Aiwa-CT-FX5300M-Service-Manual 电路图 维修手册.pdf

《Aiwa-CT-FX5300M-Service-Manual 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Aiwa-CT-FX5300M-Service-Manual 电路图 维修手册.pdf（18页珍藏版）》请在收音机爱好者资料库上搜索。

1、SERVICE MANUAL DATA BASIC TAPE MECHANISM : CDS-801AW1 STEREO CAR CASSETTE RECEIVER CT-FR530M CT-FX5300M CT-FX530M S/M Code No. 09-003-342-7N1 YZ YL YU YV YJ YH RadioFans.CN 收音机爱 好者资料库 2 SPECIFICATIONS RADIO SECTION (FM) Frequency Range:87.5 MHz108 MHz (100-kHz steps) 87.5 MHz108 MHz Except YV 65 MHz

2、74 MHz YV (50-kHz steps) Usable Sensitivity:12.7 dBf 50 dB Quieting Sensitivity:17.2 dBf IF Rejection:80 dB Frequency Response:30 Hz15,000 Hz S/N Ratio:63 dB Stereo Separation:35 dB at 1 kHz Alternate Channel Selectivity:70 dB Capture Ratio:3 dB (AM(MW) Except YZ Frequency Range:530 kHz1,710 kHz (10

3、-kHz steps) 531 kHz1,602 kHz (9-kHz steps) Usable Sensitivity:30 V (30 dB) (MW) YZ Frequency Range:531 kHz1,620 kHz (9-kHz steps) Usable Sensitivity:30 V (30 dB) (LW) YZ Frequency Range:144 kHz288 kHz (1-kHz/9-kHz steps) Usable Sensitivity:30 V (30 dB) TAPE SECTION Tape Speed:4.8 cm/sec. (17/8 ips)

4、S/N Ratio:50 dB Frequency Response:40 Hz14,000 Hz Stereo Separation:40 dB FF/REW Time:100 sec. (C-60) AUDIO SECTION Max. Power Output:45 W x 4 channels AUX IN input Input sensitivity (load impedance) AUX IN:300 mV (10 k) GENERAL Power-Supply Voltage:14.4 V (11 to 16 V allowable), DC, negative ground

5、 Load Impedance:4 Tone Control:Bass 10 dB at 100 Hz Treble 10 dB at 10 kHz Preamp Output Voltage (load impedance): 2.2 V (10 k) Installation size:182(W) x 53(H) x 155(D) mm (71/4(W) x 21/8(H) x 61/8(D) inches) STEERING-WHEEL-MOUNTED REMOTE CONTROL UNIT Dimensions:approx. 67 (W) x 26 (H) x 27 (D) mm

6、(23/4 (W) x 11/16 (H) x 11/8 (D) inches) (excluding holder) Weight:approx. 38 g (1.33 oz) (including holder, battery) Design and specifications are subject to change without notice. REF. NOPART NO.KANRIDESCRIPTION NO. REF. NOPART NO.KANRIDESCRIPTION NO. ACCESSORIES LIST 1 8A-KT9-904-010 IB,YH,Y(E CK

7、 CH A) 530M 1 8A-KT9-903-010 IB,YL(3L) 5300M 1 8A-KT9-901-010 IB,YU(3L) 530M 1 8A-KT9-905-010 IB,YV(ER) 530M 1 8A-KT8-901-010 IB,YZ(9L) FR530M 2 8A-KT5-908-010 IB,INST,YH,Y (E CK CH A)-A 2 8A-KT5-902-010 IB,INST,YU,YL (3L,P) 2 8A-KT3-902-010 IB,INST,YZ (9L)-A 3 R8-AZR-190-040 AZR-1 RCKCGNF 4 8Z-KT1-

8、625-010 CONN ASSY,16P SOC016 5 86-KT1-237-010 HLDR,REAR MTG 6 8Z-KT1-030-010 CASE,DFP -T 7 88-KC4-057-010 BELT, HRC 8 88-KC4-053-010 HLDR,BELT HRC 9 88-KC4-257-010 KEY,HEXAGON WRENCH 10 8Z-KT1-232-010 KEY,REMOVE -T 11 87-B10-141-010 NUT,5 TYPE-2 12 8Z-KT1-251-010 S-SCREW,5*6 TH+ TAPPING ST 13 88-KC4

9、-255-010 S-SCREW,HEX-SOC+3-3.5 BLK 14 88-KT1-247-010 S-SCREW,HEXAGON 15 88-KT1-250-010 S-SCREW,THIN HEAD+2.6-4 BLK 16 87-B10-143-010 UT1+5-15 W/O SLOT 17 87-B10-144-010 W,5.2-10-0.5 18 87-B10-145-010 W-SPR,5.3-8.5-1.5 TYPE MODEL NAMESUFFIX ACT-FX530MYU BCT-FX530MYV CCT-FX530MYH DCT-FX530MYJ ECT-FX53

10、00MYL FCT-FR530MYZ RadioFans.CN 收音机爱 好者资料库 3 REF. NOPART NO.KANRIDESCRIPTION NO. REF. NOPART NO.KANRIDESCRIPTION NO. ELECTRICAL MAIN PARTS LIST IC 8Z-KT1-622-010 C-IC,LC75374E 87-A21-562-010 IC,LA4743B 87-A21-530-030 C-IC,UPD178018AGF 87-002-394-010 IC,LB1641 88-KT1-608-010 C-IC,LC75854W 87-A90-951-

11、010 RCR UNIT,SBX1971-52 88-KT1-607-080 C-IC,SAA6579T 87-A21-538-010 IC,KIA2025P 87-A21-649-030 C-IC,UPD178006AGC-539-3B9 TRANSISTOR 89-423-953-010 TR,2SD2395F 87-A30-468-040 C-TR,KRC102S-RTK 87-026-576-080 C-TR,DTC343TK 87-A30-063-080 C-TR,KRA104S 87-A30-470-040 C-TR,KTC3875SY-RTK 87-A30-471-040 C-T

12、R,KTA1504SY-RTK 87-A30-295-010 TR,KRA226M 87-A30-469-040 C-TR,KRC111S-RTK 87-A30-472-040 C-TR,KRA226S-RTK 87-A30-467-040 C-TR,KRA111S-RTK 8Z-KTH-627-080 TR,KTA1273Y 87-A30-476-010 TR,KTA1046Y 8Z-KTH-626-080 TR,KTC3203Y DIODE 87-020-465-080 DIODE,1SS133 (110MA) 87-A40-350-080 ZENER,MTZJ 4.7C 87-A40-5

13、04-040 C-DIODE,KDS184 87-017-932-080 ZENER,MTZJ6.2B 87-A40-830-040 DIODE,KDS226-RTK 87-A40-250-080 C-DIODE,DAN217 87-A40-509-080 ZENER,MTZJ6.8C 87-001-783-080 DIODE,1N4002 87-020-590-080 ZENER,02CZ10Y 87-070-022-010 DIODE,IN5402 (RECT) 87-020-585-080 CHIP-ZENER,02CZ6.2Y 87-A40-624-080 ZENER,MTZJ10A

14、87-017-931-080 ZENER,MTZJ5.6B 87-A40-620-080 ZENER,MTZJ6.2A 87-A40-829-040 DIODE,KDS196-RTK 87-A40-835-080 C-ZENER,Z02W5.1VX-RTK 87-A40-869-080 C-ZENER,02CZ11X 87-A40-834-080 C-ZENER,Z02W9.1VY-RTK MAIN C.B C101 87-010-322-080 C-CAP,S 100P-50 CH C102 87-010-197-080 CAP, CHIP 0.01 DM C103 87-010-184-0

15、80 C-CAP,S 1000P C104 87-010-186-080 CAP,CHIP 4700P C105 87-010-490-040 CAP, ELECT 0.1-50 C106 87-010-198-080 CAP, CHIP 0.022 C107 87-010-553-040 CAP,E 47-16 GAS C108 87-010-196-080 CHIP CAPACITOR,0.1-25 C109 87-010-553-040 CAP,E 47-16 GAS C110 87-010-992-080 C-CAP,S 0.047-25 B C111 87-010-213-080 C

16、-CAP,S 0.015-50 B C111 87-010-198-080 CAP, CHIP 0.022 C112 87-010-213-080 C-CAP,S 0.015-50 B C112 87-010-198-080 CAP, CHIP 0.022 C113 87-010-992-080 C-CAP,S 0.047-25 B C114 87-010-992-080 C-CAP,S 0.047-25 B C115 87-010-197-080 CAP, CHIP 0.01 DM C116 87-010-495-080 CAP,E2.2-50 C117 87-010-197-080 CAP

17、, CHIP 0.01 DM C118 87-010-197-080 CAP, CHIP 0.01 DM C120 87-010-553-040 CAP,E 47-16 GAS C121 87-010-196-080 CHIP CAPACITOR,0.1-25 C301 87-010-494-040 CAP,E 1-50 GAS C302 87-010-494-040 CAP,E 1-50 GAS C303 87-010-178-080 CHIP CAP 1000P C304 87-010-178-080 CHIP CAP 1000P C401 87-010-494-040 CAP,E 1-5

18、0 GAS C402 87-010-494-040 CAP,E 1-50 GAS C501 87-010-494-040 CAP,E 1-50 GAS C502 87-010-494-040 CAP,E 1-50 GAS C503 87-010-494-040 CAP,E 1-50 GAS C504 87-010-494-040 CAP,E 1-50 GAS C505 87-010-184-080 CHIP CAPACITOR 3300P(K) C506 87-010-184-080 CHIP CAPACITOR 3300P(K) C507 87-010-198-080 CAP, CHIP 0

19、.022 C508 87-010-198-080 CAP, CHIP 0.022 C509 87-010-498-040 CAP,E 10-16 GAS C510 87-010-498-040 CAP,E 10-16 GAS C511 87-A11-177-080 C-CAP,S 0.15-16 K B C512 87-A11-177-080 C-CAP,S 0.15-16 K B C513 87-A11-177-080 C-CAP,S 0.15-16 K B C514 87-A11-177-080 C-CAP,S 0.15-16 K B C515 87-010-498-040 CAP,E 1

20、0-16 GAS C516 87-010-498-040 CAP,E 10-16 GAS C517 87-010-553-040 CAP,E 47-16 GAS C518 87-010-498-040 CAP,E 10-16 GAS C519 87-010-196-080 CHIP CAPACITOR,0.1-25 C520 87-010-494-040 CAP,E 1-50 GAS C521 87-010-494-040 CAP,E 1-50 GAS C522 87-010-494-040 CAP,E 1-50 GAS C523 87-010-494-040 CAP,E 1-50 GAS C

21、524 87-010-552-040 CAP,E 22-16 GAS C525 87-012-358-080 C-CAP,S 0.47-10 F Z C526 87-012-358-080 C-CAP,S 0.47-10 F Z C527 87-012-358-080 C-CAP,S 0.47-10 F Z C528 87-010-196-080 CHIP CAPACITOR,0.1-25 C529 87-012-141-080 CHIP-CAPACITOR,0.22-16F C530 87-012-141-080 CHIP-CAPACITOR,0.22-16F C531 87-010-178

22、-080 CHIP CAP 1000P C601 87-A11-177-080 C-CAP,S 0.15-16 K B C602 87-A11-177-080 C-CAP,S 0.15-16 K B C603 87-A11-177-080 C-CAP,S 0.15-16 K B C604 87-A11-177-080 C-CAP,S 0.15-16 K B C605 87-010-180-080 C-CER 1500P C606 87-010-180-080 C-CER 1500P C607 87-010-180-080 C-CER 1500P C608 87-010-180-080 C-CE

23、R 1500P C609 87-010-491-040 CAP,E 0.22-50 GAS C610 87-010-552-040 CAP,E 22-16 GAS C611 87-010-196-080 CHIP CAPACITOR,0.1-25 C612 8Z-KT1-633-000 CAP,E 3300U-16 105 PW C613 87-010-553-040 CAP,E 47-16 GAS C614 87-010-196-080 CHIP CAPACITOR,0.1-25 C615 87-010-196-080 CHIP CAPACITOR,0.1-25 C616 87-010-19

24、6-080 CHIP CAPACITOR,0.1-25 C617 87-010-196-080 CHIP CAPACITOR,0.1-25 C626 87-018-209-080 CHIP CAPACITOR,0.1-50 C701 87-010-490-040 CAP, ELECT 0.1-50 C702 87-010-196-080 CHIP CAPACITOR,0.1-25 C703 87-010-314-080 C-CAP,S 22P-50V C704 87-010-316-080 C-CAP,S 33P-50 CH C705 87-010-196-080 CHIP CAPACITOR

25、,0.1-25 C706 87-010-198-080 CAP, CHIP 0.022 C707 87-010-555-040 CAP,E 100-10 GAS C708 87-010-322-080 C-CAP,S 100P-50 CH C709 87-010-322-080 C-CAP,S 100P-50 CH C710 87-010-178-080 CHIP CAP 1000P C712 87-016-039-090 CAP,DL 0.022F-5.5 Z 70 FM C713 87-010-197-080 CAP, CHIP 0.01 DM C714 87-010-197-080 CA

26、P, CHIP 0.01 DM RadioFans.CN 收音机爱 好者资料库 4 REF. NOPART NO.KANRIDESCRIPTION NO. REF. NOPART NO.KANRIDESCRIPTION NO. C801 87-010-182-080 C-CAP,S 2200P-50 B C802 87-010-182-080 C-CAP,S 2200P-50 B C803 87-010-196-080 CHIP CAPACITOR,0.1-25 C804 87-010-552-040 CAP,E 22-16 GAS C805 87-010-555-040 CAP,E 100-

27、10 GAS C806 87-010-101-080 CAP, ELECT 220-16 C807 87-010-498-040 CAP,E 10-16 GAS C808 87-010-197-080 CAP, CHIP 0.01 DM C809 87-010-553-040 CAP,E 47-16 GAS C810 87-010-198-080 CAP, CHIP 0.022 C811 87-010-197-080 CAP, CHIP 0.01 DM C1205 87-010-498-040 CAP,E 10-16 GAS C1206 87-010-498-040 CAP,E 10-16 G

28、AS C1207 87-010-498-040 CAP,E 10-16 GAS C1208 87-010-498-040 CAP,E 10-16 GAS C1211 87-012-140-080 CAP 470P C1212 87-012-140-080 CAP 470P C1213 87-012-140-080 CAP 470P C1214 87-012-140-080 CAP 470P C1301 87-010-198-080 CAP, CHIP 0.022 CN701 88-KTA-603-010 CONN,15P CAM-B68 CN801 8Z-KT1-624-010 CONN,16

29、P SOC017 CNA201 8A-KT7-651-010 CONN ASSY,5P MAIN-EQ CNA251 8A-KT5-651-010 CONN ASSY,12P MAIN-DECK CNA252 8A-KT5-651-010 CONN ASSY,12P MAIN-DECK CNA801 8A-KT1-631-010 CONN ASSY,8P ISO-BLACK-A CNA802 8A-KT1-632-010 CONN ASSY,8P ISO-WHITE-A D703 87-027-262-010 LEDE,TLR-124(RED) F801 8Z-KC1-621-010 FUSE

30、,15A 32V J101 8Z-KT1-614-010 ANT,AW-002 J401 8A-KC7-620-010 JACK,DIN 13 P SKDS1302 J1201 87-A61-224-010 JACK,PIN 4P XR-401 L101 87-003-143-080 COIL 4.7 UH L102 8Z-KT1-619-010 COIL,68MH K7-D L301 87-003-143-080 COIL 4.7 UH L701 87-003-149-080 COIL,47UH L801 8Z-KT1-615-010 FLTR,AMORPHOUS -CHOKE SW701

31、87-A91-070-010 SW,TACT SKHHLV SW703 87-A91-152-010 SW,SL 1-1-2 SSSS212-11-A TU101 8A-KC8-620-010 TU UNIT,FAE347-A11 TU101 8A-KC8-621-010 TU UNIT,FAE347-A12 TU101 8A-KTG-607-010 TU UNIT,FAE347-P10 X701 87-A70-175-010 VIB,XTAL 4.5MHZ AT-49 FRONT C.B C1001 87-010-176-080 C-CAP,S 680P-50 SL C1002 87-010

32、-194-080 CAP, CHIP 0.047 C1003 87-010-194-080 CAP, CHIP 0.047 C1004 87-010-196-080 CHIP CAPACITOR,0.1-25 C1005 87-010-805-080 CAP, S 1-16 C1006 87-010-194-080 CAP, CHIP 0.047 CN1001 88-KTA-602-010 CONN,15P CAM-B67 LCD1001 8A-KT9-610-010 LCD,AKT-8/9(3COLOR) LED1001 87-017-827-070 C-LED,SEC 1201C RED

33、LED1002 87-017-827-070 C-LED,SEC 1201C RED LED1003 87-017-827-070 C-LED,SEC 1201C RED LED1004 87-A40-813-040 C-LED,SEC1E01C BLUE LED1005 87-A40-813-040 C-LED,SEC1E01C BLUE LED1006 87-A40-813-040 C-LED,SEC1E01C BLUE LED1007 87-017-827-070 C-LED,SEC 1201C RED PL1001 8A-KT7-655-010 LAMP,9V-50MA PL1002

34、8A-KT7-655-010 LAMP,9V-50MA SW1001 87-036-251-080 SW,T CT 6X3.5 160 SW1002 87-036-251-080 SW,T CT 6X3.5 160 SW1003 87-036-251-080 SW,T CT 6X3.5 160 SW1004 87-A90-001-080 C-SW,TACT SKQMAL SW1005 87-036-251-080 SW,T CT 6X3.5 160 SW1006 87-036-251-080 SW,T CT 6X3.5 160 SW1007 87-A90-001-080 C-SW,TACT S

35、KQMAL SW1008 87-036-251-080 SW,T CT 6X3.5 160 SW1009 87-036-251-080 SW,T CT 6X3.5 160 SW1010 87-036-251-080 SW,T CT 6X3.5 160 SW1011 87-A90-001-080 C-SW,TACT SKQMAL SW1012 87-A90-001-080 C-SW,TACT SKQMAL SW1013 87-036-251-080 SW,T CT 6X3.5 160 SW1014 87-036-251-080 SW,T CT 6X3.5 160 SW1015 87-A90-00

36、1-080 C-SW,TACT SKQMAL SW1016 87-036-220-080 C-SW,T VR1001 87-A91-597-010 SW,RTRY SIM-026MT W1 8A-KT9-611-010 F-CABLE,3P 50MM AUX C.B J1001 87-A61-229-010 JACK,3.5 BLK ST W/SW CONTROL C.B C251 87-010-553-040 CAP,E 47-16 GAS C252 87-012-141-080 CHIP-CAPACITOR,0.22-16F C253 87-012-141-080 CHIP-CAPACIT

37、OR,0.22-16F C254 87-010-196-080 CHIP CAPACITOR,0.1-25 C255 87-012-141-080 CHIP-CAPACITOR,0.22-16F C256 87-010-497-040 CAP,E 4.7-35 GAS C257 87-010-197-080 CAP, CHIP 0.01 DM C258 87-010-553-040 CAP,E 47-16 GAS CON251 87-099-203-010 CONN,10P 6216 H CON252 87-A61-262-010 CONN,12P V B12B-ZR EQ C.B C271

38、87-010-994-080 CAP 820P C272 87-010-994-080 CAP 820P C273 87-010-994-010 CAP 820P C274 87-010-994-080 CAP 820P C275 87-010-552-040 CAP,E 22-16 GAS C276 87-010-552-040 CAP,E 22-16 GAS C277 87-010-426-080 CAP, CHIP 0.012 C278 87-010-426-080 CAP, CHIP 0.012 C279 87-010-494-040 CAP,E 1-50 GAS C280 87-01

39、0-494-040 CAP,E 1-50 GAS C281 87-010-555-040 CAP,E 100-10 GAS C282 87-010-421-040 CAP,E 4.7-3.5 C283 87-010-498-040 CAP,E 10-16 GAS C284 87-010-494-040 CAP,E 1-50 GAS C285 87-010-494-040 CAP,E 1-50 GAS C286 87-010-553-040 CAP,E 47-16 GAS CON271 87-A61-259-010 CONN,5P V B5B-ZR CON272 87-009-349-010 C

40、ONN,6P PH H RDS C.B C1101 87-012-149-080 C-CAP,S 30P-50 CH C1102 87-010-315-080 C-CAP,S 27P-50 CH C1103 87-010-175-080 CAP 560P C1104 87-010-196-080 CHIP CAPACITOR,0.1-25 C1105 87-012-157-080 C-CAP,S 330P-50 CH C1106 87-010-495-040 CAP,E 2.2-50 GAS C1107 87-010-197-080 CAP 0.01 CON1101 8Z-KTH-613-01

41、0 CONN,3P HEADER-ANGLE CON1102 8Z-KTH-613-010 CONN,3P HEADER-ANGLE SFR1101 87-024-437-080 SFR,100K X1101 87-A70-091-010 VIB,XTAL 4.332MHZ CSA-309 MECHA. C.B 65 TRANSISTOR ILLUSTRATION IC BLOCK DIAGRAM-1 IC, LB1641IC, LA4743B IC, SAA6579T B E C DTC343TK KRA104S KRA111S KRA226S KRC102S KRC111S KTA1504

42、 KTC3875 E C B KTC3203 E C B KRA226M KTA1273 B C E 2SD2395 KTA1046 2SC2873 8 8 A Resistor Code Chip Resistor Part Coding Figure Value of resistor Chip resistor WattageTypeTolerance 1/16W 1/10W 1/8W 1608 2125 3216 5% 5% 5% CJ CJ CJ FormLWt 1.60.80.45 21.250.45 3.21.6 108 118 128 : A : A CHIP RESISTOR

43、 PART CODE 0.55 Resistor Code Dimensions (mm) Symbol 1/16W10055%CJ1.00.50.35104 L t W TYPE MODEL NAMESUFFIX ACT-FX530MYU BCT-FX530MYV CCT-FX530MYH DCT-FX530MYJ ECT-FX5300MYL FCT-FR530MYZ 3/41/2 MUTE ON TIME STBY R.FGND PRE GND NCGND VDD VSSVSS IC, KIA2025P 6 NF-1 ch1-F AMP-1 AMP-2 ch1-R 5 7 9 ch2-F

44、OUT-2Metal OUT-1Metal EQ SELECT GND VCC 13 ch2-R NF-2 11 421 15 3 1416812 M M N N BIAS F/R SELECT 87 SCHEMATIC DIAGRAM-1 9 IC BLOCK DIAGRAM-2 IC, LC75374E IC, LC75854W 10 DIFFERENCE TABLE Ref No.ABCDEF C1107F C1301BF CN801ACDEF CNA801B CNA802B D710ACDE D715ACDE D718B D721F Q1101F Q1301BF R122F R737A

45、BCDE R738ABCDE R1103F R1104F R1301BF R1302BF SFR1101F SW703ABCDE This table listes the different components marked with asterisks (*) in the MAIN CB TYPE MODEL NAMESUFFIX ACT-FX530MYU BCT-FX530MYV CCT-FX530MYH DCT-FX530MYJ ECT-FX5300MYL FCT-FR530MYZ ELECTRICAL ADJUSTMENT 1.RDS Voltage Adjustment YZ

46、Settings: Test point: Center pin of SFR1101 Adjustment location: SFR1101 Method: Set AM/FM Signal generation to 98 MHz, 30 dBV and adjust SFR1101 so that the output becames 2.0 V 0.05 V. MAIN C.B L102 TU101 SW703 SFR1101 TEST POINT FRONT SIDE 2 1234567891011121314 A B C D E F G H I J 1211 WIRING-1(MAIN C.B) CN102CN101 1413 WIRING-2 (FRONT C.B) 04.73.45 SCHEMATIC DIAGRAM-2 1234567 A B C D E F G H I J 1 A B C D E F G H I J K L M N A B C D E F G H I J K L M N O O 23456654321 15 1234567 A B C D E F G H I J WIRING-3 (EQ C.B, CONTROL C.B, MECHA C.B) CNA251