Sony-TA-AV661-Service-Manual电路原理图.pdf

《Sony-TA-AV661-Service-Manual电路原理图.pdf》由会员分享，可在线阅读，更多相关《Sony-TA-AV661-Service-Manual电路原理图.pdf（22页珍藏版）》请在收音机爱好者资料库上搜索。

1、 TA-AV661 US Model SPECIFICATIONS AV CONTROL INTEGRATED AMPLIFIER MICROFILM SERVICE MANUAL RadioFans.CN 收音机爱 好者资料库 2 TABLE OF CONTENTS SectionTitlePage SECTION 1.GENERAL. 3 SECTION 2.DIAGRAMS 2-1.Circuit Boards Location . 4 2-2.Printed Wiring Board Display Section . 6 2-3.Schematic Diagram Display S

2、ection .9 2-4.IC Pin Function IC401 System Control (PD78043AGF-033-3B9). 12 2-5.Schematic Diagram Main Section . 13 2-6.Printed Wiring Board Main Section . 17 SECTION 3. EXPLODED VIEWS 3-1.Front Panel Section . 21 3-2.Back Panel Section . 22 3-3.Chassis Section. 23 SECTION 4. ELECTRICAL PARTS LIST.

3、24 SAFETY CHECK-OUT After correcting the original service problem, perform the following safety checks before releasing the set to the customer: Check the antenna terminals, metal trim, “metallized” knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below. LE

4、AKAGE The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microampers). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the S

5、impson 229 or RCA WT-540A. Follow the manufacturers instructions to use these instruments. 2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. 3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. Th

6、e “limit” indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2V AC range are suitable. (See Fig. A) Fig. A. Using an AC voltmete

7、r to check AC leakage. To Exposed Metal Parts on Set 0.15F1.5k AC voltmeter (0.75V) Earth Ground SAFETY-RELATED COMPONENT WARNING ! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH

8、 SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. Lighting of all FLs and LEDs While pressing 3 button, connect the power supply plug to the outlet, the FL tubes and LEDs light up. Key Check With all the FLs and LEDs lit, when the 3 button and WOOFER

9、ON/OFF button are pressed simultaneously, “SET *” is displayed. When the 3 button and WOOFER ON/OFF button are pressed simultaneously again, the Key Check mode is set and “KEY 0” is displayed. Each time a button other than POWER is pressed, the display will count up to “KEY 30”. A button already pre

10、ssed will not be counted when pressed again. When the button is pressed for the 31st time, “AMP” is displayed and the key check mode is ended. Note: The * of “SET *” differs according to the version of the microprocessor. To exit the test mode, press the POWER button. Abbreviation FL : Fluorescent I

11、ndicator Tube RadioFans.CN 收音机爱 好者资料库 3 SECTION 2 GENERAL FRONT PANEL This section is extracted from instruction manual. REAR PANEL 12 34 56789! ! ! ! ! ! ! !PRESET MODE buttons (MEMORY, USER, SOUND FIELD) !VIDEO 1 button !VIDEO 2 button !VIDEO 3 button !VIDEO 4 button !TAPE button !CD button TUNER

12、button PHONO button EQ FLAT button WOOFER ON/OFF button VIDEO 4 INPUT jack (VIDEO, AUDIO L/R) 1POWER button 2CENTER MODE button 3DOLBY PRO LOGIC indicator 4SURROUND MODE buttons (DOLBY, HALL, SIMULATED) 5 / / button 6Display Window 7CONTROL MODE buttons (EQ, CENTER, REAR, WOOFER) 8Numeric buttons (1

13、-5) 9SUPER WOOFER indicator !MASTER VOLUME knob !HEADPHONES jack !DISPLAY button 21 SECTION 3 EXPLODED VIEWS NOTE: Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. The mechanical parts with no reference n

14、umber in the exploded views are not supplied. Hardware (# mark) list and accessories and pack- ing materials are given in the last of this parts list. 3-1. FRONT PANEL SECTION Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark 14-980-107-01KNOB (VOL) 23-350-426-01SPRING, RING 34-977-

15、358-11CUSHION (8X12.5) 44-979-937-11FILTER 54-979-942-21WINDOW 64-979-937-01FILTER 74-963-404-21EMBLEM (5-A), SONY 84-979-934-11PANEL, FRONT * 94-982-462-01HOUSE, LED 104-980-108-01BUTTON (PRE) 114-979-930-01BUTTON (F-8) 124-979-931-01INDICATOR 134-979-936-01BUTTON (P-T) * 14A-4389-305-A DISP BOARD,

16、 COMPLETE * 154-921-941-01CUSHION (FL) * 164-971-014-11HOLDER, FL TUBE 171-769-867-11WIRE (FLAT TYPE) (5 CORE) 184-951-620-01SCREW (2.6X8), +BVTP 191-773-286-11WIRE (FLAT TYPE) (29 CORE) * 201-661-167-11VR BOARD 213-704-366-01SCREW (CASE) (M3X8) * 224-982-682-01CASE (414532) 234-979-932-01ESCUTCHEON

17、 (V) FL4011-517-513-11INDICATOR TUBE, FLUORESCENT 1 2 3 5 7 8 10 11 12 12 13 14 15 16 17 18 19 2021 21 21 #1 #1 FL401 15 6 9 9 4 Supplied with RV401 22 23 The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. 22 3-2. BACK PAN

18、EL SECTION Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark * 521-659-607-11VIDEO 4 BOARD * 53A-4389-312-A EQ BOARD, COMPLETE * 541-661-163-11REAR SP BOARD * 551-659-613-11VIDEO BOARD * 564-979-954-52PANEL, BACK * 573-703-244-00BUSHING (2104), CORD 583-704-515-01SCREW (BV/RING) !CN

19、P901 1-690-609-21CORD, POWER The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. 56 57 CNP901 #1 #1 #1 #1 54 #1 #1 58 #1 #1 55 53 not supplied 52 23 3-3. CHASSIS SECTION #1 Ref. No.Part No.DescriptionRemarkRef. No.Part No.D

20、escriptionRemark * 1014-979-946-01PLATE (432), BOTTOM 102X-3371-405-1FOOT (SMALL) ASSY * 1031-661-168-11HP BOARD * 1041-661-166-11T-2 BOARD * 1051-661-165-11T-1 BOARD 1061-769-867-11WIRE (FLAT TYPE) (5 CORE) * 1071-661-164-11POWER BOARD * 108A-4389-302-A MAIN BOARD, COMPLETE 1091-773-286-11WIRE (FLA

21、T TYPE) (29 CORE) !F9041-533-310-11FUSE, GLASS TUBE (6.3A 125V) !F9051-533-310-11FUSE, GLASS TUBE (6.3A 125V) !F9061-533-310-11FUSE, GLASS TUBE (6.3A 125V) !F9071-533-310-11FUSE, GLASS TUBE (6.3A 125V) !T9011-429-458-11TRANSFORMER, POWER 101 102 103 104 105 108 109 #1 #1 #1 #1 #1 #1 #1 #1 #1 #1 #1 #

22、1 #1 #1 #2 #3 not supplied not supplied not supplied not supplied not supplied not supplied 106 #1 #1 T901 #2 107 F905 F906 F907 F904 #1 #1 The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. 24 Note: Due to standardization

23、, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. -XX, -X mean standardized parts, so they may have some difference from the original one. Items marked “*” are not stocked since they are seldom required for routine service.

24、Some delay should be anticipated when ordering these items. RESISTORS All resistors are in ohms METAL: Metal-film resistor METAL OXIDE: Metal Oxide-film resistor F : nonflammable SEMICONDUCTORS In each case, u: , for example: uA.: A., uPA.: PA., uPB.: PB., uPC.: PC., uPD.: PD. CAPACITORS uF : F COIL

25、S uH : H Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark SECTION 4 ELECTRICAL PARTS LIST *A-4389-305-A DISP BOARD, COMPLETE * *4-921-941-01CUSHION (FL) *4-971-014-11HOLDER, FL TUBE C4011-125-486-11DOUBLELAYERS0.22F5.5V C4021-104-664-11ELECT47uF20%25V C4031-161-494-00CERAMIC0.022uF

26、25V C4041-126-964-11ELECT10uF20%50V C4051-124-903-11ELECT1uF20%50V C4061-161-494-00CERAMIC0.022uF25V C4071-136-173-00FILM0.47uF5%50V C4081-161-494-00CERAMIC0.022uF25V C4091-161-494-00CERAMIC0.022uF25V C4111-124-903-11ELECT1uF20%50V C4121-124-903-11ELECT1uF20%50V C4131-161-494-00CERAMIC0.022uF25V C41

27、71-162-306-11CERAMIC0.01uF30%16V C4181-162-306-11CERAMIC0.01uF30%16V C4211-162-290-31CERAMIC470PF10%50V C4221-162-290-31CERAMIC470PF10%50V C4231-162-290-31CERAMIC470PF10%50V C4241-162-290-31CERAMIC470PF10%50V C4251-162-290-31CERAMIC470PF10%50V C5011-126-956-91ELECT0.1uF20%50V C5021-130-489-00MYLAR0.

28、033uF5%50V C5031-124-464-11ELECT0.22uF20%50V C5041-126-956-91ELECT0.1uF20%50V C5051-130-483-00MYLAR0.01uF5%50V C5061-130-493-00MYLAR0.068uF5%50V C5071-126-956-91ELECT0.1uF20%50V C5081-130-480-00MYLAR0.0056uF5%50V C5091-130-489-00MYLAR0.033uF5%50V C5101-126-956-91ELECT0.1uF20%50V C5111-162-302-11CERA

29、MIC0.0022uF30%16V C5121-130-483-00MYLAR0.01uF5%50V C5131-126-956-91ELECT0.1uF20%50V C5141-162-294-31CERAMIC0.001uF10%50V C5151-130-478-00MYLAR0.0039uF5%50V C5161-126-956-91ELECT0.1uF20%50V C5171-162-288-31CERAMIC330PF10%50V C5181-162-302-11CERAMIC0.0022uF30%16V C5191-126-956-91ELECT0.1uF20%50V C5201

30、-162-286-31CERAMIC220PF10%50V C5211-124-925-11ELECT2.2uF20%100V * CN4011-568-848-11SOCKET, CONNECTOR 5P * CN4021-568-871-11SOCKET, CONNECTOR 29P CN4051-770-397-11HOUSING, CONNECTOR(PC BOARD)4P D4018-719-987-63DIODE 1N4148M D4028-719-987-63DIODE 1N4148M D4038-719-987-63DIODE 1N4148M D4048-719-987-63D

31、IODE 1N4148M D4058-719-987-63DIODE 1N4148M D4068-719-014-73DIODE UZP-5.6BC-TP D4078-719-933-36DIODE HZS6B1L D4118-719-301-49DIODE SEL2810A (HALL) D4128-719-301-49DIODE SEL2810A (SIMULATED) D4138-719-301-49DIODE SEL2810A (DOLBY) D4148-719-032-98DIODE SEL5820A (DOLBY PROLOGIC) D4158-719-032-98DIODE SE

32、L5820A (DOLBY PROLOGIC) D4168-719-032-98DIODE SEL5820A (SUPER WOOFER) D4178-719-032-98DIODE SEL5820A (SUPER WOOFER) D4188-719-301-49DIODE SEL2810A (EQ) D4198-719-301-49DIODE SEL2810A (CENTER) D4208-719-301-49DIODE SEL2810A (REAR) D4218-719-301-49DIODE SEL2810A (WOOFER) D4228-719-987-63DIODE 1N4148M

33、D4238-719-987-63DIODE 1N4148M D4248-719-987-63DIODE 1N4148M D4258-719-987-63DIODE 1N4148M D4318-719-987-63DIODE 1N4148M D5018-719-987-63DIODE 1N4148M D5028-719-987-63DIODE 1N4148M D5038-719-987-63DIODE 1N4148M D5048-719-987-63DIODE 1N4148M D5058-719-987-63DIODE 1N4148M D5068-719-987-63DIODE 1N4148M

34、D5078-719-987-63DIODE 1N4148M DISP The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. When indicating parts by reference number, please include the board name. 25 Ref. No.Part No.DescriptionRemarkRef. No.Part No.Descriptio

35、nRemark FL4011-517-513-11INDICATOR TUBE, FLUORESCENT IC4018-759-366-87IC uPD78043AGF-033-3B9 IC4028-749-920-83IC GP1U52XB IC4038-759-000-48IC MC14052BCP L4011-410-521-11INDUCTOR 100uH Q4018-729-900-36TRANSISTOR DTC124ES Q4028-729-900-63TRANSISTOR DTA124ES Q4038-729-900-36TRANSISTOR DTC124ES Q4048-72

36、9-900-36TRANSISTOR DTC124ES Q4058-729-900-36TRANSISTOR DTC124ES Q4068-729-900-36TRANSISTOR DTC124ES Q4078-729-900-36TRANSISTOR DTC124ES Q4088-729-900-36TRANSISTOR DTC124ES Q4118-729-900-63TRANSISTOR DTA124ES Q4128-729-900-63TRANSISTOR DTA124ES Q4138-729-900-63TRANSISTOR DTA124ES Q4148-729-900-63TRAN

37、SISTOR DTA124ES Q4158-729-900-63TRANSISTOR DTA124ES Q4168-729-900-63TRANSISTOR DTA124ES Q4178-729-900-63TRANSISTOR DTA124ES Q4188-729-900-63TRANSISTOR DTA124ES Q4318-729-900-63TRANSISTOR DTA124ES R4011-247-807-31CARBON1005%1/4W R4021-249-429-11CARBON10K5%1/4W R4031-247-807-31CARBON1005%1/4W R4041-24

38、9-429-11CARBON10K5%1/4W R4051-247-807-31CARBON1005%1/4W R4061-247-807-31CARBON1005%1/4W R4071-247-807-31CARBON1005%1/4W R4081-247-807-31CARBON1005%1/4W R4091-247-807-31CARBON1005%1/4W R4101-247-807-31CARBON1005%1/4W R4111-247-807-31CARBON1005%1/4W R4121-247-807-31CARBON1005%1/4W R4131-247-807-31CARB

39、ON1005%1/4W R4141-247-807-31CARBON1005%1/4W R4151-247-807-31CARBON1005%1/4W R4161-249-433-11CARBON22K5%1/4W R4171-249-429-11CARBON10K5%1/4W R4181-249-429-11CARBON10K5%1/4W R4191-249-429-11CARBON10K5%1/4W R4201-249-429-11CARBON10K5%1/4W R4211-247-903-00CARBON1M5%1/4W R4221-247-807-31CARBON1005%1/4W R

40、4231-247-807-31CARBON1005%1/4W R4241-247-807-31CARBON1005%1/4W R4251-247-807-31CARBON1005%1/4W R4281-247-807-31CARBON1005%1/4W R4291-247-807-31CARBON1005%1/4W R4301-247-807-31CARBON1005%1/4W R4311-247-807-31CARBON1005%1/4W R4321-247-807-31CARBON1005%1/4W R4331-247-807-31CARBON1005%1/4W R4341-249-429

41、-11CARBON10K5%1/4W R4351-249-429-11CARBON10K5%1/4W R4361-249-429-11CARBON10K5%1/4W R4401-249-437-11CARBON47K5%1/4W R4411-249-437-11CARBON47K5%1/4W R4421-249-437-11CARBON47K5%1/4W R4431-249-437-11CARBON47K5%1/4W R4441-249-437-11CARBON47K5%1/4W R4451-249-437-11CARBON47K5%1/4W R4461-249-437-11CARBON47K

42、5%1/4W R4471-249-437-11CARBON47K5%1/4W R4481-249-437-11CARBON47K5%1/4W R4491-249-437-11CARBON47K5%1/4W R4501-249-437-11CARBON47K5%1/4W R4511-249-437-11CARBON47K5%1/4W R4521-249-437-11CARBON47K5%1/4W R4531-249-437-11CARBON47K5%1/4W R4541-249-437-11CARBON47K5%1/4W R4551-249-437-11CARBON47K5%1/4W R4561

43、-249-437-11CARBON47K5%1/4W R4571-249-437-11CARBON47K5%1/4W R4581-247-807-31CARBON1005%1/4W R4591-247-807-31CARBON1005%1/4W R4601-249-413-11CARBON4705%1/4WF R4631-247-807-31CARBON1005%1/4W R4641-247-807-31CARBON1005%1/4W R4661-249-396-11CARBON185%1/4WF R4691-249-419-11CARBON1.5K5%1/4WF R4701-249-401-

44、11CARBON475%1/4WF R4711-249-403-11CARBON685%1/4WF R4721-247-807-31CARBON1005%1/4W R4731-249-407-11CARBON1505%1/4WF R4741-249-407-11CARBON1505%1/4WF R4751-249-409-11CARBON2205%1/4WF R4761-249-411-11CARBON3305%1/4W R4771-249-413-11CARBON4705%1/4WF R4781-249-415-11CARBON6805%1/4WF R4791-249-417-11CARBO

45、N1K5%1/4WF R4801-249-419-11CARBON1.5K5%1/4WF R4811-249-421-11CARBON2.2K5%1/4WF R4821-249-423-11CARBON3.3K5%1/4WF DISP 26 Ref. No.Part No.DescriptionRemarkRef. No.Part No.DescriptionRemark R4831-249-427-11CARBON6.8K5%1/4WF R4841-249-431-11CARBON15K5%1/4W R4851-249-419-11CARBON1.5K5%1/4WF R4861-249-40

46、1-11CARBON475%1/4WF R4871-249-403-11CARBON685%1/4WF R4881-247-807-31CARBON1005%1/4W R4891-249-407-11CARBON1505%1/4WF R4901-249-407-11CARBON1505%1/4WF R4911-249-409-11CARBON2205%1/4WF R4921-249-411-11CARBON3305%1/4W R4931-249-413-11CARBON4705%1/4WF R4941-249-415-11CARBON6805%1/4WF R4951-249-417-11CAR

47、BON1K5%1/4WF R4961-249-419-11CARBON1.5K5%1/4WF R4971-249-421-11CARBON2.2K5%1/4WF R4981-249-423-11CARBON3.3K5%1/4WF R4991-249-427-11CARBON6.8K5%1/4WF R5001-249-431-11CARBON15K5%1/4W R5011-247-903-00CARBON1M5%1/4W R5021-247-881-00CARBON120K5%1/4W R5031-249-429-11CARBON10K5%1/4W R5041-247-903-00CARBON1

48、M5%1/4W R5051-247-881-00CARBON120K5%1/4W R5061-249-429-11CARBON10K5%1/4W R5071-247-903-00CARBON1M5%1/4W R5081-249-441-11CARBON100K5%1/4W R5091-249-429-11CARBON10K5%1/4W R5101-247-903-00CARBON1M5%1/4W R5111-249-441-11CARBON100K5%1/4W R5121-249-429-11CARBON10K5%1/4W R5131-247-903-00CARBON1M5%1/4W R5141-249-440-11CARBON82K5%1/4W R515