《Philips-MCM-159-Service-Manual(1) 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Philips-MCM-159-Service-Manual(1) 电路图 维修手册.pdf（28页珍藏版）》请在收音机爱好者资料库上搜索。
1、 MCM159/61/98 Copyright 2008 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior
2、 permission of Philips. Published by SL 0830 Service Audio Printed in The Netherlands Subject to modification Micro System Version 1.1 CLASS 1 LASER PRODUCT 3141 785 32951 TABLE OF CONTENTS Page Location of PCBs & Version Variations.1-2 Specifi cations .1-3 Measurement Setup .1-4 Service Aids, Safet
3、y Instruction, etc .1-5 CD Playability Check .1-6 to 1-7 Software Version Checking .2 Set Block Diagram .3 Set Wiring Diagram .4 Main Board .5 Front Board.6 Cass Board .7 Set Mechanical Exploded View & Parts List .8 Electrical Parts List .9 Revision List .10 RadioFans.CN 收音机爱 好者资料库 PCBS LOCATION FRO
4、NT BOARD MAIN BOARDCASS BOARD 1-2 /12 /61 n iRDC/n ixuA Line Out Video Out Headphone Out Digital Out Karaoke Features Voltage Selector ECO Power Standby (LCD Display Off) USB Direct Type /Versions: Features in used: /05 VERSION VARIATIONS Type /Versions: Board in used: MCM159 Service policy MAIN BOA
5、RD CASS BOARD FRONT BOARD * TIPS : C - Component Lever Repair. M - Module Lever Repair - Used C /12 /058595/16/85/ Feature diffrence C x C x MCM159 x RadioFans.CN 收音机爱 好者资料库 1-3 AMPLIFIER Output power .2 x 2W RMS Signal-to-noise ratio. ? 60 dBA (IEC) Frequency response . 125 16000 Hz Impedance louds
6、peakers .8? CD PLAYER Frequency range . 125 16000 Hz Signal-to-noise ratio. 65 dBA TUNER FM wave range .87.5 108 MHz MW wave range.531 1602 kHz Sensitivity FM 26 dB sensitivity . 20 V MW 26 dB sensitivity .5 mV/m Total harmonic distortion. ? 5% TAPE DECK Frequency response Normal tape (type I).125 8
7、000 Hz (8 dB) Signal-to-noise ratio Normal tape (type I). 40 dBA Wow and flutter. ? 0.4% JIS SPEAKERS Bass reflex system Dimensions (w x h x d) .134 x 230 x 152 (mm) GENERAL INFORMATION AC Power. 110 127 / 220 240 V . 50/60 Hz, switchable Dimensions (w x h x d) .148 x 233 x 216 (mm) Weight (with/wit
8、hout speakers) . . approx. 3.65 / 1.53 kg Power consumption Active . 15 W Standby . 4 W Specifications and external appearance are subject to change without notice. SPECIFICATIONS RadioFans.CN 收音机爱 好者资料库 LF Generator e.g. PM5110 Recorder Use Universal Test Cassette CrO2SBC419 4822 397 30069 LEVEL ME
9、TER e.g. Sennheiser UPM550 with FF-filter S/N and distortion meter e.g. Sound Technology ST1700B L R DUT or Universal Test Cassette FeSBC420 4822 397 30071 LEVEL METER e.g. Sennheiser UPM550 with FF-filter S/N and distortion meter e.g. Sound Technology ST1700B L R DUT CD Use Audio Signal Disc (repla
10、ces test disc 3) SBC429 4822 397 30184 Bandpass 250Hz-15kHz e.g. 7122 707 48001 LF Voltmeter e.g. PM2534 DUT S/N and distortion meter e.g. Sound Technology ST1700B Frame aerial e.g. 7122 707 89001 Tuner AM (MW,LW) To avoid atmospheric interference all AM-measurements have to be carried out in a Fara
11、days cage. Use a bandpass filter (or at least a high pass filter with 250Hz) to eliminate hum (50Hz, 100Hz). RF Generator e.g. PM5326 Ri=50 Bandpass 250Hz-15kHz e.g. 7122 707 48001 LF Voltmeter e.g. PM2534 DUT RF Generator e.g. PM5326 S/N and distortion meter e.g. Sound Technology ST1700B Use a band
12、pass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz). Ri=50 Tuner FM MEASUREMENT SETUP 1-4 1-5 Service Tools: Universal Torx driver holder .4822 395 91019 Torx bit T10 150mm .4822 395 50456 Torx driver set T6-T20 .4822 395 50145 Torx driver T10 extended .4822
13、395 50423 Compact Disc: SBC426/426A Test disc 5 + 5A .4822 397 30096 SBC442 Audio Burn-in test disc 1kHz .4822 397 30155 SBC429 Audio Signals disc .4822 397 30184 Dolby Pro-logic Test Disc .4822 395 10216 SERVICE AIDS GBWARNING All ICs and many other semi-conductors are susceptible to electrostatic
14、discharges (ESD). Careless handling during repair can reduce life drastically. When repairing, make sure that you are connected with the same potential as the mass of the set via a wrist wrap with resistance. Keep components and tools also at this potential. ESD CLASS 1 LASER PRODUCT GB Safety regul
15、ations require that the set be restored to its original condition and that parts which are identical with those specified, be used Safety components are marked by the symbol !. Lead free Set remains closed! Standard repair procedure N Y Play a CD for at least 10 minutes Y playability ok ? N playabil
16、ity ok ? add Info for customer SET OK playability ok ? Y N check playability N Y playability ok ? check playability check playability EYE-Pattern ok ? N Y check EYE-Pattern replace CD Drive Laser current ok ? N Y check Laser current CD Drive offsets ok ? NY check CD Drive offsets clean the lens chec
17、k playability return set Customer complaint CD related problem return set return set replace CD Drive return set replace CD Drive return set replace Signal Processor return set fast lens cleaning 1 2 3 4 5 6 7 For flap loaders (= access to CD drive possible) cleaning method 4 is recommended 1 - 7 Fo
18、r description - see following pages INSTRUCTIONS ON CD PLAYABILITY 1-6 1 PLAYABILITY CHECK For sets which are compatible with CD-RW discs use CD-RW Printed Audio Disc.7104 099 96611 TR 3 (Fingerprint) TR 8 (600 Black dot) maximum at 01:00 playback of these two tracks without audible disturbance play
19、ing time for: Fingerprint 10seconds Black dot from 00:50 to 01:10 jump forward/backward (search) within a reasonable time For all other sets use CD-DA SBC 444A.4822 397 30245 TR 14 (600 Black dot) maximum at 01:15 TR 19 (Fingerprint) TR 10 (1000 wedge) playback of all these tracks without audible di
20、sturbance playing time for: 1000 wedge 10seconds Fingerprint 10seconds Black dot from 01:05 to 01:25 jump forward/backward (search) within a reasonable time 2 CUSTOMER INFORMATION It is proposed to add an addendum sheet to the set which informs the customer that the set has been checked carefully -
21、but no fault was found. The problem was obviously caused by a scratched, dirty or copy-protected CD. In case problems remain, the customer is requested to contact the workshop directly. The lens cleaning (method 3) should be mentioned in the addendum sheet. The final wording in national language as
22、well as the printing is under responsibility of the Regional Service Organizations. 3 FAST LENS CLEANING (dry brush) Use lens cleaning CD SBC AC300.9082 100 00043 Insert the lens cleaning CD, press PLAY and follow the voice guides instructions on the CD. 4 LIQUID LENS CLEANING Because the material o
23、f the lens is synthetic and coated with a special anti-reflectivity layer, cleaning must be done with a non-aggressive cleaning fluid. It is advised to use “Cleaning Solvent B4-No2”, available with codenumber 4822 389 10026. The actuator is a very precise mechanical component and may not be damaged
24、in order to guarantee its full function. Clean the lens gently (dont press too hard) with a soft and clean cotton bud moistened with the special lens cleaner. The direction of cleaning must be in the way as indicated in the picture below. Before touching the lens it is advised to clean the surface o
25、f the lens by blowing clean air over it. This to avoid that little particles make scratches on the lens. INSTRUCTIONS ON CD PLAYABILITY 1-7 2-12-1 To hold DBB & SKIP NEXT depressed SOFTWARE VERSION CHECKING Set on Standby. Y N Y N Button pressed? 9 Button pressed? DISPLAY TEST Display shows all patt
26、erns SKIP NEXT Display shows NEW SOFTWARE RESET VER refers to Version y.yy refers to Software version number of the uProcessor (counting up from 01 to 99) xx refers to date number of the production. Display shows the MCU software version VER y.yy MTP xx-xx-2007 3-13-1 SET BLOCK DIAGRAM FRONT SET WIR
27、ING DIAGRAM 4-14-1 MAIN BOARD TABLE OF CONTENTS Layout Top View .5-2 Layout Bottom View .5-3 Circuit Diagram (AF&Amp Part) .5-4 Circuit Diagram (CD&MP3 Part) .5-5 Circuit Diagram (Tuner Part) .5-6 5-15-1 5-25-2 PCB LAYOUT - MAIN BOARD (TOP VIEW) 5-35-3 PCB LAYOUT - MAIN BOARD (BOTTOM VIEW) 5-4 5-4 C
28、IRCUIT DIAGRAM - MAIN & POWER BOARD AF & AMP PART 5-5 5-5 CIRCUIT DIAGRAM - MAIN BOARD CD & MP3 PART 5-65-6 CIRCUIT DIAGRAM - MAIN BOARD TUNER PART FRONT BOARD TABLE OF CONTENTS Layout Top View .6-2 Layout Bottom View .6-3 Circuit Diagram .6-4 6-16-1 6-2 PCB LAYOUT - FRONT BOARD (TOP VIEW) 6-2 6-3 P
29、CB LAYOUT - FRONT BOARD (BOTTOM VIEW) 6-3 6-4 CIRCUIT DIAGRAM - FRONT BOARD 6-4 CASSETTE BOARD TABLE OF CONTENTS Layout Top View .7-2 Layout Bottom View .7-2 Circuit Diagram .7-3 7-17-1 7-2 PCB LAYOUT - CASSETTE BOARD (TOP VIEW) 7-2 PCB LAYOUT - CASSETTE BOARD (BOTTOM VIEW) 7-37-3 CIRCUIT DIAGRAM -
30、CASSETTE BOARD SET MECHANICAL EXPLODED VIEW 8-18-1 MECHANICAL & ACCESSORIES PARTS LIST 5996520032155PCBA-CASS DECK J001996500042448CLOSE END WIRE CONNECTOR 6996510006668REMOTE CONTROLJ0029965100066527P FFC 1MM L=150MM (AB) 80996510006840CASS DECK JS-21FB8923-SGSJ00399400000448716P FFC L=170MM 819940
31、00005398CD MECHANISM DA11B3VFJ00499651000860817P FFC 1.25mmL=100mm 114994000003674CD DOOR SPRINGJ010!996510007312AC CORD KS APP 1.92M /61 115996510000917CASS SPRINGJ010!996510000909AC CORD VDE APP 2M /98 116996510000918CASSETTE KEY COVER SPRINGJ011996510000910FM ANT SMF-01T-1.3 L=1.1M 20199651001684
32、5FRONT CABINET /61S001996510016844SINGLE SPK BOX L/R /61 201996510018593FRONT CABINET /98S001996510018592SINGLE SPK BOX L/R /98 202996510016846REAR CABINET /61T001!996510006839TRASFO. EI48 230V /61 202996510018594REAR CABINET /98T001!996510007311TRASFO. EI48 127/240V /98 203996510016847CD TRAY /61 2
33、03996510018595CD TRAY /98 204996510016848AC CORD BRACKET 205996510016849CASSETTE DOOR /61 205996510018596CASSETTE DOOR /98 206996510016850CD DOOR /61 206996510018597CD DOOR /98 208996510016851SOURCE BUTTON COVER /61 208996510018601SOURCE BUTTON COVER /98 209996510016852DBB BUTTON COVER /61 209996510
34、018603DBB BUTTON COVER /98 210996510016853PLAY BUTTON COVER /61 210996510018602PLAY BUTTON COVER /98 211996510016854STOP BUTTON COVER /61 211996510018604STOP BUTTON COVER /98 212996510016855CASS KEY DOOR /61 212996510018598CASS KEY DOOR /98 213996510016856VOL COSMETI COVER /61 213996510018599VOL COS
35、METI COVER /98 214996510016857VOL BUTTON COVER /61 214996510018600VOL BUTTON COVER /98 215994000001295DAMPER GEAR ASSY 216996510016858POWER BUTTON /61 216996510018605POWER BUTTON /98 217996510016859PRESET BUTTON /61 217996510018606PRESET BUTTON /98 218996510016860MODE PROG BUTTON /61 218996510018607
36、MODE PROG BUTTON /98 219996510016861CASS KEY WITH HOLDER /61 219996510018608CASS KEY WITH HOLDER /98Note: Only these parts mentioned in the list are 220996510016862DISPLAY LENS /61 normal service parts. 220996510018609DISPLAY LENS /98 8-2 ELECTRICAL PARTS LIST - MAIN BOARD C220994000004351TRIMMER 20
37、PF (RED)U11996510000881IC TB2132FNG C225994000004351TRIMMER 20PF (RED)U2994000000253IC (SAMSUNG) KA7808 C236994000000254TRIMMER 10PF 6MM (WH)U33996510000880IC LM78L08 CF2994000003642CER. FILTER LT10.7MA5-A REDU801996510006679IC (SANYO) LC786921W-UPHI-E CF5996510006680CER. FILTER SFU450BX699400000435
38、2CRYSTAL 75KHZ 12.5PF DT-381 CF6994000004353DISC. FILTER JT10.7MG77-AX801994000004551CRYSTAL 16,9344MHZ -20PPM CON3996510005450SPK JACK PT-22V11A D52994000002836VARICAP DIODE 1SV-149 D53996510000879VARACTOR DIODE SVC201SPA D54996510000879VARACTOR DIODE SVC201SPA D55994000002836VARICAP DIODE 1SV-149
39、D6994000003938RECTIFIER DIODE RL-202 D7994000003938RECTIFIER DIODE RL-202 D8994000003938RECTIFIER DIODE RL-202 D9994000003938RECTIFIER DIODE RL-202 F1!994000000586GLASS FUSE W/LEAD 3.15A/250V Note: Only these parts mentioned in the list are FMANT1 996510002038FM ANT CONTACT PIN normal service parts.
40、 IC2996500039806IC ET2314 (SOP28) IC802994000004622IC LA6548NH JACK1994000004369PHONE JACK TC38-063-05-01 JACK2996510000889PHONE JACK TC38-060-01 RING L28996510000887FM COIL 3x19.5T L29996510000888FM COIL 5x3.5T L31996500039350FM COIL 4.5X2.5T (0.8MM) L32996510000888FM COIL 5x3.5T Q10996500038609TRA
41、NSISTORS 2W 8050C Q11994000001193TRANSISTORS KSB772YS Q12994000004338SMD TRANSISTORS PMBT3904 Q17994000004338SMD TRANSISTORS PMBT3904 Q18994000004338SMD TRANSISTORS PMBT3904 Q2994000004338SMD TRANSISTORS PMBT3904 Q22994000001193TRANSISTORS KSB772YS Q24996500038609TRANSISTORS 2W 8050C Q25994000004338SMD TRANSISTORS PMBT3904 Q399
免费区 
