Philips-MCM-103-Service-Manual(1) 电路图 维修手册.pdf

《Philips-MCM-103-Service-Manual(1) 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Philips-MCM-103-Service-Manual(1) 电路图 维修手册.pdf（23页珍藏版）》请在收音机爱好者资料库上搜索。

1、Version 1.4 MCM103 3141 785 34454 Micro Hi-Fi System /98/96/93 Published by LX 1125 Service Audio Subject to modification Copyright 2011 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or tr

2、ansmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. CONTENTS Technical specification .1-2 Service measurement setup.1-3 Service aids .1-4 Instructions on CD playability .2-1.2-2 Block diagram.3-1 Wiring diagram.4-1 Disas

3、sembly diagram. .5-1 Main board Circuit diagram .6-1.6-4 Layout diagram.6-5.6-6 Display board Circuit diagram .7-1 Layout diagram.7-2.7-3 AMP board Circuit diagram .8-1 Layout diagram.8-2 Exploded view diagram .9-1 Mechanical parts list.9-2 Electrical parts list.10-1 MCM103B/77/12 RadioFans.CN 收音机爱

4、好者资料库 Rated Output Power2X5W RMS Frequency Response60 - 16kHz, 3dB Signal to Noise Ratio65dB Aux Input0.5 V RMS 20kohm Disc Laser TypeSemiconductor Disc Diameter12cm/8cm Support DiscCD-DA, CD-R, CD-RW, MP3-CD, WMA-CD Audio DAC24Bits / 44.1kHz Total Harmonic Distortion65dBA Tuner Tuning RangeFM: 87.5

5、 - 108 MHz Tuning Grid50 KHz Sensitivity - Mono, 26 dB S/N Ratio 22 dBf Search Selectivity 36 dBu Total Harmonic Distortion 45 dBu Speakers Speaker Impedance4ohm Speaker Driver3.5” Sensitivity82dB/m/W General information AC power110 - 127/220-240 V, 50/60 Hz Operation Power Consumption20 W Standby P

6、ower Consumption 4 W USB DirectVersion 2.0/1.1 Dimensions - Main Unit (W x H x D) - Speaker Box (W x H x D) 150 x 152 x 250 mm 150 x 152 x 197 mm Weight - With Packing - Main Unit - Speaker Box 5.14 kg 2.002 kg 2 x 0.895 kg TECHNICAL SPECIFICATION 1 - 2 Type /Versions: Features Board in used: MCM103

7、 Service policy DISPLAY BOARD MAIN BOARD AMP BOARD * TIPS : C - Component Lever Repair. M - Module Lever Repair - Used /05/96/55 89/21B/ Feature diffrence RDS VOLTAGE SELECTOR ECO STANDBY - DARK C/M Type /Versions: MCM103 /05/96/55 89/16/85/ VERSION VARIATION 39/ 39/ C/M C/M C/M C/M C/M C/M C/M C/M

8、77B/ C/M M C/M C C/M C/M RadioFans.CN 收音机爱 好者资料库 1-3 LF Generator e.g. PM5110 Recorder Use Universal Test Cassette CrO2SBC419 4822 397 30069 LEVEL METER e.g. Sennheiser UPM550 with FF-filter S/N and distortion mete e.g. Sound Technology ST170 L R DUT or Universal Test Cassette FeSBC420 4822 397 3007

9、1 LEVEL METER e.g. Sennheiser UPM550 with FF-filter S/N and distortion meter e.g. Sound Technology ST1700B L R DUT CD Use Audio Signal Disc (replaces test disc 3) SBC429 4822 397 30184 Bandpass 250Hz-15kHz e.g. 7122 707 48001 LF Voltmeter e.g. PM2534 DUT S/N and distortion meter e.g. Sound Technolog

10、y ST1700B Frame aerial e.g. 7122 707 89001 Tuner AM (MW,LW) To avoid atmospheric interference all AM-measurements have to be carried out in a Faradays cage. Use a bandpass filter (or at least a high pass filter with 250Hz) to eliminate hum (50Hz, 100Hz). RF Generator e.g. PM5326 Ri=50? Bandpass 250H

11、z-15kHz e.g. 7122 707 48001 LF Voltmeter e.g. PM2534 DUT RF Generator e.g. PM5326 S/N and distortion meter e.g. Sound Technology ST1700B Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz). Ri=50? Tuner FM MEASUREMENT SETUP RadioFans.CN 收音机爱 好者资料库 1

12、-4 SERVICE AIDS GBWARNING All ICs and many other semi-conductors are susceptible to electrostatic discharges (ESD). Careless handling during repair can reduce life drastically. When repairing, make sure that you are connected with the same potential as the mass of the set via a wrist wrap with resis

13、tance. Keep components and tools also at this potential. ESD CLASS 1 LASER PRODUCT GB Safety regulations require that the set be restored to its original condition and that parts which are identical with those specified, be used Safety components are marked by the symbol !. Lead free Set remains clo

14、sed! N Y Play a CD for at least 10 minutes Y playability ok ? N playability ok ? add Info for customer SET OK check playability N Y playability ok ? check playability check playability return set Customer complaint CD related problem fast lens cleaning 1 2 3 For flap loaders (= access to CD drive po

15、ssible) cleaning method 4 is recommended INSTRUCTIONS ON CD PLAYABILITY 2 - 1 Exchange CDM 1- 4 For description - see following pages 1 PLAYABILITY CHECK For sets which are compatible with CD-RW discs use CD-RW Printed Audio Disc.7104 099 96611 TR 3 (Fingerprint) TR 8 (600 Black dot) maximum at 01:0

16、0 playback of these two tracks without audible disturbance playing time for: Fingerprint10seconds Black dot from 00:50 to 01:10 jump forward/backward (search) within a reasonable time For all other sets use CD-DA SBC 444A.4822 397 30245 TR 14 (600 Black dot) maximum at 01:15 TR 19 (Fingerprint) TR 1

17、0 (1000 wedge) playback of all these tracks without audible disturbance playing time for: 1000 wedge10seconds Fingerprint10seconds Black dot from 01:05 to 01:25 jump forward/backward (search) within a reasonable time 2 CUSTOMER INFORMATION It is proposed to add an addendum sheet to the set which inf

18、orms the customer that the set has been checked carefully - but no fault was found. The problem was obviously caused by a scratched, dirty or copy-protected CD. In case problems remain, the customer is requested to contact the workshop directly. The lens cleaning (method 3) should be mentioned in th

19、e addendum sheet. The final wording in national language as well as the printing is under responsibility of the Regional Service Organizations. 4 LIQUID LENS CLEANING Because the material of the lens is synthetic and coated with a special anti-reflectivity layer, cleaning must be done with a non-agg

20、ressive cleaning fluid. It is advised to use “Cleaning Solvent The actuator is a very precise mechanical component and may not be damaged in order to guarantee its full function. Clean the lens gently (dont press too hard) with a soft and clean cotton bud moistened with the special lens cleaner. The

21、 direction of cleaning must be in the way as indicated in the picture below. Before touching the lens it is advised to clean the surface of the lens by blowing clean air over it. This to avoid that little particles make scratches on the lens. INSTRUCTIONS ON CD PLAYABILITY 2 - 2 BLOCK DIAGRAM 3-13-1

22、 WIRING DIAGRAM 4-14-1 DISPLAY BOARD CON9 REM1 D23 CON12 CON13 CON11 CON14 J5 J701 CON3 J12 CON4 CON8 CON201 CON108 J702 CON5 CON2 CON7 CON1 POWER/ AMP BOARD CON6JACK1 SPEAKER JACK BOARD MAIN BOARD CON10 JK1 JK2 CDM (SANYO DA11B3VZ) SPEAKER JACK ? ? ? ? ? ? ? ? ? ? ? ? ? ? ? CIRCUIT DIAGRAM - MAIN B

23、OARD PART1 6-16-1 CIRCUIT DIAGRAM - MAIN BOARD PART2 6-26-2 CIRCUIT DIAGRAM - MAIN BOARD PART3 6-36-3 CIRCUIT DIAGRAM - MAIN BOARD PART4 6-46-4 LAYOUT DIAGRAM - MAIN BOARD TOP SIDE 6-56-5 LAYOUT DIAGRAM - MAIN BOARD BOTTOM SIDE 6-66-6 CIRCUIT DIAGRAM - DISPLAY BOARD 7-17-1 LAYOUT DIAGRAM - DISPLAY B

24、OARD TOP SIDE 7-27-2 LAYOUT DIAGRAM - DISPLAY BOARD BOTTOM SIDE 7-37-3 CIRCUIT DIAGRAM - AMP BOARD 8-18-1 LAYOUT DIAGRAM - POWER BOARD 8-28-2 SET EXPLODED VIEW DIAGRAM 9-19-1 9 - 2 MECHANICAL PARTSLIST(not for -B/77) 080996510026711CD MECHANISM 111994000005401CD DOOR SPRING 201996510029295BOTTOM CAB

25、(-/98/96) 202996510029321FRONT PANEL 203996510029293BACK CABINET 205996510029071PANEL FIXER 207996500039790FM PIG TAIL HOUSING 208996500039334CD DOOR(WHITE) (only for -/98) 208996510029752CD DOOR (only for -/96/93) 209994000005406CD GEAR 210994000005407CD GEAR BRACKET 211996510029319PANEL BUTTONS 21

26、2996510029301POWER BUTTONS 213996510029022DISPLAY LENS (only for -/98) 213996510029754DISPLAY LENS (only for -/96/93) 214996500039338IR LENS(WHITE) 216996510029298TRIM RING 5601994000004392LASER COVER (FOR SANYO CD) FFC19965100292887P FFC 1mm L=180mm FFC299651002929616P FFC 1mm L=220mm J001996510002

27、14016P FLEX CABLE 1mm (MAIN-CDM) J008996510018969FM ANT L=1.5M J011! 996510029287AC SOCKET R-201A(B00) BLACK S001994000002354CD DOOR SWITCH DLS-02-W-1 S002994000004376SWITCH SL14-22AH-5AN TR01! 996510029299TRANSFO VDE EI57 127/240V(-/96/98) 0001996510029753PCBA-MAIN MCM103/96 0001996510029297PCBA-MA

28、INMCM103/98 0002996510029756PCBA-DISPLAY/KEY (only for -/96)0002996510029756PCBA-DISPLAY/KEY (only for -/96) 0002996510029285PCBA-DISPLAY/KEY (only for -/98) 0003996510029294PCBA-AMP(-/98/96) ACCESSORIES SPK996510029292SPK BOX PART (SINGLE L/R) RC01996510029289REMOTE CONTROL J010996510000428CONNECT

29、CORD 3.5mmST/PLUGx2 J007! 996510029291AC CORD SET VDE APP 6FT (only for -/98) J007! 996510029755AC CORD SET CNS APP 2M (only for -/96) Note:Only these parts mentioned in the list are normal service parts. 201996510037695BOTTOM CAB(-/93) 0003996510037701PCBA-AMP(-/93) 0002996530037697PCBA-DISPLAY/KEY

30、 (only for -/93) 0001996510037698PCBA-MAINMCM103/93 TR01! 996510037696TRANSFO UP57 220V(-/93) 0650 996510037707GIFT BOX(-/93) 0651 996510034447CARTON BOX (2SET)(-/93) 0652 996510037694PAPER PULP -TOP(-/93) 0653 996510037702PAPER PULP -BOTTOM(-/93) 0654 996510037705E.P.E BAG 14X17(-/93) 0655 99651003

31、6648GUARANTEE BOOKLET(-/93) 0001N996510041639PCBA-MAIN (LM1B1040030096 onwards)CBA-MAINMCM103/96 0003N996510041651PCBA-AMP(LM1B1040030096 onwards) (-/96) 0001N996510041645PCBA-MAIN (LM1B1040021342 onwards)CBA-MAINMCM103/98 0003N996510041646PCBA-AMP(LM1B1040021342 onwards) (-/98) 0001N996510041708PCB

32、A-MAIN (LM1A1040025967 onwards)CBA-MAINMCM103B/12” 0003N996510041707PCBA-AMP(LM1A1040025967 onwards) MCM103B/12” ELECTRICAL PARTSLIST(not for -B/77) MAIN BOARD ASSEMBLY C4994000001346E.CAP 4700UF 25V -20% F401! 994000001222FUSE RADIAL LT 2A 250V IC2996510025073IC TC94A77FG-612 -SMD IC301996510018861

33、IC SI4702 IC701996510014303IC UE2314 IC702994000002838IC BA15BC0FP IC703994000002839IC LM1117S-3.3 IC705996510009408IC MM1669AH IC707996510009407IC BR24L32F-W Q3994000002839IC LM1117S-3.3 Q407996510020216TRANSISTORS D882F U1996510029286IC UTC7805G U2996510018852IC UTC7808 U3994000002839IC LM1117S-3.

34、3 U5996510018761FLASH IC SST39VF020 U708996520033295IC OTI6889 (LQFP-128) X301996510012559CRYSTAL 32.768KHZ X701994000004551CRYSTAL 16.9344MHZ +-20PPM X703996510008326CRYSTAL 12 MHzHC-49/US H=3.5mm DISPLAY BOARD ASSEMBLY CON713996510000344USB SOCKET D3994000005385LED LAMP (WHITE) D4994000001965LED L

35、AMP 3MM (RED) D5994000005385LED LAMP (WHITE) IC1996510029302MCU IC(GENNY) GY683 IC103994000002839IC LM1117S-3 3IC103994000002839IC LM1117S-3.3 IC104996510002114 IC BR24C02F-WE2 JK1994000005394V/PHONE JACK JK2994000005394V/PHONE JACK LCD2996510029074LCD DISPLAY SDM8A5788A-HPTNN REM2996510009320OPTIC

36、SENSER FM-6038TN2-5AN SW1996500042444TACT SWITCH 6x6mm 4.3mm SW10996500042444TACT SWITCH 6x6mm 4.3mm SW2996500042444TACT SWITCH 6x6mm 4.3mm SW3996500042444TACT SWITCH 6x6mm 4.3mm SW4996500042444TACT SWITCH 6x6mm 4.3mm SW5996500042444TACT SWITCH 6x6mm 4.3mm SW6996500042444TACT SWITCH 6x6mm 4.3mm SW79

37、96500042444TACT SWITCH 6x6mm 4.3mm SW8996500042444TACT SWITCH 6x6mm 4.3mm SW9996500042444TACT SWITCH 6x6mm 4.3mm XT1994000004451CRYSTAL 8.000MHZ +-20PPM XT2996510012559CRYSTAL 32.768KHZ AMP BOARD ASSEMBLY C113994000001346E.CAP 4700UF 25V -20% F102! 994000004599FUSE RADIAL T3.15A 250V IC101996510000882IC TFA9842BJ JACK101994000003661SPK JACK PT-22V11 Note:Only these parts mentioned in the list are normal service parts. 10 - 1