JBL SUB-135 Service Manual电路图.pdf

《JBL SUB-135 Service Manual电路图.pdf》由会员分享，可在线阅读，更多相关《JBL SUB-135 Service Manual电路图.pdf（16页珍藏版）》请在收音机爱好者资料库上搜索。

1、Cinema ProPack 600 SUB135S Amplifier/Subwoofer SERVICE MANUAL JBL Consumer Products 250 Crossways Park Dr. Woodbury, New York 11797 Rev1 04/03 RadioFans.CN 收音机爱 好者资料库 For other Service and User Manuals, go to www.ManualD Note: The SUB135S is part of the SCS135S system, which is part of the JBL Cinem

2、a Propack 600 system. Satellite loudspeakers 135SAT are replacement-only; order JBL part# SAT135. - CONTENTS - BASIC SPECIFICATIONS.1 DETAILED SPECIFICATIONS.2 OPERATION.3 EXPLODED VIEW.4 TEST SET-UP AND PROCEDURE.5 BLOCK DIAGRAM.6 PCB DRAWINGS .7 ELECTRICAL PARTS LIST .9 MECHANICAL PARTS LIST. .11

3、INTEGRATED CIRCUIT/TRANSISTOR PINOUTS.12 SCHEMATICS.13 BASIC SPECIFICATIONS SUB135S Subwoofer Configuration: Floor-firing, bass-reflex ported enclosure Woofer: 8 cone Amplifier Power output: 100W Continuous RMS power 0.8% THD, 20Hz to 100Hz LFE Input Voltage/Impedance: 2V p-p/47k ohms Dimensions: Wi

4、dth: 13 inches (330mm) Height: 15 inches (381mm) Depth: 14 inches (356mm) Weight: 30 lb/13.6kg Occasional refinements may be made to existing products without notice but will always meet or exceed original specifications unless otherwise stated RadioFans.CN 收音机爱 好者资料库 1 SUB135S 100W Powered Amplifie

5、r LINE VOLTAGEYes/NoHi/Lo LineUnitNotes US 120vac/60HzYes108-132VrmsNormal Operation Asia 100vac/50HzYes90-110VrmsNormal Operation ParameterSpecificationUnitQA Test LimitsConditionsNotes Amp Section Type (Class AB, D, other)AB ABn/aExternal Sink required for Class AB Load Impedance (speaker)4 Ohmsn/

6、aNominalZ-curve required Rated Output Power100 Watts901 input driven THD Rated Power0.08 %0.322k filter THD 1 Watt0.1 %0.522k filter DC Offset10 mV-DC20 Speaker Outputs Damping factor75 DF50 Measured at speaker terminals, Output power 90 Watts THD 0.1 % Input Sensitivity Input Frequency50 Hz50Nomina

7、l Freq.1 input driven LFE Input550 mVrms2dBTo Rated PowerLFE input Signal to Noise SNR-A-Weighted100 dBA85rel. to rated powerA-Weighting filter SNR-unweighted85 dBr85rel. to rated power22k filter SNR 1W-unweighted65 dBr60rel. to 1W Output22k filter Residual Noise Floor1 mVrms1.5Using RMS reading DMM

8、/VOM (or A/P)LFE Input termintated with 600 Ohms Residual Noise Floor1mVrms(max)1.5 UsingA/P Swept Bandpass Measurement (Line freq.+ harmonics) Input Impedance Line input L turn the power switch ON. LED should be Red. 3. Turn up the generator and adjust to 300mV, 40 Hz. LED should now be Green. 4. I

9、mmediate bass response should be heard and felt from port tube opening. Sweep Function 1. Follow steps 1-4 above, using a sweep generator as a signal source. 2. Sweep generator from 20Hz to 1kHz. Listen to the cabinet and drivers for any rattles, clicks, buzzes or any other noises. If any unusual no

10、ises are heard, remove woofer and test. Driver Function (Woofer) 1. Remove woofer from cabinet; detach the + and - wire clips. 2. Check DC resistance of woofer; it should be 3.4 ohms 10%. 3. Connect a pair of speaker cables to driver terminals. Cables should be connected to an integrated amplifier f

11、ed by a signal generator. Turn on generator and adjust so that speaker level output is 5.0V. 5. Sweep generator from 20Hz to 1kHz. Listen to driver for any rubbing, buzzing, or other unusual noises. Caution: take care to replace the + and - wire clips on the correct terminals, as they are the same s

12、ize. Red wire should connect to the red dot on the terminal. SUB135S Cinema ProPack 600 5 SUB135S Cinema ProPack 600 6 7 8 JBL SUB135S Electrical Parts List Part NumberDescriptionQTYReference Designator Main/Input PCB Semiconductors 192027c1815grTransistor 2SC1815gr NPN8Q102,111,112,113,118,206,207,

13、208 192028A1015grTransistor 2SA1015GR tap PNP2Q114,116 1921672n5551Transistor 2N5551 tap NPN2Q103,109 1921682n5401Transistor 2N5401 AI-PNP 350V2Q104,110 197131n41481N4148 26mm Diode9D101,103,105,108,206,207,208,214,215 19915000335Zener diode 3.3V 1/2W 52mm2D102,205 19915000625Zener diode 6.2V 1/2W 5

14、2mm2D106,107 19915001605Zener diode 16V 1/2W 52mm1D109 19006m4558dIC OPA 4558 Dual Op-Amp2U101,203 19016tl074cnIC TL074CN ST Quad Op-Amp1U202 192011d669aTransistor 2SD669A NPN1Q106 192012b649aTransistor 2SB649A PNP1Q105 1920251tip35cTransistor TIP35C NPN1Q107 192022tip36cTransistor TIP36C PNP1Q108 1

15、92201d882yTransistor KSD882Y NPN1Q117 192202b772yTransistor KSB772Y PNP1Q119 19700kbl405Diode Bridge 4A 500V KBL4051D110 197131n40021N4002 26mm TAP Diode2D104 19510204hgwLED 204HGW1D209 Resistors 11010821jk1Resistor 820 Ohm 1W1R132 110122r2j15Resistor 2.2 Ohm 1R127 11020331jk2Resistor 330 Ohm 2W 5mm

16、1R146 11020331jk3Resistor 330 Ohm 2W 7.5mm1R149 113500r1j20cement Resistor 0.1 Ohm 5W2R121,122 11403302m0SVR 3K 0.3W 20%1R138 11014472j26Resistor 4.7K 1/4W1R147,50 11014681j26 Resistor 680 Ohm 1/4W2R148,51 11016101j26Resistor 100 Ohm 1/6W2R120,215 11016102j26Resistor 1k 1/6W2R124,254 11016103j26Resi

17、stor 10k 1/6W7R134,230,232,235,240,260,264 11016105j26Resistor 1M 1/6W2R143,259 11016123j26Resistor 12k 1/6W2R135,139 11016124j26Resistor 120k 1/6W1R233 11016151j26Resistor 150 Ohm 1/6W1R253 11016152j26Resistor 1.5k 1/6W6R103,123,136,137,141,142 11016153j26Resistor 15k 1/6W5R118,145,152,154,234 1101

18、6154j26Resistor 150k 1/6W2R131,252 11016181j26Resistor 180 Ohm 1/6W2R111,114 11016182j26Resistor 1.8k 1/6W1R153 11016183j26Resistor 18k 1/6W1R262 11016205j26Resistor 2.0M 1/6W1R257 9 Part NumberDescriptionQTYReference Designator 11016223j26Resistor 22K 1/6W7R128,129,133,237,238,255,263 11016332j26Re

19、sistor 3.3k 1/6W3R106,107,144 11016392j26Resistor 3.9k 1/6W2R105,108 11016393j26Resistor 39k 1/6W1R126 11016470j26Resistor 47 Ohm 1/6W4R112,113,115,116 11016471j26Resistor 470 Ohm 1/6W1R140 11016472j26Resistor 4.7k 1/6W4R110,125,130,258 11016473j26Resistor 47k 1/6W4R101,219,250,251 11016560j26Resist

20、or 56 Ohm 1/6W1R117 11016563j26Resistor 56k 1/6W1R104 11016682j26 Resistor 6.8K 1/6W1R109 11016822j26Resistor 8.2K 1/6W1R231 Capacitors 1302g472md00PE capacitor 4700p 400V1 132223ja03Capacitor 0.022uf 100V2C123,127 1353107m16Capacitor 100uf 16V1C110 1354688m50Capacitor 6800U/50V2C121,122 1302b101k50

21、3PE Capacitor 100P 50V 1C220 1302b102k503Capacitor 1000P 50V1C116 1302b221k503Capacitor 220P50V2C212,230 1302f104z503Capacitor 0.1U 50V9C108,113,115,119,232,236,237,240,241 1303f473m503Capacitor 0.047U 50V1C106 130sl 470k503Capacitor 47P 50V 1C229 132103j503Capacitor 0.01U 50V 2C223,224 132104j503Ca

22、pacitor 0.1U 50V3C107,221,222 132223ja03Capacitor 0.022uf 100V4C124,125,126,128 1353105m50Capacitor 1U 50V3C105,112,228 1353106m50Capacitor 10U 50V2C219,231 1353107m16Capacitor 100uf 16V6C109,117,120,234,238,242 1353226m50Capacitor 22U 50V3C114,118,225 1353227m10Capacitor 220U 10V2C129,130 1353227m1

23、6Capacitor 220U 16V2C111,233 1353476m25Capacitor 47U 25V1C103 Misc. 653hs135-sheat sink 65*32*311 712a130IC spacer2 1933m2520mica sheet T0-3P 25*20mm2For Q107,108 171udhss124dRelay 5A 24V YDH-SS124D1RY101 1740rca108Single RCA jack1JK203 1751c07v01coupling 7pin pitch=2.5mm1P101 1751d02v01coupling 2pi

24、n pitch=3.96mm1P102 192022tip36cLED socket 14.2*8.0*5.2 t=1.6mm1 Limiter PCB 192027c1815grTransistor 2SC1815gr NPN2Q301,302 197131n41481N4148 26mm Diode2D301,302 10 Part NumberDescriptionQTYReference Designator 19016tl074cnI.C. TL074CN ST Dual Op-Amp1U301 11016103j26Resistor 10K 1/6W7R301,302,303,30

25、4,308,309,314 11016223j26Resistor 22k 1/6W2R310,312 11016333j26Resistor 33k 1/6W1R305 11016474j26Resistor 470k 1/6W1R307 11016751j26Resistor 750 Ohm 2R311,313 11016755j26 Resistor 7.5M 1/6W1R306 1302f104z503Capacitor 0.1U 50V2C305,306 132103j503PE Capacitor 0.01U 50V2C302,303 1353226m50PE Capacitor

26、22U 50V 1C301 1353476m25PE Capacitor 47U25V1C304 16210059001wire 50mm white UL10071 16250129001cable ASSY 120mm1P302 1759f40hr2coupling 40pin pitch=2.54mm1P301 Mechanical Parts list 602p8300800screw M3*86R/P TO BRKT-2,PCB TO BRKT-4 602c8401610screw M4*164XFORMER-4 610gm4bscrew nut for M44XFORMER-4 6

27、07p8300800B type screw 3*8 8L-H/S TO R/P-6,R/P TO S-H/S-2 606p8301000P type screw 3*102JK201,202 600b8401200screw 4*124R/P TO R/C-4 150e8604107transformer EI-86 120v 60Hz1 152u602015power cord 2 cond. 6 Ft.1 154u25006t0Fuse 2.5A 250v 20mm1FS101 155520020Fuse holder R3-111 16210082007wire red AWG18 8

28、0mm1 16210372000speaker wire UL1015 370mm1 176wjce1terminal CE-11 180pbr12c11sPower Off/On switch BR12C11S1SW101 640rp135saluminum faceplate 215*270*2.5t1 650sub240frame for PCB L type T=1.6mm2 653hs135-1heat sink 117.5*60*251 700rc800arear cabinet 268*213*1021 723a125EVA gasket 213*15*2.0mm2 723a12

29、5-1EVA gasket 213*15*1.0t2 725b125EVA gasket 238*15*2.0mm2 723b125-1EVA gasket 238*15*1.0t2 723j125EVA gasket 225*15*1t UL1 725a125rubber gasket 25*21*4t4 156b010010connector wire 100mm 2 11 SUB135S Cinema ProPack 600 12 SUB135S Cinema ProPack 600 13 SUB135S Cinema ProPack 600 14 SUB135S Cinema ProPack 600 15