Philips-FWP-3100-Service-Manual(1) 电路图 维修手册.pdf

《Philips-FWP-3100-Service-Manual(1) 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Philips-FWP-3100-Service-Manual(1) 电路图 维修手册.pdf（45页珍藏版）》请在收音机爱好者资料库上搜索。

1、Published by PZ-SL WK1209 BG LE Printed in the NetherlandsSubject to modication 3141 785 37310 FWP3100/05/55 Copyright 2011 Philips Consumer Electronics B.V. Eindhoven, The Netherlands. All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, i

2、n any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Version 1.0 TABLE OF CONTENTS Chapter Technical Specifications . Safety Instructions. Location of PCB Boards . Version Variation . Measurement Setup . Rescue Mode e.g. MCM394/12) b

3、ut which have a different B.O.M. number. Also, it is possible that same model on the market is produced with two production centers, however their partslist is the same. In such case, no alternative B.O.M. will be created. By looking at the third digit of the serial number, one can identify which B.

4、O.M. is used for the set he is working with. If the third digit of the serial number contains the number “1” (example: KX1B033500001), then the set has been manufactured according to B.O.M. number 1. If the third digit is a “2” (example: KX2B0335000001), then the set has been produced according to B

5、.O.M. no. 2. This is important for ordering the correct spare parts! For the third digit, the numbers 1.9 and the characters A.Z can be used, so in total: 9 plus 26= 35 different B.O.M.s can be indicated by the third digit of the serial number. Identification: The bottom line of a type plate gives a

6、 14-digit serial number. Digits 1 and 2 refer to the production centre (e.g. LM is Arts), digit 3 refers to the B.O.M. code, digit 4 refers to the Service version change code, digits 5 and 6 refer to the production year, and digits 7 and 8 refer to production week (in example below it is 2008 week 5

7、0). The 6 last digits contain the serial number. Figure 2-1 Serial number (example) 2.3.6Module Level Repair (MLR) or Component Level Repair (CLR) If a board is defective, consult your repair procedure to decide if the board has to be exchanged or if it should be repaired on component level. If your

8、 repair procedure says the board should be exchanged completely, do not solder on the defective board. Otherwise, it cannot be returned to the O.E.M. supplier for back charging! 2.3.7Practical Service Precautions It makes sense to avoid exposure to electrical shock. While some sources are expected t

9、o have a possible dangerous impact, others of quite high potential are of limited current and are sometimes held in less regard. Always respect voltages. While some may not be dangerous in themselves, they can cause unexpected reactions that are best avoided. Before reaching into a powered TV set, i

10、t is best to test the high voltage insulation. It is easy to do, and is a good service precaution. 2.4Abbreviation List 0/6/12SCART switch control signal on A/V board. 0 = loop through (AUX to TV), 6 = play 16 : 9 format, 12 = play 4 : 3 format 2DNRSpatial (2D) Noise Reduction 3DNRTemporal (3D) Nois

11、e Reduction AARAAutomatic Aspect Ratio Adaptation: algorithm that adapts aspect ratio to remove horizontal black bars; keeps the original aspect ratio ACIAutomatic Channel Installation: algorithm that installs TV channels directly from a cable network by means of a predefined TXT page ADCAnalogue to

12、 Digital Converter AFCAutomatic Frequency Control: control signal used to tune to the correct frequency AGCAutomatic Gain Control: algorithm that controls the video input of the feature box AMAmplitude Modulation ANRAutomatic Noise Reduction: one of the algorithms of Auto TV APAsia Pacific ARAspect

13、Ratio: 4 by 3 or 16 by 9 ASFAuto Screen Fit: algorithm that adapts aspect ratio to remove horizontal black bars without discarding video information ATSCAdvanced Television Systems Committee, the digital TV standard in the USA ATVSee Auto TV Auto TVA hardware and software control system that measure

14、s picture content, and adapts image parameters in a dynamic way AVExternal Audio Video AVCAudio Video Controller AVIPAudio Video Input Processor B/GMonochrome TV system. Sound carrier distance is 5.5 MHz BLRBoard-Level Repair BTSCBroadcast Television Standard Committee. Multiplex FM stereo sound sys

15、tem, originating from the USA and used e.g. in LATAM and AP-NTSC countries B-TXTBlue TeleteXT CCentre channel (audio) CECConsumer Electronics Control bus: remote control bus on HDMI connections CLConstant Level: audio output to connect with an external amplifier CLRComponent Level Repair COLUMBUSCOl

16、or LUMinance Baseband Universal Sub-system ComPairComputer aided rePair CPConnected Planet / Copy Protection CSMCustomer Service Mode CTIColor Transient Improvement: manipulates steepness of chroma transients CVBSComposite Video Blanking and Synchronization DACDigital to Analogue Converter DBEDynami

17、c Bass Enhancement: extra low frequency amplification DDCSee “E-DDC” Model FWM572/12 220-230 50Hz 60W FWM572/12 LM1A0850005644 1 - 5 Safety Instructions, Warnings, Notes, and Abbreviation List D/KMonochrome TV system. Sound carrier distance is 6.5 MHz DFIDynamic Frame Insertion DFUDirections For Use

18、: owners manual DMRDigital Media Reader: card reader DMSDDigital Multi Standard Decoding DNMDigital Natural Motion DNRDigital Noise Reduction: noise reduction feature of the set DRAMDynamic RAM DRMDigital Rights Management DSPDigital Signal Processing DSTDealer Service Tool: special remote control d

19、esigned for service technicians DTCPDigital Transmission Content Protection; A protocol for protecting digital audio/video content that is traversing a high speed serial bus, such as IEEE-1394 DVB-CDigital Video Broadcast - Cable DVB-TDigital Video Broadcast - Terrestrial DVDDigital Versatile Disc D

20、VI(-d)Digital Visual Interface (d= digital only) E-DDCEnhanced Display Data Channel (VESA standard for communication channel and display). Using E-DDC, the video source can read the EDID information form the display. EDIDExtended Display Identification Data (VESA standard) EEPROMElectrically Erasabl

21、e and Programmable Read Only Memory EMIElectro Magnetic Interference EPLDErasable Programmable Logic Device EUEurope EXTEXTernal (source), entering the set by SCART or by cinches (jacks) FBLFast BLanking: DC signal accompanying RGB signals FDSFull Dual Screen (same as FDW) FDWFull Dual Window (same

22、as FDS) FLASHFLASH memory FMField Memory or Frequency Modulation FPGAField-Programmable Gate Array FTVFlat TeleVision Gb/sGiga bits per second G-TXTGreen TeleteXT HH_sync to the module HDHigh Definition HDDHard Disk Drive HDCPHigh-bandwidth Digital Content Protection: A “key” encoded into the HDMI/D

23、VI signal that prevents video data piracy. If a source is HDCP coded and connected via HDMI/DVI without the proper HDCP decoding, the picture is put into a “snow vision” mode or changed to a low resolution. For normal content distribution the source and the display device must be enabled for HDCP “s

24、oftware key” decoding. HDMIHigh Definition Multimedia Interface HPHeadPhone dnuoS.me t s ysVTemorhconoMI carrier distance is 6.0 MHz I2CInter IC bus I2DInter IC Data bus I2SInter IC Sound bus IFIntermediate Frequency InterlacedScan mode where two fields are used to form one frame. Each field contain

25、s half the number of the total amount of lines. The fields are written in “pairs”, causing line flicker. IRInfra Red IRQInterrupt Request ITU-656The ITU Radio communication Sector (ITU-R) is a standards body subcommittee of the International Telecommunication Union relating to radio communication. I

26、TU-656 (a.k.a. SDI), is a digitized video format used for broadcast grade video. Uncompressed digital component or digital composite signals can be used. The SDI signal is self-synchronizing, uses 8 bit or 10 bit data words, and has a maximum data rate of 270 Mbit/s, with a minimum bandwidth of 135

27、MHz. ITVInstitutional TeleVision; TV sets for hotels, hospitals etc. JOPJaguar Output Processor LSLast Status; The settings last chosen by the customer and read and stored in RAM or in the NVM. They are called at start-up of the set to configure it according to the customers preferences LATAMLatin A

28、merica LCDLiquid Crystal Display LEDLight Emitting Diode L/LMonochrome TV system. Sound carrier distance is 6.5 MHz. L is Band I, L is all bands except for Band I LORELOcal REgression approximation noise reduction LPLLG.Philips LCD (supplier) LSLoudspeaker LVDSLow Voltage Differential Signalling Mbp

29、sMega bits per second M/NMonochrome TV system. Sound carrier distance is 4.5 MHz MIPSMicroprocessor without Interlocked Pipeline-Stages; A RISC-based microprocessor MOPMatrix Output Processor MOSFETMetal Oxide Silicon Field Effect Transistor, switching device MPEGMotion Pictures Experts Group MPIFMu

30、lti Platform InterFace MUTEMUTE Line NCNot Connected NICAMNear Instantaneous Compounded Audio Multiplexing. This is a digital sound system, mainly used in Europe. NTCNegative Temperature Coefficient, non-linear resistor NTSCNational Television Standard Committee. Color system mainly used in North Am

31、erica and Japan. Color carrier NTSC M/N= 3.579545 MHz, NTSC 4.43= 4.433619 MHz (this is a VCR norm, it is not transmitted off-air) NVMNon-Volatile Memory: IC containing TV related data such as alignments O/COpen Circuit OSDOn Screen Display OTCOn screen display Teletext and Control; also called Arti

32、stic (SAA5800) P50Project 50: communication protocol between TV and peripherals PALPhase Alternating Line. Color system mainly used in West Europe (color carrier= 4.433619 MHz) and South America (color carrier PAL M= 1 - 6 Safety Instructions, Warnings, Notes, and Abbreviation List 3.575612 MHz and

33、PAL N= 3.582056 MHz) PCBPrinted Circuit Board (same as “PWB”) PCMPulse Code Modulation PDPPlasma Display Panel PFCPower Factor Corrector (or Pre- conditioner) PIPPicture In Picture PLLPhase Locked Loop. Used for e.g. FST tuning systems. The customer can give directly the desired frequency PORPower O

34、n Reset, signal to reset the uP Progressive ScanScan mode where all scan lines are displayed in one frame at the same time, creating a double vertical resolution. PTCPositive Temperature Coefficient, non-linear resistor PWBPrinted Wiring Board (same as “PCB”) PWMPulse Width Modulation QRCQuasi Reson

35、ant Converter QTNRQuality Temporal Noise Reduction QVCPQuality Video Composition Processor RAMRandom Access Memory RGBRed, Green, and Blue. The primary color signals for TV. By mixing levels of R, G, and B, all colors (Y/C) are reproduced. RCRemote Control RC5 / RC6Signal protocol from the remote co

36、ntrol receiver RESETRESET signal ROMRead Only Memory R-TXTRed TeleteXT SAMService Alignment Mode S/CShort Circuit SCARTSyndicat des Constructeurs dAppareils Radiorcepteurs et Tlviseurs SCLSerial Clock I2C SCL-FCLock Signal on Fast I2C bus SDStandard Definition SDASerial Data I2C SDA-FDAta Signal on

37、Fast I2C bus SDISerial Digital Interface, see “ITU-656” SDRAMSynchronous DRAM SECAMSEequence Couleur Avec Mmoire. Color system mainly used in France and East Europe. Color carriers= 4.406250 MHz and 4.250000 MHz SIFSound Intermediate Frequency SMPSSwitched Mode Power Supply SoCSystem on Chip SOGSync

38、 On Green SOPSSelf Oscillating Power Supply S/PDIFSony Philips Digital InterFace SRAMStatic RAM SRPService Reference Protocol SSBSmall Signal Board STBYSTand-BY SVGA800 x600 (4:3) SVHSSuper Video Home System SWSoftware SWANSpatial temporal Weighted Averaging Noise reduction SXGA1280 x1024 TFTThin Fi

39、lm Transistor THDTotal Harmonic Distortion TMDSTransmission Minimized Differential Signalling TXTTeleteXT TXT-DWDual Window with TeleteXT UIUser Interface uPMicroprocessor UXGA1600 x1200 (4:3) VV-sync to the module VCRVideo Cassette Recorder VESAVideo Electronics Standards Association VGA640 x480 (4

40、:3) VLVariable Level out: processed audio output toward external amplifier VSBVestigial Side Band; modulation method WYSIWYRWhat You See Is What You Record: record selection that follows main picture and sound WXGA1280 x768 (15:9) XTALQuartz crystal XGA1024x768 (4:3) YLuminance signal Y/CLuminance (

41、Y) and Chrominance (C) signal YPbPrComponent video. Luminance and scaled color difference signals (B-Y and R-Y) YUVComponent video 1 - 7 ? ? 2-2 MLR+CLR MLR+CLR MLR MLR MLR MLR Measurement Setup ? ? ? ? 2-3 ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? 2-4 ? ? 3- 13 - 1 3 - 23 - 2 ? ? ? ? ? ? ? ? ? ? ? ? ?

42、? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? DISASSEMBLY INSTRUCTIONS 4.1 Dismantling of Main Unit 1)Upward the apparatus as shown in figure1 3) Disconnect the wires in the canbinet as shown in B Figure 1

43、Figure2 Figure3 Dismantling of MIC Board ?6$?,?6?.?:5?2 ;.?:5? ;.?:5?6? :!5:) ;?6= ;?6? /? ? ?85? ?85) :?5=7; ? ?1 ? ?% ? ? ? !* ? ? ? ? ? (? ? ? ? 3? ?!? ?4 ?1? ? ? ? ?= ? *?)? ? *?)?( ? ?8? ? *?)? ? *?)? ? *?)?( ?1 ? ? ? ?2? ?)?)? ?)?)? ?2? ? ?2? ?2? ? ? ? ? ?85? ?85) ? ? ? ? ? ? ? ? ? ?!? ?3?4 ? ?9? 9? 9? ?*? ?#; ?*? ?#; ?*? ?#