Aiwa-CS-P55-Service-Manual 电路图 维修手册.pdf

《Aiwa-CS-P55-Service-Manual 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Aiwa-CS-P55-Service-Manual 电路图 维修手册.pdf（14页珍藏版）》请在收音机爱好者资料库上搜索。

1、BASIC TAPE MECHANISM : TN-9ZR-215 STEREO RADIO CASSETTE RECORDER CS-P55 S/M Code No. 09-994-328-1R2 AHEJ(S) SERVICE MANUAL REVISION DATA This Service Manual is the Revision Publishing and replaces Simple Manual (S/M Code No. 09-994-328-3T3). RadioFans.CN 收音机爱 好者资料库 2 SPECIFICATIONS Design and specif

2、ications are subject to change without notice. RadioFans.CN 收音机爱 好者资料库 3 REF. NOPART NO.KANRIDESCRIPTION NO. REF. NOPART NO.KANRIDESCRIPTION NO. ELECTRICAL MAIN PARTS LIST IC 87-A20-955-010 IC,LA1828 87-027-761-010 IC,AN7310 86-YW2-618-010 IC,KA2209 87-A20-946-040 C-IC,MM1434XF 88-CS7-613-010 IC,KA2

3、402 TRANSISTOR 89-319-233-080 TR,2SC1923 (0.1W) 87-CD7-603-080 TR,SS8050 87-A30-092-080 2SK439F DIODE 87-070-345-080 DIODE,IN4148 87-A40-574-080 ZENER,MTZJ3.0A 87-017-074-080 ZENER,HZS3B3 87-A40-398-010 DIODE,1N4001 MAIN C.B C101 87-A10-140-010 CAP,CER 22P-50 K CH C103 87-A10-140-010 CAP,CER 22P-50

4、K CH C104 87-A10-129-010 CAP,3P-50 C106 87-A10-576-080 CAP,CER 0.01-50 Z YF C107 88-254-122-010 CAP CERA,NPO,12P C108 87-018-132-080 CAP, CER 2200P-16V C109 87-A10-576-080 CAP,CER 0.01-50 Z YF C110 87-018-132-080 CAP, CER 2200P-16V C111 88-254-122-010 CAP CERA,NPO,12P C113 87-018-142-080 CAP,TC-U 3.

5、9P-50 CH C114 87-010-400-080 CAP, ELECT 0.47-50V C116 87-018-132-080 CAP, CER 2200P-16V C117 87-A10-181-010 CAP,CER 6800P-50 M D C118 87-010-545-080 CAP, ELECT 0.22-50V C119 87-010-400-080 CAP, ELECT 0.47-50V C120 87-010-403-080 CAP, ELECT 3.3-50V C122 87-018-132-080 CAP, CER 2200P-16V C125 87-010-5

6、45-080 CAP, ELECT 0.22-50V C126 87-010-545-080 CAP, ELECT 0.22-50V C127 87-010-378-080 CAP, ELECT 10-16V C128 87-018-208-080 CAP 0.047-50F C129 87-018-208-080 CAP 0.047-50F C130 87-010-248-080 CAP, ELECT 220-10V C131 87-010-379-080 CAP, ELECT 22-16V C132 87-A10-132-010 CAP,CER 6P-50 K CH C136 87-018

7、-205-080 CAP, CERA-SOL 0.022 C138 87-018-209-080 CAP, CER 0.1-50V C140 87-018-131-080 CAP, CER 1000P-50V C141 87-018-131-080 CAP, CER 1000P-50V C203 87-010-404-080 CAP, ELECT 4.7-50V C204 87-010-404-080 CAP, ELECT 4.7-50V C205 87-010-263-080 CAP, ELECT 100-10V C207 87-010-074-080 CAP,E 4.7-35 5L C20

8、8 87-010-264-080 CAP,E 100-10 5L C209 87-010-404-080 CAP, ELECT 4.7-50V C211 87-010-263-080 CAP, ELECT 100-10V C216 87-A10-168-010 CAP,CER 220P-50 K B C217 87-A10-168-010 CAP,CER 220P-50 K B C223 87-010-248-080 CAP, ELECT 220-10V C226 87-A10-576-010 CAP,CER 0.01-50 Z YF C227 87-A10-576-010 CAP,CER 0

9、.01-50 Z YF C228 87-010-400-080 CAP, ELECT 0.47-50V C229 87-010-400-080 CAP, ELECT 0.47-50V C230 87-010-221-080 CAP, ELECT 470-10V C231 87-010-412-080 CAP,E 10-25 5L C253 87-A10-168-010 CAP,CER 220P-50 K B C254 87-A10-168-010 CAP,CER 220P-50 K B C301 87-010-400-080 CAP, ELECT 0.47-50V C302 87-010-40

10、0-080 CAP, ELECT 0.47-50V C303 87-010-248-080 CAP, ELECT 220-10V C305 87-010-402-080 CAP, ELECT 2.2-50V C306 87-010-400-080 CAP, ELECT 0.47-50V C307 87-010-400-080 CAP, ELECT 0.47-50V C317 87-010-401-080 CAP, ELECT 1-50V C318 87-010-401-080 CAP, ELECT 1-50V C319 87-018-131-080 CAP, CER 1000P-50V C32

11、0 87-018-131-080 CAP, CER 1000P-50V C321 87-010-263-080 CAP, ELECT 100-10V C322 87-010-263-080 CAP, ELECT 100-10V C323 87-018-209-080 CAP, CER 0.1-50V C324 87-010-375-080 CAP,E 330-10 SME C325 87-012-348-010 CAP,CER 0.1-50 F C326 87-012-348-010 CAP,CER 0.1-50 F C327 87-010-375-080 CAP,E 330-10 SME C

12、328 87-010-375-080 CAP,E 330-10 SME C332 87-010-263-080 CAP, ELECT 100-10V C334 87-010-248-080 CAP, ELECT 220-10V C335 87-010-376-080 CAP,E 2200-10 M SME C336 87-018-209-080 CAP, CER 0.1-50V C340 87-010-374-080 CAP, ELECT 47-10V C342 87-010-248-080 CAP, ELECT 220-10V C343 87-A11-128-080 4700P-16V D1

13、03 87-A40-226-080 VARI-CAP,SVC251SPA CF101 88-CS8-632-010 FLTR,CERAMIC CFAL-455(TOKO) CF102 88-CS8-631-010 FLTR,CERAMIC SFE10.7MS2-A JK1 87-A60-420-010 JACK,3.5 ST (MSC) JK2 88-CS7-618-010 JACK,DC 6 L101 88-CS8-630-010 COIL,FM 9T,3MM,DIA:0.4MM CS34- L102 88-CS8-629-010 COIL,FM 4T,4.5MM,DIA:0.3 MM L1

14、04 88-CS8-613-010 COIL,FM OSC 8T 2.5MM DIA 0.5MM L105 88-CS8-614-010 COIL,FM OSC 2.5-6T,DIA 0.5MM L109 87-005-151-080 COIL,2.2UH MIC1 88-CS8-625-010 MIC,ECM PVC101 88-CS8-626-010 TUN-CAP,20P-140P 16.4X16.4X 7. R323 87-029-105-010 RESISTOR, 1/2W 10 SW101 88-CS8-620-010 SW,SLIDE 2P3T SK23E03G1(BAND) S

15、W102 88-CS8-622-010 SW,SLIDE 4P2T SK42F02G1(FUNC) SW201 88-CS8-624-010 SW,REC 10P2T RSA-102D01(R/P) SW301 88-CS8-621-010 SW,PUSH 2P2T PS22E06A(Q-SOUND) T106 88-CS8-615-010 COIL,AM OSC IFT 0S06-838233 7 T107 88-CS8-616-010 COIL,AM IFT 4A625F 10MM T108 88-CS8-617-010 COIL,FM IFT 7A127N 7A5682 F31 T109

16、 88-CS8-618-010 COIL,FM DET IFT7A61R 10 MM T201 88-CS8-628-010 COIL,OSC IFT 4A-363R(B) 10MM VR301 88-CS8-627-010 SFR,SEMI FIXED FM065C-2K/ SFEV VR302 88-CS8-633-010 VR,RTRY 50KBX2,RK14K12A0,/20MM SLIDE SW C.B SW202 88-CS8-623-010 SW,SLIDE SK12 D07VG4LNSA(BEAT) LED C.B D301 88-CS8-644-010 LED,SE-3001

17、DT,3MM BRIGHT ,REDL BATT- C.B BATT+ C.B RadioFans.CN 收音机爱 好者资料库 4 TRANSISTOR ILLUSTRATION Regarding connectors, they are not stocked as they are not the initial order items. The connectors are available after they are supplied from connector manufacturers upon the order is received. 8 8 A Resistor C

18、ode Chip Resistor Part Coding Figure Value of resistor Chip resistor WattageTypeTolerance 1/16W 1/10W 1/8W 1608 2125 3216 5% 5% 5% CJ CJ CJ FormLWt 1.60.80.45 21.250.45 3.21.6 108 118 128 : A : A CHIP RESISTOR PART CODE 0.55 Resistor Code Dimensions (mm) Symbol 1/16W10055%CJ1.00.50.35104 L t W ECBEB

19、CG SD 2SC1923SS80502SK439F 65 BLOCK DIAGRAMVOLTAGE CHART 1234567891011121314 A B C D E F G H I J K 87 WIRING-1 SW102 TAPERADIO VR302 VOLUME SW301 Q SOUND SW101 AMFMFM STEREO PVC101 PVC101 TUNING MAIN C.B SLIDE SW C.B LED C.B BATT C.BBATT+ C.B GRY 1 45 8 14 58 1 9 1 12 1324 L110 (OPT/BATT) JK1 SW202

20、(NomalCrO2) JK2 DC IN BATTERY R6P(TYPEAA)X4 DC6V WHT BLK SW201 REC PB MIC 1 + BLU BLK NOTE:C XXX C XXX C XXX C XXX C XXX = = = = = CF XXX L XXX Q XXX R XXX = = = = 109 SCHEMATIC DIAGRAM SLIDE SW C.B LED C.B BATT+ C.B BATT C.B MAIN C.B FM ANT IN4148 IN4148 L110 AM BAR ANT TC102 L104,PVC101(1/4) FM SE

21、NS. ADJ. () L105,PVC101(2/4) FM FREQ. ADJ. SW101-1 SW101-2 FRONT END Q302 2SK439F RF AMP () () 3P L110,PVC101(3/4) AM SENS. ADJ. T106,PVC101(3/4) AM FREQ. ADJ. FM IF ADJ. AM IF ADJ. IF AMP SW201 REC PB SW201-2 SW201-7 REC PB AMP SW201-9 SW201-4 SW202 SW202 (Normal CrO2) SW201-3 SW201-1 SW201-10 BIAS

22、 OSC SW201-8 SW201-5 SW201-6 Q202 SWITCH AZIMUTH ADJ. IN4148 IN4148 IN4148 SW102-4 FUNCTION SW102-3 D104 MTZJ3.0A SW102-2 (OPT/BATT) +B DELAY SWITCH VR301 TAPE SPEED ADJ. IC303 KA2402 MOTOR DRIVE JK1 DC IN JK2 SP1 SP2 POWER AMP VR302 BIAS FREQ ADJ. SW102-1 MM1434XF Q SOUND EQ Q SOUND (ON OFF) 12P 12

23、11 ELECTRICAL ADJUSTMENT (TUNER SECTION) Signal noise ratio:More than 45dB Distortion:Less than 3.0% If frequency:10.7MHz Stereo separation:More than 20dB Signal noise ratio:More than 30dB (5mV/m)(at 1000kHz) Distortion:Less than 3% (at 1000kHz) If frequency:455kHz PRACTICAL SERVICE FIGURE (TAPE SEC

24、TION) Tape speed:2940-3090Hz Wow & flutter:Less than 0.45% Erasing ratio:More than 30dB Distortion:Less than 3% (PB) Less than 8% (REC/PB) Signal to noise ratio:More than 48dB (PB) 1234567891011121314 A B C D E F G H I J K 1413 WIRING-2 1615 IC BLOCK DIAGRAM IC, LA1828 IC, AN7310 IC, MM1434XF IC, KA

25、2402 REF. NOPART NO.KANRIDESCRIPTION NO. REF. NOPART NO.KANRIDESCRIPTION NO. MECHANICAL PARTS LIST 1/1 1 8Z-CS8-005-010 CASS WINDOW 2 8Z-CS8-007-010 PANEL,CASS 3 8Z-CS8-003-010 BOX,CASS 4 8Z-CS8-020-010 GRILLE,SP L 5 8Z-CS8-021-010 GRILLE,SP R 6 8Z-CS8-037-010 PANEL,TOP EX 7 8Z-CS8-031-010 CABI,FR E

26、X 8 8Z-CS8-014-010 KNOB,SL FUN 9 8Z-CS8-013-010 KEY,CASS REC 10 88-CS7-207-010 CUSH,MIC 11 8Z-CS8-016-010 KNOB,RTRY TU 12 8Z-CS8-012-010 KEY,CASS PLAY 13 8Z-CS8-011-010 KEY,CASS REW 14 8Z-CS8-010-010 KEY,CASS FWD 15 8Z-CS8-009-010 KEY,CASS STOP 16 8Z-CS8-019-010 POINTER, 17 8Z-CS8-017-010 KEY,Q SOUN

27、D 18 8Z-CS8-015-010 KNOB,RTRY VOL 19 88-CS8-645-010 TERMINAL,LB PLUG 20 88-CS8-213-010 HLDR,SPEAKER 21 8Z-CS8-205-010 SPR,CASS 22 8Z-CS8-204-010 PLATE,REC 23 8Z-CS8-201-010 POINTER,BRAKET 24 88-CS8-201-010 GEAR,PVC 25 8Z-CS8-006-010 WINDOW,DIAL 26 S8-CS8-300-000 BAR ANT HLDR 27 8Z-CS8-202-010 BOX,BA

28、TT + 28 8Z-CS8-203-010 BOX,BATT - 29 88-CS8-212-010 SPR-E,BATT - 30 88-CS7-626-010 ANT,ROD P7 TYPE 31 8Z-CS8-032-010 CABI,REAR EX 32 8Z-CS8-018-010 HANDL, 33 8Z-CS8-008-010 LID,BATT 34 8Z-CS8-208-010 PLATE,SPR CASS 35 88-CS7-625-010 SPKR,55MM 4OHM A 87-B10-114-010 VT2+2-12 CR B 87-651-073-410 VT1+2.

29、6-6 C 87-254-094-410 U+3-6 CR D 87-741-097-410 UT2+3-12 E 87-267-527-310 SCREW, V+1.7-3 F 87-741-033-410 UT2+2-4 W/O SLOT G 87-741-095-410 UT2+3-8 W/O SLOT Basic color symbolColorBasic color symbolColorBasic color symbolColor BBlackCCreamDOrange GGreenHGrayLBlue LTTransparent BlueNGoldPPink RRedSSil

30、verSTTitan Silver TBrownVVioletWWhite WTTransparent WhiteYYellowYTTransparent Yellow LMMetallic BlueLLLight BlueGTTransparent Green LDDark BlueDTTransparent Orange COLOR NAME TABLE MECHANICAL EXPLODED VIEW 1/1 1817 1 2 3 4 5 6 7 25 8 8 9 10 11 MIC1 P.C.B P.C.B P.C.B P.C.B P.C.B 12 13 14 15 16 21 22

31、23 24 26 PLATE,ANT 19 L110 31 3033 32 27 28 29 17 18 34 35 20 20 20 20 35 G G G E B G A F G D D G D D C G TN-9ZR-215 2019 TAPE MECHANISM EXPLODED VIEW 1/1 REF. NOPART NO.KANRIDESCRIPTION NO. TAPE MECHANISM PARTS LIST 1/1 1 S1-877-013-120 CHASSIS ASSY 2 S1-877-120-010 MOTOR PULLEY 3 S6-002-070-100 MO

32、TOR FR-410CA-12250T 4 S1-877-010-170 AUTO LEVER 5 S1-877-010-190 AUTO LEVER SPR 6 S1-877-030-090 SPR,EARTH 7 S1-877-010-370 SPR,LEVER BTN STOP 8 S1-867-050-040 BELT,RF 9 S1-877-093-050 FLYWHEEL ASSY 10 S1-877-090-070 BELT,MAIN 11 S1-877-070-060 SPR,ARM PULLEY RF 12 S1-877-073-030 RF PULLEY ARM ASSY

33、13 S1-877-010-110 FR BUTTON LEVER SPR 14 S1-877-010-260 BTN,ACTUATOR 15 S1-877-010-060 STOP BUTTON LEVER 16 S1-877-010-230 LEVER,BTN FF 17 S1-877-010-240 LEVER,BTN RWD 18 S1-877-010-320 SPR,PLATE T GEAR 19 S1-877-010-250 LEVER,BTN REC 20 S1-877-040-010 PINCH ROLLER ARM 21 S1-877-040-070 PINCH ROLLER

34、 ASSY 22 S1-877-010-270 PLATE,SW 23 S1-877-010-310 SPR,ACTUATOR 24 S1-877-190-020 PLATE TIMING 25 S1-877-030-080 SPR,RC 26 S1-877-030-040 P,PLATE 27 S1-877-030-030 PANEL,HEAD 28 S1-877-040-080 PINCH ROLLER ARM SPR 29 S1-877-030-070 SPR,PANEL HEAD 30 S6-401-011-490 SW,LEAF MSW-1541T 31 S1-867-020-040

35、 RPH COLLAR 32 S1-877-033-010 SENSING PLATE ASSY 33 S9-400-312-000 SPR,HEAD 34 S6-201-011-170 HEAD,RP-7442FS-1251 35 S1-877-030-050 ARM MG 36 S6-207-100-020 HEAD E TC-230AN(SL) 37 S1-877-020-010 LEVER,SAFETY REC 38 S1-821-100-700 GEAR,FF 39 S1-877-190-010 ARM RC 40 S1-877-060-020 BACK TENSION SPR 41

36、 S1-877-060-010 S REEL 42 S1-877-053-040 TAKE UP REEL ASSY 43 S1-821-103-4A0 GEAR T ROLLER 44 S1-821-100-460 BACK TENSION SPR 45 S1-877-015-030 T ROLLER GEAR PLATE ASSY A S9-817-000-000 SCREW AZIMUTH M2-4.3 B S9-210-000-000 SCREW M2-5 C S9-C33-172-030 CAMERA(SPECIAL) SCREW M2-1.7 D S9-999-000-010 P.

37、WASHER 1.85-3.2-0.2 E S9-888-000-000 P.WASHER CUT 1.2-3-0.4 F S9-999-030-010 P.WASHER CUT 1.5-3.2-0.5 G S9-316-000-000 FH WASHER 2.1-5-0.2 REF. NOPART NO.KANRIDESCRIPTION NO. 21 REF. NOPART NO.KANRIDESCRIPTION NO. ACCESSORIES/PACKAGE LIST ! 1 87-B30-166-010 AC ADAPTOR,AC-D602H 2 8Z-CS8-907-010 IB,H(ECA) 931196 Printed in Singapore 211, IKENOHATA 1CHOME, TAITO-KU, TOKYO 110-8710, JAPAN TEL:03 (3827) 3111