Pioneer-XDJAero-mp-sm 电路图 维修手册.pdf

《Pioneer-XDJAero-mp-sm 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Pioneer-XDJAero-mp-sm 电路图 维修手册.pdf（156页珍藏版）》请在收音机爱好者资料库上搜索。

1、ORDER NO. PIONEER CORPORATION 1-1, Shin-ogura, Saiwai-ku, Kawasaki-shi, Kanagawa 212-0031, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra

2、Road, #04-01, Singapore 159936 PIONEER CORPORATION2012 2012 Printed in Japan XDJ-AERO RRV4321 DJ SYSTEM XDJ-AERO THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S). ModelTypePower RequirementRemarks XDJ-AEROCUXJAC 100 V to 240 V XDJ-AEROSVWYXJ8AC 100 V to 240 V XDJ-AEROLWPWXJAC 100 V to

3、 240 V XDJ-AEROKXJ5AC 100 V to 240 V XDJ-AEROAXJ5AC 100 V to 240 V K-MZV AUG. RadioFans.CN 收音机爱 好者资料库 2XDJ-AERO 1234 A B C D E F 1234 SAFETY INFORMATION WARNING This product may contain a chemical known to the State of California to cause cancer, or birth defects or other reproductive harm. Health i

4、t is not meant for the casual do-it- yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability

5、of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician. 1. SAFETY PRECAUTIONS The following check should be performed for the continued pr

6、otection of the customer and service technician. LEAKAGE CURRENT CHECK Measure leakage current to a known earth ground (water pipe, conduit, etc.) by connecting a leakage current tester such as Simpson Model 229-2 or equivalent between the earth ground and all exposed metal parts of the appliance (i

7、nput/output terminals, screwheads, metal overlays, control shaft, etc.). Plug the AC line cord of the appliance directly into a 120 V AC 60 Hz outlet and turn the AC power switch on. Any current measured must not exceed 0.5 mA. ANY MEASUREMENTS NOT WITHIN THE LIMITS OUTLINED ABOVE ARE INDICATIVE OF

8、A POTENTIAL SHOCK HAZARD AND MUST BE CORRECTED BEFORE RETURNING THE APPLIANCE TO THE CUSTOMER. 2. PRODUCT SAFETY NOTICE Many electrical and mechanical parts in the appliance have special safety related characteristics. These are often not evident from visual inspection nor the protection afforded by

9、 them necessarily can be obtained by using replacement components rated for voltage, wattage, etc. Replacement parts which have these special safety characteristics are identified in this Service Manual. Electrical components having such features are identified by marking with a on the schematics an

10、d on the parts list in this Service Manual. The use of a substitute replacement component which does not have the same safety characteristics as the PIONEER recommended replacement one, shown in the parts list in this Service Manual, may create shock, fire, or other hazards. Product Safety is contin

11、uously under review and new instructions are issued from time to time. For the latest information, always consult the current PIONEER Service Manual. A subscription to, or additional copies of, PIONEER Service Manual may be obtained at a nominal charge from PIONEER. Leakage current tester Reading sh

12、ould not be above 0.5 mA Device under test Test all exposed metal surfaces Also test with plug reversed (Using AC adapter plug as required) Earth ground AC Leakage Test (FOR USA MODEL ONLY) RadioFans.CN 收音机爱 好者资料库 3XDJ-AERO 5678 5678 A B C D E F CONTENTS SAFETY INFORMATION.2 1. SERVICE PRECAUTIONS.5

13、 1.1 NOTES ON SOLDERING.5 1.2 NOTES ON REPLACING .5 1.3 NOTES ON SERVICING.5 2. SPECIFICATIONS.6 3. BASIC ITEMS FOR SERVICE .7 3.1 CHECK POINTS AFTER SERVICING .7 3.2 JIGS LIST.7 3.3 PCB LOCATIONS.8 4. BLOCK DIAGRAM .10 4.1 OVERALL WIRING DIAGRAM .10 4.2 OVERALL BLOCK DIAGRAM (CHASSIS SECTION) .12 4

14、.3 OVERALL BLOCK DIAGRAM (PANEL SECTION).14 4.4 POWER BLOCK DIAGRAM .16 5. DIAGNOSIS .18 5.1 SETUP SEQUENCE.18 5.2 TROUBLESHOOTING.19 5.3 VOLTAGE MONITORING.27 5.4 CONFIMATION OF WIRELESS LAN COMMUNICATION.29 5.5 HOW TO CONFIRM IF PLAYBACK OF MUSIC FILES IS POSSIBLE FROM A PC VIA WIRELESS LAN.30 5.6

15、 CONNECTION CHECK WITH USB .31 5.7 ERROR INDICATION.31 6. SERVICE MODE.32 6.1 TEST MODE.32 6.2 ABOUT THE DEVICE.39 7. DISASSEMBLY .40 8. EACH SETTING AND ADJUSTMENT.48 8.1 NECESSARY ITEMS TO BE NOTED.48 8.2 UPDATING OF THE FIRMWARE.48 8.3 USER SETABLE ITEMS.49 9. EXPLODED VIEWS AND PARTS LIST.50 9.1

16、 PACKING SECTION.50 9.2 CHASSIS SECTION.52 9.3 CONTROL PANEL SECTION (1/2).54 9.4 CONTROL PANEL SECTION (2/2).56 9.5 JOG SECTION .58 10. SCHEMATIC DIAGRAM.60 10.1 MAIN ASSY (1/15).60 10.2 MAIN ASSY (2/15).62 10.3 MAIN ASSY (3/15).64 10.4 MAIN ASSY (4/15).66 10.5 MAIN ASSY (5/15).68 10.6 MAIN ASSY (6

17、/15).70 10.7 MAIN ASSY (7/15).72 10.8 MAIN ASSY (8/15).74 10.9 MAIN ASSY (9/15).76 10.10 MAIN ASSY (10/15).78 10.11 MAIN ASSY (11/15).80 10.12 MAIN ASSY (12/15).82 10.13 MAIN ASSY (13/15).84 10.14 MAIN ASSY (14/15).86 10.15 MAIN ASSY (15/15).88 10.16 JACB ASSY (1/3).90 10.17 JACB ASSY (2/3).92 10.18

18、 JACB ASSY (3/3).94 10.19 HPJK ASSY.96 10.20 USBB ASSY .97 10.21 EUPB ASSY (1/3).98 10.22 EUPB ASSY (2/3).100 10.23 EUPB ASSY (3/3).102 10.24 SUBB ASSY (1/3).104 10.25 SUBB ASSY (2/3).106 RadioFans.CN 收音机爱 好者资料库 4XDJ-AERO 1234 A B C D E F 1234 10.26 SUBB ASSY (3/3) .108 10.27 CCNB1 and CCNB2 ASSYS.110 10.28 BLED1 and BLED2 ASSYS .112 10.29 JOGT1 ASSY.114 10.30 JOGT2 ASSY.