Pioneer-XVVS600-cs-sm2 电路图 维修手册.pdf

《Pioneer-XVVS600-cs-sm2 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Pioneer-XVVS600-cs-sm2 电路图 维修手册.pdf（23页珍藏版）》请在收音机爱好者资料库上搜索。

1、PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore

2、 159936 PIONEER CORPORATION 2001 ORDER NO. RRV2534 T ZZK SEPT. 2001 Printed in Japan THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S). Model No.Order No.Remarks XR-A9800D/KUCXJRRV2329 This service manual should be used together with the following manual(s): STEREO DVD CASSETTE DECK RE

3、CEIVER XV-VS800 XV-VS600 CONTENTS 1. SAFETY INFORMATION.2 2. CONTRAST OF MISCELLANEOUS PARTS.3 3. SCHEMATIC DIAGRAM.12 4. PCB CONNECTION DIAGRAM.22 Type Model Power Requirement RegionThe voltage can be converted by XV-VS800XV-VS600No.the following method. DXJN/NCAC110-127V/220-230V/240V3With the vol

4、tage selector RadioFans.CN 收音机爱 好者资料库 XV-VS800, XV-VS600 2 1. SAFETY INFORMATION Printed on the Rear Panel LABEL CHECK LASER DIODE CHARACTERISTICS FOR DVD :MAXIMUM OUTPUT POWER : 5 mW WAVELENGTH : 655 nm FOR CD :MAXIMUM OUTPUT POWER : 5mW WAVELENGTH : 785 nm Additional Laser Caution 1. Inside detect

5、ion switch (S201 on the SMEB assy) and loading- status detection switch (S9503 on the MOTOR assy) are detected by the microprocessor (IC11 in the DVDM assy). To permit the laser diode to oscillate, it is required to set the inside detection switch for the inside position (S201 : ON) and to set the l

6、oading-status detection switch for the clamp position (the center terminal of S9503 is shorted to +5V). The 655 nm laser diode for DVD oscillation will continue if pin 19 of IC1 is shorted to +5V (fault condition) in the DVDM assy. The 785 nm laser diode for CD oscillates if pin 20 of IC1 is shorted

7、 to +5V in the DVDM assy. In the test mode , the laser diode oscillates when microproces- sor detects a PLAY signal, or when the PLAY key is pressed (S5931 ON in the DISPLAY assy), with the above requirements satisfied. 2. When the cover is open, close viewing through the objective lens with the nak

8、ed eye will cause exposure to the laser beam. : Refer to page 82 on the service manual RRV2329. WARNING ! THE AEL (ACCESSIBLE EMISSION LEVEL) OF THE LASER POWER OUTPUT IS LESS THAN CLASS 1 BUT THE LASER COMPONENT IS CAPABLE OF EMITTING RADIATION EXCEEDING THE LIMIT FOR CLASS 1. A SPECIALLY INSTRUCTE

9、D PERSON SHOULD DO SERVICING OPERATION OF THE APPARATUS. This service manual is intended for qualified service technicians ; it is not meant for the casual do-it- yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair comple

10、x products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer th

11、e repair to a qualified service technician. RadioFans.CN 收音机爱 好者资料库 XV-VS800, XV-VS600 3 2. CONTRAST OF MISCELLANEOUS PARTS Parts marked by NSP are generally unavailable because they are not in our Master Spare Parts List. The mark found on some component parts indicates the importance of the safety

12、 factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screws adjacent to mark on product are used for disassembly. Reference Nos. indicate the pages and Nos. in the service manual for the base model. NOTES: When ordering resistors, first convert resistance va

13、lues into code form as shown in the following examples. Ex.1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47k ohm (tolerance is shown by J=5%, and K=10%). Ex.2 When there are 3 effective digits (such as in high precision metal film resistors). 5 6 1 4 7 3 R 5 0 1 R

14、 0 5 6 2 1 560 47k 0.5 1 RD1/4PU J RD1/4PU J RN2H K RS1P K 56 x 101 47 x 103 R50 1R0 561 473 5.62kRN1/4PC F562 x 1015621 CONTRAST TABLE for XV-VS800 XV-VS800/DXJN/NC and XR-A9800D/KUCXJ are constructed the same except for the following : Part No. Ref. No.MarkSymbol and DescriptionXR-A9800DXV-VS800Re

15、marks /KUCXJ/DXJN/NC PCB ASSEMBLIES MAIN ASSYXWM3174XWM3172 P5- 1 AF ASSYXWZ3330XWZ3322 COMPLEX ASSYXWM3178AWM7618 P5- 4 PRIMARY ASSYXWZ3332XWZ3326 P7- 1 DISPLAY ASSYXWZ3331AWU7801 PACKING SECTION P3- 1Power CordADG7022ADG1154 P3- 5Remote Control UnitXZN3109XZN3110 P3- 9Front PadXHA3020XHA3030 P3-10

16、Rear PadXHA3021XHA3031 P3-11Packing CaseXHD3144XHD3282 P3-12NSPWarranty CardARY7045Not used P3-14Operating Instructions (English/French)XRE3036Not used Operating Instructions (Thai)Not usedXRC3048 Caution SheetXRH3004Not used EXTERIOR SECTION P5-12 Power Transformer (T1) (AC120V)XTS3042Not used P5-1

17、2 Power Transformer (T1)Not usedXTS3055 (AC110-127V/220-230V/240V) P5-13 Fuse (FU1 : 6.3A)REK1085Not used P5-13 Fuse (FU1 : T5A)Not usedAEK1061 P5-25Rear PanelXNC3065XNC3132 P5-38Tray CapXAK3157XAK3236 Tray Panel DVDNot usedXAK3251For Tray Cap P5-41NSPFuse CardAAX2374Not used P5-42NSPGetterXAX3175XA

18、X3271 P5-4365 LabelARW7050Not used Fuse (FU2, FU3 : T3.15A)Not usedAEK1059*1 NSPName LabelNot usedXAL3102*2 Caution LabelNot usedXRW3003*3 Rear SheetAED7037Not used RadioFans.CN 收音机爱 好者资料库 XV-VS800, XV-VS600 4 Notes : For PCB ASSEMBLIES, Refer to “CONTRAST OF PCB ASSEMBLIES” and “3. SCHEMATIC DIAGRA

19、M”. The numbers in the remarks column correspond to the numbers on the “ FRONT PANEL ASSY ”. *1 Refer to “3. SCHEMATIC DIAGRAM”. *2 Stick Name Label on the Rear Panel. *3 Refer to “LABEL CHECK”. Part No. Ref. No.MarkSymbol and DescriptionXR-A9800DXV-VS800Remarks /KUCXJ/DXJN/NC FRONT PANEL SECTION P7

20、-8GND Plate CXNG3047Not used P7-8GND Plate ANot usedXNG3030 P7-18Volume KnobXAA3013XAA3022 P7-21FUNC Button LXAD3061XAD3118No.8 FUNC Cap LNot usedXAK3247No.7 P7-22FUNC Button RXAD3051XAD3112No.10 FUNC Cap RNot usedXAK3248No.9 P7-23FUNC Frame LXAD3052Not used P7-24FUNC Frame RXAD3053Not used P7-25DVD

21、 ENT ButtonXAD3056XAD3110No.12 P7-26Display PanelXAK3135XAK3315 P7-27EQ PanelXAK3150Not used SC PanelNot usedXAK3268No.26 SC Panel AssyNot usedXXG3090No.13 P7-28JOG LensXAK3152XAK3243No.23 P7-29V LensXAK3153XAK3313 P7-33FL CoverXAK3164XAK3239 P7-34Cover Sheet LXAK3184Not used P7-35Cover Sheet RXAK31

22、85Not used LED BarrierNot usedXEC3022No.24 P7-36Power ButtonXAD3044XAD3102No.17 P7-37CD ButtonXAD3045XAD3104No.19 P7-38SC ButtonXAD3060Not used SC Button LNot usedXAD3105No.29 SC Cap LNot usedXAK3241No.27 SC Button RNot usedXAD3106No.30 SC Cap RNot usedXAK3267No.28 ASES ButtonNot usedXAD3114No.20 Ti

23、mer ButtonNot usedXAD3115No.21 P7-39SC Button LXAD3047Not used Audio ButtonNot usedXAD3107No.14 P7-40SC Button RXAD3049Not used Visual ButtonNot usedXAD3108No.15 P7-41DOLBY ButtonXAD3054XAD3121No.11 P7-42Sub PanelXAK3203XAK3271No.6 P7-43Standby LensXAK3151XAK3240No.18 P7-44Deck Lens LXAK3159XAK3249N

24、o.3 P7-45Deck Lens RXAK3160XAK3250No.5 P7-46JOG ConductorXAK3165XAK3244No.22 P7-47Deck Door_LXAN3022XAN3037No.2 P7-48Deck Door_RXAN3026XAN3038No.4 P7-49Front PanelXMB3027XMB3058No.1 P7-50DV Button LXAD3057Not used P7-51DV Button RXAD3059Not used P7-52NSPFront Panel ASSYXXG3066XXG3117 O/C ButtonNot u

25、sedXAD3103No.16 SpacerXEB3012Not used SpacerXEB3013Not used Cushion SpacerXEB3015Not used Cushion SpacerXEB3016Not used Cushion SpacerXEB3017Not used SpacerXEC3014Not used SpacerXEC3019Not used XV-VS800, XV-VS600 5 XV-VS600/DXJN/NC and XR-A9800D/KUCXJ are constructed the same except for the followin

26、g : CONTRAST TABLE for XV-VS600 Part No. Ref. No.MarkSymbol and DescriptionXR-A9800DXV-VS600Remarks /KUCXJ/DXJN/NC PCB ASSEMBLIES MAIN ASSYXWM3174AWM7605 P5- 1 AF ASSYXWZ3330AWU7789 P5- 2 SECONDARY ASSYXWZ3323XWZ3317 COMPLEX ASSYXWM3178AWM7617 P5- 3 REAR AMP ASSYXWZ3325XWZ3319 P5- 4 PRIMARY ASSYXWZ3

27、332XWZ3320 P7- 1 DISPLAY ASSYXWZ3331AWU7800 PACKING SECTION P3- 1Power CordADG7022ADG1154 P3- 5Remote Control UnitXZN3109XZN3108 P3- 9Front PadXHA3020XHA3030 P3-10Rear PadXHA3021XHA3031 P3-11Packing CaseXHD3144XHD3279 P3-12NSPWarranty CardARY7045Not used P3-14Operating Instructions (English/French)X

28、RE3036Not used Operating Instructions (Thai)Not usedXRC3048 Caution SheetXRH3004Not used EXTERIOR SECTION P5-12 Power Transformer (T1) (AC120V)XTS3042Not used P5-12 Power Transformer (T1)Not usedXTS3039 (AC110-127V/220-230V/240V) P5-13 Fuse (FU1 : 6.3A)REK1085Not used P5-13 Fuse (FU1 : T5A)Not usedA

29、EK1061 P5-15Power BracketXNG3033Not used P5-25Rear PanelXNC3065XNC3129 P5-26SEC HolderXMR3013XMR3014 P5-38Tray CapXAK3157XAK3236 Tray Panel DVDNot usedXAK3251 P5-41NSPFuse CardAAX2374Not used P5-42NSPGetterXAX3175XAX3269 P5-4365 LabelARW7050Not used P5-44NSP$M Mecha. DVD (5ch)XXA3019Not used P5-44NS

30、P$M Mecha. DVD (2ch)Not usedXXA3018 Fuse (FU2, FU3 : T3.15A)Not usedAEK1059*1 NSPName LabelNot usedXAL3100*2 Caution LabelNot usedXRW3003*3 Rear SheetAED7037Not used FRONT PANEL SECTION P7-8GND Plate CXNG3047Not used P7-8GND Plate ANot usedXNG3030 P7-18Volume KnobXAA3013XAA3022 P7-21FUNC Button LXAD

31、3061XAD3118No.8 FUNC Cap LNot usedXAK3247No.7 P7-22FUNC Button RXAD3051XAD3112No.10 FUNC Cap RNot usedXAK3248No.9 P7-23FUNC Frame LXAD3052Not used P7-24FUNC Frame RXAD3053Not used P7-25DVD ENT ButtonXAD3056XAD3110No.12 P7-26Display PanelXAK3135XAK3314 P7-27EQ PanelXAK3150Not used SC PanelNot usedXAK

32、3268No.26 SC Panel AssyNot usedXXG3090No.13 P7-28JOG LensXAK3152XAK3243No.23 XV-VS800, XV-VS600 6 Notes :For PCB ASSEMBLIES, Refer to “PCB PARTS LIST”, “3. SCHEMATIC DIAGRAM” and “4. PCB CONNECTION DIAGRAM”. Part No. Ref. No.MarkSymbol and DescriptionXXA3019XXA3018Remarks (XR-A9800D)(XV-VS600) P5-10

33、CONNECT ASSY (6CH)XWX3023Not used P5-10CONNECT ASSY (2CH)Not usedXWX3019 P5-1425P Flexible CableXDD3046Not used P5-1415P Flexible CableNot usedXDD3049 P5-1830P Flexible CableXDD3044Not used P5-1816P Flexible CableNot usedXDD3043 P5-217P Flexible Cable/30VXDD3053ADD7197 P5-23DVD BaseXNG3034ANG7262 P5

34、-24DVD ShieldXNK3006ANK7097 P5-5521P Flexible CableXDD3052Not used P5-557P Flexible CableNot usedXDD3045 XXA3018 and XXA3019 are constructed the same except for the following : CONTRAST OF $M MECHA. DVD Part No. Ref. No.MarkSymbol and DescriptionXR-A9800DXV-VS600Remarks /KUCXJ/DXJN/NC P7-29V LensXAK

35、3153XAK3313 P7-33FL CoverXAK3164XAK3239 P7-34Cover Sheet LXAK3184Not used P7-35Cover Sheet RXAK3185Not used LED BarrierNot usedXEC3022No.24 P7-36Power ButtonXAD3044XAD3102No.17 P7-37CD ButtonXAD3045XAD3104No.19 P7-38SC ButtonXAD3060Not used SC Button LNot usedXAD3105No.29 SC Cap LNot usedXAK3241No.2

36、7 SC Button RNot usedXAD3106No.30 SC Cap RNot usedXAK3267No.28 ASES ButtonNot usedXAD3114No.20 Timer ButtonNot usedXAD3115No.21 P7-39SC Button LXAD3047Not used Audio ButtonNot usedXAD3107No.14 P7-40SC Button RXAD3049Not used Visual ButtonNot usedXAD3108No.15 P7-41DOLBY ButtonXAD3054XAD3121No.11 P7-4

37、2Sub PanelXAK3203XAK3246No.6 P7-43Standby LensXAK3151XAK3240No.18 P7-44Deck Lens LXAK3159XAK3249No.3 P7-45Deck Lens RXAK3160XAK3250No.5 P7-46JOG ConductorXAK3165XAK3244No.22 P7-47Deck Door_LXAN3022XAN3037No.2 P7-48Deck Door_RXAN3026XAN3038No.4 P7-49Front PanelXMB3027XMB3058No.1 P7-50DV Button LXAD30

38、57Not used P7-51DV Button RXAD3059Not used P7-52NSPFront Panel ASSYXXG3066XXG3113 O/C ButtonNot usedXAD3103No.16 SpacerXEB3012Not used SpacerXEB3013Not used Cushion SpacerXEB3015Not used Cushion SpacerXEB3016Not used Cushion SpacerXEB3017Not used SpacerXEC3014Not used SpacerXEC3019Not used Notes : F

39、or PCB ASSEMBLIES, Refer to “CONTRAST OF PCB ASSEMBLIES” and “3. SCHEMATIC DIAGRAM”. The numbers in the remarks column correspond to the numbers on the “ FRONT PANEL ASSY ”. *1 Refer to “3. SCHEMATIC DIAGRAM”. *2 Stick Name Label on the Rear Panel. *3 Refer to “LABEL CHECK”. XV-VS800, XV-VS600 7 (1)

40、 FRONT PANEL ASSY PARTS LIST Mark No. Description Part No.Mark No. Description Part No. 1Front PanelXMB3058 2Deck Door_LXAN3037 3Deck Lens LXAK3249 4Deck Door_RXAN3038 5Deck Lens RXAK3250 6Sub PanelSee Contrast table (2) 7FUNC Cap LXAK3247 8FUNC Button LXAD3118 9FUNC Cap RXAK3248 10FUNC Button RXAD3

41、112 11DOLBY ButtonXAD3121 12CD ENT ButtonXAD3110 13SC Panel AssyXXG3090 14Audio ButtonXAD3107 15Visual ButtonXAD3108 16O/C ButtonXAD3103 17Power ButtonXAD3102 18Standby LensXAK3240 19CD ButtonXAD3104 20ASES ButtonXAD3114 21Timer ButtonXAD3115 22JOG ConductorXAK3244 23JOG LensXAK3243 24LED BarrierXEC

42、3022 25ScrewBPZ30P080FMC 26SC PanelXAK3268 27SC Cap LXAK3241 28SC Cap RXAK3267 29SC Button LXAD3105 30SC Button RXAD3106 FRONT PANEL ASSY (2) CONTRAST TABLE XV-VS600 and XV-VS800 are constructed the same except for the following : MarkNo.Symbol and Description Part No. Remarks XV-VS800XV-VS600 6Sub

43、PanelXAK3271XAK3246 12 1 13 15 18 17 19 16 24 22 25 21 9 6 10 11 5 4 25 23 14 20 7 8 3 2 27, 29 26 28, 30 13 XV-VS800, XV-VS600 8 AF ASSYFI XWZ3322, AWU7789 and XWZ3330 are constructed the same except for the following : MarkSymbol and Description Part No. Remarks XWZ3330XWZ3322AWU7789 IC3301STK407-

44、070BSTK407-070BSTK407-090B IC3305, IC3306 (5A)AEK7019AEK7019Not used IC3305, IC3306 (7A)Not usedNot usedAEK7021 IC3835Not usedM65847AFPM65847AFP Q3351IRFI9Z34GIRFI9Z34GIRF9540A Q3352IRFIZ34GIRFIZ34GIRF540A Q3803Not used2SD1858X2SD1858X D30021SS1331SS133Not used D3803Not usedMTZJ5.6BMTZJ5.6B F2201, F

45、2202RTF1209XTF3002XTF3002 L3065 CHIP BEADVTL1081VTL1081Not used L3065Not usedNot usedLCTB4R7K1608 C3011, C3012Not usedNot usedCEAT100M50 C3042, C3991CKSRYB103K50CKSRYB103K50Not used C3045, C3046, C3091CEAT100M50CEAT100M50CEAT101M16 C3623, C3624CKSRYB471K50CKSRYB471K50Not used C3625CEAT330M16CEAT330M

46、16Not used C3815Not usedCEAT100M50CEAT100M50 C3816, C3819Not usedCEAT470M16CEAT470M16 C3817Not usedCKSRYB473K16CKSRYB473K16 C3818Not usedCCSRCH101J50CCSRCH101J50 C3828C3830Not usedCKSRYB683K16CKSRYB683K16 C3831Not usedCKSRYB102K50CKSRYB102K50 C3832Not usedCKSRYB122K50CKSRYB122K50 C3833C3836Not usedC

47、KSRYB103K50CKSRYB103K50 C3837Not usedCCSRCH471J50CCSRCH471J50 C3838Not usedCKSRYB472K50CKSRYB472K50 C3839, C3840Not usedCKSRYB224K10CKSRYB224K10 C3842, C3843Not usedCEAT2R2M50CEAT2R2M50 C3858CEAT100M50Not usedNot used C3890Not usedCKSRYB822K50CKSRYB822K50 R3010RS1/16S822JRS1/16S822JRS1/16S472J R3026

48、RD1/4PU822JRD1/4PU822JRD1/4PU472J R3619, R3620RD1/4LMF100JRD1/4LMF100JRD1/2LMF100J R3627RS1/16S471JRS1/16S471JNot used R3831Not usedRD1/4PU102JRD1/4PU102J R3832R3834Not usedRS1/16S102JRS1/16S102J R3835, R3839Not usedRS1/16S682JRS1/16S682J R3836, R3837Not usedRS1/16S472JRS1/16S472J R3838, R3846Not us

49、edRS1/16S153JRS1/16S153J R3840R3842, R3844, R3845Not usedRS1/16S103JRS1/16S103J R3843Not usedRS1/16S562JRS1/16S562J R3855Not usedRS1/16S680JRS1/16S680J CN3601 4P SPEAKER TERMINALAKE7018XKE3004AKE7018 CN3603 9P JUMPER CONNECTORKPE9KPE9Not used CN5104 30P FFC CONNECTORHLEM30R-1HLEM30R-1Not used CN5104 16P FFC CONNECTORNot usedNot usedHLEM16R-1 JA3441 2P PIN JAC