《AN-PRC-132_user_TM11-5820-1102-12_1992.pdf》由会员分享，可在线阅读，更多相关《AN-PRC-132_user_TM11-5820-1102-12_1992.pdf（96页珍藏版）》请在收音机爱好者资料库上搜索。
1、1-1 2-1 3-1 4-1 A-1 B-1 C-1 TM 11-5820-1102-12 OPERATORS AND UNIT MAINTENANCE MANUAL RADIO SET, AN/PRC-132 (NSN 5820-01-320-8831) (EIC: N/A) CONSISTING OF RECEIVERTRANSMITTER, RADIO RT1648/PRC132 (NSN 5820-01-320-3686) (EIC: N/A) AND BATTERY BOX CY-8629/PRC-132 (NSN 6160-01-322-9366) (EIC: N/A) Dist
2、ribution authorized to the Department of Defense and DOD contractors only for official use or for administrative or operational purposes. This determination was made on 15 February 1992. Other requests for this document will be referred to Commander, US Army CommunicationsElectronics Command and For
3、t Monmouth, ATTN: AMSELLC-LM-LT, Fort Monmouth, New Jersey 07703-5007. DESTRUCTION NOTICE Destroy by any method that will prevent disclosure of contents or reconstruction of the document. HEADQUARTERS, DEPARTMENT OF THE ARMY 15 MAY 1992 TM 11-5820-1102-12 C1 CHANGE NO. 1 HEADQUARTERS DEPARTMENT OF T
4、HE ARMY, Washington, DC, 15 November 1993 OPERATORS AND UNIT MAINTENANCE MANUAL RADIO SET, AN/PRC-132 (NSN 5820-01-320-8831) (EIC:N/A) CONSISTING OF RECEIVER-TRANSMIITER, RADIO RT-1648/PRC-132 (NSN 5820-01-320-3686) (EIC:N/A) AND BATTERY BOX CY-8629/PRC-132 (NSN 6160-01-322-9366) (EIC:N/A) TM 11-582
5、0-1102-12, 15 MAY 1992 is changed as follows: 1. Remove old pages and insert new pages as indicated below. New or changed material is indicated by a vertical bar in the margin of the page. Added or revised changes to illustrations are indicated by a vertical bar adjacent to the identification number
6、 or by miniature pointing hands Remove pagesInsert pages B-3 and B-4B-3 and B-4 NoneB-5 through B-7/(B-8 blank) 2. File this change sheet in the front of the publication for reference purposes. Distribution authorized to the Department of Defense and DoD contractors only for official use or for admi
7、nistrative or operational purposes. This determination was made on 15 August 1991. Other requests for this document will be referred to Commander, U.S. Army Communications-Electronics Command and Fort Monmouth, ATTN: AMSEL-LC-LM-LT, Fort Monmouth, New Jersey 07703-5007. DESTRUCTION NOTICE - Destroy
8、by any method that will prevent disclosure of contents or reconstruction of the document. By Order of the Secretary of the Army: GORDON R. SULLIVAN General, United States Army Chief of Staff Official: MILTON H. HAMILTON Administrative Assistant to the Secretary of the Army 05446 DISTRIBUTION : To be
9、 distributed in accordance with DA Form 12-36-E, block 9086, requirements for TM-11-5820-1102-12. TM 11-5802-1102-12 SAFETY STEPS TO FOLLOW IF SOMEONE IS THE VICTIM OF ELECTRICAL SHOCK DO NOT TRY TO PULL OR GRAB THE INDIVIDUAL IF POSSIBLE, TURN OFF THE ELECTRICAL POWER IF YOU CANNOT TURN OFF THE ELE
10、CTRICAL POWER, PULL, PUSH, OR LIFT THE PER SON TO SAFETY USING A DRY WOODEN POLE OR A DRY ROPE OR SOME OTHER INSULATING MATERIAL SEND FOR HELP AS SOON AS POSSIBLE AFTER THE INJURED PERSON IS FREE OF CONTACT WITH THE SOURCE OF ELECTRICAL SHOCK, MOVE THE PERSON A SHORT DISTANCE AWAY AND IMMEDIATELY ST
11、ART ARTIFICIAL RESUSCITATION a. TM 11-5820-1102-12 WARNING INJURY CAN OCCUR IF THE FOLLOWING ARE NOT OBSERVED WHEN USING THE RADIO SET WARNING RF VOLTAGE WARNING Exposed metal transceiver parts can assume an RF potential to ground when antenna is tuned without grounding transceiver. To avoid potenti
12、al RF burns, tie transceiver GND stud to ground. WARNING KEEP AWAY FROM LIVE CIRCUITS The antenna is a source of electrical and radio frequency energy. NEVER TOUCH THE ANTENNA WHEN THE RADIO SET IS IN USE. An RF burn may occur as a result of contact with an active antenna system. WARNING TRANSMIT PO
13、WER LIMITATION Transmit power is limited to a maximum of 20 watts when operating with two BA-5590 batteries. When batteries are combined, transmit power may be limited dependent upon the relative state of the battery charge. WARNING DO NOT OPEN TRANSCEIVER CASE Operator personnel must not remove the
14、 transceiver case. Transceiver is not repairable at operator and unit maintenance level. WARNING Operator must replace both BA-5590/U with completely new batteries at the same time. Do not mix partially used batteries with new batteries. If possible, the operator should use two BA-5590 batteries man
15、ufactured by the same vendor with the same date code. b. TM 11-5820-1102-12 WARNING Do not attempt to transmit when charging batteries. WARNING Circuit card A13 contains BERYLLIUM OXIDE (BeO) CERAMICS. The dust or fumes from BERYLLIUM OXIDE CERAMICS are HIGHLY TOXIC and breathing them can result in
16、serious personal injury or DEATH. For local guidance/assistance on disposal of unserviceable circuit card A13, contact your servicing Defense Reutilization and Marketing Office (DRMO). WARNING A lithium-sulfur dioxide (Li-S02) battery used with the AN/PRC-132 contains pressurized sulfur dioxide (S02
17、) gas. The gas is toxic, and the battery MUST NOT be abused in any way which may cause the battery to rupture. DO NOT heat, short circuit, crush, puncture, mutilate, or disassemble batteries. DO NOT USE any battery which shows signs of damage, such as bulging, swelling, disfigurement, a brown liquid
18、 in the plastic wrap, a swollen plastic wrap, etc. DO NOT test Li-S02 batteries for capacity. DO NOT recharge Li-S02 batteries. DO NOT Defense dispose of lithium batteries with ordinary trash/refuse. Turn in batteries to your local servicing Reutilization and Marketing Office. WARNING If the battery
19、 compartment becomes hot to the touch, if you hear a hissing sound (i.e., battery venting), or smell irritating sulfur dioxide gas, IMMEDIATELY Turn Off the equipment and leave the area. 1. Allow the equipment to cool at least one hour. 2. Remove and replace battery after the equipment has cooled to
20、 the touch. 3. If there is a safety incident, or if you believe a safety hazard exists, notify your local Safety Office/Officer, file a Quality Deficiency Report, SF Form 368, and notify the CECOM Safety Office, Ft. Monmouth, NJ at AV 995-3112. c. TM 11-5820-1102-12 WARNING DO NOT use a HaIon type f
21、ire extinguisher on a lithium battery fire. In the event of a fire, near a lithium battery(ies), rapid cooling of the lithium battery(ies) is important. Flood the equipment with water or use a carbon dioxide (C02) extinguisher. Control of the equipment fire, and cooling, may prevent the battery from
22、 venting and potentially exposing lithium metal. In the event that lithium metal becomes involved in fire, the use of a graphite based Class D fire extinguisher is recommended, such as Lith-X or Met-L-X. WARNING DO NOT store batteries in unused equipment for more than 30 days. DO NOT store lithium b
23、atteries with other hazardous materials and keep them away from open flame or heat d. TM 11-5820-1102-12 FIXED OPERATION WITH LONG RANGE ANTENNAS WARNING TELESCOPING ANTENNA MAST DOUBLET ANTENNA TYPICAL TOWEREXTENDED RANGE ANTENNA NEVER ERECT THESE LONG RANGE ANTENNAS DIRECTLY UNDER POWERLINES. If y
24、ou must erect these Iong range antennas near powerlines, powerline poles or towers, or buildings with overhead powerline connections, never put the antenna closer than two times the antenna height from the base of the powerline, pole, tower or buildings. NEVER ATTEMPT TO ERECT ANY LONG RANGE ANTENNA
25、 WITHOUT A FULL TEAM. Before erecting any long range antenna, inspect all the parts making up the antenna kit. Do not erect the antenna if any parts are missing or damaged. Do as much of the assembly work as possible on the ground. When erecting the antenna, allow only team personnel in the erection
26、 area. Make sure that the area for the anchors is firm. If the ground is marshy or sandy, get specific instructions from your crew chief or supervisor on how to reinforce the anchors. When selecting locations for anchors, avoid traveled areas and roads. If you specific instructions from your supervi
27、sor as to what clearance your guy wires traveled areas and road. Clearly mark all guy wires and ropes with the warning flags or signs supplied by strips of white cloth as warning streamers. cannot avoid these areas, get and ropes must have over the your unit. If an emergency, use If you suspect that
28、 powerlines have made accidental contact with your antenna, stop operating, rope off the antenna area, and notify your superiors. If the weather in your area can cause ice to form on your long range antenna and its guy wires and ropes, add extra guys to support the system. Rope off the area and post
29、 it with warning signs like BEWARE OF FALLING ICE. Do not try to erect any antenna during an electrical storm. Keep a sharp eye on your anchors and guys. Check them daily and immediately before and after bad weather. e. TM 11-5820-1102-12 HOW TO USE THIS MANUAL This manual describes the set-up and o
30、peration of the AN/PRC-132 radio set. This manual is arranged in four chapters containing: an introduction to the equipment (Chapter 1), operating instructions (Chapter 2), operator maintenance instructions (Chapter 3), and unit maintenance procedures (Chapter 4). Manual text is divided into primary
31、 and subordinate paragraph structure. Some paragraphs may also be divided into procedural steps. Throughout the manual there are illustrations that will help you determine how to set-up, operate, and maintain your radio set. While using this manual, remember that your mission and the situation you m
32、ay be involved in will determine the type of radio operations you select. This manual also describes possible trouble situations and the actions you can take to solve a potential radio set problem. f. TM 11-5820-1102-12 Technical Manual No. 115820110212 HEADQUARTERS DEPARTMENT OF THE ARMY Washington
33、, DC, 15 May 1992 OPERATORS AND UNIT MAINTENANCE MANUAL RADIO SET, AN/PRC-132 (NSN 5820-01-320-8831) (EIC: N/A) CONSISTING OF RECEIVERTRANSMITTER, RADIO RT1648/PRC-132 (NSN 5820-01-320-3686) (EIC: N/A) AND BATTERY BOX CY-8629/PRC-132 (NSN 6160-01-322-9366) (EIC: N/A) REPORTING ERRORS AND RECOMMENDIN
34、G IMPROVEMENTS You can help improve this manual. If you find any mistakes, or if you know of a way to improve the procedures, please let us know. Mail your letter, DA Form 2028 (Recommended Changes to Publications and Blank Forms) or DA Form 20282 located in back of this manual direct to: Commander,
35、 US Army Communications Electronics Command and Fort Monmouth, ATTN: AMSELLCLMLT, Fort Monmouth, New Jersey 077035007. In either case a reply will be furnished direct to you. i TM 11-5820-1102-12 TABLE OF CONTENTS PAGE CHAPTER 1 INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
36、. . . . . . . . . . . . . . . . 1-1 Section l. GENERAL INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 1-1 SCOPE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 1-1.1 Type of
37、 Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 1-1.2 Model Number and Equipment Name . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 1-1.3 Purpose of Equipment. . . . . . . . . . . . . . . . . . . . .
38、. . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 1-2 MAINTENANCE FORMS, RECORDS, AND REPORTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 1-2.1 Reports of Maintenance and Unsatisfactory Equipment . . . . . . . . . . . . . . . . . . . . . . . . 1-1 1-2.2 Report of Packaging and
39、Handling Deficiencies . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 1-2.3 Transportation Discrepancy Report (TDR)(SF 361) . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 1-3 CONSOLIDATED INDEX OF ARMY PUBLICATIONS AND BLANK FORMS . . . . . . . . . . . . . 1-1 1-4 REPORT
40、ING EQUIPMENT IMPROVEMENT RECOMMENDATIONS (EIRS) . . . . . . . . . . . . . . 1-1 1-5 NOMENCLATURE CROSS-REFERENCE LIST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2 1-6 DESTRUCTION OF ARMY MATERIEL TO PREVENT ENEMY USE . . . . . . . . . . . . . . . . . . . 1-2 1-7 PREPARATION
41、 FOR STORAGE OR SHIPMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2 1-8 WARRANTY INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2 Section l. EQUIPMENT DESCRIPTION AND DATA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
42、1-2 1-9 EQUIPMENT CHARACTERISTICS, CAPABILITIES, AND FEATURES . . . . . . . . . . . . . . . . . . 1-2 1-10 LOCATION AND DESCRIPTION OF MAJOR COMPONENTS . . . . . . . . . . . . . . . . . . . . . . 1-3 1-10.1 External Components. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
43、. . . . . . . . . . 1-3 1-10.2 Internal Components. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3 1-10.3 Auxiliary Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3 1-10.4 Accessories . . . . . . . . .
44、. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-7 1-11 EQUIPMENT DATA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-7 1-11.1 Performance Specifications . . . . . . . . . . . . . . . . . . . . . . . . .
45、. . . . . . . . . . . . . . . . . . 1-7 1-11.2 Microprocessor Capability . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-7 1-11.3 Transmitter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-9 1-11
46、.4 Receiver . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-9 1-11.5 Mechanical . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-9 1-12 SAFETY, CARE, AND HANDLlNG . . . . .
47、. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-9 Section Ill. PRINCIPLES OF OPERATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-11 1-13 GENERAL OPERATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
48、. . . . 1-11 1-14 INTERFACES AND CONTROL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-12 1-15 OPERATION IN RECEIVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-14 1-16 OPERATION IN TRANSMIT. . . . . . . . . . . . . . . .
49、 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-14 CHAPTER 2 OPERATING INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1 Section l. DESCRIPTION AND USE OF OPERATORS CONTROLS AND INDICATORS . . . . . . . . 2-1 2-1 CONTROLS, INDICATORS, AND CONNECTORS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1 Section Il. OPERATOR PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) . . . . . . 2-4 ii TM 11-5820-1102-12 TABLE OF CONTENTS (cont) PAGE Section Ill. OPERATION UNDER USUAL CONDITIONS . . . . . . . . . . . . . . . . . . .
免费区 
