Philips-CE-130-130-X-Service-Manual 电路图 维修手册.pdf

《Philips-CE-130-130-X-Service-Manual 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Philips-CE-130-130-X-Service-Manual 电路图 维修手册.pdf（20页珍藏版）》请在收音机爱好者资料库上搜索。

1、CE130/55/51,CE130X/78 TABLE OF CONTENTS Page Technicalspecification.1-2 Versionvariation.1-2 Servicemeasurementsetup.1-3 Serviceaids.1-4 InstructionsonCDplayability.2-1.2-2 Disassemblydiagram.2 SetBlockdiagram.3 SetWiringdiagram.4 Circuitdiagram Mainboard.5,6 Panelboard.7 Tunerboard.8 Layoutdiagram

2、Mainboard.9,10 Panelboard.11,12 Tunerboard.13,14 MechanicalExplodedview.15 Copyright2010PhilipsConsumerElectronicsB.V.Eindhoven,TheNetherlands Allrightsreserved.Nopartofthispublicationmaybereproduced,storedinaretrievalsystemor transmitted,inanyformorbyanymeans,electronic,mechanical,photocopying,orot

3、herwisewithout thepriorpermissionofPhilips. Published by LX 1110 Service Audio Printed in The Netherlands Subject to modification Car audio system Version 1.1 314178535401 RadioFans.CN 收音机爱 好者资料库 TECHNICAL SPECIFICATION Display Type: High contrast B/W LCD (8 characters) Key illumination: Red Audio P

4、layback Playback Media: USB flash drive, SD Card Compression format: MP3, WMA ID3 Tag support: Song title, artist, album MP3 bit rates: 32-320kbps and variable bit rate USB Direct / SD Modes: Play/Pause, Fast Backward/Fast Forward, Previous/Next, Repeat, Shuffle Tuner/Reception/Transmission Tuner Ba

5、nds: AM, FM Stereo Auto digital tuning Tuner Enhancements: Auto search and store No. of preset stations: 18(FM), 12(AM) Sound Equalizer: 2-bands Equalizer settings: Classic, Jazz, Pop, Rock, Flat, Optimal, Techno, User defined Sound Enhancement: MAX Sound, Dynamic Bass Boost Output power (MAX): 45Wx

6、4 channels Output power (RMS): 22Wx4 channels (4 ohms, 10% T.H.D.) Connectivity USB: USB 2.0 Host Memory card: SD, SDHC MP3-Link: For portable MP3 music playback Preamp output: 2 pairs RCA(L/R) Security/Anti-thief Front panel: Detachable Display blackout: 10/20 sec selectable Accessories Remote cont

7、rol: Not included User Manual: Brazilian Portuguese Quick start guide: Brazilian Portuguese Power Power supply: 12V DC Dimensions Product dimensions (W x H x D): 188 x 58 x 140 mm Chassis: 1 Din 1-2 Type /Versions: Features Board in used: CE130 Service policy Tuner BOARD C&M Main BOARD C&M * TIPS :

8、C - Component Lever Repair. M - Module Lever Repair Used /51/12/55 89/ 16/85/ Feature diffrence RDS VOLTAGE SELECTOR ECO STANDBY - DARK Type /Versions: CE130 VERSION VARIATION 39/ 39/ C&M C&M RadioFans.CN 收音机爱 好者资料库 1-3 LF Generator e.g. PM5110 Recorder Use Universal Test Cassette CrO2SBC419 4822 39

9、7 30069 LEVEL METER e.g. Sennheiser UPM550 with FF-filter S/N and distortion mete e.g. Sound Technology ST170 L R DUT or Universal Test Cassette FeSBC420 4822 397 30071 LEVEL METER e.g. Sennheiser UPM550 with FF-filter S/N and distortion meter e.g. Sound Technology ST1700B L R DUT CD Use Audio Signa

10、l Disc (replaces test disc 3) SBC429 4822 397 30184 Bandpass 250Hz-15kHz e.g. 7122 707 48001 LF Voltmeter e.g. PM2534 DUT S/N and distortion meter e.g. Sound Technology ST1700B Frame aerial e.g. 7122 707 89001 Tuner AM (MW,LW) To avoid atmospheric interference all AM-measurements have to be carried

11、out in a Faradays cage. Use a bandpass filter (or at least a high pass filter with 250Hz) to eliminate hum (50Hz, 100Hz). RF Generator e.g. PM5326 Ri=50? Bandpass 250Hz-15kHz e.g. 7122 707 48001 LF Voltmeter e.g. PM2534 DUT RF Generator e.g. PM5326 S/N and distortion meter e.g. Sound Technology ST17

12、00B Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz). Ri=50? Tuner FM MEASUREMENT SETUP RadioFans.CN 收音机爱 好者资料库 1-4 SERVICE AIDS GBWARNING All ICs and many other semi-conductors are susceptible to electrostatic discharges (ESD). Careless handling

13、 during repair can reduce life drastically. When repairing, make sure that you are connected with the same potential as the mass of the set via a wrist wrap with resistance. Keep components and tools also at this potential. ESD CLASS 1 LASER PRODUCT GB Safety regulations require that the set be rest

14、ored to its original condition and that parts which are identical with those specified, be used Safety components are marked by the symbol !. Lead free Set remains closed! N Y Play a CD for at least 10 minutes Y playability ok ? N playability ok ? add Info for customer SET OK check playability N Y p

15、layability ok ? check playability check playability return set Customer complaint CD related problem fast lens cleaning 1 2 3 For flap loaders (= access to CD drive possible) cleaning method 4 is recommended INSTRUCTIONS ON CD PLAYABILITY 2 - 1 Exchange CDM 1- 4 For description - see following pages

16、 1 PLAYABILITY CHECK For sets which are compatible with CD-RW discs use CD-RW Printed Audio Disc.7104 099 96611 TR 3 (Fingerprint) TR 8 (600 Black dot) maximum at 01:00 playback of these two tracks without audible disturbance playing time for: Fingerprint10seconds Black dot from 00:50 to 01:10 jump

17、forward/backward (search) within a reasonable time For all other sets use CD-DA SBC 444A.4822 397 30245 TR 14 (600 Black dot) maximum at 01:15 TR 19 (Fingerprint) TR 10 (1000 wedge) playback of all these tracks without audible disturbance playing time for: 1000 wedge10seconds Fingerprint10seconds Bl

18、ack dot from 01:05 to 01:25 jump forward/backward (search) within a reasonable time 2 CUSTOMER INFORMATION It is proposed to add an addendum sheet to the set which informs the customer that the set has been checked carefully - but no fault was found. The problem was obviously caused by a scratched,

19、dirty or copy-protected CD. In case problems remain, the customer is requested to contact the workshop directly. The lens cleaning (method 3) should be mentioned in the addendum sheet. The final wording in national language as well as the printing is under responsibility of the Regional Service Orga

20、nizations. 4 LIQUID LENS CLEANING Because the material of the lens is synthetic and coated with a special anti-reflectivity layer, cleaning must be done with a non-aggressive cleaning fluid. It is advised to use “Cleaning Solvent The actuator is a very precise mechanical component and may not be dam

21、aged in order to guarantee its full function. Clean the lens gently (dont press too hard) with a soft and clean cotton bud moistened with the special lens cleaner. The direction of cleaning must be in the way as indicated in the picture below. Before touching the lens it is advised to clean the surf

22、ace of the lens by blowing clean air over it. This to avoid that little particles make scratches on the lens. INSTRUCTIONS ON CD PLAYABILITY 2 - 2 2 1）Detach the the panel by press push button on it. 2）Remove screw on cover A 3）Remove cover on unit 4）Remove 6pcs 2X6BTP screw on panel button coverB 5

23、）Detach the button cover Note:put on static belt during operation and keep yourself from electronic screw driver static.Note:put on static belt during operation and keep yourself from electronic screw driver static. A Main B B 1 2 3 4 面咀+KB板 面咀+KB板 Panel Handy back 5 DISMANTLING INSTRUCTIONS 3 BLOCK

24、 DIAGRAM 4 WIRING DIAGRAM CIRCUIT DIAGRAM MAIN BOARD CIRCUIT DIAGRAM PANEL BOARD 7 KEY2 KEY1 GND +5V REMOTE SYS_5V 2COLOR BT_LED LAMP_VCC ENCODER CE CLK DATA INH GND GND DO CLK CE OSC VSS VDD INH TRACK- UPTRACK- DN USB_5V USB_DN USB_UP AUX_R AUX_L GND 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

25、20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 IC901 SC75823 R95847K C901 680P R901 180 R902 220 R903 330 R904 470 R905 680 R906 1K R907 1K5 R908 2K2 R920 680 R921 470 R922 330 R923 220 R924 180 SW1 OPTIONS/CLOCK

26、 SW2 FOLDER- SW3 SONG+ SW4 MAX/DBB SW5 EQ/AUDIO SW6 SOURCE SW7 BACK/BAND SW8 TUNE/SEEK-UP SW9 TUNE/SEEK-DN SW21 TERMINATE CALL SW22 PHONE SW23 MENU SW25 DISP Q902 NC Q904 NC R939 NC R938 NC R963 NC R936 NC R935 NC R937 NC R934 NC LED15 R+B LED16 R+B LED3 R+B LED4 R+B LED5 R+B LED6 R+B LED7 R+B LED8

27、R+B LED9 R+B LED10 R+B LED11 R+B LED12 R+B LED13 R+B LED14 R+B R927 82K R928 47K 1 2 3 IC902 REMOTE R929 10 R933 22 R932 22 R931 22 R93022 ZD901 6V8 ZD902 6V8 ZD903 6V8 ZD904 6V8 R940270 R941 NC R942 270 R943 NC R944 390 R945 NC R946270 R947 NC R948 390 R949 NC R950 390 R951 NC R952 270 R953NC C902

28、104 LED21 LED R961270 R9640R EN901 EN SW24 POWER/MUTE C905 2P ZR901 22P ZR902 22P EC901 10uF Q905 NC R965 NC R966 NC 1 2 3 4 USBIN USB C903 2P C906 2P C908 2P R975 270 R976NC R955 390 R954NC R956 390 R957 NC R969 270 R970 NC R971390 R972 NC R967 270 R968 NC R973 270 R974 NC 1 2 3 4 5 6 7 8 9 10 11 1

29、2 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 LCD1 CEM2000-LCD LED2 R+B R979 270 R977NC Q901 Q903 NC 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 CON1 24PIN-CON 1 2 3 AUX1 AUX IN

30、R901A 4K7 EC904 10uF C907 104 R902A 4K7 LED17 R+B R981 270 R980NC S0:100 S17 S18 S19 S20 S21 S22 S23 S24 S25 S26 S27 S28 S29 S30 S31 S32 S33 S34 S35 S36 S37 S38 S39 S40 S41 S42 S43 S44 S45 S46 S47 S48S1 S2 S3 S4 S5 S6 S7 S8 S9 S10 S11 S12 S13 S14 S15 S16 S49 S50 S51 S52 S53 S54 S55 S51 S55 S54 S53 S

31、49 S50 BLUE+8V RED+8V RED+8V BLUE+8V POWER POWER BLUE+8V RED+8V S1 S2 S3 S4 S5 S6 S7 S8 S9 S10 S11 S12 S13 S14 S15 S1 S16 S17 S18 S19 S20 S21 S22 S23 S24 S25 S26 S27 S28 S29 S44 S52 S16 S30 S31 S32 S33 S34 S35 S36 S37 S38 S39 S55 S53 S54 S55 S40 S41 S42 S43 S44 S45 S46 S47 S48 S35 USB-GND USB+5V USB

32、+5V USB-GND TUNER PART C115 225 C116 225 R112100R R110100R R116 100R EC1 NC C119 104 C431UF R108 100R C111 22P C112 22P 12 X101 32.768K 1 FMI 2 RFGND 3 AGC 4 CTUNE 5 GND 6 AMI 7 RST 8 SEN 9 SCLK 10 SDIO 11 RCLK 12 VIO 13 VDD 14 GND 15 ROUT 16 LOUT 17 DO 18 DFS 19 DCLK 20 INT 21 GPO1 22 NC 23 NC 24 N

33、C U16 SI4740/41 Q101 2SC9018 R102 10M R105 4K7 R107 10 R106 4K7 R1 10K R103 10K C102 33NF C103 122 C104 104 C106 104 C105 474 C110 474 L104 220UH C107 1U L105A 1MH C109 183 C101 30P L101 FB/1.5K S G D Q102 MF862 S G D Q103 MF862 L102 220NH 1 2 ANT ANT R100 47 R4 10K C123 47P L106 33UH 1 2 3 4 Q104 3

34、SK254 C118 15P C120 15P L103 220NH C121 30P L107 2.7UH R101 270K C122 223 C108 104 C1 47uF/16V C1142U2 C113 102 R104 NC 121234678910511 CON103 CON-12P TUNER-CLK TUNER-DA TUNER-RES CHGND CHGND XOUT CHGND XOUT CHGND CHGND CHGND AM_LOC2 CHGND CHGND AM_LOC2 RDS-INT TUNER-3V3 ANT ANT TUNER-3V3 TUN-LCH TU

35、N-RCH TUN-LCH TUNER-3V3 RDS-INT TUNER-RES TUNER-CLK TUNER-DA TUN-RCH CIRCUIT DIAGRAM TUNER BOARD 8 MAIN PCB COMPONENT LAYOUT TOP SIDE VIEW 9 MAIN PCB COMPONENT LAYOUT BOTTOM SIDE VIEW 10 PANEL PCB COMPONENT LAYOUT TOP SIDE VIEW 11 PANEL PCB COMPONENT LAYOUT BOTTOM VIEWPANEL PCB COMPONENT LAYOUT BOTTOM VIEW 12 TUNER PCB COMPONENT LAYOUT TOP SIDE VIEW 13 TUNER PCB COMPONENT LAYOUT BOTTOM IDE S VIEW 14 SET EXPLODER VIEW DRAWING 15