Aiwa-CADW540-cs-sm电路图 维修手册.pdf

《Aiwa-CADW540-cs-sm电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Aiwa-CADW540-cs-sm电路图 维修手册.pdf（43页珍藏版）》请在收音机爱好者资料库上搜索。

1、SERVICE MANUAL DATA COMPACT DISC CARRY COMPONENT SYSTEM CA-DW540 S/M Code No. 09-02B-456-4R3 LH(ST) BASIC TAPE MECHANISM: ZZM-2 PR3NC1 BASIC CD MECHANISM: KSM-213CDM REVISION This Service Manual is “Revision Publishing ” and replaces “Simple Manual (S/M Code No. 09-02C-456-4T3). RadioFans.CN 收音机爱 好者

2、资料库 -2- PROTECTION OF EYES FROM LASER BEAM DURING SERVICING VAROITUS! Laiteen Kyttminen muulla kuin tss kyttohjeessa mainitulla tavalla saattaa altistaa kyt-tjn turvallisuusluokan 1 ylittvlle nkymttmlle lasersteilylle. VARNING! Om apparaten anvnds p annat stt n vad som specificeras i denna bruksanvi

3、sing, kan anvndaren utsttas fr osynling laserstrlning, som verskrider grnsen fr laserklass 1. Caution: Invisible laser radiation when open and interlocks defeated avoid exposure to beam. Advarsel:Usynling laserstling ved bning, nr sikkerhedsafbrydere er ude af funktion. Undg udsttelse for strling. C

4、AUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardousradiation exposure. ATTENTION Lutilisation de commandes, rglages ou procdures autres que ceux spcifis peut entraner une dangereuse exposition aux radiations. ADVARSEL! Usynlig

5、laserstling ved bning, nr sikkerhedsafbrydereer ude af funktion. Undg udsttelse for strling. This Compact Disc player is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT label is located on the rear exterior. This set employs laser. Therefore, be sure to follow carefully the instruct

6、ions below when servicing. WARNING! WHEN SERVICING, DO NOT APPROACH THE LASER EXIT WITH THE EYE TOO CLOSELY. IN CASE IT IS NECESSARY TO CONFIRM LASER BEAM EMISSION. BE SURE TO OBSERVE FROM A DISTANCE OF MORE THAN 30cm FROM THE SURFACE OF THE OBJECTIVE LENS ON THE OPTICAL CLASS 1 KLASSE 1 LUOKAN 1 KL

7、ASS 1 LASER PRODUCT LASER PRODUKT LASER LAITE LASER APPARAT Precaution to replace Optical block (KSS-213C) 1) After the connection, remove solder shown in the right figure. Body or clothes electrostatic potential could ruin laser diode in the optical block. Be sure ground body and workbench, and use

8、 care the clothes do not touch the diode. RadioFans.CN 收音机爱 好者资料库 -3- SPECIFICATIONS -1/1 Tuner section Frequency range, antennaFM: 87.5 - 108.0 MHz Rod antenna AM: 530/531 - 1,710/1,602 kHz (10/9 kHz step) Ferrite bar antenna. Deck section Track format4 tracks, 2 channels Frequency rangeNormal tape

9、: 50 - 12,000 Hz (EIAJ) Recording systemAC bias Erasing systemMagnet erase HeadsDeck 1: Recording/playback head (1) Erasure head (1) Deck 2: Playback head (1) CD player section DiscCompact disc Scanning methodNon-contact optical scanner (semiconductor laser) Rotation speedApprox. 500 - 200 rpm/CLV E

10、rror correctionCross interleave, Reed, Solomon code Number of channels2 channels D/A conversion1 bit DAC General Power requirementsDC 12 V using eight size D (R20) batteries AC 110-120 V/ 220-240 V switchable 50/60Hz Dimensions (W x H x D)274 x 246 x 260 mm Weight3.4 kg (excluding batteries) Power o

11、utput5 W + 5 W (JEITA, 2.7 ohms DC) 3.5 W + 3.5 W (DIN 1% Rated Power) Power consumption27 W Speaker Type120 mm cone type Dimensions (W x H x D)185 x 234 x 240 mm WeightApprox. 1.3 kg x 2 Impedance2.7 ohms Allowable max. input7 W Specifications and external appearance are subject to change without n

12、otice. != ! SAFTY PARTS C= Components marked All components used on this model at the production line are shown in this service manual. However, please note that not all components will be available as spare parts for after-sales service. Components marked S and O are designated as spare parts for s

13、ervice and will be stocked at the spare parts centers. Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers. UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL -4- ACCESSORIES PARTS LIST -1/1 CA-DW540 LHSTC O AS100

14、1 SF-440-466-00L IB LH(ESP)FM DW540 a O AS1002 8Z-CK4-962-110 REM CONT RC-ZAT04 a ! O AS1003 SW-A18-0E1-79X AC CORD LH a ! O AS1004 87-A91-017-010 PLUG CONVERSION JT-0476 a != ! SAFTY PARTS C= Components marked All components used on this model at the production line are shown in this service manual

15、. However, please note that not all components will be available as spare parts for after-sales service. Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers. Components marked X and R are not designated as spare parts for after sales ser

16、vice, and will not be stocked at the spare parts centers. UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL -5- ELECTRICAL PARTS LIST - 1/10 CA-DW540 LHSTC FRONT O C 0601 87-010-313-080 CHIP.CAP,S 18P/50V (J) CH TP= a FRONT O C 0602 87-010-315-080 CHIP.CAP,S 27P/50V (J) CH TP= a FRONT O C 0603 8

17、7-010-317-080 CHIP.CAP,S 39P/50V (J) CH a FRONT X C 0604 SC-CCJ-G80-60S CHIP CAP 6P/50V a FRONT O C 0605 87-010-314-080 CHIP CAP 22P/50V (J) CH TP=8 a FRONT X C 0606 SC-CFZ-EF1-05S CHIP CAP (1206) 1UF/25V (F) Z a FRONT X C 0607 SC-CFZ-E81-03S CHIP CAP 0.01U/25V (Z) F a FRONT O C 0608 87-016-669-080

18、CHIP.CAP,S 0.1U/25V (K) B a FRONT O C 0609 87-010-196-080 CHIP.CAP,S 0.1U/25V (Z) F TP= a FRONT O C 0610 SC-ESM-CS1-01D ELEC CAP 100UF/10V (M) SME TP a FRONT O C 0611 87-010-196-080 CHIP.CAP,S 0.1U/25V (Z) F TP= a FRONT O C 0612 SC-ESM-CS4-71D ELEC CAP 470u/10V (M) SME TP= a FRONT O C 0613 SC-ESM-GS

19、2-R2D ELEC CAP 2.2u/50V (M) SME TP= a FRONT O C 0614 87-010-196-080 CHIP.CAP,S 0.1U/25V (Z) F TP= a FRONT O C 0615 SC-ESM-GSR-47D ELEC CAP 0.47U/50V (M) SME a FRONT O C 0616 SC-ESM-GS0-10D ELEC CAP 1UF/50V (M) SME TP=5 a FRONT X C 0617 SC-CBK-G81-22S CHIP CAP S 1200P/50V (K) B TP a FRONT O C 0618 SC

20、-ESM-CS1-01D ELEC CAP 100UF/10V (M) SME TP a FRONT O C 0830 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a FRONT X C 0831 SC-CFZ-E81-03S CHIP CAP 0.01U/25V (Z) F a CA-DW540 LHSTC FRONT O C 0832 87-010-181-080 CHIP CAP 1800P/50V (K) B TP=8 a FRONT O C 0833 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8

21、 a FRONT O C 0834 SC-ESM-GS4-R7D ELEC CAP 4.7u/50V (M) SME TP= a FRONT O C 0835 SC-ESM-GSR-10D ELEC CAP 0.1uF/50V (M) SME TP a FRONT O C 0836 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a FRONT O C 0837 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a FRONT O C 0838 SC-ESM-GS0-10D ELEC CAP 1UF/50V (M

22、) SME TP=5 a FRONT O C 0839 SC-ESM-GS0-10D ELEC CAP 1UF/50V (M) SME TP=5 a FRONT O C 0840 SC-ESM-CS4-71D ELEC CAP 470u/10V (M) SME TP= a FRONT O C 0841 SC-ESM-GS0-10D ELEC CAP 1UF/50V (M) SME TP=5 a FRONT O C 0842 87-012-140-080 CHIP.CAP,S 470P/50V (J) CH TP a FRONT O C 0844 SC-ESM-GS0-10D ELEC CAP

23、1UF/50V (M) SME TP=5 a FRONT O C 6003 SC-ESM-CS1-01D ELEC CAP 100UF/10V (M) SME TP a FRONT O C 6004 87-010-198-080 CHIP CAP S 0.022U/25V (K) B T a FRONT O C 6008 87-010-198-080 CHIP CAP S 0.022U/25V (K) B T a FRONT O C 6009 87-010-198-080 CHIP CAP S 0.022U/25V (K) B T a FRONT O C 6011 87-010-198-080

24、 CHIP CAP S 0.022U/25V (K) B T a FRONT O C 6012 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a FRONT O CN 0601 87-A60-109-010 CONNECTOR BASE 2P V (S2M-2W) a FRONT O CN 0602 SW-CAI-247-030 CONNECTOR ASSY 3P a CA-DW540 LHSTC FRONT O CON0601 8Z-CT9-641-010 CONNECTOR ASSY 2P a FRONT S D 0601 87-070-345-

25、080 DIODE 1N4148M DO-34 AI TAPING a FRONT S D 0602 87-070-345-080 DIODE 1N4148M DO-34 AI TAPING a FRONT S D 0611 87-070-345-080 DIODE 1N4148M DO-34 AI TAPING a FRONT S D 0612 87-070-345-080 DIODE 1N4148M DO-34 AI TAPING a FRONT S D 0615 87-070-345-080 DIODE 1N4148M DO-34 AI TAPING a FRONT S D 0616 8

26、7-070-345-080 DIODE 1N4148M DO-34 AI TAPING a FRONT S D 0623 87-070-345-080 DIODE 1N4148M DO-34 AI TAPING a FRONT S D 0625 87-070-345-080 DIODE 1N4148M DO-34 AI TAPING a FRONT S D 0626 87-070-345-080 DIODE 1N4148M DO-34 AI TAPING a FRONT S D 0630 87-070-345-080 DIODE 1N4148M DO-34 AI TAPING a FRONT

27、S D 0820 87-070-345-080 DIODE 1N4148M DO-34 AI TAPING a FRONT S D 0821 87-070-345-080 DIODE 1N4148M DO-34 AI TAPING a FRONT S D 0822 87-070-345-080 DIODE 1N4148M DO-34 AI TAPING a FRONT S IC 0601 8B-CT5-625-010 IC LC867132V5T98 a FRONT O J 0251 8A-CT9-630-010 JACK W/SW MICST a FRONT O J 0801 8A-CT9-

28、630-010 JACK W/SW MICST a FRONT O JW 0633 87-003-097-080 FIXED IND 1.0UH (K) TP=26mm a FRONT O L 0601 SL-A4K-0T4-70B FIXED IND 47 uH (K) T26 a FRONT O L 0602 87-008-372-080 BEADS CORE (BLO1RN1-A63.T6) T a CA-DW540 LHSTC FRONT O L 0604 87-003-152-080 FIXED IND 100UH a FRONT O L 0801 87-008-372-080 BE

29、ADS CORE (BLO1RN1-A63.T6) T a FRONT O LCD0601 SV-LOR-YP0-46Y LCD a FRONT S Q 0601 SK-RC1-08M-000 D TRANSISTOR KRC108M AT a FRONT S Q 0602 SB-R2S-A93-3AS TR 2SA933-R a FRONT S Q 0603 SK-RC1-08M-000 D TRANSISTOR KRC108M AT a FRONT S Q 0605 87-026-464-080 D TRANSISTOR KRC111M AT a FRONT S Q 0612 87-026

30、-464-080 D TRANSISTOR KRC111M AT a FRONT S Q 0616 SK-RC1-08M-000 D TRANSISTOR KRC108M AT a FRONT S Q 0820 87-026-610-080 TRANSISTOR KTC3198GR AT a FRONT S Q 0821 89-322-405-080 TR 2SC2240GR TP a FRONT S Q 0822 87-026-610-080 TRANSISTOR KTC3198GR AT a FRONT S Q 0823 SK-RC1-08M-000 D TRANSISTOR KRC108

31、M AT a FRONT S Q 0824 SB-R2S-C17-40S TR 2SC1740-R a FRONT X R 0279 88-118-181-080 CHIP RES 1/10W (J) 180ohm TP= a FRONT X R 0280 88-118-181-080 CHIP RES 1/10W (J) 180ohm TP= a FRONT X R 0601 88-118-821-080 CHIP RES 1/10W (J) 820ohm TP= a FRONT O R 0602 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a

32、FRONT X R 0603 88-118-474-080 CHIP RES,S 1/10W (J) 470Kohm a FRONT X R 0604 SR-ATJ-603-34X CARBON RES 1/6W(J) 330kohm TP a != ! SAFTY PARTS C= Components marked All components used on this model at the production line are shown in this service manual. However, please note that not all components wil

33、l be available as spare parts for after-sales service. Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers. Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts c

34、enters. UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL -6- ELECTRICAL PARTS LIST - 2/10 CA-DW540 LHSTC FRONT O R 0605 88-118-473-080 CHIP RES 1/10W (J) 47Kohm TP a FRONT O R 0606 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a FRONT O R 0607 88-118-104-080 CHIP RES 1/10W (J) 100Kohm TP a FRONT

35、 X R 0611 SR-ATJ-602-72X CARBON RES 1/6W (J) 2.7Kohm T a FRONT O R 0612 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a FRONT O R 0613 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a FRONT O R 0614 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a FRONT O R 0615 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a

36、 FRONT O R 0616 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a FRONT O R 0617 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a FRONT O R 0618 88-121-102-080 CARBON RES 1/6W (J) 1Kohm TP= a FRONT O R 0620 88-121-102-080 CARBON RES 1/6W (J) 1Kohm TP= a FRONT X R 0621 SR-ATJ-602-72X CARBON RES 1/6W (J) 2.7

37、Kohm T a FRONT O R 0622 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a FRONT O R 0627 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a FRONT X R 0628 88-118-821-080 CHIP RES 1/10W (J) 820ohm TP= a FRONT O R 0629 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a FRONT X R 0630 88-118-122-080 CHIP RES 1/10

38、W (J) 1.2Kohm TP a FRONT X R 0631 88-118-152-080 CHIP RES 1/10W (J) 1.5Kohm T a FRONT O R 0632 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a CA-DW540 LHSTC FRONT X R 0633 88-118-122-080 CHIP RES 1/10W (J) 1.2Kohm TP a FRONT X R 0634 88-118-152-080 CHIP RES 1/10W (J) 1.5Kohm T a FRONT O R 0635 88-11

39、8-182-080 CHIP RES 1/10W (J) 1.8Kohm TP a FRONT X R 0637 88-118-152-080 CHIP RES 1/10W (J) 1.5Kohm T a FRONT O R 0638 88-118-182-080 CHIP RES 1/10W (J) 1.8Kohm TP a FRONT O R 0640 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a FRONT X R 0641 88-118-821-080 CHIP RES 1/10W (J) 820ohm TP= a FRONT O R 0

40、642 88-121-102-080 CARBON RES 1/6W (J) 1Kohm TP= a FRONT X R 0643 88-118-122-080 CHIP RES 1/10W (J) 1.2Kohm TP a FRONT O R 0651 88-118-224-080 CHIP RES 1/10W (J) 220K ohm a FRONT O R 0652 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a FRONT X R 0653 88-118-152-080 CHIP RES 1/10W (J) 1.5Kohm T a FRON

41、T X R 0658 SR-ATJ-601-03X CARBON RES 1/6W (J) 10Kohm TP a FRONT O R 0659 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a FRONT X R 0660 88-118-122-080 CHIP RES 1/10W (J) 1.2Kohm TP a FRONT O R 0664 88-118-223-080 CHIP RES 1/10W (J) 22Kohm TP a FRONT O R 0670 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=

42、8 a FRONT X R 0672 88-118-000-080 CHIP JUMPER S 0805 TP=8mm a FRONT O R 0673 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a FRONT O R 0675 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a CA-DW540 LHSTC FRONT O R 0676 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a FRONT X R 0677 88-128-102-080 CHIP RES

43、ISTOR 1K 1/8W 1206 a FRONT O R 0680 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a FRONT X R 0878 88-118-681-080 CHIP RES 1/10W (J) 680ohm TP a FRONT O R 0879 88-118-224-080 CHIP RES 1/10W (J) 220K ohm a FRONT X R 0880 88-118-222-080 CHIP RES 1/10W (J) 2.2Kohm TP a FRONT X R 0881 88-118-474-080 CHIP RES,S 1/10W (J) 470Kohm a FRONT O R 0882 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a FRONT X R 0883