Aiwa-CRSP66-rr-sm电路图 维修手册.pdf

《Aiwa-CRSP66-rr-sm电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Aiwa-CRSP66-rr-sm电路图 维修手册.pdf（14页珍藏版）》请在收音机爱好者资料库上搜索。

1、 STEREO RADIO RECEIVER CR-SP66 S/M Code No. 09-997-330-5N1 YU SERVICE MANUAL DATA RadioFans.CN 收音机爱 好者资料库 2 SPECIFICATIONS Design and specifications are subject to change without notice. REF. NOPART NO.KANRIDESCRIPTION NO. ACCESSORIES/PACKAGE LIST 1 S7-R10-120-000 CLIP BELT 2 S0-100-270-000 HP,SET H

2、P-M027 3 S8-RC7-910-600 INSTRUC,BOOK(CRSP66YU,3L,C) RadioFans.CN 收音机爱 好者资料库 4 TRANSISTOR ILLUSTRATION B E C 2SA1362 2SC2712 2SC2714 DTA114YK DTA144EK DTC114YKA DTC144EK RN1410 RN2411 SGD 2SK118 REF. NOPART NO.KANRIDESCRIPTION NO. REF. NOPART NO.KANRIDESCRIPTION NO. ELECTRICAL MAIN PARTS LIST IC 87-0

3、01-149-080 IC,TA8158F 87-A20-851-040 IC,TA2111FN 88-RH1-601-010 IC,TC-9318FB-029 87-017-642-080 IC,CXA1622M TRANSISTOR 89-327-124-080 C-TR,2SC2712Y 87-026-230-010 C-TR,DTA114YK 87-026-263-080 C-TR,RN1410 89-327-143-010 C-TR,2SC2714Y 89-113-625-080 C-TR,2SA1362Y 87-026-211-080 C-TR,DTA144EK 87-026-21

4、0-080 C-TR,DTC144EK/EKA 87-026-268-080 C-TR,RN2411 87-026-213-080 C-TR,DTC114YKA S9-011-800-180 TR,2SK118R DIODE 87-020-339-080 C-DIODE,1SS226 87-A40-471-070 C-DIODE,KV1435 87-A40-449-070 C-DIODE,1SS268 MAIN C.B BPF1 87-A90-709-010 BAND PASS FILTER GTVSB3 C16 87-010-498-080 CAP,E 10-16V C17 87-010-4

5、18-040 CAP,E 3.3-25V C18 87-010-418-040 CAP,E 3.3-25V C21 87-010-498-080 CAP,E 10-16V C23 87-016-350-040 CAP,E 470-4V C25 87-010-587-070 CAP,E 100-2V C26 87-010-499-040 CAP,E 22-6.3V C64 87-010-044-080 CAP,E 47-4V C80 87-010-044-080 CAP,E 47-4V CF1 S0-001-070-010 CER,FILTER CF2 S0-001-070-010 CER,FI

6、LTER CF3 S0-004-500-000 CER FILTER SFU450 CF4 S6-010-700-020 CER,RESO A10.7MG60-A D2 87-A40-517-040 C-DIODE,SVC208 D3 87-A40-517-040 C-DIODE,SVC208 HP1 S0-130-020-000 PHONE JACK LGY3002-0350C L1 87-A50-375-010 INDUCTOR 1UH 2.3-3.4 L2 87-A50-375-010 INDUCTOR 1UH 2.3-3.4 L3 87-A50-375-010 INDUCTOR 1UH

7、 2.3-3.4 L5 87-005-722-080 INDUCTION 2.2UH L7 S0-311-927-410 ANT COIL ASSY BAR 5-8-50 L11 87-A50-375-010 INDUCTOR 1UH 2.3-3.4 L12 87-005-696-080 COIL,100UH SW1 S1-220-211-000 SW,SLIDE 1P2T SW2 87-036-322-010 SW,SLIDE 2P3T T1 S8-398-250-550 IFT,5.5MM T2 S8-425-550-050 AM IFT TC1 S1-000-200-010 CAP,TR

8、IMMER ECRLA020E52 5.5-20 VR1 SA-082-033-010 RES,VARIABLE 20KAx2 FRONT C.B C510 87-016-448-080 C-CAP,E 2.2-10V C516 87-010-044-080 CAP,E 47-4V L501 87-003-154-080 INDUCTOR 220UH L502 87-005-730-080 INDUCTOR,10UH LCD501 S0-041-850-000 LCD-P-4D-0425SM020P SW501 SS-KQN-AB0-000 SW,TACT SKQNAB0004 SW502 S

9、S-KQN-AB0-000 SW,TACT SKQNAB0004 SW503 SS-KQN-AB0-000 SW,TACT SKQNAB0004 SW504 SS-KQN-AB0-000 SW,TACT SKQNAB0004 SW505 SS-KQN-AB0-000 SW,TACT SKQNAB0004 SW506 SS-KQN-AB0-000 SW,TACT SKQNAB0004 SW507 SS-KQN-AB0-000 SW,TACT SKQNAB0004 SW508 SS-KQN-AB0-000 SW,TACT SKQNAB0004 SW509 SS-KQN-AB0-000 SW,TAC

10、T SKQNAB0004 SW510 SS-KQN-AB0-000 SW,TACT SKQNAB0004 SW511 SS-KQN-AB0-000 SW,TACT SKQNAB0004 SW512 SS-KQN-AB0-000 SW,TACT SKQNAB0004 SW513 SS-KQN-AB0-000 SW,TACT SKQNAB0004 SW515 S1-220-211-000 SW,SLIDE 1P2T SW516 S1-220-211-000 SW,SLIDE 1P2T X501 S4-150-000-010 XTAL,75.0 KHZ 8 8 A Resistor Code Chi

11、p Resistor Part Coding Figure Value of resistor Chip resistor WattageTypeTolerance 1/16W 1/10W 1/8W 1608 2125 3216 5% 5% 5% CJ CJ CJ FormLWt 1.60.80.45 21.250.45 3.21.6 108 118 128 : A : A CHIP RESISTOR PART CODE 0.55 Resistor Code Dimensions (mm) Symbol 1/16W10055%CJ1.00.50.35104 L t W Regarding co

12、nnectors, they are not stocked as they are not the initial order items. The connectors are available after they are supplied from connector manufacturers upon the order is received. 3 65 SCHEMATIC DIAGRAM 87 WIRING-1 (MAIN) 7865432112345678 A B C D E F G H I J A B C D E F G H I J MAIN C.B (COMPONENT

13、 SIDE)MAIN C.B (CONDUCTOR SIDE) VR1 VOLUME SW2 POWER S-BASS ON OFF SW1 FM MODE MONO ST TO/FROM FRONT C.B L7 AM BAR ANT C79 113 Q21 R70 C80 R43 R42 R45 C45 D6 R38 R41 R30 R23 R20 R32 R1 R3 R33 R36 R48 R34 R35 R27 R50 R10 C10 C12 C20 C8 D1 C24 C11 C13 C66 C62 R8 R2 R000 R16 R15 R11 R13 R17 R12 R14 R9

14、R58 R55 R57 R73 R49 R46 Q14 Q3 Q4 C48 C46 C71 C69 C22 C9 C70 C41 C47 C51 C31 C61 C76 C82 C37 C4 Q9 Q12 Q1Q2 C27 C29 D2 C42 C33C35 C30 C55 C59 C50 C52 R60 Q13 Q18 Q19 R6 R62 R52 C6 C7 R7 C60 C57 C43 D3 D4 D5 R44 R40 C84 R75 C46 C53 R47 Q15 Q6 Q7 C32 R29 R24 C28 C54 C74 R39 R31 IC1 IC2 IC4 1 1 18 916

15、12 1324 5 610 Q5Q8 R25 R26 R37 C65 C34 C38 C39 C36 D7 R5 R53 C5 C3 C1 C2 R4 Q11 R54 C75 C15 C68 C72 Q16 R59 R61 Q17 C73 R56 C14 C19 R72 R001 R19 R18 109 1-3 4-18 19-26 27-30 31-34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58, 59 60 61 62, 63 64 IC, TC9318FB-029 Pin No.Pin

16、NameI/ODescription IC DESCRIPTION Common signal outputs to the LCD panel. Segment signal outputs to the LCD panel. Segment signal outputs/key return signal outputs to the LCD panel. 4-bit inputs for key matrix. Timing signal outputs for key matrix. Band outputs. H: TV band available, L: TV band not

17、available. 9K/10K switching input which selects the number of steps for the AM band. H: 9kHz, L: 10kHz. Area inputs. * Do not care. Not connected. Key hold input.“L” input inhibits key inputs. H: Meter KG system, L: Yard/pond/mile system. Battery voltage detection. Stereo input, “L” input causes the

18、 STEREO indicator to light in the LCD. Alarm output. Muting output. Test input. Inhibits: controls the radio on/off. IF counter input. PLL phase comparator outputs. Ground. FM programmable counter input. AM programmable counter input. Power supply. Device system reset signal input. For the connectio

19、n of a 75kHz crystal oscillator. Power supply of the crystal oscillator. For the connection of a capacitor which stablizes the power supply. For the connection of capacitors which double the voltage to drive the LCD. 1.5V regulated power supply which drives the LCD. For the connection of a capacitor

20、 which stablizes the power supply. E0E1Area 00Japan 01USA 1*Europe BandBAND 0BAND 1 FMLH TV WEHL MWLL COM1-3 S1-15 S16/KR7-S23/KR0 K0-K3 T0-T3 BAND 0 BAND 1 TV-ENA 9K/10K E0 E1 NC HOLD KG/YARD BATT/VOLT STEREO ALARM MUTE TEST _ HOLD IFIN/IN DO1/OT DO2 GND FM IN AM IN VDD _ RESET X OUT, X IN V XT V L

21、CD C1, C2 VEE O O O I O O I I I I I I I O O I I I O I I I O/I IC BLOCK DIAGRAM IC, TA8158F IC, TA2111FN IC, CXA1622M 1211 WIRING-2 (FRONT) 7865432112345678 A B C D E F G H I J A B C D E F G H I J 119 16 17 1 64 4833 3249 TO/FROM MAIN C.B SW515 HOLD ON OFF FRONT C.B (COMPONENT SIDE)FRONT C.B (CONDUCT

22、OR SIDE) SW516 AM STEP 10kHz 9kHz 1413 VOLTAGE CHART 15 LCD DISPLAY 16 ELECTRICAL ADJUSTMENT 17 PRACTICAL SERVICE FIGURE Sensitivity:Less than 16dB (90/98/106MHz) (THD 3%) Distortion:Less than 2% (98MHz) Intermediate frequency:10.7MHz Stereo separation:More than 20dB Sensitivity:Less than 54dB (600k

23、Hz) (S/N 10dB)Less than 51dB (1000/1400kHz) Signal to Noise Ratio:More than 25dB (600/1000/1400kHz) (Input 74dB) Distortion:Less than 3% (1000kHz) (Input 100dB) Intermediate frequency:450kHz Sensitivity:Less than 20dB (2/8/13ch) (THD 3%) Distortion:Less than 2% (8ch) Intermediate frequency:10.7MHz S

24、ensitivity:Less than 22dB (6ch) (THD 3%) Distortion:Less than 2% (6ch) Intermediate frequency:10.7MHz 18 MECHANICAL EXPLODED VIEW 1/1 19 REF. NOPART NO.KANRIDESCRIPTION NO. MECHANICAL PARTS LIST 1/1 Basic color symbolColorBasic color symbolColorBasic color symbolColor BBlackCCreamDOrange GGreenHGray

25、LBlue LTTransparent BlueNGoldPPink RRedSSilverSTTitan Silver TBrownVVioletWWhite WTTransparent WhiteYYellowYTTransparent Yellow LMMetallic BlueLLLight BlueGTTransparent Green LDDark BlueDTTransparent Orange COLOR NAME TABLE 1 S8-RC7-050-000 KNOB,RTRY POWER GRY 2 S8-RC7-060-000 KNOB,RTRY VOLUME 3 S7-

26、R10-370-000 KNOB,SPR-C VOL 4 S8-RC7-030-100 FRONT COVER(YU) 5 S8-RC7-020-300 CAB,REAR(CRSP66YU) 6 S8-RC7-010-200 CAB,FRONT(CRSP66YU) 7 S8-RC7-140-000 KNOB,RTRY ARM 8 S8-RC7-110-000 HOLDER KNOB RTRY ARM 9 S8-RC7-040-100 LCD WINDOW 10 S8-RC7-080-100 KEY,PRESET 11 S8-RC7-090-100 KEY,FUNCTION 12 S8-RC7-

27、150-000 LCD COVER 13 S8-RC7-130-000 BATT HOLDER 14 S8-RC7-100-000 LCD HOLDER 15 S8-RC7-070-000 KNOB,RTRY ST/MO 16 S8-RC7-160-000 BATT CONTACT(+) 17 S8-RC7-180-000 BATT CONTACT(+/-) 18 S8-RC7-250-000 BATT CONTACT(-) 19 S7-R10-110-000 HOLDER BAR ANT A S0-502-001-210 SCREW,ST2-12 B 87-261-531-310 SCREW,1.7-5 PB 737004 Printed in Singapore 211, IKENOHATA 1CHOME, TAITO-KU, TOKYO 110-8710, JAPAN TEL:03 (3827) 3111