Philips-BDP-5406-Service-Manual(1) 电路图 维修手册.pdf

《Philips-BDP-5406-Service-Manual(1) 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Philips-BDP-5406-Service-Manual(1) 电路图 维修手册.pdf（32页珍藏版）》请在收音机爱好者资料库上搜索。

1、BDP5406/F7 Copyright 2011 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior pe

2、rmission of Philips. Blu-ray Disc Player Version 1.0Version 0.0 Published BG AVM Printed in The Netherlands Subject to modification TABLE OF CONTENTS Chapter Technical Specification, PCBs Location. 1 Safety Instruction 2 Instruction for Use 3 Mechanical and Dismantling Instructions. 4 Service Modes,

3、 Troubleshooting. 5 Overall Block Diagram, Wiring Diagram. 6 Electrical Diagram 7 Exploded View Diagram 5) The software will updagrde and screen will display as below: Upgrade is ongoing, Please wait Please do not unplug or switch off the device. 6) Restart the set. B) Update software via USB Flash

4、Drive: 1) Go to to check if the latest software version is available for this player. 2) Download the software onto a USB flash drives root DIR named UPG_ALL. 3) Insert the USB flash drive to the USB jack of the rear panel. 4) In the Home menu, select -. 5) Then press OK 6) youll see now searching f

5、or new software, please wait. 7) Waiting, the youll see software for this player has been found . 8) Then select Start and press OK 9) then youll see upgrade is ongoing ., wait until it ends. 10) Player will restart automatically or press Restart now to restart, after restarting the upgrade ends. su

6、binfo:xxxx system SW:xxxx ethernet MAC:xxxxxxxx 1-3 2.0 Safety instruction 1. General safety Safety regulations require that during a repair: . Connect the unit to the mains via an isolation transformer. . Replace safety components indicated by the symbol Only by components identical to the original

7、 ones. Any Other component substitution (other than original type) May increase risk of fire or electrical shock hazard. Safety regulations require that after a repair, you must Return the unit in its original condition. Pay, in particular, Attention to the following points: . Route the wires/cables

8、 correctly, and fix them with the mounted cable clamps . Check the insulation of the mains lead for external Damage . Check the electrical DC resistance between the mains Plug and the secondary side: 1) Unplug the mains cord, and connect a wire between The two pins of the mains plug. 2) Set the main

9、s switch the “on” position (keep the Mains cord unplug). 3) Measure the resistance value between the mains plug and the front panel, controls, and chassis bottom. 4) Repair or correct unit when the resistance measurement is less than 1M 5) Verify this, before you return the unit to the customer/user

10、 (ref. UL-standard no. 1492). 6) Switch the unit “off”, and remove the wire between the two pins of the mains plug. 2. Laser safety This unit employs a laser. Only qualified service personnel May remove the cover, or attempt to service this device (due to possible eye injury). Laser device unit Type

11、 :Semiconductor laser GaAIAs Wavelength :650nm (DVD) :780nm (VCD/CD) Output power :7mW(DVD) :10mW(DVD/CD) Beam divergence:60 degree Note: Use of controls or adjustments or performance of procedure other than those specified herein, may result in hazardous radiation exposure. Avoid direct exposure to

12、 beam. 2- 1 3.0 Instruction for Use You can download this information from the following websites: 3-1 4.0 MECHANICAL AND DISMANTLING INSTRUCTIONS The following guidelines show how to dismantle the player. Step1: Remove 3 screws around the Top Cover, and then remove the Top Cover 4- 1 Step3: Remove

13、the 9 screws on board to dismantle the DVD BOARD remove the door from the tray; No display on VFD, and buttons do not work No No No Yes Yes No display on VFD, and buttons do not work Check every supply voltage on main board is normal Refer to Power supply board part Correct connection Replace VU1 or

14、 VFD Yes Go Yes No Check +5V,+12V,-24V voltage on the power and front board SG,GR on the front board 1.Check whether bad solder exists on VU1 and pins of VFD 2.Check whether the circuit connected to K1, K2, K3, K4 is broken. Fix the connection J3 on front board and CN4 on power board Trouble shootin

15、g chart 5-1 Check the signals of the VU1s Check the VU1 power supply (VU1.38= +5V and VU1.27= -24V) No audio output Check whether the audio signal is right from the U1s pin 8, 9 Correct connection Yes Go No audio output No Trouble shooting chart 5-2 exists on pins of J7 Check whether bad solder Repl

16、ace the J7 No Yes Check the U1 power supply (U1.1= +3.3V and U1.11= +5V) Yes Replace the U1 Remote control does not work Go Yes Yes Remote control does not work NO Replace the battery for remote controller Check whether the remote controllers battery is exhausted or not. Check the Power supply board

17、 part Replace IR1 NO Trouble shooting chart 5-3 Check the IR1 power supply is OK Check the connection J2 on front board and J502 on main board is broken Yes Fix the connection NO Yes Cant read disc or cant open the disk door Yes Check the connection of the 9PIN cable from CN3 on the Power Board. Can

18、t read disc or cant open the disk door Check 40pin and 8pin cable from main board connection to the loader is normal Check the U900,U902 and the peripheral components near them on the main board NO GO Check whether the DVD loader running is normal Fix the connection NO Yes Trouble shooting chart 5-4

19、 No VFD display is about AC2.5V Go No No No VFD display Yes Fix the connection power board CN4 and front board J3 Check whether the voltage +5V_STB on the front board is normal Check DC5V to AC2.5V switch circuit Refer to No display on VFD, Yes -24V,+12V and D1 is normal No Check the power board or

20、replace D1 Trouble shooting chart 5-5 Check whether the voltage between VFDs F1 and F2 Check whether the voltage on the front board Yes and buttons do not work OVERALL BLOCK DIAGRAM 6-1 L-OUT COAXIAL MOTOR DRIVER CVBS R-OUT HDMI NAND FLASH DDR3 SDRAM 384M MT8560-BAAG R2A30209SP SANYO TRV414VH8 COLLI

21、MATOR DRIVER AM2158 KQ KT968 128M PWM DRV632 Laser Diode Driver BD7175FS +5v +12v KEY_OPEN VDATA VCLK VSTB IR KEY_POWER USB_VCC USB_DP USB_DM USB_GND GND BL1117-ADJ3.3VSTBY FP90123.3V G5725ADJT11U1.5V 1.2VAT1526P11U +5V(FROM PSU) DLAN IR SENSOR POWER DRIVER TNY177PN VFD 100V-230V +12V_OUT POWER PCB

22、USB_EN# USB_OC# if L,then USB_EN set L; H: enable; L: disable; USB differential impedance 90 OHM Close to Connector 20110428-ASD KUANG 20110428-ASD KUANG change port0-Build WIFI 20110428-ASD KUANG Delet Rear USB jack change port1-Front USB 20100513-ASD KUANG VOUTD6 AVDD12_REC USB_VRT GPIO4 GPIO3 GPI

23、O6 GPIO2 GPIO7 GPIO5 SCL SDA VOUTD4 VOUTD5 VOUTD3 AVDD33_COM USBM0 USBM2 TXVN_1 USBP0 USBP2 TXVP_1 USBM1 USBP1 TXVN_0 TXVP_0 AVDD33_USB REXT NFCEN NFRBN NFALE NFCLE NFREN NFWEN NFD7 NFD1 NFD4 NFD3 NFD0 NFD2 NFD5 NFD6 NFRBN2_R NFCEN2_R SDA SCL AVDD33_LD NFD3 NFD5 NFD2 NFRBN NFWEN NFALE NFWP# NFD4 NFD

24、7 NFD1 NFREN NFD6 NFD0 NFCLE NFCEN GPIO4 GPIO3 GPIO6 GPIO2 GPIO7 GPIO5 NFWEN NFCEN NFALE NFREN NFCLE VOUTD0 VOUTD1 VOUTD2 VOUTD7 VOUTD10 VOUTD11 VOUTD12 VOUTD13 VOUTD14 VOUTD15 VOUTHSYNC VOUTVSYNC VOUTCLK VOUTD9 VOUTD8 TXVP_0 TXVN_1 TXVP_1 TXVN_0 TXVP_0TXVP_0 TXVN_0TXVN_0 TXVP_1TXVP_1 TXVN_1TXVN_1 U

25、SBM0 USBP1 GPIO3 USBM1_VCC USBP0 GPIO5USB_EN0# GPIO7 USBP0 USB_VCC0 USBM1 USBM0 GPIO4USB_OC1# USBM1_VCCUSBM1_VCC USBP1 USBM1USBM1 USBP1 USB_OC0#GPIO6 USB_EN1# GPIO6 GPIO5 USB_VCC0 USBP2 USBM2 USBP0 USBM0 VOUTD36 VOUTD56 VOUTD46 VOUTD66 AMUTE4,7 3.3V 1.2V 3.3V 3.3V 3.3V 3.3V 3.3V 3.3V3.3V 3.3V 3.3V 3

26、.3V 3.3V 3.3V 3.3V 3.3V GND1 USBP1 USBM1 USB_VCC0 VCC NC11 R695.1K_1% C446 0.1uF/6.3V TP52 TP37 +CE6 100uF/10V R42810K/NC R64 10K R71 4.7K R67 10K C103 1uF/16V/X7R R70 24K_1% USBP2 C117 0.1uF/16V/X7R R18 1K R60 10K/NC C115 0.1uF/16V/X7R/NC C118 22uF/6.3V/X5R +C27 10uF/10V F400500mA SMT6.3 R62 10K TP

27、48 R424 1K/NC R66 10K TP51 R614.7K R80R/NC TP57 R97 510R ASD/R_0603 TP56 R59 10K/NC TP35 TP41 USBM1_VCC R430NC L859 TDK ACM2012H- 900- 2P/0 2 41 3 TP45 TP39 C104 10uF/10V/X5R C105 0.1uF/16V/X7R R57 10K/NC USBM2 TVS Arrays D1 NC 1 2 34 5 6 1 2 GNDGND 5 6 U1E MT8551- PBGA AB4 AC5 AC6 AD4 AD5 AD3 AE4 A

28、D6 AE5 AE3 AC3 AE2 AD2 AE1 AC2 AD1 AB3 AC1 C22 AA5 AA4 AB1 AB2 Y6 AA1 AA2 W7 AA3 W4 W1 W2 Y1 Y2 V1 V2 U3 F9 B5 A5 B6 A6 K8 G25 G24 F25 G23 E25 F24 D25 E24 C25 D24 B25 C24 A25 B24 A24 E23 H22 G21 F22 L8 F21 J11 G11 F11 B7 G20 J9 G9 F13 E9 DVCC33_IO DVCC33_IO NFALE NFCEN NFCLE NFRBN NFREN NFWEN NFCEN2

29、 NFRBN2 NFD0 NFD1 NFD2 NFD3 NFD4 NFD5 NFD6 NFD7 GPIO2 GPIO3 GPIO4 GPIO5 GPIO6 GPIO7 SCL SDA EFPWRQ AVDD33_USB AVSS33_USB USB_DP_P0 USB_DM_P0 USB_DP_P1 USB_DM_P1 USB_DP_P2 USB_DM_P2 USB_VRT AVDD33_COM TXVP_0 TXVN_0 TXVP_1 TXVN_1 DVCC33_IO VOUTD0 VOUTD1 VOUTD2 VOUTD3 VOUTD4 VOUTD5 VOUTD6 VOUTD7 VOUTD8

30、 VOUTD9 VOUTD10 VOUTD11 VOUTD12 VOUTD13 VOUTD14 VOUTD15 VOUTHSYNC VOUTVSYNC VOUTCLK DVCC33_IO DVCC33_IO DVCC33_IO AVDD12_REC AVSS12_REC REXT DVCC33_IO DVCC33_IO AVDD33_LD AVSS33_LD AVSS33_PLL RJ-45 P402 TRJ0026GBNL 6 7 3 4 5 8 1 2 10 9 12 11 TP44 FB410 BLM18P ASD/L_0805 L860 TDK ACM2012H- 900- 2P/0

31、2 41 3 TP38 R311K R63 10K USBM0 R6810K R33NC R443NC CB403 0.1uF/10V R56 10K/NC R55 10K/NC TP36 USB_VCC0 TP47 GND1 Q3 SST3904 1 32 NC8 TP54 R4010K R58 10K/NC C114 0.1uF/16V/X7R R10 47K C111 0.1uF/16V/X7R TP46 U8 H27U8G8T2BTR- BC 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 2425 26 27 2

32、8 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 NC NC NC NC NC SE R/B RE CE NC NC VCC VSS NC NC CLE ALE WE WP NC NC NC NC NCNC NC NC NC I/O0 I/O1 I/O2 I/O3 NC NC NC VSS VCC NC NC NC I/O4 I/O5 I/O6 I/O7 NC NC NC NC TP55 TVS Arrays D400 NC 1 2 34 5 6 1 2 GNDGND 5 6 C106 0.1uF/16V/X7R TP4

33、2 C110 1uF/16V/X5R R65 10K R9 4.7K C116 0.1uF/16V/X7R NC9 TP40 C435 0.1uF/6.3V CB401 0.1uF/10V C107 0.1uF/16V/X7R FB4 FB100R/2A ASD/L_0805 USBP0 R72 4.7K C372 0.1uF C109 0.1uF/16V/X7R U402 G5250K1TOU SOT- 23- 5 IC5 4 1 23 5 IN EN GNDOC OUT R422 100K/NC C108 0.1uF/16V/X7R C24 0.1uF/10V TP43 USBM3 NC1

34、0 TP49 Q1 (PMOS)SI2307 1:GND 2:D+ 3:D- 4:VCC 4 2 3 1 J1 USB/TYPEA 2 3 4 1 56 TP53 TP50 USBP3 R3010K R21 4.7K CIRCUIT DIAGRAM-DVD Main Board 7-6 HDMI Port H-Impedance Mode: R660=75 1%,R642=NC. L-Impedance Mode: R660=75 1%,R642=75 1%. Low Impedance Mode GNDGND ROUT1LOUT1COAXOUT PCB板上排列顺序，请参照此图！ CVBS C

35、lose to RCA connector -CORETEK 2011-04-11 -CORETEK 2011-04-11 20100513-ASD KUANG 20100513-ASD KUANG 20100517-ASD KUANG HDMI_SDA HDMI- CEC HTPLG HDMI_SCL F_TXC- CLK_P F_TX1- CH0_P CH0_M CLK_M SPDIF HDMI_VCC NS_XTALI AVDD33_VDAC_R AVDD33_VDAC AVDD33_HDMI NS_XTALO AMUTE AOSDATA2_R SPDIF AR0 AOLRCK_R AO

36、SDATA1_R AOSDATA0_R AOSDATA4_R AOSDATA3_R AL0 VDACR_OUT VDACG_OUT VDACX_OUT VDACB_OUT CLK_P HTPLG CH1_P CEC CH0_P CLK_M CH0_M HDMISD HDMISCK CH1_M CH2_M CH2_P AVDD33_PLLGP AVDD12_HDMI AVDD33_DAC HDMISD HDMISCK CECHDMI- CEC HDMI_SCL HDMI_SDA VDACX_OUT CVBS VDACG_OUT VDACB_OUT VDACR_OUT LOUT1 ROUT1 CO

37、AXOUT CVBS AL0 AR0 AOSDATA2_R F_TX2+ CH2_MF_TX2- CH2_P CH1_P CH1_M COAXOUT SPDIF SPDIF AMUTE5,7 ROUT17 LOUT17 AL07 AR07 DC_EN AOSDATA2_R AOSDATA2_R7 HDMI_VCC 3.3V 1.2V 3.3V 3.3V_STBY 3.3V HDMI_VCC HDMI_VCC VCC HDMI_VCC 3.3V_STBY 3.3V_STBY VCC VIDEO_VCC C9 100pF/NC U1C MT8551- PBGA E16 G14 D16 F14 C1

38、2 C13 A11 B11 A10 B10 C10 D10 C9 C8 D7 C7 A7 U5 B18 C17 C18 A18 C15 D14 E14 A15 B15 A14 B14 A13 B13 A16 B16 C20 A19 B19 B20 C16 D12 E11 AVDD33_VDAC AVSS33_VDAC AVDD33_VDAC_R AVSS33_VDAC_R AVDD33_PLLGP AVSS33_PLLGP NS_XTALI NS_XTALO AL0 AR0 AOLRCK AOSDATA0 AOSDATA1 AOSDATA2 AOSDATA3 AOSDATA4 SPDIF AM

39、UTE VDACX_OUT VDACR_OUT VDACG_OUT VDACB_OUT AVDD12_HDMI_D AVDD33_HDMI AVSS33_HDMI CH0_M CH0_P CH1_M CH1_P CH2_M CH2_P CLK_M CLK_P HTPLG CEC HDMISD HDMISCK AVDD12_HDMI_C AVDD33_DAC AVSS33_DAC C87 33pF/50V/NP0 Q21 NC 1 32 B/U C84 0.1uF/16V/X7R R1890 TP29 R/V NC5 + CE25 NC 12 R42 1.8K D4 ESD0603/SMD/NC

40、 R188100 NC4 R186 NC R41 1M + CE11 100uF/10V C80 0.1uF/16V/X7R TP34 C219 NC TVS Arrays D2 RClamp0524P 1 2 3 4 56 7 8 9 10 1 2 GND 4 56 7 GND 8 10 G/Y C88 0.1uF/16V/X7R C86 33pF/50V/NP0 +CE2 NC ROUT1 R50 0 R46 180_1% R510 NC LOUT1 TP33 TP30 TP32 COAX TVS Arrays D3 RClamp0524P 1 2 3 4 56 7 8 9 10 1 2

41、GND 4 56 7 GND 8 10 R187 NC L400 1.8uH ASD/L_0805 21 NC7 CVBS C91 33pF/50V/NPO C85 0.1uF/16V/X7R R45 1.8K C94 NC TP61 C400 47pF 21 C89 0.1uF/16V/X7R R47 100_1% + CE5 220uF/10v 12 C81 0.1uF/16V/X7R C906 47pF C90 0.1uF/50V/X7R D6 RLS4148 FB101FB600R ASD/L_0402 NC3 Q10 MOSFET N CES2302 1 32 NC6 R507 75

42、/1% R4310 FB102FB600R ASD/L_0402 F1FB600R ASD/L_0603 C82 0.1uF/16V/X7R J14 RCA- AV4 4 2 5 3 6 1 C83 0.1uF/16V/X7R R15947 D5 ESD0603/SMD/NC R185 NC R48 27K Y1 27M_20p_30 R177 NC J2 HDMI_TYPE- A 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 2221 2023 CIRCUIT DIAGRAM-DVD Main Board 7-7 DDR3#2 NEAR DR

43、AM RDQM0_B RDQ9_B RODT_B RDQS1_B RDQM1_B RDQ0_B RRESET_B RDQ12_B RBA1_B RDQ13_B RA5_B RDQ6_B RDQ15_B RDQ5_B RA0_B RCS_B RDQ8_B RDQ10_B RDQ7_B RDQ14_B RDQ11_B RDQ3_B RDQ4_B RDQ2_B RDQ1_B RDQS1_B RDQS0_B RDQS0_B RCAS_B RRAS_B RWE_B RCKE_B RBA0_B RBA2_B RA1_B RA2_B RA3_B RA4_B RA6_B RA7_B RA8_B RA9_B R

44、A10_B RA11_B RA12_B RA13_B RCLK0_B RDQS0_B RRAS_B RDQM0_B E2_ZQ RA12_B RRESET_B RDQS0_B RBA1_B RCS_B RDQS1_B RBA2_B RCAS_B RA7_B RDQS1_B RA4_B RA5_B RA10_B RA13_B RA11_B RCKE_B RDQM1_B RA3_B RBA0_B RA1_B RA2_B RODT_B RCLK0_B RWE_B RA6_B RCLK0_B RA8_B RA9_B RA0_B RCLK0_B RDQ2_B RDQ15_B RDQ4_B RDQ1_B

45、RDQ3_B RDQ5_B RDQ7_B RDQ6_B RDQ0_B RDQ13_B RDQ14_B RDQ12_B RCLK0_B RCLK0_B RDQ11_B RDQ10_B RDQ8_B RDQ9_B RDQS1_B RDQS1_B RDQS0_B RDQS0_B RA2_B RRESET_B RCS_B RDQ12_B RDQ3_B RBA0_B RRAS_B RODT_B RDQ4_B 1.2V1.2V DDR_VREF 1.5V 1.2V DDR_VREF DDR_VREF 1.5V 1.5V 3.3V C59 0.1uF/16V/X7R TP25 C68 0.1uF/16V/X

46、7R/NC TP26 C74 0.1uF/50V/X7R/NC C64 0.1uF/16V/X7R C61 0.1uF/16V/X7R C67 0.1uF/16V/X7R U1B MT8551- PBGA K9 K11 L9 U9 P9 T9 L18 T11 K12 AC12 AC13 AD13 AE13 AD21 AC21 AD20 AC20 AC15 AC16 AB15 AB14 AD18 AE18 AE19 AC19 AB16 AA15 AD16 AE16 AD17 AC17 AD10 Y12 AE11 AE10 AA12 AA6 AE7 AB8 W8 AC11 AC10 Y10 AE8

47、 AB10 AA10 AC8 AA8 AD8 W10 AD7 AB6 W12 Y8 AD22 AE22 T17 N17 K17 N18 K18 P18 AB11 L17 R17 K15 U11 T16 T12 T14 Y18 U12 U14 U15 U16 DVCC12_K DVCC12_K DVCC12_K DVCC12_K DVCC12_K DVCC12_K DVCC12_K DVCC12_K DVCC12_K RDQ0_B RDQ1_B RDQ2_B RDQ3_B RDQ4_B RDQ5_B RDQ6_B RDQ7_B RDQ8_B RDQ9_B RDQ10_B RDQ11_B RDQ1

48、5_B RDQ13_B RDQ14_B RDQ12_B RDQM0_B RDQM1_B RDQS0_B RDQS0_B RDQS1_B RDQS1_B RODT_B RCAS_B RRAS_B RCS_B RWE_B RCKE_B RRESET_B RBA0_B RBA1_B RBA2_B RA0_B RA1_B RA2_B RA3_B RA4_B RA5_B RA6_B RA7_B RA8_B RA9_B RA10_B RA11_B RA12_B RCLK0_B RCLK0_B DVCC12_K DVCC12_K DVCC12_K DVCC12_K DVCC12_K DVCC12_K RA1

49、3_B DVCC12_K DVCC12_K DVCC12_K DVCC12_K DVCC12_K DVCC12_K DVCC12_K RVREF0_B DVCC12_K DVCC12_K DVCC12_K DVCC12_K C71 0.1uF/16V/X7R C75 0.1uF/16V/X7R TP23 C72 0.1uF/16V/X7R/NC R39 100_1% U3 DDR3- 64Mx16 B2 J1 A9 B1 B7 A1 B8 B9 D3 C7 D1 A3 A8 C3 C1 C9 D7 D2 A7 D8 C2 C8 E2 A2 D9 J9 B3 E8 G3 E9 G2 F9 E7 F3 G1 H7 F1 F7 H2 E3 H9 H3 G9