Alto_APM80.1000,_APM80.1500_Powered_Mixer_Service_Manual电路图.pdf

《Alto_APM80.1000,_APM80.1500_Powered_Mixer_Service_Manual电路图.pdf》由会员分享，可在线阅读，更多相关《Alto_APM80.1000,_APM80.1500_Powered_Mixer_Service_Manual电路图.pdf（45页珍藏版）》请在收音机爱好者资料库上搜索。

1、MODEL: APM80.1000/APM80.1500 RadioFans.CN 收音机爱 好者资料库 CONTENT 1. INTRODUCTION.1 2. TECHNICAL SPECIFICATION.3 3. BLOCK DIAGRAM.5 4. SCHEMATIC DIAGRAM.6 5. WIRING DIAGRAM13 6. PCB LAYOUT.14 7. TEST PROCEDURE.21 8. EXPLODED VIEW adjust the potentiometers to the 0 position. The PAD switch is springing, t

2、he DSP turns off and the phantom power turns on. 1. Phantom Power Test Use UV-meter to test the MIC sockets pin 1 and pin 2 of each channel from CH1 to CH9/10 respectively. The voltage between pin1 and pin3 is 48V+/-3V .Turn down the 48V switch after finished testing. 2. Signal Input and Output Test

3、 a). The AP setting is as follows: b). The Range Test of Each Output Channel: Input -40dBu, 1 kHz signal to MIC socket of CH1, the output range level of each output channel is as follows: AUX2 OUT: 6dBu (3dBu) THD+N : 0.3% MONITOR OUT: -5dBu (3dBu) THD+N0.3% MAIN OUT LEFT: 0dBu (3dBu) THD+N : 0.3% M

4、AIN OUT RIGHT: 0dBu (3dBu) THD+N : 0.3% HEAD PHONE OUT: 4dBu (3dBu) THD+N : 0.3% TAPE LEFT OUT: -3dBu (3dBu) THD+N : 0.3%. TAPE RIGHT OUT: -4dBu (3dBu) THD+N : 0.3%. c). The Input Sensitivity Test of Each Channel Thereinafter is the corresponding input sensitivity of each input channel when the MAIN

5、 7. TEST PROCEDURE - 21 - OUT is equal to 0dBu and THD+N : 60V. (Amplitude value) APM80.1500: 68V. (Amplitude value) 2. AMPLIFIER MODE is the MAIN+ MONITOR status, the outputs of the amplifier are: APM80.1000: 60V. (Amplitude value) APM80.1500: 68V. (Amplitude value) 3. AMPLIFIER MODE is in the brid

6、ge status, at that time, the load is 8 ohms. APM80.1000: 108V. (Amplitude value) APM80.1500: 128V. (Amplitude value) 9. Signal Noise Test: a). Turn all the LEVEL GAIN to the minimum, and turn the GAIN of the MAIN and MONITOR knobs to the maximum, at this point, the curve of the amplifier output (LEF

7、T, RIGHT) is as follows: - 25 - The signal noise is requested to be lower than -40dBu. b). Alter AP input to the MAIN LEFT and RIGHT outputs of the MIXER, the curve is as follows: - 26 - The signal noise is requested to be lower than -65dBu. 10. Listening Test a). Adjust AC voltage, make AC input is

8、 equal to 230V; the power supply switch indicates the 230V position. Connect to the high quality cabinets, connect the signal of the DVD player to the input of each channel, adjust the LEVEL MAIN and MONITOR LEVEL to the appropriate volume, operate the switch and knob of each channel respectively (f

9、rom minimum to maximum).During the operation, there should be not occurred big sonic boom, and also doesnt have the noise of turning the potentiometers, the noise of the listening amplifier output and MAIN output can not bigger than the sample. Turn on the PHANTOM power (Note: Before turning on the

10、PHANTOM power, you should turn the MAIN LEVEL and MONITOR LEVEL to the minimum), the noise of the listening amplifier output and MAIN output can not become bigger (refer to the sample). b). Adjust the AC voltage, make the AC output is equal to 115V, the power switch indicates the 115V position, acco

11、rding to the above method to do the Listening Test. - 27 - 8. EXPLODED VIEW30F-C R1-1,R1-2,R1-3,R1-4,R1-5,R1-6,R1-7,R20,R2-1,R2-2,R2-3,R2-4, R2-5,R2-6,R2-7,R27,R3-1,R3-2,R3-3,R3-4,R3-5,R3-6,R3-7,R4-1,R4-2, R4-3,R4-4,R4-5,R4-6,R4-7,R5-1,R5-2 370 RC00360potentiometer B50K? RD12L12CA23A- 50K3BT*2(SAS1)

12、;30F-C R13,R38,R7-1,R7-2,R7-3,R7-4,R7-5,R7-6,R7-7,R8-1,R8-2,R8-3,R8-4, R8-5,R8-6,R8-7 371 RA00119fixed resistor 1/2W220? M typeR35,R42 372 RA00324fixed resistor 1/8W22? M typeR92,R93 373 RA00955metal-oxide-film resistor 5W82? P typeR108 - 39 - NO.Part No.DescriptionSpecificationRemark 374 RA00139fix

13、ed resistor 1/2W3.9K? M typeR111 375 HI00317rotary switchRE2001-40E2-155F-4BSW1,SW2 376 HI00238push-button switch-RS2 6P PS-92 26A(NON-LOCK)S1 377 HI00236push-button switch-RS2 6P PS-92 26A(SELF-LOCK)S2,S3,S1-1,S2-1,S3-1,S4-1, S5-1,S6-1,S7-1,S8-1 378 SD00032integrated circuitLM317T(TO220)/(ST)U8,U12

14、,U19 379 SD00033integrated circuitLM337SP(1.5A)(TO220)/(ST)U18 380 NI00863plastic washerTO220B 381 ME00015color nut3m/m 382 MF00037washer?3.2*?5.5*1t 383 MG00166screwM3*10 384 MG00243copper pillarM3*5*0.5PH 385 MG00326screw3*4 386 MI02137heat simk-RS-ACTPBM-8_V1.2 387 MJ00055AL plate2*2000*1000 10.8

15、8kg 388 HK00756PC boardP-PBM8_CTRL-SMD 389 HB01097PCBPBM8-CTRL_VER051124. 390 CI00146SMD ceramic capacitor 0805 0.22uF/50V X7R 10% CF1-1,CF1-2,CF2-1,CF2-2, CF10-1,CF10-2,CF10-3,CF10-4, CF11-1,CF11-2,CF11-3,CF11-4 391 CI00098SMD ceramic capacitor 0805 0.033uF/50V X7R 10% CF3-1,CF3-2,CF4-1,CF4-2,CF12-

16、1,CF12-2,CF12-3,CF12-4, CF13-1,CF13-2,CF13-3,CF13-4 392 CI00112SMD ceramic capacitor 0805 0.01uF/50V X7R 10% CF5-1,CF5-2,CF6-1,CF6-2,CF14-1,CF14-2,CF14-3, CF14-4, CF15-1,CF15-2, CF15-3,CF15-4 393 CI00021SMD ceramic capacitor 0805 0.001uF/50V NPO 5% C1-3,C2-3,C3-3,C4-3,C5-3,C6-3,CF7-1,CF7-2,C7-3,CF8-

17、1,CF8-2, C8-3,CF9-1,CF9-2,CF16-1,CF16-2,CF16-3,CF16-4,CF17-1, CF17-2,CF17-3,CF17-4,CF18-1,CF18-2,CF18-3,CF18-4,C7-13,C8-13 394 CI00007SMD ceramic capacitor 0805 22PF/50V NPOC2,C3,C5,C6,C7,C9,C11,C12, C14,C16,C18,C20,C22,C24,C26, 395 CI00013SMD ceramic capacitor 0805 56PF/50V NPOC1-1,C2-1,C3-1,C4-1,C

18、5-1,C6-1 396 CI00024SMD ceramic capacitor 0805 0.0022uF/50V X7R 10%C1-2,C2-2,C3-2,C4-2,C5-2,C6-2,C7-2,C8-2,C7-12,C8-12 397 CI00016SMD ceramic capacitor 0805 100PF/50V NPOC1-4,C2-4,C3-4,C4-4,C5-4,C6-4,C7-4,C8-4,C7-14,C8-14 398 CI00026SMD ceramic capacitor 0805 0.0033uF/50V X7R 10%C1-5,C2-5,C3-5,C4-5,

19、C5-5,C6-5,C7-5,C8-5,C7-15,C8-15 399 CI00133SMD ceramic capacitor 0805 0.047uF/-50V X7R 10?C1-6,C2-6,C3-6,C4-6,C5-6,C6-6,C7-6,C8-6,C7-16,C8-16 400 CI00001SMD ceramic capacitor 0805 10PF/50V NPO C1-8,C1-9,C23,C25,C27,C2-8,C2-9,C29,C31,C33,C3-8,C3-9,C4-8, C4-9,C5-8,C5-9,C6-8,C6-9,C7-8,C7-9,C8-8,C8-9,C7

20、-18,C7-19,C8-18, C8-19 401 CI00018SMD ceramic capacitor 0805 220PF/50V NPO 5%C28,C32 402 CI00100SMD ceramic capacitor 0805 0.1uF/50V X7R 10% C45,C46,C54,C58,C60,C61,C62,C63,C64,C65,C66,C67,C68,C1-11, C1-12,C1-13,C1-14,C2-11,C2-12,C2-13,C2-14,C3-11,C3-12,C3-13, C3-14,C4-11,C4-12,C4-13,C4-14,C5-11,C5-

21、12,C5-13,C5-14,C6-11, C6-12,C6-13,C6-14,C7-21,C7-22,C7-23,C7-24,C8-21,C8-22,C8-23 ,C8-24,C69,C50,C56 404 RD00028SMD fixed resistor 1/8W5.6K? 5% 0805 RF1-2,R33,R49,R54,R57,R62,R65,R70,RF7-2,RF10-2,RF10-9, R1-21,RF16-2,RF16-9,R2-21,R3-21,R4-21,R5-21,R6-21,R7-21,R7-44, R8-21,R8-44 405 RD00036SMD fixed

22、resistor 1/8W18K? 5% 0805 RF1-5,RF2-5,RF3-5,RF4-5,RF5-5,RF6-1,RF6-3,RF6-4,RF6-5, RF7-5,RF8-5,RF9-5,RF10-5,RF11-5,RF12-5,RF13-5,RF14-5,RF15- 1,RF15-3,RF15-4,RF15-5,RF15-8,RF16-5,RF17-5,RF18-5,RF10- 12,RF11-12,RF12-12,RF13-12,RF14-12,RF15-10,RF15-11,RF15- 12,RF16-12,RF17-12,FR18-12 406 RD00019SMD fixe

23、d resistor 1/8W1.2K? 5% 0805RF2-2,RF11-2,RF11-9 407 RD00046SMD fixed resistor 1/8W56K? 5% 0805 R14,R16,R21,RF3-1,RF3-3,RF3-4,RF8-1,RF8-3,RF8-4,RF12-1, RF12-3,RF12-4,RF12-8,RF17-1,RF17-3,RF17-4,RF17-8,RF12-10, RF12-11,RF17-10,RF17-11,R34 408 RD00025SMD fixed resistor 1/8W3.3K? 5% 0805RF3-2,RF8-2,RF12

24、-2,RF12-9,RF17-2,RF17-9 - 40 - NO.Part No.DescriptionSpecificationRemark 409 RD00040SMD fixed resistor 1/8W27K? 5% 0805 RF4-1,RF4-3,RF4-4,RF9-1,RF9-3,RF9-4,RF13-1,RF13-3,RF13-4, RF13-8,RF18-1,RF18-3,RF18-4,RF18-8,RF13-10,RF13-11, RF18-10,RF18-11 410 RD00021SMD fixed resistor 1/8W1.8K? 5% 0805RF4-2,R

25、F13-2,RF13-9 411 RD00044SMD fixed resistor 1/8W47K? 5% 0805RF5-1,RF5-3,RF5-4,RF14-1,RF14-3,RF14-4,RF14-8,RF14-10,RF14-11 412 RD00454SMD fixed resistor 1/8W2.7K? 5% 0805R29,R40,R46,RF5-2,R103,R106,RF14-2,RF14-9 413 RD00018SMD fixed resistor 1/8W1.0K? 5% 0805 R19,RF6-2,R76,R77,R81,R82,R88,R89, R96,R1-

26、22,RF15-2,RF15-9, R2-22,R3-22,R4-22,R5-22,R6-22, R7-22,R7-45,R8-22,R8-45 414 RD00049SMD fixed resistor 1/8W100K? 5% 0805 RF7-1,RF7-3,RF7-4,R74,R79,R86,RF16-1, RF16-3,RF16-4, RF16-8, RF16-10,RF16-11 415 RD00023SMD fixed resistor 1/8W2.2K? 5% 0805 RF9-2,R1-13,R1-15,RF18-2,RF18-9,R2-13,R2-15,R3-13,R3-1

27、5,R4-13, R4-15,R5-13,R5-15,R6-13,R6-15,R7-13,R7-15,R7-36,R7-38,R8-13, R8-15,R8-36,R8-38 416 RD00016SMD fixed resistor 1/8W680? 5% 0805R2,R3,R4,R5,R6,R7,R8,R9,R37,R44,R83,R90,R94 417 RD00015SMD fixed resistor 1/8W560? 5% 0805R1-8,R2-8,R3-8,R4-8,R5-8,R6-8 418 RD00479SMD fixed resistor 1/8W180? 5% 0805

28、R1-9,R2-9,R3-9,R4-9,R5-9,R6-9,R84,R91,R95 419 RD00032SMD fixed resistor 1/8W10K? 5% 0805 R10,R11,R12,R18,R24,R99,R1-14,R1-16,R1-18,R1-19,R1-27,R2-14, R2-16,R2-18,R2-19,R2-27,R3-14,R3-16,R3-18, R3-19,R3-27,R4-14, R4-16,R4-18,R4-19,R4-27,R5-14,R5-16, R5-18,R5-19,R5-27,R6-14, R6-16,R6-18,R6-19,R6-27,R7

29、-14, R7-16,R7-18,R7-37,R7-39,R7-41, R8-14,R8-16,R8-18,R8-37, R8-39,R8-41,R97,R98 420 RD00033SMD fixed resistor 1/8W12K? 5% 0805R15,R17,R22 421 RD00009SMD fixed resistor 1/8W220? 5% 0805R23,R48,R101,R104,R107,R110 422 RD00480SMD fixed resistor 1/8W68K? 5% 0805R25,R7-10,R7-33,R8-10,R8-33 423 RD00481SM

30、D fixed resistor 1/8W8.2K? 5% 0805R28,R39,R45,R7-9,R8-9,R100,R7-32,R8-32 424 RD00042SMD fixed resistor 1/8W33K? 5% 0805R32,R36,R43 425 RD00043SMD fixed resistor 1/8W39K? 5% 0805R52,R56,R60,R64,R68,R72 426 RD00056SMD fixed resistor 1/8W1.0M? 5% 0805R75,R80,R87 427 RD00030SMD fixed resistor 1/8W6.8K?

31、5% 0805R1-10,R2-10,R3-10,R4-10,R5-10,R6-10,R51,R55,R59,R63,R67,R71 428 RD00020SMD fixed resistor 1/8W1.5K? 5% 0805R1-12,R2-12,R3-12,R4-12,R5-12,R6-12,R7-35,R8-35,R7-12, R8-12 429 RD00050SMD fixed resistor 1/8W150K? 5% 0805R1-17,R2-17,R3-17,R4-17,R5-17,R6-17,R7-17,R7-40,R8-17,R8-40 430 RD00027SMD fix

32、ed resistor 1/8W4.7K? 5% 0805R1-24,R2-24,R3-24,R4-24,R5-24,R6-24,R7-24,R7-47,R8-47,R8-24 431 RD00051SMD fixed resistor 1/8W180K? 5% 0805R102 432 SG00122 SMD integrated circuit-RS- ACT NJM4580M-TE3(SOP8)/(JRC) UF1,U1,UF2,U2,UF3,U3,UF4,U4,UF5,U5,UF6,U6,UF7,U7,UF8,UF9,U9, UF10,U10,UF11,U11,U11,UF12,U12

33、,UF13,U13,UF14,U14,U15,U16,U1 7,U2-1,U2-2,U3-1,U3-2,U4-1,U4-2,U5-1,U5-2,U6-1,U6-2,U7-1,U7-2, U7-3,U8-1,U8-2, U8-3 433 RD00037SMD fixed resistor 1/8W20K? 5% 0805R41,R47,R30 434 RD00017SMD fixed resistor 1/8W820? 5% 0805R109 435 RD00052SMD fixed resistor 1/8W220K? 5% 0805R112 436 SE00011SMD rectifier

34、diodeRLS4148 0.5A (LL-34)D23,D24,D25,D27 437 SF00051transistorSST176(S6)(SOT23)/(VISHAY)TR1,TR2 438 AE00449solder material without lead9308/Sn Ag Cu 439 HK00669PC board-RSP-DIGIT_EFFECTD_REV04-DIP(RX700)P1 440 HC00618connector-RS2.54 90 12P 4.0/13.31mmP1 441 HK00668PC boardP-DIGIT_EFFECTD_REV04-SMD

35、442 HB01092PCBDIGIT_EFFECT_REV04 443 CI00026SMD ceramic capacitor 0805 0.0033uF/50V X7R 10%C1,C6 444 CJ00005SMD AL electrolytic capacitor 10uF/16V CASE4?C2,C5,C9 445 CI00013SMD ceramic capacitor 0805 56PF/50V NPOC3,C10 446 CI00100SMD ceramic capacitor 0805 0.1uF/50V X7R 10%C4,C7,C8,C12,C17,C18,C19 4

36、47 CI00146SMD ceramic capacitor 0805 0.22uF/50V X7R 10%C11 448 CI00007SMD ceramic capacitor 0805 22PF/50V NPOC15,C13 449 CI00145SMD ceramic capacitor 0805 0.0015uF/50V X7R 10%C14 450 CJ00002SMD AL electrolytic capacitor 1uF/50V CASE4?C16 - 41 - NO.Part No.DescriptionSpecificationRemark 451 SE00016SM

37、D zener diode1/2W 5.1V(RLZ5.1B) LL-34D1 452 SE00011SMD rectifier diodeRLS4148 0.5A (LL-34)D2,D3,D4,D5,D6,D7 453 SF00051transistorSST176(S6)(SOT23)/(VISHAY)Q1,Q2 454 RD00003SMD fixed resistor 1/8W10? 5% 0805R1,R9,R10,R11 455 RD00032SMD fixed resistor 1/8W10K? 5% 0805R2,R3,R12,R13,R19,R20,R22,R25, R29

38、 456 RD00042SMD fixed resistor 1/8W33K? 5% 0805R4,R14 457 RD00018SMD fixed resistor 1/8W1.0K? 5% 0805R5 458 RD00030SMD fixed resistor 1/8W6.8K? 5% 0805R6,R16,R27 459 RD00034SMD fixed resistor 1/8W15K? 5% 0805R7,R17 460 RD00056SMD fixed resistor 1/8W1.0M? 5% 0805R15,R26,R34 461 RD00023SMD fixed resis

39、tor 1/8W2.2K? 5% 0805R21,R31,R32 462 RD00049SMD fixed resistor 1/8W100K? 5% 0805R23 463 RD00267SMD fixed resistor 1/8W820K? 5% 0805R24 464 RD00057SMD fixed resistor 1/8W2.2M? 5% 0805R28 465 RD00009SMD fixed resistor 1/8W220? 5% 0805R30 466 RD00038SMD fixed resistor 1/8W22K? 5% 0805R33 467 SG00200SMD

40、 integrated circuitNJM4580V-TE1(SSOP8)/(JRC)U1,U2 468 SG00306SMD integrated circuitLM393DR(TI)/(MEXICO)U3 469 SG00068SMD integrated circuit74HC14DT(SO14)/(PHI)U5 470 SG00469SMD integrated circuit-RSSN74HC109DR(SO16)/(TI)U6 471 AE00449solder material without lead9308/Sn Ag Cu 472 SG00243SMD integrate

41、d circuitNE555DR(SO8)/(TI)U4 473 AC00179tin without lead-RSM705E Sn 3Ag-0.5Cu 474 RA00157fixed resistor 1/4W0.0?R31 475 CB00050electrolytic capacitor100uF/50V ?8*11mmC71 476 CB00069electrolytic capacitor1000uF/6.3V ?8*11mm 477 CB00064electrolytic capacitor470uF/16V ?10*12mmC59 478 NC00005micaSB-9500

42、DSP 18*13*0.1t_V1.0 479 AC00179tin without lead-RSM705E Sn 3Ag-0.5Cu 480 RA00957fixed resistor 1/8W100? RF1-6,RF2-6,RF3-6,RF4-6,RF5-6,RF6-6,RF7-6,RF8-6,RF9-6, RF10-6,RF11-6,RF12-6,RF13-6,RF14-6,RF15-6,RF16-6,RF17-6, RF18-6,RF10-13,RF11-13,RF12-13,RF13-13,RF14-13,RF15-13, RF16-13,RF17-13,RF18-13 481

43、HK01409PC board-RSP-313123-DIP(AMX-140FX) 482 SC00004crystal oscillator16.00MHZXT1 483 HC00484connector2.54 180 2*8P(gold-plated) 13.5/19mmCN2 484 SG00193SMD integrated circuitAT27LV010A-90JC/L-8IC4 485 SG00168SMD integrated circuit-RSHT27LC010-90J(PLCC32)/(HOLTEK) 486 HK03894PC board-RS-ACTP-313123

44、-SMD(L-8) 487 HB00895PCB313123/2(1*6) 488 CI00075SMD ceramic capacitor 0603 0.1uF/50V Y5V +80,-20%C17,C15,C18,C6,C10,C22,C20,C13,C14,C1,C3,C4,C11 489 RD00061SMD fixed resistor 1/10W10? 5% 0603R22 490 RD00068SMD fixed resistor 1/10W100? 5% 0603R12,R14,R7,R8,R34,R17,R13,R33 491 RD00073SMD fixed resist

45、or 1/10W220? 5% 0603R3 492 RD00085SMD fixed resistor 1/10W1.5K? 5% 0603R16,R15,R21,R20,R4,R19,R10,R18,R9,R5 493 RD00088SMD fixed resistor 1/10W2.2K? 5% 0603R28,R27,R23,R24,R29,R30,R25,R26 494 RD00101SMD fixed resistor 1/10W10K? 5% 0603R32,R31,R1 495 RD00125SMD fixed resistor 1/10W1.0M? 5% 0603R2 496

46、 RE00006 SMD resistor networks 1/16W 100?*4 5% 8P 0603AR1,AR2 497 SE00011SMD rectifier diodeRLS4148 0.5A (LL-34)D1 498 SG00068SMD integrated circuit74HC14DT(SO14)/(PHI)IC1 499 SG00410SMD integrated circuitIC41LV16256-35KG(SOJ40)/(ICSI)IC6 500 SG00166SMD integrated circuitTY-2 ALTO(GMCODE:105022)IC3

47、- 42 - NO.Part No.DescriptionSpecificationRemark 501 SG00147SMD integrated circuitCHEF DSP(GMCODE:105022) 502 SG00037SMD integrated circuitLD1117DT33C(TO252)/(ST)IC2 503 HC00611IC socket (SMD)PLCC32 (AMP S/N:822516-7)IC4 504 SG00016SMD integrated circuitUDA1345TS(SSOP28)/(PHI)IC5 505 AE00449solder m

48、aterial without lead9308/Sn Ag Cu 506 CI00264 SMD ceramic capacitor-RS 0603 15PF/50V NPO 5?C8,C9 507 NE11475labelL-8 508 NH00221paper0.055*1M 509 NI00016membrane0.05*1M 510 AC00179tin without lead-RSM705E Sn 3Ag-0.5Cu 511 CB00166electrolytic capacitor100uF/16V ?6*5mmC19,C12,C5,C2,C24,C16,C21,C25, C26,C28,C7 - 43 -