61731997137CA
34、PACITOR,VARIABLEEAI 213PAFZZ5910-00-952-2489DYA81164705624MOTOR,ACEA1 214PAFZZ6105-00-797-0044NS5W020681349INSULATOR,STANDOFFEAI 215XDFZZGS1071313INSULATOR,STANDOFFEA3 216PAFZZ5999-00-983-5213547-3632-00213499SWITCH,INTERLOCKEA1 217PAFZZ5910-00-804-7088DA134-048CB13499CAPACITOR,FXD,MICAEA1 218PAFZZ6
35、130-00-900-9411547-3694-0071590POWER SUPPLYEA2 219PAFZZ5940-00-983-5211547-3666-00313499TERMINAL BOARDEA1 220PAFZZ5910-00-725-31130344113499CAPACITOR,FXD,MICAEA1 221PAFZZ5961-00-978-76601N54056289SEMICONDUCTOR,DIODEEA1 222PAFZZ5905-00-279-3527RC42GF47K99180RESISTOR,FXD,CMPSNEA1 223PAFZZ5905-00-185-8
36、516RC42GF103K81349RESISTOR,FXD,CMPSNEA1 224PAFZZ5970-00-803-9428X8671590INSULATOR,BUSHINGEAI 225PAFZZ5999-00-979-4287547-3670-00313499PRINTED CIRCUIT BDEAI 226XDFZZ540-9230-00313499NUT,SLEEVEEA4 227PAFZZ4140-00-782-5132547-3702-0013499FAN,AXIALEA1 228PAFZZ5930-00-981-9343215870F176854SWITCH,ROTARYEA
37、1 229PAFZZ5970-00-588-0845E100011976INSULATOR,STANDOFFEA1 230PAFZZ5910-00-995-7469D3364756289CAPACITOR,ELCTLTEA6 231PAFZZ5910-00-682-3135913-4329-0013499CAPACITOR,FIXED,CEREA2 232PAFZZ5950-00-553-45274414-482142COIL,RFEA1 233PAFZZ5905-00-739-8181CM2804712697RESISTOR,FXD,WWEA6 234PAFZZ5905-00-993-697
38、5RN65B1781F81349RESISTOR,FXD,FILMEA1 235PAFZZ5905-00-279-4320RC42GF100K81349RESISTOR,FXD,CMPSNEA2 236PAFZZ5999-00-983-5213547-3632-00213499SWITCH,INTERLOCK (1) ILLUSTRATION (8) QTY INC IN UNIT (7) U/M (6) DESCRIPTION USABLE ON CODE (5) FSCM (4) PART NUMBER (3) NATIONAL STOCK NUMBER (2) SMR CODE (a)
39、FIG NO. (b) ITEM NO. 7 TM11-5820-554-24P-1 Figure 3. Amplifier, RF AM-3979/FRC-93, Printed Circuit Board. 8 SECTION IITM 11-5820-554-24P-1 3IXDFZZ1N149224446SEMICONDUCTOR,DIODEEA16 32XDFZZ851000X5U010Z205162CAPACITOR,FlXED,CEREA16 33PAFZZ5905-00-279-2530RC42GF152J81349RESISTOR,FIXED,CMPSNEA1 34PAFZZ
40、5905-00-722-3134RSM5-1R0F91637RESISTOR,FXD,WWEAI 35PAFZZ5905-00-553-2402705-4260-0013499RESISTOR,FIXED,FILMEA1 (1) ILLUSTRATION (8) QTY INC IN UNIT (7) U/M (6) DESCRIPTION USABLE ON CODE (5) FSCM (4) PART NUMBER (3) NATIONAL STOCK NUMBER (2) SMR CODE (a) FIG NO. (b) ITEM NO. 9 TM11-5820-554-24P-1 Fi
41、gure 4. Amplifier, RF AM-3979/FRC-93, Rear View. 10 SECTION IITM 11-5820-554-24P-1 41PAFZZ5910-00-666-7974557018U2P034R05162CAPACITOR,VAR,CEREA1 42XDFZZ376-0205-01399RESISTOR,YARtABLEEA1 43PAFZZ5910-00-714-3806913-3013-0013499CAPACITOR,FIXED,CEREA12 44PAFZZ5910-00-604-7566CK70AW102M81349CAPACITOR,FI
42、XED,CEREA10 45PAFZZ5950-00-993-98073017580089TRANSFORMER,POWER, EA1 46PAFZZ5905-00-985-1216710-9010-0013499RESISTOR,FIXED,WWEA1 47PAFZZ5945-00-985-3677KRP2565-177342RELAY,ARMATUREEA1 48PAFZZ5950-00-954-6551240-1244-0013499COIL,RFE&1 49PAFZZ5950-00-880-06384414278429COIL,RFEA1 410PAFZZ5910-00-958-251
43、1CM05F221JP381349CAPACITOR,FXD,MICAEA8 411PAFZZ5950-00-631-14234424-406560COIL,RFEA1 412PAFZZ5930-00-960-4826214093LK176854SWITCH,ROTARYEA1 413PAFZZ5010-00-528-99443900376487COUPLING,SHAFTEA1 414PAFZZ5905-00-113-7346RCR32G470JS81349RESISTOR,FXD,CMPSNEA4 415PAFZZ5910-00-958-2516CM05 F151JP381349CAPAC
44、ITOR,FXD,MICAEA2 416PAFZZ5910-00-892-7961CM05F101JP381349CAPACITOR,FXD,MICAEA3 411PAFZZ5910-00-965-5336CM05E470JP381349CAPACITOR,FXD,MICAEA2 418PAFZZ5961-00-975-21751N45881350SEMICONDUCTOR,DIODEEA3 419PAFZZ5910-00-958-6690CM05F271JP381349CAPACITOR,FXD,MICAEA1 420PAFZZ5910-00-578-1976CM05E820J81349CA
45、PACITOR,FXD,MICAEAI 421PAf ZZ5910-00-952-1549DM15F5116500V72136CAPACITOR,FXD,MICAEA1 422PAFZZ5910-00-954-5498MILC5-1881349CAPACITOR,FXD,MICAFA2 423PAFZZ5910-00-088-1146CM05F331J0381349CAPACITOR.FXD,MICAEAI 424PAFZZ5905-00-195-6451RC20GF472K81349RESISTOR,FXD,CMPSNEA1 425PAFZZ5905-00-190-8882RC20GF393
46、K81349RESISTOR,FXD,CMPSNEA2 426PAFZZ5905-00-141-1118RCR20G390JS81349RESISTOR,FXD,CMPSNEA1 (1) ILLUSTRATION (8) QTY INC IN UNIT (7) U/M (6) DESCRIPTION USABLE ON CODE (5) FSCM (4) PART NUMBER (3) NATIONAL STOCK NUMBER (2) SMR CODE (a) FIG NO. (b) ITEM NO. 11 TM11-5820-554-24P-1 Figure 5. Amplifier RF
47、 AM-3979/FRC-93, Rear Panel. 12 SECTION IITM 11-5820-554-20P-2 5lPAFZZ5970-00-280-9427X8771590INSULATOR,BUSHINGEA1 52PAFZZ5920-00-892-9311HKPJE71400FUSEHOLDEREA2 53PAOZZ5920-00-284-643331400875913FUSE,CARTRIDGEEA2 54PAFZZ5935-00-149-3483UG58AU80058CONNECTOR,RCPT,ELECEAI 55PAFZZ5935-00-259-2034201-11
48、-01-01871785JACK,TIPEA3 56PAFZZ5950-00-951-2799547-3659-00313499COlL.RFEA1 57PAFZZ5950-00-951-5076547-3660-00313499COIL,RFEA1 58PAFZZ5950-00-951-2798547-3661-00313 499COIL,RFEA1 59PAFZZ5950-00-988-4023547-3662-00313499COIL,RFEA1 510PAFZZ5950-00-951-5068547-3663-00313499COIL,RFEA1 (1) ILLUSTRATION (8) QTY INC IN UNIT (7) U/M (6) DESCRIPTION USABLE ON CODE (5) FSCM (4) PART NUMBER (3) NATIONAL STOCK NUMBER (2) SMR CODE (a) FIG NO. (b) ITEM NO. 13 SECTION IVNATIONAL STOCK NUMBER AND PART NUMBER INDEXTM11-5820-554-24P-1 NOTE: LATEST NAT
免费区 
