Rotel-RC1090_1-pre-sm 电路图 维修手册.pdf

《Rotel-RC1090_1-pre-sm 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Rotel-RC1090_1-pre-sm 电路图 维修手册.pdf（13页珍藏版）》请在收音机爱好者资料库上搜索。

1、T echnical Manual STEREO CONTROL AMPLIFIER RC-1090-1 Table of Contents Specification Specification. 1 Parts List. 27 Case Outlines. 8 Safety Caution. 8 PCB Assembly. 911 Schematic Diagram . 1213 Total Harmonic Distortion0.004 % (20 Hz - 20 kHz 8 ohms) Intermodulation Distortion0.004 % at 1V output (

2、60 Hz : 7 kHz 4 : 1) Input Sensitivity/ Impedance Phono - MC0.25 mV / 100 ohms Phono - MM2.5 mV / 47 kohms Line Level150 mV / 18 kohms Phono Overload (MC/MM)16 mV / 160 mV Output Level / Impedance1 V / 100 ohms Frequency Response Phono Input20 Hz - 20 kHz, 0.2 dB Iine Level Input4 Hz - 100 kHz, 0.5

3、dB Signal to Noise Ratio (IHF A weighted) Phono - MC / MM70 dB / 75 dB Line Level100 dB Power Requirements USA Version115 volts, 60 Hz European Version230 volts, 50 Hz Power Consumption13 Watts Dimensions (W x H x D) 430 x 125 x 345 mm 1615/16 x 415/16 x 1319/32 Weight (net)7.8 kg/17.2 lb. SHINSEN-B

4、LD. 4F 10-10 SHINSEN-CHO, SHIBUYA-KU, TOKYO 150-0045, JAPAN Serial. NO. Beginning Y-340B-0510/pdf RadioFans.CN 收音机爱 好者资料库 STEREO CONTROL AMPLIFIER RC-1 090 VOLUME PHONESSTANDBY RECORDING LISTENING DVD /VIDEOTUNER DVD /VIDEOTUNER TAPE 1TAPE 2AUX 2AUX 1PHONOCD PHONOCDTAPE 1AUX 2AUX 1OFF LISTENINGRECOR

5、DING TAPE 1AUX 1TUNERDVD/VIDEO OFFON BALANCED CD OFFON BALANCED OUTPUTS SWITCHED 400W MAX CDPHONOTAPE 2AUX 2 LEFT RIGHT LEFT RIGHT MM MC INOUTINOUT RL IN EXT REMIR OUT12V TRIGGER OUTCOMPUTER I/O 1212 BALANCED OUTPUTS RL BALANCED CD IN 12 Appearance RC-1090 RadioFans.CN 收音机爱 好者资料库 Parts List 1/4 RC-1

6、090 SYMBOLPARTS NO.DESCRIPTION 501 X-1299PCB ASSY H1,H2,H3,H4017 C-4401A01 SUB HEAT SINKER H=25 1025 Q501/503,502/504,505/507,506/508019 C-4334A04TRANSISTOR CAP H1,H2,H3,H4019 TO-126MICA SHEET TBM-51W-15 #9524 IC704031 LB1641IC (MOTOR DRIVE) IC542031 LC4966IC (LOGIC SWITCH) IC403,404031 NE5534AN-SIC

7、 (SELECTED OPE AMP) IC601031 NJM4556ADIC (OPE DUAL) IC901031 NJM7805FAIC (REG. +5VDC) KIA7805API-U IC902031 NJM7815FAIC (REGULATOR +15VDC) IC903031 NJM7915FAIC (REGULATOR -15VDC) IC502,503031 OPA134PAIC (OPE AMP SINGLE) IC501031 OPA2134PAIC (OPE DUAL) IC703031 TC74HC595APIC (8BIT SHIFT REGISTER/LATC

8、H) IC451031 TC9163ANIC (SWITCH ALLEY) IC401,402031 TL071CPIC (OPE AMP SINGLE) Q401-404032 D786-RSTRANSISTOR 2SD786-RS Q451-458,468032 TA1345TRANSISTOR 2SA1345AC Q527,528032 TA608-FGTRANSISTOR 2SA608KAA-FG Q460-467,470032 TC3399TRANSISTOR 2SC3399AC Q525,526,529,530,903032 TC536-FGTRANSISTOR 2SC536KAA

9、-FG Q904032 TD863-EFTRANSISTOR 2SD863AE-EF Q519,520033 A1209-STTRANSISTOR 2SA1209-ST Q409,410,521,522033 B631-EFTRANSISTOR 2SB631K-EF Q517,518033 C2911-STTRANSISTOR 2SC2911-ST Q407,408,523,524033 D600-EFTRANSISTOR 2SD600K-EF Q505-512,902033 TA1016-FGTRANSISTOR 2SA1016KAA-FG Q905033 TA1450-STTRANSIST

10、OR 2SA1450AA-ST Q405,406,501-504,513-516033 TC2362-FGTRANSISTOR 2SC2362KAA-FG Q901,906033 TC3708-STTRANSISTOR 2SC3708AA-ST D901,902034 BR84 BRIDGE POWER DIODE 8A 400V D511-514034 E-562CURRENT REGULATIVE DIODE 5.6mA D509,510034 MA27W-AVARISTOR DIODE D401-404,441-448,501-508,541034 T1N4148-86DIODE 1N4

11、148TAP-50 D601,602,707,904,905,907034 T1N4148-86DIODE 1N4148TAP-50 D911034 TRD12JST1ZENER DIODE 12V (AB2) D908,912034 TRD16JST1ZENER DIODE 16V (AB2) D405,406034 TRD18JST1ZENER DIODE 18V (AB2) D909034 TRD30JST1ZENER DIODE 30V (AB2) D906034 TRD4.7JST1ZENER DIODE 4.7V (AB2) D713034 TRD5.6JST1ZENER DIOD

12、E 5.6V (AB2) D910034 TRD9.1JST1ZENER DIODE 9.1V (AB2) D903034 W02M BRIDGE POWER DIODE 1.5A 200V F901036 5ST2.5 FUSE 250VT2.5A C501,502,507,508,517,518041 25BGF47MELECTROLYTIC CAPACITOR 25V47uF C509-512041 35BGF100MELECTROLYTIC CAPACITOR 35V100uF C513-516,918,919041 35BGF470MELECTROLYTIC CAPACITOR 35

13、V470uF C505,506041 50BGF010MELECTROLYTIC CAPACITOR 50V1uF C901-904041 ALN20S1078DDELECTROLYTIC CAPACITOR 63V4700uF C421-424041 TEEUFC1E471BELECTROLYTIC CAPACITOR 25V470uF C413-420,519-524041 TEEUFC1E101SBELECTROLYTIC CAPACITOR 25V100uF C409,410,425,426041 TEEUFC1H100LBELECTROLYTIC CAPACITOR 50V10uF

14、C912041 TUTES1A101-TFELECTROLYTIC CAPACITOR 10V100uF C451,452,607,608,916,917041 TUTES1E101-TFELECTROLYTIC CAPACITOR 25V100uF C720041 TUTES1E470-TFELECTROLYTIC CAPACITOR 25V47uF C910041 TUTES1H010-TFELECTROLYTIC CAPACITOR 50V1uF C461-468041 TUTES1H100-TFELECTROLYTIC CAPACITOR 50V10uF C913041 TUTES1H

15、470-TFELECTROLYTIC CAPACITOR 50V47uF 016 X-1299F01-05 PCB ASSY RadioFans.CN 收音机爱 好者资料库 Parts List 2/4 RC-1090 SYMBOLPARTS NO.DESCRIPTION C601,602041 TUTES1H4R7-TFELECTROLYTIC CAPACITOR 50V4.7uF C908,909,911041 TUTES1V101-TFELECTROLYTIC CAPACITOR 35V100uF C915041 TUTES1V102-TSELECTROLYTIC CAPACITOR 3

16、5V1000uF C605,606042 TP50V103JMYLAR CAPACITOR UMX-TF 0.01uF C905-907,914,923-930043 TC500V103CERAMIC CAPACITOR 500V0.01uF C703-705043 TC50V103CERAMIC CAPACITOR 0.01uF C427043 TC50V473CERAMIC CAPACITOR 0.047uF C405,406044 FSC160V101HPOLYSTYLENE CAPACITOR 160V100pF C403,404044 FSC160V331HPOLYSTYLENE C

17、APACITOR 160V330pF C411,412044 PP160V6800PFPOLYPROPYLENE CAPACITOR 2222 461-46802 C603,604044 S50V47PJSTYROL CAPACITOR 50V47PF(J) C401,402,503,504044 TFKP2-2A101HP.P CAPACITOR FKP2-100V101H C407,408044 TFKP2-2A102FP.P CAPACITOR FKP2-100V102F VR501051 C-4170A33DETENT VARIABLE RESISTOR 50KAX2 with MOT

18、OR R721053 CR14-103J-ACARBON RESISTOR 1/4W 10K R474,557,916053 CR14-104J-ACARBON RESISTOR 1/4W 100K R907053 CR14-153J-ACARBON RESISTOR 1/4W 15K R911,912,913053 CR14-223J-ACARBON RESISTOR 1/4W 22K R918053 CR14-272J-ACARBON RESISTOR 1/4W 2.7K R558053 CR14-331J-ACARBON RESISTOR 1/4W 330 R471,472053 CR1

19、4-470J-ACARBON RESISTOR 1/4W 47 R908053 CR14-472J-ACARBON RESISTOR 1/4W 4.7K R910053 CR14-473J-ACARBON RESISTOR 1/4W 47K R476053 CR14-474J-ACARBON RESISTOR 1/4W 470K R477053 CR14-561J-ACARBON RESISTOR 1/4W 560 R909053 CR14-682J-ACARBON RESISTOR 1/4W 6.8K R612053 CR14-821J-ACARBON RESISTOR 1/4W 820 R

20、716053 CR16-100J-ACARBON RESISTOR 1/6W 10 R930053 CR16-103J-ACARBON RESISTOR 1/6W 10K R717053 CR16-104J-ACARBON RESISTOR 1/6W 100K R928,929053 CR16-2R2J-ACARBON RESISTOR 1/6W 2.2 R903054 1WS120JFMOF RESISTOR 1W 120 R902,919054 1WS180JFMOF RESISTOR 1W 180 R611,904054 1WS330JFMOF RESISTOR 1W 330 R9170

21、54 1WS68JFMOF RESISTOR 1W 68 R905,906054 2WS100JFMOF RESISTOR 2W 100 R901,927054 ERQ12AJ2R2PFUSIBLE RESISTOR 1/2W 2.2 R451-464,467-470054 TMF16-1001METAL FILM RESISTOR 1/6W 1K R415,416054 TMF4700METAL FILM RESISTOR 1/4W 470 R465,466,555,556054 TMFR4001KSTANDARD METAL RESISTOR 1/4W 1K R537-540,551-55

22、4054 TMFR4010KSTANDARD METAL RESISTOR 1/4W 10K R529-532054 TMFR4010RSTANDARD METAL RESISTOR 1/4W 10 R527,528054 TMFR4018KSTANDARD METAL RESISTOR 1/4W 18K R505-512054 TMFR401K2STANDARD METAL RESISTOR 1/4W 1.2K R435,436,920,921054 TMFR401K5STANDARD METAL RESISTOR 1/4W 1.5K R417,418,517,518,547-550054

23、TMFR4022KSTANDARD METAL RESISTOR 1/4W 22K R421,422054 TMFR402K7STANDARD METAL RESISTOR 1/4W 2.7K R605,606054 TMFR4033KSTANDARD METAL RESISTOR 1/4W 33K R525,526054 TMFR403K3STANDARD METAL RESISTOR 1/4W 3.3K R433,434.535,536,545,546,609,610054 TMFR4047KSTANDARD METAL RESISTOR 1/4W 47K R409,410054 TMFR

24、4047RSTANDARD METAL RESISTOR 1/4W 47 R425,426054 TMFR404K7STANDARD METAL RESISTOR 1/4W 4.7K R411-414054 TMFR405K6STANDARD METAL RESISTOR 1/4W 5.6K R423,424054 TMFR4075KSTANDARD METAL RESISTOR 1/4W 75K R431,432,601,602054 TMFR4100KSTANDARD METAL RESISTOR 1/4W 100K R429,430,533,534,541-544054 TMFR4100

25、RSTANDARD METAL RESISTOR 1/4W 100 R607,608054 TMFR4150RSTANDARD METAL RESISTOR 1/4W 150 R523,524054 TMFR4220RSTANDARD METAL RESISTOR 1/4W 220 R419,420,513-516054 TMFR4270RSTANDARD METAL RESISTOR 1/4W 270 R603,604054 TMFR4330KSTANDARD METAL RESISTOR 1/4W 330K Parts List 3/4 RC-1090 SYMBOLPARTS NO.DES

26、CRIPTION R427,428054 TMFR4470KSTANDARD METAL RESISTOR 1/4W 470K R519-522054 TMFR4470RSTANDARD METAL RESISTOR 1/4W 470 R407,408,559,560054 TMFR4560RSTANDARD METAL RESISTOR 1/4W 560 R403,404,501,502054 TRC55C1000FMETAL RESISTOR 100 R405,406054 TRC55C10R0FMETAL RESISTOR 10 R503,504054 TRC55C3902FMETAL

27、RESISTOR 39K R401,402054 TRC55C4702FMETAL RESISTOR 47K S901061 4TR-2947PUSH SWITCH SPUN12 (STANDBY) S401061 4TR-3301PUSH SWITCH SPUJ19 (MM / MC) RY451-458,501,601,602063 A24W-KRELAY A24W-K RY902063 DG1U-24 RELAY DG24D1-O(M)-2 RY901063 DH2U-24 RELAY DH24D2-O(M) S501,502064 4TR-2341SLIDE SWITCH SSSU12

28、2 (BALANCED CD) PJ1-PJ6066 4TR-2672#3 4P PIN JACK AU (WHT.RED) DJ1,DJ2066 C-4516B013P CANNON SOCKET(MALE) YKF52-5004N DJ3,DJ4066 C-4575B01 3P CANNON JACK(FEMALE) YKF52-5006N D002068 B2B-EHCONNECTOR WAFER 2P JP5B,JP6B,JP7B,JP8A,JP9A,JP12A068 B3B-EHCONNECTOR WAFER 3P JP1B,JP2B,JP10B,JP15A068 B4B-EHCON

29、NECTOR WAFER 4P JP11B068 B6B-EHCONNECTOR WAFER 6P JP3B068 B8B-EHCONNECTOR WAFER 8P CON5068 C-3683#1PCB TERMINAL 2P P7.5 TP WE-11 I-752NA CON4,CON6068 C-3683#2PCB TERMINAL 3P P7.5 TP WE-12 I-753NA CON3068 C-3683#3PCB TERMINAL 4P P7.5 TP WE-13 I-754NA D001068 C-3963#21LED WIRE 200mm (BRN/BLK) CON2068

30、C-4422A01PCB TERMINAL 2P P=10 K1A,K2A068 TD04LG4P CONNECTOR WAFER J115069 4TR-2368BJUMPER PLATE 20mm AC01 069 C-4372A01 AC OUTLET CCT1304-0211 (120V only) GND069 C-4484A00EARTH LUG 501 E-1355-CPCB ASSY HJ1065 H2098S050SHEAD PHONE JACK 6.5F 9P (YKB26-5078) JP0068 B5B-EHCONNECTOR WAFER 5P 501 X-1300PC

31、B ASSY 014 C-4462A05FILTER BOARD 28X115 014 DB-151ORNAMENTAL CHASSIS X701023 CST10.0MTWCERAMIC RESONATOR IC701031 CXP82832-311QIC SMD (CPU) IC702031 HIN232CPIC (TRANSMITTER RECEIVER) IC904031 PC817X2IC (PHOTO COUPLER) IC705031 SBX3010-52BIC (REMOTE EYE) Q701,907032 TC536-FGTRANSISTOR 2SC536KAA-FG D7

32、01-706,708,714,914034 T1N4148-86DIODE 1N4148TAP-50 D709-712034 TRD12JST1ZENER DIODE 12V (AB2) FL701035 SVR-12MM18FL TUBE C708041 FYD0H224Z BACK-UP CAPACITOR 5.5V0.22F C722041 TUTES1A101-TFELECTROLYTIC CAPACITOR 10V100uF C707041 TUTES1E470-TFELECTROLYTIC CAPACITOR 25V47uF C713-717041 TUTES1H010-TFELE

33、CTROLYTIC CAPACITOR 50V1uF C718041 TUTES1H100-TFELECTROLYTIC CAPACITOR 50V10uF C719041 TUTES1HR22-TFELECTROLYTIC CAPACITOR 50V0.22uF C709-712,721043 TC50V101 CERAMIC CAPACITOR 50V100pF C701,702043 TC50V473 CERAMIC CAPACITOR 50V0.047uF C706044 50MSAN104JSTACKED FILM CAPACITOR 50V0.1uF R924,925053 CR1

34、6-100J-ACARBON RESISTOR 1/6W 10R R701,702,926053 CR16-101J-ACARBON RESISTOR 1/6W 100R R703-707,718,922,923053 CR16-102J-ACARBON RESISTOR 1/6W 1K 016 X-1300C01-04 PCB ASSY 016 E-1355A00 PCB ASSY Parts List 4/4 RC-1090 SYMBOLPARTS NO.DESCRIPTION R915053 CR16-103J-ACARBON RESISTOR 1/6W 10K R715053 CR16

35、-104J-ACARBON RESISTOR 1/6W 100K R914053 CR16-332J-ACARBON RESISTOR 1/6W 3.3K R714053 CR16-472J-ACARBON RESISTOR 1/6W 4.7K R709-713,720053 CR16-473J-ACARBON RESISTOR 1/6W 47K R719054 SE4473JTHICK FILM RS NETWORK 47K S701-708,711-718061 C-4679A03TACT SWITCH 5mm GRY HV061050GS HJ901-HJ905065 YKB21-510

36、3A3.5 MINIATURE JACK (ST) SKT1066 SY010-8P/KRJ45 TERMINAL (8P) JP14B068 B2B-EHCONNECTOR WAFER 2P JP13B068 B3B-EHCONNECTOR WAFER 3P JP4A068 B5B-PH-KSCONNECTOR WAFER 5P 011 FP-533-BSUB PANEL ASSY (BLACK) 011 FP-533-SSUB PANEL ASSY (SILVER) 011 TH3-01B00H/S PANEL 012 C-4711A01KNOB 43 W/LED (BLACK) 012

37、C-4711A01SKNOB 43 W/LED (SILVER) 012 RV4-09A00PUSH BUTTON 14 (BLACK) 012 RV4-09A01PUSH BUTTON 14 (SILVER) 012 TB3-18A00TACT BUTTON 16 KEY (BLACK) 012 TB3-18A01TACT BUTTON 16 KEY (SILVER) 014 C-4723B02UPPER COVER 015 RP-384BREAR CHASSIS 015 TH3-03C00FRONT CHASSIS 019 C-4714A00POWER KNOB RING 14 (BLAC

38、K) 019 C-4714A01POWER KNOB RING 14 (SILVER) 019 C-670#18FELT 56 019 PK4-07A00TMETAL FOOT 60 T001022 T-1083T03 (or 01)POWER TRANSFORMER 034 SEL1124RLED (RED) 1X5 034 SEL1E24WLED (BLU) 1X5 069 C-4629A01AC 2P INLET 6102.3100 (WIRING) 072 C-4621A03AC CORD SET SJT AWG16 for USA 072 C-4622A02AC CORD SET f

39、or AUSTRALIA 072 C-4623A02AC CORD SET for U.K. 072 C-4624A03AC CORD SET for EUROPE 081 TH3-11B00INSIDE CARTON 081 TH3-12B00SHIPPING CARTON 081 Z-204STYROL MOULDING 082 OMRC-1090-1OWNERS MANUAL (EFGISD) 092 RR-1050REMOTE CONTROL UNIT O T H E R S RC1090 SYMBOLPARTSDESCRIPTION 011 FP-533-BBLACK PANEL A

40、SSY 011 FP-533-SSILVER PANEL ASSY 011 TH3-01B00H/S PANEL H109 012 C-4711A01KNOB 43F (BLK) 012 C-4711A01SKNOB 43F (SLV) 012 RV4-09A00PUSH BUTTON 14F (BLK) 012 RV4-09A01PUSH BUTTON 14F (SLV) 012 TB3-18A00TACT BUTTON 16 KEY (BLK) 012 TB3-18A01TACT BUTTON 16 KEY (SLV) 034 SEL1124RLED (RED) 1X5 034 SEL1E

41、24WLED (BLU) 1X5 Addendum List for Black and Silver 3 1 2 Panel Assy is included: Panel Window Side Cap Knob Ring Tact buttons LED Case Outlines 2SA608K 2SA1016K 2SA1450 2SC536K 2SC2362K 2SC3708 2SD863 2SA1345 2SC3399 2SD786 2SB631K 2SA1209 2SD600K 2SC2911 LB1641 NJM78XXFANJM79XXFA PC817B Safety Cau

42、tion Cautions during Inspection and Repair 1. Keep in mind the safety warnings The safety instructions are shown as the labels or printings on the exterior, the inside chassis or the parts, etc. Refer to the instructions when proceeding with inspection or repair. 2. Use only the specified parts for

43、replacement The selected parts are used at critical area to reduce fire hazard or electrical shock. So when replacing these parts where designaged with marks or marks on the schmatic diagram or the parts list, ensure to use only the same parts. 3. Ensure to dress back the AC (Mains) cord to the orig

44、inal position If for some reason, the AC cord is moved or partially disassembled, ensure to re- route or assemble back to the original position. The AC cord area is protected and secured by tubing and insulation materials for the sake of safety, so that no loose wire will touch and cause fire hazard

45、 and electrical shock. 4. Check for safety aspects after inspection or repair Ensure all parts, such as screws or wires, removed during inspection or repair are secured back to the original positions, and check visually for any anomaly. Also check for any electrical leakage or resistance to maintain

46、 the safety. AD711JN AD712JN NE5534AN NJM4556AD TL071CP LC4966 HIN232CP TC74HC595AP TC9163AN CXP82832 PCB Assembly -1/3 RC-1090 016 X-1299F01 - 05Main PCB (1/2) Bottom Pattern Main PCB (2/2) Top Pattern016 X-1299F01 - 05 RC-1090 PCB Assembly -2/3 016 E-1355A00 Head Phone PCB 016 X-1300C01 - 04 RC-1090 PCB Assembly Schematic Diagram 1/2 RC-1090 Schematic Diagram 2/2 RC-1090