Philips-MCD-107-Service-Manual电路原理图.pdf

《Philips-MCD-107-Service-Manual电路原理图.pdf》由会员分享，可在线阅读，更多相关《Philips-MCD-107-Service-Manual电路原理图.pdf（26页珍藏版）》请在收音机爱好者资料库上搜索。

1、Version 1.2MCD1073141 785 34382DVD Micro Theater-/51/93/98Published by LX 1102 Service Audio Subject to modificationCopyright 2009 Philips Consumer Electronics B.V. Eindhoven, The NetherlandsAll rights reserved. No part of this publication may be reproduced, stored in a retrievalsystem or transmitte

2、d, in any form or by any means, electronic, mechanical, photocopying,or otherwise without the prior permission of Philips.CONTENTSTechnical specification .1-2Service measurement setup.1-3Service aids .1-4Instructions on CD playability .2-1. 2-2Disassembly diagram. .5-1Block diagram.3-1Wiring diagram

3、 .4-1Main boardCircuit diagram .6-1.6-2Layout diagram.6-3.6-4DVD boardCircuit diagram .7-1.7-5Layout diagram.7-6Exploded view diagram .9-1Mechanical parts list.9-2Electrical parts list.10-1.10-2Front boardCircuit diagram .8-1Layout diagram. 8-2.8-3FMTuning range 87.5 - 108 MHzTuning grid 50 kHzSensi

4、tivity- Mono, 26 dB S/N ratio 55 dBSpeakersSpeaker Impedance 4ohmSpeaker Driver 3.5”wooferSensitivity 82dB/m/WGeneral informationAC power 220 - 230 V, 50 HzOperation powerconsumption 20 WStandby powerconsumption 65 dBAux input 0.5 V RMS 20 kohmDiscLaser type SemiconductorDisc diameter 12 cm/8 cmVide

5、o decoding MPEG-2/MPEG-1Video DAC 10 bitsSignal system PAL/NTSCVideo format 4:3/16:9Video S/N 56 dB (minimum)Composite videooutput1.0 Vp-p, 75 ohmS-Video output Y- 1.0 Vp-p, 75 ohmC- 0.286 Vp-p, 75 ohmAudio DAC 24 bits / 96 kHzTotal harmonicdistortion 65 dBATECHNICAL SPECIFICATION1 - 2Type /Versions

6、:FeaturesBoard in used:MCD107Service policyFRONT BOARDMAIN BOARDTUENR BOARDDVD BOARD* TIPS : C - Component Lever Repair.M - Module Lever Repair- Used/05 /51 /5589/16/93Feature diffrenceRDSVOLTAGE SELECTORECO STANDBY - DARKCCType /Versions:MCD107/05 /51 /5589/16/MMVERSION VARIATION/93C&MC&MC&MC&MC&MC

7、&MC&MC&M1-3LF Generator e.g. PM5110RecorderUse Universal Test Cassette CrO2 SBC419 4822 397 30069LEVEL METERe.g. Sennheiser UPM550with FF-filterS/N and distortion metee.g. Sound Technology ST170LRDUTor Universal Test Cassette Fe SBC420 4822 397 30071LEVEL METERe.g. Sennheiser UPM550with FF-filterS/N

8、 and distortion metere.g. Sound Technology ST1700BLRDUTCDUse Audio Signal Disc(replaces test disc 3)SBC429 4822 397 30184Bandpass250Hz-15kHze.g. 7122 707 48001LF Voltmetere.g. PM2534DUTS/N and distortion metere.g. Sound Technology ST1700BFrame aeriale.g. 7122 707 89001Tuner AM (MW,LW)To avoid atmosp

9、heric interference all AM-measurements have to be carried out in a Faradays cage.Use a bandpass filter (or at least a high pass filter with 250Hz) to eliminate hum (50Hz, 100Hz).RF Generator e.g. PM5326Ri=50:Bandpass250Hz-15kHze.g. 7122 707 48001LF Voltmetere.g. PM2534DUTRF Generator e.g. PM5326S/N

10、and distortion metere.g. Sound Technology ST1700BUse a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz).Ri=50:Tuner FMMEASUREMENT SETUP1-4SERVICE AIDSGB WARNINGAll ICs and many other semi-conductors aresusceptible to electrostatic discharges (ESD).Care

11、less handling during repair can reduce lifedrastically.When repairing, make sure that you areconnected with the same potential as the massof the set via a wrist wrap with resistance.Keep components and tools also at thispotential.ESDCLASS 1LASER PRODUCTGBSafety regulations require that the set be re

12、stored to its originalcondition and that parts which are identical with those specified,be usedSafety components are marked by the symbol!.Lead freeSet remains closed!NYPlay a CD for at least 10 minutesYplayabilityok ?Nplayabilityok ?add Info for customer“SET OK“check playabilityNYplayabilityok ?che

13、ck playabilitycheck playabilityreturn setCustomer complaint“CD related problem“fast“ lens cleaning123For flap loaders (= access to CD drive possible)cleaning method 4 is recommendedINSTRUCTIONS ON CD PLAYABILITY2 - 1Exchange CDM1 - 4 For description - see following pages1PLAYABILITY CHECKFor sets wh

14、ich are compatible with CD-RW discsuse CD-RW Printed Audio Disc.7104 099 96611TR 3 (Fingerprint)TR 8 (600 Black dot) maximum at 01:00 playback of these two tracks without audible disturbanceplaying time for: Fingerprint 10secondsBlack dot from 00:50 to 01:10 jump forward/backward (search) within a r

15、easonable timeFor all other sets use CD-DA SBC 444A.4822 397 30245TR 14 (600 Black dot) maximum at 01:15TR 19 (Fingerprint)TR 10 (1000 wedge) playback of all these tracks without audible disturbanceplaying time for: 1000 wedge 10secondsFingerprint 10secondsBlack dot from 01:05 to 01:25 jump forward/

16、backward (search) within a reasonable time2CUSTOMER INFORMATIONIt is proposed to add an addendum sheet to the set whichinforms the customer that the set has been checkedcarefully - but no fault was found.The problem was obviously caused by a scratched, dirty orcopy-protected CD. In case problems rem

17、ain, the customeris requested to contact the workshop directly. The lens cleaning (method 3) should be mentioned in theaddendum sheet.The final wording in national language as well as the printingis under responsibility of the Regional Service Organizations.4LIQUID LENS CLEANINGBecause the material

18、of the lens is synthetic and coatedwith a special anti-reflectivity layer, cleaning must be donewith a non-aggressive cleaning fluid. It is advised to use“Cleaning Solvent The actuator is a very precise mechanical component andmay not be damaged in order to guarantee its full function.Clean the lens

19、 gently (dont press too hard) with a soft andclean cotton bud moistened with the special lens cleaner.The direction of cleaning must be in the way as indicated inthe picture below.Before touching the lens it is advised to clean thesurface of the lens by blowing clean air over it.This to avoid that l

20、ittle particles make scratches onthe lens.INSTRUCTIONS ON CD PLAYABILITY2 - 2BLOCK DIAGRAM3-1 3-1ANT5WX2I2CEEPROM24C02OP-AMPTU-DATATU-RESETTU-CLKEN25180TU-AUDIO_INSI4702TUNERLCD DISPLAYGY680_MCUSPHE8202TS-128DVD SERVO 1.DVD-CS2.DVD-CLK3.DVD-DATA4.DVD-IRMACHANISM (SONY KHM313)KEYI2CUE2314CHANNELSEL+D

21、SC+VOLUMECONTROLDVD-AUDIO_OUTDVD-AUDIO_INAUX-INAUDIO_OUTINKPS-RKPS-LL-SPK-OUTR-SPK-OUTTFA9842BJPOWER AMPDC POWER SUPPLYTRANSFORMKEY-CONTROLSDRAMHY57V641620ETP-7FLASHNJM45581.F+2.F-3.T+4.T-DVD BOARDMOTOR DRIVERAM5888S DVD-SUPPLYAUXUSBAC/IN127MHzDISPLAY BOARDMAIN BOARDMAIN BOARDWIRING DIAGRAM4-1 4-1CN

22、404CN402CN401CN405CN901CN963CN961CN910CN950CN101CN104CN100CN5CN102CN103FM ANTDISPLAY PCBTRANSFORMER EI57MAIN PCBDVD PCBCN3JK903JK902JK9015-1 5-1DISASSEMBLY DIAGRAMACBOTTOM CAB.1)Remove 2 screws A as indicated.2)Remove 3 screws B as indicated.2)Remoce 6 screws C as indicated to loosen the Bottom Cabi

23、net.Dismantling of the Bottom CabinetDismantling of the Front Cabinet and PCB Board.D1)Remove 2 screws D as indicated to loosen the Front Cabinet.2)Remove 9 screws E as indicated to loosen the Front Board.3)Remove 2 screws F as indicated to loosen the Main Board.EBF6-1 6-1CIRCUIT DIAGRAM - MAIN BOAR

24、DPART1SINGAL LEFT CHANNELSINGAL RIGHT CHANNELFOR PROVISION ONLY*NCNCFOR DVD PCBONLY FOR NO ECO(FOR 12/37)MUTEAU_DATAAU_CLKPRWDFAN_CTLDVD/ONTU_ONST.BY_MUTEPOWER/ONVCC_5VTU-DATATU-SCLTU-RESETGNDGNDTU_RESETTU_SCLTU_SDATU/LTU/RTU/3V3GNDTU_ONTUCD/AUX01ECO_CTLGNDGNDAUDIO_PROTECTIONA_PROTECTDVD-RCHDVD-GNDD

25、VD-LCHDVD-COX+DVD-COX-SVIDEO_CSVIDEO_YDVD+14VDVD_GNDDVD_MUTED906 RL202F901T3.15AL/250VD907 RL202D908 RL202D909 RL202C91222NC91322NC914 22NC915 22NC9991000UF/25VMC917104C918 0.47UF50VC919 0.47UF50VMC9201000PMC9211000PR90175KR90275KR903 15KR90415KC92222UF50VC923100UFR90551KR90615KQ9023904R907 1KQ903Q9

26、04R908 NCR909 NCD937 1N4148 R969 4K7C927 1000UF16VC928 1000UF16VMC929104MC930104R9102R2R9112R21234CON3TO SPEAKQ9058050D9103V9C966100UFR9142K2R915 10RC934100UFMC935104R916 100KR9171KQ9073904D9151N4001R923 56R1/2WMC943104C944100UFR9243K3C945100UFD9169V1Q91080501VDD2AGND3TREB_L4TREB_R5RIN6ROUT7LOUD_R8R

27、IN49RIN310RIN211RIN112LOUD_L13LIN414LIN315LIN216LIN117LIN18LOUT19BIN_L20BOUT_L21BIN_R22BOUT_R23OUT_R24OUT_L25DGND26DATA27CLK28REFU907UE2314LR928100RC925 2.2UFC926 2.2UFC949 2.2UFC950 2.2UFC9512.2UFC9542.2UFMC955 104MC956 104C957220U/16VMC958104C9592700PC9602700PMC961124PMC962124PMC993124PMC994124PR9

28、405K6R9415K6C9952.2UFC9962.2UFMC967 100PC96847UFR942 1KR943 1KMC969 100PR9478.2KR9488.2KC970 2.2UFC9712.2UFR95110KR955 4.7K 1/6WD9279V1C941100UFC972100UR9002.2RL908 10UHMC979104987654312IN2 OUT2 CIV IN1 GND SVR MODE OUT1 VCCU901TFA9842BJQ988SPD09P06P+C9031000UF35VMC904104L919100UHU906NCR98410KR98510

29、KR99910KR99810KQ9283904 R920 4K7C9732.2UFR934 10KR98247KQ9253904R935 10K D936 1N4148Q929BC847BQ930BC847BR95424KR96324KR978 220KC952 680PR921 4K7R976 220KC953 680PR9734K7R974470RC964220UFM C938104R96630KR96730KR9260RR9250RM C942150PM C948150PC965NCR970NCC981220PC982220PC9901UFC9911UFR968100KD9261N400

30、1R9191K 1/6WC9360.47UFD9013V3D903BAS316D9581N4001R933470KR996150R 1/2WD9611N4001C9370.47UFR975220KR92210KQ9323904R97947KR92715KD932BAS316R949 15KR950 15KR918100RMC9243.3U50VR980 22KC940470U/25VR995150R 1/2WC900NCD580 SS14L58027uHR60510KQ583 3904R61610K1BS2IN3SW4GND5FB6COMP7EN8NCU003MP1583C580223Q580

31、 3904R618 10KR600 30K R601 1KR680 10KR60410KC99392C3470uCBC4104C547104R945 33KR946 33KR92922KR93022KR931 22KR932 22KR936 22KR93722KR939 2.2KR938 2.2KQ9093904R960100RQ9083904C9083300UF/25VMC901104R961100KR96210K1243657JK102JACK-6CHAL915 100M/600RL902 100M/600RL903 100M/600RL905 100M/600RL912 100M/600

32、RL906 100M/600RMC963220PMC907220PMC905220PMC910220PMC911220PMC931220PAC/INT1EI-571234CN901D923 RL202F902F1AL/250VD925 RL202D924 RL202D922 RL202C987 22NC98922NC932 22NC988 22NC997470UMC906104124365JK101S-VEDIO OUTL914100M/600RL910100M/600RL909 100M/600RL913100M/600RMC975220PMC933220PMC974220PL907LT-F

33、ILTER3mHMC980104C9781000UC53100UFD9201N4001D921 1N4001Q912BC772R988 1K R98747KQ913BC847BR98610KD919 1N41481234567891011121314151617CON901TO-MCU BD123456789CON9TO TU BDR9642K2Q9148050R96510KC94610U/10R98310KC97710U/50VR60210KM C947104R94482KR95982KD904 1N4148C985100U/16VQ911BC847BR95647KR957 22KR9581

34、0KD9171N4148D9121N4148D9051N4148C98610U/25VC98410U/25VD9182.7VC902100UFR971 10R R972 10RC992100UFMC998104+-32148U302-ANJM4556AM+-567U302-BNJM4556AMC39333UF/16VC39233UF/16VC395100PR39256KC397470PR38747KR38647KC386100UF/16MC389104R39156KC394100PC396470PR39627KR39527KR3947.5KR3937.5KC387220U/16VMC38810

35、4PM C390102PMC391102PC3992.2UFC3982.2UFL39847UHL39947UHR3904R7R3894R7R3982.2KR3972.2KR388100RL9988UHL9998UH123456CN9106P2.0 180C(JST)R13K3C4 100UFD1 9V1Q480501234CN963R9520RR9530RDVD/RDVD/LAUX/RAUX/LAU-DATAAU-CLKMUTESTBY-MUTEPWR/ONPRWDDVD+14VDVD+5VDVD/RGNDDVD/LPWR/ONY-0UTCVBSP/UVLOUTP/VCOAXIAL+COAXIAL-P/VY-OUTDVD+14VDVD-VCCTU_RESETTU_SCLTU_DATATU_DATATU_SCLTU_RESETDVDMUTESTBY-MUTEPRWDFAN_CTLDVD-VCCPWR/ONAUDIO_PROTECTION+8VSPK-LSPK-RAUDIO_PROTECTIONA+9VA+9VA+9VGND