Aiwa-CDC-X2170-X3170-X4170-Service-Manual 电路图 维修手册.pdf

《Aiwa-CDC-X2170-X3170-X4170-Service-Manual 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Aiwa-CDC-X2170-X3170-X4170-Service-Manual 电路图 维修手册.pdf（41页珍藏版）》请在收音机爱好者资料库上搜索。

1、SERVICE MANUAL DATA STEREO CAR CD RECEIVER CDC-X217 CDC-X2170 CDC-X3170 CDC-X4170 YZ YL YL YL S/M Code No. 09-012-441-1R2 REVISION BASIC CD MECHANISM: TN-CCD1001Z-152J This Service Manual is the “Revision Publishing” and replaces “Simple Manual” of CDC-X217 / X2170 / X3170 / X4170, (S/M Code No. 09-

2、011-441-1T2). RadioFans.CN 收音机爱 好者资料库 2 SPECIFICATIONS RADIO SECTION (FM) Frequency Range87.5 MHz 108 MHz (100-kHz steps)* 87.5 MHz 108 MHz (50-kHz steps)* Usable Sensitivity12.7 dBf 50 dB Quieting Sensitivity 17.2 dBf IF Rejection80 dB Frequency Response30 Hz 15,000 Hz S/N Ratio63 dB Stereo Separat

3、ion35 dB at 1 kHz Alternate Channel Selectivity 70 dB Capture Ratio3 dB (AM) Frequency Range530 kHz 1,710 kHz (10-kHz steps)* 531 kHz 1,602 kHz (9-kHz steps)* Usable Sensitivity30 V (30 dB) 9K 10K * Set the frequency increment for your area using the switch on the bottom of the unit. (The switch is

4、set at the factory to the 10k position.) RADIO SECTION (FM) Frequency Range87.5 MHz 108 MHz (50-kHz steps) Usable Sensitivity12.7 dBf 50 dB Quieting Sensitivity 17.2 dBf IF Rejection80 dB Frequency Response30 Hz 15,000 Hz S/N Ratio63 dB Stereo Separation35 dB at 1 kHz Alternate Channel Selectivity 7

5、0 dB Capture Ratio3 dB (MW) Frequency Range530 kHz 1,710 kHz (10-kHz steps)* 531 kHz 1,602 kHz (9-kHz steps)* Usable Sensitivity30 V (30 dB) (LW) Frequency Range144 kHz 288 kHz (1-kHz / 9-kHz steps)* Usable Sensitivity30 V (30 dB) 9K 10K * Set the frequency increment for your area using the switch o

6、n the bottom of the unit. (The switch is set at the factory to the 9k position.) CD SECTION Frequency Response17 Hz 20 kHz +0/3 dB Dynamic RangeMore than 80 dB Channel SeparationMore than 65 dB S/N RatioMore than 85 dB Wow/FlutterUnmeasurable AUDIO SECTION Max. Power Output45 W x 4 channels AUX IN i

7、nput Input Sensitivity (load impedance) AUX IN300 mV (10 k) GENERAL Power Supply Voltage14.4 V (11 to 16 V allowable), DC, negative ground Load Impedance4 Tone ControlBass 10 dB at 100 Hz Treble 10 dB at 10 kHz Preamp Output Voltage (load impedance) 2.2 V (10 k) Installation Size182 (W) x 53 (H) x 1

8、55 (D) mm (71/4 (W) x 21/8 (H) x 61/8 (D) inches) STEERING-WHEEL-MOUNTED REMOTE CONTROL UNIT DimensionsApprox. 67 (W) x 26 (H) x 27 (D) mm (23/4 (W) x 11/16 (H) x 11/8 (D) inches) (excluding holder) WeightApprox. 38g (1.33 oz.) (including holder, battery) Design and specifications are subject to cha

9、nge without notice. RadioFans.CN 收音机爱 好者资料库 3 Precaution to replace Optical block (OPTIMA-720L1E) Body or clothes electrostatic potential could ruin laser diode in the optical block. Be sure ground body and workbench, and use care the clothes do not touch the diode. 1) After the connection, remove s

10、older shown in right figure. CLASS 1LASER PRODUCT KLASSE 1LASER PRODUKT LUOKAN 1LASER LAITE KLASS 1LASER APPARAT This set employs laser. Therefore, be sure to follow carefully the instructions below when servicing. WARNING! WHEN SERVICING, DO NOT APPROACH THE LASER EXIT WITH THE EYE TOO CLOSELY. IN

11、CASE IT IS NECESSARY TO CONFIRM LASER BEAM EMISSION. BE SURE TO OBSERVE FROM A DISTANCE OF MORE THAN 30cm FROM THE SURFACE OF THE OBJEC- TIVE LENS ON THE OPTICAL PICK-UP BLOCK. sCaution: Invisible laser radiation when open and interlocks defeated avoid exposure to beam. sAdvarsel: Usynlig laserstlin

12、g ved bning, nr sikkerhedsafbrydere er ude af funktion. Undg udsttelse for strling. VAROITUS! Laiteen Kyttminen muulla kuin tss kyttohjeessa mainitulla tavalla saataa altistaa kyt-tjn turvallisuusluokan 1 ylittvlle nkymttmlle lasersteilylle. VARNING! Om apparaten anvnds p annat stt n vad som specifi

13、ceras i denna bruksanvising, kan anvndaren utsttas fr osynling laserstrlning, som verskrider grnsen fr laserklass 1. PROTECTION OF EYES FROM LASER BEAM DURING SERVICING CAUTION Use of controls or adjustments or performance of proce- dures other than those specified herin may result in hazardous radi

14、ation exposure. ATTENTION Lutillisation de commandes, rglages ou procdures autres que ceux spcifis peut entraner une dangereuse exposition aux radiations. ADVARSEL Usynlig laserstling ved bning, nr sikkerhedsafbrydereer ude af funktion. Undg udsttelse for strling. This Compact Disc player is classif

15、ied as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT label is located on the rear exterior. PICK-UP ASSY PWB Solder RadioFans.CN 收音机爱 好者资料库 CAUTION WHEN SERVICING (1) Using extension jigs When the function of CD mechanism (TN-CCD1001Z-152J) is checked, connect between MAIN P.W.B and CD mechanis

16、m with the extension jigs. As the connection connector has no polar directions, check the direction of the circuit board (BKC-JIG1/2) when installing. (Refer to the PIN number in the above photo.) Parts nameJIG-BKCParts numberSV-J00-106-010 4 Extension jig MAIN P.W.B BKC-JIG(1) Bottom View CD Mechan

17、ism 13 14 26 1 14 113 26 BKC-JIG(2) KANRI NO. REF. NO.DESCRIPTIONPART NO.KANRI NO. REF. NO.DESCRIPTIONPART NO. 5 ELETRICAL MAIN PARTS LIST IC 87-A20-446-010 C-IC,LA9241ML 87-A21-319-010 C-IC,LC78622NE 87-A21-488-040 C-IC,LA6556 8Z-KT1-622-010 C-IC,LC75374E 87-A21-562-010 IC,LA4743B 88-KT1-606-080 IC

18、,PST994D 87-A21-906-030 C-IC,LC72358N-9A04 87-A21-934-030 C-IC,LC72358N-9A12 87-A21-489-030 C-IC,LC75853NW 87-A90-951-010 RCR UNIT,SBX1971-52 TRANSISTOR 89-324-122-040 C-TR,2SC2412KR 87-A30-289-040 C-TR,2SA1037AK(R) 87-A30-288-040 C-TR,DTC114YKA 87-A30-287-040 C-TR,DTC114TKA 87-A30-435-040 C-TR,DTC1

19、44EKA 87-A30-299-080 TR,2SB1326 87-A30-282-040 C-TR,DTA114TKA 89-213-750-010 TR,2SB1375 (25W) 89-420-120-010 TR,2SD2012 (25W) 87-A30-427-040 C-TR,DTC114EKA 87-A30-301-080 TR,2SD1862 DIODE 87-A40-250-040 C-DIODE,DAN217 87-001-783-080 DIODE,1N4002 87-020-331-080 CHIP-DIODE,DAN202K 87-A40-650-080 ZENER

20、,MTZJ6.8A 87-A40-523-080 ZENER,MTZJ9.1B 87-070-136-080 ZENER,MTZJ5.1B 87-017-932-080 ZENER,MTZJ6.2B 87-070-334-080 ZENER,MTZJ10B 87-A40-798-010 DIODE,1N5402 (3A/200V) 87-A40-817-040 C-ZENER,STZ6.8N MAIN C.B C101 87-012-274-080 CHIP CAP,U 1000P-50B C102 87-012-286-080 CAP, U 0.01-25 C103 87-010-495-0

21、40 CAP,E 2.2-50 GAS C106 87-012-282-080 CAP, U 4700P-50 C107 87-010-552-040 CAP,E 22-16 GAS C108 87-012-195-080 C-CAP,U 100P-50CH C109 87-010-553-040 CAP,E 47-16 GAS C110 87-010-787-080 CAP, U 0.022-25 C111 87-010-553-040 CAP,E 47-16 GAS C112 87-012-281-080 C-CAP,U 3900P-50 B C113 87-012-286-080 CAP

22、, U 0.01-25 C114 87-010-759-080 C-CAP,U, 0.1-25F C115 87-010-759-080 C-CAP,U, 0.1-25F C116 87-010-759-080 C-CAP,U, 0.1-25F C131 87-A11-228-080 C-CAP,U 0.027-25 K B C131 87-010-786-080 C-CAP,U 0.018-25 K B C132 87-A11-228-080 C-CAP,U 0.027-25 K B C132 87-010-786-080 C-CAP,U 0.018-25 K B C133 87-A10-7

23、07-080 C-CAP,U 0.47U-16 F Z C134 87-A10-707-080 C-CAP,U 0.47U-16 F Z C140 87-012-282-080 CAP, U 4700P-50 C173 87-012-195-080 C-CAP,U 100P-50CH C176 87-012-286-080 CAP, U 0.01-25 C201 87-010-553-040 CAP,E 47-16 GAS C202 87-010-553-040 CAP,E 47-16 GAS C203 87-012-274-080 CHIP CAP,U 1000P-50B C204 87-A

24、10-260-080 C-CAP,U 0.1-16 K B C205 87-A10-353-080 C-CAP,U0.22-10KB C206 87-010-492-040 CAP,E 0.33-50 GAS C207 87-010-956-080 CHIP-CAP,S 0.068-25B C208 87-012-272-080 C-CAP,U 680P-50 B C209 87-A10-504-080 C-CAP,U 0.047-16 K B C210 87-A10-260-080 C-CAP,U 0.1-16 K B C211 87-010-498-040 CAP,E 10-16 GAS

25、C212 87-012-276-080 CAP, CHIP SS 1500 PBK C213 87-A10-504-080 C-CAP,U 0.047-16 K B C214 87-A10-260-080 C-CAP,U 0.1-16 K B C215 87-012-278-080 C-CAP,U 2200P-50 B C216 87-A10-353-080 C-CAP,U0.22-10KB C217 87-A10-260-080 C-CAP,U 0.1-16 K B C218 87-010-787-080 CAP, U 0.022-25 C219 87-012-268-080 C-CAP,U

26、 330P-50 B C220 87-012-280-080 CAP, U 3300P-50 C221 87-012-195-080 C-CAP,U 100P-50CH C222 87-010-492-040 CAP,E 0.33-50 GAS C223 87-010-067-040 CAP,E 0.1-50 5L C224 87-010-553-040 CAP,E 47-16 GAS C225 87-012-280-080 CAP, U 3300P-50 C226 87-010-497-040 CAP,E 4.7-35 GAS C227 87-010-555-040 CAP,E 100-10

27、 GAS C228 87-A10-260-080 C-CAP,U 0.1-16 K B C229 87-010-498-040 CAP,E 10-16 GAS C230 87-A10-260-080 C-CAP,U 0.1-16 K B C231 87-010-555-040 CAP,E 100-10 GAS C232 87-A10-260-080 C-CAP,U 0.1-16 K B C233 87-010-555-040 CAP,E 100-10 GAS C234 87-010-828-080 CHIP CAPACITOR,U 0.033-25F C235 87-A10-504-080 C

28、-CAP,U 0.047-16 K B C236 87-010-067-040 CAP,E 0.1-50 5L C237 87-010-553-040 CAP,E 47-16 GAS C238 87-012-286-080 CAP, U 0.01-25 C240 87-A10-260-080 C-CAP,U 0.1-16 K B C250 87-A10-047-080 C-CAP,U 1-10 Z F C251 87-010-555-040 CAP,E 100-10 GAS C252 87-A10-260-080 C-CAP,U 0.1-16 K B C253 87-A10-260-080 C

29、-CAP,U 0.1-16 K B C254 87-A10-260-080 C-CAP,U 0.1-16 K B C256 87-012-282-080 CAP, U 4700P-50 C258 87-012-168-080 C-CAP,U 6P-50 CH C259 87-012-184-080 C-CAP,U 33P-50 CH C261 87-012-199-080 CAP 220P C262 87-A10-260-080 C-CAP,U 0.1-16 K B C263 87-010-555-040 CAP,E 100-10 GAS C264 87-010-555-040 CAP,E 1

30、00-10 GAS C265 87-A10-260-080 C-CAP,U 0.1-16 K B C266 87-A10-260-080 C-CAP,U 0.1-16 K B C267 87-010-498-040 CAP,E 10-16 GAS C268 87-010-498-040 CAP,E 10-16 GAS C269 87-012-276-080 CAP, CHIP SS 1500 PBK C270 87-012-276-080 CAP, CHIP SS 1500 PBK C271 87-012-172-080 CAPACITOR CHIP U 10P CH C272 87-012-

31、172-080 CAPACITOR CHIP U 10P CH C273 87-010-494-040 CAP,E 1-50 GAS C274 87-010-494-040 CAP,E 1-50 GAS C280 87-A10-189-040 CAP,E 220-10 C281 87-010-555-040 CAP,E 100-10 GAS C282 87-A10-260-080 C-CAP,U 0.1-16 K B C301 87-010-498-040 CAP,E 10-16 GAS C302 87-010-498-040 CAP,E 10-16 GAS C303 87-010-494-0

32、40 CAP,E 1-50 GAS C304 87-010-494-040 CAP,E 1-50 GAS C305 87-012-280-080 CAP, U 3300P-50 C306 87-012-280-080 CAP, U 3300P-50 C307 87-010-198-080 CAP, CHIP 0.022 C308 87-010-198-080 CAP, CHIP 0.022 C309 87-010-498-040 CAP,E 10-16 GAS C310 87-010-498-040 CAP,E 10-16 GAS C311 87-A10-781-080 C-CAP,U 0.1

33、5-10 K B C312 87-A10-781-080 C-CAP,U 0.15-10 K B KANRI NO. REF. NO.DESCRIPTIONPART NO.KANRI NO. REF. NO.DESCRIPTIONPART NO. 6 ! C313 87-A10-781-080 C-CAP,U 0.15-10 K B C314 87-A10-781-080 C-CAP,U 0.15-10 K B C315 87-010-498-040 CAP,E 10-16 GAS C316 87-010-498-040 CAP,E 10-16 GAS C321 87-010-759-080

34、C-CAP,U, 0.1-25F C322 87-010-555-040 CAP,E 100-10 GAS C323 87-010-759-080 C-CAP,U, 0.1-25F C324 87-010-498-040 CAP,E 10-16 GAS C331 87-A10-707-080 C-CAP,U 0.47U-16 F Z C332 87-A10-707-080 C-CAP,U 0.47U-16 F Z C333 87-010-759-080 C-CAP,U, 0.1-25F C334 87-010-759-080 C-CAP,U, 0.1-25F C351 87-010-494-0

35、40 CAP,E 1-50 GAS C352 87-010-494-040 CAP,E 1-50 GAS C353 87-010-494-040 CAP,E 1-50 GAS C354 87-010-494-040 CAP,E 1-50 GAS C361 87-A10-707-080 C-CAP,U 0.47U-16 F Z C362 87-A10-707-080 C-CAP,U 0.47U-16 F Z C363 87-A10-707-080 C-CAP,U 0.47U-16 F Z C364 87-A10-707-080 C-CAP,U 0.47U-16 F Z C365 87-012-2

36、71-080 CAP, U 560P-50 C366 87-012-271-080 CAP, U 560P-50 C367 87-012-271-080 CAP, U 560P-50 C368 87-012-271-080 CAP, U 560P-50 C451 87-010-498-040 CAP,E 10-16 GAS C452 87-010-498-040 CAP,E 10-16 GAS C453 87-010-498-040 CAP,E 10-16 GAS C454 87-010-498-040 CAP,E 10-16 GAS C455 87-012-270-080 CAP, U 47

37、0P-50 C456 87-012-270-080 CAP, U 470P-50 C457 87-012-270-080 CAP, U 470P-50 C458 87-012-270-080 CAP, U 470P-50 C511 8A-KC7-623-000 CAP,E 2200U-16 BT(125C) C512 87-010-759-080 C-CAP,U, 0.1-25F C513 87-010-759-080 C-CAP,U, 0.1-25F C514 87-010-553-040 CAP,E 47-16 GAS C515 87-010-498-040 CAP,E 10-16 GAS

38、 C516 87-012-274-080 CHIP CAP,U 1000P-50B C519 87-010-494-040 CAP,E 1-50 GAS C531 87-A12-317-080 C-CAP,U 0.1-50 Z F C532 87-A12-317-080 C-CAP,U 0.1-50 Z F C533 87-A12-317-080 C-CAP,U 0.1-50 Z F C534 87-A12-317-080 C-CAP,U 0.1-50 Z F C551 87-010-553-040 CAP,E 47-16 GAS C590 87-012-274-080 CHIP CAP,U

39、1000P-50B C621 87-010-553-040 CAP,E 47-16 GAS C622 87-010-553-040 CAP,E 47-16 GAS C641 87-010-759-080 C-CAP,U, 0.1-25F C642 87-010-759-080 C-CAP,U, 0.1-25F C671 87-010-787-080 CAP, U 0.022-25 C672 87-010-555-040 CAP,E 100-10 GAS C673 87-010-553-040 CAP,E 47-16 GAS C674 87-010-787-080 CAP, U 0.022-25

40、 C681 87-010-553-040 CAP,E 47-16 GAS C682 87-010-787-080 CAP, U 0.022-25 C701 87-012-182-080 C-CAP,U 27P-50 CH C702 87-012-180-080 C-CAP,U 22P-50 CH C706 87-010-497-040 CAP,E 4.7-35 GAS C711 87-012-195-080 C-CAP,U 100P-50CH C712 87-012-195-080 C-CAP,U 100P-50CH C761 87-010-555-040 CAP,E 100-10 GAS C

41、763 87-010-759-080 C-CAP,U, 0.1-25F C765 87-010-555-080 CAP,E 100-10 GAS C771 87-012-199-080 CAP 220P C831 87-010-494-040 CAP,E 1-50 GAS C832 87-010-494-040 CAP,E 1-50 GAS C835 87-012-278-080 C-CAP,U 2200P-50 B C836 87-012-278-080 C-CAP,U 2200P-50 B C881 87-012-278-080 C-CAP,U 2200P-50 B C882 87-012

42、-278-080 C-CAP,U 2200P-50 B C883 87-012-278-080 C-CAP,U 2200P-50 B C884 87-012-278-080 C-CAP,U 2200P-50 B C885 87-010-759-080 C-CAP,U, 0.1-25F CNA1 8A-KT1-646-010 CONN ASSY,8P ISO-WHITE-B CNA2 8A-KT1-645-010 CONN ASSY,8P ISO-BLACK-B CON201 87-A61-507-010 CONN,26P TKC-W26P-A1 CON851 88-KTA-603-010 CO

43、NN,15P CAM-B68 CON881 8Z-KT1-611-010 CONN,16P CAM-B51 F881 8Z-KC1-621-010 FUSE,15A 32V FC201 8B-KCF-611-010 F-CABLE,2P 55MM J101 8Z-KT1-614-010 ANT,AW-002 J451 87-A61-225-110 JACK,PIN 2P XR-401 J451 87-A61-224-110 JACK,PIN 4P XR-401 L101 87-003-143-080 COIL 4.7 UH L102 8Z-KT1-619-010 COIL,68MH K7-D

44、L461 87-003-143-080 COIL 4.7 UH L671 87-003-149-080 COIL,47UH L831 87-003-143-080 COIL 4.7 UH L881 8B-KCF-615-010 FLTR,AMORPHOUS -CHOKE LED702 87-027-262-010 LED,TLR-124(RED) SW701 87-A91-070-010 SW,TACT SKHHLV SW702 87-A91-152-010 SW,SL 1-1-2 SSSS212-11-A TU101 8B-KCF-621-010 TU UNIT, FAE347-A22 TU

45、101 8B-KCF-622-010 TU UNIT, FAE347-A21 X201 81-592-641-010 VIB,CER 16.93MHZ X701 87-A70-175-010 VIB,XTAL 4.5MHZ AT-49 FRONT C.B C901 87-A10-047-080 C-CAP,U 1-10 Z F C902 87-A10-504-080 C-CAP,U 0.047-16 K B C903 87-A10-504-080 C-CAP,U 0.047-16 K B C904 87-012-273-080 C-CAP,U 820P-50 B C905 87-A10-260

46、-080 C-CAP,U 0.1-16 K B C971 87-A10-260-080 C-CAP,U 0.1-16 K B CON901 88-KTA-602-010 CONN,15P CAM-B67 LCD901 8B-KCF-610-010 LCD,BKC-F-G-H LED951 87-A91-355-040 C-LED,BR1112H-TR-RED LED952 87-A91-355-040 C-LED,BR1112H-TR-RED LED961 87-A40-813-240 C-LED,SEC1E01C BLU LED962 87-A40-813-240 C-LED,SEC1E01C BLU LED963 87-A40-813-240 C-LED,SEC1E01C BLU LED981 87-A91-355-040 C-LED,BR1112H-TR-RED LED982 87-A91-355-040 C-LED,BR1112H-TR-RED LED983 87-A91-355-040 C-LED,BR1112H-TR-RED PL901 8B-KCF-631-010 LAMP,9V-65MA PL902 8B-KCF-631-010 LAMP,9V-65MA SW901 87-A91-987-080 SW,TACT SKQCAB SW902 87-A91-987-