《Alpine-TME-M770-Service-Manual 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Alpine-TME-M770-Service-Manual 电路图 维修手册.pdf（58页珍藏版）》请在收音机爱好者资料库上搜索。
1、TME-M770 SERVICE MANUAL 6.5-INCH TOUCH PANEL WIDE LCD MONITOR * The model is component system unit of MONITOR Unit and AV Interface Unit. 8/04-A 68E37328S01 The following cautions will prevent accidents in the workplace and will ensure safe products. *The symbols indicate caution is needed to preven
2、t injuries and damage to property. The symbols and their meanings follow. *The following symbols indicate two levels of cautions. When you see this symbol, you have to be very careful. When you see this symbol, you have to follow the instructions there. Do not look squarely into the laser light Fuse
3、 Caution coming from the pickup.Always use a designated fuse. You may loose you sight.Use of an incorrect fuse may result in a fire. Do not allow wiring to be caught in the Battery Caution screw/chassis.Use the designated battery. If wiring is caught in the screw/chassis, it mayConfirm the correct p
4、olarity and seat of the cause a short circuit, resulting in a fire.battery. An incorrect battery or an improperly connected or seated battery may result in a fire. High Temperature CautionDesignated Parts Caution Touching the heat sink may cause severe burns.Look up the part list and ensure that onl
5、y designated parts are used to prevent problems or accidents. Reverse Power Supply Connections orWiring Caution Misconnections CautionEnsure that the wiring is correct when rewiring to Reverse power supply connections orprevent problems with ignition/breakdown. misconnections may cause ignition prob
6、lems and smoke may result. Soldering CautionWear Gloves Hot solder from solder splash may cause severe Wear gloves to prevent electrical shocks or injury burns.from the end face of the metal. If you ignore this symbol and handle the product incorrectly or unsafely, injury or only material damage may
7、 result. If you ignore this symbol and handle the product incorrectly or unsafely, serious injury or death may result. Warning Caution Warning Caution - 2 - Packing Assembly Parts List Part No.Part No. 10101E37285S01ASSY DIN CABLE#1 10813E37289S01PANEL,FACE #1 10201E37286S01ASSY CONNECTOR 10P#1 1097
8、5E37290S01SPONGE,CUSHION-CASE $1 10201E37297S01ASSY CONNECTOR#1 11075E37291S01SPONGE,CUSHION-B #1 10368-00493Z15OWNERS MANUAL#1 11175E37292S01SPONGE,CUSHION-A $1 10368-00493Z17OWNERS MANUAL#1 11255E37293S01CASE,LOCK 10403E36299S01SCR,M4X14 TPG1(BLK)#1 11301E37343S01ASSY INNER CASE,RDM 770AE 10575E37
9、287S01TAPE,PAD-MAGIC#1 11437E37344S01BIND,WIRE #1 10603E33860S01SCR,M3X6 MCH(BLK)$1 11501E37298S01ASSY MONI-STAND KIT;RDM770GE #1 10745E37288S01LEVER,MONITOR$1 11601E37299S01ASSY L-TYPE BKT;RDM770GE NOTE:#1:For North American Model Only, $1:For General Foreign Model Only, Others:Common. Packing Meth
10、od View Description No.No. SymbolSymbolDescription 102 107 X2 116 106 X4 109 X4 101 X4 X2 U H N W D D N W H N D C O 105 104 115 $1 #1 #1 #1 114 X4 #1 $1 #1 #1 #1 #1 #1 #1 108 110 113 110 111 112 113 to X1 X1 X1 X1 NOTE:#1:For North American Model Only, $1:For General Foreign Model Only, Others:Commo
11、n. 103 TME-M770 AV Interface Unit MONITOR Unit - 4 - Specifications Screen Size . 6.5-Type Wide Display System . Low Reflection Rear Projection Type TN Liquid Crystal Panel Drive System . Active Matrix Drive, Nomally White Display Number of Picuture Elements . 280,000 pcs. (H : 1,200 X V : 234 Dots)
12、 Light Source . Internal Optical System (U-Type Cold Cathode Fluorescent Tube) Channel Balance (1kHz) . Head Phone Output : 03dB Frequency Response (Ref. 1kHz) . Speaker Output : 100Hz : -23dB 10kHz : -63dB Head Phone Output : 100Hz : 03dB 10kHz : 03dB S/N Ratio (1kHz) . Speaker Output : 50dB Head P
13、hone Output : 45dB Separation (1kHz) . Head Phone Output : 40dB Distortion (1kHz) . Speaker Output : 1.0% Head Phone Output : 1.0% Output Level (1kHz, Volume Max.) . Speaker Output : 1,800mVrms Head Phone Output : 300mVrms Frequency Response (Ref. 1kHz) . Speaker Output : 100Hz : -23dB 10kHz : -63dB
14、 S/N Ratio (1kHz) . Speaker Output : 50dB Distortion (1kHz) . Speaker Output : 1.0% Difference Output Level (AUX-IN 1kHz) . Speaker Output : -33dB Channel Balance (1kHz) . INPUT : AUX IN-1: 03dB Frequency Response (Ref. 1kHz) . INPUT : AUX IN-1 : 100Hz : 03dB 10kHz : 03dB S/N Ratio (1kHz) . INPUT :
15、AUX IN-1 : 70dB Separation (1kHz) . INPUT : AUX IN-1 : 55dB Distortion (1kHz) . INPUT : AUX IN-1 : 0.1% Output Level (1kHz) . INPUT : AUX IN-1 : 1200300mVrms VIDEO Output Level (Input 1.0Vp-p, 100% White) . 1.00.15Vp-p S/N Ratio (50% White) . 50dB TME-M770 - 5 - Power Supply . DC14.4V (11.0 to 16.0V
16、) Audio Output/Impedance . Speaker Output : 1,200mVrms / 8 ohm Head Phone Output : 250mVrms / 32 ohm Dimension (W x H x D) . MONITOR Unit : 161 x 109 x 28.5mm AV Interface Unit : 180 x 119 x 28.5mm Weight . MONITOR Unit : 360g AV Interface Unit : 550g NOTE : Due to Continuing product improvement, sp
17、ecifications and designs are subject to change without notice. TME-M770 - 6 - 1 u o a ; d f g h j k s p q w e r 2 y t q 8 3 4 5 6 7 9 I I I i I I I I TO CH PA EL W DE CD MONOR Connections Make connections correctly. Improper connections may cause a fire or operation failure. Battery Chassis Basic co
18、nnection System Diagram TME-M770 (North American Model Only) - 7 - 1 Foot brake lead (Yellow/Black) Connect this lead to the foot brake lead powered when the foot brake is pressed. 2 Hand brake lead (Yellow/Blue) Connect this lead to the hand brake lead powered when the hand brake is pulled. 3 Monit
19、or control lead (White/Pink) Connect when upgrading with touch panel compatible products such as the IVA-D300. 45Remote control output lead (White/Brown) To remote control input lead of ALPINE products used in the system. 6 Reverse Lead (Orange/White) Use only when a back-up camera is connected. Con
20、nect to the plus side of the cars reverse lamp that lights when the transmission is shifted into reverse (R). Switches the video picture to the back-up camera. This is linked with putting the car into reverse (R). 7 ACC power lead (Red) To ACC power lead powered when engine key position is ACC. 8 Fu
21、se (7.5A) 9 Ground lead (Black) Connect the lead to a good chassis ground on the vehicle. Make sure the connection is made to bare metal and is securely fastened using the sheet metal screw provided. p Foot brake lamp q Brake connector (Included) w Foot brake lead e Foot brake switch r Hand (parking
22、) brake lamp t Hand (parking) brake lead y Hand (parking) brake switch u Headphone i Main monitor o Connection cable ; RGB cable a To RGB output terminal s Made by Alpine navigation d Audio input connectors (AUX 1) Use these connectors to input the audio signals from a DVD player, video deck etc. f
23、Video input connector (AUX 1) Use this connector to input the video signals from a DVD player, video deck etc. g Audio input connectors (AUX 2) Use these connectors to input the audio signals from a DVD player, video deck etc. To prevent external noise from entering the audio system. Locate the unit
24、 and route the leads at least 10cm away from the car harness. Keep the battery power leads as far away from other leads as possible. Connect the ground lead securely to a bare metal spot (remove the coating if necessary) of the car chassis. If you add an optional noise suppressor, connect it as far
25、away from the unit as possible. Your Alpine dealer carries various Alpine noise suppressors, contact them for further information. Your Alpine dealer knows best about noise prevention measures so consult your dealer for further information. h Video input connectors (AUX 2) Use this connector to inpu
26、t the video signals from a DVD player, video deck etc. j Audio output connectors Use these connectors to output audio signals to a rear monitor, etc. k Video output connector Use this connector to output video signals to a rear monitor, etc. When connecting to an IVA-D300 or VPE-S431, use the “AUX I
27、N 1” connector. When connecting a rear view camera, use the “AUX IN 2”. TME-M770 - 8 - System Connections 1) 2 main units + head unit (IVA-D300) + expansion box (VPE-S431) + DVD changer (DHA- S680) + TV Tuner Expansion box (VPE-S431, sold separately) To AV SELECTOR terminal To head unit terminal AV
28、SELECTOR cable (supplied with VPE S431) RCA Extension cable RCA Extension cable To AUX OUT 2 terminal To AUX OUT 1 terminal Mon tor control 2 lead Remote control output lead (AUX1) Remote control output lead (AUX 1) Remote control input lead (AUX2) Remote control input lead (AUX 1) To AUX IN 1 termi
29、nal RCA Extension cable RCA Extension cable To audio output terminal To audio output terminal To video output terminal To video output terminal RCA Extension cable (supplied with DVD changer ) RCA Extension cable Remote control input lead White/Brown White/Brown White/Brown White/Brown Remote contro
30、l output lead (AUX1) Remote control output lead (AUX 2)Remote control input lead To AUX IN 2 terminal To AUX IN 1 terminal To AUX IN 1 terminal Monitor cable Ai NET cable Ai NET output connector (Black) Rear monitor (TME-M770) Rear monitor (TME-M770) B.BOX Monitor control 1 lead Monitor cable Main u
31、nit monitor (TME-M770) Main unit B.BOX (TME-M770) Head unit (IVA-D300, sold separately) TV Tuner or VCR (sold separately) DVD changer (DHA-S680, sold separately) To Ai NET input connector TME-M770 - 9 - 2) Main unit + navigation (NVE-N852A) + DVD player (such as DVA-5210) To AUX IN 1 terminal RCA Ex
32、tension cable To audio output terminal RCA Extension cable (supplied with DVD player)To video output terminal Remote control input lead Remote control output lead (AUX1) White/BrownWhite/Brown To RGB output terminal To RGB input terminal RGB cable (supplied with NVE-N852A ) Monitor cable Main unit m
33、onitor (TME-M770) Main unit B.BOX (TME-M770) DVD player (such as DVA-5210, sold separately) Navigation (NVE-N852A, sold separately) 3) Main unit and head unit (IVA-D300) RCA Extension cable To AUX OUT terminal Remote control output lead (AUX1) Remote control input lead To AUX IN 1 terminal Monitor c
34、ontrol lead Monitor cable Main unit monitor (TME-M770) Main unit B.BOX (TME-M770) Head unit (IVA-D300, sold separately) TME-M770 - 10 - Connections Make connections correctly. Improper connections may cause a fire or operation failure. Basic connection u y i 7 2 q w p 9 3 4 5 6 1 8 e t o ; a s d f I
35、 I I r I I I I TO CH PA EL W DE CD MON T R TME-M770 (General Foreign Model Only) - 11 - 1 Parking brake lead (Yellow/Blue) Connect this lead to the parking brake lead powered when parking brake is pulled. 2 Monitor control lead (White/Pink) Connect when upgrading with touch panel compatible products
36、 such as the IVA-D300 series. 34Remote control output lead (White/Brown) To remote control input lead of ALPINE products used in the system. 5 Reverse Lead (Orange/White) Use only when a back-up camera is connected. Connect to the plus side of the cars reverse lamp that lights when the transmission
37、is shifted into reverse (R). Switches the video picture to the back-up camera. This is linked with putting the car into reverse (R). 6 ACC power lead (Red) To ACC power lead powered when engine key position is ACC. 7 Fuse (7.5A) 8 Ground lead (Black) Connect the lead to a good chassis ground on the
38、vehicle. Make sure the connection is made to bare metal and is securely fastened using the sheet metal screw provided. 9 Brake Lamp p Brake Connector (Included) q Brake Signal Lead w Brake Switch e Headphone r Main monitor t Connection cable y RGB cable u To RGB output terminal i Made by Alpine navigation o Audio input connectors (AUX 1) Use these connectors to input the audio signals from a
免费区 
