《Roland R-09 MP3 Recorder Service Manual 电路图.pdf》由会员分享，可在线阅读，更多相关《Roland R-09 MP3 Recorder Service Manual 电路图.pdf（37页珍藏版）》请在收音机爱好者资料库上搜索。
1、SERVICE NOTES Issued by RJA Copyright 2006 ROLAND CORPORATION All rights reserved. No part of this publication may be reproduced in any form without the written permission of ROLAND CORPORATION. Printed in Japan (0400) (SC-KWS)17058420E0 Apr. 2006R-09 Table of Contents Specifications .2 Location of
2、Controls .4 Location of Controls Parts List.5 Exploded View.6 Exploded View Parts List.7 Disassembly Procedure.8 Parts List.10 Checking the Version Number.12 Factory Reset Instructions.12 System Software Updating Instructions.12 Test Mode.14 Block Diagram.22 Circuit Board (TOP BOARD 1/2) .24 Circuit
3、 Board (TOP BOARD 2/2) .25 Circuit Board (CENTER BOARD 1/2).26 Circuit Board (CENTER BOARD 2/2).27 Circuit Diagram (TOP BOARD 1/4) .28 Circuit Diagram (TOP BOARD 2/4) .30 Circuit Diagram (TOP BOARD 3/4) .32 Circuit Diagram (TOP BOARD 4/4) .34 Circuit Diagram (CENTER BOARD 1/2).36 Circuit Diagram (CE
4、NTER BOARD 2/2).38 Circuit Diagram (BOTTOM BOARD) .40 Messages.40 RadioFans.CN 收音机爱 好者资料库 2 Apr. 2006R-09 Specifications Recorder Part Tracks 2 (stereo) Signal Processing AD/DA conversion: 24 bits, 44.1/48 kHz Data Type * Stereo only FormatMP3 (MPEG-1 audio layer 3) Sampling Rate44.1/48 kHz Bit Rate
5、s64/96/128/160/192/224/320 kbps FormatWAV Sampling Rate44.1/48 kHz Bit Depth16/24 bits FormatMP3 (MPEG-1 audio layer 3) Sampling Rate32/44.1/48 kHz Bit Rates64/96/128/160/192/224/256/320 kbps or VBR (Variable Bit Rate) FormatWAV Sampling Rate32/44.1/48 kHz Bit Depth16/24 bits Memory Card SD Memory C
6、ard (supports 64 MB-2 GB) * Each recording time is approximate. The times may change depending on the card specifications. * In case that there are plural files, the sum of recording time would be shorter than above. Input/Output Audio Inputs Internal Stereo Microphone Mic input (Stereo miniature ph
7、one type, plug-in powered mic) Line input (Stereo miniature phone type) * The Internal/External MIC and the LINE IN cant be used at the same time; only the LINE IN is effective. Audio Outputs Phones (Stereo miniature phone type) Digital Out Connector (Optical miniature phone type) * Phones and Digit
8、al Out use a common jack. Nominal Input Level (Variable) Mic Input: -36dBu (Default input level) Line Input: 0dBu (Default input level) Input Impedance Mic input: 20 k ohms Line input: 17 k ohms Output Level 25 mW (In case 16 ohms load) Recommended Load Impedance 16 ohms or greater Frequency Respons
9、e 20 Hz-22 kHz USB Interface Mini-B type * support USB 2.0/1.1 mass storage device class Effects Playback Reverb 4 types (Hall 1, Hall 2, Room, Plate) Recording Time unit: minutes Settings64MB128MB512MB1GB2GB WAV (16 bits/44.1 kHz)5114488180 WAV (16 bits/48 kHz)5104081166 WAV (24 bits/44.1 kHz)37295
10、9120 WAV (24 bits/48 kHz)372754110 MP3 128 kbps621264909801,993 MP3 224 kbps35722805601,139 MP3 320 kbps2550196392797 RadioFans.CN 收音机爱 好者资料库 3 Apr. 2006R-09 Others Display 128 x 64 dot graphic display Power Supply AC Adaptor, Alkaline dry battery LR6 (AA) type x 2, or Nickel Hydrogen battery (HR15/
11、51) x 2 Current Draw 360 mA Dimensions 62.6 (W) x 102 (D) x 29.1 (H) mm 2-1/2 (W) x 4-1/16 (D) x 1-3/16 (H) inches Weight 145 g / 6 oz (including batteries and memory card.) Accessories Owners Manual English (#73233756) AC Adaptor (#03679478) AC Cord Set For 117V U/CS:120V 1.0M (NON POLAR) (#0256245
12、6) For 230V E/EU:230V 1.0M FOR PSB (#01903356) EURO CONVERTER PLUG ECP01-5A (#00905234) For 240V A:SC-078-NA05 240VA (#03785590) SD Memory Card (64 M bytes) (#04232278) USB cable (Mini-B type) (#03788289) * 0 dBu = 0.775 V rms * Expected AA alkaline life under continuous use: Continuous playback:app
13、roximately 5.5 hours Continuous recording:approximately 4 hours (These figures will vary depending on the actual conditions of use.) Options OP-R09C: Cover Stand Set for R-09 fig.OP-R09C_80 OP-R09M: Mic Stand Adaptor for R-09 fig.OP-R09M1_80 CB-R09S: Carrying Case for R-09 fig.CB-R09S_80 CS-15: Ster
14、eo Microphone fig.CS-15_80 RadioFans.CN 收音机爱 好者资料库 4 Apr. 2006R-09 Location of Controls fig.panel-front_85 1 2 4 8 12 13 5 67 9 10 11 14 15 16 2 17 24 20 21 22 19 23 25 3 18 23 5 Apr. 2006R-09 Location of Controls Parts List NoPART CODE PART NAME1DESCRIPTION1QTY 104230367KEYTOPPOWER1 204230445S-KEYT
15、OPSX2H PM1 304230512SIDE PANEL L1 404128501DC JACKHEC3600-0105101 504230467MIC COVER L1 604230456MIC COVER A2 704230478MIC COVER R1 804230389DISPLAY COVER1 904230567TOP PANEL1 1004230556TOP CASE1 11*LED (LED)TLSU1002A(TO2)1 * This part is included in #73129145 TOP BD ASSY. 1204230423C-KEYTOPSX3H1 13
16、04230434KEYTOPKEY CURSOR1 1404233190RUBBER SHEET1 * If the feel of button operations near is poor, replace this part. 1504230378KEYTOPREC1 16033480783.5MM JACK W/OPTICALGP1FD310TP0F1 1704233412S-KNOBBLK/RED1 1804230523SIDE PANEL R1 1904233245FOOT2 2004230545S-KNOBSLV4 2104230356BOTTOM PANEL1 2204230
17、334BOTTOM CASE1 2340344167SCREW 2X6BINDING P-TITE FE BZC3 24041293123.5MM JACKLGY2209-0101FC2 2573238667BATTERY CVR-TMNL PM ASSY1 6 Apr. 2006R-09 Exploded View fig.bunkai-e 26 18 30 17 29 28 7 1 10 13 11 12 131615 19 25 31 24 27 2 3 5 6 4 8 9 14 20 22 22 21 These are included in #19 CENTER BOARD ASS
18、Y. These are included in #19 CENTER BOARD ASSY. 7 Apr. 2006R-09 Exploded View Parts List NoPART CODEPART NAMEDESCRIPTION1QTY 104230567TOP PANEL1 204230389DISPLAY COVER1 304230556TOP CASE1 404230423C-KEYTOPSX3H1 504230434KEYTOPKEY CURSOR1 604233190RUBBER SHEET1 * If the feel of button operations near
19、 is poor, replace this part. 704230378KEYTOPREC1 1073129145TOP BD ASSY1 * This unit includes the following parts. 8 *DISPLAYLCD E-55028WHJ-AAN1 9 *DISPLAY HOLDER1 1104230512SIDE PANEL L1 1204230367KEYTOPPOWER1 1304230445S-KEYTOPSX2H PM2 1404230290BATTERY HOLDER1 1504233412S-KNOBBLK/RED1 1604230523SI
20、DE PANEL R1 1773238667BATTERY CVR-TMNL PM ASSY1 1804230501BATTERY COVER SHAFT1 1973233989CENTER BOARD ASSY1 2004230467MIC COVER L1 2104230478MIC COVER R1 2204230456MIC COVER A2 2473233990BOTTOM BOARD ASSY1 2504236501WIRING20624 SFWR-P=0.5-K1-6-50connects #24 Bottom BD to #19 Center BD1 2604230334BOT
21、TOM CASE1 2704233245FOOT2 2804230356BOTTOM PANEL1 2904230545S-KNOBSLV4 3040344167SCREW 2X6BINDING P-TITE FE BZC3 3104450878BOTTOM CUSHION1 * This part has been added from serial number “A*3000.” 8 Apr. 2006R-09 Disassembly Procedure Detaching the BOTTOM PANEL 1. The bottom panel is secured in place
22、with double-sided tape at the location shown by dotted lines in the figure. Peel off carefully in the direction of the arrow. * The bottom panel may deform or crack. In such cases, placing a part order for a bottom panel is required. fig.bottom-panel_85 Detaching the TOP CASE and BOTTOM CASE 2. Remo
23、ve the screws at the three locations shown in the figure. fig.top-case-screw_85 3. Place so that the top panel is at the top, then lift up the top case to remove. fig.top-case-remove_85 Detaching the TOP BOARD 4. Because this is secured in place by a circuit board to circuit board connector, grasp a
24、nd remove the top board without applying twisting force to the connector. fig.top-board-remove_85 Detaching the CENTER BOARD and BOTTOM BOARD 5. Turn upside-down, use tweezers or the like to flip up the lock tabs at the circled areas, then remove the BATTERY HOLDER while disengaging the locks. fig.b
25、attery-holder_85 9 Apr. 2006R-09 6. Flip up the tabs in the circled areas and remove the CENTER BOARD. fig.center-board-remove_85 7. For the BOTTOM BOARD as well, remove while flipping up the tabs holding the BOTTOM BOARD in place. fig.bottom-board-remove_85 10 Apr. 2006R-09 Parts List CASING #73238
26、667BATTERY CVR-TMNL PM ASSY1 #04230356BOTTOM PANEL1 #04230512SIDE PANEL L1 #04230523SIDE PANEL R1 #04230567TOP PANEL1 #04230501BATTERY COVER SHAFT1 #04230389DISPLAY COVER1 #04230456MIC COVER A2 #04230467MIC COVER L1 #04230478MIC COVER R1 #04230334BOTTOM CASE1 #04230556TOP CASE1 CHASSIS #04230290BATT
27、ERY HOLDER1 KNOB, BUTTON #04233412S-KNOBBLK/RED1 #04230545S-KNOBSLV4 #04230367KEYTOPPOWER1 #04230423C-KEYTOPSX3H1 #04230434KEYTOPKEY CURSOR1 #04230378KEYTOPREC1 #04230445S-KEYTOPSX2H PM2 JACK, EXT TERMINAL 04128501DC JACKHEC3600-010510on CENTER BOARD1 #041293123.5MM JACKLGY2209-0101FCon CENTER BOARD
28、2 033480783.5MM JACK W/OPTICALGP1FD310TPon CENTER BOARD1 PWB ASSY #73233990BOTTOM BOARD ASSY1 #73129145TOP BD ASSY1 #73233989CENTER BOARD ASSY1 * This unit includes the following parts. 04128501DC JACKHEC3600-0105101 # 041293123.5MM JACKLGY2209-0101FC2 033480783.5MM JACK W/OPTICALGP1FD310TP1 # 04233
29、189TERMINAL COVER1 # 04230301BATTERY TERMINAL M1 # 04230312BATTERY TERMINAL P1 WIRING, CABLE #04236501WIRING20624 SFWR-P=0.5-K1-6-50connects Bottom BD to Center BD1 SCREWS 40344167SCREW 2X6BINDING P-TITE FE BZC3 PACKING #04233901PACKING PADLOWER #04230278PACKING PADUPPER1 #04230267PACKING CASEJAPANE
30、SE1 #04233345PACKING CASEENGLISH1 MISCELLANEOUS #04233190RUBBER SHEET1 * If the feel of button operations near is poor, replace this part. #04233245FOOT2 #04233189TERMINAL COVERon CENTER BOARD1 #04230301BATTERY TERMINAL Mon CENTER BOARD1 #04230312BATTERY TERMINAL Pon CENTER BOARD1 #40674989DOUBLE FA
31、CED TAPE#500 W5MM X L30MM- #04450878BOTTOM CUSHION1 * This part has been added from serial number “A*3000.” 11 Apr. 2006R-09 ACCESSORIES (Standard) 03788289USB CABLEMINI-B U4A5B-100S 1.0M1 #04232278IC CARDRP-SD064BRL01 #73129090OWNERS MANUALJAPANESE1 40232334WARRANTY CARDMOCHIKOMI JAPAN ONLY1 #73233
32、756OWNERS MANUALENGLISH1 03679478AC ADAPTORPSB-6U (WITHOUT AC CORD)1 01903334AC CORD SET100V 1.0M FOR PSB-1UFor 100V1 02562456AC CORD SET120V 1.0M (NON POLAR)For 117V U, 117V CS1 01903356AC CORD SET230V 1.0M FOR PSBFor 230V E, 230V EU1 00905234EURO CONVERTER PLUGECP01-5AFor 230V E, 230V EU1 03785590
33、AC CORD SETSC-078-NA05 240VAFor 240V A1 12 Apr. 2006R-09 Checking the Version Number 1. Turn off the power to the R-09. 2. While holding down the button, turn on the power. 3. A screen like the one shown below appears, enabling you to verify the versions of the programs. fig.version_90 Program :Vers
34、ion of the main program Booter :Version of the bootup program Updater :Version of the updater program 4. Press the FINDER/MENU button to return to the MENU screen. Factory Reset Instructions Factory Reset restores to their factory defaults any parameter values changed via the setup menu, as well as
35、the input and output level setting values. 1. Turn on the power to the R-09. 2. Press the FINDER/MENU button for a while until the MENU screen appears. 3. Move the cursor to “ 8 Factory Reset ,” then press the REC button. The Factory Reset screen appears. fig.factory_90 4. Press the REC button to ex
36、ecute the Factory Reset, or press the FINDER/MENU button to cancel it. 5. “ Are you sure ? ” is displayed. Select “ Yes ” to execute or “ No ” not to execute, then press the REC button. fig.factory-sure_90 When the Factory Reset finishes, the Menu screen automatically returns. Note for User Data Par
37、ameter values set via the Menu screen and input and output level setting values are saved in memory when the power is switched off, but they cannot be saved in a file or extracted as user data. System Software Updating Instructions Copy the system-update files on the UPDATE CD-ROM to an SD card inse
38、rted into the R-09, then update the system. Items Required An SD card (blank) PC equiped with an USB connector The USB cable attached with R-09 AC adaptor UPDATE CD-ROM (#17041866) Creating an update SD card To create an update-use SD card, you first format the SD card. Formatting is performed on th
39、e R-09. 1. Turn on the power to the RC-09. 2. Press the FINDER/MENU button for a while until the MENU screen appears. 3. Move the cursor to “ 7 SD Card ,” then press the REC button. 4.Move the cursor to “2 Format,” then press the REC button. fig.sdmenu_90 5.“Are you sure ?” is displayed. Select “Yes
40、” to execute formatting. fig.sdformat_90 6.When formatting has finished, press the FINDER/MENU button several times to return to the basic screen. This completes formatting of the SD card. Next, copy the system-update file. 13 Apr. 2006R-09 7.Connect the PC to the R-09 with the USB cable. 8.Display
41、the SD card for the R-09 on the PCs screen, then copy the system- update file to the root directory of the SD card. Four types of system-update files are available. DMZ15.UPD:Update for all blocks DMZ15_BOT.UPD:Update for the Boot block DMZ15_UPD.UPD:Update for the Updater block DMZ15_PRG.UPD:Update
42、 for the Main Program block 9.When copying is finished, refer to the R-09 Owners Manual and follow the instructions in “Disconnecting the PC” (p. 59) to disconnect the R-09 from the PC. 10. Turn off the power to the R-09. System Update Procedure When performing a system update, be sure to use the AC
43、 adaptor. If this is attempted using battery power, a low battery during the procedure may cause the update to fail and cause the unit not to operate correctly. Never disconnect the AC adaptor while the update is in progress. Doing so may corrupt the system and cause the unit to fail to operate corr
44、ectly. 1.Turn off the power to the R-09. 2.Using the update-use SD card created according to the procedure described in the section of “Creating an update SD card,” insert the update-use SD card into the card slot in the R-09. 3.While holding down the REC button, turn on the power. When a valid update-use file is found on the SD card, the Program Update screen like the one shown below appears. * The screen that is displayed differs according to the type of update-use file. DMZ15.UPD (update for all blocks) fig.upd-all_90 DMZ15_BOT.UPD (update for the Boot block only) fig.upd-b
免费区 
