Roland JP-8080_SERVICE_NOTES 电路图.pdf

《Roland JP-8080_SERVICE_NOTES 电路图.pdf》由会员分享，可在线阅读，更多相关《Roland JP-8080_SERVICE_NOTES 电路图.pdf（27页珍藏版）》请在收音机爱好者资料库上搜索。

1、右左右左 右左右左 July, 1998JP-8080 TABLE OF CONTENTS目次Page SPECIFICATIONS 主仕様 LOCATION OF CONTROLS 配置図 EXPLODED VIEW 分解図 PARTS LIST IDENTIFYING THE VERSION NUMBER 確認方法 SAVING AND LOADING USER DATA FACTORY RESET HOW TO UPDATE THE SOFTWARE 方法 TEST MODE 12 ERROR MESSAGE FOR MEMORY TEST 12 BLOCK DIAGRAM 図 13 C

2、IRCUIT BOARD 基板図1416 CIRCUIT DIAGRAM 回路図1727 Printed in Japan (ACE0) (CR) 1 17059936 Issued by RJA Copyright c 1998 by ROLAND CORPORATION All rights reserved. No part of this publication may be reproduced in any form without the written permission of ROLAND CORPORATION. 本書一部、全部無断複写転載禁。 SPECIFICATION

3、S主仕様 JP-8080 SYnthesizer module Synthesizer Section GParts 2 (Upper, Lower) GKey Mode Single, Dual, Split GMaximum Polyphony 10 Voices (Voice Modulator OFF) 8 Voices (Voice Modulator ON) GWaveform OSC 1 SUPER SAWTRIANGLE MOD NOISEFEEDBACK OSC SQUARE (PWM)SAW TRIANGLE OSC 2 SQUARE (PWM)SAW TRIANGLENO

4、ISE GEffects Tone Control Multi-FX (13 types) SUPER CHORUS SLW, SUPER CHORUS MID, SUPER CHORUS FST, SUPER CHORUS CLR, FLANGER SLOW, FLANGER DEEP, FLANGER FAST, DEEP PHASING SLW, JET PHASING, TWISTING, FREEZE PHASE 1, FREEZE PHASE 2, DISTORTION Delay (5 types) PANNING L-R, PANNING R-L, PANNING SHORT,

5、 MONO SHORT, MONO LONG GInternal Memory PerformancesUser: 64 Preset: 192 PatchesUser: 128 Preset: 384 GVoice Modulator Two 12-band band-pass filters Noise Robot Oscillator Dedicated effect unit for Voice Modulator (Ensemble, Delay) Arpeggiator/RPS Section GArpeggio Mode UP DOWN UP&DOWN RANDOM GArpeg

6、gio Beat Patterns 1/4, 1/6, 1/8, 1/12, 1/16, 1/32, PORTA-A1-A11, PORTA-B1-B15, SEQUENCE-A1- A7, SEQUENCE-B1-B5, SEQUENCE-C1-C2, SEQUENCE-D1-D8, ECHO1-3, MUTE1-16, STRUMMING1-8, REFRAIN1-2, PERCUSSION1-4, WALKING BASS, HARP, RANDOM (total 90 types) GArpeggio Range 1 - 4 octave GHold ON/OFF GRPS Patte

7、rn Data (Internal Memory) Patterns: 48 Maximum Loop Length (Measures): 4 GResolution 24 ticks per quarter note GGate Time REAL, STACCATO, 33%, 50%, 66%, 100% GInput Quantize OFF, TRIPLET1/16, 1/16, TRIPLET1/8, 1/8, TRIPLET1/4, 1/4 GRecording Method Realtime (Loop Recording) GTempo 20 to 250 部 数 2（、）

8、 、 最大同時発音数 10音（Voice Modulator OFF） 8音（Voice Modulator ON） 内蔵波形 OSC 1 SUPER SAWTRIANGLE MOD NOISEFEEDBACK OSC SQUARE (PWM)SAW TRIANGLE OSC 2 SQUARE (PWM)SAW TRIANGLENOISE （13） SUPER CHORUS SLW, SUPER CHORUS MID, SUPER CHORUS FST, SUPER CHORUS CLR, FLANGER SLOW, FLANGER DEEP, FLANGER FAST, DEEP PHASI

9、NG SLW, JET PHASING, TWISTING, FREEZE PHASE 1, FREEZE PHASE 2, DISTORTION （5） PANNING L-R, PANNING R-L, PANNING SHORT, MONO SHORT, MONO LONG 本体 ： 64 ：192 ：128 ：384 122個 専用 （、） RPS部 UP DOWN UP&DOWN RANDOM 1/4, 1/6, 1/8, 1/12, 1/16, 1/32, PORTA-A1A11, PORTA-B1B15, SEQUENCE-A1A7, SEQUENCE-B1B5, SEQUENC

10、E-C1 C2, SEQUENCE-D1D8, ECHO13, MUTE116, STRUMMING18, REFRAIN1 2, PERCUSSION14, WALKING BASS, HARP, RANDOM（合計90） 14 ON、OFF RPS（本体） 数：48 最大長（小節）：4 分解能 244分音符 REAL、STACCATO、33、50、66、100 OFF、TRIPLET1/16、1/16、TRIPLET1/8、1/8、TRIPLET1/4、1/4 方式 （） 20250 RadioFans.CN 收音机爱 好者资料库 右左右左 右左右左 2 Motion Control Se

11、ction GMotion Data (Internal Memory) Motions: 2 x 2 sets (SET A, B) Maximum Loop Length (Measures): 8 Maximum Recording Length (Measures): 99 GRecording Method Realtime (Loop Recording and One Shot Recording) GTempo 20 to 250 Others GExternal Storage Device (SmartMedia) Storage: S2M-5 (2M bytes) Per

12、formances:64 x 32 Patches:128 x 32 RPS Patterns:48 Motion Controls:2 x 4 System Settings:1 S4M-5 (4M bytes) Performances:64 x 64 Patches:128 x 64 RPS Patterns:48 Motion Controls:2 x 4 System Settings:1 GDisplay 16 characters, 2 lines (backlit LCD) GConnectors MIDI connectors (REMOTE KBD IN, IN, OUT)

13、 Output jacksL(MONO): 1/4 inch phone type R: 1/4 inch phone type External Input jacks INST/LOWER(MONO): 1/4 inch phone type VOCAL/UPPER: 1/4 inch phone type MIC jack: 1/4 inch phone type Headphone jack: Stereo 1/4 inch phone type GInput Level External Input jacks INST/LOWER(MONO): -30dBm - +4dBm VOC

14、AL/UPPER: -30dBm - +4dBm MIC jack: -60dBm - -20dBm GInput Impedance External Input jacks INST/LOWER(MONO): 24k VOCAL/UPPER: 24k MIC jack: 5k GOutput Impedance Output jacks L(MONO):2.2k R:2.2k Headphone jack:100 GPower Supply AC117V, AC230V, AC240V GPower Consumption 17W(AC117V), 17W(AC230V), 17W(AC2

15、40V) GDimensions 482(W) x 88(D) x 264(H) mm 19(W) x 3-1/2(D) x 10-7/16(H) inches GWeight 4.5 Kg/9 lbs 15 oz (except Power cord) GAccessories Owners ManualEnglish:#71122323 Japanese :#71017512 Power Cord117V:#00894378 230V:#00894389 240VE:#00907001 240VA:#23495124 GOptions SmartMedia : S2M-5 (2M byte

16、s) S4M-5 (4M bytes) * In the interest of product development, the specifications for this product are subject to change without prior notice. 部 （本体） 数：22（SET A、B） 最大長（小節）：8 最大小節：99（） 方式 （、） 20250 他 外部記憶装置（） 記憶容量： S2M-5（2M） 6432 12832 RPS48 24 設定1 S4M-5（4M） 6464 12864 RPS48 24 設定1 16桁2行（照明付LCD） 接続端子

17、MIDI（REMOTE KBD IN,IN,OUT） L(MONO)：標準 R：標準 （INST/LOWER(MONO)：標準 VOCAL/UPPER：標準 ：標準 ：標準 規定入力 INST/LOWER(MONO)：-30dBm+4dBm VOCAL/UPPER：-30dBm+4dBm ：-60dBm-20dBm 入力 INST/LOWER(MONO)：24k VOCAL/UPPER：24k ：5k 出力 L(MONO)：2.2k R：2.2k ：100 電源 AC100V（5060Hz） 消費電力 17W 外形寸法 482（幅）88（奥行）264（高）mm 重量 4.5Kg (電源除) 付

18、属品 取扱説明書日本語：# 71017512 英語：# 71122323 電源 100V用：# 00894367 保証書(持込修理用）：# 40232334 別売品 MIDI/SYNC：MSC-15/25/50 ：PJ-1M ：RH-20/80/120 ：DR-10/20 ：S2M-5(2M) S4M-5(4M) 製品仕様外観、改良予告変更。 JP-8080 Jul, 1998 RadioFans.CN 收音机爱 好者资料库 右左右左 右左右左 Jul, 1998JP-8080 3 LOCATION OF CONTROLS配置図 PARTS No.PART No.PART NAMEQty. q

19、32490595P S-KEY MX BLK1 01453245PUSH SWITCH SDDLB1-B2-D-2 TV-51 w01343101D C-ESCT BX1H BLK1 01458756D C-ESCT HOLDER1 01341178CARD CONECTR CN015S-3013-01 e00231401U R-KNOB MF270 BLK/LCG10 015606019M/M ROTARY POT. EVU JFY FL1 B2410 (Serial No. earlier than Z*3399Z*3399以前) 016729459M/M ROTARY POT. EVU

20、JDE FL1 B2410 (Serial No. Z*3400 or laterZ*3400以降) r00231401U R-KNOB MF270 BLK/LCG17 015605909M/M ROTARY POT. EVU JFU FL1 B2417 t00231401U R-KNOB MF270 BLK/LCG2 015610459M/M ROTARY POT. EVU F2K FL1 A532 y00231401U R-KNOB MF270 BLK/LCG1 0167486712M/M ROTARY POT. EVJ Y15 F02 A241 u01561578J S-KNOB S B

21、LK/LCG2 0156705630M/M SLIDE POT. RS30111Z9 CLICK2 i01561578J S-KNOB S BLK/LCG12 0156707830M/M SLIDE POT. RS30111Z9 NON-CLICK12 o00900189D S-KEYTOP SX1H BLK10 01340290PTR TACT SWITCH EVQ11A H=5.010 !001129767D S-KEYTOP SX1H DRD1 01340290PTR TACT SWITCH EVQ11A H=5.01 !100900190D S-KEYTOP SX2H BLK3 013

22、40290PTR TACT SWITCH EVQ11A H=5.06 !200900145D S-KEYTOP SD1H BLK8 01340290PTR TACT SWITCH EVQ11A H=5.08 00348490PTR LED SLR-325VCT318 !300900145D S-KEYTOP SD1H BLK 01340290PTR TACT SWITCH EVQ11A H=5.01 15029342LED GL3ED81 !401013023D S-KEYTOP SD1H DRD1 01340290PTR TACT SWITCH EVQ11A H=5.01 00348490P

23、TR LED SLR-325VCT311 ! 5 01016867D S-KEYTOP SD1H LCG1 01340290PTR TACT SWITCH EVQ11A H=5.01 00348490PTR LED SLR-325VCT311 !601016867D S-KEYTOP SD1H LCG1 01340290PTR TACT SWITCH EVQ11A H=5.01 15029342LED GL3ED81 !701125890D S-KEYTOP SD1H-A CLR4 01232201TACT SWITCH SKHJGS WITH LED4 !800900156D S-KEYTO

24、P SD2H BLK4 01340290PTR TACT SWITCH EVQ11A H=5.08 00348490PTR LED SLR-325VCT318 !900900156D S-KEYTOP SD2H BLK1 01340290PTR TACT SWITCH EVQ11A H=5.02 15029342LED GL3ED82 001568356D S-KEYTOP MD4H LCG4 01340290PTR TACT SWITCH EVQ11A H=5.016 00348490PTR LED SLR-325VCT3116 100899023PTR LED LNJ282RKRXE37

25、201343090LED SPACER11 315029342LED GL3ED82 01455901LED SPACER LH-36-92 401230678VK-7 DISPLAY COVER1 00127378LCD RCM7044U-1A1 522150756JACK NUT 21 015610346.5MM JACK YKB21-52771 622150756JACK NUT 21 011291456.5MM JACK YKB21-52681 7134492836.5MM JACK HLJ7101-01-30104 813429274DIN YKF51-50411 901347623

26、AC INLET NC-176-1.01 RadioFans.CN 收音机爱 好者资料库 右左右左 右左右左 4 EXPLODED VIEW分解図 Jul, 1998 PARTS No.PART No.PART NAME q01458778 RACK ANGLE w01458712 BOTTOM COVER e12359139 FOOT FF-018 BLK r01458723 JACK HOLDER t01458701 TOP PANEL y01458734 PWR SPLY HOLDER u01561056 INSULATING SHEET i40016589 NYLON RIVET NR

27、P-335 o01458745 PWB HOLDER !032490595 P S-KEY MX BLK !100127378 LCD RCM7044U-1A !201451678 SWTNG REG KW1AA265 !301347623 AC INLET NC-176-1.0 !471017534 MAIN BOARD ASSY ! 5 71017556 PANEL BOARD ASSY !671017578 SW BOARD ASSY !771017589 MIC BOARD ASSY !871017590 PHONES BOARD ASSY !971017567 CARD BOARD

28、ASSY NOTE:Replacement CARD BOARD ASSY does not include Escutcheon and Holder. 注意 :補修用CARD BOARD ASSY、等含。 001232978 WIRING GND 101568190 WIRING W1 201568201 WIRING W2 301568212 WIRING W3 401452890 FUJI CARD 14X150-A6.0BBR-P1.25-HBL10 501568256 FUJI CARD 25X240-A6.0BBR-P1.25-HBL10 601568267 FUJI CARD

29、35X220-A6.0BBR-P1.25-HBL10 701568512 RIBON CABL 3X70-P2.0 801568534 RIBON CABL 4X90-P2.0 900789856 RIBON CABL 5X200-P2.0 #001568245 RIBON CABL 7X120-P2.0 #140016512 INSULOK TIE 80M/M T-18S SCREW 40011056 BINDING TAPTIGHT B 3*6 ZC (x19) 40011067 BINDING TAPTIGHT B 3*8 ZC (x12) 40011090 BINDING TAPTIG

30、HT B 3*6 BZC (x16) 40011123 BINDING TAPTIGHT B 4*8 BZC (x6) e 40011278 BINDING TAPTIGHT P 3*8 ZC (x2) 40011312 BINDING TAPTIGHT P 3*8 BZC (x4) 40011501 SEMS 3*8 BZC (x2) 40013056 DOUBLE SEMS(SMALL WASHER) 3*6 ZC (x4) i40011745 NUT WITH SPRING WASHER M4 ZC (x1) 22150756 JACK NUT 2 (x2) JP-8080 修理作業上注

31、意事項 図中1WIRING W1 (#01568190) 2形状全同一。接続 際、線材色、接続先十分注意、下記通正接続。 白色茶色側 SWITCHING REGULATOR KW1AA265 黒色茶色側 SW BOARD 接続 安全規格上、必上記配線必要。 CAUTIONS IN REPAIRING As shown in the diagram, the shape of the two connecters of WIRING 1(#01568190) No.1 are same. When you repairing, be careful of the combinations of

32、connection.(refer to the following) Connecter with WHITE/BROWN wirings- SWITCHING REGULATOR KW1AA265 Connecter with BLACK/BROWN wirings- SWITCH BOARD This is a ncessity for safety standard. 00231878TC74VHC00FQUAD NAND GATEIC30 on MB 00567534TC74VHC138F3-TO-8 LINE DECODERIC16 on MB 00670290TC74VHC139

33、FDUAL 2-TO-4 LINE DECODERIC5 on MB 15289106M5238AFP-600COpAmpIC14 on MB 15189261M5218AFP-600EOpAmpIC54,56 on MB 15289105UPC4570G2-T2OpAmpIC37,43,44,46,50,51,53,55 on MB 15219157M5241L-600YVCAIC48 on MB 00344390TA7805F+5V RegulatorIC35 on MB 15289123M51953AFP-600CReset ICIC2,52,67 on MB 15289125PC-41

34、0TPhoto CouplerIC45,47 on MB 15169596TC74HC4051AP8CH ANALOG MULTIPLEXERIC2,4,6,8,10 on PB 15169542TC74HC273APOCTAL D FLIP-FLOPIC7 on PB 15169550T0TC74HC138AP3-TO-8 LINE DECODERIC3,13 on PB 15189189UPC4570HAOpAmpIC1,5,9 on PB 15189186UPC4570COpAmpIC601 on VB TRANSISTOR 011212782SA1576AQ3,5,11,14-16 o

35、n MB 153191052SC3326AQ26-31 on MB 011212892SC4081Q1,6,8,10,12,13 on MB 153291042SK368GRFETQ7,9 on MB 15329507DTA114EKQ2 on MB 15329533RN2307Q17,23 on MB 15329516DTC114EKQ4 on MB 15329521RN1307Q18 on MB 151291512SC1815-GRQ7-14 on PB 15119170RN2226Q1-6,15-22 on PB DIODE 15339105DAN202KDA13,14,20,22-37

36、 on MB 01121323DA204UDA1-8,11,12,21 on MB 150191261SS133D1-59,64-69,71,86-89,147-152,155-161 on PB LED発行 00348490SLR-325VCT31D80-83,90,113,117,126,127,146,153,154 on PB 00899023LNJ282RKRXED72-79,114-116,118-125,128-145 on PB 15029342LED GL3ED8D60-63,84,85 on PB RESISTOR抵抗 15399952MCR50JZH4701/2WR221

37、,222,228,229 on MB #01561412MCR50-J2221/2WR166 on MB RESISTOR ARRAY抵抗 15399965RCE9A103JAG7ARA11,15,27 on MB 00126112EXBV8V101JVRA1-3,8,10,12-14,16 on MB 00909801EXBV8V220JVRA4-7,9,18,20,21,23,25,26 on MB 13919140RGLD8X103JRA1 on PB POTENTIOMETER #01560590EVU JFU FL1 B249mm Rotary VRVR1-6,9,10,12-15,

38、20,21,25,35,41 on PB #01560601EVU JFY FL1 B249mm Rotary VR with clickVR7,8,11,16,17,22-24,26,40 on PB (Serial No. earlier than Z*3399Z*3399以前) #01672945EVU JDE FL1 B249mm Rotary VR with clickVR7,8,11,16,17,22-24,26,40 on PB (Serial No. Z*3400 or laterZ*3400以降) #01561045EVU F2K FL1 A539mm Rotary VRVR

39、43,44 on PB #01567056RS30111Z9 WITH CLICK30mm Slide VR with clickVR32,33 on PB #01567078RS30111Z9 NON-CLICK30mm Slide VRVR18,19,27-31,34,36-39 on PB #01674867EVJ Y15 F02 A2412mm Rotary VR.DualVR601 on VB CAPACITOR 15369151S016CV100BSC47 on MB #0145584516CV22NPC259,C269,C276 on MB 15369145S016CV47BSC

40、57,C283,C309,C323 on MB 15369163S025CV10BSC293 on MB 0134026725CV100BSC278-282 on MB 15169210S050CV1BSC267,C272 on MB 15369212S050CV2R2BSC252,C325 on MB #15169214S050CV4R7BSC284 on MB 15369105S06.3CV100BSC265 on MB 15369152ECEV1CA100SRC3,18,23,49,51,70,176,207,210-214,218,242,245,247- 249,251,258,26

41、0,268,270,274,286,287,295,296,336 on MB #13529509DD106-999F103Z50C4,13,24,36,50,52 on PB 13529132RPE132-901F104Z50C1-3,5-12,14-23,25-30,32-35,38,40,46-49,51,53-62,65-69 on PB #13639674S06.3MV100SWB+T7mm HeightC39 on PB #13649158ECEA1HKA100B7mm HeightC31,37,41-45,71,74 on PB,C601-604 on VB #13519634M

42、0ECKR1H102KB5C501,502 on PHB INDUCTOR,COIL,FILTER、 01455623N2012Z102T01L3-10,12,14,15,17 on MB 00903167N2012Z601T02L1 on MB 12449355FBR07HA850TB00Ferrite BeadL1-4 on PB,L401 on MIB,L501,502 on PHB CRYSTAL水晶発振器 00894034MA-406 16.000MHzfor CPUX1 on MB #01453167SG-8002DC 67.7376MHzfor ESPX2 on MB CONNE

43、CTOR 13379151FFC ConnectorIL-FPC-14ST-NCN1 on MB 1336993453253-1210CN10 on MB 13369592B7B-XH-ACN4 on MB 00453467IL-FPC-25ST-NCN5 on MB,CN201 on CB 0078099052045-3510CN11 on MB 1336960052147-0510CN3 on MB 1336960252147-0710CN6 on MB 1342929251048-0300CN4 on PB 1342929451048-0500CN2 on PB 134292965104

44、8-0700CN3 on PB 01341178Card ConnectorCN015S-3013-0CN202 on CB 13369898B2P3-VH 7A/250VCN301 on SB 1336959852147-0310CN401 on MIB 1342929351048-0400CN501 on PHB,CN602 on VB WIRING,CABLE、 01232978WIRING GND #01568190WIRING W1SB CN301-SW REG CN1-AC INLET #01568201WIRING W2MB CN4-SW REG CN2 #01452890FUJ

45、I CARD14X150-A6.0BBR-P1.25-HBL10MB CN1-LCD unit #01568256FUJI CARD25X240-A6.0BBR-P1.25-HBL10MB CN5-CB CN201 #01568267FUJI CARD35X220-A6.0BBR-P1.25-HBL10MB CN11-PB CN1 #00789856RIBON CABLE5X200-P2.0PB CN2-MB CN3 右左右左 右左右左 5 NOTE:The parts marked # are new (initial parts) 注意:#付部品新規部品。 CASING #01458701

46、TOP PANEL #01458712BOTTOM COVER 01230678DISPLAY COVER #01458723JACK HOLDER 12359139FOOTFF-018 BLK #01458778RACK ANGLE CHASSIS #01458734POWER SUPPLY HOLDER #01561056INSULATING SHEET 40016589NYLON RIVETNRP-335 #01458745PWB HOLDER #01458756D C-ESCT HOLDER KNOB,BUTTON、 32490595P S-KEY MX BLKfor Power Sw

47、itch 00231401U R-KNOB MF270 BLK/LCGfor Rotary VR #01561578J S-KNOB S BLK/LCGfor Slide VR 01013023D S-KEYTOP SD1H DRDSmall,with Lens 01125890D S-KEYTOP SD1H-A CLRSmall,with Lens.Clear #01568356D S-KEYTOP MD4H LCGMedium,with Lens.quadruple 01016867D S-KEYTOP SD1H LCGSmall,with Lens 00900190D S-KEYTOP

48、SX2H BLKSmall,Double 01129767D S-KEYTOP SX1H DRDSmall 00900189D S-KEYTOP SX1H BLKSmall 00900156D S-KEYTOP SD2H BLKSmall,with Lens.Double 00900145D S-KEYTOP SD1H BLKSmall,with Lens SWITCH 01340290TACT SWEVQ11A H=5.0SW1-3,6-32,35-59 on PB 01232201TACT SW with Orange LEDSKHJGSSW4,5,33,34 on PB 01453245

49、Power SWSDDLB1-B2-D-2 TV-5SW301 on SB JACK,SOCKET、 13429274YKF51-5041MIDI JACKJK1 on MB(MIDI) 13449283HLJ7101-01-30101/4 inch Phone Type JackJK2,3,5,6 on MB(INPUT,OUTPUT) #01561034YKB21-52771/4 inch Phone Type JackJK401 on MIB(MIC) 01129145YKB21-5268Stereo 1/4 inch Phone Type JackJK501 on PHB(PHONES) DISPLAY UNIT表示 00127378LCD UNITRCM7044U-1A POWER SUPPLY UNIT電源 01451678Switching RegulatorKW1AA265 PCB ASSY基板完成品 #71017534MAIN BOARD ASSY #71017556PANEL BOARD ASSY #71017578SW BOARD ASSY #71017589MIC BOARD ASSY #71017590