《AN-GRC-106A_serv_TM11-5820-520-34P-2_1989.pdf》由会员分享，可在线阅读，更多相关《AN-GRC-106A_serv_TM11-5820-520-34P-2_1989.pdf（300页珍藏版）》请在收音机爱好者资料库上搜索。
1、TM 11-5820-520-34P-2 TECHNICAL MANUAL DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST (INCLUDING DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS) FOR RADIO SET AN/GRC-106A (NSN 5820-00-223-7548) Distribution authorized to the Department of Defense and DOD contract
2、ors only for official use or for administration or operational purposes. This determination was made on 6 January 1989. Other requests for this document will be referred to Commander, US Army Communications-Electronics Command and Fort Monmouth, ATTN: AMSEL-LC-ME-P, Fort Monmouth, NJ 07703-5000. DES
3、TRUCTION NOTICEDestroy by any method that will prevent disclosure of contents or reconstruction of the document. HEADQUARTERS, DEPARTMENT OF THE ARMY 15 APRIL 1989 *TM 11-5820-520-34P-2 TECHNICAL MANUAL HEADQUARTERS NO. 11 -5820-520-34P-2 DEPARTMENT OF THE ARMY Washington, DC, 15 April 1989 DIRECT S
4、UPPORT AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST (INCLUDING DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS) FOR RADIO SET AN/GRC-106A (NSN 5820-00-223-7548) Current as of 9 March 1989 REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS You can help improve this manual. If you
5、find any mistakes or if you know of a way to improve the procedures, please let us know. Mail your letter, DA Form 2028 (Recommended Changes to Publications and Blank Forms), or DA Form 2028-2 located in back of this manual direct to: Commander, US Army Communications-Electronics Command and Fort Mo
6、nmouth, ATTN: AMSEL-LC-ME-PS, Fort Monmouth, New Jersey 07703-5000. In either case a reply will be furnished direct to you. *This manual supersdes TM11-5820-520-34P-2 dated 27 April 1978 i TM 11-5820-520-34P-2 Table of Contents Page II SECTION IIntroduction. . . . . . . . . . . . . . . . . . . . . .
7、 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Repair parts list. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . GROUP 00 Radio set AWGRC-106A. . . . . . . . . . . . . . . . . . . . . . . . . .
8、 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 01 Receiver-transmitter RT-834/GRC. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0101Panel-chassis assembly 1A1. . . . . . . . . . . . . . . . . . . . . . . . 010101Front panel assembly 1A1A1. . .
9、 . . . . . . . . . . . . . . . . . . . . . . . . . 01010101Front end protection assembly 1A1A1A10 . . . . . . . . . . . . . 010102Chassis assembly 1A1A2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 01010201Internal alc assembly 1A1A2A5. . . . . . . . . . . . . . . . . . . . . . . . 0
10、1010202100 Hz synthesizer 1A1A2A8. . . . . . . . . . . . . . . . . . . . . . . . . . 01010203Voltage regulator assembly 1A1A2A9 . . . . . . . . . . . . . . . . 010103Tuning drive 1A1A3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0102100 kHz synthesizer 1A2. . . .
11、 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0103Frequency standard module 1A3. . . . . . . . . . . . . . . . . . . . . . . . . 010410 and 1kHz synthesizer module 1A4 . . . . . . . . . . . . . . . . . 0105Transmitter if and audio module 1A5. . . . . . . . . . . . . . . . . . 0106Frequenc
12、y dividers module 1A6. . . . . . . . . . . . . . . . . . . . . . . . . . 0107Receiver if module 1A7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0108Translator module 1A8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0109MHz synthesizer module 1A9. . . . . . . . .
13、. . . . . . . . . . . . . . . . . 0110Receiver audio module 1A10. . . . . . . . . . . . . . . . . . . . . . . . . . . 0111DC-to-DC convertor and regulator module 1A11 . . . . . 0112RF amplifier module 1A12. . . . . . . . . . . . . . . . . . . . . . . . 0113Case assembly 1A13. . . . . . . . . . . . .
14、 . . . . . . . . . . . . . . . . . . . . . . . 02 Amplifier, radio frequency AM-3349/GRC-106. . . . . . . . . . . . . . . . . . . . . . . . . . 0201 020101 02010101 0201010101 0201010102 02010102 020102 02010201 02010202 0201020201 0201020202 02010203 02010204 02010205 02010206 02010207 0202 020201
15、020202 0203 0204 1 1-1 1-1 2-1 3-1 4-1 5-1 6-1 7-1 8-1 9-1 10-1 11-1 12-1 13-1 14-1 15-1 16-1 17-1 18-1 19-1 20-1 21-1 22-1 23-1 Illus Figure 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 Chassis-panel assembly 2A1. . . . . . . . . . . . . . . . . . . . . . . . . . .24-1 24 Chassis ass
16、embly 2A1A1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25-1 25 Power amplifier plenum 2A1A1A2. . . . . . . . . . . . . . . . . . .26-1 26 Voltage regulator assembly 2A1A1A2A2 . . . . . . . . . . . . . . . . 27-1 27 Automatic phase control tune assembly 2A1A1A2A4. . . .28-1 28
17、Electrical chassis 2A1A1A3. . . . . . . . . . . . . . . . . . . . . . . . . . .29-1 29 Power amplifier panel 2A1A5. . . . . . . . . . . . . . . . . . . . . . . . . .30-1 30 Filter assembly 2A1A5A1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31-1 31 DC-to-DC convertor assembly 2A1A5A2
18、. . . . . . . . . . . . . . . 32-1 32 Screen rectifier assembly 2A1A5A2A4 . . . . . . . . . . . . . . . . . 33-1 33 Start circuit assembly 2A1A5A2A6. . . . . . . . . . . . . . . . . . .34-1 34 Plate assembly 2A1A5A3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35-1 35 Gear drive ass
19、embly 2A1A5A4. . . . . . . . . . . . . . . . . . . . . . . .36-1 36 Terminal board assembly 2A1A5A5. . . . . . . . . . . . . . . . . .3 7 - 1 3 7 Front panel assembly 2A1A5A6. . . . . . . . . . . . . . . . . . . . . . . . .38-1 38 Protection circuit assembly 2A1A5A7 . . . . . . . . . . . . . . . . .
20、 . 39-1 39 Turret assembly 2A2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40-1 40 Drum, turret 2A2A1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41-1 41 Drive, turret 2A2A2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
21、42-1 42 Antenna coupler assembly 2A3. . . . . . . . . . . . . . . . . . . . . . . . . .43-1 43 Discriminator assembly 2A4. . . . . . . . . . . . . . . . . . . . . . . . . . . .4 4 - 1 4 4 i i TM 11-5820-520-34P-2 Table of Contents - continued Illus Figure GROUP 02- continued 03 04 05 06 07 08 09 10
22、11 12 13 Section Ill. Section IV 0205Case assembly 2A6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 5 - 1 4 5 020501lnverter assembly 2A6A1. . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 6 - 1 4 6 0206Relay assembly 2A7. . . . . . . . . . . . . . . . . . . . . .
23、 . . . . . . . . . . . . . . . .4 7 - 7 4 7 0207Driver assembly 2A8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 8 - 1 4 8 0208PA stator assembly 2A9. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 9 - 1 4 9 Mounting assembly MT-3140/GRC-106. . . . . . . . . . .
24、. . . . . . . . . . . . . . . . . . . .5 0 - 1 5 0 Interconnecting cables (see group 00) Antenna group AN/GRA50 (see TM-11-5820-467-24P for parts) Loudspeaker LS-166/U (no parts authorized) Grounding kit (not used) Mast base AB-652/GR (no parts authorized) Mast sections MS-116A, MS-117A and MS-118A
25、(no parts authorized) Telegraph key KY-116/U (no parts authorized) Headset H-227/U (no parts authorized) Headset H-33/PT (no parts authorized) Microphone M-29B/U (no parts authorized) Special tools list (not applicable) Cross-Reference Indexes National Stock Number Index . . . . . . . . . . . . . .
26、. . . . . . . . . . . . I-1 Part Number Index. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .I-13 Figure and Item Number Index. . . . . . . . . . . . . . . . . . . . . . . . . . .I-44 i i i T M 1 1 - 5 8 2 0 - 5 2 0 - 3 4 P DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE R
27、EPAIR PARTS AND SPECIAL TOOLS LIST (INCLUDING DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST) SECTION I. INTRODUCTION 1. Scope. This RPSTL lists and authorizes spares and repair parts; special tools; special test, measure- ment, and diagnostic equipment (TM DE); and other special support equi
28、pment required for performance of direct support, and general support maintenance of the AN/GRC-106(A). It authorizes the requisitioning, issue, and disposition of spares, repair parts and special tools as indicated by the source, maintenance and recoverability (SMR) codes. 2. General. In addition t
29、o Section I, Introduction, this Repair Parts and Special Tools List is divided into the following sections: a. Section II. Repair Parts List. A list of spares and repair parts authorized by this RPSTL for use in the performance of maintenance. The list also includes parts which must be removed for r
30、eplacement of the authorized parts. Parts lists are composed of functional groups in alphanumeric ascending sequence, with the parts in each group listed in ascending item number sequence.Items listed are shown on the associated illustration(s)/figure(s). b. Section III. Special Tools List. Not appl
31、icable. c. Section IV. Cross-reference Indexs. A list, in National item identification number (NIIN) sequence, of all National stock numbered items appearing in the listing, followed by a list in alphanumeric sequence of all part numbers appearing in the listings. National stock numbers and part num
32、bers are cross-referenced to each illustration/figure and item number appearance. The figure and item number index lists figure and item numbers in alphanumeric sequence and cross-references NSN, FSCM, and part numbers. 3. Explanation of Columns (Sections II and Ill). a. ITEM NO. (Column 1). Indicat
33、es the number used to identify items called out in the illustration. b. SMR CODE (Column (2). The Source, Maintenance, and Recoverability (SMR) code is a five-position code containing supply/requisitioning information, maintenance level authori- zation criteria, and disposition instruction, as shown
34、 in the following breakout: 1 TM 11-5820-520-34P 4th position SourceMaintenance Recoverability CodeCode Code 1st two positions3rd position 5th position How you get an itemWho can install,Who can do Who determines replace or usecomplete repair*disposition the itemon the item action on an unserviceabl
35、e item *Complete Repair: Maintenance capacity, capability, and authority to perform all corrective maintenance task of the “Repair” function in an use/user environment in order to restore PA PB PC* PO PE PF PG KD KF KB serviceability to a failed item. (1) Source Code. The source code is the first tw
36、o positions of the SMR code. It tells item needed for maintenance, repair, or overhaul of an end item/equipment. AO-(Assembled by org/AVUM level) AF-(Assembled by DS/AVIM level) AH-(Assembled by GS level) AL-(Assembled by SRA) AD-(Assembled by Depot) Explanations of source codes follows: Explanation
37、 Stocked items; use applicable NSN to request/requisition items with these source codes. They are authorized to the level indicated by the code entered in the 3rd position of the SMR code. * * NOTE: Items coded PC are subject to deterioration. Items with these codes are not to be requested/requisiti
38、oned individually. They are part of a kit which is authorized to the maintenance level indicated in the 3rd position of the SMR code. The complete kit must be requisitioned and applied. Explanation Items with these codes are not to be requested/requisitioned individually. They must be made from bulk
39、 material which is identified by the part number in the DESCRIPTION AND USABLE ON CODE (UOC) column and listed in the Bulk Material group of the repair parts list in this RPSTL. If the item is authorized to you by the 3rd position code of the SMR code, but the source code indicates it is made at a h
40、igher level, order the item from the higher level of maintenance. 2 Code Explanation MO-(Made at erg/ AVUM level) MF-(Made at DS/ AVIM level) MH-(Made at GS level) ML-(Made at Spe- cialized Repair Act (SPA) MD-(Made at Depot) TM 11-5820-520-34P Explanation Items with these codes are not to be reques
41、ted/requisitioned individually. The parts that make up the assembled item must be requisitioned or fabricated and assembled at the level of maintenance indicated by the source code. If the 3rd position of the SMR code authorizes you to replace the item, but the source code indicates the item is asse
42、mbled at a higher level, order the item from the higher level of maintenance. XADo not requisition an “XA”-coded item. Order its next higher assembly. (Also, refer to the NOTE below.) XBIf an “XB” item is not available from salvage, order it using the FSCM and part number given. XCInstallation drawi
43、ng, diagram, instruction sheet, field service drawing, that is identified by manufacturers part number. XDItem is not stocked. Order an “XD” coded item through normal supply channels using the FSCM and part number given, if no NSN is available. NOTE:Cannibalization or controlled exchange, when autho
44、rized, may be used as a source of supply for items with the above source codes, except for those source coded “XA” or those aircraft support items restricted by requirements of AR 750-1. ( 2 ) Maintenance Code.Maintenance codes tells you tile level(s) of maintenance au- thorized to USE and REPAIR su
45、pport items. The maintenance codes are entered as follows: ( a ) The maintenance code entered in the third position tells you the lowest level authorized to remove, replace, and use an item. The maintenance code entered in the third position will indicate authorization to the following levels of mai
46、ntenance. Code Application/Explanation CCrew or operator maintenance done within organizational or aviation unit maintenance. OOrganizational or aviation unit level can remove, replace, and use the item. FDirect support or aviation intermediate level can remove, replace, and use the item. HGeneral s
47、upport level can remove, replace, and use the item. LSpecialized repair activity can remove, replace, and use the item. DDepot level can remove, replace, and use the item. 3 TM 11-5820-520-34P ( b ) The maintenance code entered in the fourth position tells whether or not the item is to be repaired a
48、nd identifies the lowest maintenance level with the capability to do complete repair (i.e., perform all authorized repair functions). (NOTE: Some limited repair may be done on the item at a lower level of maintenance, if authorized by the Maintenance Allocation Chart (MAC) and SMR codes.) This posit
49、ion will contain one of the following mainte- nance codes: Code O F H L D Z B ( 3 ) Application/Explanation Organizational or aviation unit is the lowest level that can do complete repair of the item. Direct support or aviation intermediate is the lowest level that can do complete repair of the item. General support is the lowest level that can do complete repair of the item. Specialized repair activity (designate the specialized repair activity) is the lowest level that can do complete repair of the item. Depot is the lowest level that can do complete repair of
免费区 
