《Sony-CDPEX100-cd-sm 电路图 维修手册.pdf》由会员分享,可在线阅读,更多相关《Sony-CDPEX100-cd-sm 电路图 维修手册.pdf(23页珍藏版)》请在收音机爱好者资料库上搜索。
1、 1 CDP-EX100 SERVICE MANUAL AEP Model UK Model E Model Model Name Using Similar MechanismCDP-EX10 CD Mechanism TypeCDM28-5BD19 Base Unit NameBU-5BD19 SPECIFICATIONS COMPACT DISC PLAYER MICROFILM This set is the CD player section in MHC-EX50/EX70AV/EX100AV. RadioFans.CN 收音机爱 好者资料库 2 The laser compone
2、nt in this product is capable of emitting radiation exceeding the limit for Class 1. The following caution label is located inside of the unit. SAFETY-RELATED COMPONENT WARNING! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO
3、 SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. TABLE OF CONTENTS 1. SERVICE NOTE. 3 2. GENERAL. 4 3. DISASSEMBLY 3-1. Loading Panel. 4 3-2. MD Block. 5 3-3. Holder (BU) Assy. 5 4. ELECTRICAL ADJUSTMENTS
4、. 6 5. DIAGRAMS 5-1. IC Pin Function . 8 5-2. Circuit Boards Location . 10 5-3. Printed Wiring Board BD Section . 11 5-4. Schematic Diagram BD Section . 13 5-5. Printed Wiring Boards Main Section . 16 5-6. Schematic Diagram Main Section . 19 6. EXPLODED VIEWS 6-1. Chassis Section. 26 6-2. Front Pane
5、l Section . 27 6-3. CD Mechanism Section. 28 6-4. Base Unit Section. 29 7. ELECTRICAL PARTS LIST. 30 This appliance is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT MARKING is located on the rear exterior. CAUTION Use of controls or adjustments or performance of proce- dures other
6、 than those specified herein may result in haz- ardous radiation exposure. Notes on Chip Component Replacement Never reuse a disconnected chip component. Notice that the minus side of a tantalum capacitor may be dam- aged by heat. NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT The laser di
7、ode in the optical pick-up block may suffer electrostatic breakdown because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic breakdown and also use the procedure in the printed matter which is
8、included in the repair parts. The flexible board is easily damaged and should be handled with care. NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pick-up block. Therefore, when
9、checking the laser diode emission, observe from more than 30 cm away from the objective lens. RadioFans.CN 收音机爱 好者资料库 3 FL tube/ KEY check mode After to enter the power on, when p button, TIME button and ) button are pressed at the same time, you will be check FL tube. Whenever press the above menti
10、oned three buttons at the same time, change to check mode of FL tube. Under check mode of FL tube when any pressing button or turn = AMS + button, change to KEY check mode. To finish KEY check mode, press the above mentioned three buttons at the same time. All FL tube indicator light on A segment pa
11、ttern mode 1 A segment pattern mode 2 Finish the test mode Note 1) All FL tube light on mode is kept when three buttons which is pressed to enter all FL tube light on mode, release at the same time. If you will be release failure them, it is moved to KEY check mode after all FL tube light on mode. N
12、ote 2) Under KEY check mode, every time and button pressed or = AMS + button turned on, figure on “ KEY= ” of FL tube is increased. How to operate with a single unit Normally this set does not operate with a single unit. When you must be mending, connect to other unit. If the SYSTEM POWER switch of
13、the amplifire is set to ON, the power supply of the set is turned on. In case of other unit is nothing, the service box (PFJ-1) and exclusive jig (J-2501-078-A) are necessary to operate the set with a single unit. In case of above mentioned, press the p button and TIME button at the same time, to en
14、ter the power on. SECTION 1 SERVICE NOTE nnn (Press three buttons at the same time) (Press three buttons at the same time) (Press three buttons at the same time) KEY check mode ( Any pressing button or turn = AMS + button. 9 ( (Press three buttons at the same time) SERVICE BOX (PFJ-1) POWER SW FH-E9
15、39, 838, 737 CDP/TC CN904 17P CN902 7P CORD WITH CONNECTOR 17P (attached to PFJ-1) JIG (J-2501-078-A) CORD WITH CONNECTOR 7P (attached to set) SET CN301 7P SYSTEM CONTROL RadioFans.CN 收音机爱 好者资料库 4 SECTION 2 GENERAL Front PanelDisplay Window SECTION 3 DISASSEMBLY Note : Follow the disassembly procedu
16、re in the numerical order given. 3-1. LOADING PANEL 1Turn the cam in the direction of arrow. bottom of chassis 2 Pull out the disc table. 4 Remove the loading panel in the direction of arrow. 3 claws bottom of chassis This section is extracted from instruction manual. 5 3-2. MD BLOCK 3-3. HOLDER (BU
17、) ASSY 3 BVTP 38 5 MD block (CDM28-5BD19) 4 claws 1 CN202 2 CN201 1Turn the cam in the direction of arrow. 2 Pull out disc table. 3 yoke bracket 4 holder (BU) assy (BU-5BD19) 6 Note : 1.Basically designed to operate without adjustment. Therefore, check each item in order given. 2.Use YEDS-18 disc (3
18、-702-101-01) unless otherwise indicated. 3.Use an oscilloscope with more than 10M impedance. 4.Clean the objective lens by an applicator with neutral detergent when the signal level is low than specified value with the following checks. 5.Adjust the focus bias adjustment when optical block is replac
19、ed. Focus Bias Adjustment SECTION 4 ELECTRICAL ADJUSTMENTS Procedure: 1.Connect oscilloscope to test point TP (RF). (GND terminal : VC) 2.Turn Power switch on. 3.Put disc (YEDS-18) in and playback. 4.Adjust RV101 so that the waveform is clear. (Clear RF signal waveform means that the shape “ ” can b
20、e clearly distinguished at the center of the waveform.) 5.After adjustment, check the RF signal level. RF signal VOLT/DIV : 200 mV TIME/DIV : 500 nS S Curve Check Procedure: 1.Connect oscilloscope to test point TP(FEO). 2.Connect between test point TP(FOK)and GND by lead wire. 3.Turn Power switch on
21、. 4.Put disc (YEDS-18) in and turnd Power switch on again and actuate the focus search. (In case of using SERVICE BOX actuate the focus search when disc table is moving in and out.) 5.Check the oscillosope waveform (S-curve) is symmetrical between A and B. And confirm peak to peak level within 2.40.
22、7 Vp-p. S-curve waveform 6.After check, remove the lead wire connected in step 2. Note : Try to measure several times to make sure than the ratio of A:B or B:A is more than 10:7. Take sweep time as long as possible and light up the brightness to obtain best waveform. RF Level Check Procedure: 1.Conn
23、ect oscilloscope to test point TP (RF) on BD board. 2.Turn Power switch on. 3.Put disc (YEDS-18) in and playback. 4.Confirm that oscilloscope waveform is clear and check RF signal level is correct or not. Note : Clear RF signal waveform means that the shape “ ” can be clearly distinguished at the ce
24、nter of the waveform. RF signal waveform BD board oscilloscope TP (FEO) TP (FOK) VOLT/DIV : 200mV TIME/DIV : 500nS level : 1.30.3 Vp-p BD board TP (RF) TP (VC) oscilloscope BD board TP (RF) VC oscilloscope (DC range) level 1.30.3 Vp-p symmetry within 2.40.7 Vp-p A B 7 E-F Balance Check Procedure: 1.
25、Connect oscilloscpe to test point TP (TEO). 2.Turn Power switch on. 3.Connect pin of IC60I on the PANEL board to GND with a lead wire. 4.Put disc (YEDS-18) in and playback. 5.Push TIME button. 6.Confirm that the oscilloscope waveform is symmetrical on the top and bottom in relation to 0Vdc, and chec
26、k this level. Traverse waveform 7.Remove the lead wire connected in step 3. Focus/Tracking Gain Adjustment (RV102, 103) This gain has a margin, so even if it is slightly off. There is no problem. Therefore, do not perform this adjustment. Please note that it should be fixed to mechanical center posi
27、tion when you moved and do not know original position. BD board oscilloscope TP (TEO) TP (VC) PANEL BOARD (Conductor Side) 0V level : 300100 mVp-p symmetry IC601 4025 64 4124 6580 1 Adjustment Location : BD BOARD (Conductor Side) IC101 RF TEI FEI RV102 RV103 IC104 IC102 FEO TEO FOK VC GND PCK RV101
28、8 5-1. IC PIN FUNCTION IC601 PD78044AGF (SYSTEM CONTROL, FL DRIVER) Pin No.Pin NameI/OFunction 1-7T6-T0OFL display grid output 8VDD+5V power supply 9CLKOSerial clock output to DSP (CXD2507AQ). 10DATAOSerial data output to DSP (CXD2507AQ). 11Fixed at Ground. 12XLATOSerial data latch pulse output to D
29、SP (CXD2507AQ). 13PRGLOSerial data latch pulse output to D/F DAC (PCM1710U). 14SQCLKOSub code Q data read clock output to DSP (CXD2507AQ). 15Not used. (Open) 16SUBQISub code Q data input from DSP (CXD2507AQ). 17RESETISystem reset input (“ L ”= Active) 18INSWIS292 (load in switch) input 19OUTSWIS291
30、(load out switch) input 20AVSSGround 21LDOUTOOutput for rotating M903 (loading motor) in the loading out direction. 22LDINOOutput for rotating M903 (loading motor) in the loading in direction. 23ADJITest mode input. (“ L ”= Stops GFS check) 24AFADJITest mode input. Fixed at “H”. (“ L ”= Test mode) 2
31、5MODEINot used. (Fixed at “ H ”.) 26-28KEY2-KEY0IKey AD input 29AVDD+5V power supply 30AVREF+5V power supply 31Fixed at Ground. 32Not used. (Open) 33VSSGround 34X1IClock input (5MHz) 35X2OClock output (5MHz) 36BDRSTOBD reset output 37BDPOWEROBD power ON/OFF output 38Not used. (Open) 39SENSISENS inpu
32、t from DSP (CXD2507AQ). 40AMUTEONot used. (Open) 41FSWOFocus switch output 42BSOUTOAudio bus output 43Not used. (Open) 44SCORISub code sync S0+S1 detection input 45JOG1IJOG input 46Not used. (Open) 47BSINIAudio bus input 48IC (VPP)Connected to Ground. 49JOG0IJOG input 50, 51Not used. (Open) 52VDD+5V
33、 power supply 53-70S22-S5OFL display segment output 71VLOAD-28V power supply for driving FL display. 72-76S4-S0OFL display segment output 77-80T10-T7OFL display grid output SECTION 5 DIAGRAMS 9 26 SECTION 6 EXPLODED VIEWS NOTE: The mechanical parts with no reference number in the exploded views are
34、not supplied. Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. Abbreviation EA : Saudi Arabia model TH : Thai model -XX and -X mean standardized parts, so they may have some difference from the original o
35、ne. Color Indication of Appearance Parts Example : KNOB, BALANCE (WHITE) . (RED) Parts Color Cabinets Color Hardware (# mark) list and accessories and packing materials are given in the last of this parts list. The components identified by mark ! or dotted line with mark. ! are critical for safety.
36、Replace only with part number specified. N N 6-1. CHASSIS SECTION * 14-970-927-21CASE (BLACK) * 14-970-927-41CASE (SILVER) 23-363-099-01SCREW (CASE 3 TP2) 34-977-986-01PANEL, LOADING (E,EA,TH,AEP:SILVER) 34-977-986-21PANEL, LOADING (AEP,UK:BLACK) 41-769-621-11WIRE (FLAT TYPE) (19 CORE) * 5A-4673-912
37、-A MAIN BOARD, COMPLETE (TH) * 5A-4673-915-A MAIN BOARD, COMPLETE (E,EA) * 5A-4673-918-A MAIN BOARD, COMPLETE (AEP,UK) * 61-659-178-11CONNECTOR BOARD * 74-977-983-01PANEL, BACK (E) * 74-977-983-11PANEL, BACK (AEP,UK:BLACK,AEP:SILVER) (Made in France) * 74-977-983-21PANEL, BACK (EA) * 74-977-983-31PA
38、NEL, BACK (TH) * 74-977-983-41PANEL, BACK (AEP:SILVER) (Made in Malaysia) 84-977-699-11LEG (F) 94-965-822-01FOOT Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark 2 1 4 5 6 3 8 7 9 not supplied CDM28-5BD19 #1 #1 #1 #1 #1 #1 #1 #1 #1 #2 #2 2 27 6-2. FRONT PANEL SECTION Ref. No.Part N
39、o.DescriptionRemarkRef. No.Part No.DescriptionRemark 51X-4946-590-1PANEL ASSY, FRONT (E,EA,AEP:SILVER) (Made in Malaysia) 51X-4946-832-1PANEL ASSY (B), FRONT (AEP,UK:BLACK) 51X-4946-852-1PANEL ASSY (S), FRONT (TH,AEP:SILVER) (Made in France) 524-962-708-11EMBLEM (4-A), SONY 534-977-987-01KNOB (JOG)
40、(SILVER) 534-977-987-11KNOB (JOG) (BLACK) 544-979-797-01HOLDER (FL) * 55A-4673-913-A PANEL BOARD, COMPLETE (TH) * 55A-4673-916-A PANEL BOARD, COMPLETE (E,EA) * 55A-4673-919-A PANEL BOARD, COMPLETE (AEP,UK) 561-776-237-11WIRE (FLAT TYPE) (23 CORE) 574-951-620-01SCREW (2.6X8), +BVTP * 584-977-985-01SH
41、EET (FL) FL6011-517-369-11INDICATOR TUBE, FLUORESCENT not supplied FL601 51 52 57 53 54 57 57 56 55 58 28 6-3. CD MECHANISM SECTION (CDM28-5BD19) Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark 1011-452-719-11MAGNET ASSY 1024-917-583-21BRACKET, YOKE 1034-960-836-01TABLE, DISC 1044
42、-927-649-01BELT 1054-960-842-01GEAR (P) 1064-960-841-01PULLEY (S) * 1074-960-839-01CAM 1084-960-838-03BASE (MD) 1094-960-835-01HOLDER (M) * 1101-650-836-11LOADING BOARD 1114-933-134-01SCREW (+PTPWH M2.6X6) 1124-959-996-01SPRING (932), COMPRESSION 1134-960-834-01HOLDER (BU) M151A-4604-363-A MOTOR (L)
43、 ASSY (LOADING) 111 112 112 BU-5BD19 113 106 104 105 111 109 #1 #1 101 (including r A) r A 107 #1 M151 110 108 102 103 29 Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark 6-4. BASE UNIT SECTION (BU-5BD19) The components identified by mark ! or dotted line with mark. ! are critical
44、for safety. Replace only with part number specified. 156 152 158 157 M101 (Including rA) M102 151 152 153 rA 155 #3 160 1574-917-564-01GEAR (P), FLATNESS 1581-769-069-11WIRE (FLAT TYPE) (16 CORE) 1604-951-620-01SCREW (2.6X8), +BVTP M101X-4917-523-3BASE (OUTSERT) ASSY (SPINDLE) M102X-4917-504-1MOTOR
45、ASSY (SLED) * 151A-4673-402-A BD BOARD, COMPLETE 1524-951-940-01INSULATOR (BU) 1534-917-565-01SHAFT, SLED ! 1558-848-367-11PICK-UP, OPTICAL KSS-213B/K-RP 1564-917-567-01GEAR (M) 30 SECTION 7 ELECTRICAL PARTS LIST NOTE: Due to standardization, replacements in the parts list may be different from the
46、parts specified in the diagrams or the components used on the set. -XX and -X mean standardized parts, so they may have some difference from the original one. RESISTORS All resistors are in ohms. METAL:Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F:nonflammable Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. SEMICONDUCTORS In each case, u : , for exampl