Pioneer-PDF507-cd-sm2电路图 维修手册.pdf

《Pioneer-PDF507-cd-sm2电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Pioneer-PDF507-cd-sm2电路图 维修手册.pdf（10页珍藏版）》请在收音机爱好者资料库上搜索。

1、ORDER NO. PIONEER ELECTRONIC CORPORATION4-1, Meguro 1-Chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS SERVICE, INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER ELECTRONIC (EUROPE) N.V . Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD

2、. 501 Orchard Road, #10-00 Lane Crawford Place, Singapore 0923 CCCCC?PIONEER ELECTRONIC CORPORATION 1998 FILE-TYPE CD PLAYER RRV1951 PD-F607 TZZY APR. 1998 Printed in Japan Refer to the service manual RRV1877 for PD-F607/KUXJ and PD-F507/KUXJ. CONTENTS 1. SAFETY INFORMATION.2 2. CONTRAST OF MISCELLA

3、NEOUS PARTS .3 3. SCHEMATIC AND PCB DIAGRAMS .8 THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S). Model PD-F607PD-F507 Type The voltage can be converted by the following method. Power Requirement WYXJOAC220-240V WVXJOAC220-240V WPWXJOAC220-240V MAMXJOAC220-230V RLXJOAC110-120V/220-240

4、VWith the voltage selector RDXJOAC110-127V/220-240VWith the voltage selector PD-F507 RadioFans.CN 收音机爱 好者资料库 PD-F607, PD-F507 2 1. SAFETY INFORMATION Additional Laser Caution 1.Laser Interlock Mechanism The position of the switch (S651) for detecting loading state is detected by the system microproc

5、essor, and the design prevents laser diode oscillation when the switch (S651) is not on CLMP terminal side (CLMP signal is OFF or high level). Thus, the interlock will no longer function if the switch (S651) is deliberatery set to CLMP terminal side. (low level) The interlock also does not function

6、in the test mode 8. Laser diode oscillation will continue, if pin 33 of CXA1782CQ (IC151) on the MOTHER BOARD ASSY is connected to GND, or pin 26 of IC351 (LDON) is connected to low level (ON), or else the terminals of Q151 are shorted to each other (fault condition). 2.When the cover is opened, clo

7、se viewing of the objective lens with the naked eye will cause exposure to a Class 1 laser beam. 8 : Refer to page 25. on the service manual RRV1877. This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the nec

8、essary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the r

9、epair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician. LABEL CHECK (For PD-F607/WYXJ,WVXJ and PD-F507/WPWXJ only) REAR PD-F607/WVXJ and PD-F507/WPWXJ only PD-F607/WYXJ only IMPORTANT THIS PIONNER APPARATUS CONTAINS LASER

10、 OF CLASS 1. SERVICING OPERATION OF THE APPARATUS SHOULD BE DONE BY A SPECIALLY INSTRUCTED PERSON. LASER DIODE CHARACTERISTICS MAXIMUM OUTPUT POWER : 5 mw WAVELENGTH : 780-785 nm RadioFans.CN 收音机爱 好者资料库 PD-F607, PD-F507 3 2. CONTRAST OF MISCELLANEOUS PARTS NOTES : Parts marked by “ NSP ” are general

11、ly unavailable because they are not in our Master Spare Parts List. The mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing,be sure to use parts of identical designation. Reference Nos. indicate the pages and Nos. in the service man

12、ual for the base model. Screw adjacent to mark on the product are used for disassembly. When ordering resistors, first convert resistance values into code form as shown in the following examples. Ex. 1When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47k ohm (tolerance

13、is shown by J = 5%, and K = 10%). 560 = 56 10 1 = 561. RD1/4PU 5 6 1 J 47k = 47 10 3 = 473 . RD1/4PU 4 7 3 J 0.5 = R50 . RN2H 5 0 K 1 = 1R0 . RS1P 1 0 K Ex. 2When there are 3 effective digits (such as in high precision metal film resistors). 5.62k = 562 10 1 = 5621 . RN1/4PC 5 6 2 1 F CONTRAST TABLE

14、 (FOR PD-F607) WYXJ, WVXJ and KUXJ types are constructed the same except for the following : Part No. Remarks KUXJWYXJWVXJ Ref. No. MarkSymbol and Description PD-F607 ASSEMBLES P5-1Mother Board AssyPWM2199PWM2200PWM2200 NSPHeadphone Board AssyNot usedPWX1549PWX1549No.9 NSPSub Board AssyPWX1540PWX154

15、1PWX1541 P7-16NSPPower SW Board AssyPWZ3622PWZ3623PWZ3623 PACKING P3-1Operating Instructions (English)PRB1262Not usedPRB1265 P3-1Operating InstructionsNot usedPRE1265Not used (English/French) P3-1Operating InstructionsNot usedPRD1026Not used (German/Italian/Dutch/Swedish /Spanish/Portuguese) P3-5Con

16、trol Cable (L=1m)PDE1247Not usedNot used P3-10Packing CasePHG2282PHG2298PHG2299 P3-12NSPWarranty CardARY1051ARY7009ARY7009 CD Liner Notes FileNot usedPHN1051PHN1051No.1 Index Label Sheet (25)Not usedPRW1422PRW1422No.2 Rear SpacerNot usedNot usedPHC1087No.3 Polyetylene Bag (115 x 270 x 0.05)Not usedN

17、ot usedZ21-013No.4 EXTERIOR P5-2Cord StopperCM-22CCM-22BCM-22B P5-4AC Power CordPDG1015PDG1003PDG1055 P5-5Power Transformer (AC120V)PTT1237Not usedNot used P5-5Power Transformer (AC220-240V)Not usedPTT1236PTT1236 P5-8Rear BasePNA2386PNA2398PNA2399 P5-4265 LabelORW1069Not usedNot used Insulator (Fron

18、t Side)Not usedPNW2766PNW2766No.5 Caution LabelNot usedNot usedPRW1018No.6 Caution Label HENot usedPRW1233Not usedN0.7 Caution LabelNot usedVRW1094Not usedNo.8 Headphone AngleNot usedPNB1584PNB1584No.10 KnobNot usedRAC1903RAC1903No.11 FRONT PANEL SECTION P7-10Display WindowPAM1740PAM1739PAM1739 P7-1

19、5Control PanelPNW2756PNW2757PNW2757 P7-20Rubber SheetAEB1111Not usedNot used LED LensNot usedPNW2019PNW2019No.12 Note: The numbers in the remarks column correspond to the numbers on the exploded diagram, Refer to “EXPLODED VIEWS”. For ASSEMBLIES, Refer to “ CONTRAST OF PCB ASSEMBLES” and “3. SCHEMAT

20、IC AND PCB DIAGRAMS”. RadioFans.CN 收音机爱 好者资料库 PD-F607, PD-F507 4 CONTRAST TABLE (FOR PD-F507) WPWXJ, MAMXJ, RLXJ, RDXJ and KUXJ types are constructed the same except for the following : RemarksRef. No.Symbol and DescriptionMarkPD-F507 Part No. KUXJWPWXJMAMXJRLXJRDXJ ASSEMBLES P5-1MOTHER Board AssyPW

21、M2193 PWM2196 PWM2197 PWM2195 PWM2195 NSPSUB Board AssyPWX1537PWX1538PWX1538PWX1538PWX1538 P7-16NSPPower SW Board AssyPWZ3622PWZ3623PWZ3623PWZ3623PWZ3623 PACKING P3-1Operating Instructions (English)PRB1265PRB1265Not usedNot usedNot used P3-1Operating InstructionsNot usedNot usedPRE1267PRE1267PRE1267

22、 (English/Spanish/Chinese) P3-1Operating InstructionsNot usedNot usedPRD1028Not usedNot used (German/Italian/Dutch/Swedish/Spanish/ Portuguese) P3-5Control Cable (L=1m)PDE1247PDE1247Not usedNot usedNot used P3-10Packing CasePHG2301PHG2303PHG2313PHG2303PHG2303 P3-12NSPWarranty CardARY1051PRY1003Not u

23、sedNot usedNot used CD Liner Notes FileNot usedPHN1051PHN1051PHN1051PHN1051No.1 Index Label Sheet (25)Not usedPRW1422 PRW1422 PRW1422 PRW1422No.2 Caution 220V LabelNot usedNot usedNot usedARR1003ARR1003No.13 EXTERIOR P5-2Cord StopperCM-22CCM-22BCM-22BCM-22BCM-22B P5-4AC Power CordPDG1015ADG1123PDG10

24、62PDG1003PDG1056 P5-5Power Transformer (AC120V)PTT1237Not usedNot usedNot usedNot used P5-5Power Transformer (AC220-240V)Not usedPTT1236PTT1236Not usedNot used P5-5Power TransformerNot usedNot usedNot usedPTT1238PTT1238 (RLXJ type: AC110-120V/220-240V) (RDXJ type: AC110-127V/220-240V) P5-8Rear BaseP

25、NA2401PNA2403PNA2416PNA2404PNA2402 P5-4265 LabelORW1069Not usedNot usedNot usedNot used Insulator (Front Side)Not usedPNW2766 PNW2766 PNW2766 PNW2766No.5 Caution LabelNot usedPRW1018Not usedPRW1018Not usedNo.6 FRONT PANEL SECTION P7-15Control PanelPNW2783 PNW2784 PNW2784 PNW2784 PNW2784 P7-20Rubber

26、SheetAEB1111Not usedNot usedNot usedNot used LED LensNot usedPNW2019 PNW2019 PNW2019 PNW2019No.12 Note: The numbers in the remarks column correspond to the numbers on the exploded diagram, Refer to “EXPLODED VIEWS”. For ASSEMBLIES, Refer to “ CONTRAST OF PCB ASSEMBLES” and “3. SCHEMATIC AND PCB DIAG

27、RAMS”. PD-F607, PD-F507 5 EXTERIOR and FRONT PANEL SECTION EXPLODED VIEWS PACKING SECTION No.4 Packing Case No.2 No.1 Front Polyetylene Bag No.3 Protecter F Protecter F Protecter R Protecter R Operating Instructions Warranty Card Remote Control unit Batteery Control Cable N0.13 Rear Base Under Base

28、Foot Screw (BBZ30P060FMC) Screw (IBZ30P080FMC) No.12 Control Panel No.5 No.6,No.8 No.7 No.11 No.10 No.9 PD-F607, PD-F507 6 CONTRAST OF PCB ASSEMBLIES MOTHER BOARD ASSY ASSY (For PD-F507) PWM2197, PWM2195 and PWM2196 are constructed the same except for the following : D391-D3941SS254Not usedNot used

29、L391LAU1R0JNot usedNot used C319,C324,C431,C432Not usedNot usedCKCYF103Z50 C399CKCYF103Z50Not usedNot used R391RD1/4PU244JNot usedNot used R392RD1/4PU102JNot usedNot used JA391,JA392RKN1004Not usedNot used S5 (Voltage selector)Not usedNot usedPSB1006 MarkSymbol and Description Part No. PWM2196PWM219

30、7PWM2195 Remarks PCB PARTS LIST MarkNo.DescriptionPart No. MOTHER BOARD ASSY (PWM2196: For PDF-507/WPWXJ) SEMICONDUCTORS IC151CXA1782CQ IC301CXD2529Q IC31,IC34ICP-N10 IC201,IC202LA6520 IC405NJM4558D-D IC351PD4900B IC21PQ05RR12 Q1512SA854S Q403,Q4042SD2144S Q3412SK246 Q152DTA124ES Q321,Q405DTC124ES D

31、321,D341,D352,D391-D3941SS254 D54MTZJ18B D218MTZJ6.2B D11-D14,D52S5688G COILS L351LAU100J L322,L391LAU1R0J CAPACITORS C181CCCCH100D50 C341,C342CCCCH120J50 C318CCCSL181J50 C315CCCSL221J50 C481,C482CCCSL390J50 C171,C175,C301,C302CEAT101M10 C311-C314,C316,C322,C352CEAT101M10 C52CEAT101M35 C26CEAT102M16

32、 C433,C434CEAT220M25 C131-C133,C27CEAT330M16 C25CEAT332M16 C351CEAT471M6R3 C169,C170,C356CEAT4R7M50 C309CEATR47M50 C156,C161,C164,C168,C218CGCYX103K25 C321CGCYX104K25 C160CGCYX333K25 C167CGCYX472K25 C152,C307CGCYX473K25 C163CKCYB102K50 C176,C306,C441,C442CKCYB152K50 C305CKCYB222K50 C162CKCYB332K50 C

33、151CKCYB682K50 C11-C13,C15,C16,C17CKCYF103Z50 C159,C172,C173,C205CKCYF103Z50 C210,C215,C219,C2231,C29CKCYF103Z50 C304,C310,C317,C323,C325CKCYF103Z50 C353,C354,C357,C399CKCYF103Z50 C153-C155,C158CQMA104J50 C157CQMA823J50 RESISTORS VR153,VR155 (10k)RCP1045 VR151,VR152,VR154 (22k)RCP1046 VR156 (220k)RC

34、P1049 Other ResistorsRD1/4PU J OTHERS CN351CONNECTORHLEM34S-1 CN201CONNECTOR 6PRKP-533 CN202CONNECTOR 25PVKN1201 JA4012P PIN JACKPKB1023 JA391,JA392 REMOCON JACKRKN1004 JA321OPTICAL OUTPUT JACK TOTX178 TERMINAL 2PRKC-061 X341CRYSTAL RESONATORPSS1008 (16.9344MHz) X351CERAMIC RESONATORVSS1014 (4.194MH

35、z) MOTHER BOARD ASSY (PWM2200: For PDF-607/WYXJ) SEMICONDUCTORS IC406BA15218 IC151CXA1782CQ IC301CXD2529Q IC31,IC34ICP-N10 IC201,IC202LA6520 IC302LC89170M IC405NJM4558D-D IC401PD2026B(L) IC351PD4900B IC21PQ05RR12 MarkNo.DescriptionPart No. J F J F J F PD-F607, PD-F507 7 MarkNo.DescriptionPart No.Mar

36、kNo.DescriptionPart No. K Q1512SA854S Q403,Q4042SD2144S Q152DTA124ES Q321,Q405DTC124ES D54MTZJ18B D218MTZJ6.2B D11-D14,D52S5688G COILS L351LAU100J L322LAU1R0J L3410LAUR47J CAPACITORS C181CCCCH100D50 C403CCCCH120J50 C404CCCCH220J50 C318CCCSL181J50 C315CCCSL221J50 C429,C430,C43-C438CCCSL390J50 C171,C1

37、75,C301,C302,C311CEAT101M10 C314,C316,C322,C352CEAT101M10 C52CEAT101M35 C26CEAT102M16 C433,C434CEAT220M25 C131-C133,C27,C432CEAT330M16 C25CEAT332M16 C351CEAT471M6R3 C169,C170,C356CEAT4R7M50 C309CEATR47M50 C413-C416CFTXA104J50 C156,C161,C164,C168,C218CGCYX103K25 C321CGCYX104K25 C160CGCYX333K25 C167CG

38、CYX472K25 C152,C307CGCYX473K25 C163CKCYB102K50 C176,C306CKCYB152K50 C441,C442CKCYB152K50 C305CKCYB222K50 C162CKCYB332K50 C151CKCYB682K50 C11-C13,C15CKCYF103Z50 C159CKCYF103Z50 C16,C17CKCYF103Z50 C172,C173,C205,C210,C215CKCYF103Z50 C219,C29,C304,C310CKCYF103Z50 C312,C313,C317,C319CKCYF103Z50 C323-C32

39、5,C353,C354,C357CKCYF103Z50 C387,C405,C417,C461,C471CKCYF103Z50 C153-C155,C158,C382CQMA104J50 C157CQMA823J50 RESISTORS VR153,VR155 (10k)RCP1045 VR151,VR152,VR154 (22k)RCP1046 VR156 (220k)RCP1049 Other ResistorsRD1/4PU J OTHERS CN401CONNECTOR52147-0310 CN351CONNECTORHLEM38S-1 CN201CONNECTOR 6PRKP-533

40、 CN202CONNECTOR 25PVKN1201 JA4012P PIN JACKPKB1023 JA321OPTICAL OUTPUT JACKTOTX178 TERMINAL 2PRKC-061 X401CRYSTAL RESONATORPSS1008 (16.9344MHz) X351CRYSTAL RESONATORVSS1014 (4.194MHz) HEADPHONE BOARD ASSY (PD-F607 only) COILS L501,L506,L507 LAU1R0J CAPACITORS C501,C502CKCYF103Z50 C507CKCYF473Z50 RES

41、ISTORS VR501(5k)PCS1003 OTHERS JA501HEADPHONE JACKRKN1002 J501JUMPER WIRE 3PD20PWY0310E POWER SW BOARD ASSY SEMICONDUCTOR D751SLR-342VCT31 SWITCHE S751RSG1030 OTHERS J801JUMPER WIRE 5PD20PWW0545E c F A B C D 1234 1234 PD-F607, PD-F507 8 3.SCHEMATIC AND PCB DIAGRAMS NOTE: The numbers marked with a ci

42、rcle show the number of each measuring point,which correspond to the number in the service manual PD-F607(ORDER NO.RRV1877) on page16-17. MOTHER BOARD ASSY PD-F607/WYXJ,WVXJ:PWM2200 PD-F507/WPWXJ:PWM2196 PD-F507/MAMXJ:PWM2197 PD-F507/RLXJ,RDXJ:PWM2195 SIGNAL ROUTE : AUDIO SIGNAL : FOCUS SERVO LOOP :

43、 TRACKING SERVO LOOP : CARRIAGE SERVO LOOP : SPINDLE DRIVE : LOADING DRIVE 23 16 19 18 53 33 223 4 3 7 5 6 8 5.0V 1.7V 1.7V 0.2V 1.6V 1.6V 0V 1.6V 1.6V 0V 1.8V 1.8V -0.7V CN701 J801 CN653 STBL PD-F607 OTHERS R351 220 150 D352 Jumper 1SS254 R310 R311 R312 DATA LRC BCK1 PD-F607 OTHERS R310-R312 220 Ju

44、mper PD-F507 Only PD-F607 Only PD-F607 Only CN351 PD-F607:HLEM38S-1 PD-F507:HLEM34S-1 POWER SW ASSY PWZ3623 5 D751 SLR-342VCT31 J811 J801 D20PWW0545E RSG1030 B B D F CF JF J FC F A B C D 5678 5678 PD-F607, PD-F507 9 NOTE: When ordering service parts, be sure to refer to “PARTS LIST of EXPLODED VIEWS

45、” or “PCBPARTS LIST”. PIN No. Voltage(V)5 0 12to4789 4.71.2-1.4 10111213 4.454.74.7 1416172324 0.0555 2526273839 02.53.1 40 IC301(CXD2529Q) 1.2-1.44.7552.6-2.72.5 4142 03.1 43 5 PIN No. Voltage(V)2.50.9 4445464748 2.52.5 50to55565761 2.5055 7175787982 2.505 8384to86878889,90 552.5 91,92 5002.500 93t

46、o9596 2.55 97 0 100 5 AC Power Cord PD-F607/WYXJ,PD-F507,RLXJ:PDG1003 PD-F607/WVXJ:PDG1055 PD-F507/WPWXJ:ADG1123 PD-F507/MAMXJ:PDG1062 PD-F507/RDXJ:PDG1056 Power Requirement WYXJ,WVXJ,WPWXJ:AC220-240 50/60Hz RLXJ:AC110-120V/220-240V 50/60Hz RDXJ:AC110-127V/220-240V 50/60Hz MAMXJ:AC220-230V 50/60Hz W

47、YXJ,WVXJ:PTT1236 WPWXJ,MAMXJ:PTT1236 RLXJ,RDXJ:PTT1238 RDXJ,RLXJ OTHER JP1 JP2 S5 HEADPHONE ASSY PWX1549 PD-F607 Only PD-F607 Only EXCEPT PD-F607 R360 R361 PD-F607 OTHER EXCEPT PD-F507/WPWXJ PD-F607 OTHERS D321 Jumper 1SS254 EXCEPT PD-F607 PD-F607 Only WYXJ,WVXJ :33/16 RDXJ :0.01 PD-F607 OTHERS C312,C313 0.01 100/10 PD-F507/WPWXJ Only PD-F607 OTHERS R447 470 Jumper R448 470 Jumper R461 470 1K R462 470 1K PD-F607 OTHERS R427-R430 22K R435,R436 16K Jumper R437,R438 16K 47K R439-R442 43K 82K R487-R490 100K C429,C430 39P C435-C4