Roland RD-700sx Service Manual 电路图.pdf

《Roland RD-700sx Service Manual 电路图.pdf》由会员分享，可在线阅读，更多相关《Roland RD-700sx Service Manual 电路图.pdf（44页珍藏版）》请在收音机爱好者资料库上搜索。

1、SERVICE NOTES Issued by RJA Copyright 2005 ROLAND CORPORATION All rights reserved. No part of this publication may be reproduced in any form without the written permission of ROLAND CORPORATION. Printed in Japan (0500) (NB)17058307E0 Jan. 2005RD-700SX CONTENTS CAUTIONARY NOTES .2 SPECIFICATIONS.2 LO

2、CATION OF CONTROLS .3 LOCATION OF CONTROLS PARTS LIST.3 EXPLODED VIEW 1.4 EXPLODED VIEW PARTS LIST 1.5 EXPLODED VIEW 2.6 EXPLODED VIEW PARTS LIST 2.7 EXPLODED VIEW 3.8 EXPLODED VIEW PARTS LIST 3.9 KEYBOARD PARTS LIST.10 WIRING DIAGRAM.12 WIRING DIAGRAM PARTS LIST.13 PARTS LIST.14 CHECKING THE VERSIO

3、N NUMBER.20 USERS DATA SAVE AND LOAD.20 FACTORY RESET INSTRUCTIONS.21 SYSTEM SOFTWARE UPDATING INSTRUCTIONS .22 TEST MODE.22 Instructions for Arranging the Cables.25 BLOCK DIAGRAM.30 CIRCUIT BOARD(MAIN BOARD).31 CIRCUIT DIAGRAM(MAIN BOARD 1/6).32 CIRCUIT DIAGRAM(MAIN BOARD 2/6).34 CIRCUIT DIAGRAM(MA

4、IN BOARD 3/6).36 CIRCUIT DIAGRAM(MAIN BOARD 4/6).38 CIRCUIT DIAGRAM (MAIN BOARD 6/6).39 CIRCUIT DIAGRAM(MAIN BOARD 5/6).40 CIRCUIT BOARD(PANEL R/PANEL L/JACK/INLET BOARD) .42 CIRCUIT DIAGRAM(PANEL R BOARD) .44 CIRCUIT DIAGRAM(PANEL L BOARD).46 CIRCUIT DIAGRAM(JACK BOARD).48 CIRCUIT BOARD(SRX BASE BO

5、ARD/LCD BOARD) .50 CIRCUIT DIAGRAM(SRX BASE BOARD) .52 CIRCUIT DIAGRAM(INLET BOARD).54 CIRCUIT DIAGRAM(LCD BOARD) .55 ERROR MESSAGES.56 CHANGE INFORMATION.56 RadioFans.CN 收音机爱 好者资料库 2 Jan. 2005RD-700SX CAUTIONARY NOTES User data status User data status after each of the following processes is descri

6、bed below. Whenever carrying out procedures that involve deleting or erasing user data, always be sure to back up the user data to some form of external media (refer to Saving and Loading Data). *Executing Test Mode during Factory Reset deletes the user data. PARTS LIST Due to one or more of the fol

7、lowing reasons, parts with parts code * cannot be supplied as service parts. Part supplied only as a component in a complete assembly Copyright does not permit the part to be supplied Part is sold commercially CIRCUIT BOARD NIU meant that “NOT IN USE “ there dont set any contents in the Circuit Diag

8、ram. There has silk-screen only in the Circuit Board. SPECIFICATIONS Main Specifications RD-700SX: Digital Piano (Conforms to General MIDI 2 System) Keyboard 88 keys (Progressive Hammer Action Keyboard) Part 16 Parts Maximum Polyphony 128 voices Wave Memory 128 M bytes (16-bit linear equivalent) Exp

9、ansion Slots Wave Expansion Board SRX Series: 2 slots Tones Normal Tones: 208 Tonewheel Organ: 10 General MIDI 2 Tones: 256 Rhythm Sets: 5 General MIDI 2 Rhythm Sets: 9 Setups 100 Effects Multi-Effects: 2 systems, 125 types Reverb: 6 types Chorus: 3 types Sound Control (3-band Compressor) 3-band Dig

10、ital Equalizer Arpeggiator 128 styles Rhythm Pattern 185 styles Flash Memory Approx. 1 M Bytes (1000 K bytes) Controllers Zone Level slider x 4 (Assignable) Equalizer knobs Reverb knob Chorus knob Multi-Effects Control knob Pitch Bend/Modulation lever Display 128 x 64 dots graphic LCD (with backlit)

11、 Connectors Headphones Jack: Stereo 1/4 inch phone type Output Jacks (L/MONO, R): 1/4 inch phone type Output Jacks (L, R): XLR type Pedal Jacks (DAMPER, FC1, FC2): 1/4 inch TRS phone type MIDI Connectors (IN, OUT1, OUT2, THRU) USB Connector (supports file transfer and MIDI) AC Inlet Power Supply AC

12、117 V, AC 230 V or AC 240 V (50/60 Hz) AC 220 V (60 Hz) Power Consumption 12 W Dimensions 1,414 (W) x 374 (D) x 143 (H) mm 55-11/16 (W) x 14-3/4 (D) x 5-11/16 (H) inches Weight 24.5 kg / 54 lbs 1 oz Accessories Owners Manual (#72896567) CD-ROM (RD USB Driver) (#03788701) Damper Pedal (DP-8) (#SK0001

13、33) Power Cord120 V (#00894378) 230 V (#00894389) 240VE (#00907001) 240VA (#23495124) Options Wave Expansion Board: SRX Series Pedal Switch: DP-2 Damper Pedal: DP-8, DP-10 Foot Switch: BOSS FS-5U, FS-6 (TRS phone jacks cannot be used.) Expression Pedal: EV-5, EV-7 *In the interest of product improve

14、ment, the specifications and/or appearance of this unit are subject to change without prior notice. ProcessUser Data Checking Version number Preserved Factory Reset Deleted System Update Preserved Test Mode Preserved RadioFans.CN 收音机爱 好者资料库 3 Jan. 2005RD-700SX LOCATION OF CONTROLS fig.03-top-rear.ep

15、s LOCATION OF CONTROLS PARTS LIST 171819 20212223242526 1213 44 33 14 5166743 89103 11 12 13 14 1514 NOPART CODECATEGORYPART NAMEDESCRIPTION 101125890KNOB,BUTTOND S-KEYTOPSD1H-A CLR 01232201SWITCHTACT SWITCH WITH LEDSKHJGS (ORANGE) 201125890KNOB,BUTTOND S-KEYTOPSD1H-A CLR 01232212SWITCHTACT SWITCH W

16、ITH LEDSKHJGR (GREEN) 302011412KNOB,BUTTONY S-KEYTOPSD1H BLK 01340290SWITCHTACT SWITCHEVQ11A H=5.0 00348490DIODELED (RED)SLR-325VCT31 402011456KNOB,BUTTONY S-KEYTOPSX1H BLK 01340290SWITCHTACT SWITCHEVQ11A H=5.0 501234090KNOB,BUTTOND T-KEYTOPMX4B BLK 01340290SWITCHTACT SWITCHEVQ11A H=5.0 603785534KNO

17、B,BUTTONY S-KEYTOPSX1H MWG 01340290SWITCHTACT SWITCHEVQ11A H=5.0 702011412KNOB,BUTTONY S-KEYTOPSD1H BLK 01340290SWITCHTACT SWITCHEVQ11A H=5.0 01787045DIODELED (ORANGE)SLR-325DCT31 802016445KNOB,BUTTONY S-KEYTOPLD1H BLK 13169727SWITCHTACT SWITCHSKPDACD010 01121689DIODELED (RED/GREEN)SPR-325MVWT31 922

18、485295KNOB,BUTTOND S-KNOBS BLK/LCG 22225373CASINGSVR COVERD S-ESCT SX1H BLK L=30 222-373 01236834CASINGPOT. DUST COVER A 00671556POTENTIOMETER30M/M SLIDE POTENTIOMETEREWANNKX10B14(10KBX2) 1022485295KNOB,BUTTOND S-KNOBS BLK/LCG 22225371CASINGESCUTCHEON 2PD S-ESCT SX2H BLK L=30 01236834CASINGPOT. DUST

19、 COVER A 13339467POTENTIOMETERPOTENTIOMETER(SLIDE)EWA-NFEX10B14 10KB 1103125589KNOB,BUTTONM R-KNOBMF-ELA BLK/LCG 01561689POTENTIOMETER9M/M ROTARY POTENTIOMETERRK09D113C 50KB W/CLICK 1203125589KNOB,BUTTONM R-KNOBMF-ELA BLK/LCG 01561690POTENTIOMETER9M/M ROTARY POTENTIOMETERRK09D113C 50KB W/O CLICK 130

20、3126189POTENTIOMETER9M/M ROTARY POTENTIOMETEREVUF2AE17B14 1400785856DIODELEDSLR-342VR3F 12169381MISCELLANEOUSLED SPACERLDS-90K 1502015623DIODELEDSLR-342MG3F 12169381MISCELLANEOUSLED SPACERLDS-90K 1603679056CASINGDISPLAY COVER 1701786045CHASSISSW HOLDERAT-217K 01786012SWITCHSEESAW SWITCHJW-M11RKK 180

21、2675701WIRING, CABLEAC INLET ASSYWIRING W3(AC INLET+GND) 1903679089CASINGEXP COVER 2002781189JACK,EXT TERMINALUSB CONNECTORYKF45-0021 2113449252JACK,EXT TERMINAL6.5MM JACKYKB21-5006 (STEREO W/SW) 2201566445JACK,EXT TERMINALDIN CONNECTORYKF51-5067 2313429274JACK,EXT TERMINALMIDI SOCKETYKF51-5041 2413

22、449283JACK,EXT TERMINAL6.5MM JACKHLJ7101-01-3010 2500679767JACK,EXT TERMINALXLR CONNECTORNC3MAH 26 13449284JACK,EXT TERMINAL6.5MM JACKHLJ7001-01-3010 RadioFans.CN 收音机爱 好者资料库 4 Jan. 2005RD-700SX EXPLODED VIEW 1 fig.05-01expld-view01-e.eps_75 View 3 Refer to fig A 3 5 4 10 B 6 7 8 14 16 1 21 22 2 18 1

23、9 17 20 13 15 11 12 9 View 1 View 2 BOTTOM 5 Jan. 2005RD-700SX EXPLODED VIEW PARTS LIST 1 Parts NO.PART CODEPART NAMEDESCRIPTIONQTY 122225373SVR COVERD S-ESCT SX1H BLK L=30 222-3731 222225371ESCUTCHEON 2PD S-ESCT SX2H BLK L=302 372789445PANEL L BOARD ASSY1 472789456PANEL R BOARD ASSY1 503679056DISPL

24、AY COVER1 672896623LCD ASSY1 703679034LCD HOLDER1 872789512LCD BOARD ASSY1 903679078BENDER PANEL1 1003679067END BLOCK1 1100128089END BLOCK HOLDER1 1272899889BENDER UNITPB-A01151 1302564878SIDE HOLDER L1 1402564889SIDE HOLDER R1 1503679101SIDE PANEL L1 1603679112SIDE PANEL R1 1771677345KEYBOARD ASSYP

25、A-588-ST FOR SERVICE1 NOTE: See KEYBOARD PARTS LIST for details. 1872891212BOTTOM BOARD1 1912359105RUBBER FOOT WRS-09 235-1054 2002672678FLAT CABLE CLIPNKF-32641 2101236834POT. DUST COVER A1/5 2201236834POT. DUST COVER A4/5 6 Jan. 2005RD-700SX EXPLODED VIEW 2 fig.05-02expld-view02-e.eps_75 Fig A Rea

26、r View 4 ABC E FGF O HF D A11 A12 A7 A8 A9 A6 A5 A4 A3 A2 A1 A10 Rear View 4 7 Jan. 2005RD-700SX EXPLODED VIEW PARTS LIST 2 Fig A View 4 Rear NO.PART CODEPART NAMEDESCRIPTIONQTY A172789467JACK BOARD ASSY1 A272789501SRX BASE BOARD ASSY1 A372789489MAIN BOARD ASSY1 A403782334SWITCHING REGULATORA1DU2L3B

27、1841 A572789478INLET BOARD ASSY1 A601786012SEESAW SWITCHJW-M11RKK1 A772900189TOP PANEL ASSY1 NOTE: TOP PANEL ASSY includes the following parts. A1203679178EXP BOARD HOLDER A801786045SW HOLDERAT-217K1 A903679089EXP COVER1 A1000341778KEY FELT1 A1102672678FLAT CABLE CLIPNKF-32641 NOPART CODECATEGORYPAR

28、T NAMEQTY A40011067SCREW 3X8BINDING TAPTITE B FE ZC4 B40013056SCREW M3X6PAN MACHINE W/SW+PW(S) ZC6 C40017934SCREW M3X6PAN MACHINE W/SW+PW(L) ZC4 D40011745HEX NUT M4SPRING NUT FE ZC1 NOPART CODECATEGORYPART NAMEQTY E40010334SCREW 4X8BINDING BZC1 F40011501SCREW M3X8PAN MACHINE W/SW BZC3 G40238501SCREW

29、 4X8BINDING TAPTITE P BZC2 H40011312SCREW 3X8BINDING TAPTITE P BZC7 O40230590SCREW M3X10BINDING MACHINE NI2 8 Jan. 2005RD-700SX EXPLODED VIEW 3 fig.05-03expld-view03-e.eps_75 A N GG N LL M L J K J A A H AA IJ View 1 BOTTOM View 2 View 3 X15 9 Jan. 2005RD-700SX EXPLODED VIEW PARTS LIST 3 View 1 View

30、2 BOTTOM View 3 NOPART CODECATEGORYPART NAMEQTY A40011067SCREW 3X8BINDING TAPTITE B FE ZC39 (*40) H40011312SCREW 3X8BINDING TAPTITE P BZC5 NOPART CODECATEGORYPART NAMEQTY I40346201SCREW 4X20TRUSS TAPPING TWIN BZC15 J40013023SCREW M4X25PAN MACHINE W/SW+PW FE BZC2 K40012145SCREW 4X14TRUSS TAPPING A BZ

31、C2 NOPART CODECATEGORYPART NAMEQTY J40013023SCREW M4X25PAN MACHINE W/SW+PW FE BZC11 L40013023SCREW M4X25PAN MACHINE W/SW+PW FE BZC13 M40010745SCREW 3X16BINDING HEAD TAPPING A1 FEZC4 NOPART CODECATEGORYPART NAMEQTY G40238501SCREW 4X8BINDING TAPTITE P BZC16 N40012301SCREW 4X8BINDING TAPTITE B FE ZC4 1

32、0 Jan. 2005RD-700SX KEYBOARD PARTS LIST fig.keyboard-e.eps PART NAME PA-5 N-KEY A PA-5 N-KEY B PA-5 N-KEY C PA-5 N-KEY D PA-5 N-KEY E PA-5 N-KEY F PA-5 N-KEY G PA-5 N-KEY A PA-5 N-KEY C PA-5 SHARP-KEY PA-5 HAMMER-1 PA-5 HAMMER-2 PA-5 HAMMER-3 PA-5 HAMMER-4 PA-5 CHASSIS 88P-A ASSY PA-5 CHASSIS 88P PA

33、-5 SUB CHASSIS 12P PA-5 SUB CHASSIS 4P PA-4A GUIDE BUSHING C PA-4 GUIDE BUSHING S-KEY PA-5 KEY CUSHION A PA-5 HAMMER CUSHION C PA-5 HAMMER CUSHION B SCREW 3 x 10 BINDING B-TITE FEZC PA-5 PWB LOW ASSY PA-5 PWB MID ASSY PA-5 PWB HI ASSY PA-5 RUBBER SWITCH 12P SCREW 3 x 6 BINDING TAPTITE P FEZC BNCD-P=

34、1.25-K-16-80 PART CODE 01894234 01894245 01894256 01894267 01894278 01894289 01894290 01894312 01894323 01894334 01906756 01906767 01906778 01906789 * * 01894434 01894445 01894923 00019912 02016901 02233878 02016945 40012256 71564612 71564623 71564634 01898956 40011267 02016989 No. 1 2 3 4 5 6 7 8 9

35、 10 11 12 *13 14 15 Qty. 7 8 7 7 7 7 7 1 1 36 22 22 22 22 1 1 7 1 52 36 3 1 1 37 1 1 1 8 22 1 PART NAME BNCD-P=1.25-K-16-700 BNCD-P=1.25-K-22-650 PART CODE 02565078 02565089 No.Qty. 1 1 71677345 ST-SERVICE ASSY PARTS LIST 12 345 67 89 1011 12131415 : Item 13 marked * is included in each unit of 12.

36、2pcs of Ban Card for conneeting the Main Board and Keyboard is not included the keyboard Assy. 12 Jan. 2005RD-700SX WIRING DIAGRAM fig.07-wiring-dia.eps 12FMN-BMT-A-TF B3B-PH-K-S CN1 PANEL L BOARD CN3 B6B-PH-K-S CN6 18FMN-BMT-A-TF CN102 CN17 25FMN-BTK-A22FE-ST-VK-N VOLUME SEND/RETURN BENDER 32FMN-BM

37、T-A-TF VOLUME SEND/RETURN 12FMN-BTK-A PANEL A/D CN2 CN104 MIDI/PEDALPOWER 22FE-ST-VK-N CN3 SRX LCD CONTRAST 22FE-ST-VK-N 16FMN-BTK-A SW/LEDSCAN B6B-PH-SM3-TB CN6 S3B-PH-K-S CN2 SRX JACK BOARD CN5 B7B-XH-A CN7 16FMN-BTK-A CN101 SWITCH/LED SCAN CN8 LCD 22FE-ST-VK-N B6B-PH-K-S AUDIO IN CN7 BENDER PANEL

38、 LR 52689-3093 SWITCHING REGULATOR CN11 B6B-PH-SM3-TB CN3 SRX BOARD SRX USB CN15 KEYBOARD 16FE-ST-VK-N CN2 32FMN-BMT-A-TF B3B-PH-K-S CN23 20FMN-BMT-A-TF BENDER UNIT:PB-A0115 BACK LIGHT CN5CN6 20FMN-BTK-A MAIN BOARD KEYBOARD UNIT includes WIRING (02016989 BAN CARD BNCD-P=1.25-K-16-80) MIDI/PEDALAUDIO

39、 OUT PANEL R BOARD LCD CN9 PANEL LR CN103 PANEL AD CN12 SRX CN21 B6B-PH-K-S LCD CONTRAST 32FMN-BMT-A-TF USB KEYBOARD SCAN 24FMN-BMT-A-TF CN1 CN4 32FMN-BMT-A-TF LCD BOARD INLET BOARD CN9 CN8 8 5 4 14 14 6 7 12 9 10 13 1716 3 11 2 1 15 18 13 Jan. 2005RD-700SX WIRING DIAGRAM PARTS LIST *INLET BOARD ASS

40、Y(72789478) includes the WIRING #1,#2,#15. *LCD ASSY(72896623) includes the WIRING #6, #18. NO.PART CODEPART NAMEDESCRIPTIONQTY 103787456WIRING W11 202564612WIRING INL-PS1 303787467WIRING W21 402343323WIRING6X550-P2.0-PHR-PHR-F1 503787534WIRING W31 6*WIRING W41 702341790WIRING3X400-P2.0-PHR-PHR-F1 8

41、03787490BAN CARDBNCD-P=1.00-K-16-3601 903234690BAN CARDBNCD-P=1.00-K-12-6501 1003237034BAN CARDBNCD-P=1.00-K-20-9001 1103787489BAN CARDBNCD-P=1.00-K-24-3801 1203565334BAN CARDBNCD-P=1.25-K-22-3001 1303780589BAN CARDBNCD-P=1.00-K-18-3201 1403787512BAN CARDBNCD-P=1.00-K-32-802 1502675701AC INLET ASSYW

42、IRING W3 (AC INLET+GND)1 1602565078BAN CARDBNCD-P=1.25-K-16-7001 1702565089BAN CARDBNCD-P=1.25-K-22-6501 18*LCD WIRING1 14 Jan. 2005RD-700SX PARTS LIST fig.part1e SAFETY PRECAUTIONS: The parts marked have safety-related characteristics. Use only listed parts for replacement. NOTE: The parts marked #

43、 are new. (initial parts) Due to one or more of the following reasons, parts with parts code * cannot be supplied as service parts. Part supplied only as a component in a complete assembly Copyright does not permit the part to be supplied Part is sold commercially The description QTY means a necessa

44、ry number of the parts per one product. CASING #03679045BLIND1 #03679056DISPLAY COVER1 #03679089EXP COVER1 01236834POT. DUST COVER A1 22225371ESCUTCHEON 2PD S-ESCT SX2H BLK L=302 22225373SVR COVERD S-ESCT SX1H BLK L=30 222-3731 #03679067END BLOCK1 #03679078BENDER PANEL1 #03679101SIDE PANEL L1 #03679112SIDE PANEL R1 #72891212BOTTOM BOARD1 NOTE: BOTTOM BOARD includes the following parts. # *BOTTOM BOARD1 12359105RUBBER FOOT WRS-09 235-1054 40010745SCREW 3X16BINDING HEAD TAPPING A1 FEZC4 40011712NUT M4X11.5WOOD ANCHOR B ZC2 40231845STRAIGHT PIN 6X20FOR WOOD2 72900189TOP P