Pioneer-VSX1130K-avr-sm电路图 维修手册.pdf

《Pioneer-VSX1130K-avr-sm电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Pioneer-VSX1130K-avr-sm电路图 维修手册.pdf（75页珍藏版）》请在收音机爱好者资料库上搜索。

1、ORDER NO. PIONEER CORPORATION 1-1, Shin-ogura, Saiwai-ku, Kawasaki-shi, Kanagawa 212-0031, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra

2、Road, #04-01, Singapore 159936 PIONEER CORPORATION2015 2015 Printed in Japan VSX-1130-K RRV4597 AV Receiver VSX-1130-K VSX-90 VSA-1130 THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S). THIS SERVICE MANUAL SHOULD BE USED TOGETHER WITH THE FOLLOWING MANUAL(S). ModelTypePower Requirement

3、Remarks VSX-1130-KCUXESMAC 120 V VSX-90CUXEAC 120 V VSA-1130JXEVAC 100 V ModelOrder No.Remarks VSX-1130-K, VSX-90RRV4596BLOCK DIAGRAM, EXPLODED VIEWS AND PARTS LIST etc. K-MZV MAY RadioFans.CN 收音机爱 好者资料库 2VSX-1130-K 1234 A B C D E F 1234 SAFETY INFORMATION WARNING This product may contain a chemical

4、 known to the State of California to cause cancer, or birth defects or other reproductive harm. Health it is not meant for the casual do-it- yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as tho

5、se covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualifie

6、d service technician. 1. SAFETY PRECAUTIONS The following check should be performed for the continued protection of the customer and service technician. LEAKAGE CURRENT CHECK Measure leakage current to a known earth ground (water pipe, conduit, etc.) by connecting a leakage current tester such as Si

7、mpson Model 229-2 or equivalent between the earth ground and all exposed metal parts of the appliance (input/output terminals, screwheads, metal overlays, control shaft, etc.). Plug the AC line cord of the appliance directly into a 120 V AC 60 Hz outlet and turn the AC power switch on. Any current m

8、easured must not exceed 0.5 mA. ANY MEASUREMENTS NOT WITHIN THE LIMITS OUTLINED ABOVE ARE INDICATIVE OF A POTENTIAL SHOCK HAZARD AND MUST BE CORRECTED BEFORE RETURNING THE APPLIANCE TO THE CUSTOMER. 2. PRODUCT SAFETY NOTICE Many electrical and mechanical parts in the appliance have special safety re

9、lated characteristics. These are often not evident from visual inspection nor the protection afforded by them necessarily can be obtained by using replacement components rated for voltage, wattage, etc. Replacement parts which have these special safety characteristics are identified in this Service

10、Manual. Electrical components having such features are identified by marking with a on the schematics and on the parts list in this Service Manual. The use of a substitute replacement component which does not have the same safety characteristics as the PIONEER recommended replacement one, shown in t

11、he parts list in this Service Manual, may create shock, fire, or other hazards. Product Safety is continuously under review and new instructions are issued from time to time. For the latest information, always consult the current PIONEER Service Manual. A subscription to, or additional copies of, PI

12、ONEER Service Manual may be obtained at a nominal charge from PIONEER. Leakage current tester Reading should not be above 0.5 mA Device under test Test all exposed metal surfaces Also test with plug reversed (Using AC adapter plug as required) Earth ground AC Leakage Test (FOR USA MODEL ONLY) RadioF

13、ans.CN 收音机爱 好者资料库 3VSX-1130-K 5678 5678 A B C D E F CONTENTS SAFETY INFORMATION.2 10. SCHEMATIC DIAGRAM.4 10.1 OVERALL WIRING DIAGRAM .4 10.2 MAIN ASSY.6 10.3 DMAIN ASSY (1/11) .8 10.4 DMAIN ASSY (2/11) .10 10.5 DMAIN ASSY (3/11) .12 10.6 DMAIN ASSY (4/11) .14 10.7 DMAIN ASSY (5/11) .16 10.8 DMAIN A

14、SSY (6/11) .18 10.9 DMAIN ASSY (7/11) .20 10.10 DMAIN ASSY (8/11).22 10.11 DMAIN ASSY (9/11).24 10.12 DMAIN ASSY (10/11).26 10.13 DMAIN ASSY (11/11).28 10.14 OPTCO and BRIDGE ASSYS .32 10.15 AUDIO ASSY.34 10.16 CPU ASSY.36 10.17 AMP7 ASSY (1/2).38 10.18 AMP7 ASSY (2/2).40 10.19 FHDMI ASSY.42 10.20 T

15、EMP, FRONT, HPMIC and INSEL ASSYS.44 10.21 SMPS ASSY.46 11. PCB CONNECTION DIAGRAM.48 11.1 MAIN ASSY.48 11.2 DMAIN ASSY.52 11.3 OPTCO ASSY .56 11.4 BRIDGE ASSY .57 11.5 AUDIO ASSY.58 11.6 CPU ASSY.60 11.7 AMP7 ASSY .64 11.8 FHDMI, TEMP, FRONT, HPMIC and INSEL ASSYS.66 11.9 SMPS ASSY.70 12. PCB PARTS

16、 LIST.71 RadioFans.CN 收音机爱 好者资料库 4VSX-1130-K 1234 A B C D E F 1234 10. SCHEMATIC DIAGRAM 10.1 OVERALL WIRING DIAGRAM CP5 3P WIRE(NTC) CN3501A CN3004(S4) CN9501 CN1802 CP2009 CP1 CN3 CN9502 CN1 CN7202A 10P WIRE(+/-B, GND) 2P WIRE(SPK OUT SB) CX102 CP405 4P WIRE 7P WIRE 9P WIRE(HP/MIC) CP403 CX101 CX1

17、00 AC IN CN3501B CN5 (S1) CN2 CN5 3P WIRE (SPK OUT F) CN7202B 4P WIRE (SPK OUT C/S) CP406 7P WIRE(SMPS 5.6V) MAIN TRANS D10S CN1801 CN2111 - When ordering service parts, be sure to refer to EXPLODED VIEWS and PARTS LIST or PCB PARTS LIST. - The mark found on some component parts indicates the import

18、ance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. - : The power supply is shown with the marked box. BBB1/11-11/11 DMAIN ASSY (VSX-1130-K/CUXESM: 70280778 (VSX-90/CUXE: 7028077871010) (VSA-1130/JXEV: 7028077871030 G AM (VS (VS C OPTCO AS

19、SY (VSX-1130-K/CUXESM, VSX-90/CUXE: 70280777230A0) (VSA-1130/JXEV: 70280777230B0) DBRIDGE A (VSX-1130-K 702807781 (VSX-90/CUX I TEMP ASSY (SX-1130-K/CUXESM, VSX-90/CUXE: 7028077816010) (VSA-1130/JXEV: 7028077816030) J FRONT ASSY (VSX-1130-K/CUXESM: 70280777210D0) (VSX-90/CUXE: 70280777210A0) (VSA-11

20、30/JXEV: 70280777210C0) L INSEL ASSY (70280777220A0) K HPMIC ASSY (70280777240A0) M SMPS ASSY (VSX-1130-K/CUXESM: 702807336108B) (VSX-90/CUXE: 702807336106B) (VSA-1130/JXEV: 702807336109B) 5VSX-1130-K 5678 5678 A B C D E F FLSO CN601 CN305 CN314 CN2103 CN801 CN9202 13P WIRE (AUDIO) KEY3 KEY2 KEY1 CN

21、3001 5P WIRE CN301 HDMI CABLE 6P F_USB VCC WIRE (S2) CP3 CN803 SR_IN HDLED iPodLED VOLA VOLB DIMCTL Z2-KEY V+5R0_EV USBDCERR GNDD GNDD DC_DET V+6.8_A V-6.8_A XMICDET MICOUT HP_L GND_HP GND_HP JOGA FLSCK XFLRST FLOFFLED CN404 (S3) CP2 CN308A CN5 3P WIRE (SPK OUT F) CP3002 JA8203 CNT-19P RYAC POWKEY P

22、OWLED GNDD V+5R0_EV GNDD CP401 HP_R JOGB GNDA FLREQO JA9620 7805 5P WIRE(USB)_SHLD 27P FFC CARD CABLE 39P FFC CARD CABLE(FRONT) HDMI CABLE H/P DETECT MCACCLED CP3601 3P WIRE(F-USB/HDMI) 5P WIRE(USB)_SHLD CP404 D10SB6078127912 TUNER 6P F_USB VCC WIRE CP20 CN313A CP12 CN312 CP15 CN311 CN302 CN607 CP19

23、 CP17 CN1801 CN2111 CP25 CP19 CP21 CN310 CN1504 CP15 CP14CN2107 CN2204 CN2114 CN303A CN902 CP3603 AMAIN ASSY (VSX-1130-K/CUXESM: 7028077811040) (VSX-90/CUXE: 7028077811010) (VSA-1130/JXEV: 7028077811030) B11/11 Y XESM: 7028077871040) 028077871010) 7028077871030) GGG1/12,2/2 AMP7 ASSY (VSX-1130-K/CUX

24、ESM, VSX-90/CUXE: 7028077751010) (VSA-1130/JXEV: 7028077751030) VSX-90/CUXE: 777230B0) DBRIDGE ASSY (VSX-1130-K/CUXESM, VSA-1130/JXEV: 7028077812020) (VSX-90/CUXE: 7028077812010) E AUDIO ASSY (VSX-1130-K/CUXESM: 7028077841040) (VSX-90/CUXE: 7028077841010) (VSA-1130/JXEV: 7028077841030) F CPU ASSY (V

25、SX-1130-K/CUXESM: 70280777310D0) (VSX-90/CUXE: 70280777310A0) (VSA-1130/JXEV: 70280777310C0) H FHDMI ASSY (VSX-1130-K/CUXESM, VSX-90/CUXE: 7028077881010) (VSA-1130/JXEV: 7028077881030) 777210D0) A0) 0C0) 6VSX-1130-K 1234 A B C D E F 1234 10.2 MAIN ASSY FROM MAIN TRANS NOTE FOR FUSE REPLACEMENT CAUTI

26、ON - FOR CONTINUED PROTECTION AG REPLACE WITH SAME TYPE AND R CV R45 4K7 SUV SBV A+12V R23 10 V+5V U/DGND SBRL R43 - L2SP-2507 C14 15N(EB)-100V L5SP-2507 3216 SIZE L6 SP-2507 SBV SUV C/SURL CV CHASSIS TO CHASSIS AGND C77 - DLXE EXCEPT 10000/25 10000/16 C13 - ACWP DGND2 C18 - C106 - D14 - D18- D16- R

27、75 - V-6.8_A GNDA MICOUT HPDET V-7_A CHASSIS GND R42 0R22(1) C83 47N(EB)-100V R41 0R22(1) GND4 C79 47N(EB)-100V F34 4AL/250V F33 4AL/250V C65 100N(R)-250V C61 100N(EB)-100V C4 47N(EB)-100V FV GND 2P WIRE D12 1N4007 D13 1N4007 D101N4007 D11 1N4007 D19 LBAS16HT1G C91 10/50 C78 - C67 100N(R)-250V R10 1

28、0(2) C9 47N(EB)-100V C2 - - C5 C85 C84 C104 10N-K Q18 RT1N237C 0 R57 C76 10000/16(16*35.5) GND2 CHASSIS R36 47K(1/4) R6 10(2) C1 47N(EB)-100V C40- C41 - FILM CAP FILM CAP GND/ 2P WIRE R14 10(2) R12 10(2) C17 47N(EB)-100V - C10 TO CHASSIS D15 - IC2 KIA7912PI TO CHASSIS IC1 KIA7812API C97 100N-K R85-

29、CN2 R16 10(2) C22 47N(EB)-100V C23 - C16 15N(EB)-100V C94 - RB551V-30TE-17 D28 TO CHASSIS C105 10N-K C92 100/16 C96 10N-K R18 10(2) C25 47N(EB)-100V F-BV C20 - C21 15N(EB)-100V C108- R81 330(2) V+5V D6 LBAS16HT1G R24 10 GNDA MICDET V+6.8_A FBRL Q13 RT1N237C D5 LBAS16HT1G V+7_A HP_RLY R47 - D4 LBAS16

30、HT1G R22 10 C60 - C62 - R44 - D3 LBAS16HT1G R21 10 132 CP3 5267-03A 312 CP1 35328-0360 C82 47N(EB)-100V C81 47N(EB)-100V JP83 0 C66 100N(R)-250V C64 100N(EB)-100V R25 5R6(1) R32 JUMPER D20 LBAS16HT1G C68 100N(R)-250V R48 - L3SP-2507 R9 10(1) C6 15N(EB)-100V C3 15N(EB)-100V R46 22K ZJ22B DZ3 R35 47K(

31、1/4) C58 10000/71(35*50)-LAO L4SP-2507 L1SP-2507 R510(1) C8 15N(EB)-100V 21 CN7A R13 10(1) R11 10(1) C19 15N(EB)-100V C11 15N(EB)-100V IC5 KIA7812API L7SP-2507 R15 10(1) IC3 KIA7805API C93- C107 - RB551V-30TE-17 R17 10(1) C90 100/10 C95- R71 - R72 - R82 330(2) 6213457891011 CP25 9115S-8P F-BV 543126

32、789101112 CP19 NOT USED NOT USED 312 CP2 35313-0360 RLY3 G5PA-28(OMRON) RLY4 G5PA-28(OMRON) G5PA-28(OMRON) RLY5 G5PA-28(OMRON) RLY6 100/25(6.3*11)C53 74562318 CP7 - ACWP OPTION VSX-90 ONLY USB+12V C15 - AGND A+12V AGND V+5V C311N-J C331N-J MIC_OUT HP_DET A+12V AGND A-12V DAB_L DAB_R DAB_GND C87 10N(

33、EB)-100V DZ2 ZJ4.7B R55 0 (2012)J MODEL ONLY C75 JUMPER 132 CN5 1234 CN1 R8 10(2) C12 47N(EB)-100V C7 - JACK1 JACK101 LARGE_6P SPEAKER TERMINAL A-12V C89 56789104321 CN3 C261N-J C24 15N(EB)-100V C341N-J C321N-J C301N-J C291N-J JACK102 LARGE_4P OPTION Q12 RT1N237C Q11 RT1N237C MIC_DET GNDA C122 10N-K C86 10N(EB)-100V R102 0 0 R56 D4912 BR64 D7 D10SB60 C55 100