RCA-Victor-Co-Inc-R-14 电路原理图.pdf

《RCA-Victor-Co-Inc-R-14 电路原理图.pdf》由会员分享，可在线阅读，更多相关《RCA-Victor-Co-Inc-R-14 电路原理图.pdf（6页珍藏版）》请在收音机爱好者资料库上搜索。

1、PAGE 60-A MODELS R-14, R-15, RE -17, 42 &48 VICTOR MODELSRADIOLA VOLUME CONTROLDIAL RADIOLA 42 STATION SELECTOR OPERATING SWITCH TONE CONTROL VOLUMEDIALSTATION CONTROLSELECTOR ElectricalSpecifications RADIOLA 48 OPERATING SWITCH Voltage rating105 - 125 Volts Frequency rating25/40 and 50/60 cycles Po

2、wer consumption Radio only) Power consumption (Model RE -17) Type of circuit Type and Number of tubes4 UY 224, 2 UX 245,1 UX 280 Loudspeaker Wattage dissipation In L.S.Field 115 Watts 170 Watts ACScreen-grid, T.R.F. Elec tro-dynamic 10 Watts,(110 V. 85 M.A.) Undistorted output2.5 Watts Victor Model

3、R-14 is Victor Model R-15 is Victor Model RE -17 is equipment. identical to Radiola 42. identical to Radiola 48. Victor Model R-15 combined with Electrola record blaying RCA Radiola 42 is a four circuit, tuned radio frequency radio receiver utilizing the chassis and reproducer unit of Radiola 48 tog

4、ether with a tone control. The tone control is mounted on the side directly under the operating switch. It will be noted that a new volume control is used. The antenna section of this unit has a value of 25,000 ohms instead of 50,000 ohms as used in the Radiola 48. This volume con- trol is also bein

5、g used as a replacement in Radiola 48. The screen grid voltage section has a value of 10,000 ohms and the 12,000 ohm shunt resistor is not used. The 0.005 mfd. con- denser across the plates of Radiotrons UX-245 has been omitted due to the connection of the tone control in the same position.When maki

6、ng replacements of the condenser and reactor unit it will be necessary to clip the two leads that are connected to the .005 mfd. condenser close to the container.The reason for this is that the replacement unit supplied is suitable for either the Radiola 42or 48. RCA VICTOR DIVISION OF RADIO CORPORA

7、TION OF AMERICA, CAMDEN N. J., U. S. A. 收音机爱 好者资料库 RadioFans.CN PAGE 61-A R-14, R-15, RE -17, 42 & 48 3.0 SHIELD 4 -GANG CONDENSER., I4-224UY 224U3Y-282.4F. IM029. R.F.N 47- -t4on g Co e2 .11F -30A GROUND ./LEAD ALE GROUNDS ARE TO FRAME AND TO GROUND LEAD .75 MFD. N. IF-. 3.04 -,t 1 MF11 3.011. u9-2

8、24 9.DETECTOR 404= 0.1.74 -lira ,=. -1r 17,000 .164FD N. 25425n. 3 4 INTERNAL CONNECTIONS OFINTERNAL CONNECTIONS OF SY. PASS CONDENSERS s.V-MED. NECTIONS OF SY-PASS CONDENSERS 251). 25/1. R. F. CHOKE MOUNTING BOARD CONNECTIONS BY-PASS CONDENSERS ,430,0004 C197v i A Kt=Pa 430,000/1. WRITE AND GREEN 3

9、200 It BLACK .1640.041 LACI, AND GREY RESISTOR MOUNTING BOARD CONNECTIONS RtO TR&CEI IlE ESA VIIOw TAKER INTERNAL CONNECTIONS OF FILTER REACTOR Schematic wiring diagram UY- 224 DETECTOR fr000n d-0010 V 3 4 3 0 2541. 113011. 4 2 MFD. 1_065 9011. -.25 UFO. 200,00011. TOTAL -35 MFD. A25 WV -.1 MFD. 904

10、 9041. 320 IFMFD. - 75 164D. -200,00 ftA 15.000 / TOT -75 MF -.1 LIFO .025 MFD .025 MFD 32004 NYAA TOIMO -GO-, 0 MAI -25- TO ALL FILAMENTS mEATERS AND DIAL LAMP 00.245 POLOWLIEFRi RFIELD COIL CONE COIL j.,1330 .11, 2.5 IL I T3034 AL 1, 4:.)41 PS -Air . i pt 0.1 M 1.5 MFD 211. 1.AFL.11-.1512 .soon 1r

11、 IIf ssonToym. 0.1 UFO.JF OPERATING SITCN .-715.11. R-14 IL RADIOLA 42 .025 LIFO. 3 200 it 1.0 MF0.-60 MFD.-25-9 TO ALL FILAMENTS 1204 AVTDT LAMP 0 tt UN. 245 POWER IAMPLIFIER FIELD COIL 1330 IL , 330.11. TOTAL .4 I.5 MFD. ll 11-.N.15n 2.0 54fD.11.2%- .=.30041. V 0 530ILTOTAL O O 105125 VOLT 50.60.

12、A.C. V. 1200. PONER TRANSFORMER CONE COIL 2.5111, :005 MFD. .2.CL 0.1 MFD. OPERATING SWITCH 715A 105-125 VOLT 50.6x A.C. POWER TRANSFORMER Schematic circuit diagram. R-158 RADIOLA 48 .005 MFD., .025 MEP L.6 IUD. 4 .1 MFD. MFD. SIAFD.26- t 1_02 315,000. I HOLE .020 LIFO. ISOMER PRIMARY 4TOTAL -s., Ea

13、wcW M EN Mel 10104 REEMILVER IllAOL1114 IENE TRACER UM- 280 FILAMENTS NIGH VOLTAGE MErao.an530 II TOTAL KKR WITOI B oNNEORCIR RATERS. FILAMENTS AND re- DIAL LAMP INTERNAL CONNECTIONS OF OUTPUT TRANSFORMER. INTERNAL CONNECTIONS OF CAPACITOR AND COUPLING REACTOR PACK INTERNAL CONNECTIONS OF POWER TRAN

14、SFORMER 收音机爱 好者资料库 RadioFans.CN PAGE 6 2 -A R-14 R-15 RE -17 42 & 48 MAGNETIC PICK-UP TERMINAL STRIP FILTER REACTOR POWER. TRANSFORMER OUTPUT TRANSFORMER. DETECTOR STAGE TO ANTENNA 4-BLAcoe TO GROUNDow DIAL SCALE VOLUME CONTROL A.C. INPUT CORD 25,000.5. SECTION.svOLuhit CONTROL TPA. 10,000.N. -SECTI

15、ON BRAIDED SHIELD REVISED VOLUME CONTROL WIRING 3.R. F. STAGE 2_ R.F. STAGE - Is! R.F.STAGE CAPACITOR -AND COUPLING REACTOR UNIT -REPRODUCER UNIT Rear interior cabinet view with shields removed. The Victor Radio with Electrola RE -17 is a combina- tion of the four circuit radio equipment in the R -I

16、5, with the Electrola equipment, less home recording, of the RE -57. A transfer switch controls the change- over from radio to record operation.When the switch is in the Electrola position, the power detector Radiotron becomes a first stage audio amplifier, transformer coupled, by a change in the gr

17、id bias of this tube when a 600 ohm resistor is connected into the grid bias circuit.The screen grid voltage supply to the R. F. tubes is opened during record reproduction to prevent the possibility of obtaining both radio and record reproduction simultaneously. Electrola Terminal Strip Radio Chassi

18、s Terminal Board, showing Additional Connections for Motor ROO A TIMPIIRAL STRIP MOTS: IT HAT SI !OSAUDCRS/AMY TO PIACI A 1111OLPIORDMR OA OROS N MONO PISMO SOCIAARION DOOM PORS MOO TAMP stmcn -VNO Al RADIO-11/CR soros! PIER -VP !SPOT TRAAISPORPOR OP ROMA RATIO MR PICIVIJO DIM POOP PROOTORRAIO/1 VOl

19、ufAll CONTRA.PICK-UP MAGNETIC PICKUP CONNECTIONS 收音机爱 好者资料库 RadioFans.CN PAGE 63-A Stock No. 2722 DESCRIPTION 2723 2737 2741 2747 2786 2792 2793 2794 279 5 2796 2797 2798 2799 2800 2801 2802 2803 2804 280 5 2808 2807 7054 7066 7 10 5 7106 7 107 7108 710 9 7 110 7 111 Resistor - 55 ohm Mid -tapped fi

20、lament resis- tor. Switch -Power line operating switch - Toggle type - Package of 5. Escutcheon- Operating switch escutcheon - Package of 5. Idler - For Condenser drive cord - Package of 5. Cap-Contact cap for Radiotron UY-224 - Package of 5. Spring - Holding spring for Control Switch - Package of 1

21、0. Cable- Shielded twin conductor cable - 72 long - Shield 7 long (Antenna and ground leads). Cord -Shielded connector cord - 18-3/4 long. Resistor - 3200 ohms - Carbon type - Bleeder resistor - Package of 5. Resistor -12,000 ohms - Carbon type - Vol- ume control shunt resistor - Package of 5. Resis

22、tor - 16,000 ohms - Carbon type - Radio frequency screen grid series resistor- Package of 5. Resistor-17,000 ohms- Carbon type - De- tector bias resistor - Package of 5. Resistor - 200,000 ohms - Carbon type - De- tector screen grid resistor -Package of 5. Resistor - 430,000 ohms - Carbon type - Out

23、- put tube grid resistor - Package of 5. Spring-Tuningcondenser shield contact spring - Makes contact with motor shaft - Package of 10. Cord - Condenser drive cord - Package of 5. Clip - Contact clip - For maintaining con- tact between tuning condenser shield and cast portion of tuning condenser - P

24、ack- age of 10. Screw - Special hex. head - No. 4-40 machine screw -Used to adjust line-up condensers - Knob- stationselector or Volume control knob - Package of 5. Screen - Station selector screen- Package of 5. Support - Metal escutcheon for dial panel. Contact spring-Tuning condenser contact spri

25、ng - Located on cast partition of tun- ing condenser - Package of 5. Power Cord-Flexibletwin conductor cord with male connector. Wrench- Special end wrench for tuning con- denser line-up adjusting screw. Cable - Receiver wiring cable. Capacitor Pack-Detector by-pass capacitor pack-Comprising one 0.7

26、5 mfd. and one 0.27 mfd. capacitorsin metal containers. Capacitor Pack - Detector screen grid supply and heater busby-pass capacitor pack - Comprising two 0.1 mfd. capacitor in metal container. Capacitor Pack - Radiofrequency,cathode, screen grid and plate by-passcapacitor pack -Comprising three 0.1

27、 mfd. capacitors in metal containers. Clamp bar - Clamping bar for tuning conden- ser shield. Coil - R.F. plate supply filter coil mounted micarta strip. Coil - R.F. interstage filter coil assembly. R-14, R-15, RE -17, 42 & 48 Stock No. DESCRIPTION 7112 7 113 7 114 7 115 7 116 7117 7 118 7 119 7 120

28、 7 12 1 7122 7 123 7 124 7 125 7 126 7127 7128 7129 7130 7 150 7153 8571 8602 8604 8605 8606 8607 8608 8809 Transformer - Antenna transformer. Transformer - Interstage R.F. transformer. Condenser - Adjustableline-up condenser - Capacity 5 to 15 mmfd. Filter assembly- Detector plate filter- Comprisin

29、g 2 coils and 2 capacitors mount- ed on micarta strip. Resistor board assembly - Comprising micarta board with two 430,000 ohms, one 3200 ohm andone18,000 ohm resistors, with mount- ing screws, lockwashers and nuts. Resistor-Procelaintype voltage divider resistor - Comprising one 3200 ohm section an

30、d one 1665 ohm section tapped at 8.0.0 and 950 ohms. Shield - Metal shield for 1st,2,3d R.F. or Detector radiotrons - 2 sections - Cap anc sleeve. Shield- Metal shield for antenna or R.F. interstage transformers - 2 sections - Cap and sleeve. Shield- Metal shieldfor phonograph input terminal board.

31、Socket-Diallamp socketwithbracket, mounting screw, washer and nut. Socket - Single socket for Radiotron UX-280. Socket - Double socket for Radiotron UX-245. Socket - Single socket for Radiotron UY-224. Terminal strip - Distribution terminal strip for A.C. line and tapped filter inductor - Comprising

32、 micarta strip with 8 terminals, mounting screws lockwashers and nuts. Terminal strip-Heaterbusdistribution terminal strip- Comprising micarta strip with 2 terminals, mounting screws,lock - washers and nuts. Terminal strip - Phonographinput terminal strip- Comprising micarta strip with 4 terminals,

33、mounting brackets, screws, wash- ers and nuts. Scale - Dial scale - Package of 5. Volume control- Two units- With mounting washersand nuts(For 60 cyclel Grille cloth and baffle board - Assembled. Wrench - Special combination open end wrench and screw driver - For adjusting line-up condensers. Volume

34、 control- With mounting washers and nut (For 25 cycle). Transformer - Power transformer - 220 volt - 60 cycle. Condenser - Tuning condenser assembly - Com- prising 4 condensers, drive,drive cord, spring dial drum,dial lamp, socket and bracket and 4adjustableline-upCondensers. Inductor - Tapped filte

35、r inductorin metal container - Used as Filter reactor. Shield- Metal shield for tuning condenser assembly. Shield -Metal shield for (7106 and 7107) De- tector by-pass capacitors. Shield - Metal shield for R.F. Filter coil and by-pass capacitor packs. Transformer and Capacitorassembly -Compris- ingin

36、terstage transformer one 2 mfd. and 0.1 mfd., one 1.5 mfd., one 1 mfd., two0.025 mfd. and one 0.005 mfd. capacitors in metal container - For 60 cycle. Transformer- Power transformer - 105-125 volts - 60 cycles. PAGE 64-A R-14, R-15, RE -17, 42 & 48 Stock No.DESCRIPTION Stock No.DESCRIPTION 2804 2825

37、 2827 2828 2829 2872 2873 2947 3,218 3052 7077 7078 7085 7088 7087 70 88 7093 7147 7148 7151 8582 10174 10181 10184 10196 10289 10378 10688 10695 10879 10882 7092 10901 10904 10905 10906 10922 10923 10924 10946 11057 Knob - Transfer switch or Pickup volume con- trol knob - package of 5. Connector bl

38、ock - pickup connector block and wire. Resistor- Motor resistor- 38 ohms for 25 cycles. Screw assembly -pickup mounting screw, washer and nut - package of 10 sets. Knob - Motor board lifting knob with screw - Package of 2. Governor Balls-Governor balls and spring with mounting washers and screws - S

39、crew assembly - Top plate, screws, washer, nut and ball bearing - Package of 5 sets. Leather -Brake frictionleather -package of 20 Resistor- Carbon type - 600 ohms - Screw assembly - Pickup pole piece mounting screw, washer and nut -package of 10 sets. Regulator-Speed regulator escutcheon and screw,

40、 with mounting screws -Package of 2. Volume control-Pickup volume control- Complete less knob. Pickup - pickup unit complete. Lever - Regulator lever - package of2. Gear-Turntable spindlegovernor driving gear with set screw. Disc - Rotor disc with set screw. Cover - pickup unit cover. Inductor - mot

41、or inductor- 110 volts - 25 cycles. Capacitor - Motor capacitor for 25 cycles. Back - Pickup unit back. Turntable - Turntable with cover. Springs - Brake springs - Set of 4 springs Package of 2 sets. Brake - Complete - Less switch with mounting screws. Plate -Brakelatch plate and 2 mounting screws -

42、 package of 5. Spring - Regulator shaft spring - package of 10. Governor-Complete- Comprising spindle, collar, friction Disc, balls and springs - Assembled. Top plate. Screw and washer - Motor board mounting screw and finishing washer - package of 10. Cup - Needle cup - package of 2. panel - Cabinet

43、 front panel. Escutcheon - Tuning escutcheon. Arm - Pickup arm and base (less unit) with mounting screws. Spring - Lid support spring - package of 2. Cushion - Lid cushion - package of 20. Ratchet - Lid support ratchet and bracket. Support - Lid support - Complete. Switch -Radio -Record transfer swi

44、tch -Complete - Less knob. Transformer - pickup input transformer. Inductor - Motor inductor- 110 volts, 60 cycles. Foot - Cabinet foot. Dial Screen 8814 8615 10778 10834 10863 10884 10887 2791 7103 7104 8559 8599 8600 8801 10885 10887 10888 10890 10885 10887 10888 10889 10891 11057 2814 2820 2749 2

45、759 2762 2763 2784 2765 2788 2767 2768 2789 2771 27 73 2774 2778 2781 2785 27 86 Transformer and Capacitor assembly -Compris- ing interstage transformer, one 3mfd., one 1.15 mfd., one 2. mfd., one 0.1 mfd., two 0.025 mfd. and one 0.005 mfd. in metal con- tainer (For 25 cycle). Transformer- power tra

46、nsformer - 105-125 volt - 25 cycle. Shield - Detector plate filter shield. Clip - Tube socket clip - Package of 10. Shaft - Drive shaft - Package of 2. Shaft - Idler shaft - Package of 5. Spring - Drive cord spring - Package of 5. LOUDSPEAKER ASSEMBLY Ring -Field coil spacing ring -One set of 2. Bol

47、t - Nut and lockwasher assembly - One set of 4. Transformer -Output transformer with spacers, lockwashers and nuts. Ring - Cone retaining ring. Coil - Field coil. Support - Metal cone support with terminal board. Cone -Complete with Voice coil -package of 5. SPECIAL PARTS FOR RCA RADIOLA Condenser -

48、Tone controlcondenser -0.05mfd. Knob - Tone control knob - package of 5. Control - Tone control - Less knob. Grille - Grille cloth and baffle board. SPECIAL PARTSFOR VICTOR RADIO R-14 Condenser - Tone control condenser 0.05 mfd. Knob - Tone control knob - package of 5. - Tone control - Complete less

49、 knob. Escutcheon - Tuning escutcheon. Scale - Tuning dial scale. Screen - Dial screen. SPECIAL PARTS FOR RE -17 Switch - Brake motor switch. Cushion - pickup rubber cushions- Set of damper and 2 pivot cushions - package of set. Capacitor-pickup transformer condenser 2400 mmfd. Box - Needle box with lid - package of 2. Bearing assembly - Governor bearing assembly Comprising 2 bearings, 2 set screws and 2 ball bearings - Package of 3 sets. Bolt assembly - Motor mounting screw, rubber washer and cushion, Washers and nut -pack- age ofi set. Spindle - Turntab